2022 TOYOTA HIGHLANDER Air Bags Problems

Vehicle is parked in the sun for over 30 minutes and when the start button is pushed the Air Bag System Malfunction light is on. After restarting the light goes away.

When the vehicle is parked in the sun for 30 minutes or more. After pushing the start button, the SRS airbag system malfunction light came on. After restarting the vehicle, the airbag light was out.

Water leaking into airbag area. Known leak issue per NHTSA [XXX] ) from defective roof rack attachment clips. Per Toyota, not covered by Toyota unless car still under warranty. Leak issue is common issue with many Toyota (RAV4, Highlander). I cannot tell if the potentially waterlogged airbag area is defective unless I get into an accident to test it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The component that failed is the roof rail clips that hold the roof rack to the vehicle (Toyota Service Bulletin T-SB-0040-24). The clips under the rail fail and cause water to leak into the headliner and down the A-pillars on both sides of the vehicle. It presents itself by causing water staining where the headliner meets the A-pillar cover. This issue presented itself in January of 2023, a few months after we bought the vehicle. Toyota Bountiful (Utah) tried to tell us that it is the sunroof drain lines that are clogged and required a $100 service to clear them which is an annual service. After some push back they found the problem with the roof rack clips. However, they only replaced the passenger side and neglected to repair both sides. April of 2025 the driverside failed and Toyota Bountiful once again confirmed that the driverside clips failed. This creates a danger to the front occupants of the vehicle by allowing a possible mold issue within the cabin. Secondly, it allows water into the front curtain airbags of the vehicle.

r 2022 Toyota Highlander was involved in a motor vehicle incident wherein the Vehicle Stability Control (VSC) and front airbags may not have functioned as expected.

On or about 9/22/24 I was driving on a parkway and was alerted by a high pitched alarm in the vehicle’s dashboard that the airbag had a malfunction and that the seatbelt was not engaged. I removed my seatbelt and clipped it back in but that did not stop the alarm. The vehicle continued to beep and say the airbag was malfunctioning. I made an appointment with Toyota service for 9/26/24 and when I arrived I was told they do not do diagnostic tests on Thursdays. They proceeded to give me a new appointment for today 9/28/24, and when I arrived they once again turned me away explaining that today was not a good day for a diagnostic. They mockingly told me that my vehicle warranty was about to expire. Furthermore, the Toyota has refused to fix the recall issue, and now is refusing to even run a diagnostic test to see what the problem is with the airbags. I am afraid the airbags will fail if I am in an accident. This is a very dangerous situation. Please help me!

My father in law drove my highlander car and got into an accident on 8/27/2024. Front of the car was damaged but did not deploy the airbags. And as far I know it is equipped with automatic braking system but the damaged looks really bad.

The contact owns a 2022 Toyota Highlander. The contact stated that while driving at an undisclosed speed, the contact's vehicle was involved in a crash. The contact stated that the other vehicle that crashed into the contact stated the vehicle's speed was about 75 MPH. The contact stated that when the contact's vehicle was impacted, the contact's vehicle air bags failed to deploy. The contact stated that after the crash, the ABS warning light illuminated. The contact's vehicle was occupied by the contact's husband, who was seated in the front passenger's seat. The contact's two children, ages [XXX] and [XXX] old, were seated in the rear seat. The Police and Fire departments arrived on the scene. The contact stated that medical attention was provided at the scene. The contact sustained injuries included a concussion, a sprained left ankle, and a sprained right wrist. The contact's husband sustained injuries, including a sprained right wrist and a sprained left ankle. In addition, the contact's children sustained cuts and bruises. A Police report was filed. The vehicle was towed to the contact's residence and later towed to an independent mechanic. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 70,765. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mileage: 70,765

Met with an accident in dallas north tollway due to hydro plane and hit in the median. But airbag not deployed. Four people were in the car

Was in a frontal collision air bags failed to deploy and forward collision system did not work. Received error messages from both systems that they failed

I got hit by a full size van at the red light and pushed to the traffic. Van is totaled and airbags deployed. I and my passenger got a whiplash, yet airbags deploy.

On June 26 2023 the vehicle didn't stop automatically when another car was in view in the intersection, the automatic breaking system didn't work and the air bags didn't deploy,

On our 22' Highlander I observed water lines on the passenger side A pillar, one of which was colored pinkish this led me to believe it was dyed from car wash soap. I found that whenever you go through a car wash water leaks into the headliner and down the passenger side A-pillar where the air bag module is. Toyota Bountiful claims that the drainage channels are likely clogged and it failed to drain properly. I ran the test as recommended by pouring water into the corner drainage hole identified by the service advisor. I found the water to exit the drainage port behind the front tire in two different spots at a very quick rate, yet the headliner and A-pillar covering got wet again. Toyota claims this is supposed to cleaned annually by the vehicle owner and is likely not covered by warranty. Obviously, the issue overall is irritating on a 1-year-old car, clean title, no accidents, no windshield replacement vehicle. However, what is most concerning is water is free flowing into the air bag area on the a-pillar.

The airbag malfunction alert message has been displayed for more than two months. The vehicle was taken to Toyota of Newnan (GA) dealership four times for repair; they kept my vehicle for an entire week at their facility the latest time (fourth). The problem still exists! It seems they have not taken this problem seriously because they have not called me regarding the problem. I called them so many times ... I need help from the your office because I have to use this vehicle for my three kids to go to and from schools every day. Please please please help me! Thank you.

1. The SRS airbag malfunction alert message has been displayed for more than a month. The vehicle was brought to the Toyota dealer where it was purchased for being diagnosed and repaired TWICE, but the problem still exists now. [The alert message is always displayed and keeps the driver from seeing any other information on the instrument panel. This is annoying and very dangerous.] 2. The engine sometimes automatically turned off while the vehicle stopped and was waiting for green lights at intersections or yielding to other vehicles at stop signs. The driver had to start the engine again before continuing driving. The vehicle was also brought to the dealer where it was purchase for repair, but the technicians were unable to find the problem.