2004 TOYOTA RAV4 Power Train Problems

I was driving on a highway, there was a red light and I pressed on the brakes. The car kept going forward, the brakes became resistant to any pressure and the car continued to roll forward. There were no warning lights when the car was started or during the incident. I kept trying to brake the car, but the car kept moving forward and was about to hit the car in front of me. The cars around me started honking, trying to move out of the way; Luckily the light turned red and the car in front of me was able to move out of the way. I could not press on the gas or the break, I decided to turn the ignition off and the car was able to turn off. I re-started the car and then was able to go again. Had this been on the highway and I was moving at a faster speed, I probably wouldn't be typing this right now and would be in the ER with potentially others. This is the second time an issue like this happened. The first time the car was in reverse and it wouldn't brake and I almost slammed into the car behind me. The brakes and gas were not responsive. I took it to a mechanic right away, got new brakes, rotors, engine and transmission was checked. A couple months later this happened again.

10 days ago transmission on 2004 Rav started to act funny. Slow/jerky to engage in lower gears. Check engine lights came on. Checked out by mechanic who said it looked like a transmission problem and should have it looked at by transmission specialist who said it was not safe to drive as is since it could simply die at any time, and it needed a new transmission. When replacing trans, the trans man found the ECM had to be replaced. He said this often happened with 2003 thru 2005 RAV4s. On looking through your site, discovered others had similar issues with their 2004 Ravs. I also found out that the electronic control module for these vehicles is defective and must be repaired to correct the transmission issues. What did Toyota have to say when you looked into this, or do you not think it’s a safety issue?

The transmission slips suddenly, even during highway driving conditions, which almost resulted in a terrible crash. I found out that the electronic control module for these vehicles is defective and must be repaired to correct the transmission issues.

THE VSC/TRAC LIGHT CAME ON WHILE DRIVING. ALSO TRANSMISSION STARTED ACTING FUNNY. FROM A STOP SIGN IT WOULD HESITATE AND THEN START WITH A JERK. WHILE DRIVING AT A CONSTANT SPEED THE RPMS WOULD GO UP AND DOWN. I TOOK IT TO AN AUTO PARTS STORE TO HAVE THEM READ THE ERROR CODE. THEY SAID IT WAS A SOLENOID PROBLEM WITHIN THE TRANSMISSION. I TOOK IT TO A TRANSMISSION SHOP AND THEY CHECKED IT OUT AND ORDERED A REMANUFACTURED TRANSMISSION. TOTAL COST WAS OVER $4,600. SINCE THE TRANSMISSION WAS REPLACED HAVE HAD THE CAR BACK 3 TIMES IN 2 WEEKS WITH SAME PROBLEM. TODAY, 1-23-17, I DROVE IT ABOUT 1 MILE AND VSC/TRAC LIGHT CAME ON AGAIN. I TOOK IT BACK TO TRANSMISSION SHOP AND LEFT IT RUNNING. THEY CAME OUT AND TRIED TO USE THEIR SCANNER BUT HAD SOME DIFFICULTY SO THEY TURNED OFF THE ENGINE AND WHEN THEY TRIED TO RESTART IT THE ENGINE WOULD NOT TURN OVER. SO THE CAR NOW HAS BEEN TOWED TO TUNEX SINCE THEY HAVE MORE DIAGNOSTIC EQUIPMENT. ON THE INTERNET I SEE ARTICLE THAT CLAIM THAT THE PROBLEM WITH THESE 2001 THRU AT LEAST 2005 RAVS IS THE ECM. THE SITE OF OTHER DEAL.COM SAYS THIS IS A VERY COMMON PROBLEM BECAUSE OF DEFECTIVE ECMS FROM THE MANUFACTURER. THERE WAS A CLASS ACTION SUIT AGAINST TOYOTA THAT COVERED TRANSMISSION PROBLEMS ON 2001-2003 RAVS. SEEMS LIKE WHETHER IT IS THE ECM OR THE TRANSMISSION OR BOTH THAT TOYOTA SHOULD BE HELD RESPONSIBLE. *TR

Mileage: 125,000

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. WHILE DRIVING AT ANY SPEED AND WHEN THE GEAR SHIFTER WAS PLACED INTO THE DRIVE POSITION, THE VEHICLE HESITATED AND ALL OF THE INSTRUMENT PANEL INDICATORS ILLUMINATED, ALONG WITH "TAKE THE VEHICLE FOR SERVICE" MESSAGE APPEARED. THE VEHICLE WAS DRIVEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE TRANSMISSION WAS REPLACED, BUT THE FAILURE RECURRED. THE DEALER DIAGNOSED THAT THE COMPUTER WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

Mileage: 50,000

THE POWER OF THE CAR IS IN TROUBLE AT START, JUMPS LIKE IS LOCKED, OR LOSE POWER, THAN, WHEN I GIVE GAS IS RUNNING OK IN THE STREET OR IGHWAY, TILL STOP AND RENEW RUNNING THE CAR.EVERY TIME THAT I STOP IS THE PROBLEM. THE PROFETIONAL MECHANIS LOOK AT IT, AND HE SAY THE TRANSMITION (SELENOID) IS NOT WORKING.

Mileage: 112,000

AS MY FAMILY AND I WERE LEAVING MY HOUSE TO GO TO THE COAST, MY 2004 TOYOTA RAV4 SUDDENLY, WITHOUT ANY PRIOR WARNING OR INDICATION, JERKED AND SPUTTERED AND FELT AS IF IT WERE DOWNSHIFTING, AS IF THE TRANSMISSION WERE SLIPPING OR NOT ENGAGING OR MAINTAINING GEAR. UPON TAKING IT TO THE DEALERSHIP, I WAS TOLD THAT THE DIAGNOSTIC REVEALED THAT THE TRANSMISSION HAD TO BE REPLACED. I WAS ALSO INFORMED THAT TOYOTA WOULD NOT ALLOW IT TO BE OPENED UP, ONLY REPLACED. I MENTIONED THE ECM AND WAS TOLD THAT THEY FOUND NOTHING TO INDICATE ANYTHING OTHER THAN THE TRANSMISSION NEEDED TO BE REPLACED. WERE IT NOT A HIGHER POWER CARING FOR ME AND MY LOVED ONES THAT DAY, I BELIEVE IT COULD HAVE BECOME AN EVEN MORE DANGEROUS SITUATION THAN IT ALREADY WAS.

Mileage: 136,600

TL* THE CONTACT OWNS A 2004 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT WARNING. AFTER STOPPING, THE VEHICLE JERKED FORWARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 39,000.

Mileage: 39,000

I WAS STARTING TO MAKE A K-TURN IN A PARKING LOT. I PUT ON THE BRAKES TO SHIFT INTO REVERSE. I MOVED BACK IN REVERSE A LITTLE BIT. THEN I STOPPED THE CAR AND PUT IT IN DRIVE, WHEN THE CAR SUDDENLY LURCHED FORWARD OUT OF MY CONTROL CRASHING INTO A GARBAGE DUMPSTER, FRIGHTENING ME AND DAMAGING MY VEHICLE SEVERELY. I AM CERTAIN I DID NOT GIVE THE CAR ANY GAS TO MAKE IT GO FORWARD AND CAUSE THAT ACCIDENT. I FEEL VERY FORTUNATE THAT I SUFFERED ONLY MINOR ACHES AND PAINS AS I WAS 75 AT THE TIME. I STILL OWN THE RAV4 AND HAVE HAD NO OTHER ACCIDENTS OR PROBLEMS SINCE THAT TIME. NOW THAT I SEE THERE ARE RECALLS ON LATER YEAR VEHICLES, I WONDER ABOUT THE SAFETY OF THE 2004 RAV4. I HOPE NHTSA CAN HELP ME. *TR

Mileage: 1,000

I HAVE A 2004 TOYOTA RAV4. THE CHECK ENGINE LIGHT AND VSC LIGHT CAME ON WHILE DRIVING AT 30 MPH. NOTICED THAT AS I CONTINUED TO DRIVE HOME AT APPROXIMATELY 65 MPH, THE CAR WAS NOT SHIFTING INTO OVERDRIVE AND THE RPM'S WERE VERY HIGH. TOOK IT TO THE DEALER, AND THEY SAID THE CODE SHOWED THAT THE SOLENOID WAS BAD. THE PART WAS REPLACED AT A COST OF $750. THEN TOLD THAT DID NOT CORRECT THE PROBLEM, NEEDED A NEW TRANSMISSION AND ANOTHER $4300. I KNOW THERE WAS A CLASS ACTION LAWSUIT FOR THE 2001-2003 TOYOTA RAV4 TRANSMISSIONS, THINK IT SHOULD HAVE BEEN EXPANDED TO INCLUDE THE 2004 AS THE PROBLEMS SEEM TO BE THE SAME. THIS PROBLEM IS DANGEROUS AND COULD HAVE CAUSED SERIOUS ACCIDENT AND DAMAGE TO MYSELF OR OTHERS. BOUGHT A TOYOTA FOR RELIABILITY AND WHAT I THOUGHT WERE GREAT VEHICLES. VERY SAD WHEN I READ ALL OF THE COMPLAINTS WITH THIS VEHICLE. I KNOW WHAT MY NEXT CAR WILL NOT BE. *TR

Mileage: 101,500

TL* THE CONTACT OWNS A 2004 TOYOTA RAV 4. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE SHIFTED FROM FOURTH GEAR TO NEUTRAL INDEPENDENTLY. THE FAILURE RECURRED THE FOLLOWING DAY. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS ADVISED THAT THERE WERE COMPLAINTS ON THE VEHICLE AND PROVIDED NO FURTHER ASSISTANCE. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE TRANSMISSION. THE FAILURE AND THE CURRENT MILEAGE WAS 94,000. UPDATED 8/29/12 *CN

Mileage: 94,000

I HAVE A 2004 TOYOTA RAV4. THE CHECK ENGINE LIGHT CAME ON AND AFTER ABOUT 20 MILES THE CAR STARTED SHIFTING HARD AND FINALLY WOULDN'T GET IN GEAR. TOOK IT TO THE DEALER, AND THEY SAID THE ELECTRONIC CONTROL MODULE (ECM) IS AT FAULT (ERROR P0766- SHIFT SOLENOID D STUCK). THEY REPLACED THE ECM BUT THE PROBLEM PERSISTED. THE DEALER TOLD ME THE ONLY WAY TO FIX THE PROBLEM IS TO REPLACE THE TRANSMISSION. I SPOKE TO TOYOTA CORP BUT THEY TOLD ME THE PROBLEM WITH THE SHIFT SOLENOID IS A "WHOLLY" SEPARATE ISSUE. I TOLD THEM ABOUT THE 2001-2003 EXTENSION OF WARRANTY THAT TOYOTA DID THE RAV4 BUT THEY REFUSED TO COVER THE TRANSMISSION REPLACEMENT. THIS PROBLEM IS VERY DANGEROUS BECAUSE THE TRANSMISSION CAN JUST DISENGAGE FROM THE MOTOR AND LEAVE YOU STUCK IN THE MIDDLE OF THE ROAD WHEN YOU PULL OUT OF DRIVEWAY OR ON THE RAMP ENTERING A HIGHWAY. *TR

Mileage: 77,836

VEHICLE WAS NOT SHIFTING PROPERLY ON THE HIGHWAY. THE RPMS WERE ABOVE 3000. HAD TO SLOW DOWN TO 50 -55 MILES PER HOUR AND REMAIN IN THE SLOW LANE. REST OF THE TRAFFIC WAS TRAVELING AT 65 MPH.

Mileage: 94,046

2001 TOYOTA RAV 4. CONSUMER STATES PROBLEMS WITH COMPUTER AND TRANSMISSION *TGW THE CONSUMER STATED A FEW MONTHS AFTER THE VEHICLE WAS PURCHASED, THE CHECK ENGINE LIGHT ILLUMINATED. THE CONSUMER TOOK THE DEALER TO TWO DEALERS WHO GAVE HIM DIFFERENT STORIES AS TO WHAT THE PROBLEM WAS. HE FINALLY TOOK THE VEHICLE TO HIS PERSONAL MECHANIC FOR THE CHECK ENGINE LIGHT. AND IT WAS DETERMINED THE OXYGEN SENSOR NEED TO BE REPLACED. ALSO, THE TRANSMISSION WOULD SLOW DOWN IN FIRST GEAR AND THEN ACTIVATE HARD IN SECOND GEAR. THE CONSUMER WAS INFORMED A LETTER WAS MAILED REGARDING PROBLEMS WITH THE TRANSMISSION. HOWEVER, THE CONSUMER STATED HE NEVER RECEIVED A LETTER AND THE VEHICLE WAS SERVICED SEVERAL TIMES AT THE DEALER AND NO ONE MENTIONED IT. *JB

TL*THE CONTACT OWNS A 2004 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE JERKED VIOLENTLY WHILE THE GEARS WERE CHANGED AND THERE WAS TROUBLE ACCELERATING. THE FAILURE OCCURRED AT ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION FLUID WAS BLACK; THE FLUID WAS REPLACED. THE FAILURE OCCURRED INTERMITTENTLY. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000 AND THE CURRENT MILEAGE WAS 62,600.

Mileage: 50,000

I DROVE MY 2004 (6 1/2 YEAR OLD) RAV4 SPORT AWD TODAY AS USUAL TO WORK (16 MILES). IT HAS JUST SHORT OF 50,000 MILES ON IT AND IS READY FOR THE NEXT OIL CHANGE IN MORE THAN 1000 MILES. I HAVE DONE THE MAJORITY OF MAINTENANCE AT THE DEALERSHIP. I DROVE THE CAR FROM MY OFFICE AT 169 AND 62, ON 62 THEN NORTH ON I35W TO MINNEAPOLIS AND THEN ON I94E TO ST. PAUL. SOON AFTER I GOT ON I94 I NOTICED SUDDEN FAILURE TO ACCELERATE WITH A JERKING AND HIGH REVS (TO ABOUT 4500) WHEN GOING FROM 55 TO 60. THE GEARS DID NOT FULLY ENGAGE AND RUMBLED AND DID NOT CHANGE OR DRIVE FULLY IN ANY GEAR. I WAS CONCERNED ABOUT TRANSMISSION PROBLEMS AND STOPPED AT A SERVICE STATION (MIKE'S BP IN ST. PAUL DOWNTOWN) THAT HAD DONE AN OIL CHANGE ON MY CAR. THE SERVICE PERSON CHECKED MY TRANSMISSION FLUID AND SAID IT WAS "FILTHY" BUT FULL. HE SAID IT MAY NEED A NEW TRANSMISSION. I CHOSE TO CANCEL MY TRIP OUT OF STATE FOR WORK, AND DROVE DIRECTLY HOME AFTER SETTING UP WITH MY REGULAR MECHANIC FOR NEXT TUESDAY, THE EARLIEST OPEN APPOINTMENT. I WAS SURPRISED TO HAVE THIS ISSUE COME UP SO SUDDENLY AND IT IS A CLEAR DANGER SINCE I MOSTLY WOULD DRIVE ON INTERSTATE HIGHWAYS IN RUSH HOUR TRAFFIC OR LONG DISTANCE FOR WORK AND IT COULD CAUSE A CRASH. I WILL NOT DRIVE THE VEHICLE. THIS CAR HAD NO ISSUES AT ALL SO FAR - ONLY REPLACED THE WIPERS A YEAR AGO. I AM CONCERNED TO HAVE FURTHER DAMAGE TO THE TRANSMISSION AS THE CAR DROVE SO UNPREDICTABLY AND MAKES STRANGE NOISES NOW IF IT IS SHIFTING. I HAVE A TOYOTA PURCHASED EXTENDED WARRANTY GOOD UNTIL END OF JUNE 2011 AND I'LL WORK ON GETTING THIS COVERED. IT IS FRIGHTENING TO HAVE THIS HAPPEN TO MY VEHICLE AS I DEPEND ON MY CAR FOR WORK TRIPS AND FOR COMMUTING. I'M GLAD I HAVE THE WARRANTY AND WILL HAVE THE WORK DONE TO FIX THE PROBLEM IF THAT IS POSSIBLE. MY CAR GOES THROUGH REGULAR MAINTENANCE AT A TOYOTA DEALERSHIP AND THEY RUN CHECKS FOR ANY RECALLS EVERY TIME IT IS IN THE SHOP. THERE HAS BEEN NOTHING AT ALL ON THE VEHICLE THUS FAR. *TR

Mileage: 49,500

TRANSMISSION ISSUES, NOT SHIFTING PROPERLY ALL THE TIME! DEALER TELLS ME TRANS NEEDS $3000.00 IN REPAIRS! *TR

WAS DRIVING DOWN THE ROAD AND THE TRANSMISSION STARTED MAKING NOISES. IT CRACKED REAL LOUD ONE TIME AND I HAD NO POWER. WHEN I CAME TO A RED LIGHT AND TRIED TO GO AGAIN IT WOULDN'T TAKE OFF. TOOK ME 3 HRS TO DRIVE 55 MILES TO GET MY RAV HOME. CONTACTED A GARAGE THAT SPECIALIZES IN TRANSMISSION. WAS TOLD THEY JUST RECEIVED A NOTICE FROM TOYOTA THAT THE COMPUTER CHIP IN THE TRANSMISSION WAS FAILING BUT THAT I HAD TO MANY MILES TO QUALIFY. THE GARAGE PUT IN A NEW COMPUTER CHIP (RECOMMENDED BY TOYOTA) AND IT DIDN'T COMPLETELY TAKE CARE OF THE PROBLEM SO THEY ENDED UP PUTTING A WHOLE NEW TRANSMISSION IN TO THE PRICE OF $4611. *TR

Mileage: 102,000

2004 RAV 4 AUTOMATIC TRANSMISSION BEGAN SHIFTING VERY HARD. I HAVE RESEARCHED THE INTERNET AND THERE ARE MANY COMPLAINTS ON THIS SAME ISSUE. TOOK IT TO AAMCO FOR TESTING. IT IS RELATED TO THE COMPUTER MODULE AND CAUSED INTERNAL DAMAGE TO THE TRANSMISSION. *TR

Mileage: 135,000

2004 RAV4. ACCELERATOR HAS BECOME ERRATIC IN THE LAST 3 MONTHS. CAR WILL LEAP AHEAD WITH VIRTUALLY NO PRESSURE ON PEDAL. ONLY DOES IT OCCASIONALLY. PEDAL IS MOUNTED QUITE HIGH, ABOVE THE BRAKE PEDAL, AND CANNOT CONTACT FLOOR MATS. WHILE PULLING INTO A RIGHT ANGLE PARKING SPOT AT LOW SPEED AND WITH FOOT ON BRAKE, VEHICLE SUDDENLY SURGED AHEAD. I WAS ONLY 5 FEET FROM A BRICK WALL AND COULD NOT RESPOND QUICKLY ENOUGH TO BRAKE THE VEHICLE. IMPACT WITH WALL PLASTER (ABOUT 1 FOOT WIDE) CRUSHED THE BUMPER, GRILL AND BUCKLED THE HOOD. APPARENTLY SPEED WAS NOT GREAT AND THE AIRBAGS DID NOT DEPLOY BUT SEATBELTS CAUSED CHEST INJURY TO BOTH MY PASSENGER AND MYSELF. PERHAPS FORTUNATE THAT THE WALL WAS SO CLOSE OR MY PASSENGER AND MYSELF MIGHT HAVE BEEN MORE SERIOUSLY INJURED. WILL BE TRADING THIS CAR IN AS SOON AS IT IS REPAIRED. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA RAV 4. THE VEHICLE WOULD ONLY DRIVE NORMALLY WHEN THE ENGINE WAS WARM. WHILE IDLING ON TOP OF A HILL THE VEHICLE WOULD ALSO ROLL BACKWARDS. THE DEALER HAS NOT DIAGNOSED THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

Mileage: 50,000

AUTOMATIC TRANSMISSION SHIFT CABLE BROKEN WHILE SELECTING TO PARK, THIS VEHICLE COULD ROLL FORWARD OR BACKWARD UPON RELEASING THE BRAKE. IF IN CASE THE CABLE BROKEN WITHOUT KNOWING WHILE CRUISING I HAVE NO OPTION TO DOWNSHIFT IN CASE OF EMERGENCY ON A DOWNHILL ROAD OR BRAKE SYSTEM FAILURE. I'VE REPLACED THE PART AT A COST OF $196.00 + LABOR. *NM

Mileage: 67,000