2006 TOYOTA RAV4 Power Train Problems

WE PURCHASED A 2006 RAV4 LIMITED THE FIRST WEEK OF MARCH 2019. A REAR DIFFERENTIAL COUPLING GROWL NOISE WAS NOTICEABLE A MONTH AFTER WE PURCHASED THE VEHICLE. WHILE DRIVING THE REAR END STARTED MAKING A GROWLING NOISE. IN EARLY JANUARY 2015 TOYOTA ISSUED A WARRANTY ENHANCEMENT PROGRAM (ZF4) FOR YEARS 2006-2012 RAV4 TO HAVE THE DEFECTIVE BEARING REPLACED, BUT THEY PUT AN EXPIRATION DATE OF APRIL 30TH 2017 OR 9 YEARS FROM THE DATE OF FIRST USE REGARDLESS OF MILEAGE. I CAN'T UNDERSTAND HOW YOU CAN PUT AN EXPIRATION DATE ON A DEFECTIVE PART. THESE BEARINGS COULD GO BAD AND SEIZE AT ANY TIME POSSIBLY CAUSING AN ACCIDENT WITH INJURIES OR EVEN DEATH. WE HAPPEN TO OWN TWO OF THESE VEHICLES, SAME YEARS, ONE MAKING NO NOISE AND NOT GOING BAD YET, BUT THE OTHER DECIDED IT WAS TIME. THERE SHOULD BE A RECALL ON THIS REAR DIFFERENTIAL COUPLING BEARING, NOT A WARRANTY ENHANCEMENT PROGRAM. TOYOTA HAS ALREADY ACKNOWLEDGED A DEFECT WITH THE BEARING BY INITIATING A WARRANTY ENHANCEMENT PROGRAM, YOU CAN'T JUST SAY AFTER APRIL 30TH 2017 NO OTHER BEARINGS WILL FAIL AND IF THEY DO WE PASS THE BUCK ON THE PROBLEM. THANK YOU FOR HEARING MY CONCERNS, I LOOK FORWARD TO HEARING BACK FROM YOU. I WOULD LIKE TO DEBATE THE ISSUE WITH ONE OF THEIR REPRESENTATIVES WITH YOU LISTENING, I'D RIP'EM APART. IT IS TIME THESE BILLION DOLLAR COMPANIES OWN UP TO THEIR MISTAKES AND NOT PASS THE BUCK TO THE LITTLE GUY. THANK YOU AGAIN, (XXXX). YOU CAN CONTACT ME AT (XXXX). PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Mileage: 150,000

LOSING OIL ENGINE MAKING NOISE NO POWER

TAMARA RECALL ENGINE FAILURE ALMOST CAUSED A MAJOR ACCIDENT. DEALERSHIP TELLS ME THE IT'S AN RECALL BUT, IT HAS NOW EXPIRED. I DON'T UNDERSTAND HOW A SAFETY RECALL CAN EXPIRE. I NEED HELP FROM AN ATTORNEY ON THIS MATTER. BECAUSE THIS ISN'T RIGHT. CAN YOU RECOMMEND AN ATTORNEY? THEY SAID THEY COULD ONLY DO NEW RINGS AND NEW PISTONS BACK THEN BUT NOW TOYOTA WILL NOT EVEN DO THAT. SO NOW I JUST HAVE A 5,000 BILL FOR A NEW ENGINE.

REAR DIFFERENTIAL COUPLER IS FAILING. EMITTING AN AWFUL NOISE AND GETTING WORSE. SPOKE TO TOYOTA CUSTOMER SERVICE. THEY TOLD ME THAT THE ENHANCED EXTENDED WARRANTY HAS EXPIRED AT THE END OF LAST YEAR. I DID NOT KNOW ABOUT THIS, UNTIL THE PART HAS WORN OUT. (DEFECTIVE) IT IS A $1400. PART PLUS LABOR TO INSTALL. THEY CANNOT EXTEND THE ENHANCED EXTENDED WARRANTY ACCORDING TO THE RULES THAT NHTSA HAS SUGGESTED. DON'T YOU THINK IT IS TIME FOR NHTSA TO REQUIRE THAT TOYOTA RENEW THIS REPLACEMENT, OR CALL IT A RECALL FOR THEIR DEFECTIVE MANUFACTURING PROCESS?

Mileage: 115,000

I BOUGHT THE CAR BACK IN AUGUST 2006 AT TOYOTA DEALER. THERE WERE CLUNKY SOUNDS FROM THE STEERING WHEEL WHEN AFTER COUPLE MONTHS OF PURCHASE. I BROUGHT THE CAR BACK TO DEALER TO REQUEST FOR A FIX BUT I WAS TOLD THAT THE CLUNKY SOUNDS FROM THE STEERING WHEEL SHOULD BE CONSIDERED AS NORMAL AS THE WAY THE IT CAME FROM TOYOTA FACTORY. THERE WAS NO FIX TO CORRECT THAT CLUNKY NOISES FROM STEERING WHEEL ON THAT DAY. I HAD TRUSTED TO TOYOTA'S ADVICE ON THAT DAY AND KEPT DRIVING THE CAR UNTIL OTHER MECHANICS AND FRIENDS TOLD ME THAT MY CAR NEEDED TO BE FIXED WITH THE STEERING WHEEL SINCE THERE HAD BEEN CLUNKY NOISES WHEN THEY TESTED DRIVE ON MY CAR. THE SOUNDS ALWAYS CAME UP WHEN I MOVED THE STEERING WHEEL. I CALLED TOYOTA SERVICE AROUND 06/2014 ABOUT THE CLUNKY NOISE SINCE THE CONDITION GOT WORSE. I WAS TOLD THAT MY CAR IS OUT OF WARRANTY SO THERE IS NOTHING FROM TOYOTA TO HELP FIXING THE PROBLEM. TOYOTA TOLD ME THAT THERE WOULD BE RECALL IF THERE HAD BEEN NUMEROUS COMPLAINTS WITH THE SAME PROBLEM I HAD. I WAS ADVISED TO WAIT FOR A RECALL. FOR SAFETY CONCERN, I BROUGHT THE CAR TO TOYOTA DEALERSHIP AFTER MY CONVERSATION WITH TOYOTA CUSTOMER SERVICE ON 06/2014. TOYOTA DEALERSHIP HAD QUOTED WITH A FIX FOR $600 FOR THE PART NOT INCLUDING THE LABOR. THE CLUNKY NOISE WAS CAME FROM THE INTERMEDIATE STEERING WHEEL SHAFT. I COULD NOT AFFORD TO FIX BECAUSE THE PRICE WAS TOO EXPENSIVE SO I HAD TO KEEP THE CAR CONDITION AS IT WAS. TOYOTA SHOULD FIX THE PROBLEM WHEN I BROUGHT IT IN. THERE HAVE BEEN SO MANY COMPLAINTS FROM 2006 TOYOTA RAV4 OWNERS WHO HAVE THE SAME THIS INTERMEDIATE STEERING SHAFT. I DON'T KNOW IF THERE HAS BEEN ANY ACCIDENT INVOLVED THIS ISSUE OR NOT BUT I AM VERY SURE THAT THIS IS A SERIOUS MATTER SINCE THIS INTERMEDIATE SHAFT IS RELATING TO THE CONTROLLING CAR'S FRONT WHEELS. FOR THE SAFETY CONCERN, PLEASE HELP TO LOOK INTO THIS COMPLAINT.

Mileage: 2,000

WHEN TRYING TO BACK UP A HILL, THE TRANSMISSION POPS OUT OF GEAR AND THEN BACK INTO GEAR. WHEN IT POPS BACK INTO GEAR THE CAR LUNGES IN AN UNCONTROLLABLE MANNER. THIS IS VERY DANGEROUS! I HAVE READ THAT THIS IS CAUSE BY PREMATURE WEAR-OUT OF THE REVERSE CLUTCHES AND THE FIX IS A NEW $4000 TRANSMISSION. THIS IS A SAFETY ISSUE THAT TOYOTA SHOULD AT LEAST PROVIDE AN ASSISTANCE PROGRAM TO REPAIR. THE PROBLEM IS CONTINUOUS, IT WAS ALWAYS OCCUR WHEN TRYING TO BACK UP A HILL.

Mileage: 111,000

TRANSFER CASE NOISE; QUELLING NOISE IS COMING FROM ENGINE ( I HEAR THIS NOISE AT LOW SPEED BETWEEN 20 MILES AND 40MILES). WHEN I PUSH GAS PEDAL VEHICLE DON,T PICK THE SPEED, ENGINE RUNS FAST AND IT JUMPS TO GET ITS SPEED.

Mileage: 132,000

WHEN PLACED IN REVERSE GEAR CAR BOLTS OR JUMPS. LOUD NOISE. EITHER REVERSE GEAR OR TRANSMISSION IS FAULTY. HAS GOTTEN WORSE OVER THE YEARS.

Mileage: 60,000

BOUGHT USED 2006 RAV 4 FROM WHAT I THOUGHT WAS A REPUTABLE TOYOTA DEALER IN LAKE CITY FLORIDA.WITHIN 2 WEEKS OF BUYING THIS CAR CHECKED OIL AND IT WAS 2 QUARTS LOW.NOW ABOUT EVERY 1000 MILES OR LESS THIS VEHICLE IS USING NEARLY 2 QUARTS OF OIL.PLEASE HELP IN THIS MATTER.THIS WAS SUPPOSED TO BE MY DAUGHTERS GOING OFF INTO THE WORLD VEHICLE BUT ITS TURNING OUT TO BE A PIECE OF CRAP.AND A WASTE OF MONEY.I KNOW TOYOTA IS AWARE OF THE PROBLEM AND WILL DO NOTHING TO FIX IT.LAKE CITY TOYOTA ARE RUDE AND HAVE DONE NOTHING TO HELP IN THIS PROBLEM. AND IN HINDSIGHT BUYING THIS CAR THEY WERE VERY SKETCHY IN THE WAY THEY GOT US THERE TO BUY IT IN THE FIRST PLACE.NOW I KNOW WHY.I JUST WANT THIS VEHICLE REPAIRED.WE LIKE EVERYTHING ELSE ABOUT IT.BUT ENGINE FAILURE AND OR CATALYTIC CONVERTER ISSUES DOWN THE ROAD IS SADDENING FOR A VEHICLE WE JUST PAID 7000 DOLLARS FOR.TOYOTA WE WILL NEVER BUY AGAIN. *TR

Mileage: 101,000

AT APPROXIMATELY 81000 MILES, RAV-4 STARTED TO BURN OIL AT A RATE OF TWO QUARTS PER EVERY 3000 MILES. NOW AT 120,000 MILES, IT BURNS ONE QUART EVERY 1000 MILES. BY COMPARISON, MY 1987 TOYOTA CAMRY DOES NOT BURN A DROP. *TR

Mileage: 81,000

LETTER FROM CONSTITUENT REGARDING PROBLEMS WITH HIS 2006 TOYOTA RAV 4; HE HOPING THAT TOYOTA CAN BE FORCED TO REPAIR THE TRANSMISSION AND REIMBURSE THE COST OF REPAIRING STEERING SHAFT (FULL DOCUMENT NOT IMAGED). *SMD THE CONSUMER STATED HE HAS BEEN TRYING TO GET THE TRANSMISSION REPLACED PER TOYOTA TSB-0130-12, BECAUSE OF WHINING NOISE BUT HE WAS INFORMED THE TSB WAS NO LONGER IN EFFECT. IT WAS CONFIRMED, THAT AN INTERNAL NOISE WAS COMING FROM THE TRANSMISSION. *JB

LOUD GRINDING SOUND AT APPROX 40MPH, EASILY REPLICATED AND SOUNDS AS IF SOMETHING IS STUCK UNDERNEATH CAR. DEALER REFUSES TO ACKNOWLEDGE FAULTY PARTS OR COVER ANY REPAIRS. *TR

Mileage: 84,000

OUR 2006 RAV4 CREATES A GROWLING SOUND FROM THE REAR DIFFERENTIAL AREA WHEN DRIVING AT 35 TO 40 MPH. THE SOUND GOES AWAY WHEN ACCELERATING ABOVE 40 MPH. THE NOISE IS BECOMING MORE PRONOUNCED WITH TIME. TWICE THE VEHICLE WAS TAKEN TO A TOYOTA DEALERSHIP AND THEY WERE UNABLE TO IDENTIFY THE CAUSE. RESEARCH ONLINE LOCATED TECHNICAL SERVICE BULLETIN TSB-0080-13 WHICH DISCUSSES SYMPTOMS VERY SIMILAR TO WHAT OUR RAV IS EXPERIENCING. A CALL TO THE TOYOTA DEALERSHIP RESULTED IN BEING INFORMED THAT DETERIORATION OF THE REAR DIFFERENTIAL COUPLING DUE TO CONTAMINATED BEARING COULD BE THE PROBLEM, AND THAT ESTIMATED COST OF REPAIR COST IS $1,925. I ASKED IF FAILURE OF THE COUPLING COULD BE CATASTROPHIC, CAUSING LOSS OF CONTROL. THE ANSWER WAS NOT LIKELY UNLESS DRIVING ON SLIPPERY SURFACES. THIS VEHICLE IS REGULARLY MAINTAINED, AND HAS NOT BEEN IN AN ACCIDENT. IT IS DISAPPOINTING THAT WE ARE LOOKING AT AN IMPENDING FAILURE OF THE DRIVETRAIN. IS THIS A FLAW IN THE ENGINEERING/DESIGN THAT WENT INTO THIS VEHICLE? WHAT ELSE CAN BE DONE BEYOND INFORMING OTHERS IN THE INTEREST OF THEIR PERSONAL SAFETY? *TR

Mileage: 85,000

I HAVE A 2006 RAV4, BUILT IN NOVEMBER, 2005. MY CHECK ENGINE, VSC AND 4WD LIGHTS LIT UP ON AUGUST 16, 2013. AFTER REFERRING TO THE MANUAL AND FOLLOWING DIRECTIONS YIELDED NO RESULT, I KEPT DRIVING AND WENT TO A TOYOTA DEALER THE NEXT DAY. I WAS ADVISED THE TRANSMISSION IN MY CAR HAD FAILED AND I NEEDED A NEW ONE. THE TRANSMISSION HAD BEEN FLUSHED ON 9/18/12 WITH 59,767 MILES ON MY CAR, THE DEALER MARKED THE TRANSMISSION FLUID "GOOD" ON 6/17/13 WITH 65,143 MILES AND THERE WERE ONLY 66,319 WHEN THE TRANSMISSION FAILED IN AUGUST, 2013. BEING STRANDED OUT OF TOWN FOR THREE DAYS ALLOWED ME TO FIND NUMEROUS COMPLAINTS ABOUT THE TRANSMISSION FAILING IN RAV4'S WITH LOW MILEAGE. THERE WAS ABSOLUTELY NO WARNING THAT A HUGE PROBLEM AND EXPENSE WAS ABOUT TO OCCUR (WHICH IS STRANGE WHEN AN ALARM BLEATS, REQUESTING FASTENING OF THE SEATBELT, WHEN A GALLON OF MILK IS PUT ON THE PASSENGER SEAT.) AND THERE IS NOTHING IN THE MANUAL TO EVEN SUGGEST THE LIGHTS THAT LIT INDICATE A TRANSMISSION PROBLEM. I HAVE FILED CASE #1310310749 WITH TOYOTA AND AWAIT THEIR FOLLOW UP ON PROMISES MADE. I WILL HAPPILY PROVIDE COPIES OF ANY PAPERWORK, SHOULD IT BE REQUESTED. I WOULD ASK FOR THE TRANSMISSION FAILURES TO BE LOOKED INTO AS WELL AS THE TOTAL LACK OF CLARITY AND/OR DIRECTION IN THE MANUAL. THANK YOU FOR YOUR TIME. *TR

Mileage: 66,319

SATURDAY, OCTOBER 12, 2013 WHEN MY WIFE AND TWO YOUNG DAUGHTERS (AGES 2 & 4) WERE COMING HOME FROM SHOPPING. OUR VEHICLE EXPERIENCE CATASTROPHIC FAILURE, ENDANGERING THE LIVES MY WIFE AND MY TWO YOUNG CHILDREN. SHE HEARD A LOUD BANG FROM THE REAR OF THE VEHICLE AND SHE LOST CONTROL. LUCKILY, SHE WAS NOT MOVING VERY FAST AND WAS ABLE TO STOP QUICKLY AND PULL TO THE SIDE OF THE ROAD. THE FAILURE OCCURRED ON THE ON-RAMP TO AN INTERSTATE 71 WITH A POSTED SPEED LIMIT OF 70 MPH AND THE CAR WAS NOT DRIVABLE. HAD THE FAILURE OCCURRED 20 SECONDS LATER, MY FAMILY WOULD HAVE BEEN TRAVELING AT A HIGH SPEED IN A RAV 4 WITH ABSOLUTELY NO CONTROL. WE CANNOT EVEN FATHOM THE POTENTIAL OUTCOME IF THAT FAILURE HAD OCCURRED ON A BUSY HIGHWAY WITH TRUCKS ETC. WE TOOK THE RAV INTO THE LOCAL TOYOTA DEALERSHIP AND THEY DEEMED THE ACCIDENT TO BE CAUSED BY THE REAR LOWER SUSPENSION ARM. THE REAR LOWER SUSPENSION ARM WAS RECALLED IN THE FALL/WINTER OF 2012, WHERE WE TOOK IT TO THE DEALERSHIP TO BE FIXED IN NOV. 2012 WITH THE SO CALLED "CLIP". *TR

Mileage: 97,000

WHILE DRIVING FROM MARYLAND TO MAINE FOR A VACATION, I NOTICED MY TRANSMISSION WAS SLIPPING AND GRINDING GEARS FREQUENTLY IN THE RANGE OF 20-35 MPH. I NOTICED IT HAPPENING MORE FREQUENTLY DURING SLOWDOWN FOR MAKING A TURN AND THEN ACCELERATION TO RESUME DRIVING. I DID NOT HAVE ANY ACCIDENTS, BUT THIS HAS BEEN HAPPENING MORE FREQUENTLY. I HAD PREVIOUSLY REPORTED THE PROBLEM, WHEN IT HAPPENED LESS FREQUENTLY, TO MY DEALERSHIP (DARCARS OF FREDERICK) AND THEY TOLD ME THAT 1)THEY COULD NOT DUPLICATE THE SOUND DURING THEIR TEST RUN AND 2) IF SUCH A THING HAD HAPPENED, MY ECU WOULD HAVE MADE A NOTE OF IT AND RECORDED IT. SINCE THERE WAS NO RECORD OF IT HAPPENING, IT WAS NOTHING. HOWEVER, UPON READING SEVERAL COMPLAINTS ABOUT THE RAV4 02-03 MODELS, REGARDING TRANSMISSION PROBLEMS, I FIND THAT THEIR ISSUES OF HANGING BEFORE SLIPPING INTO GEAR, GRINDING GEAR AND NOT FINDING THE GEAR AT ALL ARE THE SAME ONES I HAVE BEEN EXPERIENCING IN MY '06 RAV4. COULD IT BE THAT MY ECU IS BAD? YES, BUT MY DEALER WON'T ACKNOWLEDGE THAT POSSIBILITY. THEY CHECK MY FLOOR MATS, BUT NOT THE ECU FOR FAULTY ISSUES. THIS IS MY PRIMARY VEHICLE AND I TRANSPORT MY DAUGHTER IN IT ALL OF THE TIME. I AM WORRIED ONE DAY I AM GOING TO BE DRIVING AND GET INTO A SERIOUS ACCIDENT BECAUSE OF THIS ISSUE. I HAVE ALL OF MY MAINTENANCE RECORDS AND RECENTLY HAD THE TRANSMISSION FLUSHED AND FILLED COMPLETELY. I USED OEM FLUID AND AM ON SCHEDULE WITH ALL OF MY MAINTENANCE. *TR

WHILE DRIVING ON A SUBURBAN NJ ROAD AT AROUND 30-40MPH, THE VEHICLE LOST STEERING CONTROL OUT OF THE BLUE. THE CAR VEERED INTO THE LEFT LANE, I ATTEMPTED TO RIGHT THE CAR AND SIMULTANEOUSLY HIT THE BREAKS. THE ABS RESPONSE KICKED IN, AND THE CAR VEERED DRASTICALLY TO THE RIGHT, GOING OFF THE ROAD, ACROSS THE SIDEWALK, AND FINALLY COMING TO A STOP IN THE WOODS. THE REPAIR SHOP DISCOVERED THAT THE CAUSE OF ACCIDENT WAS A BROKEN TIE ROD OF THE BACK RIGHT WHEEL, THAT HAD BEEN BROKEN FOR A WHILE BECAUSE THE SLEEVE ENCASING HAD RUSTED OVER. THE DAMAGE TO THE CAR TOTALLED $10,000, AND THE SHOP WOULD HAVE TOTALED THE CAR IF THE MILAGE HADNT BEEN SO LOW. *TR

Mileage: 43,116

MY TRUCK HAS HAD 4 INCIDENTS OF DANGEROUSLY LOW OIL LEVELS. TOYOTA HAS SERVICE BULLETINS OUT REGARDING OIL CONSUMPTION AND MY MODEL OF THE 2006 TOYOTA RAV4 REGARDING FAULTY PISTONS AND RINGS. I HAVE BROUGHT MY TRUCK TO TOYOTA 4 TIMES FOR THIS ISSUE AND TOYOTA REFUSES TO FIX THE PROBLEM UNDER MY WARRANTY STATING THAT I AM OUT OF WARRANTY EVEN THOUGH MY FIRST COMPLAINT WAS 10/13/13 AND MY WARRANTY EXPIRED JAN 2013 T-SB-0094-11 IS THE TOYOTA SERVICE BULLETIN. *TR

Mileage: 91,738

MY POWER STEERING P/S WARNING LIGHT CAME ON AS I WAS BACKING OUT OF A PARKING SPACE. I NOTICED MY POWER STEERING SUDDENLY WASN'T WORKING. I DROVE HOME AND THEN TOOK IT BACK OUT OF MY GARAGE, IN WHICH THE LIGHT THEN TURNED OFF AND I HAD MY POWER STEERING BACK. IS THIS A KNOWN DEFECT OF MY CAR? I DID RECEIVE ONE ABOUT THE REAR LOWER SUSPENSION ARM #1 AND A FLOOR MAT RECALL, BUT THAT'S ALL. *TR

Mileage: 74,400

DRIVE SHAFT BROKE. *TR

Mileage: 104,000

STEERING WHEEL "CLUNKS" AT RELATIVELY LOW SPEEDS - CLUNKING INCREASES OVER TIME. CONCERN IS IF STEERING FAILS AS A RESULT. TOYOTA'S FIX IS TO REPLACE INTERMEDIATE DRIVESHAFT AND AN ALIGNMENT. APPARENTLY THIS IS A PERVASIVE PROBLEM ON A NUMBER OF RAV4 MODEL YEARS (BASED ON HUNDREDS OF POSTINGS ON INTERNET DISCUSSION SITES, AT LEAST ONE OF WHICH CLAIMS FAILED STEERING RESULTING IN MULTICAR CRASH). PER THESE ONLINE DISCUSSIONS, SOME TOYOTA DEALERS HAVE STATED IT IS A SERIOUS SAFETY ISSUE, SOME HAVE NOT. GIVEN THIS PROBLEM HAS EXISTED FOR A NUMBER OF YEARS (TOYOTA HAS TWO SERVICE MEMOS ISSUED ON THE PROBLEM AND EVEN DEVELOPED NEW REPLACEMENT PARTS), IF THE NHTSA HAS INVESTIGATED THIS ISSUE AND DETERMINED THERE IS NO CONSUMER SAFETY ISSUES, IS THAT CONCLUSION AVAILABLE TO THE PUBLIC? WOULD APPEAR THIS WOULD BE PROPER TO DISCLOSE, AS CONSUMERS GET VERY CONCERNED WITH A POTENTIAL LOSS OF STEERING AND ITS POTENTIAL CRASH RAMIFICATIONS. *TR

Mileage: 40,000

THERE WAS A RUMBLE IN THE REAR @ 40 MPH. I HAD MAPLEWOOD TOYOTA CHECK IT 2-3 TIMES, THEY SAID THEY COULDN'T HEAR IT, CAR WAS FINE; THEY CHECKED THE TRANS OIL ONCE AND SAID IT WAS FINE. IT'S A CLOSED SYSTEM-YOU NEVER NEED TO CHANGE ITS OIL. (I HAD ASKED THIS QUESTION SEVERAL TIMES OVER THE YEARS AND THEY ALWAYS TOLD ME THAT I NEVER NEEDED TO CHANGE THE TRANS OIL & THE MANUAL DOES NOT LIST IT EITHER). THEY TOOK IT FOR A DRIVE AND CHECKED IT GOOD-SAID THAT 1ST GEAR WAS GOING, BUT IT WAS FINE TO DRIVE-COME BACK WHEN I COULDN'T STAND THE NOISE AND THEY'D PUT IN A NEW TRANS FOR $4,500. I WAS GOING OUT OF TOWN, THEY SAID OK, CAR WILL BE FINE. SINCE THE RUMBLE WAS SO LOUD, 3 DAYS LATER I GOT A SECOND OPINION AT A TRANSMISSION SPECIALIST'S SHOP RECOMMENDED TO ME BY SEVERAL FRIENDS. THEY PUT IT UP ON A RACK AND TESTED IT WITH A STETHOSCOPE TYPE DEVICE. THEY SAID THAT THE BEARING WAS VERY BAD AND THAT I SHOULD NOT TAKE THE CAR OUT OF TOWN OR DRIVE IT AS IT WAS NOT SAFE TO DRIVE AND COULD STOP AT ANY TIME. THEY REPLACED M,W/S, U240/24E 00-UP (CORK); FILTER; BUSHING, A40 SERIES PUMP; TC, RAV4, MED STALL, INK 14; CENTER GEAR BEARING, ETC. WHEN THE TOYOTA TECHNICIAN CHECKED THE TRANS OIL, I REALIZED THAT IT WAS NOT "A CLOSED SYSTEM"! ALSO, THE OIL WAS BLACK AND I NOW KNOW THAT IT SHOULD BE RED. I THINK I SHOULD HAVE BEEN CHANGING THE TRANS OIL ALL ALONG AND MY TRANSMISSION PROBABLY WOULD NOT HAVE FAILED. I THINK THEY SHOULD ORDER A RECALL ON ALL THESE TRANSMISSIONS - AND PAY FOR THE WORK THAT I HAD TO HAVE DONE BEFORE MY CAR FAILED ON A FREEWAY SOMEWHERE. A TRANSMISSION SHOULD LAST FOREVER, ESPECIALLY SINCE HALF OF THE MILES HAVE BEEN FREEWAY MILES AND I DRIVE MY CAR VERY GENTLY. I JUST PUT IN NEW BRAKE PADS FOR THE FIRST TIME RECENTLY AND THERE WAS STILL 20-30% LEFT ON THEM. PREVIOUSLY I HAD TO PAY TOYOTA $400 TO REPAIR THE STEERING COLUMN-ANOTHER DEFECT THAT SHOULD BE A RECALL. *TR

Mileage: 107,000

WHEN STARTING UP FROM A STOP, THE AUTOMATIC TRANSMISSION SHIFTS PROPERLY FROM 1ST TO 2ND GEARS HOWEVER WHEN IT SHIFTS FROM 2ND TO 3RD GEAR, IT APPEARS TO MOMENTARILY GO IN TO NEUTRAL WHERE THE ENGINE WINES OUT BEFORE QUICKLY BANGING INTO THIRD GEAR. VERY HARSH SHIFTING. THIS APPEARS TO OCCUR ONLY AFTER THE TRANSMISSION HEATS UP AFTER DRIVING FOR ABOUT 30 MINUTES OR LONGER. AFTER THIS OCCURS, IT WILL DO THIS EVERY TIME WHEN STARTING FROM A STOP. I HAVE COMPLAINED ABOUT THIS TO THE DEALER FOR SOME TIME HOWEVER WAS ONLY RECENTLY ABLE TO PROVE IT TO THEM. I WAS THEN TOLD THAT I WOULD NEED A NEW TRANSMISSION FOR ABOUT $4000.00. *TR

Mileage: 70,000

MY 2006 RAV4 SPORT THAT OCCASIONALLY HAS PROBLEMS WITH ACCELERATION, THIS USUALLY OCCURS RIGHT AFTER STARTING THE VEHICLE AND CAN LAST UP TO 15 MIN INTO THE DRIVE. OCCURS WHEN ACCELERATING FROM A STOP, YOU PRESS THE GAS PEDAL AND RECEIVE A VERY SLOW RESPONSE FROM THE VEHICLE; ALMOST AS IF TRYING TO DRIVE WITH THE E BRAKE ON. ONCE YOU HAVE REACHED 5-10MPH IT ENGAGES AND GOES, BUT UNTIL THEN IT IS VERY UNSAFE. THIS IS ESPECIALLY TRUE WHEN MAKING A LEFT HAND TURN, ALTHOUGH YOU WOULD NORMALLY HAVE ENOUGH ROOM AND TIME TO TURN AND BE OUT OF THE WAY FOR INCOMING TRAFFIC, IF YOU DON'T COMPENSATE FOR THAT ADDITIONAL LAG , YOU COULD GET T-BONED. *TR

Mileage: 30,000

AT APPROXIMATELY 60,000 MILES I NOTICED WHEN I BACKED UP I HEARD A LOUD CLUNKING NOISE IN WHAT SEEMED TO BE THE REAR. AT APPROXIMATELY 62,000 MILES I TOOK IT TO MY DEALER AND IT WAS DIAGNOSED AS A "TRANSAXLE" PROBLEM. *TR

Mileage: 61,000

WHEN FIRST DRIVING MY NEW 2006 TOYOTA RAV4, I NOTICED AT SLOW SPEEDS IT WOULD SOMETIMES ACCELERATE WHEN I HIT THE BRAKE. I ATTRIBUTED THIS TO BIG FEET AND A NEW CAR WHERE I DID NOT YET MASTER THE RELATIVE POSITIONS OF THE PEDALS. I STARTED DRIVING WITH TWO FEET, JUST AS I WAS TAUGHT AS A TEENAGER IN DRIVERS ED. OCCASIONALLY, THIS HAS HAPPENED AGAIN IN THE ENSUING 3 YEARS. UNTIL THIS UNINTENDED ACCELERATION PROBLEM CAME TO LIGHT IN 2010, I THOUGHT IT WAS JUST "OPERATOR ERROR." NOW, I AM BEGINNING TO THINK THERE IS SOME DEFECT - MAYBE IT'S HARDWARE LINKAGES, BUT I SUSPECT THERE IS A SOFTWARE PROBLEM IN THE ELECTRONIC COMPUTER OF THE CAR. I ALSO HAD THE STEERING MID-SHAFT PROBLEM AFTER WARRANTY AND SCREAMED UNTIL THEY FIXED IT UNDER WARRANTY FOR $50. THERE WAS ALSO A "RUNAWAY" FUEL PUMP SERVICE BULLETIN I MADE THEM COVER AS WELL. I HAVE WORKED WITH TOYOTA QUALITY ENGINEERS SINCE THE 1980S AND AM DISGUSTED BY THEIR RESPONSES REPORTED IN THIS ODI SITE. TOYOTA'S CLAIM TO FAME WAS THERE QUALITY AND CUSTOMER FOCUS. LOOKS LIKE THE CURRENT GENERATION OF TOYOTA PEOPLE HAVE LOST THIS, AND THAT POINTS DIRECTLY TO TOP MANAGEMENT THERE. SHAME, SHAME, SHAME. AS THEY SAY IN JAPANESE, THEY ARE "ON SHIRAZU" (DO NOT UNDERSTAND THEIR OBLIGATION TO THEIR CUSTOMERS). *TR

Mileage: 1,000

2006 RAV4 UNSAFE TO DRIVE!!! LE BRUN TOYOTA, CANADAIGUA, NY, MADE ME PAY TO EXCHANGE LEMON WITH ONLY 150-200 MILES 2 DAYS AFTER PURCHASE, THEY MADE ME PAY AN ADDITIONAL 7K TO TRADE FOR THE V-6 I HAVE NOW, BECAUSE OF THE TRANSMISSION ACCELERATED DOWNHILL, ON BOTH 4CYL AND V-6, IT STILL DOES IT THOUGH NOT AS SEVERE, STILL SCARY AT TIMES. RECENTLY,MY STEERING WENT OUT ON THE EXIT RAMP LUCKILY AND LOCKED A FEW TIMES, IT NOW MAKES A THUMP AND CAUSED A MINOR ACCIDENT, NEXT TIME I WON'T BE SO LUCKY. REALLY LOUD NOISE FROM REAR ALSO. ANTIFREEZE SMELL INSIDE CAR TOO.H.E.L.P. *TR

Mileage: 100,203

THE POWER STEERING IN MY 2006 TOYOTA RAV4 WENT OUT SUDDENLY WHEN I WAS DRIVING THIS MONTH. I PULLED OVER AND TURNED OFF THE MOTOR. WHEN THE CAR STARTED AGAIN THE POWER STEERING WAS WORKING. THE TOYOTA DEALER HAD REPORTS OF THIS PROBLEM ON THIS CAR FROM TOYOTA. THE POWER STEERING GOES OUT SUDDENLY. TOYOTA WOULD NOT REIMBURSE ME THE COST OF FIXING THIS SAFETY DEFECT. IT COSTS ABOUT $1000. HAD I BEEN ON A HIGHWAY, I COULD HAVE BEEN IN A SERIOUS ACCIDENT. TOYOTA SHOULD RECALL THESE CARS AND FIX THIS SAFETY DEFECT. *TR

Mileage: 31,700

2006 TOYOTA RAV4 V-6 ENGINE. SUDDEN AND MASSIVE LOSS OF ALL ENGINE OIL. DEALER IS AWARE THAT THIS IS CAUSED BY A DEFECTIVE OIL HOSE. NO RECALL ISSUED YET. DEALER STATES "WE'RE JUST FIXING THEM AS THEY COME IN". I WAS FORTUNATE I WAS CLOSE TO HOME. ENGINE WAS BONE DRY OF OIL IN LESS THAN 3 MILES. SHOULD THIS HAVE HAPPENED FURTHER AWAY; 1. ENGINE WOULD HAVE SEIZED. 2. POTENTIAL FIRE - THE UNDERSIDE OF VEHICLE WAS COVERED IN OIL AND COULD HAVE EASILY IGNITED. TOYOTA NEEDED TO RECALL THIS DEFECTIVE PART. NOT "JUST REPAIR AS THEY COME IN." *TR

Mileage: 38,000

2006 TOYOTA RAV 4 RUBBER OIL HOSE (PART NO. 15707-31010) RUPTURE SPEWED OIL ALL OVER ENGINE AND ROAD. VEHICLE HAS 61000 MILES. THE 2008 AND LATER MODEL RAV 4'S NOW USE A DIFFERENT METAL PART (PART NO. 15772-31030). LUCKILY I WAS ABLE TO GET TO THE BREAKDOWN AFTER NOTICING ENGINE SMOKING FROM EXCESS OIL. THE DEALERSHIP WILL ONLY INSTALL ORIGINAL PART NUMBER FOR THE 2006 AND 2007 RAV 4 MODELS, EVEN THOUGH APPARENTLY THE 2008 METAL PART IS SUPERIOR. *TR

Mileage: 61,000

ON FREEWAY, OTHER MOTORIST NOTIFIED ME MY CAR WAS "ON FIRE!" I SAW EXCESSIVE SMOKE IN REARVIEW MIRROR. I TOOK THE NEXT EXIT WHICH WAS DIXON, CA OFF INTERSTATE 80 WEST IN CALIFORNIA. THE SIDE OF THE FREEWAY THERE IS GRASSY, DID NOT THINK IT WAS SAFE TO STOP...I STOPPED THE CAR AND SMOKE WAS EVERYWHERE, COMING UP THROUGH THE HOOD & UNDER THE CAR. THIS WAS TUES, 2/3/09. I HAS THE CAR SERVICED THE FRI BEFORE, 1/30/09 AT TOYOTA VALLEJO IN VALLEJO, CA. I CALLED THE DEALERSHIP AFTER CALLING AAA FOR A TOW. THE SERVICE ADVISOR, RYAN SAID "IT COULDN'T HAVE BEEN FROM ANYTHING THEY HAD DONE. BUT THERE IS AN 'OIL HOSE' THAT HAD BEEN COMING OFF ALOT OF THE RAV4'S." I WAS ALREADY UPSET & THAT MADE ME LIVID!! IF IT WERE A KNOWN PROBLEM THE DEALERSHIP SHOULD HAVE CHECKED DURING THE SCHEDULED MAINT. MY CAR WAS TOWED TO LITHIA TOYOTA OF VACAVILLE #47 AT 500 ORANGE DRIVE, VACAVILLE, CA. WORK ORDER 394212. AS OF YESTERDAY, 2/12/09, THE ASSISTANT SERVICE MANAGER, MEGAN, TOLD ME THERE WAS NO TSB SHE WAS AWARE OF, YET THE PART THAT CAME OFF (VVTI OIL PIPE) WAS NOT FOUND AT ANY OTHER DEALERSHIP OR SUPPLIER IN THE UNITED STATES, AND WAS ON ORDER FROM TOYOTA IN JAPAN. I AM FURIOUS THAT IT APPEARS TOYOTA WAS WELL AWARE OF THIS PROBLEM AND HAS FAILED TO INITIATE ANY STEPS TO PREVENT RISK TO ITS CONSUMERS. I AM ASKING FOR A FULL INVESTIGATION WHICH HOPEFULLY WILL LEAD TO A RECALL OF THE 2006 RAV4'S AND ANY OTHER YEAR THIS AFFECTS. MEGAN, THE ASSISTANT SERVICE MANAGER AT LITHIA TOYOTA CONFIRMED WITH MY INSURANCE ADJUSTER, JOSE LARA (GEICO 707-688-3318) THE COST IS COVERED UNDER THE POWERTRAIN WARRANTY....WHAT ABOUT THE COST OF MY LIFE, AND THE LIVES OF THE OTHER MOTORIST SURROUNDING ME??? THE RISK OF FIRE IS NEVER TO BE TAKEN LIGHTLY. PLEASE INVESTIGATE THIS MATTER TO AVOID ANY COST OF LIFE. *TR

Mileage: 59,177

THIS IS IN REFERENCE TO THE ELECTRICAL PROBLEM REFERENCED RECENTLY. I HAVE HAD THE SAME EXPERIENCE OF THE CAR JUST NOT STARTING. I DISCOVERED THAT IT IS RELATED TO THE STICK SHIFT. IT LOOKS LIKE IT IS ENGAGED. IF YOU GIVE IT THE TINIEST JIGGLE IT ENGAGES AND THE CAR WILL START. I DON'T KNOW WHAT THE DEAL IS, BUT PLANNED TO BRING IT UP WHEN I TAKE CAR TO BE SERVICED NEXT. *TR

TL*THE CONTACT OWNS A 2006 TOYOTA RAV4. ON MARCH 17, 2008, WHILE COASTING INTO A PARKING SPACE WITH HER FOOT ON THE BRAKE, THE ENGINE REVVED AND THE VEHICLE ACCELERATED AT A HIGH RATE OF SPEED AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO WARNING SIGNS PRIOR TO THE FAILURE. THE VEHICLE HAD UNDERGONE REGULARLY SCHEDULED MAINTENANCE BEFORE THE CRASH OCCURRED. THE WEATHER WAS DRY ON THE DAY OF THE CRASH. THE VEHICLE WAS RELEASED BACK TO THE CONTACT; HOWEVER, IT HAD TO BE TAKEN BACK TO THE SHOP DUE TO RIDING ROUGHLY WHEN PLACED INTO OVERDRIVE. THE DEALER STATED THAT THE TORQUE CONVERTER WAS LOCKING EVERYTIME THE TRANSMISSION WAS PLACED INTO OVERDRIVE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES AND THE CONTACT WAS NOT CITED. THE CURRENT MILEAGE IS 17,690 AND FAILURE MILEAGE WAS 17,687. UPDATED 5/13/08 *CN THE DEALER DETERMINED THERE WAS A PROBLEM WITH THE OVERDIRVE. UPDATED

Mileage: 17,687

TL*THE CONTACT OWNS A 2006 TOYOTA RAV4. THE DRIVETRAIN IN THE TRANSMISSION MAKES A WHINING SOUND. THE DEALER REPLACED THE TRANSMISSION. A REGIONAL ENGINEER RECENTLY STATED THAT THE NOISE WAS TYPICAL OF A 2006 RAV4 AND THERE WAS NOTHING TO REPAIR. THE NOISE BEGAN WHILE DRIVING 40 MPH HOUR AND IS CURRENTLY ONGOING WHILE DRIVING BETWEEN 30 TO 55 MPH. THE ENGINEER ALSO STATED THAT THE SOUND OF THE TRANSMISSION IS INHERENT TO THE VEHICLE. THE FAILURE MILEAGE WAS 5,070 AND CURRENT MILEAGE WAS 24,100. UPDATED 04-08-08 *BF UPDATED 04/08/08 *TR

Mileage: 5,070

TWO SEPARATE PROBLEMS: 1) LEFT REAR SUSPENSION, REPORTED TO TWO DEALERS STARTING 8/11/07 FOLLOWED BY THREE OTHER COMPLAINTS, DIAGNOSED AS WORN BUSHING. PARTS ON ORDER; PROBLEM GETTING WORSE. NOTIFIED DEALER THROUGH FACTORY REP; DEALER HAS NOT INDICATED THAT DRIVING VEHICLE IS A SAFETY ISSUE. 2) HESITATION DOWNSHIFTING WHEN DEPRESSING GAS PEDAL. FIRST REPORTED TO TWO DEALERS ON 9/8/07 FOLLOWED BY TWO OTHER COMPLAINTS. INFORMED IT WAS/IS A SOFTWARE PROBLEM CORRECTED AT THE FACTORY, YET PROBLEM PERSISTS. *TR

Mileage: 10,846

PURCHASED RAV IN 1/2006 AND HAVE HAD MANY ACCELERATION ISSUES WITH THIS CAR. FROM A SLOW/START OR STOP/START, I HAVE EXPERIENCED THE CAR HESITATE ON ACCELERATION. THIS OCCURRENCE IS ALL THE TIME, CREATING A VERY UNSAFE SITUATION. HAVE COMPLAINED TO THE DEALER SEVERAL TIMES ABOUT THIS ISSUE AND WAS TOLD THAT IT WAS A SAFETY MECHANISM TO PREVENT "HARD" SHIFTING IN THE TRANSMISSION. THIS SITUATION STILL OCCURS SEVERAL TIMES DAILY. *TR INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

DETAILS: THE VEHICLE HAS FREQUENT PROBLEMS WITH ACCELERATION WHEN COLD. CAR HAS NO POWER WHEN TRYING TO ENTER TRAFFIC. I WILL STEP ON THE GAS, BEGIN MOVING, THEN THE ENGINE WILL BOG DOWN AND I WILL HAVE NO ACCELERATION AT ALL. I HAVE TAKEN THIS UP TO MY DEALER, AND THEIR EXPLANATION IS THAT NOTHING IS WRONG. HOWEVER, THIS PROBLEM CAN OCCUR WHEN EVER IT IS COLD. *JB

Mileage: 5,000

OUR 2006 TOYOTA RAV4 HAS HAD ISSUES ON SEVERAL OCCASIONS OF EITHER HESITATING WHEN THE GAS PEDAL IS PRESSED OR LUNGING FORWARD WHEN TRYING TO SLOW DOWN FOR TRAFFIC OR A STOP LIGHT. WE HAVE MADE SEVERAL COMPLAINTS TO OUR DEALER, BUT THEY KEEP SAYING NOTHING IS WRONG. WE FEEL THIS CAR IS UNSAFE/ RELIABLE AT THIS POINT. *JB

Mileage: 16,000

THROTTLE LAG WHEN REQUESTING IMMEDIATE ACCELERATION FROM EITHER A STOP OR A T LOW SPEEDS.

Mileage: 14,400

TL*- THE CONTACT OWNS A 2006 TOYOTA RAV 4. WHEN STARTING THE VEHICLE THE CVS, ABS, 4 WHEEL DRIVE, AND BRAKE WARNING LIGHTS REMAINED ILLUMINATED ON THE DASHBOARD. THE FAILURE OCCURRED TWICE AND FOR AS LONG AS 1 WEEK. THE DEALER STATED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE, BUT THAT THEY WOULD RESEARCH IT. AS OF THIS DATE THE DEALER HAD NOT INFORMED THE CONTACT OF THEIR FINDINGS. THE FAILURE MILEAGE WAS 17,000, AND THE CURRENT MILEAGE WAS 21,000. *AK

Mileage: 17,000

TL*- THE CONTACT OWNS A 2006 TOYOTA RAV 4. WHEN STARTING THE VEHICLE THE CVS, ABS, 4 WHEEL DRIVE, AND BRAKE WARNING LIGHTS REMAINED ILLUMINATED ON THE DASHBOARD. THE FAILURE OCCURRED TWICE AND FOR AS LONG AS 1 WEEK. THE DEALER STATED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE, BUT THAT THEY WOULD RESEARCH IT. AS OF THIS DATE THE DEALER HAD NOT INFORMED THE CONTACT OF THEIR FINDINGS. THE FAILURE MILEAGE WAS 17,000, AND THE CURRENT MILEAGE WAS 21,000. *AK

Mileage: 17,000

I WAS DRIVING MY 2006 TOYOTA RAV4 WHEN I APPLIED THE BRAKES FROM ABOUT 25 MPH TO STOP FOR TRAFFIC AT A LIGHT. AS I APPLIED THE BRAKE THE ENGINE ACCELERATED AND I HAD TO STAND HARD ON THE BRAKE TO KEEP FROM HITTING THE CAR IN FRONT OF ME. AFTER A FEW SECONDS THE ENGINE SPEED CAME BACK TO NORMAL. AT THAT TIME I DOUBLE CHECKED MY FOOT POSITION ON THE BRAKE PEDAL AND AM CONFIDENT THAT I WAS IN NO WAY CONTACTING THE ACCELERATOR PEDAL. *JB

Mileage: 9,400

I HAVE THE 2006 TOYOTA RAV4 BASE MODEL WITH AN AUTOMATIC TRANSMISSION. I HAVE NOTICED THAT THE TRANSMISSION IS VERY SLUGGISH TO RESPOND TO BRAKING, SUCH THAT THE ENGINE SOMETIMES CONTINUES TO REV FORWARD FOR A SECOND OR TWO EVEN AFTER THE BRAKE PEDAL IS DEPRESSED. THIS LEADS TO EXCESSIVE BRAKING DISTANCES. I BELIEVE THIS PROBLEM IS THE CAUSE OF AN AUTOMOBILE ACCIDENT THAT WE SUFFERED ON 8/5/06. IN DENSE HIGHWAY TRAFFIC, I WAS ABOUT 20 FEET BEHIND AN OLDER TOYOTA PATHFINDER AND HAD JUST ACCELERATED FROM ABOUT 15 MPH TO ABOUT 25 MPH, AS THE DISTANCE BETWEEN THE VEHICLES WAS GROWING. THEN THE PATHFINDER IN FRONT OF ME SUDDENLY SLAMMED ON HIS/HER BRAKES BECAUSE ANOTHER VEHICLE SWERVED DIRECTLY IN FRONT OF IT. I SLAMMED ON MY BRAKES TOO, BUT THE RAV4 DID NOT IMMEDIATELY BEGIN TO SLOW. INSTEAD, I COULD FEEL THE ENGINE STILL PUSHING THE CAR FORWARD. THE RAV4 FINALLY DID BEGIN TO SLOW DOWN RIGHT ABOUT THE SAME TIME THE PATHFINDER CAME TO A COMPLETE STOP. AS A RESULT, WE HIT THE NOW-STATIONARY PATHFINDER IN FRONT OF US AT A SPEED OF ABOUT 5 MPH. FORTUNATELY, NO ONE WAS HURT, BUT THE FRONT END OF THE RAV4 WAS MASHED IN. I HAVE DRIVEN DOZENS OF DIFFERENT VEHICLES OVER NEARLY 20 YEARS OF DRIVING EXPERIENCE, AND I THINK EVERY OTHER ONE WOULD HAVE COME TO A COMPLETE STOP WELL BEFORE THE POINT OF IMPACT (AS DID THE PATHFINDER IN FRONT OF ME, DESPITE A VEHICLE CUTTING DIRECTLY IN FRONT OF IT). THIS LEADS ME TO SUSPECT THERE MUST BE SOMETHING WRONG WITH THE RAV4 TRANSMISSION. THE TRANSMISSION SHOULD IMMEDIATELY DISENGAGE FROM DRIVE WHENEVER THE BRAKE IS DEPRESSED, BUT THERE SEEMS TO BE A DANGEROUS TIME LAG. WHEN I TOOK THE VEHICLE TO THE DEALERSHIP AND EXPLAINED WHAT HAPPENED, THEY ROAD-TESTED AND EXAMINED THE VEHICLE AND SAID NOTHING WAS WRONG. THEY CLAIMED WHAT I EXPERIENCED WAS THE VEHICLE DOWN-SHIFTING, WHICH RESULTS IN HIGHER RPMS BUT LESS FORWARD MOTION. I DON'T BUY IT. I HAVE TRIED JAMMING ON THE BRAKES TO CAUSE SUCH DOWNSHIFTING AND IT DOESN'T HAPPEN. *JB

DT*: THE VEHICLE HAD AN ACCELERATION LAG ISSUE CAUSING THE TRANSMISSION TO NOT SWITCH GEARS IN A TIMELY MANNER. THE SERVICE DEALER COULD NOT DUPLICATE THE PROBLEM.

I HAVE A SERIOUS DELAY IN THE ACCELERATION OF MY 06 TOYOTA RAV4. IT IS DANGEROUS ESPECIALLY WHEN PULLING INTO TRAFFIC. I HAVE GOTTEN NO HELP FROM THE DEALER OR TOYOTA. IT HAPPENS ABOUT 5-10 TIMES PER WEEK. *NM

ON SEVERAL OCCASIONS THERE IS A SEVERE HESITATION WHEN PRESSING ON THE ACCELERATOR. THIS IS MOST NOTABLE WHEN ACCELERATING FROM A STOP OR A NEAR STOP. I THOUGHT IT WAS JUST THE A/C BEING ON OR IN MY HEAD, BUT I HAVE RULED OUT THE A/C, AND SOMETIMES IT WILL WORK WONDERFULLY ONE NIGHT AND THE NEXT MORNING, THE THROTTLE RESPONSE IS VERY SLUGGISH. SOMETIMES SEEMS TO BOG DOWN IF YOU GIVE IT MORE GAS AND THEN YOU HAVE TO EASE WAY BACK ON THE ACCELERATOR PEDAL ONCE IT GETS GOING. *NM

Mileage: 800

MY RAV4 "LAGS" OR "HESITATES" WHEN I TRY TO ACCELERATE IN ORDER TO GET UP TO SPEED-ESPECIALLY WHEN I AM TRYING TO MERGE INTO ONCOMING TRAFFIC. I HAVE BEEN TOLD BY TECHNICIANS THAT OTHERS ARE EXPERIENCING THE SAME PROBLEM AND THAT THERE IS NO "FIX" FOR THIS PROBLEM. *NM

NEW 2006 RAV 4 WAS PURCHASED AT GRAPPONE TOYOTA, CONCORD NH, ON 7-28-06. DURING HE FIRST 600 MILES OF OPERATION PER THE MANUFACTURER. BREAK IN RECOMMENDATIONS IT BECAME APPARENT THAT THE VEHICLE HAD A SERIOUS MALFUNCTION REGARDING NORMAL ACCELERATION AND THROTTLE USE. THIS CONDITION LEADS IN AN INTERMITTENT FASHION TO FAILURE TO ACCELERATE WHEN MERGING ON THE HIGHWAY, FAILURE TO RESUME STEADY THROTTLE SETTING AFTER ROUNDING A CORNER, SUDDEN AND SERIOUS HESITATION WHEN ATTEMPTING TO ACCELERATE NORMALLY AND SUDDEN AND SERIOUS LOSSES OF POWER ON THE ROAD. THESE SYMPTOM ARE ACCOMPANIED BY A FULL TIME THROTTLE LAG, WHICH PREVENTS NORMAL USE OF THE THROTTLE AND OFTEN, AFTER A VARIED PERIOD OF DELAY, IS FOLLOWED BY A SUDDEN DOWNSHIFT AND RUSH OF POWER AND ACCELERATION. I COMPLAINED TO THE DEALER ON 8-22-06 AND WAS DEFERRED UNTIL 8-25-06 AT WHICH TIME THE DEALER CHECKED THE ENGINE COMPUTER AND TOLD ME THAT THE DEGREE OF MALFUNCTIONING IS "NORMAL" AND COULD NOT BE ADDRESSED. I TOLD THEM THAT WAS UNACCEPTABLE AND THAT SINCE THIS UNCERTAIN AND ERRATIC PERFORMANCE COMPROMISED THE SAFETY OF MY WIFE AND MYSELF WE WOULD NOT BE ABLE TO RESUME NORMAL USE OF THE CAR UNTIL THE DEALER OR MANUFACTURER CHOSE TO ADDRESS THE PROBLEM. AFTER 43 YEARS OF SAFE DRIVING, I'M NOT ABOUT TO DRIVE AN UNCONTROLLABLE CAR IN TRAFFIC ON PUBLIC ROADS WHEN IT MAY SUDDENLY FAIL TO ACCELERATE OR FAIL TO RESUME NORMAL SPEED AFTER BRAKING. ANY SUDDEN ERRATIC MOVES CAN BE DANGEROUS TO OURSELVES AND TO SURROUNDING TRAFFIC AND I FIND IT DEEPLY DISTURBING THAT NEITHER TOYOTA NOR GRAPPONE TOYOTA WILL BOTHER TO RETURN MY CALLS NOR ADDRESS THIS MATTER. I HAVE SPOKEN WITH TOYOTA AND THEY HAVE NOT RETURNED MY CALLS, FACILITATED A REPAIR OR EVEN BOTHERED TO TRY TO FIX THE CAR. PLEASE INVESTIGATE THIS SITUATION WHICH I NOW BELIEVE IS COMMON TO ABOUT 10% OF RAV 4S BEFORE IT COSTS SOMEONE THEIR LIFE. THANK YOU. *NM

Mileage: 150

MY 2006 TOYTOA RAV4 HAS DISPLAYED NON RESPONSIVE THROTTLE ON MANY OCCASIONS WHERE YOU GIVE IT GAS AND IT DOES NOTHING, THEN IT TAKES OFF LIKE A ROCKET. I HAVE NEARLY BEEN IN ACCIDENTS BECAUSE I PULL OUT FROM A STOP AND THE THROTTLE IS UNRESPONSIVE WHILE TRAFFIC IS BEARING DOWN ON ME. *JB

Mileage: 500

SERIOUS HESITATION PROBLEM IN MY 2006 TOYOTA RAV4. I'VE REPORTED TO TOYOTA, BUT THEY INDICATE IT'S NORMAL. PROBLEM HAS HAPPENED SERIOUSLY 3-4 TIMES. WHEN SLOWING TO A NEAR STOP OR FROM A STOP, ACCELERATING, I GET NOTHING WHEN I PUSH ON ACCELERATOR. THIS IS BEYOND HESITATION. THE FIRST 2 TIMES I PANICKED SINCE I WAS MERGING IN TRAFFIC, FLOORED THE PEDAL AND AFTER PERHAPS 1/2 TO 1 SECOND (MIGHT NOT SOUND LONG, BUT IMAGINE NO RESPONSE TO PUSHING YOU PEDAL WITH ONCOMING TRAFFIC DOING 60-70)....IT KICKED IN/DOWNSHIFTED OR WHATEVER. REALLY SCARY. AGAIN, I NOTED THIS TO TOYOTA. I NOTED A POST ON EDMUNDS SITE TODAY WITH A 2005 ARTICLE ON PAST HESITATION PROBLEMS WITH TOYOTA/LEXUS. AND OTHER COMPLAINTS AS WELL ON THIS SERIOUS SAFETY ISSUE. I'VE POSTED A DATE OF JUNE 30 FOR INCIDENT, BUT ACTUALLY 3-4 SEPARATE TIMES IN PAST 4 MONTHS. *JB

Mileage: 1,000

HESITATION PROBLEM - '06 RAV4 I4 SPORT MODEL WHEN TRYING TO OVERTAKE, WHEN PRESSING THE PEDAL HARDER, ENGINE DIDN'T RESPOND RIGHT AWAY. *JB

Mileage: 2,312

A 2006 TOYOTA RAV4 V6 LIMITED 4X2. PROBLEM: AUTOMATIC TRANSMISSION DEFECT? SOMETIMES WHEN I STEP ON ACCELERATOR THERE'S LAG TIME BEFORE CAR SHIFTS AND GETS GOING. ALSO THERE'S AN ONGOING (MONTH OR SO) DRONING NOISE. I TOOK CAR TO TOYOTA DEALER 6/15/06. SERVICE WRITER AND 2 TECHS HEARD DRONING NOISE WHILE I WAS THERE. WITH THE CAR. I ASKED TO BRING THE CAR IN THE FOLLOWING SATURDAY AS I WORK DURING THE WEEK, BUT THEY SAID SATURDAYS NOT GOOD SO I MADE APPOINTMENT FOR 6/26/06. THEY TOLD ME IT WASN'T DANGEROUS TO DRIVE THE CAR. I TOOK CAR IN 6/26/06 & RODE WITH MASTER TECH WHO WAS ABLE TO HEAR THE DRONING NOISE. HE DROVE CAR, ALSO SAT IN PARKING LOT WITH ENGINE RUNNING AND SHIFTED INTO PARK AND INTO REVERSE ETC. WITH HIS FOOT ON THE BRAKE AND NOISE CHANGED IN INTENSITY IN DIFFERENT GEARS. HE TOOK CAR BACK TO SERVICE CENTER AND CHECKED IT OUT. THE SERVICE WRITER SAID THE TECH NOT ABLE TO PINPOINT PROBLEM, BUT TECH WOULD CALL TOYOTA ENGINEERING THE NEXT MORNING BECAUSE HE DIDN'T WANT TO TRY A FIX WHEN HE DIDN'T KNOW WHAT THE PROBLEM WAS. THEY GAVE ME MY CAR BACK, SAID THEY'D CALL ME AFTER TALKING TO TOYOTA ENGINEERING. THEY CALLED ME 6/27/06, SAID MASTER TECH HAD TALKED TO TOYOTA ENGINEERING AND THEY'VE HAD OTHER COMPLAINTS RE SAME DRONING NOISE, ARE WORKING TO FIND CAUSE SO THEY CAN CREATE A TSB AND EITHER REDUCE OR ELIMINATE THE NOISE. SERVICE WRITER TOLD ME T THERE IS NO TIMELINE FOR A FIX AND TO JUST "SIT TIGHT" AND WAIT UNTIL THEY CALL. THEY AGREE THE NOISE SHOULD NOT BE THERE. I'M WORRIED THAT ONGOING NOISE INDICATES THAT SOME PART IS OVERWORKING AND MAY WEAR OUT AND SINCE THE NOISE CHANGES IN INTENSITY SOMETIMES DEPENDING WHAT GEAR THE CAR IS IN I WORRY THAT IT IS THE TRANSMISSION AND THAT A FAILURE MAY RESULT. I DON'T UNDERSTAND HOW THEY CAN TELL ME THE VEHICLE IS SAFE TO DRIVE WHEN THEY CLAIM THEY DON'T KNOW WHAT THE PROBLEM IS. IT IS VERY UNSETTLING TO HAVE TO JUST WAIT FOR WHO KNOWS HOW LONG FOR THEM TO FIX THE PROBLEM. *NM

Mileage: 2,400

I HAVE A NEW 2006 TOYOTA RAV4 WITH AUTOMATIC TRANSMISSION AND, IN THE FIRST 2000 MILES, IT HAS FAILED TO SHIFT CORRECTLY ON 3 SEPARATE OCCASIONS. THIS HAS CREATED DANGEROUS SITUATIONS WHEN MERGING IN TRAFFIC. SPECIFICALLY, WHEN I STEP ON THE GAS PEDAL, THE RPMS SHOOT ABOVE 4-5K BUT THERE IS NO ACCOMPANIED INCREASE IN SPEED. GIVEN THE REPEATED POSTINGS ON EDMUNDS.COM ABOUT THESE PROBLEMS, IT DOES NOT APPEAR TO BE AN ISOLATED CASE WITH MY VEHICLE. *JB

Mileage: 1,900

I HAVE A BRAND NEW 2006 TOYOTA RAV4 V6 SPORT 4WD AND WITHIN 4 DAYS OF COLLECTION, THE REAR LEFT WHEEL WAS IN THE PROCESS OF FALLING OFF. WHILE THIS PROBABLY SOUNDS DRAMATIC AND AN EXAGGERATION, IT IS NOT. WITH 144 MILES ON THE ODOMETER, I TOOK IT BACK TO THE DEALER TO HAVE THE SOURCE OF A SQUEALING SOUND LOOKED AT. THE SOUND BEGAN AROUND 50 MILES AS A VERY FAINT, BRIEF NOISE AND GRADUALLY GOT WORSE UNTIL AT 144 MILES I WAS AT THE DEALER. ON THE SHOP LIFT, IT WAS APPARENT THE NOISE WAS THE WHEEL BEARING/HUB ASSEMBLY COMING APART. THE LUG NUTS WERE TIGHT AND THE WHEEL WAS LOOSE - VERY LOOSE. I AM THANKFUL I DID NO HIGHWAY DRIVING IN THOSE 144 MILES. THE TECHNICIAN SAID THE WHEEL WOULD HAVE FALLEN OFF. TOYOTA HAVE SINCE REPLACED THE PARTS UNDER WARRANTY BUT I AM VERY UNHAPPY WITH THEM AND HOW THEY DEALT WITH THE WHOLE POTENTIALLY FATAL SITUATION. I HAVE VIDEO OF THE LOOSE WHEEL IN THE SHOP THAT I WOULD BE HAPPY TO SHARE WITH YOU. *JB

Mileage: 144