2007 TOYOTA RAV4 Electrical System Problems

My driver side door caught on fire and was completely destroyed to include all associated wiring. Toyota had my contact information but never contacted me about any of the recalls.

The contact owns a 2007 Toyota Rav4. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. There was no warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to an independent mechanic where it was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The vehicle was repaired; however, the failure recurred. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was not available.

I own a 2007 Toyota Rav-4 with 155k miles. I had bought the vehicle used from a licensed Toyota dealership about 3 years ago and have been diligent about conducting the routine scheduled maintenance. The vehicle had no known recalls. I was driving about 25mph when I started to smell smoke. The drivers side door caught on fire while the vehicle was in motion. There were literally flames coming out of area with the buttons used to control the windows. I immediately pulled the vehicle over and the car ended up having to be towed. On Google, Toyota has had several other incidents where this exact same recall issue happened and the vehicle caught on fire. I called the dealership where I purchased the vehicle and the Toyota Corporate as well. I smoke to a representative on a Wednesday and they let me know my case number and that someone would be in touch to follow-up within 48 hours. However, it has been 6 days and I haven’t received any update.

I was driving and the engine caught on fire. Thank God for people telling me that my car was having flames coming from under my car. By the time I pull over flames were coming out of my hood

while driving down the big bear mountain, the vehicle lost power steering i could not turn the wheel and hit the railing, thank god i didn't hit another car. The battery light was flashing steering locked up other dash lights came on. The mechanic could not give me any answers, Toyota says there is no recall on this and after reading other complaints about the 2007 Toyota RAV 4 i am shocked that the dealership has nothing to say and can not fix the problem, this is so dangerous and i am at a loss on how to fix the problem. who has to die for them to take this problem seriously!!!

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE CONSUMED AN EXCESSIVE AMOUNT OF OIL. THE CONTACT ADDED ADDITIONAL OIL AND THE ENGINE WAS COLD. IN ADDITION, THE CHECK ENGINE, SLIP TRACTION CONTROL, AND 4WD WARNING INDICATORS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO BREWER AIRPORT TOYOTA (8900 UNIVERSITY BLVD, MOON, PA 15108, (412) 357-5503), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: [XXX]. THE FAILURE MILEAGE WAS 115,000 *BF *JS PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Mileage: 115,000

POWER SWITCH CONTROL ON DOOR PANEL WAS ON SMOKE AND MELTED . IT WAS INTOXICATING AND SCARY. WHY DD IT HAPPEN? VERY DANGEROUS. IS THERE A RECALL FOR THIS ? I WAS DRIVING WHEN IT HAPPENED.

WHETHER I'M DRIVING OR PARKED WITH THE ENGINE RUNNING, THE CAR SHUTS DOWN COMPLETELY. I CANT TURN ON THE HAZARD LIGHTS OR ROLL DOWN THE POWER WINDOWS. I HAVE NO LIGHTS WHATSOEVER, SO NO ONE CAN SEE ME AT NIGHT. I HAD THE CAR TOWED TO THE DEALERSHIP AFTER A BUS ALMOST REAR-ENDED ME. PREVIOUSLY THEY REPLACED THE ALTERNATOR. THAT DID NOT FIX THE PROBLEM. THEY CANNOT FIX MY CAR.

Mileage: 107,000

I WAS TRAVELING DOWN ARROW HWY IN THE RAIN WHEN MY ELECTRICAL SYSTEM FAILED. I LOST POWER FROM BOTH MY ALTERNATOR AND BATTERY INTERMITTENTLY. I WAS COASTING DOWN TO AN APPROACHING INTERSECTION WHEN I MADE THE DESCISION TO TURN RIGHT AT THE INTERSECTION. THE STEERING WAS SO HARD THAT I NEARING HIT THE CENTER DIVIDE. MY WINDSHIELD WIPERS WERE BARELY WORKING AND MANY OF MY DASH ICONS WERE COMING ON RANDOMLY. THROUGH IT ALL, MY ENGINE CONTINUED TO RUN AND I MADE TO THE NEXT STREET THAT TURNED INTO CONDOS THAT HAD PARKING SPACES. I SHUT MY ENGINE OFF AND TRIED A RESTART. THE ENGINE,OF COURSE,DID NOT START. AFTER BEING HAULED TO THE NEAREST TOYOTA DEALER THEY DIAGNOSED THE PROBLEM AS AN ALTERNATOR THAT SHORTED THE BATTERY. HAVING A LITTLE EXPERIENCE IN THIS ELECTRICAL AREA, I UNDERSTAND HOW THIS CAN HAPPEN BUT WITH PROPER DESIGN IT COULD HAVE BEEN AVOIDED. THE BATTERY WAS SAVED AFTER RECHARGING. HERE IS MY POINT; I DON'T WANT ANY ONE THAT I KNOW AND LOVE TO GO THROUGH WHAT I HAD TO. THOSE THAT DRIVE THIS CAR SHOULD BE MADE AWARE THAT THIS COULD HAPPEN WITH A CAR EQUIPPED WITH ELECTRICAL STEERING. THIS PROBLEM COULD HAVE BEEN MORE SEVERE IF THE ENGINE WOULD HAVE STALLED; WHICH, BY THE WAY WOULD HAVE HAPPENED IN A SHORT TIME.

Mileage: 110,000

ALTERNATOR FAILS AT 45000

Mileage: 45,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT OBSERVED WATER IN HER VEHICLE ON THE FRONT PASSENGER FLOOR WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO A LOCAL DEALER (A1 TOYOTA, 50 AMITY RD, NEW HAVEN, CT, 06515, 203-389-1521) WHERE IT WAS DIAGNOSED THAT THE AIR CONDITIONING CABINET FILTER AND DRAIN HOSE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE BACK TO THE SAME DEALER WHERE IT WAS DIAGNOSED THAT THE WINDOW COWL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,663.

Mileage: 89,663

MY VEHICLE WAS PARKED IN A PARKING LOT BUT WHEN I WANTED TO OPEN THE DOOR, THE FOB WOULDN'T WORK. THE BATTERY HAD BEEN DEPLETED AND WHEN I REPLACED THE BATTERY, BY AAA, THE DASHBOARD LIGHTS STAYED ON EVEN AFTER I TOOK OUT THE KEYS FROM THE IGNITION. THIS CAN CAUSE THE BATTERY TO DIE AGAIN. I HAVE TO DISCONNECT THE BATTERY SO THAT THE LIGHT THAT STAYS ON WILL NOT DEPLETE THE BATTERY. THE CAR SHAKES BECAUSE THE POWER ISN'T GETTING TO THE RECEIVER VERY WELL. THIS IS A PROBLEM INSIDE THE ELECTRIC HUB. AT ANY MOMENT MY CAR CAN SHUT OFF BECAUSE THE ELECTRIC CURRENT ISN'T STABLE WHEN THE CAR IS ON. ONE OF THE FUSES OR SOMETHING ISN'T DISCONNECTING PROPERLY, CAUSING THE DASHBOARD LIGHTS TO STAY ON.

DROVE FOR OVER AN HOUR IN DRY, STABLE WEATHER CONDITIONS. UPON SLOWING TO MAKE A LEFT TURN INTO A PARKING GARAGE ON SURFACE STREETS THE STEERING COMPLETELY STALLED WITH MULTIPLE ALARM LIGHTS FLASHING, INCLUDING BATTERY. VEHICLE WAS STILL ON AND ABLE TO DRIVE BUT WITH VERY POOR ACCELERATION. THIS CAUSED ME TO BLOCK TRAFFIC ONCOMING TRAFFIC FOR OVER 10 MINUTES AS I LABORED (WITH A LOT OF STRENGTH) WITH THE STALLED POWER STEERING BACK AND FORTH UNTIL INLINE WITH THE GARAGE. CALLED TRIPLE A IMMEDIATELY AND HAD BATTERY CHANGED. DESPITE THE CAR WORKING AGAIN WITH STABLE STEERING, STILL CONCERNED ABOUT STALLING AGAIN, PARTICULARLY IN CITY STREETS (INCLUDING THE SF HILLS) AND FREEWAYS. THERE NEEDS TO BE SOME FIX FOR POWER-STEERING BEING THE FIRST THING TO FAIL WITH THE BATTERY/ALTERNATORS.

Mileage: 92,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING AT UNKNOWN SPEEDS, THE BATTERY LIGHT ILLUMINATED AND THE POWER STEERING MALFUNCTIONED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ALTERNATOR AND BATTERY NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 88,000.

Mileage: 88,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE SUDDENLY STOPPED AND SMOKE AND FLAMES WERE PRESENT BEHIND THE STEERING WHEEL. THE CONTACT USED WATER TO EXTINGUISH THE FLAMES. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 90,000.

Mileage: 90,000

DRIVING ON THE HIGHWAY GOING ABOUT 75MPH AFTER ABOUT 5 HOURS WHEN A BUNCH OF WARNING LIGHTS CAME ON (INCLUDING BATTERY, AIR BAG, AND BRAKE), MY POWER STEERING FAILED AND MY SPEEDOMETER QUIT WORKING. PULLED OVER ON THE SIDE OF THE HIGHWAY AND LET MY CAR SIT FOR A MINUTE, RESTARTED MY CAR AND THREE DIFFERENT LIGHTS CAME ON (VSC, CHECK ENGINE AND SLIP INDICATOR) AND MY CRUISE CONTROL WOULDN'T WORK ANYMORE. MY CAR CURRENTLY HAS ABOUT 110,000 MILES. THIS IS NOT A WEAR AND TEAR ISSUE; THIS IS A DEFECT. FROM READING ONLINE, THERE ARE MANY COMPLAINTS OF THE SAME ISSUE. THIS COULD BE A FATAL DEFECT AND SHOULD BE TAKEN SERIOUSLY. THIS IS THE SECOND TIME MY POWER STEERING HAS FAILED WHILE DRIVING.

Mileage: 110,000

WHILE DRIVING THE CAR SUDDENLY LOSES ALL ELECTRICITY, ALL THE LIGHTS, EVERY LIGHT INDICATOR, THE RADIO ARE OFF. THE ENGINE STOPS RUNNING AND THE CAR STOPS IMMEDIATELY. THIS NORMALLY HAPPENS WHILE DRIVING ON CITY STREETS BUT ALSO HAPPENED ONCE WHEN THE CAR WAS PARKED AND THE KEY WAS OUT. AFTER I ENTERED AND TURNED THE KEY THE CAR WOULDN'T START AND THERE WAS NO ELECTRICITY IN THE CAR. NO LIGHTS, NO INDICATORS, ETC WERE ON. TOOK IT TO THE MECHANIC TO TAKE A LOOK BUT HE COULDN'T FIND ANYTHING. ALSO TOOK IT TO TOYOTA DEALERSHIP AND THE TECHNICIAN INSPECTED IT AND RAN A DIAGNOSTICS TEST BUT COULDN'T FIND THE PROBLEM EITHER.

Mileage: 75,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING AT VARIOUS SPEEDS AND ATTEMPTING TO MAKE A TURN, THE POWER STEERING SEIZED AND SEVERAL WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BATTERY AND SENSORS WERE CHANGED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 79,800.

Mileage: 79,800

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN AT APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT MENTIONED THAT ON SEVERAL OTHER OCCASIONS, THE FAILURE RECURRED WHEN THE RADIO OR TURN SIGNAL WAS ACTIVATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 111,000. THE VIN WAS NOT AVAILABLE.

Mileage: 111,000

DRIVING 55 MPG AROUND CURVE IN HEAVY TRAFFIC STEERING LOCKED UP HARDLY ABLE TO PULL.OFF SIDE OF ROAD. HAPPENED AGAIN TODAY JULY 25 2015 GOING 60 DOWN BUSY HEY RUSH HOUR TRAFFIC AND STEERING FROZE HAD TO GET OF TO THE SIDE AND RESTART THEN IT WAS ABLE TO STEER BUT BATTERY.LIGHT FLICKERS HA D BATTERY LREPLACED DAY BEFORE.

Mileage: 90,300

THE CAR FAILED TO START, THE BATTERY WAS EXTREMELY HOT AND HAD NOT WATER IN IT. CHANGED THE BATTERY, THE CAR STARTED PROPERLY; HOWEVER, ONCE SET TO DRIVE IT HESITATED A BIT, AS IF IT WERE CHOCKING FOR LACK OF GAS BUT IT HAD GAS. DROVE ON AND AT ABOUT SPEED OF 40 MPH STEERING BECAME HARD TO HANDLE, AC AND ENGINE CUT OFF. RESTARTED IT DROVE BACK HOME... JUST MADE THE LAST PAYMENT ON THE CAR, CAR WAS REGULARLY SERVICED AT THE DEALER.

Mileage: 128,910

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT IT HAD OIL CONSUMPTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.

Mileage: 123,000

2007 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO THE POWER WINDOW MASTER SWITCH ASSEMBLY RECALL NOTICE ISSUES. *SMD THE CONSUMER STATED THE WINDOW WOULD ROLL UP. *JB

OCCUPANT CLASSIFICATION SYSTEM MALFUNCTION (ECU). TOYOTA IS REFUSING TO COVER THE REPAIR SINCE THE VEHICLE IS NO LONGER UNDER WARRANTY. WAS ADVISED AT THE DEALERSHIP (KENDALL TOYOTA) THAT THIS MALFUNCTION WILL PREVENT THE PASSENGER AIRBAG FROM DEPLOYMENT IN EVENT OF AN ACCIDENT. THE SYSTEM MALFUNCTION IS NOT SPECIFICALLY A WEAR N TEAR ITEM AND I FIRMLY BELIEVE IT SHOULD BE COVERED BY TOYOTA. RAV 4 HAS HAD MULTIPLE RECALLS BUT NONE FOR THIS PROBLEM. *TR

Mileage: 88,584

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, ALL OF THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT THE CRUISE CONTROL FAILED TO ACTIVATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 51,000.

Mileage: 51,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE REVERSING AT 5 MPH, THE AIR BAG, POWER STEERING, AND BRAKE LIGHT ILLUMINATED AND REMAINED ILLUMINATED. THE TACHOMETER DID NOT INDICATE THE RPM. THE SPEEDOMETER AND ENGINE TEMPERATURE GAUGE WERE INOPERABLE. ALSO, THE GEAR SHIFTER FAILED TO INDICATE WHAT GEAR WAS IN SHIFT. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,526.

Mileage: 45,526

ALL DASH LIGHTS TURNED ON AND STEERING WHEEL WAS HARD TO TURN. DROVE HOME. RESTART THE VEHICLE, NO ISSUES, LEFT IT RUNNING, IT HAPPENED AGAIN AND SMELLED A BURNING SMELL. HAD IT TOWED TO TOYOTA DEALERSHIP. THEY REPLACED BATTERY. YESTERDAY 11-18-14, SAME ISSUE GOING ABOUT 40 MPH. HAD IT TOWED TO SAME DEALERSHIP. ALTERNATOR NEEDS TO BE REPLACED. TOYOTA ALSO INFORMED THAT WATER PUMP IS FAILING. THROUGH INTERNET RESEARCH, THESE ARE EXTREMELY COMMON ISSUES THAT SHOULD BE RESOLVED BY TOYOTA AND PEOPLE SHOULD BE REIMBURSED FOR SUCH AN EXTENSIVE PROBLEM. *TR

Mileage: 106,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING 40 MPH, THE OIL WARNING INDICATOR FAILED TO ILLUMINATE WITHIN A REASONABLE AMOUNT OF TIME WHEN THE ENGINE OIL LEVEL WAS LOW. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 46,925.

Mileage: 46,925

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. WHILE DRIVING 65 MPH, THE BATTERY WARNING INDICATOR ILLUMINATED, THE STEERING WHEEL SEIZED, AND THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

ON 08/09/14 WE WERE DRIVING IN PARKING LOT WITH 5 PEOPLE IN CAR. STARTED DRIVING AND ENGINE SUDDENLY STOPPED. CAR GLIDED TO A STOP WITH GEARS AND STEERING WHEEL LOCKED. CAR WOULD NOT RESTART. CALLED AAA FOR A TOW 20+ MILES AWAY TO CLOSEST TOYOTA DEALERSHIP AND THEN GOT TRANSPORT FOR OURSELVES TO HOTEL FOR THE NIGHT. NEXT MORNING GOT RENTAL CAR TO DRIVE TO TOYOTA DEALER WHERE CAR HAD BEEN TOWED TO. REPAIR WAS SIMPLY A BLOWN FUSE FOR VEHICLE REMOTE STARTER WHICH WAS ODDLY LOCATED UNDER STEERING WHEEL. SIMILAR INCIDENT HAPPENED (03/12/08) WHILE DIVING IN CANADA AND REPAIRED THEN AT A TOYOTA DEALER AT 12,101 KM. THE REMOTE STARTER WAS PART OF ORIGINAL EQUIPMENT ON THE NEW CAR. NOW, WE FEAR DRIVING RAV4 ON HIGHWAY AT ANY SPEED FOR FEAR CAR WILL SUDDENLY STOP AND STEERING WILL LOCK UP. REMOTE STARTER NEEDS TO BE REMOVED OR FIXED AT IT IS NOT SAFE. *TR

Mileage: 80,450

WELL-MAINTAINED 2007 RAV4 (67K MILES, NO ISSUES IN THE PAST) STALLED COMPLETELY WHILE DRIVING 50 MPH. NEARLY GOT REAR ENDED AS HAZARD FLASHER LIGHTS DID NOT WORK AT ALL. ALL POWER CUTS OFF TO INSIDE OF CAR. ONCE FAN IN ENGINE TURNS OFF (ABOUT 6 MINUTES) CAR CAN START AGAIN. DEALERSHIP SAID "DIRTY THROTTLE BODY PART" SO THEY CLEANED IT. HAPPENED 2ND TIME THE NEXT WEEK! THEN DEALERSHIP REPLACED ENTIRE THROTTLE BODY ASSEMBLY. HAPPENED 3RD TIME THE FOLLOWING WEEK! IT'S AT DEALERSHIP AGAIN NOW. EACH TIME IT HAPPENS, CAR IS DRIVING AND ONCE ABOUT 6 MINUTES PASSES, I CAN DRIVE AGAIN. BARELY HAVE TIME TO GET NEAR THE SHOULDER OF ROAD. *TT

Mileage: 67,800

ON MARCH 21ST THE ABS, VSC, TRACTION AND BRAKE WARNING LIGHTS CAME ON WHILE DRIVING AT 35 MPH IN DRY WEATHER CONDITION. WHEN THE LIGHTS WERE ON, THE ABS SYSTEM WAS TRIGGERED MAKING DIFFICULT TO BRAKE TO STOP. SINCE THEN THE WARNING LIGHTS HAVE BEEN ON AND OFF AND SO I'VE BEEN HAVING DIFFICULTIES WHEN SLOWING DOWN AT A HIGHER SPEED RATE 60 MPH, SLOW SPEED 20 MPH, AND EVEN STOPPING. ON TUESDAY, APRIL 8 I BROUGHT THE RAV4 TO THE DEALER AND THEY SAID THAT THERE IS NOTHING WRONG WITH THE CAR AND THAT THE BREAKS WERE OK. DEALER SAID: IT IS JUST THE A REAR SENSOR THAT NEEDS TO BE RESET. SO DEALER TECHNICIAN RESET THE SENSOR THE SAME DAY. ON WEDNESDAY, APRIL 9, 2014 AROUND 6:00 PM WHEN TURNING LEFT AT A CORNER I HEARD A TICKING NOISE THEN FOUR WARNING LIGHTS APPEARED AGAIN AND THE BREAKS STARTED TO MALFUNCTION AGAIN. I'LL BRING THE RAV4 TO THE DEALER ON APRIL 12, 2014 AND SEE WHAT THEY HAVE TO SAY. THE CODES THE DEALER HAVE INITIALLY WERE C0210 AND C1223. MY SPOUSE AND I DON'T WANT TO DRIVE THE RAV4 WITHOUT KNOWING THAT THE SENSOR THAT THE DEALER TALKS ABOUT IS EITHER FIXED OR REPLACED. I DON'T WANT TO BE EXPOSED NOR EXPOSE MY FAMILY TO ANY POSSIBLE ACCIDENT DUE TO THE SENSOR/BRAKING SYSTEM FAILURE. *TR

Mileage: 50,000

TOOK VEHICLE IN FOR DIAGNOSTICS AS SEVERAL LIGHTS WERE ON. WAS CALLED BY SERVICE ADVISOR THAT THE D SQUIB CIRCUIT/SPIRAL CABLE IS FAULTY AND THEREFORE THE AIR BAG SYSTEM IS NOT OPERATIONAL. THIS IS A HUGE SAFETY ISSUE AS I WAS UNAWARE OF MY AIRBAGS NOT FUNCTIONING. THANK GOD, WE DID NOT GET INTO AN ACCIDENT! THE TOYOTA DEALER WHOM WE PURCHASED OUR 2007 RAV 4 FROM BRAND NEW OF COURSE WANTS TO REPAIR IT FOR APPROX. $500.00. THAT IS INSANE AS THIS ISSUE SHOULD NEVER OCCUR. AFTER READING MANY POSTINGS ON THE INTERNET, OBVIOUSLY THIS IS A KNOWN ISSUE AND CLEARLY THERE SHOULD BE A RECALL TO FIX THIS. *TR

Mileage: 119,816

2007 TOYOTA RAV 4. CONSUMER WRITES IN REGARDS TO VEHICLE WATER PUMP FAILURE. *SMD THE #6 IGNITION COIL WAS REPLACED, AS IT WAS SHORTING OUT AND THE STEERING WHEEL MADE AN UNUSUAL NOISE, WHEN IT WAS TURNED.*JB

A R E CALL NOW ON THE CLOCK SPRING STOP ACTING STUPID'S. *TR

UPON STARTING THE VEHICLE I NOTICED THAT ON THE INSTRUMENT PANEL THE AIRBAG LIGHT WAS ILLUMINATED. THIS INDICATED THAT THERE WAS A PROBLEM WITH THE SAFETY SYSTEM WHICH ALLOWS THE AIRBAG TO INFLATE DURING A FRONTAL OR SIDE IMPACT CRASH. I SCHEDULED AN APPOINTMENT WITH THE LOCAL TOYOTA DEALERSHIP FOR FURTHER INVESTIGATION. ON THE DAY OF THE APPOINTMENT I WAS INFORMED THAT THERE WAS A MALFUNCTION IN THE SPIRAL CLOCK CABLE WHICH RESIDES UNDER THE STEERING WHEEL AND IS AN INTRICATE PART OF THE SAFETY, DRIVER SIDE AND OTHER AIRBAGS WITHIN THE VEHICLE. IF THIS PART WAS NOT REPLACED THEN I COULD BE FATALLY HURT OR KILLED IF THE AIRBAG WOULD NOT DEPLOY. I WAS ALSO INFORMED THAT TOYOTA HAD DONE A RECALL ON THIS EXACT PART BUT ONLY ON THE TOYOTA TACOMA, THIS EFFECTED OVER 700,000 VEHICLES RECALLED FOR THIS SAME PROBLEM. I CONTACTED TOYOTA IMMEDIATELY AFTER HAVING THE REPAIRS DONE TO MY VEHICLE. I RECEIVED A MESSAGE BACK FROM THEM STATING THAT THEY WOULD REIMBURSE ME FOR THE PART PLUS THE TAX BUT NOT FOR THE LABOR CHARGES, THEY CLAIM THAT THE LABOR CHARGES WOULD NOT BE REIMBURSED DUE TO THE NUMBER OF MILES ON MY VEHICLE, BUT IF THEY HAD INCLUDED THE RAV4S IN THE RECALL THE LABOR CHARGES WOULD HAVE BEEN INCLUDED. I HAVE HAD MORE THAN 4 RECALLS ON MY VEHICLE DONE IN JUST THE PAST COUPLE OF MONTHS. ALTHOUGH I AM GRATEFUL THAT I AM RECEIVING THE REIMBURSEMENT FOR THE PART AND TAX I THINK THAT THE LABOR SHOULD BE INCLUDED, DUE TO THE FACT THAT THE PART WAS A MAJOR RECALL ON OTHER MODELS. *TR

Mileage: 130,000

MY 8 MONTH OLD BABY WAS AUTO- LOCKED IN THE CAR ON AN 80 DEGREE SUNNY DAY! I DOUBLE CLICKED THE UNLOCK BUTTON ON MY CAR'S KEY FOB ON APPROACH, OPENED THE REAR PASSENGER SIDE DOOR AND PUT MY CHILD IN THE CAR SEAT AND PUT MY PURSE (KEYS ON TOP) IN THE FLOOR WITH THE DIAPER BAG. ENTIRE CAR STILL UNLOCKED, I CLOSED THE REAR PASSENGER DOOR AND WALKED AROUND TO THE DRIVER'S SIDE TO GET IN. THE CAR BEEPED ALOUD BEFORE I COULD GRAB THE DOOR HANDLE TO GET IN, LOCKING ALL DOORS OF THE VEHICLE. LUCKILY THERE WAS A MECHANIC ON THE SAME STREET I WAS ON, BUT IT STILL TOOK 15 MINUTES START TO FINISH TO FINALLY GET MY CHILD OUT. UPON READING THE OWNER'S MANUAL, IT STATED THAT THERE IS A 30 SECOND TIMER FOR THE AUTOLOCK FEATURE THAT AUTOMATICALLY LOCKS THE ENTIRE VEHICLE IF A DOOR IS NOT OPENED IN THAT TIME AFTER BEING UNLOCKED. I HAD, HOWEVER, OPENED THE REAR DOOR TO PLACE THE CHILD IN HIS SEAT. THERE IS NO WAY THIS COULD HAVE BEEN AN ERROR ON MY PART AS I WAS NOT ONLY OUTSIDE THE VEHICLE WHEN IT LOCKED ITSELF, BUT THERE ARE NO LOCK/UNLOCK BUTTONS IN THE CAR EXCEPT ON THE DRIVER'S SIDE WHICH I HAD YET TO ENTER. SO I COULD NOT HAVE EVEN HIT ONE BY ACCIDENT. *TR

Mileage: 115,251

MY 2007 TOYOTA RAV4 WAS BEING DRIVEN BY MY WIFE AND SHE NOTICED INDICATOR LIGHTS SUDDENLY COMING ON THE DASHBOARD AND THE VEHICLE SPUTTERING AND STARTING TO STALL. PRIOR TO THE VEHICLE STALLING, SHE NOTICED THE POWER STEERING INOPERABLE AND SHE WAS HAVING DIFFICULTY STEERING TO BRING THE VEHICLE TO THE SHOULDER LANE AND TO A STOP. SHE CALLED ME AND I CALLED FOR EMERGENCY ROADSIDE ASSISTANCE. THE VEHICLE WAS RESTARTED. AT THIS TIME, AS THE ENGINE RAN, THE POWER STEERING WAS STILL INOPERABLE AND THE VEHICLE WAS UNDRIVABLE. IT WAS THEN TOWED HOME. MY MECHANIC CHECKED AND FOUND THE BATTERY TO BE UNDERCHARGED DUE TO A DEFECTIVE ALTERNATOR NOT PROPERLY CHARGING THE BATTERY. THE BATTERY AND THE ALTERNATOR WAS REPLACED AND THE POWER STEERING AND ALL OTHER FUNCTIONS RESUMED BACK TO NORMAL. MY SAFETY CONCERN IS THAT THE POWER STEERING UNIT SHOULD NOT HAVE STOPPED FUNCTIONING AS LONG AS THE ENGINE WAS IN OPERATION. IF THE BRAKING SYSTEM CONTINUED TO OPERATE NORMALLY AS THE ENGINE RAN, THE POWER STEERING UNIT SHOULD ALSO CONTINUE TO OPERATE SO THAT THE DRIVER CAN STAY IN COMPLETE CONTROL OF THE VEHICLE. IF MY WIFE WAS TRAVELING AT A HIGHER RATE OF SPEED AND ON A BUSY INTERSTATE FREEWAY, THE OUTCOME COULD HAVE BEEN DISASTROUS. PLEASE LOOK INTO GETTING TOYOTA TO RECALL AND CORRECTING THIS SAFETY ISSUE ON MINE AND OTHER 2007 RAV4S. THANK YOU FOR YOUR ASSISTANCE. A REPLY WOULD BE GREATLY APPRECIATED. *TR

Mileage: 49,889

MY AIRBAG LIGHT WAS ON. WHEN I TOOK MY CAR IN FOR THE ANNUAL STATE INSPECTION, I WAS INFORMED THAT I WOULD HAVE TO REPLACE THE SPIRAL CABLE FOR AIRBAG LIGHT THAT HAD SHORTED OUT. THE ASSEMBLY WAS REPLACED AT A TOTAL COST OF $442.01. THIS VEHICLE HAS HAD AN EARLIER RECALL FOR AN AIRBAG SENSOR AND I FEEL THAT THIS SHOULD BE A SAFETY RECALL ISSUE AS WELL AND NOT THE FINANCIAL RESPONSIBILITY OF THE CAR OWNER. *TR

Mileage: 154,402

WITH NO WARNING, THE THREE LIGHTS CAME ON: 4WD, VSC, ENGINE. NOW THE DEALER TELLS ME THAT COIL #5 FAILED AND NEEDS TO BE REPLACED FOR A STAGGERING $350 PARTS AND LABOR. AMAZING, BECAUSE THE PART COSTS ONLY $40, WHAT IS THERE WORTH LABOR FOR $310? I RESEARCHED THIS ISSUE AND IT TURNS OUT THAT THIS IS A VERY COMMON ISSUE WITH THESE TOYOTA RAV4 CARS. I FIXED IT AND TWO WEEKS LATER, COIL #4 FAILED, THIS ONE FOR ANOTHER $350! WHAT IS GOING ON WITH THIS CAR. IT IS A BIG PROBLEM WITH COILS FAILING.

Mileage: 98,000

I WAS DRIVING DOWN FOREST AVE IN BROCKTON, MA, THE DRIVER SIDE DOOR STATED SMOKING, I QUICKLY TURNED THE ENGINE OFF, GOT ME AND MY SON OUT OF THE CAR AND CALLED THE FIRE DEPARTMENT WHO DISCONNECTED THE BATTERY AND SUGGESTED THAT I GOT IT TOWED TO A REPAIR SHOP. SO I DID, TO COPLAND TOYOYTA WHERE IT WAS TROUBLESHOOT TO A MASTER SWITCH ASS. IT WAS REPAIRED AND I HAD TO PAY $580.70 BECAUSE THEY SAID ITS NOT COVERED BY WARRANTY. *TR

Mileage: 85,000

TRAVELING APPROXIMATELY 45 MPH ON DRY PAVEMENT. WENT TO APPLY BRAKES PRIOR TO APPROACHING TURN LANE AND COULD NOT STOP. BRAKES WERE THERE (PEDAL WAS FIRM AND DID NOT GO TO FLOOR) BUT ACCELERATOR SEEM TO OVERRIDE THE BRAKING SYSTEM. PROCEEDED TO STAND ON BRAKES TO ATTEMPT TO STOP AS THERE WERE THREE LANES OF STOPPED TRAFFIC AND NO WHERE ELSE TO GO. SHIFTED CAR INTO PARK TO COME TO AN ABRUPT STOP TO AVOID HITTING 8+ CARS AND PUSHING THEM INTO A VERY LARGE INTERSECTION. CAR HAD APPROXIMATELY 46000 MILES ON IT AND HAD NEW BRAKES INSTALLED 8 MONTHS PRIOR. CAR HAD BEEN SERVICED 1 MONTH PRIOR FOR GENERAL SERVICE POINT CHECKS. TOOK CAR TO DEALERSHIP SAME DAY OF THIS INCIDENT - THEY COULD NOT FIND NOTHING WRONG WITH THE CAR. OFFERED TO SERVICE BASED ON A PREVIOUS RECALL TO REMOVE THE CURRENT FLOORMAT AND ADJUST ACCELERATOR. ONE MONTH PRIOR TO THIS INCIDENT THE RADIO STOPPED WORKING FOR A COUPLE OF DAYS THEN STARTED WORKING INTERMITTENTLY SOMETIMES DISPLAYING GARBLED TEXT ON THE RADIO DISPLAY. *TR

Mileage: 46,000

MY WIFE LEFT HOME TO DRIVE TO THE STORE - A 3-MILE TRIP, ALL IN-TOWN DRIVING. AFTER TRAVELING ABOUT 1/2 MILE, SMOKE STARTED COMING INTO THE CAR FROM BEHIND THE PANEL ON THE INSIDE OF THE DRIVER'S DOOR. SHE STOPPED THE CAR. THE VOLUME OF SMOKE ACCUMULATING IN THE CAR INCREASED. A PASSER-BY STOPPED, CALLED 911, REPORTED THE FIRE, AND ASSISTED MY WIFE, WHO CLIMBED INTO THE FRONT PASSENGER SEAT AND EXITED THE CAR OUT THE FRONT, RIGHT PASSENGER DOOR. BY THE TIME THE FIREMEN AND POLICE ARRIVED, APPROXIMATELY 3-5 MINUTES LATER, SMOKE WAS DENSE AND FLAMES WERE SURROUNDING THE EDGES OF THE DOOR PANEL. FIREMEN SPRAYED WATER ON THE PANEL, PULLED THE PANEL OFF THE DOOR, AND CONTINUED TO APPLY WATER UNTIL THE FIRE WAS EXTINGUISHED. THANKFULLY, MY WIFE WAS ABLE TO STOP AND EXIT THE CAR QUICKLY. HAD SHE BEEN IN HEAVY, FAST-MOVING TRAFFIC, IT COULD HAVE BEEN A LIFE-THREATENING SITUATION. ALSO, THE NON-AVAILABILITY OF FIREMEN WOULD HAVE RESULTED IN MUCH MORE FIRE- DAMAGE TO THE CAR AND POSSIBLY AN EXPLOSION. *TR

Mileage: 86,600

I WAS DRIVING THE RAV4 IN APRIL 2011 AND AGAIN ON SEPTEMBER 14, 2012 WHEN THE SAME INCIDENT OCCURRED.THE FIRST TIME THERE WAS NO WARNING, THE BATTERY LIGHT DID NOT COME ON, FIRST THE RADIO QUIT PLAYING AND THEN THE CAR WENT DEAD AS I WAS MOVING IN TRAFFIC. NEEDLESS TO SAY IT WAS VERY STRESSFUL BEING STRUCK IN TRAFFIC. THANKS TO SOME KIND LADIES, THE CAR WAS PUSHED OUT OF THE WAY. WE SUSPECTED IT WAS A BATTERY MALFUNCTION, ALTHOUGH THE BATTERY WAS ONLY 8 MONTHS OLD. WE TOOK THE BATTERY TO PLACE OF PURCHASE AND THEY TRIED TO CHARGE IT, IT WOULD NOT CHARGE SO THEY REPLACED THE BATTERY FOR FREE BECAUSE IT WAS STILL UNDER WARRANTY. ON FRIDAY, SEPTEMBER 14 I WAS DRIVING IN HEAVY TRAFFIC AND THIS TIME THE BATTERY LIGHT CAME ON FOR A FEW MINUTES, THEN THE RADIO WENT OUT AND THE CAR DIED. THIS WAS EXTREMELY STRESSFUL AS TRAFFIC WAS SPEEDING BEHIND ME AND I WAS AFRAID I WOULD GET REAR ENDED. ONCE AGAIN THERE WERE TWO FEMALES THAT HELPED ME PUSH THE CAR OUT OF TRAFFIC. ONCE AGAIN THE BATTERY WAS REPLACED AS IT WAS STILL UNDER WARRANTY, HOWEVER THIS TIME THE BATTERY LIGHT WILL NOT GO OUT. AFTER DOING SOME INVESTIGATING, I BELIEVE THE PROBLEM STEMS FROM THE RAV 4 'S ELECTRICAL STEERING AND THE FACT THAT IT PULLS TO MUCH POWER. THERE IS NOT REASON WHY THE CAR SHOULD JUST QUIT WHILE YOUR DRIVING IN TRAFFIC. IT IS HARD TO TRUST THE VEHICLE WHEN IT SUDDENLY STOPS IN TRAFFIC AND WILL NOT START AGAIN. *TR

Mileage: 72,000

THE CAR FILLED WITH THE SMELL ,AND SMOKE OF BURNING WIRE. *TR

Mileage: 80,200

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING 40 MPH BURNING FUMES WERE EMITTED INTO THE VEHICLE AND SMOKE STARTED TO COME OUT FROM THE DOOR. THE CONTACT MENTIONED THAT RIGHT BEFORE HE WAS ABLE TO STOP THE VEHICLE IT ENGULF INTO FLAMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 55,000.

Mileage: 55,000

WAS DRIVING NORMAL - ONLY A FEW MINUTES AFTER IGNITION - STRANGE SCENT OF PLASTIC BURNING. LOOKED DOWN TO FIND A THICK WHITE SMOKE COMING FROM WINDOW SWITCHES, FLAME SEEN THROUGH CRACKS. HAD TO PULL OVER IMMEDIATELY @ GAS/SERVICE STATION TO EXTINGUISH THE FLAME - I HAD NO LIQUID TO EXTINGUISH AT TIME OF INCIDENT. WENT DIRECTLY TO TOYOTA DEALERSHIP AND DROPPED OFF VEHICLE. THEY ARE SAYING THERE IS NO RECALL - SO THEY WOULD NOT PURCHASE ME A RENTAL HAD TO PAY FOR IT MYSELF. I FOUND THESE LINKS RIGHT AWAY ONCE I GOT IN FRONT OF A COMPUTER: HTTP://WWW.KTVU.COM/NEWS/NEWS/TOYOTA-RECALLING-778000-RAV4-SUVS/NP8CR/ THIS IS THE LATEST ISSUE FOR THE POPULAR RAV4, WHICH IS CURRENTLY INVOLVED IN A GOVERNMENT INVESTIGATION OF DOOR FIRES THAT HAVE BEEN LINKED TO POWER WINDOW SWITCHES. HTTP://WOT.MOTORTREND.COM/BURNING-TOYOTA-CAMRYRAV4-WINDOW-SWITCHES-PROMPT-NHTSA-INVESTIGATION-168895.HTML END OF REPORT. *TR

Mileage: 93,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THERE WAS SMOKE AND A BURNING SMELL COMING FROM THE DRIVER SIDE ELECTRICAL PANEL. THE VEHICLE WAS PULLED INTO A TIRE SHOP AND THE FIRE WAS EXTINGUISHED. THE VEHICLE WAS LATER TAKEN TO THE DEALER WHO ADVISED THAT THEY WOULD NEED TO REPLACE THE CONTROL PANEL BECAUSE ALL OF THE WIRES WERE MELTED. THE MANUFACTURER WAS NOTIFIED WHO SENT OUT A REPRESENTATIVE TO INSPECT THE FAILURE, ADVISING THE CONTACT THAT THEY WOULD RESPOND WITHIN THIRTY DAYS. THE VEHICLE WAS NOT YET REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 74,120.   ..UPDATED 09/12/12 *BF UPDATED 09/12/2012 *JS

Mileage: 74,120

I WAS DRIVING WHEN SUDDENLY I SAW SMOKE COMING OUT OF THE POWER WINDOW SWITCH ON THE DRIVER'S-SIDE DOOR. WHEN I STOP TO CHECK I SAW FIRE INSIDE THE DOOR. I IMMEDIATE ASK FOR ASSISTANCE. WHEN HE UNCOVER THE SWITCH IT HAS A NICKEL SIDE HOLE. THERE IS NO MAJOR DAMAGE TO MY VEHICLE OTHER THAN THE SWITCH NOT WORKING OR MY WINDOWS. I REALLY THINK I WAS LUCKY THAT I WAS NEAR MY BROTHERS HOME WHEN THIS HAPPEN. IF I WAS SOMEWHERE (LIKE THE FREEWAY) I REALLY TAUGHT MY WHOLE CAR WOULD OF CAUGHT ON FIRE AND LUCKY MY CHILD WAS NOT IN THE VEHICLE WITH ME. *TR

Mileage: 111,731

MY 2007 RAV4 DRIVER SIDE REAR WINDOW WONT GO UP AND DOWN. THE DRIVER SIDE CONTROL SWITCH FOR THE REAR DRIVER SIDE WINDOW DOES NOT MOVE. THE SWITCH FOR THE REAR DRIVER SIDE WINDOW ON THE BACK DOOR DOES NOT WORK ALL THE TIME. WHEN IT DOES WORK JUST ONE TAP AND THE REAR WINDOW (DRIVER SIDE) GOES DOWN ALL THE WAY BY ITS SELF. THE OTHER THREE SWITCHES FOR THE WINDOWS AND THE OTHER THREE WINDOWS SEEM TO WORK AND RESPOND HOW THEY SHOULD. ONLY PROBLEM IS WITH THE REAR WINDOW AND THE SWITCH ON BOTH THE DRIVER DOOR AND THE REAR WINDOW DOOR (DRIVER SIDE). ALSO WHILE DRIVING TO WORK DRIVING APROX 10 MPH MY REAR PASSENGER SIDE WHEEL BENT IN TOWARD THE WHEEL WELL. THE TIE ROD WAS BROKE AND THE TIE ROD WAS VERY RUSTED . THE DEALER SAID IT WAS A FREAK OCCURRENCE AND FIXED IT WHILE UNDER WARRANTY. PROBLEM IS THAT THE OTHER SIDE OF THE REAR SUSPENSION (DRIVER SIDE) IS ALSO RUSTED BUT THEY DID NOT FIX IT AT THE SAME TIME. THIS HAPPENED JUNE 14TH AT ABOUT 6:10 AM I WAS NOT TOLD OF THE RECALL OF THIS TIE ROD ISSUE AT THE TIME OF IT GETTING FIXED . THEY PLAYED IT OFF AS IT WERE A FREAK OCCURRENCE.. TOYOTA/SCION DEALER OF BERLIN CITY TOYOTA. *TR

Mileage: 64,000

THIS JUST HAPPEND TO ME ON THE MORNING OF 07/26/2012. I WAS ON A BUSINESS TRIP AND LEAVING THE AIRPORT. AS I WAS ABOUT TO PAY MY PARKING FEE THE DRIVER SIDE DOOR STARTED SMOKING AND I SAW A SMALL FIRE STARTING TO FLARE UP ON THE DRIVER'S SEAT DOOR BY THE WINDOW SWITCH. I TURNED OFF THE CAR AND WITHIN 3 MINUTES THE WHOLE DOOR WAS UP IN FLAMES. *JS

Mileage: 85,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV4. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE DRIVER'S SIDE DOOR CAUGHT ON FIRE INSIDE OF THE DOOR PANEL. THE VEHICLE HAD NOT BEEN DIAGNOSED BY A DEALER AT THE TIME. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 107,802.

Mileage: 107,802

THE DRIVER DOOR'S WINDOW/LOCK CONTROL PANEL SPONTANEOUSLY CAUGHT FIRE WHILE I WAS OPERATING THE VEHICLE. I WAS NOT USING THE CONTROLS AT THE TIME. I COULD HEAR THE SOUND OF BURNING AND FEEL HEAT BEHIND THE PANEL, HOWEVER NO ACTUAL FLAMES CAME OUTSIDE OF THE PANEL. COPIOUS AMOUNTS OF SMOKE BEGAN TO BILLOW FROM THE OPENINGS IN THE CONTROL PANEL. I STOPPED THE CAR AND TURNED OFF THE IGNITION. AFTER SEVERAL SECONDS THE SOUND OF BURNING CEASED. THE SMOKE CONTINUED TO BILLOW FROM THE OPENINGS IN THE CONTROL PANEL FOR A COUPLE OF MINUTES. I CALLED THE TOYOTA DEALER WHERE I PURCHASED THE CAR AND WAS TOLD BY THE SERVICE DEPARTMENT TO COME IN. I RESTARTED THE CAR AND DROVE ABOUT ONE MILE TO THE DEALERSHIP. WHILE I WAS DRIVING SMALL AMOUNTS OF SMOKE CONTINUED TO COME OUT THROUGH THE OPENINGS IN THE CONTROL PANEL. AT THE DEALERSHIP THEY PLACED SOME KIND OF "LOCK" ON THE DRIVER'S SIDE CONTROL FOR THE FRONT PASSENGER WINDOW. I HAVE SINCE SEEN THE ACTUAL CONTROL MECHANISM. A PORTION OF THE ELECTRICAL COMPONENT IS CHARRED, AND WHERE THIS CHAR IS THERE IS A HOLE BURNED THROUGH THE PLASTIC ENCLOSURE. *TR

TL* THE CONTACT OWNS A 2007 TOYOTA RAV-4. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, SMOKE STARTED TO EMIT OUT OF THE DRIVER SIDE DOOR PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS NOT ABLE TO DIAGNOSE THE PROBLEM. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 59,000.

Mileage: 59,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV 4. WHILE PARKED, THE FRONT DRIVER'S SIDE DOOR IGNITED INTO FLAMES. THE FIRE DEPARTMENT REPORTED TO THE SCENE AND A REPORT WAS FILED. THE FIRE BEGAN IN THE FRONT DRIVER'S SIDE POWER MASTER SWITCH. THERE WAS AN INVESTIGATION OPEN UNDER NHTSA ACTION NUMBER: PE12002 (ELECTRICAL SYSTEM) THAT MAY BE RELATED TO THE FAILURE. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Mileage: 10,000

WHEN I TURNED THE CAR ON A SMELL EMANATED AND SMOKE CAME FROM THE WINDOW SWITCH AREA OF THE FRONT DRIVER DOOR. THE PASSENGER SIDE WINDOW WOULD NO LONGER WORK. THE SMELL LINGERED BUT THE SMOKE STOPPED. *TR

Mileage: 125,000

MASTER WINDOW SWITCH BURNED AND EMITTED SMOKE WITH HIGH CONCENTRATION OF IRRITATING FUMES THROUGHOUT THE SUV WHILE ENROUTE IN MARYLAND. *TR

Mileage: 90,440

IT WAS A SUNNY DAY, AND I DROVE MY 2007 RAV4 AT THE SPEED OF 40 MILES PER HOUR. SUDDENLY, I HEARD A NOISE ZIIIII FROM THE MASTER WINDOW SWITCH AT THE DRIVER SIDE. I SAW AN ELECTRICAL FIRE AT THE MASTER WINDOW SWITCH AT THE DRIVER SIDE. THE SMOKE CAME OUT FROM THE MASTER WINDOW SWITCH. I PULLED OVER MY CAR, TURNED OFF THE ENGINE AND LEFT THE CAR. WHEN THE FLAME WENT OUT, I SAW A BURNED HOLE ABOUT QUARTER SIZE IN THE SWITCH. NOTE: THERE IS NO WATER LEAKED / COFFEE SPILLED INSIDE THE SWITCH. I WENT TO TOYOTA DEALER. THE MECHANICS STATED THAT THE FUSE DID NOT BLOW OUT. DEALER DENIED TO REPLACING THE SWITCH WITHOUT CHARGING. *JS

Mileage: 70,943

NEUTRAL START SWITCH HIDDEN WITHIN THE CONFINES OF THE ENGINE MANAGEMENT SYSTEM CAN FAIL TO WORK AND THUS NOT SEND A SIGNAL TO START THE ENGINE. ACCORDING TO THE HEAD MECHANIC, THE DEFECT IS UNCERTAIN WHY IT HAPPENS OTHER THAN THE STANDARD RESPONSE THAT IT IS NORMAL ASPECT OF WEAR. I DON'T AGREE, SINCE THE COMPONENT IS UNDER NO STRESS LIKE FOR EXAMPLE A SPARK PLUG. THANK YOU FOR LOOKING IN THE MATTER. *TR *KB

Mileage: 47,500

MY WIFE STARTED VEHICLE IN GARAGE TO WARM IT UP WHEN SHE SMELLED SMOKE. SHE THEN NOTICED SMOKE AND FLAMES COMING FROM THE DRIVERS SIDE WINDOW/POWER LOCK SWITCH AREA. SHE POURED HER CUP OF COFFEE ON THE FLAMES TO EXTINGUISH THEM. VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO HAD TO REPLACE THE DRIVERS SIDE MASTER WINDOW SWITCH WHICH HAD BURNT UP. *TR

Mileage: 77,950

A CAR PULLED OUT OF DRIVEWAY AND I TOUCHED THE BRAKE PEDAL AND MY ENGINE INCREASED ACCELERATION WHEN IT SHOULD HAVE SLOWED ACCELERATION AND I PUSHED MY CAR INTO NEUTRAL AND I PULLED CRUISE CONTROL LEVER TOWARDS ME AND THE ENGINE SLOWED DOWN-MY CAR HAD BEEN SET TO CRUISE AT 52 MPH. AFTER THE INCIDENT I SHUT THE CRUISE CONTROL OFF AS I WAS HEADING INTO TOWN. I THEN PULLED INTO BIG SCOOP(CANTON,IL BUSINESS) PARKING LOT GOING LESS THAN 5 MPH-A LADY WALKED IN FRONT OF MY CAR AND I TOUCHED THE BRAKE AND AGAIN I EXPERIENCED UNWANTED ACCELERATION AND AGAIN I WAS QUICK IN SHOVING CAR INTO NEUTRAL PREVENTING A SERIOUS INJURY. I WENT HOME AND CALLED FORT TOYOTA IN PEKIN, IL AND I TOOK CAR IN FEB, 17, 2012 AT NOON. THEY HAD THEIR TOP MECHANIC CHECK IT OUT-HE SAID HE COULD FIND NOTHING WRONG. THEY CALLED TOYOTA'S HEADQUARTERS AND THEY TOLD THEM IT WAS A FLOORMAT ISSUE. THEY TOLD ME THAT AND I TOLD THEM IT HAD NOTHING TO DO WITH THE FLOORMATS BUT RATHER AFTER TOUCHING THE BRAKE PEDAL IS WHEN I RECEIVED UNWANTED ACCELERATION IN BOTH INCIDENTS. THEY ASKED ME SEVERAL QUESTIONS ABOUT THAT AND THEY GAVE ME TOYOTA'S HEADQUARTERS NUMBER AND GAVE ME A RENTAL CAR TO USE. WHEN I CALLED THEIR HEADQUARTERS THEY SAID IT WAS A FLOORMAT ISSUE AND THAT WAS THEIR FINAL STATEMENT ON THE MATTER. I TOLD THEM IT WAS A BRAKE ISSUE BUT THEY STUCK TO FLOORMATS AS THE CAUSE AND THAT IS WHY I'M REPORTING THIS MATTER TO YOU AS I FEEL FOR THE SAFETY OF ALL DRIVERS; THIS ISSUE NEEDS TO BE RESOLVED BY ANY AUTOMAKER WITH UNWANTED ACCELERATION PROBLEMS. A FIRST STEP IS TO ADMIT THAT THEY HAVE THE PROBLEM THEN GOOD(SAFE) THINGS WILL RESULT. THANK YOU FOR HEARING ME OUT. IT IS APPRECIATED VERY MUCH,[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I PURCHASED A NEW 2007 RAV4 FROM TOYOTA OF BRAINTREE IN 2007. 1. IN 2009 I COULD HEAR WIND IN THE DRIVER'S WINDOW; I TOOK THE VEHICLE TO BE CHECKED, TOYOTA SERVICE DEPARTMENT SAID I WAS HEARING THINGS. 2.THE DRIVER'S DOOR CAUGHT FIRE (I HAD THE KEYS WITH ME) I HAD TO SPEND $606.01 TO FIX IT, TOYOTA SAID THERE WAS WATER INTRUSION (I THOUGHT, IT PROBABLY WAS, BECAUSE OF THE AIR LEAK PREVIOUSLY REPORTED IN 2009) 3. THE STEERING WHEEL FELT STRANGE WHEN I DROVE, I TOOK IT BACK FOR SERVICE, THE DIAGNOSIS WAS STEERING SHAFT INTERNAL FAILURE WHICH NEEDED TO BE REPLACED; I FOUGHT TO GET THAT FIXED OUT OF WARRANTY. 5. ON NOVEMBER 25, 2011 I WAS DRIVING, THE WINDOW FELL IN ON ME AND ON NOVEMBER 26, 2011, I HAD TO HAVE THE DRIVER'S SIDE WINDOW REGULATOR REPLACED FOR $338.30 7. NOW, OIL IS LEAKING INTO THE MUFFLER. (I PURCHASE OIL FREQUENTLY) THIS VEHICLE IS ONLY 4.5 YEARS OLD AND SHOULD NOT HAVE ANY OF THESE MAJOR PROBLEMS, WHEN I PURCHASED THIS RAV4, IT WAS GOING TO BE MY LAST VEHICLE PURCHASE BECAUSE TOYOTA ADVERTISES LONGEVITY OF THEIR PRODUCTS. I ALSO KNOW PEOPLE WHO DRIVE 1990 AND 1995 TOYOTA PRODUCTS WHO HAVE NEVER HAD ANY OF THESE PROBLEMS. I WAS ALSO TREATED VERY POORLY DURING SOME OF MY REPAIR VISITS. AFTER THE DOOR CAUGHT ON FIRE, I HAD A MEETING WITH THE OWNER OF TOYOTA OF BRAINTREE, [XXX] BUT HIS RESOLUTION WAS GIVING ME $13,000.00 FOR MY VEHICLE (WHICH I OWN) AND ME PURCHASING A BRAND NEW VEHICLE, WHICH MEANT I WOULD HAVE A MONTHLY PAYMENT. I DID CONTACT TOYOTA HEADQUARTERS IN CALIFORNIA AND FILED A COMPLAINT AND NEVER RECEIVED ANY RESOLUTION. SINCE THEN I RECEIVED A LETTER FROM THE NATIONAL CENTER FOR DISPUTE SETTLEMENT STATING THEY CAN'T HELP ME. THANK YOU FOR ANY ASSISTANCE, SINCERELY, TOYOTA RAV4 OWNER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

Mileage: 18,462

TL* THE CONTACT OWNS A 2007 TOYOTA RAV-4. THE CONTACT STATED THAT THE FRONT DRIVER'S DOOR CAUGHT ON FIRE. THE VEHICLE HAD BEEN INSPECTED BY THE DEALER AND THE CONTACT REMOVED ALL OF THE SWITCHS AND FUSES FROM THE DOOR. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

I WAS DRIVING HOME FROM WORK LAST JANUARY 19 AT 5PM I SAW MY WINDOW THAT IT LOOKS LIKE SO HOT OUTSIDE AND WHEN I TRIED TO OPEN IT,I SAW A FLAME COMING OUT FROM THE LEFT POWER SWITCH. I WAS SO SCARED BECAUSE IT LOOKS LIKE IT WAS GETTING BIG SO I STOP MY CAR ,TURN OFF MY ENGINE,GET OUT OF THE CAR AND CALL 911. WHEN POLICE AND FIRE DEPARTMENT ARRIVED, THE FIRE OR FLAMES GONE. IT WAS SO STRANGE AND SCARY. GOOD THING I NEVER GOT HURT AND I TURNED OFF THE ENGINE RIGHT AWAY. I FILE THIS COMPLAINT BECAUSE I JUST WANT YOU TO BE AWARE SO THAT YOU GUYS CAN DO ANY SOLUTION FOR THIS MATTER AND I DON'T WANT ANYBODY TO EXPERIENCE WHAT HAPPEN TO ME. POLICE REPORT # 12-024482. *KB

Mileage: 48,037

MASTER WINDOW POWER SWITCH CAUGHT A FIRE IN AUGUST 2011. IT HAD BEEN GIVING ME PROBLEMS SINCE JULY 2009. TOYOTA WOULD NOT FIX IT BECAUSE TO MANY MILES. HOW DOES A POWER WINDOW STOP WORKING ON A 2007 RAV4 WHEN IT ONLY TWO YEARS OLD. FAULTY MASTER POWER SWITCH. IT HAD A BURN HOLE THE SIZE OF A DIME. I'M GLAD I TOOK A PICTURE OF IT. THE FIRST TIME I SAW SMOKE WAS JUNE 2011. I WAS SO AFRAID TO DRIVE THE FIRE TRAP I TRADED IT IN FOR A NEW CAR. THE RAV4 WAS PAID OFF NOW I HAVE A CAR LOAN AT 19.9%. *KB

Mileage: 84,000

AFTER DRIVING FOR APPROXIMATELY 15 MINUTES, I SAW A SMALL AMOUNT OF SMOKE COMING FROM THE DRIVERS DOOR PANEL AND IT SMELLED LIKE AN ELECTRICAL FIRE. AFTERWARDS, THE DRIVERS SIDE POWER WINDOW SWITCH AND THE PASSENGER SIDE POWER WINDOW SWITCH WAS NOT FUNCTIONAL. THE PASSENGER WINDOW WOULD ONLY LET DOWN (VERY SLOWLY) BUT WOULDN'T GO BACK UP. I TOOK THE VEHICLE TO A TOYOTA SERVICE CENTER AND THEY SHOWED ME THAT THE MAIN POWER WINDOW SWITCH ON THE DRIVERS SIDE HAD A HOLE BURNED INTO IT THE SIZE OF A DIME. THE SERVICE MANAGER SAID HE HAD NEVER SEEN ANYTHING LIKE THIS BEFORE. PRIOR TO THIS THE PASSENGER WINDOW SWITCH WAS REPLACED TWICE BETWEEN SEPTEMBER 2010 AND NOVEMBER 2010. HOWEVER, THE REPLACEMENTS STILL NEVER TOOK CARE OF THE PROBLEM OF THE PASSENGER WINDOW SWITCH INTERMITTENTLY WORKING. IN FACT, A COUPLE MONTHS AGO I WAS JUST AT THE DEALERSHIP COMPLAINING THAT I WAS STILL HAVE THE PROBLEM WITH THE WINDOW SWITCH ON THE PASSENGER SIDE INTERMITTENTLY WORKING. I NEVER GUESSED THAT MY CAR COULD CATCH ON FIRE! NOW I'M A LITTLE WORRIED ABOUT DRIVING MY VEHICLE! UPDATED 11/17/11 *BF UPDATED 06/06/12 *JS

Mileage: 88,000

ELECTRICAL FIRE STARTING INSIDE MASTER WINDOW CONTROL SWITCH. I WAS CLEANING MY CAR WITH THE IGNITION ON BATTERY POWER (IN ORDER TO LISTEN TO THE RADIO). AFTER APPROXIMATELY 30 MINUTES I NOTICED A BURNT PLASTIC SMELL, CONSIDERABLE SMOKE POURING OUT OF THE DRIVER'S DOOR AND A SMALL TONGUE OF FLAME FROM THE SAME PLACE. THE SOURCE OF THE FIRE WAS (LATER FOUND TO BE) THE WHITE ELECTRICAL CONNECTOR, FOR THE FRONT PASSENGER WINDOW MASTER CONTROL, WHERE THE PHYSICAL WINDOW SWITCH MEETS THE CIRCUIT BOARD. I WAS NOT TOUCHING ANY WINDOW OR OTHER CONTROLS AT THE TIME OR WITHIN 15 MINUTES BEFORE THE FIRE. THE FIRE STOPPED RAPIDLY AFTER I TOOK THE KEYS OUT OF THE IGNITION, DISCONNECTED THE BATTERY CABLES, POPPED OFF THE MASTER SWITCH ASSEMBLY WITH A SCREWDRIVER AND THEN SMOTHERED THE CONTROLS WITH A WET TOWEL. ALL THE VEHICLE'S WINDOWS WERE INOPERABLE AFTER THAT. I BROUGHT THE VEHICLE TO MY LOCAL TOYOTA DEALERSHIP. THEY PERFORMED AN INSPECTION AND REPORTED THAT THEY WERE 'MYSTIFIED' AS TO THE CAUSE. THE SERVICE MANAGER'S WORDS WERE: 'I'VE NEVER SEEN ANYTHING LIKE THAT IN MY 25 YEARS WORKING ON CARS.' THE PROPERTY DAMAGE WAS CONFINED TO THE MASTER SWITCH ASSEMBLY AND COST $422 TO REPLACE. TOYOTA REFUSED TO PAY FOR THIS. *TR

Mileage: 68,850

LAST NIGHT, MY RAV4 BATTERY DIED DUE PRESUMABLY TO THE REAR DOOR LIGHT GETTING ACCIDENTALLY TURNED ON. UPON JUMP STARTING THE CAR, EVERYTHING SEEMED FINE. I DROVE IT HOME WITHOUT INCIDENT. THEN, THIS MORNING, THE BATTERY WAS NOT QUITE UP HIGH ENOUGH TO START THE CAR, SO I JUMP STARTED IT AGAIN. IT STARTED, BUT A FEW HUNDRED FEET AWAY, I LOST POWER STEERING AND POWER BRAKE ASSIST. IT REQUIRED EVERY OUNCE OF FORCE I COULD MUSTER TO TURN THE VEHICLE AROUND AND GET IT BACK TO MY HOUSE. THANKFULLY, THIS HAPPENED ON CITY STREETS NEAR MY HOUSE AND NOT ON THE HIGHWAY LAST NIGHT OR THE CHP WOULD HAVE BEEN SCRAPING ME OFF A BRIDGE POST. THE RAV4 CANNOT REALISTICALLY BE STEERED BY AN AVERAGE PERSON WITHOUT THE POWER STEERING ASSIST BECAUSE OF THE GEARING RATIO, MAKING THIS A VERY SERIOUS DESIGN DEFECT. IF A VEHICLE CANNOT SAFELY OPERATE, THE VEHICLE SHOULD NOT OPERATE. THE PROBLEM IS THAT, BECAUSE THE BATTERY PLAYS AN INTEGRAL ROLE IN POWER SMOOTHING, AND BECAUSE THE POWER STEERING AND POWER BRAKE PUMPS ARE ELECTRICALLY OPERATED, A LOW BATTERY CAN RESULT IN FAILURE OF THE POWER STEERING AND BRAKE PUMPS WHILE THE ENGINE IS STILL FUNCTIONAL. THIS CAN EASILY RESULT IN AN UNCONTROLLABLE VEHICLE BARRELING DOWN THE HIGHWAY AT 80 MPH. I BELIEVE THAT FIXING THIS PROBLEM REQUIRES A FUNDAMENTAL REDESIGN OF THE ELECTRICALLY OPERATED PUMPS TO ADD ADDITIONAL CAPACITORS SO THAT THE BATTERY IS NOT PLAYING SUCH A CRUCIAL ROLE IN SMOOTHING OUT THE PULSATING DC FROM THE ALTERNATOR ALONG WITH THE ADDITION OF SENSOR HARDWARE TO DETECT A LOW BATTERY CONDITION AND ACTIVATE AN INDICATOR LIGHT UNTIL THE VEHICLE IS SAFE TO DRIVE. IDEALLY, THE STEERING GEARBOX SHOULD ALSO BE REDESIGNED WITH A LOWER GEAR RATIO SO THAT IT DOES NOT BECOME UNDRIVEABLE. WITHOUT THESE FIXES, THE 2007 RAV4 IS FUNDAMENTALLY UNSAFE. THIS DESIGN FLAW PROBABLY ALSO AFFECTS MOST OTHER LATE MODELS OF TOYOTA. *TR

Mileage: 22,300

1. WHILE DRIVING A 2007 TOYOTA RAV4 AT LOW SPEED, THE STEERING WHEEL LOCK ENGAGED, INSTRUMENT CLUSTER LIGHTS FLASHED AND THE RADIO SILENCED FOR ABOUT 5 SECONDS. THE CAR WAS ABLE TO BE SAFELY STOPPED. NORMAL STEERING RESUMED RADIO CAME BACK ON AND CLUSTER LIGHTS STOPPED FLASHING. THE CAR WAS DRIVEN APPROXIMATELY 2-3 MILES AND PARKED FOR APPRX. 1 HOUR. 2. THE CAR WOULD NOT START, AGAIN NO RADIO, BUT LIGHTS WERE ILLUMINATED TO FULL BRIGHTNESS. NO WARNING/FAULT LIGHT WAS ILLUMINATED. THE CAR WAS "JUMP-STARTED". WHEN PULLING OUT OF THE PARKING STALL, THE STEERING WHEEL LOCK ENGAGED AGAIN. A TOW TRUCK WAS CALLED. THE CAR ENGINE REMAINED RUNNING NORMALLY. 3. WHILE LOADING THE CAR, THE TOW TRUCK DRIVER HAD THE STEERING WHEEL LOCK ENGAGE AND DISENGAGE REPEATEDLY 4 - 5 TIMES. THE TOYOTA OF WALNUT CREEK (CALIFORNIA) TECHNICIAN STATES THAT THE PROBLEM IS A DISCHARGED BATTERY, CAUSING THE ELECTRIC POWER STEERING ASSIST TO NOT OPERATE AND STATED THAT THE STEERING WHEEL LOCK CANNOT ENGAGE WHILE THE CAR IS IN MOTION. THE PROBLEM WAS THAT THE STEERING WHEEL LOCK DID ENGAGE, NOT A LACK OF STEERING ASSIST. THE TECHNICIAN STATED HE "CANNOT DUPLICATE" THE PROBLEM. *TR

Mileage: 55,000

TL* THE CONTACT OWNS A 2007 TOYOTA RAV-4. THE CONTACT STATED THE VEHICLE WOULD NOT START AND RECEIVED A JUMP START. AFTER RECEIVING THE JUMP START AND DRIVING 15 MPH, THE POWER STEERING LOCKED AND THE POWER STEERING WARNING LIGHT BEGAN TO SPORADICALLY ILLUMINATE. THE DEALER ADVISED THE CONTACT THAT THE BATTERY WOULD NEED TO BE REPLACED TO CORRECT THE FAILURE. THE BATTERY WAS REPLACED. THE CONTACT WAS CONCERNED WITH THE SAFETY OF A RECURRING FAILURE IF DRIVING ON THE HIGHWAY AND THE POTENTIAL OF A CRASH. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 45,000.

Mileage: 45,000

OEM BATTERY DIED. VEHICLE WAS JUMP STARTED. DURING SUBSEQUENT OPERATION POWER STEERING STOPPED WORKING INTERMITTENTLY CAUSING DIFFICULTY STEERING VEHICLE. *TR

Mileage: 56,000

COMPLAINT:SECOND COMPLAINT I PURCHASED MY TOYOTA RAV 4 2007 IN OCTOBER OF 2007. A FEW MONTHS AFTER I HAD THE CAR I STARTED NOTICING THAT THE CAR, FOR NO REASON WOULD HESITATE, LEAVING ME AT TIMES IN THE MIDDLE OF CROSSINGS AN INTERSECTIONS WITH NO POWER. AFTER OTHERS BEGAN MAKING COMMENTS THAT THERE WAS SOMETHING WRONG I BROUGHT IT INTO LEITH TOYOTA. THE FIRST TIME WAS APRIL 24TH 2008. I EXPLAINED TO THE SERVICE ADVISOR I WAS HAVING INTERMITTENT PROBLEMS WITH THE CAR. I TOLD HIM I WOULD START ACROSS AN INTERSECTION (4 LANES) AND ALL OF A SUDDEN THE CAR HESITATED, THERE WAS NO POWER. I WOULD PRESS THE GAS PEDAL TO THE FLOOR AND APPROXIMATELY 10-15 SECONDS LATER THE CAR WOULD LUNGE FORWARD. I TOLD THEM IT CONCERNED AND SCARED ME. I WAS TOLD THAT THEY COULD NOT FIND ANY PROBLEMS. APRIL 28TH 2008 I RETURNED AGAIN TO THE DEALERSHIP ADVISING THEM THERE WAS A PROBLEM, I WAS AFRAID TO DRIVE THE CAR AND WANTED IT FIXED. I AGAIN WAS TOLD THERE WAS NOT ANY PROBLEM WITH THE CAR. THIS TIME I REFUSED TO LEAVE UNTIL THE PROBLEM WAS FIXED. THEY FINALLY BROUGHT THE CAR BACK IN AND TOLD ME THE MODELS HAVE A PROBLEM WITH THE ECM SYSTEM. I WAS TOLD THEY REFLASHED THE ECM SYSTEM WITH AN UPDATE SENT BY CORPORATE AND THINGS SHOULD BE FINE. YESTERDAY I RETURNED TO THE DEALERSHIP. I TOLD THEM THE CAR WAS OK FOR A NUMBER OF MONTHS BUT AGAIN THIS WEEK I WAS ALMOST IN AN ACCIDENT BECAUSE THE CAR HAD STARTED TO HESITATE AGAIN, AND I AM LEFT IN THE INTERSECTION WITHOUT POWER AND ON-COMING TRAFFIC. THEY TOOK THE CAR OUT AND OF COURSE THE PROBLEM IS INTERMITTENT SO THEY WERE UNABLE TO FIND ANYTHING ABNORMAL. THEY TOLD ME THEY WOULD CHECK TO SEE IF THERE WERE ANY ADDITIONAL COMPUTER UPDATES FOR THE PROBLEM. THE CAR ALSO LOOSES POWER ON HIGHWAY AT 60 MPH, SHUTS DOWN AFTER A WHILE. THEY ADVISED ME THERE WERE NO ADDITIONAL UPDATES. I TOLD THEM THE PROBLEM IS PUTTING ME IN DANGER OF HAVING AN ACCIDENT. THEY TOLD ME TOYOTA DOES NOT FEEL THIS IS A PROBLEM. *TR UPDATED IVOQ 07/15/10.*JB

Mileage: 100

THE BATTERY ON MY WIFE'S 2007 TOYOTA RAV4 WENT OUT WITHOUT WARNING, & SO ON THE ADVICE OF THE FOLSOM LAKE TOYOTA GARAGE, I JUMP STARTED HER CAR TO GET HER HOME. THE NEXT MORNING I DID THE SAME, SO THAT SHE COULD DRIVE IT TO THE GARAGE TO GET FIXED. WHEN SHE STARTED TO DRIVE THE CAR HOWEVER, THE STEERING LOCK WOULD NOT ALLOW HER TO TURN THE WHEEL & SHE ENDED UP DRIVING TOWARDS THE MIDDLE OF THE ROAD. SHE IMMEDIATELY STOPPED, & TOLD ME, & SO AS I THOUGHT SHE MEANT THAT THE POWER STEERING SIMPLY WASN'T WORKING, I SAID THAT I WOULD DRIVE IT TO THE GARAGE FOR HER. WHEN I STARTED OFF HOWEVER, THE CAR STEERING LOCK STOPPED ME TURNING THE WHEEL, ALTHOUGH ONLY FOR A SECOND OR TWO, BEFORE THE STEERING BEGAN TO WORK CORRECTLY, & SO I VERY SLOWLY & CAREFULLY DROVE THE CAR TO THE GARAGE. THE GARAGE CHECKED THE CAR & SAID THAT IT WAS JUST A FAULTY BATTERY, BUT WHEN I POINTED OUT THAT IF A FAULTY BATTERY COULD CAUSE THE STEERING LOCK TO ENGAGE WHILE DRIVING, THIS WAS A SAFETY HAZARD, THEY SAID THAT WHEN THEY ASKED TOYOTA, THEY SIMPLY SAID THAT IT WAS WORKING AS DESIGNED, & SO THERE WAS NOTHING THEY COULD DO. CONSEQUENTLY, I CALLED TOYOTA, & THEY TOLD ME THAT AS THE CAR HAS AN ELECTRONIC POWER STEERING MODULE, THE STEERING LOCK COULD ENGAGE WITH A BAD BATTERY. WHEN I SUGGESTED TO THE CUSTOMER SERVICES REP THAT THEY NEEDED TO ADDRESS THIS ISSUE AS A SAFETY HAZARD, SHE WASN'T INTERESTED IN HELPING, & POINT BLANK REFUSED TO GIVE ME CONTACT DETAILS FOR HER BOSS, OR ANYONE AT TOYOTA NORTH AMERICA OR JAPAN, ONLY THE CUSTOMER SERVICES DEPT., I.E., PEOPLE LIKE HERSELF. I FIND IT INSULTING THAT TOYOTA NOT ONLY APPEARS NOT TO CARE ABOUT THE SAFETY OF THEIR CUSTOMERS, BUT ALSO DOESN'T APPEAR TO WANT TO HEAR FROM THEIR CUSTOMERS, E.G., WHEN I TOOK A SURVEY AFTER MY CALL, & ENTERED SOME VERY LOW NUMBERS FOR SERVICE CARE, THE CALL WAS DELIBERATELY CUT OFF BY TOYOTA. SO MUCH FOR JAPANESE SERVICE! *TR

Mileage: 19,250

I PURCHASED MY 2007 RAV4 USED IN EARLY 2008. IT HAS THE FACTORY INSTALLED PREMIUM JBL 6-DISC STEREO. SINCE THE DAY THAT I HAVE OWNED IT, I HAVE HAD PROBLEMS WITH RADIO RECEPTION. THE RADIO'S DISPLAY WAS ALSO MALFUNCTIONING, SO THE DEALER REPLACED THAT, BUT I STILL HAVE POOR RECEPTION. THE RECEPTION IS FINE IF I AM WITHIN ABOUT 5 MILES OF A RADIO TOWER, BUT JUST OUTSIDE OF CITY LIMITS, I EITHER GET STATIC OR THE SIGNAL IS LOST COMPLETELY. WHEN I HAD THE DISPLAY REPLACED, I TOLD THE DEALERSHIP (BILL PENNEY TOYOTA, HUNTSVILLE, ALABAMA) ABOUT THE POOR RECEPTION, BUT THEY DIDN'T DO ANYTHING ABOUT IT. *TR

Mileage: 16,000

2007 RAV4 LTD V6 - ALARM SYSTEM THAT KILLS ENGINE -- MALFUNCTIONED. SHORT IN ELECTRICAL SYSTEM BETWEEN ALARM SYSTEM AND BATTERY. DEALER SUPPOSEDLY FIXED, BUT I HEAR A BUZZ NOISE LIKE A WIRE SHORTING OUT AND THE ONE BEEP THE ALARM SYSTEM IS TO MAKE WHEN LOCKING CAR DOESN'T BEEP. SYSTEM MALFUNCTIONED 2 X AND LAST TIME WAS LEAVING AIRPORT AT MIDNIGHT. LUCKILY PULLED OFF INTERSTATE. CAR DIED. COULD HAVE HAPPENED WHILE DRIVING ON INTERSTATE. CAR HORN CONTINUOUSLY BEEPED WHEN MALFUNCTIONING - WHICH COULD HAVE CAUSED ME TO BE CAR JACKED BY SOMEONE WHO THOUGHT I WAS INTENTIONALLY DOING THE BEEPING OR IT COULD HAVE KILLED THE ENGINE WHILE DRIVING ON INTERSTATE. DEALER SAID PROBLEM WAS BATTERY THEN SAID SHORT BETWEEN BATTERY AND ALARM SYSTEM. SUPPOSEDLY FIXED IT BUT IT APPEARS THAT IT'S STILL NOT WORKING PROPERLY 2 WEEKS LATER SO TAKING BACK TO DEALER TODAY. *TR

Mileage: 24,113

LEADS TO BATTERY WERE COLORED WRONG. THE POSITIVE LEAD WAS PAINTED BLACK AND THE NEGATIVE LEAD WAS PAINTED RED. WHEN I JUMP-STARTED THE CAR I PUT THE BATTERY CABLES TO THE ASSOCIATED COLORS. IT WAS CONNECTED FOR ABOUT 1 MINUTE WHEN I NOTICED SOMETHING SMOKING. AFTER I FOUND OUT WHAT THE PROBLEM WAS I CORRECTED THE CONNECTION AND STARTED THE CAR. THE CAR WOULD ONLY IDLE DUE TO A BLOWN FUSE, WHICH THE CAR DEALERSHIP HAD TO FIND. *TR

Mileage: 19,000