2023 TOYOTA RAV4 Unknown Or Other Problems

I purchased my 2023 Toyota RAV4 new back on March 13,2023. 10 days later on March 23 it was raining as I pulled into BJ’s parking lot, I parked and began fumbling around getting my bag and keys together when my car started shaking and sputtering eventually shutting down with an error message engine stopped steering power low. After a call to the salesman I was able to get my car restarted after 15minutes and many failed attempts. Car was bought back to service the following week and I was told car was not properly programmed at delivery, it was now programmed correctly and this should not happen again. April 17,2023 my son pulling into Tractor supply , raining out, pulls into spot and car again shakes, sputters and shuts off, same message engine stopped steering power low. After many attempts car restarts approximately 20 minutes later. Car serviced codes ARE FOUND and cleared, road tested and told car was ok. May 31,2025 I was driving down Rt 80, pouring rain when traffic comes to a complete stop due to accident ahead. Car starts shaking, sputtering and shuts down. Same message code as always. I turned the car completely off as not to kill battery and started to goggle the RAV4. I attempted to restart the car numerous times. Called for a tow, prayed that I didn’t get killed once traffic started to move. Finally 1-1/2 hours later it started. Traffic began moving 15 minutes after I got it started. Took in for service, charged $199.61 only to be told there were no codes. Problem could not be duplicated and in the future to always disable the start/stop button while using the vehicle. October30, 2025 raining, I stopped at Panera drive thru. Placed an order waiting in line and car shuts down, same error code, couldn’t restart car for 20 minutes. Took to Toyota November 5th same response no codes and cannot replicate issue, car is ok. Please help rectify this before someone gets killed!

We discovered severe mold contamination and water intrusion in our 2023 Toyota RAV4 Hybrid. My wife, our [XXX] child, and I have been experiencing dizziness and nausea for months whenever we were inside the vehicle, but we did not know the cause until the dealer (DLL) showed us extensive mold throughout the cabin and standing water trapped inside the vehicle. The dealer confirmed that this was not normal wear and tear. The mold has spread into the floors, interior panels, and even the steering components. This is a serious health hazard. After doing research, we found many other RAV4 Hybrid owners reporting similar water leaks and mold growth issues. This raises the concern of a potential design or sealing defect in this model. This vehicle is unsafe to drive, especially with a young child. We are requesting a full safety investigation into the water intrusion, sealing integrity, and air quality risks associated with this model. Symptoms:     •    Dizziness     •    Nausea     •    Headache     •    Strong mold smell     •    Corrosion of interior components This is a serious safety and health issue, and we are asking NHTSA to investigate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When driving, I occasionally hear a sloshing sound. After inspecting the vehicle, I realized it was coming from the rear passenger door of the RAV4. After putting down large bowls to catch the water, I pulled up on the rubber weather strip at the bottom of the rear passenger door and water gushed out. I collected over 13 cups of water out of the door. This is not an isolated incident, as it has happened before. At first I thought it was debris/a fluke that caused this water to accumulate, but after reading forums, there are multiple people out there running into the same issue. It's only ever been the rear passenger door too; none of the other doors are holding water.

I purchased a new 2023 Toyota RAV4 in March 2023, which is covered by Toyota’s 36-month/36,000-mile New Vehicle Limited Warranty. In August 2025, while the vehicle was still within warranty, a malfunction warning appeared for the pre-collision system and Road Sign Assist. The Toyota dealership diagnosed an internal failure of the forward recognition camera (DTC C1A95:00 — image processing module malfunction) and recommended replacement and calibration at a cost of approximately $2,300. Toyota denied warranty coverage despite the failure being internal to the part and occurring within the warranty period. I am seeking reimbursement for repair costs that should be covered under the manufacturer’s warranty.

I was driving yesterday when we suddenly heard a pop on the roof. We pulled over and noticed that the sunroof was broken, with the glass sticking outward, as if something from the inside had exploded outward. The dealership would not take ownership of the damage, therefore i had to use my insurance. upon inspection I was told that it was pressure from inside the vehicle that caused it to explode and that they have seen it before in Toyota RAV 4 models

For over month on multiple random events, the car shuts down while traveling at hwy speeds. The car light prompt to shift the vehicle into neutral and push the start button to re start the engine. We have had the car at the dealership 4 separate occasions and they can not find the issue because it does not cause an engine light to come on when this happens. They also supposedly can not get it to duplicate so they are refusing to go any further. We have video of this occurring at 50mph. This causes lost of steering and braking. We reported this to Toyota and opened a case. They to will not pursue fixing the issue as they are not getting a trouble code. I fear this is going to cause a major accident and this poses a severe safety risk as you loose control of the vehicle

Rear passenger door drain is not clearing water and is building up in door frame. Have to pull back bottom of door trim to get the water to clear

The issue is with the moonroof, which is part of the panoramic roof on the 2023 RAV4 hybrid driving down the freeway at highway speeds. The moon roof shattered. It sounded like a shotgun and it seemed to have broken and upward direction versus downward. There were no rocks from cars noticed in any vehicles in front of me to which could have caused this issue. If you’re looking at the photos all around the edge, there seems to be a seam on all four sides of the Glass giving away along with the hole protruding up.

While raining, noticed smoke coming from under the hood, engine seemed as if it didn’t have any power. Car shut off. While attempting to restart I seen a message in dashboard that said Engine stopped: steering power low. Took a while to get car cranked again after multiple attempts. Message in dashboard disappeared after multiple attempts to restart nor is there a message in remote application health status section.

The multimedia screen powers on and off consistently.

I drive through heavy rain for about 20 miles and I got to my mom’s house, put the car in park for about 5 minutes, when I get back in the car the car shut off when I put it in drive and was smoking. Now it will not crank up.

I went to start my car , the engine turned off stating power steering low engine off . Then tried again and got more errors likes brake engaged power off also the lane monitor was not working.

Car had error on dashboard of Engine stopped power steering low, car is available for inspection. Car would not start in the middle of the night while raining, had smoke coming out the front. Problem not reproduced at dealership. No other warnings were shown beforehand.

As I was driving on the highway, the glass of my sunroof imploded. There were no other cars around nor was there any people. It sounded as if something popped above my head. I researched this incident and apparently there are other RAV4 owners that had the same problem.

Leaving my house and around 20 ft away the soon roof burst. Nothing hit it, i live in a rural area, asphalt road. Now toyota dealer is saying that something hit the soon roof. I checked online and there are several incidents with the same model.

While driving at about 30 mph on [XXX] on Sunday, [XXX] at [XXX] the moonroof suddenly exploded. It sounded like a gunshot and startled me. I was not going under an overpass, there were no people nearby who would have thrown anything at the car, and I was not following another vehicle. I believe the glass shattered as result of mechanical defect. The moonroof was closed at the time so I was not hit with flying glass, but the situation could have been quite dangerous had the roof been open. I also think the loud sound of glass exploding could cause other motorists to jerk the wheel in shock at the loud noise. Naturally, there were shards of glass flying off my vehicle afterward, which creates something of a road hazard for anyone following behind. I have had the moonroof inspected by the Toyota dealer. They advise that glass is not covered under warranty, which is nonsense because at the least it violates the warranty of fitness for a particular purpose. But, it is hard to prove a manufacturer's defect so I will be submitting a claim through insurance. In my opnion, Toyota should cover the repair costs as I did nothing wrong and was not hit by a foreign object. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Sunroof glass blew out. Driving down road, no traffic, sounded like a shotgun blast. Pulled over and saw the sunroof had a hole and the rest was crystallized. Had the interior cover been pulled back we would have been showered with broken glass.

While making a slow right turn into a carport (1-2 mph), the vehicle suddenly accelerated on its own and crashed into the carport wall, continued to full throttle causing the tire to skip along side of the wall. The vehicle is currently not being used as we continue with the process with our insurance provider and begin to initiate contact with the car dealer. There were no warning lights or indications of a malfunctioning vehicle prior to that point. Initial online research provided at least 10 other reports that the exact same occurence happended to other 2023 RAV owners causing vehcile and property damage. We are fearful to use this vehicle now and would like to submit a safety report to prevent any similar instances in the future that may result in serious injury or death. NOTE: We also have video footage of the incident from our carport security camera, if you need that for further review.

While driving early in the morning on 95 without other traffic nearby, my moonroof exploded. There was no crack of a rock, only a very loud pop. The glass broke outward. I pushed it in to vacuum the pieces out in the picture attached

The incredibly frightening incident occurred 2 times within 3 days. My 2023 RAV unexpectedly and very forcibly accelerated on its own when I was pulling into a parking space. Luckily I am in the habit of parking my RAV far away from other vehicles in parking lots when the option exists. The first ‘acceleration and/or braking’ malfunction occurred 5/31/24 in a Walmart parking lot. When pulling into a parking spot my right foot was fully off the accelerator (I use my right foot only for the accelerator and brake pedals) and was gradually depressing the parking brake pedal to come to a complete stop. Instead my RAV suddenly and forcibly accelerated forward through the empty parking spot in front of me and beyond!! I would have absolutely smashed into the car and or person if one were there!! As the RAV shot forward I began desperately pushing full force on the brake pedal; the RAV did not stop! so, I began full force repeatedly pushing and pumping the brake pedal. My RAV eventually came to a halt as the tires may have locked up which it skidded about 12-18 inches. By God’s grace no one was hurt! On 6/2/24 ‘it’ happened again!! Pulling into a parking spot at an outdoor cafe, as I was gradually depressing the brake pedal to come to a complete stop my RAV instead quickly and forcibly accelerated forward!! I thank God that I did not pull into the other spot (my sister took that one) which was just a few feet away from around 12 people and families enjoying their outside lunch dining!!! This 2nd horrifying incident my RAV took longer to come to a complete stop. I fully and forcefully pushed on the brake pedal but my RAV kept going!! I continued repeatedly releasing and fully depressing the brake pedal but it kept going! The next thing my RAV was approaching was someone’s backyard and house!! I forcibly pushed the brake pedal one more time and also threw the RAV shifter into “park” finally the RAV stopped! I am so shaken up by these traumatic malfunction incidents.

Unintended sudden aggressive acceleration when I made a right as I was slowly pulling into a spot in the parking lot. Breast’s did not work fast enough and car ended up going up the hill and front colliding with it.

A car pulled out right infront of me at an intersection, I hit their back drivers side rear with most of the front of my car. I was doing approximately 41-45 mph. No airbags were deployed and my SOS button didn't work nor did it call for help.

Pre collision malfunction, RSA malfunction, LTA malfunction, Headlight malfunction. These warnings keep coming up showing the vehicle is not safe. Parts were ordered in February but are on back order. Might get by June. Vehicle has also rebooted the screens, tried to lane change, and failed to start once. To me this is a programming problem. This has been an on going problem for months now. The dealership claims that it is a wonky camera causing the problem.

While driving down the highway at the speed limit in our town on a clear evening with no weather, the sunroof of our 2023 Toyota RAV 4 exploded. There was a loud bang and it shattered as if the glass had been under significant stress or pressure. The glass bowed up in the middle and a section the size of a small saucer dropped out. There was a rigged break along the front edge of the sun roof. There were no bumps or holes in the road - it was smooth. There were no other vehicles nearby - no one threw a rock at our car. The noise was so loud that it was disruptive and shocking and thankfully I was not in heavy traffic or an accident might have occurred. I researched the web and found numerous instances of this sunroof explosion occurring. Please get Toyota to fix this before someone is serious injured.

Screen used for backup camera and radio was intermittently non-responsive. Issue has been seen/confirmed at the dealership. Safety concern is the failure/inaccessibility to the safety/visibility feature associated with the reverse camera. (Issue was intermittent upon ignition and remain non functional until vehicle would be powered off and back on again.)

The navigation system very frequently loses your location and begins jumping all over the place searching. I've been complaining to Toyota about since the day after I purchased my 2023 RAV4 Hybrid and at first they blamed my iPhone, then claimed they knew nothing about the problem, only after months of complaining do they now acknowledge that there is an issue and they are working to fix it. In addition to the navigation issues with the new head unit, it also no longer pauses or mutes music when reading text messages or dictating text messages. I previously had a 2019 RAV4 Hybrid and didn't have either of these issues. Now I am no longer able to handsfree listen to or respond to text messages and the navigation system is so faulty it is virtually useless.

The Media system is used prevalently to navigate in cities like Dallas and can be considered a crucial part of the car. However in all Toyotas this is a defective part and often disconnects while driving making it difficult and often unsafe due to the sudden interruptions especially when you are traveling at on highways or city streets.

I was coasting into a parking space (at 6.8 mph) and as I attempted to park, the car suddenly accelerated and went up and over the concrete rectangle park stop and smashed into a brick building (12.4 mph) and went back over the park stop before the engine in the vehicle finally died. During the acceleration, I was trying to brake the car, but the car wouldn’t stop. I was yelling to my husband that the car wouldn’t stop. The driver airbags deployed as well as the knee air bag. The passenger airbags did not deploy as there was not a passenger in the front seat. The car had 4258 miles and was totaled. My husband and I both sustained injuries. According to the Toyota app, the vehicle had a “0” rating for fast acceleration and a “1” rating for harsh braking during this particular trip. I contacted Toyota and an investigation was conducted using Bosch Crash Data Retrieval Tool 23.2.1. The data shows a 5 second timeframe with .50 second intervals. The vehicle speed at the 5 second mark was 6.8mph with 0% accelerator pedal. At 2 seconds, the speed was 5.0mph with 8.5% accelerator pedal. And, at the crash point the vehicle speed was 12.4mph with 100% accelerator pedal. Toyota product liability contacted me with their report stating that there was no brake pedal application prior to the impact and that pressure was applied to the accelerator pedal at wide open throttle seconds prior to the impact, and they found no obstructions or interference with the operation of the accelerator pedal. Further, they found the brakes to be operational However, the vehicle could not be test test driven as it would not turn on. In summary they did not find any evidence of an issue or defect with the vehicle based on inspection and electronic data.

As I was entering a covered parking structure, I came to a complete stop at the entrance of the gate to obtain my parking ticket. I was driving very slow less than 5 mph, and engaged the brakes as to stop to get my parking ticket before entering the parking garage. I have my foot on the brake pedal, I am at a complete stop of 0mph for several seconds now, and suddenly the engine revved and my car lunged forward a bit. I had not lifted my foot from the brake pedal, and yet the engine revved and my car lunged forwards. My passenger at the time yelled, WHOAA why are you pressing on the gas!!? So my passenger in the car at the time was also startled by this incident and felt the car surge forward. He thought that I had pressed on the gas pedal. If someone was to be in front of my vehicle they would have potentially been hit with my car, or if I had been closer to the parking entrance gate my car could have hit the gate. I am highly concerned this just occurred as this could cause a great accident or injury. I have 1,100 miles on the car. It was purchased brand new. Another issue I have been experiencing is when I engage the gas pedal, it does not accelerate and takes a few seconds to accelerate causing my forward momentum to stall out, this is an issue when I have been trying to merge into traffic and my car does not drive as I have anticipated. I am not sure if this is an issue with it being in "ECO" mode or not, but there is a stalled acceleration issue, that happens sometimes, but not always and I cannot pin point why it is happening at certain moments.

Driver side and passenger side mirror, as well as rearview mirror vibrate. Driver, side mirror, and rearview mirror are the worst with the passenger rear view mirror better than the other two. Brought into Toyota of Dothan couple of times, and they say it’s normal. This is not normal. It is a safety hazard. It started on day one that I own the car, which was July 3, 2023. There is known problems with previous models, as well as with the Lexus NX and RX models, which is based off of Toyota. This needs to be addressed and fixed. There were previous announcements made for 2019 year I believe of the RAV4, but there still is a problem with the 2023 models.

When the AC is turned on, the AC is not blowing cold AC air. Have turned on the AC to the lowest temperature setting, turned the fan to high, activated the circulation button and it’s only blowing room temperature/warm air. Have tried different combinations of the settings and the AC quality is still only blowing room temperature/warm air. Have driven car to hotter temperature areas and the AC, at this point, is blowing warm/hot air.

When using an Apple iPhone 12 connected to the vehicle's head unit with CarPlay, and when using any navigation application (Apple Maps, Waze, Google Maps), the car's GPS position on the map randomly becomes extremely inaccurate. The car's map cursor suddenly jumps to a different road than the one the vehicle is on, heads in the wrong direction, or circles wildly. If using the GPS application for directions, the directions suddenly become incorrect. The issue never occurs when the iPhone is not connected to the vehicle's CarPlay display. This is a safety issue because it is extremely distracting or dangerous if the driver is using the GPS application for navigation and is directed to the wrong road or becomes lost in an unknown area due to failure of the navigation application on CarPlay.

For the last six months our vehicle has had it's infotainment system malfunction. It shuts off unexpectedly while driving or stopped. It shuts off and on repeatedly as if car is turning on and off. The bright warning sign will show and proceed to act normal then again 5-10 seconds later it shuts off again. This issue happens with and without a phone connected to it via bluetooth. While screen off the rear view camera does not work and nothing else is operable within the screen/ infotainment system. We've brough car to dealership three times in six months.

Panoramic sunroof. First one is fine, back one exploded. All around the edges is a very distinct crack in a connected line. There was minimal traffic, and I was the only other vehicle on the interstate with a good 4 car length between me and the next car which was 2 lanes over. I didn’t see or hear anything other than the “gunshot” sounding explosion. No wind or hail or anything, skies were clear, I was going about 60 on the interstate. It freaked me out. Luckily, I did not swerve or change my driving (slam on brakes etc), but with another person driving, this could have caused an accident. Toyota claims it was a piece of debris or rock that hit it so they say it is not under warranty. $14k repair price which is almost a quarter of what I am paying for the vehicle. Waiting to see if my insurance covers it.