2004 TOYOTA SEQUOIA Structure Problems

Rust! Frame completely rusted, even though the CRC was applied back in 2013.

The contact owns a 2004 Toyota Sequoia. The contact stated that while completing an inspection and emissions test on the vehicle, the mechanic informed the contact that there was severe rust on the rear subframe of the vehicle, near the control arm, and several other areas on the subframe. The contact stated that there were several holes on the subframe caused by the extreme rust. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 203,000.

Mileage: 203,000

See attached document for complaint.

See attached document for complaint.

TOYOTA frame is falling apart due to the use of faulty metal to manufacture those frames they ran a limited service campaign to replace some of the frames and they denied many other owners that right please help by telling TOYOTA North America to take care of this very hazardous issue thank you

The undercarriage is rotten you help my thanks

The frame is rusting away due to poor grade of metal that it is built from.

SIGNIFICANT FRAME RUST IN THE REAR LEFT AND RIGHT

Mileage: 100,000

FRAME RUSTED THROUGH

Mileage: 100,000

REAR HATCH DOOR WOULD NOT CLOSE. HANDLE FAILED DEALER REPLACE LOCK SUB ASSY AND HANDLE ASSY.

Mileage: 81,840

FOR THE SECOND TIME IN 4 YEARS FIRST FAILED IN 2010., REAR HATCH DOOR WOULD NOT CLOSE. HANDLE FAILED DEALER REPLACED LOCK SUB ASSY AND HANDLE ASSY.

Mileage: 134,444

REAR HATCH DOOR WOULD NOT OPEN. HANDLE FAILED DEALER REPLACE LOCK SUB ASSY AND HANDLE ASSY. THIRD FAILURE IN 8 YEARS, 2010, 2014 AND 2018. PARTS ARE FAILING ABOUT EVERY 4 YEARS. OWNED CAR 6 YEARS BEFORE FIRST FAILURE.

Mileage: 214,792

REAR HATCH DOOR WOULD NOT OPEN DEALER HAS REPLACED LOCK SUB ASSY AND HANDLE ASSY 3 TIMES IN THE PAST 10 YEARS. THIS IS THE FOURTH FAILURE LATCH HAS, 2010, 2014, 2018 AND 2021. THE FIRST THREE FAILURES OCCURRED ABOUT EVERY 4 YEARS THE CURRENT FAILURE WAS 2 YEARS AND 3 MONTHS. OWNED. CAR 6 YEARS BEFORE FIRST FAILURE.

Mileage: 250,600

MY 2004 TOYOTA SEQUOIA HATCH (LOCK SUS ASSY AND HANDLE ASSY) HAVE FAILED AND BEEN REPLACED ON TWO OCCASIONS. ON 10 JULY 2014 AND 23 NOVEMBER 2018 EACH WERE COSTLY REPAIRS FOR A SIMPLE HANDLE/LOCK THAT WERE POORLY DESIGNED. A DOOR HANDLE AND LOCK SHOULD NOT COST OVER ONE THOUSAND DOLLARS DURING THE LIFE OF THE VEHICLE. AS THE ORIGINAL OWNER AND A LOYAL TOYOTA CUSTOMER I AM DISAPPOINTED WITH QUALITY OF SMALL PART REPLACEMENT JOBS I HAVE HAD TO COMPLETE TO MAINTAIN MY VEHICLE. HATCH DOOR FAILED WITH NO WARNING OR PREVIOUS PROBLEMS SUMMER AND WINTER CONDITIONS.

Mileage: 52,482

MY 2004 TOYOTA SEQUOIA HATCH (LOCK SUS ASSY AND HANDLE ASSY) HAVE FAILED AND BEEN REPLACED ON TWO OCCASIONS. ON 10 JULY 2014 AND 23 NOVEMBER 2018 EACH WERE COSTLY REPAIRS FOR A SIMPLE HANDLE/LOCK THAT WERE POORLY DESIGNED. A DOOR HANDLE AND LOCK SHOULD NOT COST OVER ONE THOUSAND DOLLARS DURING THE LIFE OF THE VEHICLE. AS THE ORIGINAL OWNER AND A LOYAL TOYOTA CUSTOMER I AM DISAPPOINTED WITH QUALITY OF SMALL PART REPLACEMENT JOBS I HAVE HAD TO COMPLETE TO MAINTAIN MY VEHICLE. HATCH DOOR FAILED WITH NO WARNING OR PREVIOUS PROBLEMS SUMMER AND WINTER CONDITIONS.

Mileage: 134,444

TOOK 2004 SEQUOIA TO KINGS TOYOTA FOR THE AIRBAG RECALL AS WELL AS DIAGNOSTIC EVAL OF VSC ABS LIGHTS ISSUE. RECEIVED A PHONE CALL THAT THE TECH COULD NOT DETERMINE THE ELECTRICAL PROBLEM UNLESS WE PAID AN ADDITIONAL $360 FOR MORE TIME TO DIAGNOSE AND THAT THE FRAME WAS RUSTED THROUGH WITH LARGE HOLES. WONDERED IF WE WANTED TO PURSUE THE ELECTRICAL ISSUE WITH THE LARGER SAFETY ISSUE WITH THE FRAME. ORIGINAL ISSUE OCCURRED WITH LIGHTS COMING ON (HAD HAPPENED SEVERAL TIMES PREVIOUSLY) FOLLOWED BY THE POWER WINDOWS CEASING TO WORK, SEVERAL HOURS LATER THE WIPERS AND WINDOW SEEMED SLUGGISH AND THE CAR LOST ALL POWER. HAD TO JUMP THE CAR SEVERAL TIMES TO GET OFF THE ROAD AND THEN WHEN JUMPING NO LONGER WORKED, WE HAD TO PUSH THE VEHICLE INTO A CHURCH PARKING LOT. AFTER BEING TOLD BY MR. HOWARD THAT THEY DON'T SEE VEHICLES COME INTO SERVICE WITH LARGE HOLES IN THE FRAME, I RESEARCHED ONLINE AND FOUND THAT 10S OF THOUSANDS OF TOYOTA TRUCKS, INCLUDING 05-08 SEQUOIAS, HAVE BEEN RECALLED - CRC APPLIED AND FRAMES REPLACED AS WELL AS TOYOTA BUYING BACK 95-00 TRUCKS WITH RUSTED FRAMES FOR 1.5 TIMES THE BLUE BOOK VALUE. 04 SEQUOIAS MENTIONED MORE THAN 300 TIMES FOR THE VSC, TAILGATE AND RUSTED FRAME ISSUES THAT ARE PREVALENT IN THIS MODEL - MY VEHICLE HAS ALL 3. SPOKE WITH COLIN, THE SERVICE MANAGER, WHO REITERATED WHAT I FOUND ONLINE. TOYOTA WILL DO NOTHING SINCE THE RECALL IS CLOSED AND DID NOT INCLUDE THE 04 MODELS.

Mileage: 187,000

FRAME HAS RUST HOLES AND THE STEERING STABILIZER MOUNT RUSTED COMPLETELY OFF. VERY UNSAFE ! THE REST OF THE CAR IS IN EXCELLENT CONDITION SO THE SEVERITY OF RUST ON THE FRAME SEEMS VERY OUT OF PLACE. THIS ISSUE IS EXTREME AND NOT NORMAL. NOT ACCEPTABLE FROM A MANUFACTURER KNOWN FOR ITS QUALITY SYSTEMS. TPS SIX SIGMA EMBARRASMENT IN MY OPINION

FUEL GAUGE NOT MEASURING FUEL PROPERLY. AFTER A FULL TANK, GAUGE INDICATES EMPTY TANK AFTER FEW DAYS. SPEEDOMETER NOT WORKING AND ENGINE LOSES POWER FOR A WHILE WHILE THE GAUGE GOES TO 100 MILES ON THE HIGHWAY AND GOES BACK TO ZERO AND RESTORES POWER TO THE ENGINE. THE VEHICLE HAS ONLY 145,000 MILES ON IT. ALSO RUST ON THE BODY FRAME .

Mileage: 145,000

OUR 2004 TOYOTA SEQUOIA HAS EXTENSIVE RUST ON THE FRAME OF THE CAR THAT HAS MADE IT UNSAFE TO OPERATE. WE UNDERSTAND THAT TOYOTA USED POOR QUALITY STEEL TO MAKE THE FRAME. WE HAVE CONTACTED TOYOTA, WHICH HAS REFUSED TO FIX OR REPLACE THE FRAME BECAUSE WE MISSED THE JULY 31 2014 DEADLINE. WE KNOW THAT THERE IS A RECALL FOR 2005-08 MODELS AND THE 2004 MODEL SHOULD BE INCLUDED AS WELL. WE WANT THE FRAME TO BE REPLACED. THE REST OF THE CAR IS IN GOOD WORKING CONDITION.

I WAS CHECKING EVERYTHING ON MY VEHICLE OVER BEFORE I WENT FOR INSPECTION AND I NOTICED RUST CORROSION STARTING ON THE FRAME. I TOOK TO A FRIEND TO CHECK FOR ME AND THEY TOLD ME THAT THERE WAS A SAFETY ISSUE WITH THE FRAMES AND THERE WAS A RECALL OF SORTS BACK IN 2012 REGARDING THE FRAMES WERE NOT COATED CORRECTLY FOR THE COLDER STATES. I HAD HEARD ABOUT THIS WARRANTY ISSUE BEFORE BUT WAS NEVER NOTIFIED. MY BROTHER IN LAW TOLD ME TO CHECK IT OUT BACK IN 2016 WHEN THERE WAS A RECALL ON THE AIRBAG/STEERING COMPONENT. I WAS TOLD AT THAT TIME THAT THE RECALL/ WARRANTY ISSUE HAD EXPIRED AND NOTHING COULD BE DONE. I HAVE NOT NOTICED ANY RUST UNTIL THIS YEAR. THIS VEHICLE DOES NOT GO OFF ROAD AND IS ONLY DRIVEN ON PAVED ROADS. I CALLED TOYOTA USA ON 7/24/2019 AND EXPLAINED TO THEM THE SITUATION. ONE OF THE LADIES FELT CONFIDENT THAT I COULD BE HELPED. THEN WHEN I WAS TRANSFERRED TO A LADY NAMED ASHLEY, SHE INFORMED ME THAT THERE WAS NOTHING THEY COULD DO. SHE TOLD ME THAT THE WARRANTY ISSUE WAS SENT TO THE ORIGINAL OWNER IN JUNE OF 2012 AND THEY DID NOT RESPOND. THEY PROBABLY DID NOT RESPOND SEEING HOW I HAVE BEEN THE OWNER OF THIS VEHICLE SINCE 1/26/2012. I WAS THEN TOLD THAT SINCE I DO NOT TAKE IT TO A CERTIFIED TOYOTA SERVICE CENTER TO HAVE MY REGULAR MAINTENANCE DONE THAT THERE WAS STILL NOTHING THEY CAN DO. I SHOULD HAVE THE RIGHT TO TAKE MY VEHICLE WHERE I WANT WITHOUT THE MANUFACTURER DECIDING TO HONOR A WARRANTY BASED ON THE FACT THAT I GO TO ONE OF THEIR SERVICE CENTERS. I WOULD HAVE TAKEN MY VEHICLE DURING THE CORRECT DATES TO HAVE THE COATING PUT ON MY VEHICLE IF THEY WOULD HAVE SENT ME THE NOTICE AND NOT TO THE ORIGINAL OWNER. ESPECIALLY SINCE I WAS THE OWNER OF THE VEHICLE FOR 5 MONTHS WHEN THEY SENT OUT THE WARRANTY NOTICE BUT THEY SENT IT TO THE WRONG OWNER. I FEEL THAT TOYOTA SHOULD TAKE CARE OF THIS ISSUE.

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. WHILE THE VEHICLE'S OIL WAS BEING CHANGED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT THE FRONT SWAY BAR BRACKET WAS ROTTED OUT. THE VEHICLE WAS TAKEN TO IRA TOYOTA OF TEWKSBURY (LOCATED AT 468 MAIN ST, TEWKSBURY, MA 01876, (978) 863-9009) WHERE IT WAS DIAGNOSED THAT THE ENTIRE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 219,000.

Mileage: 219,000

THE BOTTOM PART OF THE TUBE FRAME IS RUSTED THROUGH. WHEN I WENT TO LIFT IT UP TO CHECK A LEAKING POWER STEERING FLUID LINE, THE JACK WENT THROUGH THE BOTTOM OF THE FRAME.

Mileage: 178,865

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE REAR FRAME ON THE VEHICLE WAS RUSTED. THE VEHICLE WAS TAKEN TO TOYOTA OF CEDAR PARK (LOCATED AT 5600 183A, LEANDER, TX 78641, (512) 379-7575) WHERE THE CONTACT WAS NOTIFIED THAT AN UNKNOWN RECALL PERTAINING TO THE VEHICLE BODY HAD EXPIRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 219,000.

Mileage: 219,000

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE VEERED UNCONTROLLABLY FROM LEFT TO RIGHT. THE CONTACT WAS ABLE TO MOVE THE VEHICLE OFF THE ROADWAY SAFELY. THE CONTACT ALSO STATED THAT THE REAR TRAILING ARM FRACTURED DUE TO EXCESSIVE CORROSION. THE SUBFRAME WAS SPRAYED PER AN UNKNOWN SERVICE CAMPAIGN, BUT IT DID NOT PREVENT THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE SUBFRAME WAS PLATE WELDED. TOYOTA OF SMITHFIELD (LOCATED AT 550 GEORGE WASHINGTON HWY, SMITHFIELD, RI 02917, (401) 723-0972) WAS CONTACTED AND REFERRED THE CONTACT TO THE MANUFACTURER. THE CONTACT WAS INFORMED THAT THE SERVICE CAMPAIGN HAD EXPIRED AND NO FURTHER ASSISTANCE WOULD BE OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 210,000. THE VIN WAS NOT AVAILABLE.

Mileage: 210,000

TOYOTA SEQUOIA WITH 139K MILES. THIS SUV HAD A FRAME RECALL IN 2014, TOYOTA DEALER APPLIED THE PAINT/EPOXY TO THE RUSTED FRAME INSTEAD OF REPLACING THE RUSTED FRAME. THE PAINT PEELED OFF WITHIN 6 MONTHS OF THE APPLICATION. NOW THE FRAME IS RUSTED VERY BADLY. WHEN DRIVING IT MAKES GRINDING NOISES. MY MECHANIC SAID THAT BECAUSE OF EXTENSIVE FRAME RUST, THE FRAME HAS GOTTEN WEAKER AND IS SLIGHTLY BENT. THIS MAKES THE MOVING PARTS TOUCH THE OTHER PARTS OF THE BODY/FRAME RESULTING IN THE NOISES. HE SUGGESTED REPLACING THE RUSTED FRAME.

Mileage: 139,000

I PURCHASED A TOP OF THE LINE '04 TOYOTA SEQUOIA IN JANUARY OF THIS YEAR FOR ALMOST 9K. IT HAS LESS THAN 110K MILES ON IT AND IN PRISTINE CONDITION. WE TOOK IT TO THE SHOP IN AUGUST BECAUSE WE THOUGHT IT NEEDED A FRONT END ALIGNMENT. NOPE! THIS WAS THE FRAME THAT WAS RECALLED UNDER THE TUNDRA TRUCKS FOR RUSTING OUT BECAUSE THE FRAMES WERE NOT BUILT CORRECTLY. NO WHERE IN MY RESEARCH DID THE RECALL MENTION THE SEQUOIAS. THE FRAME IS RUSTED SO BADLY THAT IT ISN'T EVEN SAFE FOR ME TO DRIVE. I HAVE BEEN TO KERRY TOYOTA IN FLORENCE KY, AND SPOKE WITH SEVERAL DIFFERENT PEOPLE AND KEEP BEING TOLD THERE IS NOTHING YOU TOYOTA CAN DO ABOUT IT BECAUSE THE PREVIOUS OWNER DIDN'T TAKE IT IN WHEN THE RECALL WAS ACTIVE AND HAVE THE SPECIAL SPRAY COATING SPRAYED ON TO THE FRAME. THIS IS ABSOLUTELY OUTRAGEOUS. YOU HAD A RECALL ON THESE FRAMES AND DIDN'T INCLUDE THE SEQUOIA MODEL NAME AND TOYOTA KNEW THESE FRAMES WOULD BECOME DANGEROUS AND DETRIMENTAL TO THE LIFE OF THE CAR. THIS ISN'T A FEW HUNDRED DOLLAR FIX WHICH WE COULD DEAL WITH, IT'S 7 THOUSAND OR MORE DOLLARS FIX AFTER I PAID ALMOST 9K FOR A CAR THAT HAD LESS THAN 110K MILES AND IS OTHERWISE IN PERFECT CONDITION. WHEN WE PURCHASED THE CAR YOU COULDN'T TELL THAT THE FRAME WAS RUSTED SO BAD BECAUSE SOMEONE HAD SPRAYED UNDERCOATING ALL OVER THE FRAME. THIS CAR AND THE CONDITION IT IS IN MINUS THE FRAME SHOULD LAST ANOTHER 200K MILES OR MORE. I HAVE NO CHOICE BUT TO CONTINUE TO DRIVE IT, I SPENT ALL THAT MONEY ON IT AND I CAN NOT BELIEVE THAT WITH EVERYONE WE HAVE SPOKEN TO NO ONE WANTS TO MAKE THIS RIGHT ESPECIALLY BECAUSE YOUR COMPANY KNEW HOW DETRIMENTAL AND DANGEROUS THIS FRAME IS, AND HERE I AM DRIVING MY CHILDREN AROUND IN IT. IT IS ATE UP WITH RUST SO BAD THAT IT CAN'T EVEN BE WELDED.

Mileage: 110,000

THE REAR DRIVERS FRAME SNAPPED IN HALF. BROKE IN FRONT OF REAR WHEEL. NO HELP FROM TOYOTA. SO IT SITS IN DRIVEWAY. RUMOR HAS IT A RECALL IS ON WAY.

UNDERCARRIAGE IS RUSTED, DCH TOYOTA NEW BRUNSWICK TECHNICIAN CONFIRMED THAT THE SEALANT THEY USED DID NOT PREVENT THE PROBLEM FROM OCCURRING. AND NOW THE VEHICLE IS NOT ROAD SAFE. BUT THEY DO NOT WANT TO MAKE THE REPAIR THAT THEY SHOULD HAVE DONE ORIGINALLY. STRANGE, THOUGH, IS THAT THEY FIXED THE SAME YEAR TUNDRA THAT HAS THE SAME FRAME AND UNDER CARRIAGE.

Mileage: 118,000

AT ON OR ABOUT 7:30 PM ON MAY13TH 2018 OUR SON WAS DRIVING THE FAMILIES 2004 TOYOTA SEQUOIA NORTHBOUND IN 2 LANE DIVIDED HIGHWAY AND NO OTHER TRAFFIC PRESENT. WEATHER WAS INCLEMENT, VISIBILITY CLEAR BUT NOTHING OUT OF THE ORDINARY FOR FLORIDA. HE WAS TRAVELING 41 MPH IN A 45 IN THE LEFT LANE. NO SOONER THAN HE WENT THROUGH THE INTERSECTION TRAFFIC LIGHT CONTROLLED, (HE HAD THE RIGHT OF WAY) DID HE GO THROUGH WHAT THE DEPUTY SAID WAS A SLIPPERY SECTION OF THE ROAD WAY COVERED WITH STANDING WATER. HE RELEASED PRESSURE ON THE ACCELERATOR TO DIMINISH HYDROPLANING AND NO SOONER THAN THAT INSTANT THE VSC LIGHTS (VARIABLE SPEED CONTROL) LIGHTS ILLUMINATED IN THE DASH. HE REPORTED THAT THE RIGHT FRONT WHEEL LOCKED UP AND CREATED A PIVOT POINT FOR THE CAR TO SPIN AROUND 180 DEGREES CLOCKWISE, NOW FACING ONCOMING TRAFFIC AS HE WAS NOW IN THE RIGHT LANE. HE WAS FRANTICALLY ATTEMPTING TO REGAIN CONTROL OVER THE VEHICLE BY CONSTANTLY DEPRESSING THE BRAKES IN ORDER TO STOP THE VEHICLES MOTION HOWEVER UNSUCCESSFUL AS HE WAS PRESSING ON THE BRAKING PEDAL WITH NO RESPONSE, THE CAR NOW STILL IN MOTION, HIT THE CURB, AND LEFT THE ROADWAY BY GOING NOW BACKWARDS DOWN A STEEP EMBANKMENT OF OVER 12 FEET AND CAME TO A HALT. LUCKILY, A SHERIFFS DEPUTY WAS TRAVELING IN THE OPPOSITE DIRECTION AND HAD WITNESSED THIS AND WAS ABLE TO SAVE MY SONS LIFE BY HIS QUICK RESPONSE. THE CAR HAD TO BE EXTRACTED OUT OF THE CULVERT WITH RECOVERY CRANES. OUR FAMILY IS SO GRATEFUL TO THE DEPUTY AND THAT WE HAVE OUR SON ALIVE AND WITHOUT A SCRATCH. HE IS A BIT WORN FOR WEAR BEING SHOOK UP LIKE THAT. THE SEQUOIA HAS ALWAYS BEEN SERVICED BY TOYOTA AND WE ENJOYED YEARS OF TROUBLE-FREE OWNERSHIP UNTIL THIS INCIDENT.

Mileage: 145,350

RUST, RUST, RUST. I CAN SEE THROUGH THE LEFT SIDE REAR WHEEL WELL. IT'S EMBARRASSING WHEN I OPEN THE DOOR LOOKS LIKE SOMETHING IS MISSING. HEY PART OF DOOR AND WHEEL WELL IS GONE. HATE THINKING ABOUT WHAT ELSE IS MISSING, BECAUSE IT RUSTED AWAY. ORIGINAL OWNER.

REAR HATCH HANDLE HARD TO OPEN AND DOES NOT CLOSE AT TIMES. IT'S BEEN REPLACED ONCE SIMULAR SMYPTOMS BEFORE IT BROKE. ORGINAL OWNER.

REAR HATCH HANDLE HARD TO OPEN AND DOES NOT CLOSE AT TIMES. IT'S BEEN REPLACED ONCE SIMULAR SMYPTOMS BEFORE IT BROKE. ORGINAL OWNER.

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEERING WHEEL BEGAN TO SHAKE VIOLENTLY. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE VEHICLE WAS DRIVEN TO THE CONTACT'S HOME WHERE SHE NOTICED THAT THE FRAME WAS RUSTED. THE DEALER (ELGIN TOYOTA, 1600 W LAKE ST, STREAMWOOD, IL 60107) INFORMED THE CONTACT TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT HAD THE WARRANTY ENHANCEMENT PERFORMED ON THE FRAME IN 2014. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS 177,000.

Mileage: 177,000

THE FRAME IS RUSTED THROUGH IN LARGE, WEIGHT-BEARING AREAS. SOME OF THE HOLES ARE 3 INCHES OR MORE IN DIAMETER. I HAVE BEEN TOLD IT IS DANGEROUS TO DRIVE. TOYOTA HAD A RUST PROOFING RECALL AROUND 2012. THEY SPRAYED SOME TAR-LIKE MATERIAL ON IT WHICH DID NO GOOD. I AM THE ORIGINAL OWNER AND HAVE TAKEN GOOD CARE OF THE VEHICLE. THIS FRAME IS EVERY BIT AS BAD AS ALL THE SEQUOIA FRAMES TOYOTA RECALLED AND REPLACED FROM MODEL YEAR 2005 ON. I DESERVE THE SAME TREATMENT AS THE LATER OWNERS WITH THEIR RUSTED FRAMES. LESS IMPORTANT BUT ANNOYING IS THE RUST ON THE BODY OVER THE LEFT READ WHEELWELL WHICH IS GLARINGLY OBVIOUS WHEN A PASSENGER OPENS THAT DOOR. YOU CAN SEE RIGHT THROUGH THAT PART OF THE BODY. IT HAPPENED WITHIN A FEW YEARS OF PURCHASE.

RUST IN FRAME VEHICLE IS NOT SAFE TO DRIVE I OWN THIS VEHICLE FOR AROUND 10 YEARS NEVER RECEIVE A LETTER FROM TOYOTA ABOUT THE WARRANTY ENHANCEMENT

Mileage: 100,000

TL* THE CONTACT'S FRIEND OWNS A 2004 TOYOTA SEQUOIA. WHILE THE VEHICLE WAS TAKEN TO AN INSPECTION STATION, THE CONTACT'S FRIEND WAS INFORMED BY THE INSPECTOR THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

REAR HATCH HANDLE BREAKS PROBABLY DUE TO FAULTY DESIGN OF HANDLE, CABLE AND LATCH. FALURE HAPPENS WHEN OPENING REAR HATCH. VEHICLE STATIONARY. IF HANDLE BREAKS YOU ARE UNABLE TO ACCESS THE SPARE TIRE DUE TO WHERE THE CRANK MECANISM THAT LOWERS SPARE TIRE IS LOCATED. CLOSED DOOR HATCH BLOCKS ACCESS TO CRANK. NO OTHER ACCESS TO CRANK. ON THIS VEHICLE HANDLE HAS BROKEN 3 TIMES. ON OUR 2005 SEQUOIA IT HAS BROKEN 4 TIMES. TOYOTA PLASTIC HANDLE IS OBVIOUSLY WEEK SINCE IT BREAKS IN THE SAME SPOT EVERY TIME AT A REPLACEMENT COST AT THE DEALER OF $600.00 TO $850.00 EACH OCCASION. I AM UNABLE TO PROVIDE PICTURES AS THE BROKEN PARTS WERE DISPOSED OF.

Mileage: 154,000

VEHICLE HAS LARGE HOLES IN FRAME ON LH SIDE AND BOTTOM EXTENDING NEXT TO BODY MOUNT . NEEDS TOYOTA TO REPLACE FRAME HAVE PLATED IT BUT NOT SURE HOW LONG IT WILL LAST

Mileage: 175,000

THE FRAME OF THE VEHICLE HAS COMPLETELY RUSTED THROUGH. THERE ARE LARGE HOLES IN THE FRAME WHERE THE SWAY BAR CONNECTS TO THE FRAME

Mileage: 135,000

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE CONTACT NOTICED THAT THE FRONT FRAME FRACTURED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER (RUDY LUTHER TOYOTA, 8805 WAYZATA BLVD, GOLDEN VALLEY, MN 55426; (612) 424-7924) AND THE CONTACT WAS ADVISED TO CALL THE MANUFACTURER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-331-4331 AND STATED THAT NOTHING COULD BE DONE. THE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

MY FAMILY CAR IS CURRENTLY A 2004 TOYOTA SEQUOIA WITH 161,000 MILES. RECENTLY I BROUGHT IT TO THE LOCAL DEALERSHIP WHERE I WAS INFORMED THE FRAME WAS ROTTED SIGNIFICANTLY AND MAY BE HAZARDOUS TO DRIVE. I THEN CALLED TOYOTA CUSTOMER SERVICE AND WAS INFORMED THAT MY PARTICULAR MODEL IS NOT INCLUDED IN THEIR VERY LARGE AND EXPENSIVE DEFECTIVE FRAME RECALL.THE LOCAL DEALERSHIP CONCLUDED THAT THE FRAME IS INDEED DEFECTIVE, BUT UNTIL TOYOTA MOTOR CORP. ADMITS THERE IS A PROBLEM, I WILL BE FORCED TO USE A POTENTIALLY UNSAFE VEHICLE AS WE AREN'T ABLE TO AFFORD A REPLACEMENT AT THIS TIME. THANK YOU FOR YOUR CONSIDERATION.

Mileage: 161,000

TOYOTA SEQUOIA 2004 FRAME DEGRADATION TO POINT OF UNSAFE. FRONT-PASSENGER SIDE FRAME WHERE STABILIZER BAR IS WELDED TO FRAME HAS RUSTED THROUGH, LEAVING A LARGE HOLE AND DISCONNECTING THE STABILIZER BAR FROM THE FRAME. KNOWN ISSUES BY TOYOTA. AS FRAMES WERE INSPECTED BY SERVICE CENTERS. FRAME "PASSED". ISSUES WAS NOTICED DURING NORMAL INSPECTION - VEHICLE OPERATED WITHIN ORIGINATING INTENT AND PURPOSE. NORMAL DRIVING. TOYOTA SERVICE CENTER SUGGESTS A $12,000 FRAME REPLACEMENT TO FIX PROBLEM.

Mileage: 120,000

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. WHILE JACKING UP THE VEHICLE TO CHANGE THE REAR DRIVER'S SIDE TIRE, THE JACK WENT THROUGH THE FRAME AND CREATED A VISIBLE HOLE AND CRACK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRAME WAS RUSTED. THE FRAME WAS NOT REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,800.

Mileage: 150,800

I BOUGHT THIS VEHICLE NEW AND HAVE MAINTAINED IT IN ACCORDANCE WITH MANUFACTURER SPECIFICATIONS. ADDITIONALLY, THIS PARTICULAR VEHICLE IS GARAGE KEPT SO IT IS NOT SUBJECT TO WEATHER ROUTINELY. THE REAR LIFT GATE LATCHING MECHANISM HAS FAILED ON MY VEHICLE 4 TIMES. THIS IS A VERY COMMON PROBLEM WITH TOYOTA SEQUOIA VEHICLES. BOTH OF MY LOCAL DEALERS STATE IT IS A VERY COMMON PROBLEM. THIS TIME THE CABLE JUST "SNAPPED". IT FAILED WHILE I WAS AT A GAS STATION AND NEEDED TO OPEN THE HATCH. IT HAS BEEN REPAIRED/REPLACED TWICE IN THE LAST FEW YEARS, BUT CONTINUES TO FAIL. A SIMPLE SEARCH ON GOOGLE WILL SHOW TENS OF THOUSANDS OF THESE VEHICLES WITH THE SAME PROBLEM. IT IS A SAFETY PROBLEM BECAUSE IT FAILS WITHOUT NOTICE AND WHEN IT DOES IT ELIMINATES A MEANS OF EGRESS FROM THE VEHICLE IN THE CASE OF AN ACCIDENT. TOYOTA MOTOR SALES HAS IN THE LAST FEW YEARS BEEN IN THE MEDIA MULTIPLE TIMES FOR "NOT DOING THE RIGHT THING" WHEN THEIR VEHICLES HAVE DESIGN FLAWS. THIS IS JUST ONE MORE CASE. THE FOLLOWING WEBSITE DOCUMENTS MANY OWNERS PROBLEM WITH THE SAME PROBLEM OF THE LIFT GATE LATCH FAILING. HTTP://PROBLEMTOYOTA.COM/TAG/LATCHES-LOCKS-LINKAGES/PAGE/6/ THIS IS NOT AN ITEM THAT SHOULD FAIL AS OFTEN AS IT DOES. SIMPLE FAILURES OF BEARINGS, BRAKES... CAN BE EXPECTED BUT THIS IS A DESIGN FLAW AND IT IS DANGEROUS. TOYOTA SHOULD ISSUE A RECALL AND FIX THIS ITEM.

Mileage: 184,879

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE VEHICLE FAILED STATE INSPECTION. THE CONTACT WAS INFORMED THAT THERE WAS SEVERE CORROSION TO THE SUBFRAME OF THE VEHICLE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE AND SHOULD NOT BE DRIVEN. THE CONTACT ALSO STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,561.

Mileage: 108,561

FRAME IS RUSTING UNDERNEAYH TO THE POINT WHERE I HAVE HAD TO REPAIR THE VEHICLE CONTROL ARM WHICH RUSTED OFF AND BROKE WHILE DRIVING. MY TOW HITCH MOUNT HAS RUSTED OFF. THERE ARE MORE THAN 5 SPOTS ALONG THE FRAME WHERE RUST HAS PERFORATED AND THE FRAME HAS VISIBLE SIGNS OF ROT. I HAD A LICENSED GARAGE INSPECT THE FRAME AND WAS TOLD THE VEHICLE IS DANGEROUS AND THAT THE FRAME SHOULD BE REPLACED. I AM HAVING CONTINUOUS PROBLEMS WITH THE SUSPENSION COMPONENTS RUSTING OUT.

Mileage: 162,000

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE TECHNICIAN STATED THAT THE FRAME WAS SEVERELY RUSTED. THE VEHICLE WAS UNSAFE TO BE DRIVEN AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION). THE FAILURE MILEAGE WAS 138,000.

Mileage: 138,000

TOTALLY RUSTED FRAME. UNSAFE TO DRIVE. NEVER RECEIVED A NOTICE TO REPLACE A FRAME. CAMPAIGN ENDED ON JULY 2014 . NOW I STUCK WITH UNSAFE VEHICLE WHICH STILL HAS OVER 100,000 MILES TO DRIVE. THERE SUPPOSE TO BE ANOTHER ACTION TO REPLACE THE FRAME.

Mileage: 128,000

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE VEHICLE COULD NOT BE INSPECTED DUE TO EXCESSIVE RUST ON THE FRAME. THE CONTACT CALLED A LOCAL DEALER WHO REFERRED HIM TO THE MANUFACTURER, BUT WAS NOT PROVIDED ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V285000 (AIR BAGS). THE FAILURE MILEAGE WAS 149,525. PARTS DISTRIBUTION DISCONNECT.

Mileage: 149,525

THE FRAME ON OUR 2004 SEQUOIA HAS FAILED ITS INSPECTION DUE TO BEING VERY RUSTY AND HAVING MULTIPLE PERFORATIONS. WE HAVE BEEN INFORMED THAT IT IS NO LONGER SAFE TO DRIVE UNTIL REPAIR OR REPLACEMENT OF THE FRAME OR PORTIONS OF THE FRAME HAS BEEN COMPLETED. I SPOKE WITH MULTIPLE PEOPLE WITH TOYOTA WARRANTY CLAIMS, THEY HAVE REFUSED TO ASSIST US WITH GETTING A NEW FRAME. THEY CLAIM THEIR LIMITED SERVICE CAMPAIGN ON THE FRAME HAS ENDED AND THEY ARE NOT ABLE TO ASSIST AT THIS TIME. THEY SAID THEIR MANAGERS DO NOT ACCEPT PHONE CALLS. SO I HAVE A DECADE OLD SEQUOIA WHICH IS UNSAFE TO DRIVE. SHAME ON TOYOTA!

Mileage: 149,000

TOOK MY 2004 TOYOTA SEQUOIA FOR SERVICE AT IRA TOYOTA OF DANVERS MASSACHUSETTS ON 9/13/2012. WAS NOTIFIED THAT A RECALL REGARDING FRAME RUST WAS ALSO AVAILABLE AND THE FRAME NEEDED TO BE INSPECTED. NEVER RECEIVED A LETTER IN THE MAIL AND THEY INFORMED ME IN PERSON WHILE AT SERVICE THAT THEY WILL COAT THE FRAME IN CRC COMPOUND. NEVER EVEN SAID IF IT WAS BAD ENOUGH (WHICH THE PHOTOS SHOW) THAT THEY WILL REPLACE THE FRAME. THEY DID REPLACE THE SPARE TIRE CARRIER DUE TO RUST. A FEW YEARS PRIOR TO 2012, PAYED 950$ AT A LOCAL BODY SHOP TO HAVE THE VEHICLE COATED IN AN ANTI RUST PROTECTION, STILL DID NOT HELP. HAVE HAD A HUGE ISSUE WITH RUST DEVELOPMENT SINCE BUYING THE CAR BRAND NEW FROM IRA TOYOTA OF DANVERS IN 2004. SINCE THE CRC WAS DONE, IT HAS CHIPPED AWAY, RUST IS STILL VERY PREVALENT ON FRAME/ALL OVER THE VEHICLE. HAVE LOST MY FRONT SKID PLATE WHILE TRAVELING DUE TO RUST, EXHAUST, CATALYTIC CONVERTER, MULTIPLE O2 SENSORS, HEAT SHIELD, BACKING PLATE, FRONT CALIPER, REAR GATE HINGES, ETC. OPENED UP A COMPLAINT WITH TOYOTA CORPORATE. SAID THAT THEY CAN DO NOTHING AND THE CRC ISN'T NECESSARILY GOING TO SOLVE THE PROBLEM, ALL OTHER ISSUES MUST BE DEALT WITH DIRECTLY BY THE OWNER. EXTREMELY UNHAPPY AND FEEL VERY UNSAFE IN VEHICLE.

Mileage: 65,000

FRAME RUST MAKES THE VEHICLE UNSAFE IN LESS THAN TWO YEARS. DEALERSHIP SAYS LIMITED SERVICE CAMPAIGN C0D EXPIRED. RECORD OF VEHICLE SHOWS NO INSPECTION OF VEHICLE THROUGHOUT NUMEROUS SERVICE VISITS TO DEALERSHIPS BETWEEN 2004 AND NOW. DEALERSHIP COULD NOT TELL ME TIMEFRAME OF CAMPAIGN.

Mileage: 120,405

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. WHILE UNDERGOING AN ANNUAL SAFETY INSPECTION, IT WAS DISCOVERED THAT THE VEHICLE'S FRAME WAS RUSTED OUT. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.

Mileage: 145,000

HELLO I PURCHASED A 2004 TOYOTA SEQUOIA THROUGH A PRIVATE SALE ON 4/1/15. WE BROUGHT THE CAR HOME AND TOOK IT TO OUR LOCAL MECHANIC TO HAVE A NEW EXHAUST SYSTEM PUT IN. AT THAT TIME WE WHERE TOLD THAT THE VEHICLE HAS EXTENSIVE FRAME RUST AND HOLES AND WE SHOULD TAKE IT TO A TOYOTA DEALER. AFTER BRINGING THE CAR TO THE DEALER, WE WHERE TOLD THAT THE VEHICLE HAS FRAME RUST AND HOLES FROM FRONT TO REAR AND THE VEHICLE WILL NOT PASS STATE INSPECTION. I CALL CORPORATE TOYOTA AND WAS TOLD THAT THEY CANNOT DO ANYTHING ABOUT THIS SINCE THE CAMPAIGN TO REPLACE/FIX THE FRAMES EXPIRED 7/31/2014. SO BASICALLY WE HAVE A 2004 TOYOTA SEQUOIA THAT IS A NO GOOD AND TOYOTA IS NOT GOING TO TAKE CARE OF THEIR FAULTY FRAME. *TR

Mileage: 180,297

AFTER GETTING OFF THE HIGHWAY AND PARKING, I FOUND IT HARD TO MOVE STEERING WHEEL AND THE CAR BEGAN MAKING LOUD NOISE. WHEN OUR MECHANIC LOOKED AT IT, HE SAID THE ENTIRE FRAME HAD RUSTED, INCLUDING THE PART THAT HOLDS THE POWER STEERING FLUID, CAUSING THE POWER STEERING FLUID TO FALL OUT, AND CREATING THE STEERING PROBLEMS. HE DETERMINED THE VEHICLE WAS UNSAFE TO DRIVE AND RECOMMENDED I CALLED TOYOTA DEALERSHIPS TO SEE IF THEY WOULD REPLACE THE FRAME AS PART OF TOYOTA'S FRAME REPLACEMENT PROGRAM. I TRIED CALLING 2 TOYOTA DEALERSHIPS (INCLUDING THE ONE FROM WHICH I PURCHASED THE VEHICLE) AND BOTH SAID THEY'RE NOT RUNNING THAT PROGRAM ANYMORE AND THERE'S NOTHING THEY CAN DO. I THEN CALLED TOYOTA CUSTOMER SERVICE, FILED MY CASE AND REQUESTING THAT FRAME BE REPLACED DUE TO THE EXTREME RUST AND THE PROBLEMS IT WAS CAUSING WITH UNDER 75,000 MI ON IT. THEY SIMPLY SAID THERE IS NOTHING THEY CAN DO. I AM NOW WITHOUT THE VEHICLE, WHICH I USE FOR MY BUSINESS, AND PURCHASED JUST A YEAR AND A HALF AGO. WHEN WE PURCHASED THE VEHICLE, WE WERE NOT TOLD THERE HAD BEEN A RECALL OR POSSIBLE PROBLEM WITH RUST. *TR

Mileage: 74,500

WHILE HAVING 4 NEW TIRES PUT ON MY VEHICLE, THE MECHANIC TOLD ME ABOUT SEVERE CORROSION ON THE FRAME OF MY CAR. HE SAID IT WAS SO BAD IT IS STARTING TO BUCKLE. HE MENTIONED THAT IT WAS A RECALL AND THAT I SHOULD CONTACT TOYOTA. TOYOTA TELLS ME I HAVE NO RECOURSE AS RECALL ENDED 6 MONTHS AGO. I NEVER RECEIVED INFO ON THE RECALL AND DO BELIEVE THAT A DEFECTIVELY MADE FRAME SHOULD BE RECTIFIED BY THE COMPANY, NOT THE CONSUMER. I AM THE MOTHER OF 4 CHILDREN AND AM CONSTANTLY DRIVING CARPOOLS AROUND TOWN. *TR

Mileage: 173,344

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE CONTACT HEARD ABOUT AN AIR BAG RECALL THAT POTENTLY AFFECTED HIS VEHICLE. THE CONTACT BROUGHT THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THAT RECALL WAS NOT AFFECTED BY THE AIR BAG RECALL; HOWEVER, IT WAS INCLUDED IN AN IN-HOUSE RECALL (C0D) RESISTANT COMPOUND TO THE VEHICLE'S FRAME. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED THAT THE ENTIRE FRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE RECALL NUMBERS WERE UNAVAILABLE. THE FAILURE MILEAGE WAS 175,000.

Mileage: 175,000

THE DRIVERS SIDE REAR SLIDING DOOR STUCK IN THE OPEN POSITION DUE TO THE ELECTRICAL SYSTEM. THERE WAS NO WAY TO CLOSE THE DOOR ONCE OPENED. THE WIFE HAD TO DRIVE TO DEALERSHIP WITH DOOR STUCK WIDE OPEN IN THE DARK. THIS WAS NOT SAFE FOR VARIOUS REASONS... I READ WHERE OTHER VEHICLES HAD THE SAME PROBLEMS BUT DO NOT SEE A RECALL YET BY TOYOTA. WE WILL HAVE THE DEALER BREAK THE CABLE AND RENDER THE DOORS ELECTRICAL SYSTEM USELESS FOR THAT DOOR. THIS REALLY CAUSES ISSUES FOR A PERSON WITH A DISABILITY AND A SPECIAL NEEDS CHILD. HOPEFULLY TOYOTA WILL STEP UP AND RECALL THESE VEHICLES AND CORRECT THIS PROBLEM. *TR

Mileage: 116,300

*FILED WITH ATTORNEY GENERAL OF NEW YORK* RECALL WAS ISSUED ON THE 2004 SEQUOIA DUE TO CORROSION. ON JULY 25, 2013 WE BROUGHT OUR CAR TO THE DEALERSHIP TO APPLY A PROTECTIVE COAT AND WAITED A WEEK FOR THE CAR TO BE RETURNED TO US. WE HAD TO RETURN THE VEHICLE, SEPTEMBER, 2014, TO THE DEALER WITH THE SAME PROBLEM, THE SPRAY WAS FLAKING OFF EXPOSING THE RUST UNDERNEATH. THE VEHICLE WAS SPRAYED FOR THE SECOND TIME IN ONE DAY AND THAT TIME WE WERE TOLD THE VEHICLE'S REAR AXLE TRAILING ARM MOUNT WAS ALMOST SEPARATED FROM THE REAR AXLE HOUSING DUE TO THE CORROSION AND IT WAS RECOMMENDED TO REPLACE THE AXLE. AT THAT TIME WE ASKED IF THIS COULD HAVE BEEN TO THE RECALL OF THE CORROSION, FLAT OUT WE WERE TOLD NO. WE THEN PROCEED TO TAKE THE VEHICLE TO OUR PERSONAL MECHANIC FOR SECOND OPINION, OCTOBER 27, 2014, AND HE CONFIRMED THE AXLE IS DAMAGE AND THE FRAME OF THE VEHICLE IS IN SUCH POOR CONDITION THAT IT MUST BE FIRST ADDRESSED BEFORE REPLACING THE AXLE; HE ALSO MENTIONED TO US THIS IS THE SECOND SEQUOIA THAT HE HAD SEEN WITH THE SAME ISSUE, ALONG HE TOLD US THE SECOND SPRAYING WAS DONE INCORRECTLY, IT WAS NOT CLEANED OUT THEY JUST SPRAYED OVER THE FLAKING PROTECTIVE COAT AND THE RUST. OUR MECHANIC SAID THE VEHICLE SHOULD NOT BE USED BECAUSE IT IS NOT SAFE AND HE IS WILLING TO SIGN AN AFFIDAVIT IF NECESSARY.

Mileage: 70,000

THE DASH BOARD RIGHT ABOVE THE AIR BAG PANEL APPEARS TO BE MELTING. THERE IS A STICKY SUBSTANCE LIKE GLUE ALL OVER IT. ALL ATTEMPTS TO CLEAN IT HAVE FAILED. IT LOOKS LIKE THE DASH PANEL IS JUST MELTING. ANY THING THAT TOUCHES IT STICKS TO IT LIKE GLUE TO INCLUDE SKIN AND HAIR. *TR

Mileage: 105,000

THE HANDLE BREAKS. THIS WILL BE THE THIRD TIME REPLACING THE PLASTIC HANDLE. *TR

Mileage: 89,000

RECEIVED NOTIFICATION FROM TOYOTA THAT MY SEQUOIA WAS BEING RECALLED FOR FRAME CORROSION. OBVIOUSLY THIS COULD CAUSE SAFETY CONCERNS IN THE FUTURE. THEY STATED THAT THE LAST FOR REMEDY WAS JULY 31,2014. I BROUGHT THE SEQUOIA TO MY LOCAL DEALER (MIRACLE TOYOTA, HAINES CITY FLORIDA). THE DEALER EXAMINED THE VEHICLE AND SAID IT REQUIRED REMEDY, BUT THEY COULD NOT PERFORM THESE SERVICES BECAUSE THEY DID HAVE THE PROPER TOOLS AND SUPPLIES. I CALLED THE TOYOTA CORPORATE OFFICE SHOWN ON THE RECALL NOTICE AND THEY GAVE ME A CASE NUMBER 14070872160. I WAS CALLED THE NEXT DAY BY [XXX] AT TOYOTA CORPORATE OFFICE AND WAS TOLD THAT MY LOCAL DEALER COULD NOT PERFORM THE SERVICE AND THAT I WOULD HAVE TO DRIVE MY VEHICLE A 1,000 MILES TO A DEALER THAT COULD PERFORM THE SERVICE. I AM 65 YEARS OLD AND ONLY DRIVE MY VEHICLE LOCALLY- HAVE NOT DRIVEN ON EXPRESSWAYS FOR MANY YEARS, THUS IT IS IMPOSSIBLE FOR ME TO REMEDY THIS SAFETY ISSUE. MY VEHICLE IS REGISTERED IN ILLINOIS BUT HAS BEEN IN FLORIDA THE LAST TWO YEARS SINCE MY SON DROVE IT DOWN TO FLORIDA FROM ILLINOIS TO MY RETIREMENT HOME. IT IS NOT REASONABLE TO ASK SENIOR CITIZENS TO DRIVE 1,000 MILES TO FIX A SAFETY PROBLEM CREATED BY TOYOTA. PLEASE HELP ME WITH THIS SITUATION. I AM HOLDING TOYOTA RESPONSIBLE FOR ANY FUTURE SAFETY HAZARDS THAT MAY AFFECT THIS VEHICLE, WHISH I INTEND TO DRIVE FOR MANY MORE YEARS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 97,785

WE HAD A VOLUNTARY RECALL ON OUR SEQUOIA, WE TOOK IT TO THE DEALERSHIP IN WILKESBORO NC AND THEY TOOK PICTURES AND SENT THE TOYOTA AND SAID WE WOULD BE SAFE DRIVING IT IN MARCH OF 2014. THAT WAS WRONG ON MAY 18TH THE SWAY BAR RIPPED FROM THE FRAME CAUSING TOYOTA TO HAVE TO COME GET IT ON A ROLL BACK AND I HAVE BEEN STUCK IN A SMALL CAR WITH THREE KIDS 13, 8, & 3 SINCE THAT DATE. I PERSONALLY DO NOT FEEL SAFE IN THE CAR EITHER AS OF COURSE THEY SENT ME IN IT. I WOULD LIKE FOR TOYOTA TO SEND OUT A APOLOGY TO OTHERS AS WELL AS MYSELF FOR SENDING VEHICLES OUT WITH A FRAME THAT WOULDN'T LAST. MY SEQUOIA IS IN GREAT CONDITION OTHER THAN THE FRAME WITH 116,500 MILES ON IT. I HAVE DEALT WITH CORPORATE AS IF MY HUSBAND WHO WAS WITH ME WOULDN'T HAVE BEEN IT COULD HAVE CAUSED A MAJOR INCIDENT AS I AM ON THE ROAD CONSTANTLY AND ON INTERSTATES. I HAVE LOST TWO CHILDREN DUE TO STILLBIRTHS AND I DON'T FILL LIKE TOYOTA CARES ABOUT IT'S CUSTOMERS AND THEIR LIVES. *TR

Mileage: 116,500

IN JANUARY 2013, WE RECEIVED A RECALL NOTICE FROM TOYOTA ON OUR 2004 TOYOTA SEQUOIA AS TOYOTA WAS CONCERNED ABOUT THE VEHICLES FRAMES RUSTING PREMATURELY. TOYOTA-TRAINED TECHNICIANS AT DEALER ASSESSED OUR FRAME AND DETERMINED IT WAS NOT RUSTING AND, ACCORDINGLY, WE DID NOT NEED A NEW FRAME. INSTEAD, THE TECHNICIANS SANDED THE FRAME AND APPLIED A COATING TO THE FRAME THAT WAS DESIGNED TO INCREASE THE LONGEVITY OF THE FRAME BY PREVENTING RUST. WE HAD NO CHOICE IN THE MATTER. WE DID NOT CHOOSE TO ACCEPT THE COATING IN LIEU OF A NEW FRAME, THE COATING WAS THE ONLY OPTION WE WERE OFFERED. RECENTLY, WE NOTICED RUST ON THE CAR AND RETURNED TO DEALER. DEALER LOOKED AT THE CAR AND DETERMINED THAT THE FRAME HAD COMPLETELY RUSTED THROUGH AND THE CAR WAS UNSAFE TO DRIVE. UP UNTIL THAT DATE MY FAMILY WAS DRIVING THE CAR ON A REGULAR BASIS HAVING NO IDEA IT WAS UNSAFE. THIS IS A MERE 15 MONTHS AFTER TOYOTA TECHNICIANS ASSESSED THE FRAME AND CONCLUDED THE FRAME WAS SAFE. I CALLED TOYOTA AND HAVE BEEN STONEWALLED. THEIR POSITION IS THAT THE RECALL WAS SATISFIED WHEN THEY APPLIED THE COATING AND MATTER IS CLOSED. A MISTAKE HAD TO HAVE BEEN MADE BECAUSE A FRAME THAT IS SAFE, RUST FREE, AND COATED WITH SOMETHING TO INCREASE LONGEVITY AND PREVENT RUST HAS TO LAST LONGER THAN 15 MONTHS. DEALER EITHER ERRED IN ITS INITIAL ASSESSMENT IN 2013 (MEANING FRAME WAS IN FACT RUSTED AND SHOULD HAVE BEEN REPLACED) OR ERRED IN APPLYING THE ANTI-RUSTING COATING. BOTTOM LINE IS THAT TOYOTA SHOULD HAVE REPLACED THE FRAMES ON ALL OF THEIR VEHICLES. THIS PROCESS OF COATING THE FRAME OBVIOUSLY DOES NOT WORK AND THERE ARE LIKELY MANY U.S. CITIZENS DRIVING SEQUOIAS THAT ARE COATED BUT UNSAFE LIKE MINE. TOYOTA IS KNOWINGLY ALLOWING PEOPLE TO DRIVE UNSAFE CARS AND MUST BE STOPPED. MY TOYOTA CASE NUMBER IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 167,000

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE CONTACT STATED WHILE HAVING THE VEHICLE SERVICED AT A DEALER, THE TECHNICIAN NOTICED EXCESSIVE RUST ON THE FRAME AND SUSPENSION. THE TECHNICIAN ALSO STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE CONTACT MENTIONED THAT THE VEHICLE WAS INCLUDED IN A MANUFACTURER'S RECALL BUT THE DEALER WAS CHARGING FOR PARTS BECAUSE THERE WAS A POSSIBILITY THAT THE PART COULD HAVE FRACTURED DURING THE REMEDY REPAIR. THE CONTACT NOTIFIED THE MANUFACTURER OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 132,000.

Mileage: 132,000

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE REAR TRUNK EXTERIOR LATCH FAILED, MAKING THE DOOR INOPERABLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER, WHO STATED THAT THE LATCH WOULD NEED TO BE REPLACED. THE MANUFACTURE WAS MADE AWARE OF THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

Mileage: 140,000

THE LIFTGATE HANDLE BROKE AND WAS REPLACED WITH AN ORIGINAL EQUIPMENT PLASTIC PART. ACCORDING TO OTHER'S COMPLAINTS, I EXPECT IT TO HAPPEN AGAIN VERY SOON. THEN THE HANDLE STOPPED OPENING THE LIFTGATE ALTOGETHER. I FINALLY GOT THE GATE OPEN AND REPLACED THE PULL CABLE BUT IT DID NO GOOD. ONCE WHILE DRIVING, THE GATE OPENED BY ITSELF AND LIFTED UP WHEN I WENT OVER A SMALL BUMP. I CAN'T GET THE GATE OPEN IN CASE OF AN EMERGENCY OR TO ACCESS THE SPARE TIRE AND SOMETIMES IT OPENS BY ITSELF. CERTAINLY THIS IS A MAJOR SAFETY ISSUE THAT TOYOTA SHOULD ADDRESS. *TR

Mileage: 135,000

REAR DOOR WILL NOT OPEN AT ALL. REAR WINDOW ALSO WILL NOT WORK. I FIND THIS A SAFETY ISSUE AS SOMEONE COULD BE TRAPPED INSIDE IF THERE WAS A CRASH. ALSO CAN NOT ACCESS SPARE TIRE. TOYOTA SHOULD RECALL THIS AY THEIR EXPENSE. THERE ARE WAY TOO MANY COMPLAINTS ON THIS ISSUE EVEN AFTER PEOPLE HAVE PAID FOR REPAIRS, IT BREAKS AGAIN. SAFETY COMES FIRST. *TR

Mileage: 65,000

I RECEIVED A "LIMITED SERVICE CAMPAIGN" NOTICE REGARDING CORROSION-RESISTANT COMPOUND APPLICATION TO BE APPLIED TO MY 2004 TOYOTA SEQUOIA. I BROUGHT THE VEHICLE IN TO THE DEALER AND WAS GIVEN A LOANER CAR FOR THE 4 DAYS THEY HAD MY VEHICLE, WHICH I WAS THANKFUL FOR. THEY SAID MY SEQUOIA'S FRAME WAS NOT RUSTED THROUGH AND APPLIED A VERY STICKY, MESSY , SHINY TAR-LIKE SUBSTANCE THAT NOW 6 DAYS LATER IS STILL NOT DRY. TOYOTA DEALER ALSO TOLD ME I NEEDED ABOUT $5000 IN REPAIRS (WHICH I BROUGHT TO MY LOCAL MECHANIC AND FIXED FOR $380), BUT THAT'S NOT WHY I AM WRITING. I AM VERY CONCERNED FOR MY FAMILYS SAFETY IN THIS VEHICLE AFTER READING HUNDREDS OF COMPLAINTS ON THE SEQUOIA ON THE MANY TOYOTA FORUM WEBSITES AVAILABLE. I ALSO HAVE THE SAME PROBLEMS THAT ARE DISCUSSED IN THE FORUMS INCLUDING EXCESSIVE RUST INSIDE THE TAILGATE CAUSING THE TAILGATE WINDOW TO NOT OPERATE AND ALSO RUST SO BAD WE CAN'T EVEN USE THE HITCH ON OUR VEHICLE WHICH WAS THE MAIN REASON WE PURCHASED THE VEHICLE TO BEGIN WITH. IT IS A COMPLETE RUST BUCKET. *TR

Mileage: 142,000

I WAS MAKING MAINTENANCE FOR MY VEHICLE AND WHILE UNDER THE CAR I SPOTTED THE FRAME IS COVERED BY EXCESSIVE RUST MOSTLY ON JOINT AREAS. I HAVE READ TOYOTA FORUMS TODAY AND FOUND THAT THE PROBLEM WITH THE FRAME CORROSION IS NOT ONLY MINE. ALSO, I HAVE CONTACTED TOYOTA DEALERSHIP TODAY AND THEY SAID THEY ARE NOT AWARE OF ANY RECALLS REGARDING THIS ISSUE. TOYOTA MUST TAKE AN ACTION TO MAKE THOSE SEQUOIAS MORE SAVED TO DRIVE. AT LEAST, I AM EXPECTING THEM TO ISSUE A RECALL AND COVER THE FRAME WITH ANTI-RUST MATERIALS. *TR

Mileage: 91,000

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE CONTACT STATED WHILE HAVING THE VEHICLE SERVICED AT A BODY SHOP, THE MECHANIC NOTICED EXCESSIVE RUST BUILD UP ON THE FRAME AND SUSPENSION. THE MECHANIC ALSO STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE CONTACT NOTIFIED THE MANUFACTURER AND FILED A COMPLAINT. THE FAILURE MILEAGE WAS 86,000.

Mileage: 86,000

TL* THE CONTACT OWNS 2004 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR ROUTINE MAINTENANCE WHEN HE WAS INFORMED THAT THERE WAS A FOUR INCH HOLE IN THE FRAME. THE HOLE WAS THE RESULT OF CORROSION. THE DEALER STATED THAT IN ORDER TO REPAIR THE VEHICLE, THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE BECAUSE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 255,000.

Mileage: 255,000

2004 TOYOTA SEQUOIA. THE REAR DOOR (HATCH) EXTERNAL DOOR HANDLE FAILS MID WAY DURING NORMAL OPERATION LEADING THE DOOR TO CONTINUOUSLY BE AJAR DURING VEHICLE OPERATION. DOOR HANDLE IS DISABLED AND THERE IS NO OTHER WAY TO OPEN/CLOSE DOOR (THERE IS NO INTERNAL HANDLE). TOTAL FAILURE. LOCAL TOYOTA DEALER SERVICE DEPARTMENT STATED THAT THIS PART FAILS OFTEN ON TOYOTA SEQUOIAS AND TOYOTA SIENNAS. SEARCH OF INTERNET WEBSITE REVEALS FAILURE IS DUE TO USE OF "CHEAP PLASTIC PARTS" ON THIS ESSENTIAL PIECE OF VEHICLE EQUIPMENT. *TR

Mileage: 99,000

THE TRAC CONTROL OFF AND VSC LIGHT ALONG WITH BRAKE LIGHT COME AND WE LOSE ACCELERATION AND POWER STEERING. THE CAR ALMOST COMES TO A STOP. ALSO THERE IS A CRUNCHING NOISE COMING FROM THE BRAKES. WE KEEP TAKING IT TO THE DEALER AND THEY KEEP REPLACING PARTS. ALREADY REPLACED THE SKID CONTROL COMPUTER. IT DID NOTHING STILL HAVE PROBLEMS. THEY ARE REPLACING THE BRAKE BOOSTER ASSEMBLY TOMORROW. IT COST ME 2,000 AND THEY STILL DON'T KNOW WHAT IS THE PROBLEM. *TR

Mileage: 60,000

TL* THE CONTACT OWNS A 2004 TOYOTA SEQUOIA. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BECAUSE THE LIFT GATE WAS CORRODED. THE VEHICLE WAS REPAIRED AT THAT TIME. THE CONTACT STATED THAT THE LIFT GATE WAS RUSTED AGAIN AND UNABLE TO LOCK PROPERLY. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALERSHIP FOR DIAGNOSTIC TESTING AND HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT BELIEVED THAT THE STEEL USED FOR THE LIFT GATE WAS DEFECTIVE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000 THE APPROXIMATE CURRENT MILEAGE WAS 139,000.

Mileage: 50,000

EXCESSIVE RUSTING UNDER THE TRUCK, INCLUDING THE AXLE, BRAKE AREAS AND GAS TANK. *TR

Mileage: 70,000

WHILE DRIVING FRONT DRIVER/PASSENGER DOORS VIBRATED HEAVILY. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 5,000