2005 TOYOTA SEQUOIA Engine Problems

Starter replacement is exceptionally high, self repair impossible. There should be recall on manufacturing design of starter placement inside intake manifold amongst other impossible expectations

Malfunction indicator lights - Check engine, VSC off and TRAC off. The vehicle goes into limp mode. The issue is both a mechanical and engineering defect causing the override of the entire AIP system. Parts affected are Air injection pumps, Air switching valves, Air pump inlets/covers, Gaskets/connectors/clamps and Speed sensors.

ENGINE KNOCKING SOUND OR TICKLING NOISE.I WENT TO THE DEALER TO DIAGNOSIS WHAT IS WRONG, BUT THEY CANNOT FIGURE OUT. THE DEALERSHIP RECOMMENDED TO REPLACE THE WHOLE ENGINE QUOTING $9,800 FOR PARTS AND LABOR. THE VEHICLE HAS ONLY 52,000 MILES ON IT, IT SHOULD NOT BE HAVING THIS PROBLEM. THE CAR IS NOT WORTH THAT MUCH, AS I WOULD BE SPENDING ON IT. LOOKING ONLINE THERE ARE OTHERS WITH THE SAME PROBLEM AND SOME HAVE SAID TOYOTA HAS REPLACED THEIR ENGINE. I CONTACTED THE EXECUTIVE OFFICE AND THEY DENIED ANY ASSISTANCE, SEEMS LIKE THEY DO NOT WANT TO STAND BEHIND THEIR CUSTOMERS WHEN PROBLEMS ARISE UNTIL IT BECOMES A BIGGER ISSUE. I AM JUST LETTING YOU GUYS KNOW OF THIS PROBLEM, I AM NOT SURE IF YOU CAN DO ANYTHING, BUT I WANT TO INVOLVE MEDIA AND OTHERS WITH THIS PROBLEM. IT IS NOT FAIR TO SPEND SO MUCH MONEY ON A CAR JUST FOR THE ENGINE TO GO OUT AT 52,000 MILES. THERE HAS TO BE SOME KIND OF MANUFACURE DEFECT.

TOYOTA EXTENDED THE WARRANTY COVERAGE FOR REPAIRS RELATED TO ILLUMINATION OF THE CHECK ENGINE LIGHT (MALFUNCTION INDICATOR LIGHT) DUE TO MOISTURE/WATER IN THE AIR INJECTION PUMPS AND/OR AIR SWITCHING VALVES FOR SELECT SEQUOIA TRUCKS. IT SHOULD BE REQUIRED TO EXTEND IT TO ALL SEQUOIA TRUCKS AS IT CLEARLY RECOGNIZES THIS PUMP AND VALVE ASSEMBLY IS DEFECTIVE IN THIS MODEL. THE COVERAGE EXTENDS FOR THE LESSER OF 10 YEARS OR 150,000 MILES BUT INSTEAD SHOULD BE FOR THE GREATER OF THE TWO. THIS REPAIR COSTS $4000 AND TYPICALLY OCCURS WHEN THE TRUCK VALUE IS NEAR $7000. MY TRUCK IS EXPERIENCING THIS PROBLEM AND WILL NOT ACCELERATE ABOVE 50 MPH WHICH CAN BE DANGEROUS.

Mileage: 95,000

TL* THE CONTACT OWNS A 2005 TOYOTA SEQUOIA. WHILE STARTING THE VEHICLE, AN ABNORMAL NOISE WAS OBSERVED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SECONDARY AIR PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED THE FAILURE MILEAGE WAS APPROXIMATELY 117,000. UPDATED 04/18/17LJ *CN

Mileage: 117,000

VSC TRAC, VSC OFF, BRAKE, ABS LIGHTS... ALL ON, ALL AT ONCE. AND LOOSES POWER ON THE FREEWAY VERY DANGEROUS. I HAVE DONE SOME RESEARCH AND THERE IS THOUSANDS OF COMPLAINS . IT HAPEN TO ME LAST NIGHT VSC TRAC, VSC OFF, BRAKE, ABS LIGHTS.CAME ON ALL ON, ALL AT ONCE.AND I START LOOOSING POWER LUCKY I WAS CLOSE TO A EXIT

Mileage: 145,000

VSC VSC TRACTION CONTROL LIGHTS COMES ON AS WELL AS THE CHECK ENGINE LIGHT. THE VEHICLE ACCELERATES POORLY. THIS MAKES FOR A VERY DANGEROUS SITUATION BECAUSE THE VEHICLE CAN SLOW DRAMATICALLY AT HIGHWAY SPEEDS. LIGHTS GO OFF FOR A LITTLE WHILE WHEN THE BATTERY IS DISCONNECTED BUT ALL LIGHTS AND ACCELERATION PROBLEMS RETURN SHORTLY. OWNERS HAVE SPENT THOUSANDS OF DOLLARS REPLACING PARTS WITHOUT A LONG TERM FIX. SPOUSE WILL NO LONGER DRIVE THE VEHICLE BECAUSE OF THIS DANGEROUS PROBLEM. TOTOYA NEEDS TO FIX THIS WIDESPREAD PROBLEM.

ENGINE WARNING AND VSC TRAC OFF LIGHTS, I HAD SEVERAL ISSUES WITH THESE WARNINGS. THIS IS THE SECOND TIME IT HAD HAPPENED TO MY SUV. THE LAST TIME WAS ON A LONG VACATION TRIP AND IT SUDDENLY GOES ON AND THE ENGINE STARTS TO GO ON LIMP MODE, WHERE IT SLOWS DOWN DRAMATICALLY EVEN THOUGH THE SUV'S ENGINE IS FINE. IT WAS PRETTY DANGEROUS BECAUSE WE WERE ON A FWY WHERE THE SPEED IS 75 MPH. WE TOOK IT IN FOR REPAIR IN TOYOTA DEALER AND IT JUST NEED A ROUTINE MAINTENANCE WHICH COST ME $2600 TO GET THIS LIGHTS OFF! TWO YEARS LATER TO THIS DAY, THE LIGHTS WENT ON AGAIN AND NOW THE SAME THING, IT IS GOING TO COST ME $2600 TO GET THESE LIGHT OFF! THIS IS HAPPENING A LOT TO ALL 2005 SEQUOIA. THERE SHOULD BE A RECALL FOR THESE...

Mileage: 112,000

OYOTA SEQUOIA 2005 ENGINE LIGHT ON ,VSC OFF LIGHT AND TRAC VSC LIGHT ON. THESE COMPLAINTS ARE ABOUT THIS PROBLEMS HTTP://WWW.AUTOMOTIVEFORUMS.COM/T544406-SEQUOIA_VSC_TRAC_PROBLEM.HTML,HTTP://WWW.CARCOMPLAINTS.COM/TOYOTA/SEQUOIA/2003/ELECTRICAL/VSC_TRAC_LIGHTS_ARE_ON.SHTML,HERE ARE TONS OF OTHER COMPLAINTS ON THIS PROBLEM AND IT IS NOT LIMITED TO OUR YEAR MODEL. IF ALL OF THE COMPLAINTS WERE COMPILED IN ONE AREA AND PRESENTED TO THE NTSB, I'M SURE THAT TOYOTA WOULD BE FORCED TO DEAL WITH THIS ISSUE AND CORRECT IT. ITS A BIG ISSUE ESTIMATED COST FOR THAT AROUND $ 2000 TO $ 5000 I DON`T KNOW IF U INVESTIGATE OR NO .I AM NOT GOING TO GET THIS ISSUE REPAIR UNTIL I WILL HEAR FROM YOU .PLEASE TAKE IT SERIOUSLY

Mileage: 39,002

A COUPLE OF DAYS AGO, WHEN I WAS DRIVING ON THE HIGHWAY, MY SEQUOIA SUDDENLY STOPPED ACCELERATING. TRAC LIGHT AND VSC LIGHT AND CHECK ENGINE LIGHT CAME ON. MY SPEED WOULD NOT GO ABOVE 40MPH AND WOULD NOT EVEN BRAKE. I WAS IN THE LEFT LANE AND THE CARS BEHIND ME WERE GOING PRETTY FAST AND ALMOST HIT ME. I AM LUCKY THERE WAS NO CAR IN THE RIGHT LANE, SO I PULLED TO THAT LANE JUST IN TIME. IT WAS A SCARY MOMENT FOR ME BECAUSE MY KIDS WERE WITH ME ALSO. I ALWAYS THOUGHT OF TOYOTA OF HAVING SAFETY IN THEIR CARS, BUT WHEN I CAME HOME TO RESEARCH WHAT MIGHT BE HAPPENING TO THE CAR, I FOUND OUT MANY PEOPLE ARE HAVING THE SAME EXACT PROBLEM AND THUS IT IS A MANUFACTURERS PROBLEM. I AM SUPRISED TOYOTA IS NOT DOING ANYTHING ABOUT THIS. DO THEY NOT CARE OF THE SAFETY OF THE CONSUMERS? THE MILAGE ON MY SEQUOIA IS ONLY 39,000 AND I DO NOT DRIVE IT TOO OFTEN, AND ALSO HAVE MAINTAINED IT VERY WELL. WE SPEND SO MUCH MONEY ON THIS CAR AND THIS VEHICLE REALLY WAS NOT WORTH IT IF IT CAME WITH SO MANY FACTORY DEFAULTS. PLEASE FOLLOW-UP ON THIS ISSUE TO HAVE IT RESOLVED.

Mileage: 39,003

THE SECONDARY INJECTION PUMP HAS FAILED. IT STARTED WITH A LOUD WINDING NOISE ANYTIME IT WAS STARTED AT A COLD START. THE NOISE WOULD LAST A FEW MINUTES. THEN EVERYTHING WAS FINE. THEN THE ENTIRE THING WENT OUT AND MY CHECK ENGINE LIGHT CAME ON ALONG WITH ALL TRACTION CONTROL HAS GONE OUT. THE VEHICLE WILL NOT ACCELERATE AT A NORMAL SPEED AND IT IS VERY DANGEROUS WHILE DRIVING, ESPECIALLY ON THE INTERSTATE. TOTAL COST TO REPAIR IS OVER $3,000.00 IT IS A WELL DOCUMENTED CASE OF COMPLAINTS AND THEY HAVE ISSUED WARRANTY FOR OTHER YEAR MODELS FOR THIS PART TO BE REPLACED- BUT NOT 2005. *JS

WHEN TURNING CORNERS IN MOTION, THE TRACTION CONTROL LIGHT ILLUMINATES CAUSING A LOSS OF BRAKING AND ACCELERATION. THERE IS NOW WAY TO CONTROL THE VEHICLES ACCELERATION/DECELERATION UNTIL THE LIGHT GOES OFF. TYPICALLY LAST ABOUT 3-5 SECONDS. THIS HAPPENS FREQUENTLY EVERY TIME THE VEHICLE IS DRIVEN.

Mileage: 70,000

VSC TRAC---VSC--CHECK ENGINE LIGHT--AND THEN PROBLEMS WITH ACCELERATION ON A STREET DOING 35 MPH. WOULD BE VERY DANGEROUS IF IT HAPPENED ON A HIGHWAY. NEEDS TO BE A RECALL- MANY SIMILAR COMPLAINTS ONLINE

Mileage: 185,000

WHILE DRIVING AT 35 MPH, THE CHECK ENGINE LIGHT, VSC OFF LIGHT, VSC TRAC LIGHT, AND THE EMERGENCY BRAKE LIGHT ALL CAME ON AT ONCE, AND THE VEHICLE STOPPED ACCELERATING, AND I EXPERIENCED A DRAMATIC DECREASE IN VEHICLE POWER. I DROVE THE VEHICLE HOME NOTICING A DRASTIC CHANGE IN ACCELERATION AS THE SEQUOIA WOULD NOT ACCELERATE NORMALLY; IT WOULD ACCELERATE AT A SIGNIFICANTLY REDUCED RATE, TOPPING OUT AT 35MPH ON THE FLATS, 30 MPH ON AN INCLINE, I WAS ABLE TO REACH 70MPH GOING DOWN HILL ON A HIGHWAY. SINCE THAT DAY, DURING START UP, THE ENGINE MAKES A HIGH-PITCH VACUUM NOISE, WHICH DROPS OFF AND NORMAL ENGINE SOUND RETURNS. ALL DASHBOARD LIGHTS ARE NORMAL, UNTIL 10-15 SECONDS AFTER START, WHEN THE VSC OFF/VSC TRAC/BRAKE LIGHTS ALL ILLUMINATE, AND REMAIN ON UNTIL THE ENGINE IS TURNED OFF AND THE POOR ACCELERATION AND DECREASE POWER ARE NOW THE NORM. THIS IS A VERY DANGEROUS SAFETY ISSUE SHOULD THIS HAPPEN TO SOMEONE ACCELERATING OUT OF AN INTERSECTION, OR NEEDING MORE POWER ON A HIGHWAY.

Mileage: 145,575

PIECE OF FOAM WORTH $.10 DISLODGED FROM BLOWER MOTOR AND WAS JAMMED IN BLOWER MOTOR VALVE. THIS CREATED A LOUD SQUEAL SOUND. HAD REPAIR DONE AT COST OF $2000 LAST YEAR 2014. TOYOTA DEALER STATES SAME PROBLEM ONCE AGAIN . *TR

CHECK ENGINE LIGHT, VSC TRAC AND BREAK LIGHT CONSTANTLY. *JS

Mileage: 90,000

VSC TRAC---VSC--CHECK ENGINE LIGHT--AND THEN PROBLEMS WITH ACCELERATION!! *TR

Mileage: 80,000

TRAC OFF, VSC TRAC ,ENGINE LIGHT CAME ON...TROUBLE CODE WAS P1444 (SECONDARY AIR INJECTION SYSTEM SWITCHING VALUE STUCK)...VEHICLE HAD PROBLEMS ACCELERATING. REPAIRMAN INDICATED THAT THE AIR INJECTION PUMP/CHECK VALUES NEEDED TO BE REPLACED AND VERY EXPENSIVE. BASED ON OTHER REPORTS IT APPEARS THAT THIS IS A FREQUENT OCCURRENCE AND VEHICLES SHUTTING DOWN ON INTERSTATES. OTHERS HAVE SAID THAT TOYOTA KNOWS ABOUT THIS BUT WON'T ISSUE AN EXTENDED WARRANTY, BUT OFFERS FOR NEWER VEHICLES . OWNED SEVERAL TOYOTAS BEFORE THIS...THIS COULD BE A DEAL BREAKER FOR FUTURE TOYOTAS. *TR

Mileage: 118,000

VEHICLE WHEN ON A STOP AND MAKING A TURN DOESN'T ACCELERATE FOR A FEW SECONDS IT GOES BLANK THEN AFTER GETS SPEED. IN MANY OCCASION I HAD CLOSE CALLS WITH UPCOMING TRAFFIC BEHIND ME AFTER MAKING THE TURN BECAUSE OF THE ACCELERATION FAILURE. I CALLED THE DEALER WHERE THE CAR WAS OBTAINED AND THEY SAID THAT THERE IS NO RECALL FOR THAT VEHICLE EVEN WHEN I TOLD THEM THAT THE SEQUOIA 2003 WAS RECALLED BECAUSE OF THE SAME ISSUE. THE TOLD ME THAT THEY CAN CHECK WHAT IS WRONG WITH IT BUT I WILL NEED TO PAY THE INSPECTION PLUS THE REPAIRS. LAS CONVERSATION WITH THEM WAS 6/27/2014. *TR

Mileage: 95,000

BOTH VSC TRAC AND ENGINE LIGHT ARE ON. ENGINE MAKES A LOUD GRINDING NOISE EVERY TIME THE CAR NEEDS TO BE WARMED UP. READ OTHER REPORTS THAT SEQUOIA 2005 OWNERS ARE HAVING THE SAME ISSUES. SHOULDN'T THERE BE A RECALL BY NOW FOR SAFETY ISSUE? *TR

Mileage: 143,000

THE VEHICLE HAS A FAILED AIR INJECTION SYSTEM THAT CAUSES A REDUCTION IN THE ENGINE'S POWER OUTPUT. WHEN THE INITIAL FAILURE BEGAN THERE WAS A LOUD VACUUM SOUND UPON START UP AND ALL DASH WARNING LIGHTS CAME ON. OVER TIME THE SOUND WENT AWAY BUT ENGINE POWER IS STILL GREATLY REDUCED. THIS POSES A VERY SERIOUS SAFETY RISK AS THE VEHICLE CAN NOT ACCELERATE ADEQUATELY TO HIGHWAY SPEEDS OR MAINTAIN SPEEDS ON AN INCLINE THUS POSING A RISK FOR ACCIDENTS AND AS A RESULT POSSIBLE INJURY. TOYOTA WAS NOTIFIED OF THE ISSUE IN SUMMER 2012 BUT STATED THEY WOULD NOT COVER OR REPLACE ANY COMPONENTS RELATED TO THIS AS THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS TAKEN TO THE DEALERSHIP TOYOTA SCION CONCORD (CONCORD, NC) AND A DIAGNOSTIC TEST WAS PERFORMED SHOWING A FAILED AIR INJECTION SYSTEM. THE REPLACEMENT COST ARE APPROXIMATELY $3,500 AND REQUIRES A SERVICE TECHNICIAN TO BREAK DOWN THE MOTOR TO REPLACE THE NECESSARY COMPONENTS. WITH THE COST OF THE SYSTEM BEING SIGNIFICANT THIS GOES BEYOND THE SCOPE OF A BASIC REPAIR. 2ND GENERATION SEQUIOAS (2008-CURRENT) ALSO EXPERIENCED FAILED AIR INJECTION SYSTEMS AND TOYOTA REPLACED THE SYSTEM IN THESE VEHICLES BUT DID NOT IN THE 1ST GENERATION ALTHOUGH THEY SHARE A SIMILAR POWERTRAIN. *TR

Mileage: 120,000

THE VSC TRAC LIGHT IS ON , AND ENGINE LIGHT TOO. *TR

Mileage: 162,870

TL* THE CONTACT OWNS A 2005 TOYOTA SEQUOIA. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN SHE ATTEMPTED TO DRIVE UPHILL AND THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT STATED THE DEFECT WAS ONLY PRESENT WHEN ATTEMPTING TO DRIVE UPHILL. THE VEHICLE WAS DIAGNOSED BY THE DEALER AND THE CONTACT WAS INFORMED THAT THE AIR INJECTION SYSTEM EXHIBITED AN INTERNAL MALFUNCTION FROM DEBRIS THAT RUPTURED FROM INSIDE THE AIR INJECTION SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 99,500.

Mileage: 99,500

I WAS TOLD THE VEHICLE CONTROL AND STABILITY SYSTEM WAS OFF. AND IS A COMMON ISSUE WITH THIS YEAR MAKE AND MODEL. VSC AND TRAC OFF LIGHT KEEPS COMING ON. ALSO SECONDARILY VALVE STUCK CLOSED. P1445 & P1442 CODES. ALSO ANOTHER KNOWN ISSUE FOR THIS VEHICLE YEAR MAKE AND MODEL. TOYOTA IS AWARE BUT WON'T FIX AFTER CERTAIN MILES. *TR

Mileage: 96,000

AFTER CRANKING THE CAR AND DRIVING FOR A FEW MINUTES, THE FOLLOWING LIGHTS ON THE DASHBOARD APPEARED: VSC OFF / VSC TRAC / CHECK ENGINE LIGHT. I ENTERED THE ON RAMP TO THE INTERSTATE AND COULD NOT ACCELERATE PAST 40 MPH. HAD TO PULL OVER AND LET THE CAR "RESET". ATTEMPTED TO RE-ENTER THE INTERSTATE AND THE FLOW OF TRAFFIC BUT CAR WOULD NOT ACCELERATE BEYOND 40 MPH AND I HAD MY 3 SMALL CHILDREN IN THE VEHICLE. VERY TERRIFYING EXPERIENCE. DROVE TO A DEALERSHIP THAT ADVISED ME A SECONDARY HOSE HAD TO BE REPLACED ON THE ENGINE. LATER DETERMINED THAT TOYOTA RELEASED A TECHNICAL BULLETIN AND ARE AWARE OF THIS ISSUE BUT WILL NOT ISSUE A RECALL. IT IS AN EXTREMELY COSTLY PART TO FIX. PARTS ALONE ARE $3200. *TR

Mileage: 100,000

MY SEQUOIA WILL ALL OF A SUDDEN STOP ACCELERATING WHILE DRIVING. TRAC LIGHT AND VSC LIGHT AND CHECK ENGINE LIGHT CAME ON. I HAD TO TURN THE IGNITION OFF AND BACK ON TO GET IT MOVING AGAIN...I TOOK IT STRAIGHT TO THE TOYOTA DEALERSHIP. THEY DID SEVERAL TESTS. ALL BUT ONE TEST DETERMINED IT WAS THE ENGINE CONTROL UNIT (OF WHICH IS COVERED UNDER A CLASS ACTION LAWSUIT). BECAUSE OF THAT ONE TEST, THEY WILL NOT FIX IT. THE SERVICE MANAGER TOLD ME I HAD TO KEEP DRIVING IT UNTIL IT BREAKS DOWN ON THE SIDE OF THE ROAD AND THEY WOULD TOW IT BACK THERE. PROBLEM IS...I MIGHT BE DEAD IN THE TRUCK DEPENDING ON WHERE AND WHEN IT HAPPENS AGAIN. I AM TERRIFIED TO DRIVE IT! MY SEQUOIA HAS BEEN A LEMON! I HAVE PREVIOUSLY HAD TO REPLACE 1)THROTTLE BODY 2)THROTTLE PEDAL POSITION SWITCH 3)BRAKE BOOSTER 4)MASTER CYLINDER AND 5)SKID CONTROL ECU. AT 120,000 MILES AND ALL OF THOSE PROBLEMS ALREADY? AND NOW THIS ISSUE?....IT MUST BE A LEMON! *JS

Mileage: 120,000

CHECK ENGINE LIGHT CAME ON AND HEARD A LOW "SUPERCHARGER" TYPE NOISE FROM THE ENGINE. TOOK VEHICLE TO DEALER WHO DIAGNOSED THE PROBLEM AS AN AIR INJECTION PUMP PROBLEM (CODES P1442, P1445) WHICH HAS BEEN FOUND ON 2008-2010 SEQUOIAS. VEHICLE COMPUTER IS OPERATING IN SAFE MODE AT A REDUCED CAPACITY UNTIL REPAIR IS DONE. TOYOTA HAS EXTENDED THE WARRANTY TO 10 YEARS OR 150,000 MILES FOR THIS PROBLEM BUT NOT FOR THE 2005 MODEL YEAR. TOYOTA ACKNOWLEDGED THE PROBLEM IN THE 2008-2010 MODEL YEARS BUT WOULD NOT CONSIDER ANY ACTION OR NECESSARY COMMUNICATION FOR THE 2005 MODEL YEAR. *TR

Mileage: 89,915

ABOUT A MONTH AGO, BEGINNING OF MARCH, THE ENGINE LIGHT, VSC TRAC LIGHT, TRAC OFF LIGHT, ARE ALL LITE UP WHEN I TURN ON THE ENGINE. A WEEK LATER, THOSE LIGHT GO OFF AND ON ALL THE TIME AND IT STILL DOES IT. FROM WHAT I KNOW, THE TRAC OFF & VSC TRAC HAS SOMETHING TO DO WITH THE BRAKE AND I DON'T FEEL SAFE TO DRIVE IN IT. I WENT ONLINE AND SEARCH TO MY PROBLEMS AND APPARENTLY, ALOT OF PEOPLE HAVE THE SAME PROBLEM AS I DO. TOYOTA NEED TO HAVE THIS RECALL AND FIX THIS PROBLEM TO ALL THEIR CUSTOMERS WHO HAVE THIS PROBLEM. *TR

Mileage: 62,000

WHILE DRIVING ON THE HIGHWAY AT 55 MPH, MY VEHICLE SUDDENLY DECELERATED TO 20 MPH. AFTER EXITING, I STILL COULD NOT ACCELERATE ABOVE 20 MPH. I SCHEDULED AN APPOINTMENT WITH R&H TOYOTA IN OWINGS MILLS, MD FOR FRIDAY, MARCH 15, 2013. I RECEIVED A CALL FROM THE DEALERSHIP INFORMING ME IT WAS NECESSARY TO REPLACE THE SECONDARY AIR INJECTION PUMP, BUT SINCE THE PART WAS NO LONGER AVAILABLE, I WOULD NEED TO REPLACE THE ENTIRE VALVE ASSEMBLY AND THE SKID CONTROL COMPUTER, AT A TOTAL COST OF $4,845.02. MY INTERNET RESEARCH REVEALED TOYOTA IS AWARE OF THE DEFECTIVE SECONDARY AIR INJECTION SYSTEM IN THEIR VEHICLES AND AS A RESULT ISSUED A WARRANTY ENHANCEMENT, IN RESPONSE TO REPORTS OF AIR INDUCTION PUMP ASSEMBLIES AND/OR AIR INJECTION SWITCHING VALVES ISSUES ON THEIR 2007-2010 TUNDRA AND 2008-2010 SEQUOIA MODELS, UP TO 150,000 MILES. I CALLED TOYOTA TO QUESTION WHY THE DECISION WAS MADE TO NOT INCLUDE ALL MODEL YEARS WITH THE DEFECTIVE SECONDARY AIR INJECTION SYSTEM AND WAS INFORMED IT WAS THEIR ENGINEERS' DECISION. NO ONE AT TOYOTA COULD FURTHER EXPLAIN THIS TO ME. MY RESEARCH REVEALS THERE ARE MANY MODELS FOR 2005 - 2008 AFFECTED BY THIS DEFECT. THE EXPLANATION FOR THE EXORBITANT EXPENSE WAS BECAUSE OF A DESIGN CHANGE AND THAT TOYOTA NO LONGER MANUFACTURES THE DEFECTIVE PART, OWNERS OF VEHICLES FOR MODELS 2005 - 2008 WOULD NEED TO REPLACE ENTIRE SYSTEM. SO, TOYOTA APPARENTLY ACKNOWLEDGES A DEFECT IN THEIR DESIGN AND ITS IMPACT ON VEHICLE OWNERS. I CANNOT AFFORD $5,000.00 FOR A VEHICLE THAT IS ONLY EIGHT (8) YEARS OLD. BASED ON MY RESEARCH, THERE IS A LARGE CLASS OF TOYOTA CUSTOMERS AFFECTED BY THIS DEFECT. PLEASE INVESTIGATE AND ADVISE. *TR

Mileage: 149,325

THE BRAKE LIGHT CONSTANTLY GOES ON AND OFF. TRAC OFF, VSC TRAC AND CHECK ENGINE LIGHTS ALL COME ON. A LOUD RATTLING NOISE COMING FROM THE FRONT END OF VEHICLE AND VIBRATION THE ENGINE WILL NOT ACCELERATE RANDOMLY WHILE DRIVING AND THE TRAC CONTROL LIGHT GOES ON AT THE SAME TIME. *TR

Mileage: 120,400

TL* THE CONTACT OWNS A 2005 TOYOTA SEQUOIA SR5. THE CONTACT STATED THAT WHILE PARKED, THE CHECK ENGINE LIGHT, TRAC OFF, AND VSC TRAC WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE SECONDARY AIR INTAKE PUMP AND VALVE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE CONTACT STATED A REPORT WAS FILED WITH THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 121,600.

Mileage: 121,600

SLOWING DOWN TO TURN THE VSC TRAC< TRAC OFF < CHECK ENGINE<BRAKE LIGHTS COME ON. THIS HAS HAPPENED THREE TIMES AND I TEMPORARILY LOSE CONTROL OF BRAKING AND EXCELLERATION. THIS IS DANGEROUS AND NEARLY CAUSED ME TO ENTER TRAFFIC IN AN INTERSECTION. *TR

Mileage: 167,000

THE SKID CONTROL COMPUTER ON MY 2005 TOYOTA SEQUOIA MALFUNCTIONED CAUSING LOW POWER/LOW ACCELERATION. THE ENGINE HAS 65,000 MILES. BECAUSE THIS PART FAILED, SEVERAL ENGINE PARTS MALFUNCTIONED. THE ENGINE NEARLY BLEW UP AS A RESULT. TOYOTA RECALLED 2003-04 MODELS FOR THIS SAME PROBLEM, BUT HAS ONLY ISSUED A TSB FOR THE 2005 MODEL. THE SERVICE DEPARTMENT AT THE DEALERSHIP EXPLAINED THAT MY ENGINE WOULD NOT HAVE NEARLY EXPLODED HAD THE SKID COMPUTER NOT BEEN FAULTY. I FILED A COMPLAINT WITH TOYOTA, AND THEY EXPLAINED THAT THIS PART IS NOT CONSIDERED TO BE A PROBLEM IN THE 2005 MODEL, AND WILL NOT ASSIST IN REPAIRING IT. THE ESTIMATED REPAIR FOR THIS IS $4000. *TR

Mileage: 65,000