2004 TOYOTA SIENNA Seat Belts Problems

Driver's side seat belt buckle stopped locking in seat belt. Buckle unit then came apart. I called toyota; was informed that there was a recall on this matter. I was told that I was 2 years past the scope of the recall. I informed them I never received a notice of recall so how would I be aware of problem until it occurred. Spoke to supervisor was told I was no longer covered under recall. Went to 2 mechanics and was unable to obtain needed part. I feel that for this safety item there should be no time limit on a recall and I felt Toyotas help in remeding the situation was poor especially as they tout their vehicles safety.

Drivers side seat belt broke and was replaced. Fuel sensor not replaced causes vehicle to hesitate at times at freeway speed

FROM THE TIME I PURCHASED MY 2004 TOYOTA SIENNA, THE DRIVER-SIDE SEAT BELT HAS NEVER WORKED PROPERLY. MOST OF THE TIME IT WOULD NOT RETRACT, BUT WAS SOMETIMES FIXABLE BY MOVING THE HEIGHT ADJUSTER UP AND DOWN. SOMETIMES IT WOULD BE OVER-EXTENDED FOR DAYS, THEN RETRACT ON ITS OWN. IT IS NOW FULLY EXTENDED AND UNABLE TO RETRACT. I MADE AN APPOINTMENT TWO WEEKS IN ADVANCE WITH A TOYOTA DEALERSHIP (80 MILES AWAY) TO FIX IT BUT, BECAUSE OF A MISCOMMUNICATION, THEY WERE PREOCCUPIED WITH REPAIRING FOUR RECALL ISSUES AND NEGLECTED TO ADDRESS THE SEAT BELT PROBLEM. INSTEAD, THEY GAVE ME AN ESTIMATE OF $335 TO REPLACE IT. THE FOLLOWING STATEMENT, DATED JAN 7, 2016, WAS SENT TO OWNERS OF 2004-2006 TOYOTA SIENNAS. APPARENTLY THE FORMER VEHICLE OWNER DID NOT FOLLOW THROUGH. I PURCHASED THE VEHICLE FROM A MAUI DEALERSHIP IN OCTOBER OF 2018. "WARRANTY ENHANCEMENT PROGRAM ' ZF2 2004 ' 2006 MODEL YEAR SIENNA VEHICLES EXTENSION OF WARRANTY COVERAGE FOR FRONT SEATBELT ASSEMBLIES TOYOTA HAS RECEIVED A NUMBER OF REPORTS REGARDING FRONT SEATBELTS IN CERTAIN 2004 ' 2006 MODEL YEAR SIENNA VEHICLES. IN THESE REPORTS, CUSTOMERS HAVE INDICATED THAT THE FRONT SEATBELTS (RIGHT AND/OR LEFT) MAY SLOWLY OR NON-SMOOTHLY RETRACT. ALTHOUGH THE FRONT SEATBELT ASSEMBLY IS COVERED BY TOYOTA'S NEW VEHICLE LIMITED WARRANTY FOR 5 YEARS OR 60,000 MILES (WHICHEVER COMES FIRST), WE AT TOYOTA CARE ABOUT THE CUSTOMERS' OWNERSHIP EXPERIENCE. TOYOTA IS NOW EXTENDING THE WARRANTY COVERAGE FOR REPAIRS RELATED TO SLOW OR NON-SMOOTH RETRACTION OF FRONT SEATBELTS." SINCE THIS IS OBVIOUSLY A COMMON AND HAZARDOUS PROBLEM WITH 2004-2006 SIENNAS, IT SEEMS LIKE IT SHOULD BE WARRANTIED UNDER A RECALL PROGRAM.

Mileage: 90,000

1) SEATBELT TWISTS AND GETS JAMMED IN THE GUIDE NEAR THE RETRACTOR. SEAT BELT PULLS OUT, BUT THEN WILL NOT RETRACT AS IT IS WEDGED IN THE GUIDE.THIS HAS HAPPENED NUMEROUS TIMES, BUT NOW IT IS QUITE WEDGED. AND UNUSABLE AT THE MOMENT. 2) CABLE THAT PULLS THE SIDE DOOR OPEN AND CLOSED HAS RUSTED AND BROKEN. THIS WAS SUBJECT TO A TOYOTA VOLUNTARY SERVICE CAMPAIGN, BUT MY PROBLEM STARTED AFTER THE EXPIRATION OF THE SERVICE CAMPAIGN.

Mileage: 165,000

PASSENGER SIDE SEATBELT CONSTANTLY GETS JAMMED UP, FOLDED OVER AND RENDERS IT UN-USEABLE. VERY UNSAFE!!!! I JUST FIXED IT SO I AM NOT GOING TO RECREATE THE SCENARIO JUST TO GET A PHOTO....THIS IS THE 5TH TIME IT HAS HAPPENED!

Mileage: 75,000

SEATBELT IS NOT PULLING WHEN BUCKLING UP ON THE PASSENGER SEAT.

SEAT BELT BUCKLE UNLATCHES ITSELF WHILE DRIVING (CITY STREETS AS WELL AS HIGHWAY) OR STATIONARY. THIS OCCURS EVER AFTER SHOVING THE TONGUE BACK AND FORTH IN THE LATCH SEVERAL TIMES AND IT REMAINS LATCHED. LATER, IT WILL UNLATCH ITSELF. IT HAS OCCURRED MOSTLY ON STRAIGHTAWAYS, BUT ALSO IN TURNS. I REMOVED THE LATCH ASSEMBLY AND BLEW COMPRESSED AIR THROUGH IT. TWO LARGE RED PLASTIC PIECES CAME OUT, BUT THE PROBLEM RETURNED ON THE NEXT DRIVE. THIS SITUATION HAS BEEN GOING ON FOR ABOUT TWO WEEKS NOW. IT HAS OCCURRED FROM ZERO TO 65 MILES AN HOUR.

Mileage: 111,000

THE FRONT DRIVER AND PASSENGER SIDE SEAT BELTS DO NOT RETRACT. HAVE TO YANK THEM AND TRY ALL KINDS OF THINGS TO GET THEM TO RETRACT.

Mileage: 125,000

DRIVER'S SIDE SEAT BELT ONCE ENGAGED IN CLIP IT KEEPS ON COMING OFF. SOMETIMES IT TAKES SEVERAL TIMES FOR SEAT BELT TO STAY ENGAGED.

Mileage: 2,100,000

WAS GETTING INTO VAN TO DRIVE AND PULLED THE SEATBELT ACROSS MY CHEST, IT WAS SLACK SO PULLED A LITTLE MORE TO GET IT TO RETRACT AND COME OUT, IT WOULD NOT, KEPT COMING OUT AND STUCK ALL THE WAY OUT NOW. WOULD NOT GO BACK IN.

Mileage: 94,000

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE FRONT DRIVER SIDE SEAT BELT FAILED TO PROPERLY RESTRAIN HER. WHILE DRIVING AND WHILE ALSO IN PARK, THE SEAT BELT WOULD RELEASE AND UNSECURED THE CONTACT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SEAT BELT ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 113,310.

Mileage: 113,310

FRONT PASSENGER SIDE SEAT BELT GETS JAMMED WHERE IT COMES OUT OF PILLAR. WON'T RETRACT OR PULL OUT. I HAVE TO REMOVE TRIM AND PULL IT LOOSE FROM INSIDE. THIS HAS HAPPENED MANY TIMES OVER THE LAST SEVERAL YEARS AND IF YOU GOOGLE IT YOU WILL FIND MANY HITS ON THIS.

TOYOTA HAS OFFERED A WARRANTY EXTENSION ON DEFECTIVE DRIVER/PASSENGER SEATBELT MECHANISM, HOWEVER, WHEN I VISITED THE DEALER AND AFTER THEY HAVE CONFIRMED THAT MY SEATBELTS ARE DEFECTIVE, THEY CANNOT PROVIDE AN ESTIMATE ON WHEN THE PARTS NEEDED FOR REPAIR WOULD BE AVAILABLE. I OPENED A CASE WITH TOYOTA CORPORATE, HOWEVER, AFTER NUMEROUS PHONE CALLS AND PROMISES FOR CALLBACK AND RESOLUTION THEY HAVE NOT RETURNED A SINGLE PHONE CALL. THIS IS A SAFETY ISSUE AND NEEDS TO BE ADDRESSED ASAP NOT AFTER SOMEONE DIES IN AN ACCIDENT DUE TO DEFECTIVE SEATBELTS. SYMPTOMS INCLUDE SEATBELTS NOT RETRIEVING, GETTING STUCK, AND OVERALL NOT ADVANCING IN OR OUT REQUIRING THAT THEY BE LOOSE WHEN DRIVING. SEATBELTS ARE GETTING STUCK AT DIFFERENT TIMES, BUT MOST FREQUENTLY WHEN BEING OPERATED SUCH AS EXTENDED OR RETRACTED. ONCE THE SEATBELT IS STUCK, IT'S VERY DIFFICULT TO GET IT GOING AGAIN SUCH THAT MY SPOUSE HAD TO DRIVE HOME ON A FEW OCCASIONS WITHOUT THE SEATBELT. TOYOTA KNOWS ABOUT THIS ISSUE, BUT IS NOT DOING ANYTHING TO FIX IT.

Mileage: 100,000

FRONT SEAT BELTS FAIL TO RETRACT BACK. I SPEND ATLEAST 15 MINS TO RETRACT IT BACK WITH PLIERS EACH TIME IT HAPPENS. HUGE SAFETY ISSUE AS MY FAMILY WITH KIDS USE THE VAN. THE ISSUE IS HAPPENING SINCE I BOUGHT THE VAN (USED) IN JAN2015 AND IT HAPPENED AGAIN TODAY 4/12/2016

Mileage: 120,000

THE PROBLEM: FRONT SEAT BELTS INTERMITTENTLY FAIL TO RETRACT. THIS ISSUE HAS BEEN OBSERVED TO OCCUR WHEN GETTING INTO THE CAR AND FASTENING THE SEATBELT. THIS ISSUE OCCURS INFREQUENTLY BUT REPEATEDLY. TOYOTA HAS PROVIDED A "WARRANTY ENHANCEMENT" FOR THIS PROBLEM. HOWEVER, THE PROBLEM CANNOT BE DUPLICATED "ON DEMAND" AT THE DEALERSHIP (TOYOTA OF PUYALLUP), SO THE DEALERSHIP IS REFUSING TO FIX THE PROBLEM. I HAVE REPEATEDLY EXPLAINED TO THE DEALERSHIP AND TOYOTA CORPORATE THAT THE ISSUE IS INTERMITTENT AND CANNOT BE DUPLICATED "ON DEMAND", AND TOYOTA CORPORATE HAS IN FACT AFFIRMED THAT THE ISSUE IS INDEED "INTERMITTENT." BUT THEY STILL REFUSE TO REPLACE THE SEATBELT MECHANISM WITH AN UPDATED VERSION THAT PURPORTEDLY REMEDIES THE PROBLEM, SIMPLY BECAUSE THE ISSUE CANNOT BE DUPLICATED AT THE TIME WHEN THE CAR HAPPENS TO BE AT THE DEALERSHIP FOR SERVICING. MY CONCERN HERE IS THAT SEATBELTS ARE (OBVIOUSLY) AN INTEGRAL FACET OF PASSENGER RESTRAINT DURING AN ACCIDENT, SO I'M PERPLEXED AS TO WHY TOYOTA IS UNWILLING TO FIX A PROBLEM THAT WOULD APPEAR TO BE RELATED TO PASSENGER SAFETY AND IS -- BY THEIR OWN ADMISSION -- KNOWN TO BE INTERMITTENTLY DUPLICABLE.

Mileage: 90,000

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 13V429000 (POWER TRAIN) AND 05V327000 (SEAT BELT) AND STATED THAT THE PARTS NEEDED FOR THE REPAIRS WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PART DISTRIBUTION DISCONNECT.

THE FRONT DRIVER'S SIDE SEAT BELT HAS A TENDENCY TO FOLD OVER AND GET JAMMED IN THE SLOT WHERE IT RETRACTS. A QUICK SEACH ONLINE HAS FOUND MANY OWNERS WITH THIS SIMILAR ISSUE. WHEN THIS ISSUE OCCURS, IT PRETTY MUCH LEAVES US IN AN UNPROTECTED AND DANGEROUS STATE. SURPRISINGLY, WHAT APPEARS TO BE A SIMILAR PROBLEM HAS PROMPTED A RECALL FOR THE SECOND ROW PASSENGER SEATS, BUT NOT FOR THE FRONT DRIVER'S SIDE. BASED ON THE NUMEROUS CUSTOMER COMPLAINTS ONLINE, IT APPEARS TOYOTA'S ONLY SOLUTION IS TO HAVE CUSTOMERS REPLACE THE SEATBELT SYSTEM FOR HUNDREDS AND HUNDREDS OF DOLLARS. IN REGARDS TO THIS KIND OF SAFETY CONCERN, I AS THE CONSUMER FEEL THAT TOYOTA SHOULD BE RESPONSIBLE TO REPLACE THIS OBVIOUS DESIGN FLAW/OR PRODUCTION DEFECT IMMEDIATELY BY ISSUING A RECALL PARTICULARLY FOR THE DRIVER'S SIDE FRONT. I'M URGING INVESTIGATION INTO THIS SO THAT A SOLUTION CAN BE OBTAINED, BEFORE IT IS TOO LATE, AND SOMEONE IS SERIOUSLY INJURED IN THE EVENT OF AN EMERGENCY OR ACCIDENT. THE SEAT BELT SEEMS TO FOLD OVER TOO EASILY WHEN SEAT BELT IS PULLED A LITTLE FASTER (NOT TO BE CONFUSED WITH THE CLICK AND STOP, WHICH IS HOW ALL SEAT BELTS ARE DESIGNED). THIS IS SEEMINGLY A REGULAR OCCURANCE NOW IN MY CASE, AND FOR THE AFFECTED SIENNA OWNERS, WE CAN'T KEEP TAKING THE CAR BACK TO THE DEALERSHIP, OR TAKING THE INNER PANEL OUT TO FIX OURSELVES (WHICH IS WHAT I'VE BEEN DOING), EVERY OTHER DAY. PLEASE ISSUE A RECALL FOR THIS, AS I AM SURE MANY OWNERS WILL BE VERY GRATEFUL FOR THIS. THANK YOU.

Mileage: 124,000

DRIVERS SEATBELT FOLD OVER AND BECOMES STUCK IN ITS RETRACTION SLOT. SEATBELT IS UNUSABLE. I NEED TO DRIVE WITHOUT A SEATBELT. UNABLE TO FIX BY SELF. I THEN NEED TO TAKE TO DEALER OR MECHANIC TO HAVE SEATBELT UNTWISTED. THIS HAS OCCURRED NUMEROUS TIMES OVER THE PAST 3-5 YEARS. [INTERNET SEARCH FINDS NUMEROUS PERSONS COMPLAINING ABOUT THIS ISSUE FOR 2004 SIENNA]. *TR

Mileage: 80,000

THE FRONT PASSENGER SEAT BELT GOT STUCK IN LOOSE CONDITION SO IT IS UNSAFE FOR ANYONE TO SIT IN THE FRONT PASSENGER SEAT. *TR

Mileage: 110,000

THE DRIVER SIDE SEATBELT TWISTS AND GETS STUCK IN THE BEZEL. THIS HAS HAPPENED SEVERAL TIMES AND I HAVE BEEN ABLE TO FIX IT AFTER WORKING ON IT FOR A FEW MINUTES BUT TODAY IT HAPPENED AGAIN AND I WAS UNABLE TO FIX IT AND AM FORCED TO DRIVE WITHOUT A DRIVERS SEATBELT!!! I HAVE ONLY OWNED THIS CAR FOR THREE WEEKS AND HAVE HAD THIS SEAT BELT GET STUCK AFTER NORMAL USE AT LEAST 6 TIMES. *TR

Mileage: 119,000

THE DRIVER'S SIDE SEATBELT GETS FOLDED UP AND CANNOT RETRACT. THIS WAS A SAFETY ISSUE BECAUSE I HAD TO DRIVE WITH NO EFFECTIVE SEATBELT UNTIL I COULD GET HOME AND FIX IT. THIS IS NOT THE FIRST TIME THIS HAS HAPPENED. ONCE I TOOK IT TO GET FIXED BUT RECENTLY I LEARNED HOW TO FIX IT MYSELF. THIS REQUIRED TOOLS AND ABOUT 30 MINUTES TO COMPLETE. IF THIS HAPPENS AGAIN WHEN I AM NOT AT HOME OR DON'T HAVE TIME TO FIX IT, I'LL BE IN THE SAME UNSAFE SITUATION AGAIN. PLEASE ISSUE A RECALL. *TR

Mileage: 113,344

THE DRIVER SIDE SEATBELT GETS JAMMED AND CANNOT BE USED. THIS HAS HAPPENED MULTIPLE TIMES AND RENDERS THE VEHICLE UNUSABLE. *JS

Mileage: 100,000

BOTH FRONT SEAT BELTS FAIL TO RETRACT, REMAINING MUCH TOO LOOSE TO PROVIDE SAFETY TO PASSENGER. I HAVE BEEN ABLE TO FOOL WITH THE MECHANISM IN VARIOUS WAYS AND GET THE SEATBELT WORKING AGAIN UNTIL TODAY -- 3-28-14. DRIVER'S SIDE IS FULLY EXTENDED, FOLDED OVER, AND THERE IS NO WAY TO GET IT UNFOLDED AND REACTIVATE THE RETRACTING NOW THAT IT IS FULLY EXTENDED. I HAVE ACTUALLY BEEN FUSSING WITH THIS ON AND OFF FOR A COUPLE OF YEARS, BUT IN THE LAST MONTH IT IS CONSTANT. I LOOKED FOR A SOLUTION ONLINE AND DISCOVERED IT IS A VERY COMMON PROBLEM FOR SIENNA OWNERS. ALL AGREE THAT ONCE THE BELT IS ALL THE WAY OUT, IT CANNOT BE FIDDLED WITH ENOUGH TO FIX IT. *TR

Mileage: 142,500

I LOVE THIS VEHICLE, BUT THE DRIVERS SIDE SEATBELT PERIODICALLY STICKS. I'VE TRIED PULLING MORE BELT OUT, OFTEN RUNNING OUT OF BELT AND NOT BEING ABLE TO GET UNSTUCK INITIALLY. SOMETIMES THE BELT HAS FOLDED OVER, BUT NOT IN ALL INSTANCES. I HAVE OFTEN HAD TO USE NEEDLE NOSE PLIERS TO GRIP, PULL AND/OR FLIP THE BELT OVER IF FOLDED. OFTEN THIS TAKES 10 MINUTES TO CORRECT. THIS HAS HAPPENED WHEN I'M NOT AT HOME, AND I'VE HAD TO DRIVE HOME WITH NO SEAT BELT. THIS IS A CONSISTENT PROBLEM, AND ONE MY TUNDRA, AVALON AND ECHO DO NOT EXPERIENCE. I AM AN AVID TOYOTA OWNER, STILL OWNING 3 OF 4 I'VE BOUGHT. TOYOTA SHOULD RESOLVE THIS ISSUE AS IT SEEMS FROM THE ONLINE COMMUNITY THAT SEAT BELTS 'LOCKING' IS A PERSISTENT ISSUE. *TR

Mileage: 149,943

ON THE DAY I PURCHASED THIS (USED) VEHICLE, I NOTICED THAT THE DRIVER'S SIDE SEATBELT WOULD NOT RETRACT. AFTER EXAMINING THE SEAT BELT I NOTICED THAT IT HAD FOLDED IN ON ITSELF AND WAS JAMMED AT THE SITE OF WHERE IT RETRACTS. I COULD SEE THAT BELT WAS NOT ONLY FOLDED ON ITSELF FROM THE OUTSIDE, BUT ALSO PAST THE PLASTIC HARDWARE AND BEHIND THE CASING. I COULD NOT UNFOLD THE BELT WITH MY HANDS BECAUSE THE FOLDED PART OF THE BELT WAS INSIDE THE PLASTIC, WHICH I BELIEVE IS WHERE THE TROUBLE WAS OCCURRING. I HAD TO DRIVE HOME WITH A LOOSE SEATBELT (AS I HAD PULLED IT OUT WHILE TRYING TO GET IT TO RETRACT) AND USE A PAIR OF PLIERS TO UNTWIST THE FOLDED PART. THIS HAS HAPPENED EVERY SINGLE DAY SINCE I PURCHASED THIS VEHICLE 6 DAYS AGO. I CALLED MY TOYOTA DEALER WHO SAID THERE IS A SEAT BELT RECALL FOR THE SECOND ROW SEAT BELT, FOR THE SAME PROBLEM, HOWEVER, THERE IS NO RECALL FOR THE DRIVER'S SIDE AND THEREFORE THEY COULD NOT FIX THE PROBLEM. IT IS A BIG PROBLEM WHEN I AM OUT IN PUBLIC AND CANNOT GET THE SEATBELT UNFOLDED. I AM FORCED TO DRIVE MY VEHICLE BACK HOME WITHOUT THE ABILITY/PROTECTION OF USING A SEATBELT. *TR

Mileage: 102,678

THE FRONT SEAT BELTS ON BOTH THE DRIVER'S SIDE AND THE PASSENGER'S SIDE WILL NOT RETRACT. ONCE EXTENDED, THEY GET STUCK IN THE EXTENDED POSITION, MAKING THE SEAT BELT RESTRAIN SYSTEM COMPLETELY INOPERABLE. THE SEAT BELT WILL CLICK INTO THE LOCK MECHANISM, BUT THE BELT IS COMPLETELY LOOSE, AND THE RETRACT/LOCK SYSTEM DOES NOT WORK. THIS IS AN UNSAFE CONDITION. I RESEARCHED ONLINE TO TRY TO FIX THIS PROBLEM MYSELF, AND I FOUND HUNDREDS OF OTHER COMPLAINTS EXACTLY LIKE THIS ONE, EACH WITH VARYING MILEAGE ON THEIR 2004-2010 MODEL YEAR SIENNAS. ITS ONE OF THE MOST POPULAR SELLING MINIVANS, DON'T YOU THINK TOYOTA SHOULD FIX THIS SAFETY ISSUE?? *TR

Mileage: 96,000

IN JUST NORMAL USE, WITHOUT EVER HAVING BEEN INVOLVED IN A COLLISION CAUSING THE SEATBELT TO RESTRAIN A PASSENGER, THE SEAT BELT ON THE FRONT PASSENGER SIDE OVER EXTENDS AND FOLDS. THE BELT WILL NOT RETRACT AND CAUSES THE PASSENGER SEAT TO BE UNUSABLE. THE FOLD IS NEARLY IMPOSSIBLE TO REMOVE AND THE BELT REMAINS EXTENDED. THIS HAS HAPPENED NUMEROUS TIMES OVER THE COURSE OF OWNING THE VEHICLE, TO MANY DIFFERENT PASSENGERS. *TR

Mileage: 76,000

THE FRONT PASSENGER SEATBELT HAS A TENDENCY TO TWIST WHEN RETRACTING. I'VE SEEN ONLINE THAT THIS IS A COMMON PROBLEM WITH TOYOTA SIENNAS. I'VE READ THAT SOME PEOPLE IRON AND STARCH THEIR SEATBELTS - BUT HEAT/MELTING IS A TERRIBLE SOLUTION. *TR

Mileage: 65,000

BELT ON DRIVER SIDE REPEATEDLY JAMS WHEN RETRACTING. *TR

Mileage: 49,000

THE SEAT BELT HAS MANAGED SEVERAL TIMES BECOME TWISTED/JAMMED UP IN THE RETRACTOR PORTION OF THE SEAT BELT. IF AN ACCIDENT WERE TO HAPPEN IN THIS VEHICLE THE SEAT BELT WOULD FAIL TO OPERATE AS IT IS INTENDED, WHICH I FEEL WOULD RESULT IN SERIOUS INJURY. I WOULD LIKE TO HAVE OUR SEAT BELT FIXED AT THE COST OF TOYOTA. *TR

Mileage: 120,000

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THE FRONT DRIVER'S SIDE SEAT BELT WEBBING FAILED TO RETRACT OR PROPERLY RESTRAIN HER. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO STATED THAT THE ENTIRE SEAT BELT ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. THE CURRENT MILEAGE WAS 140,000. *TR

Mileage: 60,000

FRONT PASSENGER SEAT BELT FOLDS OVER ON ITSELF WHEN PULLED TO ENGAGE. THIS PROHIBITS THE USE OF THE SEATBELT. DOES NOT HAPPEN EVERY TIME BUT PROBABLY OCCURS 15 TO 20 TIMES A YEAR. WHEN IT JAMS IF THE OCCUPANT DOES NOT KNOW HOW TO CORRECT THE PROBLEM THEY RIDE WITH NO SEATBELT PROTECTION. TOYOTA WASHES THEIR HANDS AND STATES THAT IT IS OUT OF WARRANTY. *TR

Mileage: 23,000

THE FRONT PASSENGER SEAT BELT OFTEN GETS FOLDED AND JAMMED AND DOES NOT RETRACT. IT TAKES A LOT OF MESSING WITH TO GET IT TO RETRACT. TODAY, I COULD NOT GET IT TO RETRACT, SO IT IS EXTENDED ALL THE WAY SO NOONE CAN SAFELY SIT IN THE FRONT SEAT. *TR

THE FRONT PASSENGER SEAT BELT HAS A TENDENCY TO JAM WHENEVER PUT ON IN A CERTAIN WAY. I HAVE FOUND A WAY TO ALMOST CONSISTENTLY REPEAT IT AND HAVE FOUND THAT IT TENDS TO HAPPEN WITH PASSENGERS OF GREATER GIRTH OR STATURE. DEFINITELY MORE LIKELY TO HAPPEN WHEN THE PASSENGER PULLS THE SEATBELT OUT FORWARD TOWARDS THE DASHBOARD TO PUT IT ON. WHAT HAPPENS IS THE BELT FOLDS OVER DUE TO THE DESIGN OF THE PIVOT AREA AND GETS JAMMED IN THE GAP RESULTING IN AN INOPERATIVE SEATBELT. THIS HAS HAPPENED SO MANY TIMES THAT THE SEATBELT TENSION ON THE PASSENGER SIDE IS NOW NOTICEABLY LOWER THAN THE DRIVER'S SIDE. ALSO REPRODUCIBLE ON THE DRIVER'S SIDE BUT HAPPENS LESS FREQUENTLY MOSTLY DUE TO A CONSISTENT DRIVER. DEFINITELY A HAZARD IF IT CAN'T BE UNJAMMED AS THE SEATBELT CANNOT BE FASTENED OR USED PROPERLY. THERE IS ALSO A HIGH CHANCE OF CAUSING THE BELT TO TWIST INSIDE THE PILLAR WHEN TRYING TO UNJAMMING IT THEREBY DECREASING ITS STRENGTH. HAVE NOT FOUND A WAY TO CONSISTENTLY UNJAM IT EASILY AND USUALLY JUST REQUIRES LOTS OF MANIPULATION. *TR

Mileage: 50,000

THE FRONT SEAT BELTS--ESPECIALLY THE PASSENGERS SEAT BELT, OFTEN BECOME STUCK WHEN EXTENDED BECAUSE OF TWISTING AND FOLDING UP UPON ITSELF. SOMETIMES THE SEAT BELT CANNOT RETRACT AT ALL; MORE OFTEN THAN NOT, BECAUSE OF THE TWISTING, THE SEAT BELT BECOMES JAMMED IN THE FULLY EXTENDED POSITION. THE RESULT IS THAT THE IT THE OCCUPANT ISN'T (ADEQUATELY) RESTRAINED. THIS HAPPENS 5 - 8 TIMES PER WEEK. ALSO A PROBLEM, BECAUSE THE BELT IS NOT RETRACTED, IT FREQUENTLY GETS SLAMMED IN THE DOOR WHEN THE DRIVER OR PASSENGER GET OUT OF THE VEHICLE. OVER TIME, THE INTEGRITY OF THE BELT WILL SUFFER FROM THIS. I NEVER KNOW WHEN THE BELT WILL TWIST. IF A PASSENGER LEANS FORWARD AND THEN BACK,THAT IS ENOUGH FOR THE BELT TO TWIST UPON RETRACTION. NOW I HAVE AN IMPROPERLY RESTRAINED PASSENGER AT RISK FOR INJURY IN A MOVING VEHICLE. PLEASE DO NOT WAIT FOR A FATALITY BEFORE ACTING ON THIS. WE REQUIRE OCCUPANTS TO WEAR BELTS FOR A REASON. IT IS THE LAW. IF TOYOTA'S BELTS ARE FAILING, WE LOSE THE BENEFIT OF THE SEAT BELT AND ARE UNPROTECTED. PLEASE SEE OTHER WEBSITES THAT LIST THIS PROBLEM, THE VIN NUMBERS OF THESE CARS ARE SIMILAR. HTTP://WWW.CARPROBLEMZOO.COM/TOYOTA/SIENNA/SEAT-BELT-PROBLEMS.PHP AND ALSO HTTP://WWW.ABOUTAUTOMOBILE.COM/COMPLAINT/2004/TOYOTA/SIENNA/SEAT+BELT. *TR

Mileage: 98,000

BOTH FRONT SEAT BELTS ON THIS VEHICLE FOLD OVER AND BIND UP. THEY CANNOT BE RETRACTED PROPERLY. THE FRONT PASSENGER SIDE IS BOUND SO BAD, IT IS UNUSABLE. FRUSTRATING. *TR

Mileage: 145,000

FRONT DRIVE AND PASSENGER SEAT BELTS ARE GETTING JAMMED. SOME TIME, UNABLE TO RELEASE THE SEAT BELT, OTHER TIME, SEAT BELT WILL NOT GET LOCKED. *TR

Mileage: 144,521

THE FRONT SEAT BELTS DO NOT RETRACT. I JUST BOUGHT THIS VEHICLE USED NEW YEARS EVE AND THE FIRST TIME USED THE SEAT BELTS JAMMED. I JUST LOOKED ON LINE TO SEE IF THERE IS A FIX AND THERE ARE NONE LISTED, BUT HUNDREDS OF SIENNAS WITH THIS PROBLEM. THIS IS A SAFETY PROBLEM BECAUSE I STILL HAVE TO USE THE VAN, BUT THE FRONT SEAT BELTS DO NOT RETRACT TO TIGHTEN AROUND PASSENGERS. *TR

Mileage: 108,000

THE FRONT SEAT BELTS (BOTH DRIVER AND PASSENGER SIDE) ARE EASILY JAMMED AND GETTING FOLDED OVER SO THAT THE SEAT BELT NEITHER RETRACTS OR PULLS OUT. IT IS EXTREMELY DIFFICULT TO UNJAM THE BELT, AND OFTEN NECESSITATES DRIVING WITHOUT THE SAFETY OF AN EFFECTIVE SEAT BELT. THIS HAS NEVER HAPPENED IN ANY OTHER MAKE/MODEL CAR I'VE DRIVEN - TOYOTA NEEDS TO ADDRESS THIS SAFETY ISSUE PROMPTLY. *TR

Mileage: 70,000

NUMEROUS TIMES THE SEAT BELT FOLDS AS IT IS PULLED OUT AND THEN JAMS. PRIOR TO TODAY I HAVE BEEN ABLE TO GET IT UNFOLDED. TODAY I AM NOT ABLE TO AND NOW CANNOT DRIVE MY CAR SAFELY. IF I CAN'T FIX IT MYSELF I WILL HAVE TO DRIVE IT TO THE TOYOTA DEALERSHIP WITHOUT WEARING THE SEATBELT. *TR

Mileage: 97,000

THE FRONT SEAT BELTS ON THIS VEHICLE JAM ALL THE TIME. THEY FOLD AND JAM WITH THE SEATBELTS UNABLE TO RETRACT AND HOLD THE DRIVER OR PASSENGER IN A SAFE MANNER. THIS IS THE ONLY VEHICLE I HAVE OWNED WITH THIS CONTINUOUS PROBLEM. *TR

Mileage: 145,500

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THE FRONT DRIVERS SIDE SEAT BELT WAS RESTING IN AN UNCOMFORTABLE POSITION ACROSS HER NECK. THERE WAS NO OPTION TO ADJUST THE SEAT BELT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED THERE WAS NO REPAIR AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 2.

Mileage: 2

PASSENGER FRONT SEAT BELT IS TWISTED AND WILL NOT RETRACT AND IS THEREFORE UNSAFE FOR USE. SINCE THIS IS A SAFETY CONCERN, I ASKED TOYOTA DEALERSHIP IF THERE WAS ANY RECALL OR SERVICE BULLETIN ISSUED FOR THIS PROBLEM AND I WAS TOLD THERE IS NOTHING THEY ARE AWARE OF. REQUEST TOYOTA TO INVESTIGATE THIS CONCERN AND TAKE PROMPT ACTION IN RESOLVING THIS SAFETY ISSUE. IF THERE IS A RECALL / SERVICE BULLETIN ISSUED OR IN THE WORKS, PLEASE LET US KNOW. *TR

Mileage: 160,000

I OWN 2004 TOYOTA SIENNA MINI VAN . FOR MANY YEARS, I ALWAYS HAVE A PROBLEM WITH THE DRIVER SIDE SEAT BELT. IT SOMETIMES SIMPLY DOES NOT RETRACT. THE FRONT SEAT BELTS FREQUENTLY JAMMED AND FOLDED AND UNABLE TO RETRACT BY ITSELF. I HAVE TOYOTA DEALERS TO CHECK THE PROBLEM IN 2011 AND 2012, BUT THEY ARE NOT BE ABLE TO FIX IT. PLEASE GO TO THE LINK BELOW, THERE ARE 33 CASES REPORTED THERE HTTP://WWW.CARPROBLEMZOO.COM/TOYOTA/SIENNA/SEAT-BELT-PROBLEMS.PHP NHTSA SHOULD HAVE TOYOTA TO RECALL THIS SAFETY DEFECT. *TR

Mileage: 58,888

ON PASSENGER SIDE, FRONT SEAT BELT FOLDS AND JAMS AS IT IS BEING PULLED OUT TO BE BUCKLED. IF THE BELT IS PULLED OUT FURTHER, IT STAYS JAMMED AND DOES NOT RETRACT, THUS CREATING A HAZARD FOR THE PASSENGER. *TR

Mileage: 100,000

THE SIENNA 2004 FRONT SEAT BELTS ARE GETTING FREQUENTLY JAMMED AND FOLDED AND UNABLE TO FULLY RETRACT. THIS IS A PROBLEM THAT HAS BEEN HAPPENING WITH ALOT OF THE SIENNA OWNERS. THE BELTS ARE GETTING JAMMED, AND UNLESS YOU USE A PLIER TO TWIST TO UNFOLD TO BE ABLE TO GET IT TO ITS RETRACTING POSITION. IT IS A DRIVING HAZARD AS THERE IS ALOT OF SLACK ON THE SEAT BELT WHEN THE RETRACTION IS JAMMED. I TOOK TO DEALER AND SAID THE WHOLE SEAT BELT SYSTEM NEEDS TO BE REPLACED. I FEEL THIS IS A DEFECT WITH THE MANUFACTURING AND A RECALL NEEDS TO BE MADE ON THIS ISSUE. IT IS HAPPENING ON THESE VEHICLE AFTER 4-5 YEARS OF USE. *TR

Mileage: 149,000

SEAT BELT TWISTS AND JAMS EXTREMELY EASILY. EXTENDS ALL THE WAY, AND WILL NOT RETRACT. SOMETIMES IT CAN BE MANIPULATED TO STRAIGHTEN IT AND GET IT TO RETRACT, BUT IT RECURS REGULARLY. THE FRONT PASSENGER SEAT IS NOT USABLE WHEN IT HAPPENS. IT HAS HAPPENED ONCE OR TWICE ON DRIVER'S SIDE, BUT OCCURS AT LEAST ONCE OR TWICE A MONTH ON PASSENGER SIDE. *TR

Mileage: 42,000

THE DRIVERS SEAT BELT IS STUCK IN THE EXTENDED POSITION AND WILL NOT RETRACT. DEALERSHIP SAID THE RETRACTION MECHANISM IS BROKEN AND THE PART COSTS $400. I'VE READ ABOUT MANY OTHER OWNERS HAVING THE SAME PROBLEM. WHEN WILL SOMETHING LIKE THIS BE RECALLED. IT IS A REAL SAFETY ISSUE. *TR

Mileage: 90,000

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THE FRONT DRIVER'S SIDE SEAT BELT WEBBING FAILED TO RETRACT AND PROPERLY RESTRAIN THE OCCUPANT. THE EXCESS WEBBING WAS HANGING ON THE FLOOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO PERFORMED A TEMPORARY REPAIR. THE TECHNICIAN STATED THE ENTIRE SEAT BELT ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

THE DRIVER'S SEAT BELT CONTINUOUSLY BINDS UP IN THE RE-TRACTOR BEZEL. BECAUSE OF THIS THE RE-TRACTOR UNIT DOES NOT FUNCTION PROPERLY. SOME TIMES IF YOU DO GET IT TO COME OUT, YOU CAN GET IT LATCHED BUT THE BELT FAILS TO TIGHTEN. IN OTHER CASES IT BINDS SO BADLY THAT THE SIDE WALL MUST BE TAKEN APART TO FREE IT. *TR

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE FRONT SEAT BELTS FAILED AND WOULD BECOME JAMMED WHEN RETRACTED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE DEALER ADVISED THE CONTACT THAT THE SEAT BELTS FOR THE FRONT DRIVER AND PASSENGER SIDES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000.

Mileage: 66,000

TL* THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THAT THE REAR SEAT BELTS WOULD NOT SECURE IN THE LATCH. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 1 AND THE CURRENT MILEAGE WAS 129,000. THE VIN WAS UNAVAILABLE.

Mileage: 1

BOTH THE DRIVER'S AND PASSENGER'S SIDE SEAT BELT REPEATEDLY CATCH SO THAT THEY ARE STUCK AND FULLY EXTENDED. OFTEN IT TAKES HOURS TO WIGGLE THE SEAT BELTS BACK INTO POSITION SO THAT THEY ACTUALLY ROLL FREELY. *TR

Mileage: 40,000

TL*THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE CONTACT STATED THE FRONT DRIVER'S SEAT BELT INTERMITTENTLY JAMMED AND BECAME STUCK WHENEVER HE ATTEMPTED TO BUCKLE THE BELT. THE SEAT BELT WOULD BECOME STUCK WHILE PARTIALLY REMOVED FROM IT'S RETRACTOR. IN ORDER TO REMOVE THE BELT FROM THE JAMMED POSITION, THE CONTACT WOULD NEED THE ASSISTANCE OF A SCREW DRIVER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THE VEHICLE WAS OPERATING AS INTENDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 25,000 AND THE CURRENT MILEAGE WAS 65,000. THE VIN WAS UNAVAILABLE. UPDATED 06/08/11*LJ

Mileage: 25,000

2004 TOYOTA SIENNA. THE DRIVER'S SEAT BELT GETS STUCK IN THE BEZZLE AND FAILS TO RETRACK. THIS HAPPENS ALMOST EVERYTIME I TRY TO USE THE SEAT BELT CREATING A SERIOUS SAFETY CONCERN. MANY OWNERS OF THE SAME VEHICLE REPORTED THE SAME PROBLEMS. THERE WAS A RECALL ON THE SEAT BELT FOR MIDDLE SEATS. THE SEAT BELT FOR DRIVER'S SEAT SHOULD BE ALSO RECALLED. *TR

Mileage: 95,000

THE DRIVER SEAT BELT IN MY 2004 TOYOTA SIENNA GETS TWISTED AND STUCK WHERE IT RETRACTS INTO THE SIDE PANEL. THIS CONTINUES TO HAPPEN OVER AND OVER AND IT IS DIFFICULT TO FIX. SOMETIMES FIXING IT REQUIRES RIPPING APART THE SIDE PANEL. THIS HAS BEEN HAPPENING SINCE ABOUT 2007. WE ARE OFTEN LEFT WITHOUT A WORKING SEAT BELT AND EVEN MORE OFTEN LEFT WITH AN ILL FITTING SEAT BELT. THE DEALERSHIP WANT $500 TO REPLACE BUT I FEEL IT WAS A DEFECTIVE DESIGN AND IS LIKELY TO HAPPEN AGAIN. *TR

3RD ROW MIDDLE SEAT IS EQUIPPED WITH A CEILING DROP DOWN SEAT BELT FOR THE SHOULDER ASSEMBLY. THE ASSEMBLY IS TO HOOK INTO A HOLDER IN THE CEILING WHEN NOT IN USE. WHEN PULLED FROM THE CEILING IT ATTACHES TO THE LAP BELT FOR USE BY THE REAR MIDDLE OCCUPANT. THE ASSEMBLY DOES NOT STAY HOOKED AND WILL FALL OUT OF THE CEILING HOLDER AFTER DRIVING A MILE OR TWO, STRIKING THE OUTER REAR (PASSENGER SIDE) OCCUPANT IN THE HEAD. HAPPENS CONSTANTLY, DEALER SAYS THERE IS NO FIX. *TR

Mileage: 30,000

THE DRIVERS SEAT BELT JAMS AND WILL NOT RETRACT. OCCASIONALLY WHEN PULLED OUT, THE DRIVERS SEAT BELT FOLDS OVER AND JAMS IN THE TOP MOST EXIT (ROLLER) AS IT COMES OUT OF THE PILLAR AND INTO THE DRIVERS AREA. THE BELT WILL NOT RETRACT WITHOUT STOPPING THE CAR AND CLEARING THE TWIST THAT RESULTS IN THE JAM. SOMETIMES YOU HAVE TO REMOVE THE COVER ON THE PILLAR THAT THE BELT RETRACTS INTO. THIS EFFORT TAKES LONGER AND REQUIRES YOU TO GO INTO THE BACK SEAT FOR ACCESS. THIS HAS HAPPENED 3 TIMES IN THE LAST 30 DAYS AND 10 TIMES IN THE LAST YEAR. MY WIFE HAS DRIVEN HOME EACH TIME THIS OCCURS WITH THE SEAT BELT "JAMMED" SO I CAN MAKE THE REPAIRS. SHE ISN'T STRONG ENOUGH TO REPAIR THE CAR ONCE THE JAM OCCURS. *TR

Mileage: 139,968

THE SEATBELTS IN THE MIDDLE ROW DO NOT ALWAYS WORK PROPERLY. THEY FREQUENTLY LOCK UP OR DON'T FLOW SMOOTHLY FROM THE BELT CASE. IT CONCERNS ME THAT THE SEAT BELTS WILL NOT PROPERLY RESTRAIN MY CHILDREN IN THE EVENT OF AN ACCIDENT. THIS HAPPENS SEVERAL TIMES A WEEK. *TR

Mileage: 10,000

2004 TOYOTA SIENNA. THE PASSENGER SIDE AUTOMATIC SLIDING DOOR WILL NOT OPEN AUTOMATICALLY OR FROM WITHIN. CHILDREN SITTING IN THE BACK THAT COULD NOT OPEN FROM THE INSIDE AND HAD TO CRAWL OUT OVER CAR SEATS TO THE OTHER DOORS. MYSELF INCLUDED WHEN I SHUT THE DOOR TO CLEAN THE INTERIOR. THE PASSENGER SIDE SEAT BELT (SECOND ROW CABIN CHAIR) WON'T RETRACT AND WAS CHECKED AND FOUND THAT THE SEAT BELT WAS NOT TWISTED TO CAUSE THE MALFUNCTION, BUT WITH THE DEVICE ITSELF. *CN

THE SEAT BELTS ON OUR 2004 TOYOTA SIENNA MINIVAN DO NOT WORK PROPERLY. APPROXIMATELY ONCE EVERY TEN TO TWELVE DAYS, THE BELTS WILL NOT RETRACT PROPERLY TO THEIR ORIGINAL POSITION. THE BELTS CURRENTLY NOT WORKING PROPERLY ARE THE DRIVER SIDE AND THE MIDDLE SEAT PASSENGER SIDE. WE HAVE TAKEN THE VEHICLE BACK TO COBB COUNTY TOYOTA IN GEORGIA FOR REPAIR. THEY CLAIM IT IS "USER ERROR," A CHARACTERIZATION I COMPLETELY REJECT. I HAVE DRIVEN SEVERAL CARS AND HAVE NEVER HAD A PROBLEM LIKE THIS. THEY HAVE MANAGED TO RETURN THE BELTS TO THEIR ORIGINAL POSITION BUT WITHIN A FEW DAYS TO A WEEK, THEY ARE IMPROPERLY WORKING AGAIN. WE ALL KNOW THAT SEAT BELTS ARE ONE OF THE MOST IMPORTANT PIECES OF SAFETY EQUIPMENT IN A VEHICLE. IF THEY DO NOT WORK PROPERLY, THE EVIDENCE IS CLEAR THAT PASSENGERS IN THAT VEHICLE ARE MUCH MORE LIKELY TO DIE. I BELIEVE THIS IS A MANUFACTURER'S DEFECT WHICH SHOULD BE REMEDIED IMMEDIATELY. *TR

Mileage: 80,000

DRIVER SIDE SEAT BELT NOT EASILY RELEASED *TW

Mileage: 98,915

IT HAPPENED TWICE DURING 2 WEEKS AGO ( DURING HEAVY RAIN). I WAS DRIVING MY 2004 TOYOTA SIENNA ON A PARKING LOT. THE STEERING WHEEL IS VERY HARD TO TURN, IT SEEMS LIKE I LOST THE POWER STEERING. AFTER RESTARTING THE VAN, THE PROBLEM DISAPPEARED. NEXT DAY, MY WIFE ENCOUNTERED THE SAME PROBLEM WHEN SHE IS PICKING UP OUR KIDS FROM SCHOOL. WE BELIEVE THERE IS A MAJOR PROBLEM WITH THE ELECTRICAL SYSTEM OR COMPUTER SYSTEM. I HAVE SO MANY PROBLEM WITH THIS VANS AND THE DEALER REFUSE TO FIX IT, I HAVE SEAT BELT PROBLEM, IT IS NOT EASY TO RELEASE AFTER DRIVING, DEALER WANTS 300 TO FIX. ELECTRICAL SLIDING DOOR PROBLEM ETC. *TR

Mileage: 110,000

I WAS DRIVING WITH TWO OF MY BOYS IN BOOSTERS IN THE 3RD ROW SEAT. THE BOY ON THE PASSENGER SIDE PULLED THE MIDDLE SEAT BELT DOWN FROM THE CEILING AND WRAPPED AROUND HIS NECK TWICE AND THEN PUT THE BUCKLE IN THE LAP CLASP. I WAS DRIVING AND HAD THE RADIO ON. LUCKILY MY 14 YEAR OLD DAUGHTER NOTICED HIM STRUGGLING AND BEGAN SCREAMING, "HE'S CHOKING, HE'S CHOKING"; SHE IMMEDIATELY JUMPED OVER THE SEAT AND TRIED TO FREE HIM WHILE I STOPPED THE CAR IN TRAFFIC. SHE FRANTICALLY TRIED TO UNDO THE BELT; HE WAS UNABLE TO MAKE ANY NOISE. ANYONE THAT HAS A SIENNA KNOWS THAT THE MIDDLE SEAT BELT ON THE THIRD SEAT CLIPS INTO A LAP BELT THAT YOU NEED A PEN OR KEY TO RELEASE. AS MY SON STRUGGLED, AND WIGGLED TO FREE HIMSELF THE BELT BECAME TIGHTER, LOCKED IN AND WAS BASICALLY HANGING HIM IN HIS BOOSTER SEAT. I STOPPED IN TRAFFIC, GOT IN BACK AND WAS ABLE TO LIFT THE BOOSTER UP IN THE AIR SO THAT IT WASN'T CHOKING HIM BUT COULDN'T RELEASE THE BELT. MY 15 YEAR OLD WAS IN THE FRONT SEAT AND I ASKED HER TO TAKE THE KEYS OUT OF THE IGNITION, WHICH I USED TO RELEASE THE BUCKLE. MY SON IS FINE. LUCKILY MY DAUGHTER SAW WHAT WAS HAPPENING. *TR

Mileage: 73,000

"CLUNKING" NOISE NOTED ON STEERING THE 2004 TOYOTA SIENNA JUST A FEW MONTHS AFTER IT WAS BOUGHT. IT HAD GONE THROUGH 3 RECALLS ALREADY WHEN FIRST THE FUEL TANK, THEN THE DOOR SILLS, THEN THE MIDDLE ROW SEATBELT BEZEL, AND FINALLY RECENTLY, THE REAR HATCH STRUTS WERE ALL REPLACED. VEHICLE WAS TEST DRIVEN, BUT NO MENTION OF "CLUNKING" DOCUMENTED. HOWEVER, ALL THIS TIME, THE CLUNKING HAD BECOME MORE NOTICEABLE, AND VEHICLE HAD GONE THROUGH 2 ALIGNMENTS ALREADY, WITH ONLY ABOUT 42,000 MILES ON IT. LAST SERVICED FOR ALIGNMENT, DEALER DID NOTE CLUNKING AND RECOMMENDED REPLACEMENT OF INTERMEDIATE STEERING SHAFT. IT IS NOW BECOMING MORE DIFFICULT TO STEER THE VEHICLE, ESPECIALLY AT LOW SPEEDS, AND "K-TURNS" NOW REQUIRE MORE MANEUVERS, AND THE STEERING RADIUS HAS INCREASED POTENTIALLY CAUSING COLLISIONS WITH OBJECTS OR PEDESTRIANS IF COMPENSATORY ACTION IS NOT INITIATED. (STEERING OUTPUT HAS SOMETIMES BEEN UNPREDICTABLE). SECOND COMPONENT IS LACK OF TPMS SENSORS WHEN TIRES WERE CHANGED AT A FACILITY, AND I HAD THE FACILITY DOCUMENT THE LACK OF SENSORS. *TR

Mileage: 1,200

BOTH FRONT SEATBELTS IN OUR 2004 TOYOTA SIENNA HAVE REPEATEDLY JAMMED IN THE PLASTIC BEZEL WHEN RETRACTED OR EXTENDED, RENDERING THEM USELESS. WITH CONSIDERABLE EFFORT THE SEATBELTS HAVE BEEN LOOSENED, HOWEVER, THEY ARE NOW TWISTED INSIDE. HAVING DONE A QUICK SEARCH ONLINE, THIS APPEARS TO BE AN ONGOING SOURCE OF FRUSTRATION AND HAZARD FOR A NUMBER OF VAN OWNERS. *TR

TL*THE CONTACT OWNS A 2004 TOYOTA SIENNA. WHILE DRIVING 40 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL, BUT THE VEHICLE DID NOT STOP. THERE WERE 30-40 YARDS BETWEEN THE CONTACT'S VEHICLE AND THE PRECEDING VEHICLE. THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD. THE BRAKES GRABBED MOMENTARILY, BUT THEN BECAME "MUSHY." THE CONTACT CRASHED INTO THE PRECEDING VEHICLE AND CAUSED INJURIES TO THE OCCUPANT IN THE OTHER VEHICLE. THE PASSENGER'S SEAT BELT DID NOT ENGAGE PROPERLY, CAUSING THE PASSENGER TO STRIKE THE DASHBOARD AND SUSTAIN MINOR INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED FROM THE SCENE. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 55,000.

Mileage: 55,000

ALL SEAT BELTS STICKING OR NOT RETRACTING. *TR

Mileage: 91,342

TL*THE CONTACT OWNS A 2004 TOYOTA SIENNA. THE SHOULDER PORTION OF THE SEAT BELT BINDS IN THE BEZEL TRIM PIECE. THE AFFECTED SEAT BELT BEZEL IS LOCATED ON THE SHOULDER PORTION ON THE FRONT DRIVER SIDE SEAT. THE SEAT BELT BINDS IN THE BEZEL, AND THE EXTRA WEBBING RESULTS IN AN IMPROPERLY FITTED SEAT BELT ON THE DRIVER. THE POWERTRAIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 26,000 AND CURRENT MILEAGE WAS 28,000.

Mileage: 26,000

DRIVER'S SEAT BELT JAMS WHERE IT COMES OUT OF THE SEATBELT GUIDE ASSEMBLY CAUSING EXCESS SLACK IN THE SEAT BELT SO THAT IT IS INOPERABLE. I HAVE ONLY BEEN ABLE TO UNCANNY IT ONCE AND HAVE HAD TO DRIVE IT TO THE DEALERSHIP WITHOUT SEAT BELT PROTECTION TO HAVE THEM UNJAM IT. THEY SOMEHOW YANK IT LOOSE BUT WE HAVE ONLY BEEN ABLE TO DO THIS ONCE (TODAY). IT IS STARTING TO JAM ALMOST EVERY TIME ITS USED NOW AND DESPITE BEING VERY CAREFUL, IT HAS COMPLETELY JAMMED 5 TIMES NOW. IT IS A 2004 TOYOTA SIENNA LIMITED MINIVAN. *TR

Mileage: 70,000

AT TIMES WHEN THE DRIVER QUICKLY PULLS OUT HIS SHOULDER BELT THE BELT DOUBLES OVER ITSELF INSIDE THE GUIDE ON THE DOOR POST BEHIND AND TO THE LEFT OF THE DRIVER'S SHOULDER. IF THE DRIVER CONTINUES TO PULL THE BELT THE AMOUNT OF OVERLAP INCREASES CAUSING THE BELT TO JAM VERY TIGHLY INSIDE THE BELT GUIDE. WHEN THIS HAPPENS IT IS ALMOST IMPOSSIBLE TO UNDO THE DOUBLED OVER BELT (WITHOUT DAMAGING THE BELT) UNLESS THE TRIM PANEL AND MECHANISM THAT ATTACHES THE BELT GUIDE TO THE CAR FRAME IS REMOVED. THE SHOULDER/SEAT BELT CANNOT BE USED WHEN THE BELT IS DOUBLED OVER AND JAMMED TIGHTLY INSIDE THE GUIDE SINCE THE BELT LENGTH CANNOT BE ADJUSTED. AS SUCH, WHEN THIS FAULT OCCURS, THE DRIVER WOULD BE UNBELTED WHEN OPERATING THE VEHICLE. *TR

Mileage: 38,757

FRONT SEAT PASSENGER UNFASTENED FRONT SEAT BELT WHEN EXITING VEHICLE AND NOTED THAT SEAT BELT WOULDN'T RETRACT. *TR

Mileage: 50,000

DRIVER SEAT BELT FAILS TO RETRACT AS THE STRAP GETS CAUGHT IN THE OPENING WHERE IT RETRACTS. IT DID THIS ON RARE OCCASION UNDER WARRANTY BUT NOW DOES IT CONSTANTLY. THERE FORE THE SEAT BELT IS VERY LOOSE AND DOES NOT RESTRAIN THE OCCUPANT. THE REAR BELTS WERE RECALLED FOR THIS TYPE OF DEFECT AND WERE WORKING FINE AT THE TIME OF THE RECALL. THIS PROBLEM HAS BEEN IGNORED BY THE DEALER UNDER WARRANTY AND NOW THEY SIMPLY WORK IT FREE WHEN WE BRING IT IN, DESPITE US TELLING THEM THAT IT RECURS DAILY. *TR

DRIVER SEAT BELT FAILS TO RETRACT AS THE STRAP GETS CAUGHT IN THE OPENING WHERE IT RETRACTS. IT DID THIS ON RARE OCCASION UNDER WARRANTY BUT NOW DOES IT CONSTANTLY. THERE FORE THE SEAT BELT IS VERY LOOSE AND DOES NOT RESTRAIN THE OCCUPANT. THE REAR BELTS WERE RECALLED FOR THIS TYPE OF DEFECT AND WERE WORKING FINE AT THE TIME OF THE RECALL. THIS PROBLEM HAS BEEN IGNORED BY THE DEALER UNDER WARRANTY AND NOW THEY SIMPLY WORK IT FREE WHEN WE BRING IT IN, DESPITE US TELLING THEM THAT IT RECURS DAILY. *TR

I OWN A 2004 TOYOTA SIENNA. SINCE 7,000 I HAVE BEEN IN NUMEROUS TIMES TO FIX THE MIDDLE PASSENGER SEATBELT. IT BECOMES TWISTED AND UNABLE TO RETRACT PROPERLY. IT HAS BEEN REPLACED TWICE AND UN-TANGLED SEVERAL TIMES BY THE DEALERSHIP. THEY HAVE TAKEN THE SEAT OUT TO REPAIR IT NUMEROUS TIMES. IT HAS HAD THE RECALL DONE IN THE PAST. RECENTLY IT WAS BROUGHT BACK FOR ANOTHER SEATBELT REPLACEMENT DUE TO IT BEING TIGHTLY CAUGHT INSIDE THE SEAT. WHEN THE CAR WAS RETURNED TO ME, THE SAME SEAT NO LONGER LOCKED INTO PLACE. IT WAS BROUGHT BACK TO THE DEALERSHIP AND I HAVE BEEN TOLD THEY WILL NOT FIX IT BECAUSE IT WAS CAUSED BY CRUMBS BEING IN THE TRACK WHEN THE SEAT WAS PUT BACK IN. I HAVE NEVER FELT SAFE BUT A CHILD IN THIS SEAT BECAUSE I NEVER KNEW WHEN THE SEATBELT WOULD NOT RETRACT PROPERLY. I HAVE TRIED TALKING WITH THE DEALERSHIP ABOUT REPAIRING THE SEAT HOWEVER THEY REFUSE. THIS SEAT IS NOT SAFE. *JB

Mileage: 7,800

THE DRIVER SIDE SEAT BELT SOMETIMES FAILS TO RETRACT. WHEN I PULLED THE BELT OUT, IT STAYED OUT AND WOULD NOT RETRACT. I INSPECTED THE AREA AND FOUND NO INTERFERENCE. THIS HAPPENED ON A SAT. I DROVE THE VEHICLE SAT. AND SUN WITH A FAULTY BELT. I CALLED THE DEALERS SERVICE DEPT. TOLD THEM THE PROBLEM BUT COULDN'T GET IN FOR A WEEK. IN THE MEANTIME, THE BELT BEGAN TO WORK AGAIN. THE DEALER SAID"BRING IT BACK WHEN IT DOESN'T WORK." I HAVE A PHOBIA NOT KNOWING WHEN THE SEAT BELT WILL FAIL AGAIN. THE VEHICLE IS A 2004 TOYOTA SIENNA. I PURCHASED IT NEW FROM THE SAME DEALER. CARMAX IN KENOSHA WI. I SENT THIS SAME E MAIL TO TOYOTA. *JB

Mileage: 21,890

DT*: THE CONTACT STATED THE FRONT DRIVER SEATBELT BUCKLE DID NOT STAY LATCHED. THE RELEASE BUTTON ON THE SEATBELT WAS DEPRESSED A COUPLE TIMES, AND THEN THE BUCKLE LATCHED. AFTER THIS INCIDENT, THE SEATBELT NO LONGER STAYED LATCHED AT ALL. THERE WAS AN AUDIBLE CLICK WHEN THE BUCKLE WAS FORCEFULLY LATCHED INTO PLACE. ALSO, THE CONTACT STATED THAT THERE WAS DIFFICULTIES RELEASING THE BUCKLE AFTER THE FIRST INCIDENT. THE BUCKLE WAS FREE OF DIRT AND OTHER CONTAMINANTS. THERE WERE NO PICTURES OF REPAIR INVOICES AVAILABLE. THE DEALER WAS CONTACTED, WHO DETERMINED THAT THE COMPONENT WAS NOT UNDER ANY RECALL.

Mileage: 75,000

DRIVER SEAT BELT WILL, AT TIMES, NOT RETRACT DUE TO CLOTH BECOMING JAMMED. *JB

OUR POOL IS TWO BLOCKS FROM OUR HOUSE AND WITH THE THIRD ROW SEATS FOLDED DOWN IN OUR TOYOTA SIENNA MINIVAN, WE OFTEN LET OUR CHILDREN (AGES 5 AND 7) SIT IN THE BACK TO RIDE HOME. WHEN LEAVING THE POOL ON MAY 29, THERE WAS AN ADULT FRIEND IN THE FRONT PASSENGER SEAT AND FOUR CHILDREN (AGES 5,5,7 AND 8) IN THE BACK. WHEN WE WERE ALMOST HOME, ONE CHILD SAID THAT THE 7 YEAR OLD WAS STUCK. THE ADULT PASSENGER TURNED AND SAW THAT THE SIDE SEAT BELTS FOR THE THIRD ROW WERE WRAPPED AROUND HIS NECK AND TIGHT. WHEN WE STOPPED THE VAN AND OPENED THE TAILGATE, WE DISCOVERED THAT HE HAD PULLED BOTH SIDES OUT FAR ENOUGH TO ACTIVATE THE RACHET MECHANISM, PUT THE BELTS FROM EACH SIDE AROUND HIS NECK AND TIGHTENED THEM TO A POINT HE COULD NOT GET THEM OFF. WHEN WE TRIED TO HELP, WE FOUND OUT WE COULD NOT GET HIM OUT. WITH THE RACHET MECHANISM ACTIVATED, THE BELTS HAVE TO GO ALL THE WAY BACK IN BEFORE THEY RELEASE AGAIN. SINCE HE HAD USED ONE FROM EACH SIDE THAT IS FASTENED AT BOTH ENDS, THIS COULD NOT BE DOWN WITHOUT STRANGLING THE CHILD. THE ONLY WAY WE COULD GET HIM OUT WAS TO GO IN THE HOUSE AND GET SCISSORS, THEN CUTTING THE SEAT BELT. LUCKILY WE WERE HOME. *JB

REAR RIGHT SEAT BELT REPEATEDLY FAILS AND HAS BEEN REPLACED TWICE NOW. IT HAS FAILED YET A THIRD TIME. THE SEAT BELT GASKET AT THE TOP OF THE SEAT COMES APART AND RESTRICTS THE BELT MOVEMENT RENDERING IT UNUSABLE. ITS A SAFETY HAZARD FOR PASSENGERS. *JB

Mileage: 1,000

DT*: THE CONTACT STATED THE FRONT PASSENGER SIDE SEAT BELT RETRACTOR LOCKS UP WHILE IN USE. THE SEAT BELT MUST BE RELEASED, AND THEN PUT BACK ON. THE DEALERSHIP DETERMINED THIS WAS A SAFETY FEATURE FOR CHILD SAFETY SEATS. THE DEALERSHIP STATED IT WAS ILLEGAL TO REPLACE THE FRONT SEAT BELT ASSEMBLY.

Mileage: 9,000

CONSUMER HAS MADE NUMEROUS ATTEMPTS TO HAVE SEAT BELT RECALL (05V327000) WORK PERFORMED. CONSUMER HAS BEEN TOLD THAT THE PARTS WERE NOT IN OR WERE USED ON ANOTHER CUSTOMER. *TS *NM

RADIATOR RUPTURED AND THE ENGINE OVERHEATED; HOSE REPLACED IN STEERING COLUMN RECALL; RUST PROTECTIVE TAPE RECALL; DVD SCREEN REPLACED AND THE ENTIRE DVD PLAYER REPLACED(SCREEN STILL NOT EASILY VISIBLE IN MIDDLE ROW); PASSENGER SEAT BELT REPLACED; MIDDLE PASSENGER SEAT BELT FAILING; GASOLINE SMELL INSIDE OF CAR WITH AC ON RECIRCULATION; DRIVER'S WINDOW FELL INSIDE DOOR IN SNOW STORM AND WAS NOT CONSIDERED A SAFETY ISSUE TO GET A LOANER VEHICLE EVEN THOUGH THE VEHICLE COULD NOT BE LOCKED; TIRES COMPLETELY BALD AND LEAKING UNDER 30,000 MILES, DVD PLAYER MUST BE AT A HIGH DB VOLUME AND WHEN RETURNED TO RADIO/CD WILL ALMOST DEAFEN YOU; INTERIOR LIGHTS HAVE TO BE MANUALLY OVER RIDDEN OR WILL DRAIN BATTERY; CAR HESITATES 1-2 SECONDS WHEN TRYING TO QUICKLY ACCELERATE AND THEN LURCHES FORWARD ALARMINGLY; CRUISE CONTROL IS NOT FUNCTIONING; WAITING TO HAVE FUEL MIXTURE SENSOR REPLACED. I WAS NOT INFORMED OF FIRST 2 RECALLS UNTIL I MY ENGINE OVERHEATED. I DID GET THE RUST RECALL AND A STICKER ON MY SLIDING DOOR INFORMING USER OF DANGER OF HAVING MIDDLE WINDOWS OPEN WHILE OPENING THE MIDDLE DOOR COULD CATCH A HEAD OR OTHER EXTREMITY. TOYOTA DEALER SERVICE MANAGER SAYS MINE IS THE ONLY 04 SIENNA EXPERIENCING ANY PROBLEMS EXCEPT FOR THE RECALLS ON THE RADIATOR; THE STEERING HOSE; THE RUST TAPE; AND THE MIDDLE SEAT BELT. NOT SO ACCORDING TO ALL I HAVE READ HERE. MOST OF THE PROBLEMS HAVE OCCURRED BETWEEN 22,000 AND 34,000 MILES; THE DVD SCREEN ALWAYS FAILED TO LOCK INTO A GOOD POSITION FOR THE MIDDLE ROW VIEWERS. *NM

Mileage: 22,000

THE SEAT BELT COVER (BEZEL) ON THE MIDDLE ROW PASSENGER-SIDE SEAT COMES APART, CAUSING THE SEAT BELT TO NOT PROPERLY RETRACT. THE DEALERSHIP HAS REPLACED THE COVER 4 TIMES AND TRIED TO GLUE IT TOGETHER 3 TIMES. THE DEALERSHIP AND THE TOYOTA DISTRICT MANAGER CLAIM NO KNOWLEDGE OF IT BEING A WIDESPREAD PROBLEM, BUT OBVIOUSLY IT IS.

DT: READ AN ARTICLE ABOUT TOYOTA SIENNA MINIVANS CONCERNING SEAT BELTS IN THE SECOND ROW PASSENGER SIDE JAMMING IN THE PLASTIC MOLDING. HAD TO FIX IT MANY TIMES. TOOK VEHICLE TO THE DEALER, AND THEY COULD NOT FIX IT. THE CLIP THAT THEY INSTALLED POPPED OFF. THE SEAT BELT WILL GET STUCK AND NOT RETRACT.*AK

Mileage: 15,000

SEAT BELT GETS JAMMED IN THE GUIDES, DOES NOT RETRACT. THIS IS A MAJOR SAFETY CONCERN BECAUSE WHEN SEAT BELT DOES NOT RETRACT IT IS USSLESS. DEALER REPLACED GUIDES BUT STILL OCCURING. SAME ISSUE HAPPENED IN LOANER SIENNA. GETTING PASSED AROUND CALLING TOYOTA.

WITH NORMAL USE SEAT BELT ON 2004 TOYOTA SIENNA LOCKS AND WILL NOT RELEASE WITHOUT THE BELT BEING COMPLETELY RELEASED BACK IN TO HOUSING. THIS HAPPENS AT ANY TIME, NOT JUST WHEN BREAKING OR WHEN TURNING. WE HAVE TAKEN TWICE TO TOYOTA DEALERSHIP TO HAVE IT FIXED BUT HAVE BEEN TOLD IT IS TO DEALER SPEC.*AK

1. MID ROW PASSENGER CAPTAINS CHAIR SEAT BELT-SHOULDER HARNESS WEBBING JAMS. . TOOK VEHICLE TO DEALER--REPLACED PLASTIC BELT GUIDE. DID NOT IMPROVE SITUATION. JAMMED BEFORE I LEFT THE DEALERSHIP. 3. I NOW USE STRAPLING TAPE TO HOLD GUIDE IN PLACE. STILL CAN HAVE JAM PROBLEMS. . PURCHASED THIS VEHICLE BECAUSE OF SAFETY RATING, SINCE I TRANSPORT MY GRANDCHILDREN ON A REGULAR BASIS. HAVE BEEN VERY DISAPPOINTED WITH TOYOTA'S "NON RESPONSE" TO THE PROBLEM. 5. I FEEL MANY PERSONS ARE NOT AWARE OF THE PROBLEM SINCE CHILDREN ARE THE USUAL PASSENGERS IN THIS POSITION & ARE NOT AWARE THAT THIS MALFUNCTION SHOULD BE REPORTED.*AK

Mileage: 3,777

PE0500,8 REAR PASSENGER SEAT BELT CATCHES IN PLASTIC HOUSING THAT REPEATEDLY COMES APART.*AK

Mileage: 1,000

REAR SEAT BELTS DID NOT LOCK, MAKING IT UNSAFE IN CASE OF AN ACCIDENT. DEALER WAS AWARE OF THE PROBLEM , AND WILL CONTACT MANUFACTURER.*AK

WHILE DRIVING MY TOYOTA VAN (SEINA 2004) AN ELEVEN YEAR OLD CHILD WAS ABLE TO WRAP THE SEAT BELT IN THE REAR PASSENGER SIDE AROUND HIS NECK. THIS WAS DONE WHILE PLAYING IN THE BACKSEAT. HE BEGAN TO CHOCK AND REQUIRED A FIREMAN TO CUT THE BELT TO SAVE HIS LIFE. *JB

MID-ROW PASSENGER SIDE SEAT BELT GUIDE/COVER BROKEN JAMMING THE SEAT BELT PREVENTING IT TO RETRACT. FAILURE REPEATED THREE TO FOUR TIMES AFTER EACH SEPARATE REPAIRS. I'M CONCERN FOR MY 7-YEAR OLD DAUGHTER WHO MAY NOT BE PROPERLY RESTRAINTED AFTER SHE LEANS FORWARD AND THE SEAT BELT DOES NOT RETRACT.

Mileage: 12,000

SEAT BELT ON PASSENGER'S SIDE GOT STUCK, IT DID NOT RETRACT OR EXTEND. DEALER REPAIRED IT AT LEAST 6 TIMES. MANUFACTURER RECOMMEND THEY GO TO ARBITRATION. *AK THE CONSUMER BELIEVES THE MANUFACTURER NEEDS TO REDESIGN THE SEAT BELT BECAUSE THE FIX ONLY ALLEVIATES THE PROBLEM TEMPORARILY. *NM EA05-010.PCO

Mileage: 800

MIDDLE SEAT SEAL BELT TOP POSITIONER SOMETIMES GETS JAMMED, CAUSING THE BELT TO BE VERY LOOSE, ESPECIALLY WITH CHILDREN WHO MAY NOT REALIZE THAT IT IS LOOSE. IT APPEARS THAT THE PLASTIC SUPPORT AT THE TOP OF THE SEAT IS NOT VERY SECURE, AND BECOMES LOOSE AFTER A WHILE.*AK

EVERY THREE THOUSAND MILES THE SECOND ROW OF SEATS, SEAT BELT FAILS. THE SEAT BELT WILL SLIP DOWN A CRACK ON THE SIDE OF THE SEAT AND LOCKS ITSELF. THE DEALER HAS REPAIRED THE SEAT BELT FOUR TIMES FOR THIS ONE PROBLEM. *NM

Mileage: 3,000

RIGHT SIDE SECOND ROW SEAT BELT FAILS EVERY 2000 TO 3000 MILES. ENCASEMENT IS LOCATED ON THE SEAT ITSELF INSTEAD OF THE ROOF OF THE VEHICLE. THIS CLIP HOLDING THE ENCASEMENT TOGETHER POPS OUT ALLOWING THE SEAT BELT TO CATCH IN OPENING BELOW, CAUSING THE SEAT BELT TO FAIL. A CHILD OR PASSENGER COULD BE SERIOUSLY HURT. MOST PEOPLE WON'T EVEN REALIZE THERE IS A PROBLEM UNLESS THEY CHECK THIS BELT REGULARLY AS CHILD PASSENGERS GENERALLY WON'T TELL YOU WHEN THE BELT DOESN'T NOT OPERATE CORRECTLY. *JB

Mileage: 3,000

THE WAY THE MIDDLE SEAT IS LOCATED AND DESIGNED IT HAS A SPLIT IN THE PLASTIC. THE SEAT BELT GETS CAUGHT IN THE SPLIT, AND AS A RESULT, THE SEAT BELT FAILS TO RETRACT. DEALERSHIP REPLACED THE SEAT BELT, BUT PROBLEM STILL EXISTS. *AK *CB

THE PLASTIC COVER/GUIDE FOR THE SHOULDER BELT ON THE PASSENGER SIDE MIDDLE ROW CAPTAIN SEAT CAME APART, CAUSING THE BELT TO STICK AND NOT RETRACT PROPERLY. DEALER REPLACED THE PART, AND WITHIN A DAY OR TWO THE NEW PART FAILED IN THE SAME WAY. RETURNED TO DEALER; THEY SAID 2 OTHER PEOPLE HAD THE SAME PROBLEM. DEALER SIMPLY REMOVED THE PART, WHICH IMPROVED OPERATION OF THE BELT; NOW IT SEEMS TO WORK, JUST LOOKS UGLY. *LA EA05-010.PCO

PASSENGER'S SIDE SEAT BELT IN MIDDLE ROW OF THE CAPTAIN CHAIR WILL NOT RETRACT. DEALER IS AWARE OF THE PROBLEM. DRIVER IS CONCERNED BECAUSE HE PICKS UP AND TRANSPORTS CHILDREN FROM PLACE TO PLACE. *AK