2009 TOYOTA TACOMA Structure Problems

The contact owns a 2009 Toyota Tacoma. The contact stated that upon further inspection, the contact became aware that the chassis was rusted. The local dealer was contacted; however, the contact was informed that an unknown Toyota recall for warranty coverage had expired. The manufacturer was made aware of the failure. The failure mileage was approximately 110,000.

Mileage: 110,000

The contact owns a 2009 Toyota Tacoma. The contact stated that after maintenance service on the vehicle, it was discovered that the front subframe of the vehicle was severely corroded. The vehicle was taken to an independent mechanic, where it was inspected, and determined that the entire subframe had failed and needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer, where the same diagnostic result was provide,d and the contact was informed that the entire subframe needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 85,000.

Mileage: 85,000

THE FRAME HAS RUSTED AND HOLES ARE UNSAFE. I AM WORRIED ABOUT DRIVING MY VEHICLE. THE SAFETY OF ME AND OTHER DRIVERS ON THE ROAD I AM TRAVELING ARE AT RISK. I WENT TO LIBERTY TOYOTA IN BURLINGTON, NJ AND THEY REFUSED TO REPAIR. THE RUST IS UNUSUAL AND THERE HAVE BEEN OTHER YEARS AFFECTED AND FRAMES REPLACED. MY WIFE PURCHASED THIS TRUCK FROM LIBERTY TOYOTA

Vehicle: 2009 Toyota Tacoma VIN: [XXX] Mileage: 128,400 Owner: Jacob Grove, Anderson, SC Summary of Issue: The frame of this 2009 Toyota Tacoma has developed severe rust perforation that makes the vehicle unsafe to drive. My independent mechanic has refused to work on it due to safety concerns, and Toyota of Greenville (SC) has confirmed that the frame is extensively corroded and requires replacement. Background: Toyota previously issued a Customer Support Program (CSP) for frame corrosion affecting 2005–2009 Tacomas in northern states, including Ohio, where this truck was purchased and operated. In June 2018, the vehicle was inspected at Don Wood Toyota in Athens, OH (91,600 miles). The dealership recorded “no perforation” and did not apply the protective coating or replace the frame. The truck has been minimally driven since (an average of 6,000 miles per year). In May 2024, at 128,400 miles, a mechanic and dealership confirmed the frame has multiple areas of severe perforation, including around brake lines and exhaust mounts. Concern: It is unreasonable that a vehicle frame could go from “no perforation” to “severe perforation” in only 36,000 miles and six years of light use. This indicates either: The 2018 inspection under Toyota’s CSP was inadequate, or The frame was already compromised but not properly addressed at the time. Safety Risk: The vehicle cannot be safely lifted, worked on, or driven in its current condition. The rapid deterioration presents a risk of frame failure while driving, endangering occupants and others on the road. Request: I am submitting this complaint so that NHTSA is aware of ongoing frame corrosion failures in 2005–2009 Toyota Tacomas, even in cases where Toyota previously inspected and declined to repair during the CSP period. This case demonstrates that the problem may not have been properly identified or corrected during program inspections, leaving unsafe vehicles on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2009 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from underneath the vehicle. Upon inspection, the contact discovered a branch lodged beneath the vehicle and the corroded subframe with a hole in the front passenger’s side subframe. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 113,000.

Mileage: 113,000

I just learned from my Mechanic that the Frame Corrosion is bad. The frame was inspected by Vanderstyne (now West Herr) Toyota on 06/20/2020. It passed the Inspection at that time, so they did not do anything. But within 4.5 years and only a little more than 6,000 miles driving since then - this corrosion shows up. I think the Toyota Specs for the Corrosion Inspection were not sufficient. Toyota should be held accountable for their negligence. I only have 72,900 miles on this Tacoma. I would have liked to keep it for another 5 years or so, but now I cannot and Toyota washed their hand when I contacted them.

See Attached Letter

My frame is rusting and has holes in places. Is there a recall for that?

Chassis in the middle frame back left too much rust and big hole due to rust

See attached document for complaint

We recently went to have new tires put on the Tacoma at Costco. The Costco technician said that the frame was rusted and he had a similar problem with his Tacoma and Toyota repaired it. He told us that he couldn't install the new tires with the rusted frame and suggested that we go to our Toyota Dealer. We went to Toyota Direct in Columbus, Ohio (where we have had the vehicle serviced every time) and they took pictures of the rust and told us they would call us back. Although we have inquired several times, they had not called us back so we reached out to Toyota Corporate and they said that the recall/warranty extension had expired and there was nothing they could do. Costco has refused to install the new tires until the frame is repaired. (our problem is not with Costco.) The Costco tech did tell us that he was surprised that the rust had not been noticed before by the Dealer during regular service as it would not have appeared so quickly. So the complaint goes against Toyota Corporate and Toyota Direct... why did they not notice any rust while the warranty/recall was in effect or any of the service visits if this is a standard problem with 2009 Toyotas. If the vehicle has a rusted frame, that could be dangerous to whoever is driving the vehicle. In addition, without being able to have new tires installed due to the frame issue, that creates another safety concern with winter weather approaching and tires that need replaced.

Just learned from CT Toyota dealer that my 2009 Toyota Tacoma frame has significant corrosion and that it's time to replace frame or vehicle. Very disappointed. Vehicle did go in for recall service on 12/7/17 and CRC spray was applied as frame was determined ok at that time. Looks like that didn't help much to prevent further corrosion less than 6 years later. Voicing my frustration over those that got new frames are still driving on road, while I have to retire my truck. Extending warranty to 12 years from date of first use clearly did me no help. Do I and others like this have any options?

Rust flaking frame small hole

Significant amount of rust and rot on multiple structural points of the truck’s frame. This deterioration has advanced much quicker than anticipated, compromising the structural integrity and safety of the vehicle. The rust and rot have affected crucial components of the frame, including crossmembers and suspension mounting points. I have entered my vin # multiple times in the past years to the Toyota frame recall webpage but I am continually denied frame replacement. I feel that the extent of rust and the time frame in which it occurred should allow for a manufacturer replacement or compensation.

I purchased this vehicle on 12/16/2019 with 20,990 miles on it. Now the vehicle has 33,000 miles on it and I was told by an independent service station that I have a large hole in the frame. I brought the truck on 4/07/2023 to a Toyota dealer and they said the recall for a new frame expired 12 years after the vehicle was purchased. I called Toyota and they told me the same thing. I had know idea that these trucks had frame rust issues when I bought it. I read that Canada received a 3 year extension to 15 years on Tacoma 2009 trucks with mileage under 36,000, I have only 33,000 miles. Please help!

Went for an inspection and entire frame is completely rotting out. Could have ben killed. Truck only has 65,000 miles on it because it was previously owned by my 80 year old grandfather. Toyota should have to fix everyone of these issues not just a certain time frame.

The contact owns a 2009 Toyota Tacoma. The contact stated that he noticed that the subframe was excessively rusted. The vehicle was taken to a local dealer for routine oil change and tire rotation services, and after the contact made the mechanic aware of the failure, he was informed that the vehicle could not be raised up on the lift because the subframe had excessive rust and would fracture. The contact was informed that the subframe needed to be replaced. The contact then made Toyota of Bedford (18151 Rockside Rd, Bedford, OH 44146) aware of the failure; however, the dealer declined to diagnose or repair the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 104,000.

Mileage: 104,000

Went to get an undercoat application. Tech pointed out severe rust/rot on my truck frame, located on both front wheel control arm area. Vehicle was inspected by N.E. Undercoating, Plainfield Ct. No warnings. NEVER RECEIVED A FRAME RECALL NOTICE Contacted Toyota Corporation and they said "sorry, nothing we can do"

The contact owns a 2009 Toyota Tacoma. The contact stated while driving at an unknown speed, the vehicle started shaking abnormally. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the subframe needed to be replaced. The contact stated that she had received a recall in the past for the subframe however, the vehicle was not repaired. The dealer and manufacturer were notified of the failure but informed the contact that the recall had expired. The vehicle was not repaired. The failure mileage was approximately 95,000.

Mileage: 95,000

Never received notice for XX Warranty Enhancement Program and found out in March 2022 as vehicle cannot pass inspection due to rusty on frame. BRAND ENGAGEMENT ADVOCATE March 09, 2022 at 12:18 PM Dear [XXX], Thank you for contacting Toyota Motor Sales, U.S.A., Inc. regarding your frame concern in your 2009 Tacoma. We are sorry to learn you're experiencing a concern with your vehicle. We were able to further look into your frame concern and have verified your vehicle is beyond the parameters of the Warranty Enhancement Program for this concern. This warranty enhancement program was an extension of the vehicle's Basic Warranty. Primary coverage for this program expired on 01/31/19 and Secondary coverage for your vehicle expired 12 years after the date of first use: 06/30/20. Once the vehicle is outside of the program parameters, the cost of repairs becomes the owner’s responsibility, as the component is now outside of all factory coverage. We have also verified that one letter was sent to you at the mailing address we have on file. The remedy letter for the XX Warranty Enhancement Program was sent on 11/08/2018. We hope this provides clarity to your inquiry. Your comment has been documented at our National Headquarters under your case number. If we can be of further assistance, please feel free to contact us. Sincerely, [XXX] Toyota Brand Engagement Center INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Severe rusting and corrosion of chassis/under body, body and frame of truck.

The contact owns a 2009 Toyota Tacoma. The contact stated while driving approximately 60 MPH, the tire hit the wheel well and the frame was ripped apart. The dealer sent a technician to the contact’s home to inspect the vehicle. The contact was informed that the sub frame needed to be replaced however, the vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer informed the contact that the vehicle was out of warranty. The failure mileage was approximately 250,000.

Mileage: 250,000

The contact owns a 2009 Toyota Tacoma. The contact stated that while the vehicle was at an independent mechanic for routine maintenance, the mechanic informed him that there was a hole in the sub-frame and that the sub-frame was severely corroded. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. Additionally, the extended warranty had expired. The vehicle had previously been serviced in 2017 when the dealer applied an undercoating to the subframe. The failure mileage was 65,136.

Mileage: 65,136

I own a '09 Toyota Tacoma (VIN: [XXX]) that I purchased 5/15/18 from Long Subaru, Webster Ma. On 9/1/21 we noticed a rot hole in the frame. We then learned there was a recall/warranty extension on rotted '09 Tacoma frames. On 9/2/21 we brought the truck to Toyota of Nashua, NH. We were told the warranty extension expired in May and the frame would not be covered. We were sent on our way as if this vehicle is safe to drive. I brought the vehicle to a mechanic to see if he could weld a plate over the hole. He said the frame was so rotted and nothing to weld it to. He also detected movement in the frame due to all the rot. He said it was unsafe to drive. On 9/23 I called Toyota corporate customer service to understand why I was never notified. They said they sent notification to the previous owner, then tried to backtrack and say they also sent it to me. Several days later we learned from a Toyota dealership employee (off the record) that the notification was never sent to us and only sent to the previous owner . Their failure to notify us of a safety recall (which some articles state was masked as a warranty extension) has put us at risk. This rot didn't happen over the summer! They need another recall to save lives before someone gets injured! 10/19/21 I called Toyota customer service again. I tried to get this issue escalated to a supervisor. They put me on hold. After 1 hour I hung up. 10/19/21 I filed a claim with the Massachusetts AG. They pointed me in your direction I am so baffled how this vehicle passed yearly inspections. During Mass inspections we don’t pass vehicles with dark tinted windows, lift kits that are too high, aftermarket headlights/brake light, yet, we pass a vehicle with a rotted frame that had a recall on it and a class action lawsuit. There are so many failure points here. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The vehicle has an excessive frame rotten. The car was inspected by Toyota dealer confirming the issue. The issue appeared the first week of August 2021.

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICED AT TOYOTA CITY (1305 E BOSTON POST RD, MAMARONECK, NY 10543, (914) 825-5611) UNDER NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION) HE BECAME AWARE THAT THE SUBFRAME OF THE VEHICLE WAS CORRODED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 34,000.

Mileage: 34,000

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED HE BECAME AWARE THAT THE CHASSIS UNDERNEATH THE VEHICLE WAS EXTREMELY RUSTED. THE CONTACT CALLED BRISTOL TOYOTA LOCATED AT 2283 GRAND ARMY OF THE REPUBLIC HWY, SWANSEA, MA 02777, (401) 253-2100, AND WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED AS OF YET. THE MANUFACTURER HAD NOT BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 92,458.

Mileage: 92,458

I HAD A RUSTY FRAME RECALL WHICH I TOOK IN ON FEB. 2018 AND HAD THEY SUPPOSEDLY REPAIRED THIS BY RUSTPROOFING. SINCE THEN ALL THE NEW RUSTPROOFING APPLIED FOR THIS FIX HAS DETERIORATED. THIS TRUCK HAS ONLY BEEN DRIVEN LESS THAN 10,000 MILES SINCE THAT TIME AND IS HOUSED IN A GARAGE. THIS RECALL ENDS ON JULY 28TH OF 2020 AND MY DEALER SAYS THE WILL DO NOTHING. BECAUSE NO PERFORATIONS ARE SEEN THEY WILL NOT HELP. I ASSUMED THAT THIS WAS REPAIRED CORRECTLY WHEN IT WAS DONE INITIALLY BUT HAVE FOUND THAT THE JOB DONE WAS MAINLY COSMETIC AND THE MATTER WAS NOT FIXED. I AM NOW ASKING FOR HELP TO HAVE THIS REPAIR DONE PROPERLY. *TR

Mileage: 68,000

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO NEW COUNTRY TOYOTA OF SARATOGA SPRINGS (3002 NY-50, SARATOGA SPRINGS, NY 12866, (518) 584-7272) AND REPAIRED PER AN UNKNOWN RECALL REGARDING THE FRAME. WHILE DRIVING VARIOUS SPEEDS, THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE. WHEN THE VEHICLE ACCELERATED, THE NOISE INTENSIFIED AND THE STEERING WHEEL VIBRATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 92,000.

Mileage: 92,000

TL- THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V604000 (SUSPENSION), 13V337000 (SEAT BELTS) AND 11V148 (TIRE) THE CONTACT CALLED SEVERAL DEALERS INCLUDING THE TOYOTA DIRECT DEALER (614-476-1979, LOCATED AT 4248 MORSE RD, COLUMBUS, OH 43230) AND IT WAS CONFIRMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT FE

IN ADDITION TO A RUSTED FRAME, MY 2009 TACOMA HAS 1.A RUSTY AIR CONDITION SYSTEM WITH RUSTED COMPONENTS. 2.A RUSTED U JOINT FOR STEERING THAT WAS EXTREMELY DIFFICULT & EXPENSIVE TO REPLACE. 3.A RUSTED POWER STEERING COMPONENT WITH A HOLE IN BOTTOM. IT CAN'T BE FIXED UNTIL THE FRAME IS REPLACED. I CAN'T SAFELY DRIVE THE VEHICLE. 4.A RUSTED 4-WHEEL DRIVE ACTUATOR ' TO BE REPLACED. IT DOESN'T G INTO 4 WHEEL DRIVE. 5.BRAKE LINE RUSTED THRU. WILL THESE REPAIRS BE COVERED BY TOYOTA AS WELL DURING THE FRAME REPLACEMENT?

Mileage: 108,000

THE ENTIRE FRAME OF THE VEHICLE IS RUSTED

THE PAINT ON MY 2009 TOYOTA TACOMA STARTED TO FAIL ABOUT A YEAR AGO APPROX. MARCH 2017. IT STARTED ON THE HOOD WITH SLIGHT CRACKING THAT LED TO PEELING THAT LED TO IT'S CURRENT CONDITION WHICH IS BARE METAL IN LARGE AREAS. THE ROOF WAS THE NEXT AREA TO HAVE THE PAINT FAIL AND IT IS THE SAME SCENARIO AS THE HOOD. THE REST OF THE TRUCK IS STARTING TO FAIL BUT NOT AS BAD AS THE ROOF AND HOOD. THE PAINT COLOR IS DARK CHARCOAL. RUST SPOTS HAVE ALSO STARTED TO FORM WHERE THERE IS BARE METAL. THE TRUCK HAS 66,000 MILES ON IT. THE TRUCK IS A FLORIDA VEHICLE AND HAS NEVER LEFT THE STATE.

THE FRAME HAD TO BE REPLACED BY TOYOTA DUE TO EXCESSIVE RUST

Mileage: 105,000

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER (JOSEPH AIRPORT TOYOTA IN VANDALIA, OHIO, 937-898-8060) WHERE THE TECHNICIAN OFFERED TO SPRAYPAINT OVER THE RUST, BUT THE CONTACT DECLINED THE OFFER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT TO DO WHAT THE DEALER RECOMMENDED, STATING THAT IF THE FAILURE CONTINUED, THE FRAME WOULD BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.

Mileage: 75,000

THE FRAME IS COVERED BY A RECALL. TOYOTA IS LIMITING IT TO CERTAIN STATES. I WAS IN ONE OF THOSE STATES (MAINE). TOYOTA SAYS THE CAR MUST BE REGISTERED IN ONE OF THOSE STATES. MY REGISTRATION ENDED AT THE END OF OCTOBER. WE KNOW LIVE IN FLORIDA WHICH IS NOT COVERED. THE FRAME WAS INSPECTED BY A TOYOTA DEALERSHIP IN FLORIDA THAT SAID IT NEEDED TO BE TREATED FOR RUST. (RECALL). BUT BECAUSE MY REGISTRATION CHANGED THEY ARE USING IT AS A REASON NOT TO COVER VEHICLE. I BELIEVE IT IS A SAFETY ISSUE AND THAT THEY ARE USING LOOPHOLES NOT TO COVER ALL THE VEHICLES THAT SHOULD BE COVERED.

Mileage: 133,500

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO CHARLIE'S TOYOTA (451 WESTERN AVE, AUGUSTA, ME 04330 (207) 622-4748) AFTER HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED THAT THE VEHICLE WAS INSPECTED AND DIAGNOSED, AND WAS INFORMED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND WAS ABLE TO CONFIRM THAT THE PARTS WERE ORDERED. THE FAILURE MILEAGE WAS 204,333. PARTS DISTRIBUTION DISCONNECT.

Mileage: 204,333

FRAME HAS EXCESSIVE RUST. VEHICLE WAS BOUGHT NEW IN SUMMER 2008, LESS THAN 3 YEARS LATER THE SEAMS OF THE FRAME HAD SUBSTANTIAL RUST. FRAME IS NOW COVERED IN RUST . WHEN THE TOYOTA DEALER WAS CONTACTED THEIR REPLY WAS ~THERE IS NO RECALL FOR YOUR VEHICLE REGARDING THIS MATTER. I AM AWARE OF MANY OTHER MODEL YEARS OF TACOMA BEING RECALLED FOR THIS PROBLEM. THIS IS A SAFETY HAZARD FOR THE MODEL YEAR 2009 TACOMAS AND THAT MODEL YEAR SHOULD BE INCLUDED IN THE RECALL. FORM REQUIRES A "WHEN DID THIS HAPPEN" DATE, A DATE OF JUNE 2011 WAS ENTERED AS THE APPROXIMATE DATE WHEN THE EXCESSIVE RUST WAS FIRST NOTICED

Mileage: 20,606

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V604000 (FUEL SYSTEM, BODY); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THERE WAS AN EXCESSIVE AMOUNT OF RUST ALL OVER THE FRAME OF THE VEHICLE AND THE WELDED TOWING UNIT. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

Mileage: 40,000

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. WHILE DRIVING 2 MPH, THE CONTACT HEARD AN ABNORMAL NOISE UNDERNEATH THE VEHICLE. THE DEALER REPAIRED THE VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION); HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE SUBFRAME AND REAR PASSENGER SIDE LEAF SPRING FRACTURED DUE TO CORROSION. THE MECHANIC DIAGNOSED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,500.

Mileage: 50,500

THE PAINT IS PEELING OFF THE CAB OF MY TACOMA, EVEN THOUGH I WASH IT FREQUENTLY AND WAX IT. IT IS FADED AND NOW STARTING TO RUST DUE TO THE PAINT PEELING AND COMING OFF THE TOP OF THE CAB. I HAVE TRIED EVERYTHING TO STOP THIS, BUT NOTHING SEEMS TO WORK, AND SEEMS TO BE POOR QUALITY PAINT OR WORKMANSHIP. I HAVE SEEN SEVERAL VEHICLES OF THE SAME YEAR AS MINE WITH THE SAME ISSUES.

PURCHASE NEW A 2009 TOYOTA TACOMA FROM TOYOTA OF SCRANTON-VEHICLE FINAL PAYMENT FOR OUR TRUCK WAS OCT 2012. THE TRUCK HAS NOT MISSED AN APPOINTMENT AT TOYOTA OF SCRANTON (THEY ALWAYS MAINTAINED THE VEHICLE). WE TOOK THE TRUCK FOR INSPECTION AT TOYOTA OF SCRANTON IN SEPTEMBER (YEARLY INSPECTION) THE TRUCK FAILED INSPECTION WITH REGARDS TO RUST SPOTS AT FRAME OF TRUCK. TOYOTA DID NOT PASS THE TRUCK FOR INSPECTION AND TOLD US TO GO TO A LOCAL WELDING COMPANY AND HAVE IT WELDED "SUPERIOR WELDING CO." I HAVE BEEN IN TOUCH WITH CORPORATE AND MANUFACTURE REGARDING THIS ISSUE. THEY ARE WORKING ON CASE. I FEAR FOR OTHER MOTORIST WHO MAY HAVE IT WELDED BY OTHERS OR NOT WELDED AND IT BE UNSAFE ON THE HIGHWAY/ROADS. THE TRUCK WAS AT DEALERSHIP WHEN TOLD OF ISSUE. TOYOTA RECALLED 2008 TRUCKS FOR RUSTED FRAMES (DANA MANUFACTURE) - A TOYOTA TACOMA RUSTED FRAMES LAWSUIT FILED IN ARKANSAS. I HAVE SPOKEN TO 14 PEOPLE + 3 SUPERVISORS, IT IS NOW IN THE HANDS OF A "FIELD TECHNICIAN SPECIALIST". THEY TOLD ME THE DECISION WITH NOW GO OUTSIDE THE REGIONAL OFFICE.

Mileage: 100,000

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME AND CARRIAGE WERE RUSTED. IN ADDITION, THE SPARE TIRE WAS RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 21,062.

Mileage: 21,062

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE SUBFRAME AND THE BRACES FOR THE REAR PANEL WERE CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V604000 (SUSPENSION). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000.

Mileage: 25,000

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE REAR BUMPER WAS RUSTED. THE DEALER STATED THAT THE REAR BUMPER WAS RUSTING PREMATURELY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 12/30/14*CN UPDATED 05/27/2015 *JS

Mileage: 50,000

BOTH FRONT AMBER DAYTIME RUNNING LIGHTS (DRL) ARE MELTING THE PLASTIC LENS COVERS AND IT LOOKS LIKE THERE IS RISK OF A FIRE. THE ORIGINAL BULBS ARE IN THE TRUCK. I AM THE ORIGINAL OWNER AND HAVE NEVER OPENED OR CHANGED ANY OF THE LIGHTS ON THIS TRUCK. I DON'T KNOW HOW LONG THIS HAS BEEN LIKE THIS, BUT I WOULD GUESS THAT IT HAS BEEN OVER-HEATING FOR QUITE SOME TIME. THE PLASTIC IS BUBBLING AND IS TURNING A BURNT COLOR. *TR

Mileage: 45,000

TOYOTA TECHNICAL SERVICE BULLETIN# T-SB-0129-11 TOYOTA KNEW THERE IS A MELTING/SAFETY ISSUE WITH DRL YET I WAS NOT INFORMED WHILE VEHICLE WAS IN WARRANTY BACK IN SEPTEMBER 2011, WHEN THE TSB ABOVE WAS PUBLISHED BY TOYOTA. TOYOTA STILL WANTS ME TO PAY AT 31,000 MILES 2009 TACOMA ALMOST $300 TO FIX IT. MAJOR SAFETY ISSUE SINCE MELTING HAS DIMMED THE LIGHTING OUTPUT & POSES A FIRE HAZARD AS THE MELTING HAS ALSO REACHED THE BACK OF THE BULB SOCKET WHERE THE WIRING IS. PLEASE HELP. *TR

Mileage: 30,500

AFTER PURCHASING THE VEHICLE, IN SEPT 2011, I HAD MY TRUCK FOR ONLY A FEW WEEKS AND I WAS DRIVING AND HIT A SMALL BUMP AND HEARD AS WELL AS FELT A LOUD THUMP COMING FROM THE STEERING COLUMN AREA, I ALSO NOTICED MY BED WAS MOVING A LITTLE AS WELL. I BROUGHT THE TRUCK INTO THE DEALERSHIP AS SOON AS I HEARD THE ISSUE, BUT THE DEALERSHIP SAID THEY DIDN'T HEAR OR FEEL ANYTHING. NOW WHEN I HIT ANY BUMP (BIG/SMALL) I CAN LITERALLY SEE THE BED ON MY TRUCK MOVE IN MY SIDE MIRRORS, THE ISSUES ARE PROGRESSING AND MY TRUCK IS STILL UNDER WARRANTY AND I WANT THESE ISSUES FIXED ASAP, ESP SINCE ITS STILL UNDER WARRANTY . EXTREMELY HARSH RIDE, AND FEELING UNSAFE TO DRIVE, NEEDS TO BE FIXED ASAP. *TR

THE RUBBER STRIP RUNNING FORE - AFT ON THE CAB OF THE TRUCK CAME OFF DURING DRIVING. THE RUBBER STRIP COULD HAVE LANDED ON THE WINDSHIELD OF A FELLOW MOTORIST AND CAUSED AN ACCIDENT. THIS COULD BE AN ANOMALY, HOWEVER, THE SAME THING HAPPENED TO MY SON'S TOYOTA 2005 FOUR RUNNER. I RECOMMEND AT LEAST A CURSORY INVESTIGATION. *TR

Mileage: 52,000

THE DAYTIME RUNNING LIGHTS HAVE MELTED AND CRACKED THE LENS/PLASTIC. THESE ARE ALSO USED AS FRONT END TURN SIGNALS. IF THESE FAIL, IT COULD BE A MAJOR SAFETY HAZARD. WHILE THERE IS A TSB, THE DEALERSHIP DENIED TO PAY FOR REPLACEMENTS SINCE MY 36K WARRANTY HAS NOW EXPIRED. THIS IS NOT SOMETHING THAT JUST STARTED TO HAPPEN AND TOYOTA IS AWARE OF THE PROBLEM. *TR

Mileage: 35,000

TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE FOOT REST NEXT TO THE CLUTCH SNAPPED AND DETACHED FROM THE VEHICLE. THE PIECE THAT CAME OFF, FELL BEHIND THE HER FOOT, CAUSING A DISRUPTION IN OPERATING THE VEHICLE PROPERLY. THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT THEY COULD PROVIDE NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 19,200. UPDATED 07/17/12*LJ

Mileage: 19,200