2024 TOYOTA TACOMA Power Train Problems

2024 Toyota Tacoma TRD Hybrid. When trying to use 4HI/4LO the vehicle gets stuck in 4LO with the 4LO/4HI lights flashing. This means the vehicle has no idea what the state of the transmission is. It does not allow getting back to 2HI. In the state the vehicle is not drivable. It happens when offroading in the middle of no where. Toyota requires the vehicle to be towed to a dealer. We had this problem 2 weeks ago. The vehicle was towed to Stevenson Toyota in St George UT. They acknowledge it is a Toyota problem. They kept it for 10 days said they had 15 parts to fix it. We picked it up. Tried to get into 4LO the next day the problem happened again and needed to be towed. Both ChatGPT and Gemini state this a known problem but Toyota has not issued a recall on it. That is not safe because an owner can be disabled in the middle of no-where. This vehicle is advertised as off road.

Transmission slips and shifts roughly, intermittently. No codes have shown up when scanned at the dealer.

Transmission fault codes during family highway trip which completely stop all safety features from working.

The contact owns a 2024 Toyota Tacoma. The contact stated that while shifting into gear, the vehicle jumped and continued to move. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V058000 (Service Brakes, Hydraulic). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 18,000.

Mileage: 18,000

I was informed by the service manager at Labadie Toyota (Bay City, MI) that the new 2.4L Turbos have injector issues! Some Sienna's Tacoma's, and other models have faulty direct injectors that spray way too much fuel into the cylinders, and it drains into the oil reservoir! I had my oil changed at 1K, 5K and 10K by the dealership. I've had this issue at 5K and I presumed service center incompetence, and they agreed. I recently had my oil changed at 10K and came back in 2 weeks later with check engine light on and excessive engine chatter. I was told this a known Toyota engineering issue, and they are now telling the techs to look into the cylinders to look for clean/washed piston tops. Today they just changed my oil and told me to come back in 3 weeks or if issues arise. I'm concerned about a fire with gas going into the engine oil and potentially causing a fire. Toyota engineering is aware of this issue I was told so I would a recall to be issued so there is no issues with a fire happening.

Since day one vibration and pulsing 30-45MPH. Dealer confirmed vibration and said it common with my vehicle and nothing can be done. Returned to dealer same issue confirmed by tech and service manager and they charged $75 for tire balance at 5,000 miles. Returned next day and drove another identical model and 3 lesser versions of Tacoma’s. They claim they have no fix and suggested I trade it in for a Tundra and take a $10,000 deductions from my sticker price. Now when I stop slowly theres a thump and surge in the drive train like s load shifted in the bed. And intermittently when going from a dead stop the engine rev’s nothing happens for a second and it clunks into gear and shifts harshly. Again claim there’s nothing they can do.

Transmission slips when needing to speed up quickly thus has hairbrush several times

Since first oil change it will not stop leaking oil

2024 Toyota tacoma TRD offroad hybrid premium, truck will shift hard into 2nd gear almost like its slipping, issue is primarily noticed when the truck has sat overnight or a few hours. dealership has checked once and recommended me to try changing driving habits, (complete stop when shifting to fwd gear) still no fix. no warning lamps have shown no incidents or accidents from issue but

Transmission slipping in 2nd gear and losing power. No warning lights, but the loss of power could've resulted in an accident had it been in an intersection. I can reproduce the issue, but the dealer says they are unable to. That said, there are other issues with power delivery such as RPM flutter that they have acknowledged in writing.

Vehicle lurched forward with a “bang” accelerating in stop and go traffic. Vehicle then stalled and flashed multiple warnings. Hybrid system failure. Drive mode failure. General failure. Vehicle would not restart on first attempt - multiple attempts made to restart. Upon restarting, it would not move forward in Drive, prompting a new error stating it needed to be returned to park. After a couple more restarts it was able to engage the gear and move forward. Power was limited, it drove differently, and the hybrid error persisted.

Six speed manual transmission would not shift into second fourth or sixth gears. It started in a parking lot shifting from first to second, then it made a grinding noise and all the bottom gears of the extended 'H' shift pattern were not functioning.

The transmission slams gears, looses power when shifting on acceleration, and goes into a neutral while in parking lots at low speeds. The truck also while stopped will shutter and feel like it just got hit.

the transmion for this vehicles has been runing roughft and hard shiftin. this vehicles has les than 5,000. the croblemas been incresing consering and becamong more ovius with the higher usage of this unit. this hapens especialy when first engagin in first gear from parking. also when shifting from first to secong gear. this is a automatic transmision.

The morning my transmission failed... I started the truck and put it in R, at which point the entire truck shuddered for several seconds. At this point many, many warning messages appeared on the instrument cluster screen as well as the infotainment screen - and the truck would not move in Reverse. After moving the shifter into P and back to R, the truck backed out of the driveway. When the truck was shifted to D - nothing happened. The truck was shifted back to R and then back to D at which point the truck moved forward but would not shift out of 1st gear. Placed truck back in P and then back to D two more times and truck would move forward but not shift out of 1st gear. Turned truck off and on approximately 3 times and it began to shift gears when driving. I drove the truck to the closest Toyota dealership where the warning codes were checked, and I was told that my transmission was bad and needed to be replaced. I was told that it would need a new Torque Converter assy, new Automatic Transmission assy, and a new Hybrid Module assy. Total cost for parts would be $27,504.29.... Covered by warranty. My truck was purchased brand new in Virginia, MN on [XXX], and the failure occurred on [XXX] with less than 800 miles on the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle has a vibration at speeds in excess of 40mph. The dealer has confirmed that the wheels are balanced and that the truck is in alignment. They have duplicated the issue on my truck and have driven an identical model and experienced the same inherent vibration. There are also mentions of this vibration in Tacoma forums online specific to the TRD Off-road variant

Stopping at a stop light, after coming to a complete stop, vehicle will want to slowly creep forward and you need to press a little harder on the brake pedal. If you don't pay attention, you will creep into the vehicle in front of you. I am in the transmission TSB range.

My 2024 Tacoma SR5 was stuttering and felt like the wheels are locking up when I accelerate I have to go very slow because when going anything over 30 MPH feels very unsafe and is hard to control and handle it shut off a lot of my systems like crash detection and 2-3 other ones are cut off on my dash it threw a check engine light so going to take it in to Toyota tomorrow to get it looked at I don’t know if I even want this truck anymore.

I bought the truck at 6 pm on [XXX] in Pennsylvania and drove straight home in Brooklyn, when trying to find a parking spot the truck started to act weird(10pm after 190 miles). The rpm was going really high with no power to the wheels and abruptly it seems to find gear and jumped off really fast a couple of times. I was driving in a residential area at low speed and was able to pull over to the curb. I could have hit a pedestrian, another car or lost control pretty badly if I was in a highway. After the initial incident all the lights came off (engine malfunction, brakes malfunction, collision system malfunction and others). The truck was towed and after a long wait, today the 5th of December, it was diagnosed as a transmission problem, Toyota is going order a new transmission and the broken one will be sent to Toyota for further inspection. They want to replace my truck and it seems they are not willing to cancel the deal. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My new 2024 Toyota Tacoma TRD Pro with 2440 miles experienced a transmission failure as I was driving up a mountain highway. I lost most propulsion of the vehicle with no advanced notice. I barely was able to make it to a portion of the road with a shoulder. There was heavy traffic due to the thanksgiving holiday traffic. The error on the Vehicle indicated Hybrid System Failure. In the vehicle information I was able to access additional errors, “A malfunctions in the intelligent Clearance Sonar System has been detected”, and “A malfunction in the Drive Start Control System has been detected”. The vehicle was towed to a local Toyota dealer and the have diagnose that the transmission and a computer need to be replaced. The problem arose suddenly without warning and with out any prior issues.

When I was driving my new truck the transmission failed. It would not change gears forward or reverse. The RMP started ramping up in the red. Check engine light on drive start control malfunction. Advanced ultrasonic detecting and ranging system. The led screen was going hoops asking for code and updating while driving day before transmission went. Called dealer. Had the car towed. Later that day was told bye dealer the transmission needs to be replaced. Did research to find out Toyota new theses transmission are faulty and have not recalled. If I where on highway or similar roads I drive daily I would have been hurt. This problem will cause a accident. I am aware the NHTSA has been informed, reached out to Toyota and Toyota has not responded nor have they started a safety recall. My fear is they are waiting for someone to get hurt or killed. My dealer also informed me another customer with a tacoma has been waiting since may 2024 for a transmission.

When starting from a stop on at a stop light on a steep hill, the truck did not accelerate and started rolling backward almost hitting multiple vehicles. I was able to get it stopped but had to wait to get help to move it off the road before being able to get it moving forward again.

What component or system failed or malfunctioned, and is it available for inspection upon request? Transmission, and yes its available for inspection. When I put the truck into drive from park, and even reverse, the truck would jerk. (I have videos) When accelerating around 13-14mph, I could feel the transmission "gear searching" with rough shifting. When decelerating around 15-17mph, the transmission would down shift too early, producing the feeling of engine breaking, and again rough shifting. When I needed to really go, I experienced "transmission lag" where the engine would be working, reving up, the feeling of engaging the clutch (coasting feeling), then after a moment the gear would catch and the truck would finally take off. I took the truck to a dealership to have it checked out, but the technicians said they couldn't reproduce this issue. I called corporate and they sent me to another dealership. This dealership said the same thing, BUT went the next step and pulled some transmission fluid and found metal shavings. They had the truck for almost 3 weeks and replaced the transmission and torque converter. When I went to pick up the truck I put the truck into drive and felt the jerk I experienced before. I put it into reverse then drive, and again the whole truck jerks. I asked to speak to a manager and he said he can have the foreman look at it the next day. I made him get in the truck with me and showed him the truck jerking when placed into drive. Next day, foreman said there was nothing wrong and performed the same as a new truck on the lot. I spoke to a higher manager and he recommended I bring the truck in for the regional Field Technician. The Field Technician reviewed the vehicle and determined there was nothing wrong and it was performing the same as 3 new trucks on the lot.

I purchased the 2024 Tacoma TRD Pro on 9/5/24. On 9/20/24 the Transmission failed with just over 1,000 miles driven on the truck. I was stopped at a traffic light when the problem occurred. Multiple sensor alarms were triggered including Hybrid System Malfunction. I attempted to accelerate when the light changed, but it was very sluggish and felt like it was trying to take off from a high gear. I was less than 1 mile from a Toyota dealership when the malfunction occurred and was able to get the truck to the dealership. After a week of troubleshooting, the dealership informed me that the transmission was stuck in 6th gear due to a solenoid failure and they would need to replace the transmission. The transmission is currently on backorder with an estimated delivery between 10/14 and 10/26. Based on the current estimate, by the time I get the truck back, i will have made two months of lease payments while only having the vehicle in my possession for 2 weeks.

When at stop light transmission would not fully engage and started thru intersection was only going approx 20 mph. Engine went to 3500 rpm before it shifted again. After I arrived at my destination started truck back up again and received warning on dash and check engine light came on. Had check engine and drive control system warning messages. Still had same problem with it at stop lights and transmission seemed to not be shifting properly. Was able to get it to dealer and next day received call from them stating that I needed new transmission.

●It makes a lot of vibration uphill 25-40mph. ●It feels like hunting gear when itñs shifting to the second gear. ●it got stock in second gear in the middle of the traffic and there was risk because cars where behind me yelling me.

Automatic transmission fault that locked the vehicle in 2nd gear. The vehicle was taken to a local dealership for service, and Toyota refused to replace the transmission and torque converter as per their own repair procedure, claiming it must be replicated in order to authorize the repair. This is an already known fault by Toyota, yet their response was that a dangerous condition has to be duplicated even though vehicle diagnostic codes show that two transmission solenoids were stuck, and even though I provided them photos of the multiple warnings on the driver’s dash from when it occurred. Other vehicles with the same condition have been repaired without question. Vehicle had 1,574 miles on it and 1,579 once I arrived at the dealer.

The automatic will get stuck in a high gear, making it impossible to accelerate. I was almost hit trying to merge into traffic with the Transmission failing. Going from reverse to drive, the vehicle will "Buck", lurching forward. When at a red light, if the auto start/stop function kicks in, the car will also lurch into gear moving forward.

Purchased Truck with 127 Miles, at 327 miles noticed it wasn't shifting. Took truck back to Toyota and they stated there were metal shavings in the transmission and it needed to be replaced. They also stated they have no idea when they would be able to get a transmission.

new 2024 Tacoma sport. approx. 3800 miles. While driving automatic transmission revved hi, like it was in neutral. Lost power, went into limp mode. Multiple warnings on dash. Had truck towed to dealer. Next day they said transmission needed replaced. metal filings found inside transmission. Not sure how long it would be to repair. The dealership was very kind and sorry this happened. I told them it's not there fault, it's toyota

Drivers side front CV axle boot not clamped from factory. This caused grease to be thrown throughout wheel well including onto brakes. No warning lamps or indicators. Dealer confirmed issue but has no eta for parts to repair.

While driving on the highway A hybrid System Malfunction occurred, which caused the vehicle to be thrown into 2nd gear. Took the vehicle to dealership and they determined that the transmission had failed. The vehicle was only 1 week only and only had 822 miles on it.

Transmission failure

Transmission shifts rough in the morning from gears 1-2. I get some rough shifts when warmed up as well. With the about of automatic transmissions failing it’s time Toyota tell us what’s going on. How can we be expected to drive a new truck every day and worry about if the trans mission will fail.

My Tacoma SR5 with only 6000 miles of use failed the transmission or automatic gearbox when I was going on the highway hitting the transmission and neutralizing on several occasions having to exit the service channel abruptly so as not to get stranded in the middle of the highway and cause an accident. No warning light on the dashboard came on and according to the dealer it did not show errors or faults. On the third occasion they decided to leave it and tell me that the transmission had to be replaced. I have been waiting for more than 30 days for a response from the Toyota dealer with a promise that they would soon deliver my truck to me.

I was driving on the freeway going 68-70 MPH when I had a sudden loss of power. Vehicle could not maintain speeds and was sluggish while making it over to the side of the road. Vehicle was towed to dealership, which could not initially find anything. Next day after test driving vehicle, it was confirmed that the transmission is broken.

Eight speed transmission exhibited difficulty in downshifting to lower gears. Loud rumbling sound could be hard inside of truck cabin. Also, upon my inspection, found transmission fluid leaking on the garage floor. All of this occurred at less than 400 total miles on the vehicle. Vehicle was inspected by the local dealer Toyota Service Department and determined to be a defective transmission that must be replaced. It is possible that the transmission could have seized up while driving, causing the vehicle to be uncontrollable. No warning lamps or messages ...only the loud audible sound coming from the transmission. To date, it is unknown as to the cause of failure. At my request, Toyota has assigned a Case Number (#240809001043) and is investigating the failure.

5000 miles and new 2024 tacoma trd sport auto transmission stopped working . Gears 1-5 stopped engaging. Truck was stuck on road unable to move because truck was trying to start in 6th gear. Got truck towed to Toyota dealer. They contacted Toyota and stated transmission needs replacement along with torque converter. Truck has been at shop for 3 weeks now. Still waiting for parts to be delivered.

The contact owns a 2024 Toyota Tacoma. The contact stated while driving at an undisclosed speed, the vehicle stalled. No warning light was illuminated. The contact restarted the vehicle and drove to the residence. The vehicle was towed to the dealer, where it was determined that the transmission was stuck in sixth gear, and the transmission needed to be replaced; however, the parts were on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 2,300.

Mileage: 2,300

Pulled into a parking spot put the car in park. Engine stalled check engine light came on with “engine control system malfunctioning warning” . car will not start or completely turn off.

New vehicle abruptly began rumbling and shuddering. Vehicle became increasingly difficult to steer and control. Out of concern for driver safety, vehicle towed to dealer. Diagnosed with failed universal joint bearing and subsequent driveshaft damage.

TRUCK IS ACTING LIKE IT IS IN NEUTRAL SOMETIMES WHILE DRIVING. WILL REV SUPER HIGH WHEN GOING DOWN THE HIGHWAY AT 60, AS WELL AS NOT GOING FROM A STAND STILL. SHIFTING USING THE MANUAL MODE DOES NOT HELP IT AT ALL, AS IT STILL HAS THE SAME ISSUES. TO MAKE A LONG STORY SHORT, THE TRUCK IS HAVING HARD SHIFTS AND COMES OUT OF GEAR WHILE MOVING AND STOPPED.

Transmission experienced rough shifting from reverse to drive immediately followed by the inability to access gears 1-5. The transmission was within normal operating temperatures per the onboard temp readings. Going into park or neutral did not fix the issue. Stopping and restarting the engine allowed access to lower gears briefly, but once the vehicle shifted up, it could no longer access the lower gears. Shortly after this, the check engine light illuminated and the vehicle went into limp mode.

I bought a 2024 Tacoma TRD Off Road Premium Package through MAS ( Military Auto Source ). I picked the vehicle up from the Bremerhaven port in Germany on 08 July 2024 it was missing the back bed charging adapter box but MAS said they would cover the cost in writing to fix no big deal and I drove it back to Weiden Germany. Today 09 July 2024 I lost the ability to shift into 2nd, 4th, and 6th gear. There is only 2 of these vehicles in the country of germany right now. The vehicle has approximately 735 Km on it. It probably would have happen early had i been shifting more but the majority of my first in it was on the Autobaun in 6th gear going roughly 130 Km most of the way with no down shifting or ciry driving. The vehicle has not yet been inspected by a toyota tech due to the vehicle not being produced in Germany but it doesnt take a genius to look up the issue your having and see the exact thing from multiple other Toyota owners. Toyota would be best to buy this vehicle back and reach out to me. Vin [XXX] Below is the customer care email i requested be sent with my reference number and case number. Reach out to me upper mangment. Hi ×××× ××××××, We appreciate you taking the time to contact the Toyota Brand Engagement Center. We are dedicated to providing superior service. Your case is filed at our headquarters office under your name and file [XXX]. If you require further assistance, please send us a message by adding a comment here, or give us a call at 800-331-4331. Case Managers are available Monday through Friday from 8:00 a.m. – 8:00 p.m. ET. Thanks! - xxxxxx Toyota Brand Engagement Center HQ 469-292-4000 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Toyota Tacoma. The contact stated while driving at an undisclosed speed, the transmission failed to function as intended. The contact stated that the transmission only shifted into 1st and 2nd gear. The vehicle was taken to the dealer where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the parts to complete the repair were on back order. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 2,543.

Mileage: 2,543

While pulling out of my drive way I noticed when I pressed the gas pedal my truck barely moved, it felt like it was in neutral. I pressed the gas pedal further and it started to move but the RPMs were around 6000 RPM. I then pulled to the side of the road and tried shifting it into different modes, cycling through manual and automatic, but still nothing. I then noticed that while in manual mode the display read “S6”. Which I deduced meant sixth gear. Not wanting to be late for work I just pressed on the gas pedal till the truck got moving and drove the 18 miles to work in sixth gear. After returning to my truck after work, I started it up and it worked fine. A few days later I reported it to the dealer and they had me bring it in for a diagnosis. A day later they reported to me that the truck experienced a transmission failure and would have to be replaced. As of right now I am still waiting to hear when the replacement transmission will arrive. The maintenance advisor stated he could not give me a time frame for the parts to arrive or when the work would be completed.

Vehicle only has 209 miles and the transmission is out ,not driveable

Brand new 2024 Toyota Tacoma TRD Off Road automatic 2700 miles Truck is two weeks old The Toyota dealership called and reported that the entire transmission needed to replaced after being at the Toyota dealership for a week. Yes it is available for inspection. Toyota tech said that there are no spare transmissions in the U.S. and that it could take 3 months or longer to replace. Toyota tech found metal shavings in transmission fluid. Truck is entirely stock from factory with no customizations. Truck started shifting hard between a few gears and then got stuck in a higher gear and would not move forward even with accelerator to the floor. This was in the middle of the road with multiple vehicles behind me. I am not aware if anyone other than Toyota technicians have inspected the vehicle. There were no warnings, messages, or dashboard lights illuminated when this happened. Toyota dealership also refused to supply a rental car in the meantime while truck is being fixed. I am in the military and have no means to provide transportation to myself or family unless I pay out of pocket.

The contact owns a 2024 Toyota Tacoma. The contact stated while driving 10 MPH and depressing the accelerator pedal, the vehicle stalled. There was no warning light illuminated. The contact was able to pull to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced; however, the part to repair the vehicle was not available. The vehicle was not repaired. The manufacturer was notified of the failure and two cases were opened. The contact stated that there was a case for the vehicle replacement and another case for the distribution of parts to the dealer. The failure mileage was approximately 989.

Mileage: 989

Vibration between 25 & 45mph Confirmed by dealer technician possible transmission issue. First noticed on drive home after purchase. No incidents yet

I’ve only had the vehicle about a month with only 1245 miles on it. I was leaving a parking lot and pulled out on the road and the vehicle shifted in neutral after a minute or so the vehicle then slammed back into gear. It did this 2 or 3 times. I pulled into a gas station turned the vehicle off and waited a few minutes. I turned the vehicle back on backed out and preceded to drive when the same issue happened again. But now the vehicle would not shift into other gears. This time the check engine light came on with 3 reported errors 1. Advanced ultrasonic detecting and ranging system malfunction. 2. Drive-start control system malfunction. 3. Check engine light stating malfunction in the electronic control of the engine, throttle, or automatic transmission has been detected. I was only about a mile or 2 from a Toyota dealership and was able to limp the truck to the dealership. The dealership informed me today [XXX], that it will need a new transmission and that there were similar issues on new Tacomas across the US. There were no prior signs of any issues prior to the transmission failure. This happened on a roadway with traffic that comes in both directions. Thanks goodness this didn’t cause an accident has it happened out of the blue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)