2005 TOYOTA TUNDRA Structure Problems

The frame is so rusted in my truck my mechanic said it may snap at anytime and is not safe to drive. I know Toyota tundra’s from 2000-2003 have been recalled for same reason.

This report addresses the critical structural integrity concerns related to excessive corrosion, and frame material loss affecting the main ladder frame chassis. The degradation of the frame members poses a significant and immediate safety risk, including potential catastrophic structural failure, detachment of critical components, and failure of safety systems (e.g., braking and fuel lines) mounted to the frame. Location: Mid-frame section (beneath the cab) and rear sections (near the leaf spring mounts and rear axle).

1)Frame is rusting out. Not repairable. 2) Fuel tank strap rusted through and broken.

know issue with Toyota Tundra Frame, and refuse to give option to repair.

We are the first owner of this 2005 Toyota Tundra Limited with only 91K miles. The frame is rusted so badly that we are afraid to drive down the road. This rusted problem could cause potential harm or death to us and others on the road.

The contact owns a 2005 Toyota Tundra. The contact stated that the sub frame was rusted and had holes. The parking brake and oil warning lights were illuminated. The vehicle was taken to the local dealer, who determined that the vehicle might not pass a safety inspection due to the position of the holes and rust. The warning lights were repaired but the sub frame was not repaired. The vehicle was taken to a frame shop, the frame shop declined to service the vehicle. The manufacturer was contacted and informed the contact about an Extended Warranty, but no assistance was provided. The failure mileage was approximately 139,000.

Mileage: 139,000

Frame rusted thru to point it is unsafe to drive

Frame and suspension is rotted away badly was recall on frame In 2005

Severe frame rust due to cheap frame material. Earlier year models were recalled but 05 and 06 were not, just a limited campaign. Frame looks like it has been coated before, but this is a known issue with these trucks. I have contacted Toyota and they basically said, sorry, we can't do anything.

Severe rust throughout the frame

Original owner. Well known frame rust safety issue as documented by thousands of 2005 Tundra owners. Toyota did an inspection for frame rust several years ago and opted for coating to deal with issue hastily given the long delay/backlog with replacing entire frame. Two wrongs don’t make a right. Now major safety/inspection issues with frame area and gas tank. Unable to allow my child to drive back to college. Not safe. Not worth risking kids lives. Would be interested to learn how many owner/operators need to report serious injury/fatalities before NHTSA enforces action against Toyota for corporate greed.

The driver's side front frame has rotted out disconnecting the mount for the anti-roll bar. This has happened despite several reports to the dealership going back many years that the frame was rusting rapidly which, upon examination, they said that it was OK. They did apply a coating which might have delayed the process a bit but ultimately resolved nothing. For trucks that had perforated frames during the first few years, they replaced the frame. I tried to take care of mine, but it has finally failed and they say the replacement program is over. They are unwilling to provide even the necessary frame section and mounting bracket for the sway bar (~$545) for the frame shop to install %(2120).This vehicle has less than 98,000 miles on it and is used for short trips performing farmette duties. Frame failure can cause catastrophic accidents and should not be ignored by the manufacturer regardless of age. They know they used bad steel and should act accordingly. My action has been delayed by storm damage to frame shop which didn't reopen until December.

The contact owns a 2005 Toyota Tundra. The contact stated while performing a routine inspection, the contact noticed that the subframe was rusted on the front and the rear suspension of the vehicle. The vehicle was taken to the dealer and the mechanic stated that the vehicle had a spray-on coating however, the vehicle was rusted and the subframe needed to be replaced. The vehicle was not replaced. The manufacturer was not contacted. The failure mileage was 60,000.

Mileage: 60,000

******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE THE CONSUMER PLACED THE REQUEST.*DJR ******* DELETE VOQ *******

The contact owns a 2005 Toyota Tundra. The contact stated that he was informed at the State Inspection facility that the entire sub-frame of the vehicle was severely corroded. The dealer was not notified of the failure. The manufacturer was notified of the failure and advised the contact that they could not assist as the vehicle was not included in a recall related to the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 148,518.

Mileage: 148,518

The contact owns a 2005 Toyota Tundra. The contact stated that he was made aware of the vehicle's frame corrosion by an independent mechanic. The dealer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 98,000.

Mileage: 98,000

This vehicle was purchased as a certified used vehicle from Johnston Toyota. It was recalled by Toyota for a rust problem. In October 2014 the vehicle was treated by the dealer (Johnston Toyota) with a rust inhibiting compound due to the rust problem. Approximately 1-2 years ago this vehicle was inspected by an independent mechanic who stated that the vehicle was badly rusted, and he believed that Toyota had a program to address this issue. I spoke to the Toyota service department and I was told that this vehicle is not covered. Approximately 2 weeks ago an independent mechanic advised the rust problem is extensive and the vehicle will be unsafe to operate. Although Toyota advises that this is a widespread problem for this type vehicle, they refuse to address it. Furthermore, when I asked them why the rust inhibiting compound they used to correct the problem did not solve the issue, they further refuse to respond.

The contact owns a 2005 Toyota Tundra. The contact stated that while the vehicle was in for the state inspection, it was discovered that the subframe had sustained severe rusting and corrosion causing the vehicle to fail the state inspection. The cause of the rusting and corrosion was not determined. The local dealer and manufacturer were notified of the failure. The contact indicated that the vehicle was previously treated with a rust inhibitor coating, but the failure still occurred. The failure mileage was 311,000.

Mileage: 311,000

Frame is rusted. Whole on front passenger side frame.

FRAME IS VERY RUSTY. STRAP HOLDING FUEL TANK IS DANGEROUS , REAR SUSPENTION ,AND SHOCKS BROKEN

I seen that Toyota were recalled for the frame issues on 2004 and up, mine is 2005 tundra with frame issues, like it’s sad, such a nice truck, but frame is horrible. Why is mine not being shown as recalled, but yet I have frame problems? I got my truck from a 1 owner who had it since new, it just hit 100,000 miles on it, it was serviced by Toyota dealership, I’m not sure why they didn’t do nothing with it over the years to help or fix the rust issue on the frame. It’s not just a little rusty, it’s really rusty, and it was garage kept too. Did they forget to include my vin number when they started the recalls? Doesn’t make sense why they would fix some and not all, all around the same years. Thanks Jim

The frame has several holes in it. Toyota said they did the corrosion prevension on it and said the repair is out of warranty. The sway bar has broken free of the frame and there are several hole and flaking spots on the frame.

DISCOVERED SEVERE RUST THROUGH ON THE UNDERSIDE FRAME.

2005 TUNDRA FRAME IS RUSTED IN MANY PLACES. VERY BAD WHERE FRAME SECTIONS MEET AND NOW THE FRAME IS RUSTING THROUGH THE MAIN HORIZONAL FRAME ITSELF AS THE ATTACHED PICTURE INDICATES. THIS HAS BEEN AN ONGOING ISSUE FOR YEARS BUT IS BAD ENOUGH NOW THAT IT IS NOT SAFE AND WILL NOT PASS INSPECTION. I KNOW THERE WAS A RECALL ON THIS FRAME AND I WAS TOLD IT WAS OK WHEN I BROUGHT IT IN FOR THE RECALL. I T HAS BEEN RUSTING EVER SENSE. WE HAVE ONLY PURCHASED TOYOTAS AND LEXUS VEHICLES FOR THE LAST 20 OR MORE YEARS AND THIS IS THE THIRD TRUCK RUST HAS TOTALED. PLEASE HELP

I PURCHASED A 2005 TOYOTA TUNDRA UNAWARE OF THE WIDE-SPREAD RUST ISSUES THIS MODEL FROM TOYOTA IS SUFFERING. THE VEHICLE CAME WITH AN INSPECTION STICKER FROM THE DEALER SO IT WAS WELL PAST THE DEALER'S WARRANTY WINDOW TO DO ANYTHING ABOUT THIS ONCE I FOUND OUT ABOUT THE ISSUE. THE VEHICLE WAS PURCHASED IN MAINE AND WAS SOLD TO ME IN NEW YORK. I WAS INFORMED BY MY MECHANIC THAT THERE ARE 4 SERIOUS RUST ISSUES PRESENT ON THE VEHICLE THAT PREVENT IT FROM PASSING INSPECTION. 1) A LARGE SEVERAL SQUARE INCH PERFORATION IN THE CENTER OF THE FRAME MEMBER 2) "PANCAKING" PRESENT ON A LARGE SECTION OF THE FRAME 3) A LARGE PERFORATION IN ONE OF THE FRAME'S CROSS MEMBERS 4) A SIGNIFICANTLY RUSTED BODY MOUNT SOMEHOW, ONLY MODEL YEARS 2000-2003 WERE RECALLED FOR THE TUNDRA BY TOYOTA, AS IF THE REST OF THE GEN 1 TUNDRAS DIDN'T HAVE THE EXACT SAME FRAME PART NUMBER. WORSE YET, I REGISTERED ON TOYOTA.COM AND FOUND THAT THE PREVIOUS OWNER REQUESTED A FRAME REPLACEMENT 60,000 MILES AGO IN 2014. TOYOTA DID NOTHING AND INSTEAD APPLIED A "CRC" OR CORROSION RESISTANT COMPOUND TO THE TRUCK. BASED ON WHAT I'VE READ ONLINE THE APPLICATION OF THIS COATING THIS CAN MAKE YOUR TRUCK INELIGIBLE FOR THE RECALL SERVICE THIS ISSUE EFFECTIVELY TOTALS THE TRUCK AS IT WON'T PASS A SAFETY INSPECTION WITHOUT RECTIFYING THIS ISSUE. I AM IN QUITE AN UNFORTUNATE SITUATION AS A RESULT AS THIS IS MY ONLY VEHICLE.

Mileage: 160,000

LIMITED SERVICE CAMPAIGN DSD 2004-11006 TUNDRA FRAME INSPECTION. I BOUGHT AN 05 TUNDRA LAST YEAR. CALLED TOYOTA AND THEY SAID THIS RECALL IS OVER. MY FRAME NEEDS REPAIRING. THEY ARE NOT HELPING. DO I HAVE ANY RECOURSE?

WHILE DRIVING DOWN THE ROAD MY SPARE TIRE MOUNT FAILED DO TO RUST CORROSION CAUSING MY SPARE TIRE TO FALL OFF OF MY VEHICLE. UPON INSPECTION THE ENTIRE REAR FRAME AS WELL AS PARTS OF THE FRONT ARE CORRODED AND FLAKING CHUNKS OF METAL OFF. THIS RUSTING ALSO AFFECTS SUSPENSION MOUNTS AND THE ENTIRETY OF THE REAR AXLE.

Mileage: 139,500

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHEN THE VEHICLE WAS INSPECTED, HE LEARNED THAT THE VEHICLE WAS SEVERELY RUSTED. THE CONTACT CONTACTED DCH AUTO GROUP (955 U.S. 9, SOUTH AMBOY, NJ 08879; (877) 324-2886) WHO INFORMED THE CONTACT THAT PARTS OF THE VEHICLE HAD RUSTED THROUGH AND THE VEHICLE WAS NOT SAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND OPENED CASE. THE APPROXIMATE FAILURE MILEAGE WAS 193,000.*DT *TR*DT*JB

Mileage: 183,000

I PURCHASED TRUCK 2 YEARS AGO WITH A INSPECTION STICKER GOOD FOR 5 OR 6 MONTHS. WHEN INSPECTION WAS DUE I BROUGHT IT INTO HAVE IT INSPECTED. IT WOULDN'T PASS INSPECTION DO TO THE ADVANCED STATE OF CORROSION. I WAS TOLD THAT THERE WAS RECALL FOR FRAME REPLACEMENT DUE TO THIS PROBLEM AND ALL THESE TRUCKS ARE RUSTING OUT AND MANY STILL ON RD PUTTING LIVES IN JEOPARDY AS THOUSANDS ARE UNSAFE GOING DOWN HIGHWAYS. I BROUGHT IT INTO BERLIN TOYOTA IN PORTLAND ME ON RIVERSIDE DR. THEY BROUGHT ME TRUCK IN AND DID THE INSPECTION AND AGREED FRAME WAS NOT SAFE. THEY SAID MY TRUCK HAD TOO MANY MILES ON IT. I ASKED ABOUT THIS SAME TOYOTA THAT THEY BOUGHT BACK FROM A CUSTOMER WITH OVER A MILLION MILES ON IT ORIGINAL DRIVE TRAIN AND THEY HAVE BRAGGED THAT THESE TRUCK GO MORE THAN A MILLION MILES IF MAINTAINED PROPERLY. THEY KEPT TRYING TO TALK ME INTO BUYING A NEW TRUCK AND WERE ADAMANT ABOUT MY MILES BEING TOO HIGH. 220,009 MILES PLUS OR MINUS THIS WAS JUST OVER A YEAR AGO. I EXPLAINED TO THEM THAT I STILL OWED CLOSE TO 10,000 FOR THIS VEHICAL AND THAT THEY NEEDED TO STAND BEHIND IT. WELL LEFT EMPTY HANDED AND WENT BACK TO MY MECHANIC AMD TOLD HIM WHAT WAS SAID. HE INFORMED ME THAT THAT WAS RIDICULOUS BECAUSE HE HAD A CUSTOMER COME IN LAST WEEK THAT JUST HAD THEIR FRAME REPLACED AT 300,000 MILES AND IM JUST GETTING BLOWN OFF BY THEM. A YEAR LATER AMD I CANT EVEN GET TOYOTA TO RESPOND. THEY KEEP SENDING ME RECALL INFO ABOUT AIRBAG RECALL BUT WON'T ACKNOWLEDGE THE FRAME RECALL. ABOUT TWO WEEKS AGO MY MECHANIC CALLED ME TO SEE IF THEY REPLACED MY FRAME YET AND TOLD HIM NO. HE SAID THAT REALLY STRANGE BECAUSE HE'S HAD 3 CUSTOMERS OVER PAST 6 MONTHS WITH SAME TRUCK SAME YEAR AMD THEY WERE ABLE TO GET THEIR FRAMES REPLACED BY TOYOTA AND THEIR MILEAGE WAS AROUND THE SAME WITH THE EXCEPTION OF ONE BEING ALMOST 290,000. IM A SINGLE PARENT WITH CHILDREN AND IM MAKING PAYMENTS ON THIS.

Mileage: 200,000

FRAME UNDERNEATH AT SWAY BAR AND SURROUNDING AREA IS RUSTED OUT. IT COULD BE A HUGE SAFETY HAZARD. THIS IS ON THE RECALL LIST. I AM REQUESTING THIS BE FIXED.

TOOK VEHICLE FOR INSPECTION AND WAS INFORMED THAT THE FRAME WAS ROTTED OUT. I KNOW THIS IS COMMON WITH SOME OF TOYOTA VEHICLES AND THEY HAVE HAD RECALLS BUT NOT ON MY VEHICLE. VEHICLE ONLY HAS 59000 MILES ON IT. TOYOTA WAS OF NO HELP. BASICALLY TOLD ME TOUGH LUCK. TOYOTA DEALERSHIP ALSO OF NO HELP. NOT EVEN WILLING TO GIVE ME ANYTHING TOWARD NEW VEHICLE.

2005 TUNDRA WITH MAJOR FRAME RUST. TOOK IT IN DURING THE ORIGINAL RECALL WHERE THEY SPRAYED THE FRAME WITH A "RUST PREVENTATIVE COATING" WHICH FELL OFF IN A YEAR. THE FRAME IS NOW DANGEROUSLY RUSTY AND TOYOTA REFUSES TO DO ANYTHING MORE. TOYOTA NEEDS TO BE HELD RESPONSIBLE FOR REPLACING ALL OF THE AFFECTED FRAMES, NOT JUST THE ONES THAT DIDN'T PASS THEIR "INSPECTION" BACK WHEN THE ORIGINAL RECALL HAPPENED. THE RUST THROUGH PROBLEM IS A VERY WELL KNOWN ISSUE AND THERE ARE THOUSANDS OF TUNDRAS AND TACOMAS ON THE ROAD THAT ARE DANGEROUSLY RUSTY BECAUSE OF TOYOTA'S FAITHLESS RESPONSE TO THE PROBLEM. TOYOTA NEEDS TO BE FORCED TO REPLACE THE REMAINING FRAMES THAT WERE PART OF THE RECALL.

Mileage: 77,200

I RECENTLY PURCHASED THIS 2005 TUNDRA AND LATER FOUND OUT THAT THE FRAME OF THE VEHICLE WAS MASSIVELY RUSTED AND WILL NEED TO BE REPLACED. THIS VEHICLE WAS PART OF THE TOYOTA FRAME RECALL BUT WAS NEVER REPLACED AND AFTER CONTACTING TOYOTA THEY ARE TELLING ME THAT THEY WILL NOT REPLACE THE FRAME. TOYOTA SAID THE FRAME WAS 'TREATED' IN 2015 AND THAT SHOULD'VE TAKEN CARE OF ANY ISSUES. GIVEN THE PHOTOS THIS RUST HAS BEEN BUILDING FOR YEARS. THIS VEHICLE IS NOT ONLY DANGEROUS TO DRIVE BUT IS EFFECTIVELY USELESS. CONSIDERING IT ONLY HAS 77,000 MILES ON IT THIS LEVEL OF RUST SHOULD NOT BE PRESENT. *TR

Mileage: 77,000

THE VEHICLE WILL NOT PASS INSPECTION DUE TO FRAME FOR. THE BODY AND ENGINE ARE IN GREAT CONDITION FOR THE AGE. AN UNDERCOATING WAS APPLIED BUT DID NOT PREVENT THE RUST FROM SPREADING. TOYOTA HAS REPLACED MANY FRAMES FOR THIS SAME REASON AND SHOULD INCLUDE THE '04-'06 MODEL YEARS TO ENSURE ALL OWNERS OF TRUCKS WITH FAULTY FRAMES ARE SAFE. *TR

Mileage: 170,000

SIGNIFICANT FRAME CORROSION IN MULTIPLE AREAS TO INCLUDE ONE AREA WITH A HOLE ALL THE WAY THROUGH THE FRAME RAIL, AND MOST ACUTELY WHERE THE REAR LEAF SPRING CONNECTS TO THE FRAME WITH ONLY 50% OF THE CONTACT AREA APPEARING TO BE STRUCTURALLY SOUND. INSPECTED BY TOYOTA DEALERSHIP WHO RATED DAMAGE AS JUST BARELY BETTER THAN UNSAFE TO DRIVE, HOWEVER NOT COVERED UNDER RECALL. VEHICLE HAS 175K MILES ON IT, AND HAS SPENT THE MAJORITY OF ITS LIFE IN SC AND MD WHERE ROAD SALT USAGE IS LOW. FREQUENTLY CLEANED UNDERCARRIAGE, AND PERIODIC APPLICATION OF CORROSION PREVENTATIVE COMPOUNDS DID NOT ALTER OUTCOME WHICH IMPLIES POOR MATERIALS AND/OR MANUFACTURING DEFECTS. *TR

Mileage: 175,000

MY 2005 TOYOTA TUNDRA THE FRAME HAS ROTTED THROUGH BEHIND THE FRONT TIRE ON THE DRIVER SIDE. THE VEHICLE WILL NOT PASS A NEW YORK STATE INSPECTION. TOYOTA EXTENDED THE WARRANTY UNTIL 2015 IN 2014. THEY KNOW THERE'S A PROBLEM WITH THESE VEHICLES BUT CURRENTLY THEY REFUSE TO ADDRESS. THE VEHICLE IS NOT SAFE TO DRIVE IN ITS PRESENT CONDITION. THERE APPEARS TO BE A LOT OF TOYOTA VEHICLES WITH SIMILAR PROBLEMS THAT THE MANUFACTURER IS REFUSING TO ADDRESS.

Mileage: 211,000

SIGNIFICANT FRAME RUST, AFFECTING THE STRUCTURE OF THE VEHICLE

Mileage: 1

MAIN FRAME OF THE 2005 TUNDRA IS ROTTEN FROM RUST AND A CHUNK OF THE FRAME HAS FALLEN OUT. SEE PICTURE. I CONTACTED LOCAL TOYOTA DEALER AND THEY SAID THERE IS NOTHING THEY CAN DO AS RECALL HAS EXPIRED AND TOYOTA CORPORATE WILL NOT DO ABSOLUTELY NOTHING. THIS TUNDRA WAS SUPPOSED TO BE SPRAYED IN 2014 AS PART OF THE "FIX" BUT THE FRAME IS RUSTING AND ROTTING APART. MORE SIGNS OF ROTS ARE VISIBLE ON THE FRAME.

Mileage: 151,000

I OWN A 2005 TOYOTA TUNDRA WITH JUST 60,000 MILES. IN 2014 TOYOTA WAS ALLOWED TO PUT A BAND-AID ON A PROBLEM THAT NEEDED A TOURNIQUET - APPLYING A RUST CONVERTER COATING TO A FRAME THAT, BECAUSE OF THEIR FAILURE TO MANUFACTURER IT PROPERLY, DESERVED REPLACING. I WAS TOLD BY TOYOTA (CASE NUMBER [XXX]) THAT BECAUSE THE PREVIOUS OWNER TOOK THE BAND-AID THEY WERE NO LONGER LIABLE UNTIL THE GOVERNMENT FORCED THEM VIA FURTHER GOVERNMENT SAFETY RECALL ACTIONS TO DO MORE. MY HOPE IS BY WRITING THIS THAT THE GOVERNMENT CAN BE PROACTIVE AND SOLVE THIS SAFETY CONCERN BEFORE THEY HAVE TO COLLECT ENOUGH DEATH AND ACCIDENT STATISTICS TO TAKE NOTICE OF THIS ISSUE. NOT ONLY THAT, I SEE THAT TOYOTA IS BEING OFFERED THE SAME BAND-AID SOLUTION ON A NUMBER OF NEW MODELS WITH THE SAME ISSUE - PROVING THAT THEY DIDN'T LEARN ANY LESSON JUST HOW THEY CAN GET AWAY WITH ACTUAL MURDER. THE RESULT WILL BE MORE VEHICLES IN 5 YEARS IN WORSE SHAPE DUE TO THE LENIENT RECONCILIATION MANDATED BY THE GOVERNMENT. DO NOT PUT MORE LIVES AT RISK IN ORDER TO SAVE A MULTI-BILLION DOLLAR COMPANIES BOTTOM LINE. THE FRAME WHICH IS KNOWN TO BE PRONE TO EXCESSIVE, PREMATURE RUST CORROSION BECAUSE THE FRAMES WERE NOT PROPERLY PREPARED AND TREATED AGAINST RUST CORROSION WHEN THEY WERE MANUFACTURED SHOULD ALL HAVE TO BE REPLACED UNDER THIS RECALL TO PROTECT AMERICAN DRIVERS. THIS EXCESSIVE RUST CORROSION COMPROMISES THE VEHICLES' SAFETY, STABILITY, AND CRASH-WORTHINESS BECAUSE IMPORTANT SUSPENSION COMPONENTS, ENGINE MOUNTS, TRANSMISSION MOUNTS, AND BODY MOUNTS ANCHORED TO THE VEHICLES' FRAMES ARE AT RISK OF FAILURE. DO YOU WANT THIS VEHICLE (PICTURE ATTACHED) PASSING YOUR FAMILY ON A TWO-LANE HIGHWAY, BECAUSE I CAN TELL YOU THERE ARE A LOT, AND SOON TO BE EVEN MORE, DOING IT EVERY DAY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 60,000

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT EXPERIENCED ISSUES WITH THE VEHICLE'S FRAME EVER SINCE IT WAS PURCHASED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE WHO STATED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO PRIME TOYOTA (783 PORTLAND ROAD, SACO, ME 04072, 202 252-6161) WHERE IT WAS DIAGNOSED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 1912111347. THE CONTACT WAS INFORMED THAT THE REPAIRS WERE NOT COVERED. THE FAILURE MILEAGE WAS 156,000. *TR

Mileage: 156,000

I WENT TO HAVE MY 2005 TOYOTA TUNDRA INSPECTED AND IT FAILED DUE TO FRAME CORROSION CAUSING FRACTURE AND SPLINTERING OF THE FRAME SUPPORTS. THE FRAME OF MY 2005 TOYOTA TUNDRA HAS RUSTED THROUGH AT 4 POINTS, FRACTURING AND SPLINTERING AT 3 OF THE POINTS OF FAILURE. THE VEHICLE CAN NOT PASS THE VIRGINIA INSPECTION AND IS NOW UNDRIVEABLE. IT IS NOT SAVE TO HAUL OR TOW ANYTHING, THE TWO MAIN FUNCTIONS OF MY TRUCK.

Mileage: 149,000

FRAME IS RUSTING , AND WILL NOT PASS PA STATE INSPECTION.

Mileage: 161,539

FRAME HAS PREMATURELY RUSTED RESULTING IN THE SWAY BAR MOUNTING BRACKET TO BREAK OFF. FRAME IS CLOSE TO COMPLETE FAILURE WHICH WOULD RESULT IN FUEL AND BRAKE LINES SEVERING WITH CATASTROPHIC RESULT.

Mileage: 125,000

BRAKES FAILED2 TIMES IN LESS THAN 1 YEAR CAUSE OF FAILURE,BRAKE LINES RUSTED THROUGH. FRAME IS VERY RUSTY THE TRUCK WAS IN MOTION BOTH TIMES

Mileage: 195,000

WHILE DRIVING TRUCK ON PUBLIC ROAD, I HEARD A LOUD POP SOUND. PULLED OFF THE ROAD AND LOOKED UNDER THE TRUCK AND LOOKED LIKE THE SPARE TIRE WAS LOOSE. REMOVED THE SPARE TIRE AND PLACED IN THE BED OF THE TRUCK AND FURTHER INSPECTED THE REAR CROSS MEMBER. IT APPEARED TO BE CRACKED. CALLED TOYOTA DEALERSHIP TO HAVE TRUCK FRAME INSPECTED SPECIFICALLY THE REAR CROSS MEMBER. I HAVE ATTACHED THE WORK ORDER FROM HICKORY TOYOTA WHICH STATES DO NOT RECOMMEND DRIVING VEHICLE. HAVE ALSO ATTACHED A COUPLE OF PICTURES WHERE I HAVE HAD TO REPLACE THE REAR SHACKLE BRACKET ON THE REAR DRIVERS SIDE AND ALSO THE RACK PORTION OF THE RACK& PINION STEERING. I HAVE ATTACHED THE INVOICE FOR THE REAR BRACKET AND CAN SUPPLY AN INVOICE FOR THE RACK IF NEEDED.

Mileage: 191,300

TOYOTA TUNDRA FRAME RECALL - FRAME COATING APPLIED PER RECALL IN 2014. VEHICLE INSPECTED TWICE BY DEALER IN 2018 & 2019 AND VEHICLE DETERMINED TO BE OK. RECENTLY EXPERIENCED LOSS OF BRAKES AND CRASH INTO GARAGE. VEHICLE INSPECTED BY INDEPENDENT MECHANIC AND FOUND 2 PERFORATED AND RUSTED BRAKE LINES. SCRAPING AWAY THE UNDERCOATING UNCOVERED OTHER CORROSION IN VARIOUS DEGREES. DETERMINED THAT SPRAY UNDERCOATING CAME WAY TO LATE AS TRUCK ALREADY HAD 9 YEARS OF CORROSION. UNDERCOATING ONLY HID THE PROBLEM. SUBMITTED A CLAIM WITH TOYOTA WHO OFFERED NO ASSISTANCE.

Mileage: 140,000

DURING ANNUAL INSPECTION ON JULY 19, 2019, RUST HOLES FOUND IN THE FRAME. ONE HOLE WAS ALMOST 2 INCHES IN DIAMETER. ADDITIONAL PERFORATIONS FOUND NEAR THE LEAF SPRING AREA. VEHICLE WAS SUBJECT TO LSC IN 2014 AND TREATED WITH CRC COMPOUND. THIS JUST APPEARS TO HAVE DELAYED THE ONSET OF THE FRAME CANCER. TOYOTA WAS NOTIFIED. NO SUPPORT FROM THEM - THEY ARE SAYING IT IS MY PROBLEM.

Mileage: 95,480

SEPT 2014 MY TRUCKS FRAME WAS RECALLED FOR THE RUST PROBLEM. THE FRAME WAS SCALED AND SPRAYED. MILEAGE 134,500. 6/2018 WITH MILEAGE 164,301 DEALER ADVISES ME FRAME IS GETTING RUSTY! I SAID YOU SCALED AND COATED IT IN 2014 ISN'T IT WARRANTED? THERE ANSWER WAS THAT ENDED LAST MONTH. NOW IT'S A YEAR LATER JUNE 2019 IT ONLY HAS 171,000 AND ONLY 36,500 MILES SINCE THE FRAME WAS COATED. THE TOYOTA DEALER FAILED THE NH STATE INSPECTION. I AM VERY UPSET AS I HAVE SPENT OVER $4500 IN THE PAST 18 MONTHS ON OTHER REPAIRS AND ON GONE 8K MILES. I NEVER WOULD HAVE DONE THOSE REPAIRS IF I WAS ADVISE HOW BAD IR HOW FAST THE RUST WAS GOING TO MAKE MY TRUCK UNSAFE TO DRIVE. WHY DID OTHER TRUCKS GET NEW FRAMES BECAUSE THEY DROVE MORE MILES THEN ME AND HAD THERE FRAMES RUST FASTED. THERE ARE TRUCKS NOW OF THE SAME AGE WITH NEW FRAMES WITH WELL OVER 200K +MILES BECAUSE THERE FRAMES RUSTED FASTER( TIME WISE). THIS IS NOT FAIR FOR THOSE WHO STILL HAVE JUNK FRAMES. ALL THE FRAMED ARE JUNK! BUT MANY GET STUCK WITH THEM BECAUSE IT TOOK LONGER TO RUST TO THE POINT OF FAILER BECAUSE WE DROVE THEM FEWER MILES PER YEAR! MY FRAME HAS FAILED IN THE SAME PLACES AS EVERY FRAME THAT HAS BEEN REPLACED,BUT BECAUSE IT LASTED PAST MAY 2018 MY TRUCK IS JUNK NOW BUT THE PERSON WHO'S FRAME RUSTED OUT BEFORE MAY 18 GETS TO CONTINUE DRIVING IT WITH THERE REPLACEMENT FRAME! HOW IS THIS FAIR???? IF MY FRAME WASN'T SCALED AND COATED IT WOULD HAVE RUSTED BEFORE MAY 2018 AND BEEN REPLACE! THEY JUST MADE IT LAST LONGER TO GET PAST THE MAY 2018 DATE!

I HAVE ONLY OWNED THIS TRUCK FOR ABOUT 6 MONTHS NOW. TOOK MY TRUCK TO MY MECHANIC TO GET SOME BRAKE WORK DONE. WHEN HE PULLED THE TIRE OFF OF THE FRONT PASSENGER SIDE HE NOTICED A CRACK IN THE FRAME. SOME FURTHER INVESTIGATION REVEALED SOME VERY BAD ROT ON THE FRAME AND A HOLE ABOUT THE SIZE OF TWO FISTS THAT SOMEBODY HAD TRIED TO PATCH WITH JUST BONDO AND PAINTED BACK OVER TO HIDE IT. IT WOULD NOT HAVE BEEN VISIBLE WITHOUT PULLING THE TIRE OFF. UNSURE OF WHEN THIS ALL OCCURRED BUT APPEARS TO HAVE BEEN ROTTED OUT FOR A WHILE. I HAVE NO PICTURES TO UPLOAD AS IT IS UNSAFE TO DRIVE AND STILL AT THE GARAGE. I'M CONCERNED ABOUT THE SAFETY OF OTHERS DRIVING THESE LATER YEARS FIRST GENERATION TUNDRAS AND TOYOTAS NEGLECT AT FIXING THIS SAFETY ISSUE

Mileage: 108,000

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE AT TOYOTA OF BEDFORD (18151 ROCKSIDE RD, BEDFORD, OH 44146), THE TECHNICIAN INFORMED THE CONTACT THAT THE FRAME WAS CORRODED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.

Mileage: 190,000

MY 2005 TOYOTA TUNDRA HAS 217K MILES AND IS, MECHANICALLY, IN TERRIFIC SHAPE, EXCEPT THE FRAME HAS RUSTED OUT ON THE DRIVERS SIDE. STRUCTURALLY, IT'S STILL DRIVABLE SAFELY, BUT IT WILL NO LONGER PASS STATE INSPECTION (MAINE, USA). THOUSANDS OF OTHER TOYOTA TUNDRAS OF THE SAME STYLE AND MANUFACTURING PROCESS AND SIMILAR MODEL YEAR HAVE HAD FRAME RECALLS DONE FOR THE EXACT SAME REASON. I DO NOT FEEL IT IS FAIR TO SKIP THIS YEAR. THIS IS MY FAMILY'S ONLY SOURCE OF TRANSPORTATION RIGHT NOW, AND IT IS VITAL TO KEEP IT ON THE ROAD. PLEASE ALLOW A FRAME RECALL FOR THIS MODEL YEAR!

Mileage: 217,000

BOUGHT THE TUNDRA IN LATE 2014 FROM TOYOTA OF KEENE IN NH. WAS TOLD FRAME WAS CHECK AND THE RUST PREVENTION SPRAY WAS APPLIED, VEHICLE FRAMED LOOKED CLEAN AND HAD NO VISIBLE RUST , THEY COULDN'T PROVIDE ME WITH ANY RECORD OF THIS . IN FEBRUARY OF 2016. I TOOK THE VEHICLE TO GRAPPONE AND HAD NOTICED SOME RUST ON THE FRAME AROUND THE GAS TANK AND UNDER THE DRIVERS SIDE. GRAPONNE TOLD ME THAT THE FRAME SERVICE WAS COMPLETED AND THEY COULDN'T ( OR WOULDN'T) BE ABLE TO HELP AND NOTED THE SPRAY WAS INTACT. AFTER THAT THE POWER STEERING ROTTED AWAY WHICH GRAPPONE TOYOTA REPLACED AND AT THAT TIME I BROUGHT THE RUST TO THERE ATTENTION AGAIN . THEY SAID IT LOOKED NORMAL AND NOT TO WORRY. AFTER THAT I KEPT MY EYE ON IT. BROUGHT IT TO GET MY ANNUAL INSPECTION. THE TECH BROUGHT ME OUT SHOWED ME THE RUST AND TOLD ME THAT I HAD 1 OR 2 YEARS LEFT BEFORE THE FRAME WOULD NEED TO REPLACED OR REPAIRED DUE TO RUST . THE TUNDRA HAS 155.XXX MILES ON IT GETS WASHED REGULARLY . CONTACTED TOYOTA USA THEY TOLD ME THEY WOULD HAVE SOMEONE CONTACT ME. TOYOTA OF KEEN CALLED ME AND TOLD BE THE TRUCK WAS OLD AND THE PERSON WHOM I SPOKE WITH TOLD ME IT WAST HIS FAULT BECAUSE HE WASN'T THERE AND THE PROBLEM AREAS I DESCRIBED TOYOTA DIDN'T PAY THE TO SPRAY PROPERLY, ( PARTS PEOPLE CANT SEE UNLESS THEY REALLY LOOK) BUT I COULD DRIVE IT IN AND THEY COULD LOOK AT IT . I CALLED TOYOTA USA AFTER RECEIVING AN EMAIL THE NEXT DAY THAT STATED I HAD THERE POSITION REGARDING MY INCIDENT AND THE REP SAID IT WASN'T TOYOTA'S PROBLEM BECAUSE THE EXTENDED SERVICE PROGRAM WAS NOT A RECALL AND EXPIRED IN 2015 I FEEL THAT IF TOYOTA KNEW THERE WAS A PROBLEM WITH THESE FRAMES THEY MIGHT INCLUDED THEM WITH ALL THE OTHER MODELS A BUT THEY DECEITFULLY COVERED UP THE PROBLEM WITH A SPRAY THAT HIDES THE PROBLEM LONG ENOUGH TO MAKE THEM "OLD " AS THEY PUT IT . MANY OTHERS WOULD AGREE

Mileage: 155,500

WAS PULLING LIGHT DUTY COVERED UHAUL TRAILER THAT WAS MAYBE 1/10 FULL OF HOUSEHOLD ITEMS. FRAME PULLED APART. WAS IN MY DRIVEWAY WITH SON IN LAW HELPING GUIDE BACKING UP TO GARAGE.

Mileage: 101,732

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME UNDERNEATH THE DRIVER'S SIDE BUCKLED WHEN IT WAS PLACED ON THE LIFT AT STOLTZ TOYOTA OF DUBOIS (860 BEAVER DR, DUBOIS, PA 15801, (814) 371-3333. THE DEALER STATED THAT THERE WAS A VOLUNTARY RECALL ON THE FRAME AND ADVISED THE CONTACT TO CALL THE MANUFACTURER. THE MANUFACTURER STATED THAT THE VOLUNTARY RECALL EXPIRED IN JULY OF 2015 AND THEY COULD NOT ASSIST. THE CONTACT DID NOT RECEIVE A RECALL NOTICE. THE CONTACT PURCHASED THE VEHICLE IN 2009 FROM THE ORIGINAL OWNER. THE FAILURE MILEAGE WAS 150,000.

Mileage: 150,000

FRAME IS RUSTING AND BREAKING

Mileage: 130,000

MY 2005 TUNDRA IS ROTTING OUT IN THE FRAME ABOVE THE REAR LEAF SPRING FRONT CONNECTION TO THE FRAME. DEALER HAS LOOKED AT IT TWICE IN THE LAST SIX YEARS SAID NO PERFORATIONS. NOW IN 2018 THE FRAME IS ROTTING AND BUCKLED. TOYOTA CORPORATE SAYS THERE IS NOTHING THEY CAN DO BECAUSE IT OUTSIDE OF THE WINDOW OF SERVICE. SO NOW I AM STUCK WITH A TRUCK WITH JUST OVER 100K MILES, LOOKED AT BY A TOYOTA DEALER IN THE PAST AND WAS DEEMED NOT IN NEED OF A FRAME REPLACEMENT. NOW IT IS IN NEED OF A FRAME REPLACEMENT BUT TOYOTA WON'T HONOR ANY PAST RECALLS OR INSPECTIONS DONE BY A TOYOTA DEALER AND HAS LEFT IT TO ME TO DEAL WITH THE ROT. VERY DISAPPOINTED THERE IS NO HELP FOR CUSTOMERS IN THIS SITUATION FROM THE MANUFACTURER.

Mileage: 103,000

GOOD AFTERNOON, I'M WRITING TO REPORT AND REQUEST ASSISTANCE WITH CATASTROPHIC FRAME ISSUES ON MY 2005 TOYOTA TUNDRA. THERE ARE A NUMBER OF HOLES IN THE FRAME AND PLACES I BELIEVE TO BE COMPROMISED. THE TRUCK HAS 96,000 MILES. I HAVE AN OPEN INCIDENT TICKET WITH TOYOTA BUT ALSO WANTED TO REPORT THIS ISSUE HERE.

MY 2005 TOYOTA TUNDRA WAS RECALLED FOR RUST PROBLEMS, AND IN 2013 THE TOYOTA DEALERSHIP APPLIED A COATING TO THE FRAME WHICH THEY ADVISED WOULD REMEDY THE PROBLEM. ON 06/01/18 I NOTICED I HOWEVER HAVE HOLES IN MY FRAME NEAR WHERE THE SUSPENSION ATTACHES, AND THE FRAME IS NOT SAFE FOR OPERATION ON THE ROAD. THE DEALERSHIP SAID THEY ARE NOT LIABLE, AND I CALLED TOYOTA AND THEY SAID THEY ARE NOT LIABLE AND NO ONE WILL FIX THE ISSUE. THE DEALERSHIP HAD THE OPTION IN 2013 TO EITHER SPRAY OR REPLACE THE FRAME, THEY SPRAYED MINE BUT IT WAS NOT EFFECTIVE AND NOW I BELIEVE THE VEHICLE IS A HAZARD DUE TO HOLES IN THE FRAME. I ONLY HAVE 118,000 MILES ON THE TRUCK, AND IT HAS BEEN IN MY FAMILY SINCE BEING BRAND NEW. I BELIEVE THE FRAME IS DEFECTIVE AND TOYOTA INC. IS NOT ASSISTING ME WITH FIXING THE PROBLEM, THEY ADVISED ME I NEED TO GO TALK TO A BODY SHOP TO SEE IF THEY CAN WELD A PIECE INTO THE FRAME.

Mileage: 118,000

MAJOR RUSTING OF FRAME, RUSTED BRAKE LINES, RUSTED POWER STEERING LINES. VEHICLES IS UNSAFE DUE TO RUSTING.

I HAVE A 2005 TOYOTA TUNDRA, WHICH HAS THE ENTIRE FRAME ALL RUSTED. I ALREADY REPLACED ALL BRAKE LINES AND DIFFERENTIAL BECAUSE OF THE RUST. THE MECHANIC SAID IT IS RUSTED SO BAD THAT IT COULD FALL APART. THERE WAS A LIMITED CAMPAIGN FOR A RECALL ON OUR TUNDRA AND THE SPRAY WAS DONE IN 2015. OBVIOUSLY IT DIDN'T TAKE BECAUSE OF ALL THE CONTINUOUS ISSUES WE ARE HAVING. I CALLED THE CORPORATE OFFICE OF TOYOTA AND OPENED AN CLAIM AND THE MANAGER I SPOKE TO REALLY COULD CARE LESS AND TOLD ME THAT ONCE THE WARRANTIES ARE OVER ITS NO LONGER THEIR (TOYOTA) PROBLEM. I REQUESTED A FIELD INSPECTION TECHNICIAN TO LOOK AT THE TRUCK . THAT REQUEST WAS DENIED BY THE MANAGER WHO STATED THAT HE WAS SPEAKING FOR TOYOTA. I ASKED FOR MY CLAIM TO BE REVIEWED BY SOME ONE ABOVE HIM AND HE STATED THEIR WAS NO ONE HIGHER THEM HIMSELF AND HIS DECISION WAS FINAL. I DON'T UNDERSTAND WHY THEY CAN'T LOOK AT THEIR PRODUCTS AND TELLS US IF IT IS SAFE TO DRIVE. OBVIOUSLY THEY NEW THERE WAS A PROBLEM OR THEY WOULDN'T HAVE THE LIMITED CAMPAIGN FOR A RECALL. THEY NEED TO DO MORE.

Mileage: 105,000

THE FRAME HAS ROT ON IT AND TOYOTA HAS RECALLED YEARS BEFORE AND AFTER MINE FOR FRAME REPLACEMENT BUT NOTHING FOR 2005

TOYOTA HAS JUST SETTLED A CLAIM FOR FRAME RUST FOR 2007-2008 TUNDRAS. I OWN A 2005 TUNDRA AND THE FRAME IS COMPLETELY RUSTED AND MUST BE REPLACED. I DON'T UNDERSTAND WHY I'M HAVING THE SAME PROBLEMS AND IT IS NOT COVERED IN THE RECALL.

THE BREAKLINE BROKE IN AUGUST 2017 TOOK IT TO MECHANIC LEARNED THAT THE FRAME WAS TOO RUSTED TO PUT IT ON THE LIFT TO FIX THE BRAKE LINE - LEARNED IT HAD BEEN UNDER COATED BY TOYOTA JUNE 2014. DIDN'T WORK - RUSTED FULL OF HOLES AND CRACKS !

Mileage: 136,000

TOYOTA FRAME RUST, 2005 TOYOTA TUNDRA RECALLED AND "INSPECTED" IN 2014 BY TOYOTA FOR RUST HOLES. REPORT WAS THAT NONE WERE FOUND AND TOYOTA PERFORMED A "GOODWILL" SPRAY UNDERCOAT. PLEASE EXAMINE PICTURES OF SWAY BAR MOUNT TO FRAME AS WELL AS GAPPING HOLE IN FRAME DISCOVERED TWO DAYS AGO. TOYOTA HAS AN OBVIOUS FRAME PROBLEM AND HAS REPLACED FRAMES IN 2000-2003 TUNDRAS AS WELL AS 2007-2008. WHY NOT IN 2004-2006 WITH OBVIOUS ISSUES? PLEASE HELP.

2005 TOYOTA TUNDRA. CONSUMER WRITES IN REGARDS TO REPLACEMENT PARTS NOT AVAILABLE TO REPAIR AIRBAG RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE WAS RETURNED DAMAGED FROM HAVING A RECALL REPAIR COMPLETED. UPDATED 09/14/2017*JS UPDATED 09/14/2017*JS

ON 09/09/17 THE FRAME RUSTED THROUGH CAUSING A ME TO RUN OVER A CURB AND INTO A PARKING LOT. TOYOTA TREATED THE FRAME TO PREVENT RUST, BUT IT DID NOT STOP IT. NOW IT HAS RUSTED THROUGH AND CAUSED AN ACCIDENT. THIS IS DANGEROUS AND ALMOST KILLED US! IN ADDITION TO THE IMAGES I HAVE SENT, I CAN PROVIDE MANY MANY MORE!

Mileage: 75,000

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. UPON INSPECTION, IT WAS DISCOVERED THAT THE SUBFRAME OF THE VEHICLE SUSTAINED SEVERE RUST AND CORROSION. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER (ROCHESTER TOYOTA IN ROCHESTER, NH) WAS NOTIFIED, BUT THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 75,000.

Mileage: 75,000

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO STEVE HAMLIN, AN INDEPENDENT MECHANIC SHOP, FOR YEARLY INSPECTION WHERE IT WAS NOTICED THAT THE ENTIRE FRAME UNDERNEATH THE VEHICLE WAS CORRODED. THE CONTACT ALSO STATED THAT PART OF THE FRAME THAT PROTECTED THE HEAT SHIELD BECAME DETACHED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS A CLASS ACTION SUIT FOR THE SAME ISSUE, BUT THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 97,012.

Mileage: 97,012

THE ENTIRE FRAME OF THE TRUCK AND EVERY COMPONENT DIRECTLY IN CONTACT WITH IT INCLUDING THE SUSPENSION IS AND HAS BEEN OXIDIZING/RUSTING/ROTTING OFF IN LAYERS SOME FRAGMENTS OF RUST SCALE FALLING OFF MEASURE 1/8" IN THICKNESS I CONTACTED TOYOTA OF NORTH AMERICA KNOWING ABOUT THE RECALLS ON THE TOYOTA TACOMA MODEL TRUCKS WITH ALOT OF DETAILED PHOTOS THEY SAID BASICALLY TOO BAD. IVE KEPT THE UNDERCARRIAGE CLEAN EVEN TRIED USING COATINGS TO SLOW THE DETERIORATION DOWN THE TRUCK HAS 122,000 MILES ON IT AND WAS VERY WELL TAKEN CARE OF THE PROBLEM IS TOYOTAS POOR QUALITY STEEL USED AND IMPROPER FACTORY COATINGS I PURCHASED THE TRUCK IN 2014 AND I GLIMPSED UNDERNEATH THE DAY I BOUGHT IT AND THOUGHT THE FRAME LOOKED GOOD THEN A FEW MONTHS GO BY AND I GO TO DO A TUNE UP AND I START SEEING HUGE RUST SCALE FALLING ALL OVER UPON FURTHER INVESTIGATION NOTICED THE PROBLEM AND HOW BAD IT WAS AS WELL AS THE REASON I DIDNT NOTICE IT AT THE DEALER WAS THEY SPRAY PAINTED THE UNDERSIDE BLACK TO HIDE THE PROBLEM, I AM A MARINE CORPS VETERAN I SERVED 2007-2011 ACTIVE DUTY EVERY PENNY I HAD SAVED UP I USED TO BUY THIS TRUCK (MY FIRST BIG PURCHASE ALL IN CASH) IVE PUT THOUSANDS INTO THIS TRUCK ALREADY REPLACING SUSPENSION COMPONENTS AND MOUNTS AND ITS BECOMING A TOTAL LOSS I CANT SELL IT TO A PRIVATE PARTY KNOWING HOW DANGEROUS IT CAN BE IF THE WRONG PART FINALLY ROTS ALL THE WAY THRU AND I CANT AFFORD A NEW VEHICLE I CAN BARELY FIND WORK WITH THE ECONOMY AND PERSONAL STRUGGLES I HAVE RELATED TO MY SERVICE, I AM BEYOND UPSET AND I PRAY SOMEONE SOMEWHERE CAN HELP ME I KNOW MY TRUCK IS NOT THE ONLY TUNDRA WITH THIS MAJOR PROBLEM

Mileage: 108,000

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD A CRUSHING NOISE COMING FROM THE REAR DRIVER SIDE. ONCE HE ARRIVED HOME, THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND NOTICED THAT THE FRAME HAD CORRODED THROUGH THE ENTIRE CHASSIS ON THE FRONT DRIVER SIDE. THE CONTACT ALSO STATED THAT THE FRONT OF THE CHASSIS DROPPED BELOW THE REAR PART APPROXIMATELY ONE INCH AND A QUARTER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY WOULD NOT ASSIST WITH THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000. ..UPDATED 06/27/17 *BF UPDATED 08/22/2017*JS

Mileage: 82,000

THE FRAME OF THE TRUCK WAS RECALLED FOR EXCESSIVE RUST. THE DEALER SPRAYED ON A COATING PER THE RECALL IN 2013. THE COATING HAS ALL FLAKED OFF AND THE FRAME IS LOSING CHUNKS OF RUST. TOYOTA KNOW ABOUT THIS PROBLEM BUT WON'T DO ANYTHING ABOUT IT ONCE THEY SPRAY THE DEFECTIVE COATING ON IT. THE TRUCK FRAME NEEDS REPLACED AND THEY WON'T DO IT. SOMEBODY IS GOING TO BE SERIOUSLY INJURED OR KILLED IN ONE OF THESE TRUCKS WHEN THE FRAME BREAKS AT SPEED.

Mileage: 70,000

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT NOTICED EXTENSIVE RUST AND CORROSION NEAR THE MOTOR MOUNTS. THE VEHICLE WAS INCLUDED IN A MANUFACTURER RECALL, BUT THE CONTACT WAS INFORMED THAT THE STATUTE HAD EXPIRED TO RECEIVE THE REPAIR. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WOULD BE REPAIRED BY A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFUSED TO REPAIR THE VEHICLE. THE RECALL DETAILS WERE NOT PROVIDED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED SEVERE CORROSION ON THE REAR FRAME OF THE VEHICLE. UPON INSPECTION, IT WAS DIAGNOSED THAT THE FRAME WAS "FLAKING AWAY" DUE TO SEVERE CORROSION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 129,000. UPDATED 10/06/16*LJ *JS

Mileage: 129,000

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE THE VEHICLE WAS BEING INSPECTED, IT WAS NOTICED THAT THE REAR FRAME WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 129,000. UPDATED 08/16/16*LJ *CN

Mileage: 129,000

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THERE WAS SEVERE CORROSION TO THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER TO BE INSPECTED. THE CONTACT WAS INFORMED THAT DUE TO THE SEVERE CORROSION, THE VEHICLE COULD NOT BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

Mileage: 102,000

I WENT TO A CERTIFIED TOYOTA DEALER FOR AN OIL CHANGE FEW DAYS AGO AND THEY NOTIFIED ME ABOUT THE MASSIVE CORROSION ON THE FRAME THAT DO NOT REFLECT THE AGE OR THE OVERALL CONDITION OF MY VEHICLE. THEY STRONGLY RECOMMEND ME TO STOP DRIVING THE VEHICLE IMMEDIATELY DUE TO THE HIGH DEGREE OF DAMAGE ON THE ENTIRE BODY. I JUST BOUGHT THIS VEHICLE FROM GRIECO MAZDA OF DELRAY BEACH ON 10/13/15. THE VEHICLE WAS NOT INSPECTED AT ALL PRIOR TO SELL IT TO ME BECUASE GRIECO MAZDA DID NOT MENTION THIS MASSIVE CORROSION WHILE DOING THE BUSINESS.

Mileage: 128,270

I BROUGHT MY TRUCK IN ON JULY 13TH 2015 TO HAVE THE FRAME INSPECTION DONE BY HURLBURT TOYOTA IN EPPING NH. THEY DETERMINED THAT MY FRAME PASSED INSPECTION AND WANTED ME TO BRING IT BACK TO HAVE CRC DONE. I EXPRESSED MY CONCERN ABOUT THE CONDITION OF MY FRAME WHEN I DROPPED IT OFF AND HANDED THE SERVICE REP TWO PIECES OF METAL THAT HAD BASICALLY FALLEN OFF IN MY HAND. I WAS TOLD NOT TO WORRY AND THAT THEY WOULD LOOK AT IT. I KNEW THE FRAME WAS IN BAD SHAPE AND WAS DISGUSTED WHEN I WAS TOLD THAT THERE WAS NOTHING WRONG WITH IT. I WAS THEN CONTACTED A FEW WEEKS LATER 2 DAYS BEFORE THE RECALL EXPIRED AND WAS ENCOURAGED TO GET MY TRUCK IN TO HAVE CRC DONE, BUT THEY COULD NOT PROVIDE ME A LOANER THAT I COULD TOW WITH SO I NEVER WENT IN. I WAS PREPARED TO UNDERCOAT TRUCK MYSELF AND WHILE UNDERNEATH MY TRUCK I FOUND A HOLE IN THE BOXED SECTION OF THE DRIVERS SIDE(NOT A DRAINAGE HOLE) I CONTACTED THE DEALER THAT INSPECTED AND THEY TOLD ME TO CONTACT TOYOTA CORP WHICH I DID AND RECEIVED A CASE # AND AFTER A LOT OF WASTED TIME WAS TOLD THERE WAS NOTHING THAT COULD BE DONE. SOMETHING NEEDS TO BE DONE ABOUT THE WAY THIS IS BEING HANDLED. THERE IS NO WAY THEY CAN GET CRC IN THAT BOXED SECTION WHICH IS WHERE MY PROBLEM IS. IT IS FRAME ROT NOT RUST. APPLYING CRC TO THAT AREA WILL PROBABLY ONLY MAKE THE ROT WORSE. I WAS TOLD THAT THEY DO A MORE THOROUGH INSPECTION BEFORE UNDERCOATING BUT THEY HAD MY TRUCK FOR TWO DAYS AND PRINTED ON SERVICE SLIP THAT IT PASSED. ALL OF THE FRAMES ARE BAD ON THESE TRUCKS. IM NOW STUCK WITH A TRUCK THAT I PAID $10,000 TWO YEARS AGO AND NOW FEEL ITS WORTH NOTHING. I WOULD NOT SELL IN THIS CONDITION AND CANT GET ANY HELP FROM TOYOTA! ANY THOUGHTS OR SUGGESTIONS WOULD BE GREATLY APPRECIATED.

2005 TOYOTA TUNDRA. CONSUMER WRITES IN REGARDS TO VEHICLE FRAME CORROSION ISSUES. *SMD THE CONSUMER STATED THE BED CORROSION WAS CAUSED BY THE FRAME RUST. HOWEVER, TOYOTA REFUSED TO COVER THE COST OF THE BED CORROSION. *JB

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT THE SERVICE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT CHECKED THE FLUID LEVEL AND NOTICED THAT THE BRAKE FLUID WAS NEARLY DEPLETED. THE CONTACT REPLENISHED THE FLUID AND THE LIGHT DIMMED. WHEN THE BRAKE PEDAL WAS DEPRESSED, IT SANK TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE ENTIRE UNDER CARRIAGE WAS EXCESSIVELY CORRODED AND THE BRAKE LINES FRACTURED. THE MANUFACTURER AND DEALER WERE MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 36,121. UPDATED 01/20/15*LJ UPDATED 01/10/15. *JB UPDATED 02/05/15*JB UPDATED 03/10/15*LJ UPDATED 06/17/2015 *JS

Mileage: 36,121

FACTORY DEFECT, PART OF DASHBOARD MELTING/STICKY. *TR

Mileage: 28,550

WE RECEIVED SEVERAL RECALL NOTICES FOR FRAME DETERIORATION AND THE NEED FOR INSPECTION, CORRECTION AND ANTI-CORROSION CHEMICAL APPLICATION. WE TOOK IT TO THE TOYOTA DEALER AS REQUESTED. THEY CALLED THE NEXT MORNING TO HAVE US PICK UP THE VEHICLE AND THE ANTI-CORROSION SPRAY (BLACK GOOEY STUFF SIMILAR TO UNDERCOATING) THAT THEY USED WAS EVERYWHERE, INCLUDING ON THE WIRING HARNESSES, BRAKE LINES, THE STEP BARS THAT WE INSTALLED AFTERMARKET LAST YEAR, INSIDE OF THE WHEEL WELLS, THE MUD FLAPS - IT WAS STILL WET AND SMELLED AWFUL. WE CONTACTED THE SERVICE MANAGER WHO BLEW US OFF, WE CALLED TOYOTA AND THEY REFUSED TO ASSIST, OTHER THAN TO TAKE DOWN THE COMPLAINT ON PAPER. I CAN'T SEEM TO FIND AN ATTORNEY EVEN REMOTELY INTERESTED IN ASSISTING WITH THIS CASE. TOYOTA SAYS THAT THE COATING MAY NEVER DRY SO IT WILL ATTRACT ALL DIRT AND GRIME THAT IT'S EXPOSED TO. IT LOOKS AND SMELLS HORRIBLE. WE CAN'T EVEN SELL IT BECAUSE IT SMELLS SO BAD! TOYOTA WON'T REMOVE IT OR EVEN REPAIR IT, NOR WILL THEY REPLACE THE VEHICLE. *TR

Mileage: 65,000

BOUGHT THIS VEHICLE USED IN 2010 AND IT HAD A LOT OF CORROSION UNDERNEATH THEN. CURRENTLY HAS 50 K MILES. MY BRAKES ARE SQUEALING DUE TO CORROSION PREVENTING THE CALIPERS FROM MOVING AND THE WHEEL WAS CORRODED TO THE HUB AND IT TOOK A LOT OF EFFORT TO REMOVE IT. THE STRUCTURAL MEMBERS AND ALL THE COMPONENTS HAVE LOOSE LAYERS OF RUST. THE EXHAUST HEAT SHIELDS FELL OFF. THE SPARE TIRE RESTRAINT SYSTEM LOOKS TOO WEAK SO I REMOVED THE SPARE. THE SPARE WHEEL IS SO CORRODED THAT THE BOLT HOLES ARE NO LONGER SMOOTH FOR THE LUGS TO BEAR AGAINST EVENLY. I AM CONCERNED THAT SOMETHING BAD WILL HAPPEN EVENTUALLY IF A WEAKENED CRITICAL PART WERE TO FAIL. I DOUBT THE UNDERCOATING TOYOTA IS OFFERING FOR 04 TO 06 TRUCKS CAN HELP MUCH AT THIS POINT. I DON'T WANT TO BE THE GUY WHO DROPS A FUEL TANK ON THE FREEWAY. *TR

Mileage: 50,000

WAS TAKING IT TO HAVE ITS OIL CHANGED AND NOTICED A SMALL PUDDLE OF OIL UNDER THE REAR AXLE SETTING IN MY DRIVEWAY WHEN I TOOK IT BACK TO THE DEALER I ASK THEM TO CHECK THE REAR AXLE TO SEE WERE THE OIL WAS COMING FROM THEY TOLD ME THAT THE AXLE HOUSING HAD RUSTED THROUGH TOYOTA WONT COVER IT UNDER WARRANTY BECAUSE WARRANTY DOSNT COVER RUST AND IT IS GOING TO COST ME 3600.00 FOR THEM TO FIX IT . TO ME I THINK THIS IS A BUNCH OF BULL THIS TRUCK ONLY HAS 70192 MILES ON IT THERE IS NO WAY THIS SHOULD OF RUSTED OUT CAUSING A MAJOR SAFETY ISSUE IF I DIDN'T NOTICE THIS THE REAR AXLE COULD HAVE LOST ALL OF ITS OIL CAUSING A MAJOR MALFUNCTION THE AXLE COULD OF LOCKED UP BROKE THE AXLE CAUSING TO LOOSE CONTROLL CREATING A BAD ACCIDENT THEY SAY IT DOSNT COVER RUST BUT YET I GOT A RECALL NOTICE TO BRING IT IN TO HAVE THE FRAME INSPECTED FOR EXTREME RUST CORROSION. THIS DOSNT MAKE MUCH SENCE TO ME THEY WILL COVER THE RUSTY FRAME WHICH IS GREAT BUT THEY WONT COVER THE RUSTED OUT REAR AXLE THAT COULD CAUSE A CATASTROPHIC ACCIDENT AS WELL AS THE FRAME. *TR

Mileage: 70,192

JANUARY 28TH (2014) I WAS INTO YORK'S TOYOTA FOR DIAGNOSIS OF A CHECK ENGINE LIGHT AND ROUGH IDLE PROBLEM. THE CLERK AT YORK'S TOYOTA ADVISED ME OF (2) RECALLS ON MY PICKUP TRUCK (BALL JOINT & SPRAY FRAME) AND SAID "WE WILL CALL YOU TO SCHEDULE WHEN TO HAVE THESE COMPLETED AT NO COST TO YOU". FEBRUARY 6TH WHILE DRIVING SOUTHBOUND ON INTERSTATE 95 AT THE POSTED SPEED OF 75MPH IN SHERMAN MAINE THE FRONT DRIVER'S SIDE OF MY 2005 TOYOTA TUNDRA BUCKLED. AFTER PULLING TO SIDE OF THE HIGHWAY I GOT OUT OF THE TRUCK AND SAW THE FRONT DRIVER'S SIDE BALL JOINT APPEARED TO HAVE SHEERED OFF CAUSING DAMAGE TO TIE ROD END, OTHER FRONT STEERING COMPONENTS AND SOME FRONT QUARTER PANEL DAMAGE. I CALLED THE MAINE STATE POLICE WHICH COMPLETED AN ACCIDENT REPORT. YORK'S HAS REFUSED TO PAY FOR THE REPAIRS TO THE VEHICLE. MY INSURANCE REFUSES TO PAY BECAUSE THE CAUSE OF THE ACCIDENT WAS A RECALLED PART. TOYOTA CORP IN CALIFORNIA HAS REFUSED TO PAY FOR ALL THE REPAIRS TO MY VEHICLE STATING THE BALL JOINT RECALL WAS FOR PREMATURE WEAR AND SINCE MY TRUCK HAS 150,000MILES IT DOESN'T QUALIFY. THIS IS COMPLETELY UNACCEPTABLE. A RECALL WAS ISSUED AND TOYOTA IS REFUSING TO FIX THE RECALLS AND THE DAMAGES. *TR

Mileage: 150,000

I HAVE BEEN TOLD MY TRUCK HAS EXCESSIVE RUST ON THE BRAKE LINE, FRONT BRAKE ROTORS AND POWER STEERING UNIT. THEY WILL AL NEED TO BE REPLACED. *TR

Mileage: 112,000

THE FRAME ON MY 2005 TOYOTA TUNDRA IS RUSTED TO THE POINT OF FAILURE. FRAME RECALL SHOULD INCLUDE ALL TOYOTA TUNDRAS. ADDITIONAL COMPONENTS HAVE RUSTED INCLUDING LINKAGE ARMS. BODY LOOKS GREAT. TOYOTA HAS NO COMMENT. *TR

Mileage: 140,000

BROUGHT TOYOTA TUNDRA 2005 TO DEALERSHIP TO INSPECT FRAME FOR RUST. RUST HOLE IN FRAME UNDER DRIVER SIDE, AND ALONG SEAM OF FRAME. DEALER DECLARED VEHICLE UNSAFE TO DRIVE, AND TOOK PICTURES OF FRAME. INSTRUCTED TO CALL TOYOTA AND CREATED CASE. BUT TOYOTA SAID VEHICLE WAS OUT OF WARRANTY AND THEY WOULD DO NOTHING. *TR

Mileage: 60,000

DUE TO EXCESSIVE HEAT FROM BULBS OR MATERIAL TOO CLOSE TO HEAT SOURCE, HOLES WERE BURNED INTO A LENS CASING LOCATED ABOVE SLIDING GLASS WINDOW TO REAR OF DRIVER. *TR

Mileage: 50,000

2005 TOYOTA TUNDRA. S10 APPROPRIATE HANDLING- LETTER TO THE SECRETARY FROM REGARDING TOYOTA PROBLEMS *TGW THE CONSUMER STATED THE OIL PAN WAS CRACKED ON THE SIDE, THE RACK AND PINION ASSEMBLY AND FAN HAD TO BE REPLACED. THE DRIVERS SIDE DOOR WAS LOOSE, THE SPRING WAS STICKING OUT OF THE SEAT COVER. THE CONSUMER HAS SINCE SOLD THE VEHICLE. *JB

I NOTICED AROUND AUGUST 2006 ONE RUST SPOT ON THE BODY OF MY 2005 TUNDRA, THESE GREW TO ABOUT 12 SPOTS BY 2007 AND NOW I HAVE ABOUT 15 SMALL RUST SPOTS, THE LARGEST ABOUT THE SIZE OF A QUARTER. THEY START OUT BUBBLING UP THE PAINT UNTIL THE PAINT CORRODES AND FALLS OFF AND THE PROBLEM GETS BIGGER. AFTER SEVERAL ATTEMPTS TO GET TOYOTA TO CORRECT THIS (FROM OCTOBER 2007 UNTIL NOW JUNE 2008) I AM ATTEMPTING TO WARN ALL BUYERS TO BEWARE OF THE POSSIBLE PROBLEM, AND BE AWARE OF THE PROMISES YOU GET FROM THE VAN TROW TOYOTA DEALERS FROM MONROE, LA. I WAS ASKED TO GIVE THEM A COUPLE OF MONTHS TO "GET TO IT, THEY WERE TOO BUSY", THEN I WAS TOLD THAT MOTHER NATURE HAS DONE THIS,,, IN GENERAL, GETTING THE RUN-AROUND. THIS TRUCK WAS PARKED IN MY CARPORT, WASHED EVERY TWO WEEKS, AND STILL SMELLS AND LOOKS NEW ON THE INSIDE. I ONLY HAVE 23,000 ON THIS TRUCK, IT WAS BOUGHT JUNE 30, 2005. YES, THEY ARE GETTING THE WARRANTY TO RUN OUT. CAN SOMEONE ADVISE ME WHO TO COMPLAIN TO BESIDES NHTSA? THANKS *TR