2001 VOLKSWAGEN BEETLE Exterior Lighting Problems

LEFT TURN INDICATOR RAPID BLINKS EVEN WITH ALL NEW BULBS

THE BRAKE LIGHTS ARE INOPERATIVE, REMAIN OFF. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. PREVIOUS RECALL 06V183000: BRAKE LIGHT SWITCH DEFECT MAKE/MODELS: MODEL/BUILD YEARS:VOLKSWAGEN/JETTA 1999-2002VOLKSWAGEN/NEW BEETLE 1998-2002MANUFACTURER: VOLKSWAGEN OF AMERICA, INC.NHTSA CAMPAIGN ID NUMBER: 06V183000 MFG'S REPORT DATE: MAY 24, 2006COMPONENT: EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH. VW IS NOT INTERESTED TO INVESTIGATE THE PROBLEM SAYING THAT HAVE COMPLETED THE RECALL AND THIS IS MY PROBLEM NOT THEIRS EVEN THOUGH BRAKE LIGHT PROBLEM IS BACK. *TR

THE HAZARD LIGHTS, TURN SIGNALS AND HEADLIGHTS ON MY CAR DO NOT WORK. I'VE TAKEN IT IN TO AN AUTO SHOP AND THEY CANNOT FIND OUT WHAT IS WRONG WITH THE CAR. HOPING MAYBE THERE IS A RECALL THAT I HAVE MISSED. *TR

THROTTLE BODY GOES OUT (02-03-2009) CV AXEL GOES OUT (03-31-2009 BRAKE LIGHTS GO OUT (02-18-2010) CV AXEL GOES OUT AGAIN (4-31-2010) ALTERNATOR GOES OUT (06-21-2010) IGNITION COILS FAIL (09-13-2010) IGNITION COILS FAIL AGAIN(01-21-2011) BRAKE SWITCH REPLACED AGAIN (01-21-2011) AIR FLOW SENSOR FAILS (01-21-2011) AIR FLOW SENSOR FAILS AGAIN (07-26-2011) TIMING BELT REPLACED (06-15-2011) THERMOSTAT REPLACED (06-15-2011) WATER PUMP REPLACED (06-15-2011) NOW HAVING PROBLEMS WITH THROTTLE BODY/ THROTTLE BODY SENSOR/ ELECTRICAL ISSUE. DEALER IS NOT SURE WHAT THE PROBLEMS IS AND WANTS TO THROW MONEY AT IT TO SEE WHAT THE PROBLEMS IS. THIS CAR IS JUST ONE PROBLEM AFTER ANOTHER AFTER ANOTHER.

Mileage: 69,890

THROTTLE BODY GOES OUT (02-03-2009) CV AXEL GOES OUT (03-31-2009 BRAKE LIGHTS GO OUT (02-18-2010) CV AXEL GOES OUT AGAIN (4-31-2010) ALTERNATOR GOES OUT (06-21-2010) IGNITION COILS FAIL (09-13-2010) IGNITION COILS FAIL AGAIN(01-21-2011) BRAKE SWITCH REPLACED AGAIN (01-21-2011) AIR FLOW SENSOR FAILS (01-21-2011) AIR FLOW SENSOR FAILS AGAIN (07-26-2011) TIMING BELT REPLACED (06-15-2011) THERMOSTAT REPLACED (06-15-2011) WATER PUMP REPLACED (06-15-2011) NOW HAVING PROBLEMS WITH THROTTLE BODY/ THROTTLE BODY SENSOR/ ELECTRICAL ISSUE. DEALER IS NOT SURE WHAT THE PROBLEMS IS AND WANTS TO THROW MONEY AT IT TO SEE WHAT THE PROBLEMS IS. THIS CAR IS JUST ONE PROBLEM AFTER ANOTHER AFTER ANOTHER.

Mileage: 69,890

THE HEADLAMPS HAVE BEEN REPLACED FOUR TIMES. ACCORDING TO A VW DEALERSHIP WHO SERVICED THE VEHICLE, I WAS INFORMED THAT THE VEHICLE'S WIRING HARNESS IS DEFECTIVE, CAUSING THE HEADLIGHTS AND INSTRUMENTATION CLUSTER TO FAIL. THE DEALERSHIP INFORMED ME THAT THEY ARE AWARE OF THE WIREING HARNESS PROBLEM, BUT ARE NOT AWARE OF ANY SERVICE RECALLS.

Mileage: 64,300

TL*THE CONTACT OWNS A 2001 VOLKSWAGEN NEW BEETLE. THE CONTACT STATED THAT WHENEVER HE DROVE 35 MPH OR MORE AT NIGHT THE HEADLIGHTS FAILED. THEY ARE NOT ADJUSTABLE; YET, THE ONE ON THE DRIVERS SIDE WAS AIMED LOWER AND THE PASSENGER SIDE WAS AIMED HIGHER. THE VEHICLE WAS TAKEN TO THE DEALER PREVIOUSLY WHO ADJUSTED THE HEADLIGHTS BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 168,000.

Mileage: 168,000

I HAVE A 2001 VW NEW BEETLE. I HAVE REPLACED BRAKE LIGHT, WHICH WAS DRAINS THE BATTERY, SERPENTINE BELT, REMOTELESS KEY WHICH IS STILL BROKEN- BASICALLY 6 DAYS AFTER BUYING THIS CAR- I SPENT $1200 ON REPAIRS- NOW THE CHECK ENGINE LIGHT IS ON, THE TRANSMISSION IS ACTING FUNNY, AND BASICALLY- MY VW DEALERSHIP HAS A FIELD DAY WITH ME. TO TOP IT OFF- MY BATTERY DIED A MONTH AGO- AND CAUGHT ON FIRE WHEN I TRIED TO JUMP IT. I AM AFRAID THAT THIS CAR WILL BLOW UP ON ME AT ANY TIME. PLEASE HELP ME! *TR

Mileage: 75,000

2001 VOLKSWAGEN BEETLE DEFECTIVE TURN SIGNAL /HAZARD WARNING SWITCH RELAY. CUSTOMER STATES THAT HIS TURN SIGNAL SWITCH IS DEFECTIVE. HE ALSO STATES HE WOULD LIKE TO KNOW WHERE TO SEND THE DEFECTIVE SWITCH TO FOR ENGINEERING ANALYSIS. *KB THE CONSUMER STATED HE EXPERIENCED THE SAME PROBLEM ON HIS VEHICLE THAT HAS BEEN SUBJECTED TO A RECALL, HOWEVER THE RECALL PERTAINS TO OTHER 2001 VOLKSWAGENS. *JB

2001 VOLKSWAGEN BEETLE WITH TURN SIGNAL PROBLEMS CUSTOMER STATES THAT THE HAZARD WARNING SWITCH RENDERED THE TURN SIGNALS INOPERATIVE OR INTERMITTENT**CC THE CONSUMER BELIEVED HIS VEHICLE SHOULD HAVE BEEN A PART OF THE RECALL THAT WAS ISSUED. THE CONSUMER WAS TOLD THE CAUSE OF THE FAILURE WAS DUE TO HIGH CURRENT LOADS FROM THE BULBS USED THAT WERE OVERHEATING THE RELAY. *JB

I HAVE TWO VOLKSWAGEN BEETLES THAT HAVE BEEN RECALLED FOR A BRAKE LIGHT SWITCH. LAST YEAR BEFORE WE WERE AWARE OF THIS RECALL, THE CAR LEFT ME ABANDONED AT THE HOSPITAL EMERGENCY ROOM PARKING LOT. I WAITED FOR HALF AN HOUR AND THEN IT WENT OFF AND I WAS ABLE TO PUT THE CAR IN REVERSE TO GET HOME. THE PROBLEM CORRECTED ITSELF AND YESTERDAY WHEN I GOT OUT OF WORK IT DID THE SAME BUT I WAS ABLE TO DRIVE IT HOME AFTER. NOW THE CAR WILL NOT EVEN ALLOW ME TO PUT THE GEAR IN REVERSE TO GET IT TO THE DEALER FOR THIS RECALL AND VOLKSWAGEN, EMPLOYEE BY THE NAME OF AMY AT 1-800-822-8987, SAYS I NEED TO HAVE IT TOWED AT MY EXPENSE IN ORDER FOR IT TO BE FIXED. THEY REFUSE TO PAY FOR THE CAR TO BE TOWED TO GET FIXED. VOLKSWAGEN ROADSIDE ASSISTANCE IS REFUSING TO TOW IT TO GET IT FIXED. *TR

Mileage: 188,000

TURN SIGNALS OPERATE INTERMITTENTLY OR CEASE WORKING AFTER A FEW FLASHES. THE IMMEDIATE FAILURE MODE"VIOLATES THE FMVSS, AND SUBJECTS THE DRIVER TO CITATIONS FOR FAILING TO PROPERLY SIGNAL A TURN AND/OR DEFECTIVE EQUIPMENT. SAFETY HAZARD FOR SURROUNDING TRAFFIC PUTTING VEHICLE AT GREATER RISK. *AK

Mileage: 64,500

TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH. FIRST IT WOULD BLINK ONLY A FEW TIMES AND THEN STOP, AFTER 2 MORE DAY IS NOT WORKING AT ALL. THIS CASE IS SIMILAR TO RECALL #04V584000, BUT THE CAR TYPE IS VW NEW BEETLE 2001. *JB

Mileage: 55,000

2001 VW BEETLE - GASKET FOR HEADLIGHTS AND HEADLIGHT LENSES DETERIORATED. HAD TO HAVE REPLACED. *JB

THE TURN SIGNALS AND HAZARD SOME TIMES WORK , OR THEY JUST STOP WORKING FOR DAYS AT A TIME AM GOING TO TAKE CAR IN TO DEALER TO FIND OUT WHAT THE PROBLEM IS AND HAVE IT FIXED. NOW THEY HAVE FAILED ALL TOGETHER AND AM AFRAID I AM GOING TO GET IN TO A ACCIDENT IF I DON'T GET THEM FIXED. THIS HAS BEEN GOING ON FOR A YEAR. *NM

Mileage: 51,810

EMERGENCY LIGHT SWITCH (HAZARD SWITCH) THERE WAS A VW RECALL ISSUED TO REPLACE THIS SWITCH THAT NOT ONLY CONTROLS THE HAZARD FLASHERS BUT ALSO THE TURN SIGNALS, IN THE JETTA, GOLF, & GTI. MY BEETLE USES THE SAME SWITCH I AM WONDERING WHY IT WAS NOT INCLUDED IN THIS RECALL (VW RECALL VX). MY SWITCH HAS THE SAME INTERMITTENT PROBLEM AS DESCRIBED IN THE MARCH 2005 RECALL LETTER, I WILL BE REPLACING THE SWITCH ON MY OWN ACCORD, BUT THIS BULLETIN SHOULD INCLUDE THE VW NEW BEETLE MODEL IN MY OPINION. *NM

Mileage: 119,750

EMERGENCY LIGHT SWITCH (HAZARD SWITCH) THERE WAS A VW RECALL ISSUED TO REPLACE THIS SWITCH THAT NOT ONLY CONTROLS THE HAZARD FLASHERS BUT ALSO THE TURN SIGNALS, IN THE JETTA, GOLF, & GTI. MY BEETLE USES THE SAME SWITCH I AM WONDERING WHY IT WAS NOT INCLUDED IN THIS RECALL (VW RECALL VX). MY SWITCH HAS THE SAME INTERMITTENT PROBLEM AS DESCRIBED IN THE MARCH 2005 RECALL LETTER, I WILL BE REPLACING THE SWITCH ON MY OWN ACCORD, BUT THIS BULLETIN SHOULD INCLUDE THE VW NEW BEETLE MODEL IN MY OPINION. *NM

Mileage: 119,750

DT*: THE CONTACT STATED THE SERVICE BRAKE LIGHT SWITCH WAS NOT WORKING AND EXPRESSED THAT THE DEALER DID NOT CONSIDER THIS A SAFETY ISSUE. UPDATED 08/25/06. *JB

Mileage: 46,909

MY 2001 VW BEETLE TURBO WILL NOT COME OUT OF PARK. IT IS STUCK THERE. I WAS PARKED ON A DOWNWARD SLOPE WITHOUT THE PARKING BRAKE ON. I T WAS 95 DEGREES F. I CALLED VW AND THEY TOLD ME TO DO THE FOLLOWING. * 1. I HAVE TO TURN IT OFF * 2. PUMP THE BRAKE 5 TIMES AND HOLD IT FOR THE 5TH TIME ALL THE WAY DOWN * 3. TURN THE CAR ON COMPLETELY * 4. WAIT 5 SECONDS * 5. THEN TURN IT OFF * 6. TURN IT 1/4 TURN (NO LIGHTS ON THE DASHBOARD OF THE CAR) * 7. THEN I CAN TURN THE SHIFT IN BETWEEN NEUTRAL AND DRIVE * 8. THEN TURN THE CAR COMPLETELY ON TO TURN IT COMPLETELY ON TO SHIFT IT INTO DRIVE. *JB

Mileage: 76,000

DT*: THE CONTACT STATED THE BRAKE LIGHT SWITCH MALFUNCTIONS CAUSING THE BRAKE LAMPS TO BECOME INOPERATIVE. AS A RESULT, THE VEHICLE GETS STUCK IN THE PARK POSITION. AN NHTSA RECALL, # 03V265000 WAS PERFORMED ON THE VEHICLE CONCERNING, THE EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH HOWEVER; THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WOULD NOT OFFER A SECOND REPAIR WITHOUT CHARGE UNDER THE RECALL.

Mileage: 62,000

DT*: THE CONTACT STATED THAT THE VEHICLE WOULD NOT SHIFT OUT OF PARK INTERMITTENTLY. THERE IS RECALL, #03V265000, CONCERNING THE BRAKE LIGHT SWITCH. THE RECALL DID NOT CORRECT THE PROBLEM. THE VEHICLE IS HAVING THE SAME PROBLEMS AGAIN. THE DEALERSHIP HAS BEEN CONTACTED. FOUR BRAKE SWITCHES HAVE BEEN REPLACED. THE CONTACT HAD TO PAY FOR ALL OF THEM. VEHICLE HAS BEEN A PROBLEM SINCE DAY ONE. THE CONTACT PURCHASED EXTENDED WARRANTY, BUT IT DID NOT HELP. IT COST THE CONTACT OVER $3,000 IN REPAIRS. UPDATED ON 05/16/2006. *AK *NM

Mileage: 56,920

THESE ARE SECONDARY SAFETY ISSUES: 1) GAS GAUGE REQUIRES $700 INSTRUMENT CLUSTER 2) HEADLIGHTS SHIPPED FROM FACTORY MISSING RETAINER BAND AND REQUIRE $650 FIX JUST TO ALIGN. VW SAN JOSE, CA INVOICE [XXX] ON 2001 VW BEETLE LEMON [XXX]. *NM UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mileage: 62,738

AT THE END OF MY WORKDAY MY CAR WOULD NOT COME OUT OF PARK. I CALLED MY MECHANIC AND HE SAID IT WAS PROBABLY AN ELECTRICAL PROBLEM THAT HE WOULD RATHER SOMEONE WITH MORE VW EXPERIENCE LOOK AT IT. WHEN I CALLED THE VW DEALER THE SERVICE PERSON SAID IT WAS PROBABLY THE BREAK LIGHT SWITCH AND THAT THERE WERE RECALLS THAT IT MAY BE COVERED UNDER. THE CAR WAS TOWED TO THE DEALER AND THE NEXT DAY THE FAULTY BRAKE LIGHT SWITCH WAS REPAIRED. HOWEVER, AFTER SEARCHING MY VIN# THE DEALER SAID MY CAR WAS NOT ON ANY RECALL. AFTER SEARCHING THE NHTSA WEBSITE, I FOUND A RECALL FOR MY MAKE/MODEL/YEAR VEHICLE PERTAINING TO THE BRAKE LIGHT SWITCH. *JB

Mileage: 31,189

TURN SIGNAL/HAZARD FLASHER ON 2001 VOLKSWAGEN NEW BEETLE FAILED IN SAME WAY AS DESCRIBED IN YOUR RECALL #04V584000-WHICH APPLIES TO OTHER MODELS BUT NOT NEW BEETLE. OCCURRENCE DATE: 12 JANUARY 2006, MILEAGE 64,200 APPROX. THIS IS SAME BEHAVIOR ALREADY IDENTIFIED BY YOU. I REQUEST THAT INVESTIGATION BE OPENED TO BROADEN THE RECALL TO THIS MODEL. I AM TRYING TO FIND REPLACEMENT PART. *JB

Mileage: 64,260

DT*: THE CONTACT STATED WHEN THE VEHICLE WAS PUT INTO PARK THE BRAKE LAMP SWITCH MALFUNCTIONED. THE LAMPS ILLUMINATED, EVEN THOUGH THE VEHICLE WAS PARKED. THE VEHICLE WAS TAKEN TO A CERTIFIED DEALER FOR A REPLACEMENT OF THE BRAKE LIGHT SWITCH. *AK

Mileage: 29,352

DT: HAVING THE SAME PROBLEM FOR THE RECALL. EPC LIGHT CAME ON AND OFF, CAME ON AGAIN. CURRENTLY, THE BRAKE LIGHTS WERE OFF. TRIED TURNING OFF THE VEHICLE, JUST TURNING THE KEY HAVE WAY , BUT THEY STILL WILL NOT COME ON. IT CAME ON ONCE BEFORE ABOUT 4 OR 5 MONTHS, BUT IT WENT BACK OFF. CONTACTED DEALER ,THEY HAD CHECKED WITH THE MANUFACTURER. THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN.*AK

Mileage: 65,000

2001 VW BEETLE WOULD NOT COME OUT OF PARK. RESEARCED ON LINE TO FIND THERE WAS A RECALL CONCERNING BRAKE LIGHT SWITCHS IN 2001 BEETLE. TOOK CAR TO BUTLER VW TO HAVE FIXED AND WAS CHARGED FOR REPAIR KNOWING THEY HAVE A HISTORY WITH THESE SWITCHS BEING DEFFECTIVE. DEALER WOULD NOT PAY BASED ON VEHICLE NOT FALLING INTO VIN'S THAT WERE RECALLED.

PURCHED A USED 2001 VOLKSWAGEN BEETLE FOR MY DAUGHTERS 16TH BIRTHDAY. THIS CAR HAS BEEN NOTHING BUT TROUBLE. CHECK ENGINE LIGHT CAME ON FIRST. AFTER 3 TRIPS TO THE DEALER( WHICH IS 50 MILES AWAY) THAT WAS FINALLY FIXED. THEN IS WOULDN'T COME OUT OF PARK. SO WE HAD IT TOWED TO THE DEALER AND THEY PUT IN A NEW BRAKE LIGHT SWITCH. WELL NOW IT IS STUCK IN PARK AGAIN AND WE'RE GOING TO HAVE TO PAY FOR TOWING AGAIN TO HAV THE SAME PART REPLACED AGAIN. THE TOW BILL ALONE IS WELL OVER 100.00. I CALLED VW AND THEY TELL ME THAT MY CAR IS NOT PART OF THE RECALLL THAT IS NOW IN EFFECT FOR THE BRAKE LIGHT SWITCH. THIS CAR IS COSTING ME A FORTUNE AND SHE HAS HAD IT ONLY 1 YEAR AND IT HAS ONLY 48,000 MILES. THIS CAR HAS BEEN IN THE SHOP MORE TIMES THEN OUT. I WILL NEVER BUY ANOTHER VW. THEY ARE TOTALLY JUNK.

MULTIPLE REQUESTS TO HAVE OUR 2001 NEW BEETLE TDI HEADLIGHTS ADJUSTED PROPERLY HAVE NOT BEEN COMPLIED WITH BY GURLEY-LEEP VW SERVICE DEPARTMENT, SINCE THE FIRST YEAR OF OWNERSHIP, 2001 WHEN THE CAR WAS NEW.*AK SPECIFICALLY: LOW BEAM HEADLIGHTS ARE SET FAR, FAR TOO LOW; I ESTIMATE THE HEADLIGHTS ILLUMINATE ABOUT 60 FEET IN FRONT OF THE VEHICLE, LIMITING TRAVEL AT NIGHT TO ~35 MPH; THIS IS OBVIOUSLY A SAFETY HAZARD FOR TWO REASONS: 1) WE CAN'T SEE HAZARDS SOON ENOUGH, AND 2) OUR LOWER SPEEDS PRESENT A HAZARD TO OTHER VEHICLES TRAVELING AT HIGHER (NORMAL) SPEEDS. WHEN I ASK WHY THE HEADLIGHTS ARE SET TOO LOW, I'M TOLD BY SERVICE DEPARTMENT PERSONNEL THAT "THEY'RE SET TO SPEC". LATEST, 12/14/04: SERVICE DEPARTMENT AGAIN TOLD US THEY SET THE HEADLIGHTS "TO SPEC", BUT THE RIGHT LIGHT ASSEMBLY DOESN'T STAY IN ADJUSTMENT, I.E., IT "DROPS", AND WE NEED TO BUY A NEW ASSEMBLY AT ABOUT $330.00. THIS IS A STRANGE SITUATION BECAUSE THE LEFT HEADLIGHT ILLUMINATES THE ROAD AT THE SAME DISTANCE AS THE RIGHT HEADLIGHT, AND THE GURLEY LEEP SERVICE DEPARTMENT PEOPLE DID NOT TELL US THERE WAS A PROBLEM WITH THE LEFT. BOTTOM LINE: THIS IS APPARENTLY EITHER A MANUFACTURING DEFECT OR A POORLY MANAGED MAINTENANCE DEPARTMENT; EITHER WAY IT IS A SAFETY HAZARD AND MUST BE CORRECTED BY VW AT NO CHARGE.

REIMBURSEMENT REQUEST FOR REPLACEMENT OF BRAKE LIGHT SWITCH.*MR (NAR) *CB THE CONSUMER STATED THE BRAKE LIGHT SWITCH WAS RECALLED. *JB

Mileage: 30,468

ON 7 DIFFERENT OCCASIONS WE HAVE HAD A FAULTY BRAKE LIKE SWITCH REPLACED ON A 2001 VW BEETLE THAT WE BOUGHT NEW. WHEN THIS PROBLEMS OCCURS, THE CAR WILL NOT MOVE FROM PARK TO REVERSE OR DRIVE. I AM CONCERNED ABOUT MY DAUGHTER'S SAFETY. THIS PROBLEM STARTED IN OCT. 2001 AND IS CONTINUING TO OCCUR REPEATEDLY. WHAT CAN I DO AS A CONSUMER? MY DAUGHTER WILL BE MOVING 120 MILES AWAY IN ONE MONTH TO ATTEND THE UNIVERSITY OF ALABAMA AND I WILL NOT BE ABLE TO PICK HER UP AND HAVE HER CAR TOWED WHEN THIS PROBLEM OCCURS AGAIN. PLEASE HELP!!!!!*AK

Mileage: 2,052

THE VEHICLES DAYTIME RUNNING LIGHTS/HEADLIGHT HAVE ONE SWITCH WHICH CONTINUOUSLY BURNED OUT AND RESULTED IN NO HEAD LIGHTS. *NLM