2004 VOLKSWAGEN BEETLE Electrical System Problems

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE BATTERY AND ABS INDICATORS ILLUMINATED AND THE VEHICLE DOWNSHIFTED INTO FIRST GEAR. THE VEHICLE SEIZED AND WAS MOVED TO THE SIDE OF THE ROAD. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIRE HARNESS FAILED AND NEEDED TO BE REPLACED. THE FUSE BOX WAS REPLACED THREE TIMES, BUT THE FAILURE RECURRED. LEITH VOLKSWAGEN OF CARY (2300 AUTOPARK BLVD, CARY, NC 27511, (919) 842-5624) AND THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.

Mileage: 157,000

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING AT A SLOW RATE OF SPEED, THE CONTACT SMELLED BURNING RUBBER AND THE VEHICLE'S RADIO STOPPED WORKING. AS THE CONTACT PROCEEDED DRIVING, SEVERAL UNKNOWN WARNING INDICATORS BEGAN FLASHING. THE CONTACT STATED THAT THE VEHICLE SHUT COMPLETELY OFF. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC. THE MECHANIC WAS ABLE TO DIAGNOSE THE VEHICLE AND HAD THE FUSE BOX REPLACED, YET THE FAILURE STILL PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

Mileage: 50,000

THE FUSE BOX IS BURNING BECAUSE SOME CABLES ARE TOO SMALL AND ACCORDING TO THE MECHANICS, IT IS SOMETHING EXTREMELY COMMON BUT ACCORDING TO ME, IT IS NOT SUPPOSED TO HAPPEN.

Mileage: 350

CONTINUED HEADLAMP FAILURE RE: HEADLAMP COVER GLASS / LEXAN COMES OFF AND FLYS OFF OF CAR. SEVERAL OWNERS REPORT SAME PROBLEM. CREATES HAZERDOUS DEBRIS WHEN IT HAPPENS ON HIGHWAY AND ALSO EXPOSES HEADLAMP LIGHTS DIRECTLY TO WEATHER AND CAUSES FAILURE.

Mileage: 164,500

VW CHECK ENGINE LIGHT ON, OBD SENSOR PORT NOT READING, BATTERY LIGHT CAME ON, AND ABS LIGHT CAME ON, NOW RADIO IS GOING ON AND OFF. STARTED YESTERDAY MORNING,WHILE DRIVING TO WORK THE ABS STARTED AFTER WORK ON THE WAY HOME.

Mileage: 5

THE FIRST TIME I ROLLED WINDOWS DOWN IN MY DRIVEWAY SO THAT I COULD TAKE TOP DOWN. THEY WOULD NOT ROLL UP PROPERLY TO MAKE A CONNECTION TO THE TOP CONVERTIBLE OF THE CAR. SO THE CAR WAS NOT WEATHER SAFE.

Mileage: 15

POWER PASSENGER SIDE REAR WINDOW. STOPPED 3/4 OF WAY UP, HEARD A "CRACK". ROLLED DOWN AND NO LONGER WORKS.

Mileage: 64,000

JUST PURCHASED THIS VEHICLE IN NOVEMBER 2015, FEBRUARY 29, 2016 THE VEHICLE WOULDN'T START, HAD MY SONS JUMP IT AND DROVE IT TO WORK, AFTER TURNING VEHICLE OFF TRIED TO START AGAIN RIGHT AWAY, VEHICLE DEAD. MADE AN APPOINTMENT MARCH 4, 2016 WITH VOLKSWAGEN DEALERSHIP, THEY STATED THAT THE ISSUE IS A BURNT ALTERNATOR CABLE AND MELTED FUSE BOX. AFTER READING NUMEROUS ACCOUNTS ONLINE, IT SEEMS THAT IS GOES OUT BETWEEN 70,000 - 80,000 MILES, MY VEHICLE HAD 79,000 MILES WHEN IT HAPPENED. VOLKSWAGEN ISN'T DOING ANYTHING ABOUT IT EVEN THOUGH IT IS A COMMON COMPLAINT I'VE SEEN...WANTING VOLKSWAGEN TO PAY FOR REPAIR...VERY FRUSTRATED, DON'T THINK I WOULD OWN ANOTHER VOLKSWAGEN AGAIN!...IF THIS IS THE WAY THEY TREAT CUSTOMERS. THERE WASN'T A FIRE, BUT IT COULD'VE HAPPENED, ISN'T VOLKSWAGEN CONCERNED ABOUT INDIVIDUALS SAFETY, THINK THEY SHOULD RESOLVE THE ISSUE BY PROVIDING A DIFFERENT SOLUTION TO HOW THE VEHICLE IS DESIGNED PERTAINING TO THE FUSE BOX, ETC.

Mileage: 79,000

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE ALTERNATOR CABLE MELTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

FOR THE PAST 3-4 YEARS MY BEETLE HAS HAD WORSENING ELECTRICAL ISSUES. SOMETIMES IT JUST TURNS OFF ALL BY ITSELF. EVERYTHING ELECTRICAL GOES OUT. IT HAS EVEN HAPPENED WHILE DRIVING, I WAS IN TRAFFIC AND IT SHUT OFF. I WAS NEARLY KILLED.

Mileage: 75,000

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE CONVERTIBLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE JERKED AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED BUT THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER; HOWEVER, THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

Mileage: 73,000

IT STARTED WITH THE BATTERY LIGHT COMING ON. I MADE IT HOME. I TURNED OFF THE CAR AND WHEN I TRIED TO RESTART, DEAD. I FIRST ASSUMED THE BATTERY NEEDED TO RECHARGE AND DID THAT. IT WOULDN'T HOLD A CHARGE. WHEN I LOOKED AT THE FUSE BLOCK ON TOP THE BATTERY, IT WAS MELTED! ALONG WITH THE WIRE GOING TO THE ALTERNATOR. THIS SEEMS TO BE A VERY COMMON COMPLAINT WITH THESE VEHICLES.

Mileage: 80,000

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THE BATTERY FUSE BOX WAS HEATED AND POTENTIALLY NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,300.

Mileage: 83,300

ATTEMPTED TO START VEHICLE. VEHICLE ACTED AS IF THE BATTERY WAS DEAD. OPENED HOOD AND FOUND A PARTIALLY MELTED FUSE BOX FUSES, BURN MARKS AND MELTED WIRES. *TR

Mileage: 76,000

THE BACK PASSENGER WINDOW MOTOR WAS REPLACED. TODAY 12/09/14 NOT THE FRONT PASSENGER WINDOW MOTOR NEEDS REPLACED. I THINK THIS IS FAULTY. THIS IS A COMMON OCCURRENCE ACCORDING TO THE LOCAL VW REPAIR DEALERSHIP. *TR

MY 16 YEAR OLD DAUGHTER DRIVES THIS CAR. INITIALLY THE HEADLIGHT WAS BURNT OUT. ORDERED A NEW HEADLIGHT AND INSTALLED IT AND IT WORKED FINE FOR ABOUT AN HOUR. THEN MY DAUGHTER DROVE THE CAR APPROXIMATELY 10 MILES. WHEN SHE ARRIVED AT HER DESTINATION SHE ATTEMPTED TO TURN THE CAR OFF BUT THE KEY WOULD NOT COME OUT OF THE IGNITION. WHEN I ARRIVED I COULD SMELL SOMETHING BURNING AND THE CAR BATTERY WAS NOW DEAD. I HAD THE BATTERY JUMPED BUT NOW THE HEADLIGHT THAT I JUST REPLACED WAS NOT WORKING AGAIN, AND NOW THE BRAKE LIGHTS AND THE RUNNING LIGHTS WERE NOT WORKING. THE NEXT MORNING THE BATTERY WAS DEAD AGAIN. WHEN WE FINALLY GOT OVER TO THE MECHANIC THE WIRING WAS COMPLETELY MELTED AND THE HEADLAMP MODULATOR WAS BLOWN. THE WINDOW WASHER FLUID RESERVOIR WAS MELTED AND RUINED. AFTER ABOUT $1000 IN REPAIRS THE MECHANIC IS EXPLAINING THIS IS JUST THE ONE SIDE, THE WIRING FOR THE OTHER SIDE IS GOING TO NEED TO BE REPLACED IN NEXT 6 MONTHS OR SO. HE EXPLAINED THIS IS A COMMON OCCCURANCE WITH THESE CARS. I AM HONESTLY AFRAID TO ALLOW MY DAUGHTER TO DRIVE THE CAR AS IT SEEMS IT IS A FIRE HAZARD. *JS

Mileage: 102,000

MY ENGINE LIGHT CAME ON AND THE AC STOPPED BLOWING COLD AIR. I ALSO NOTICED A BEEP SOUND THAT WOULD COME ON WHEN I TURNED THE HEADLIGHTS ON BUT THE SOUND WOULD TURN OFF AND ON WHILE I DROVE. THEN THE ALARM STOPPED WORKING AND THE INTERIOR LIGHTS MALFUNCTIONED, THE RADIO ALSO GAVE OUT AND THE VEHICLE SEEMED TO HESITATE WHILE DRIVING IT. I CHECKED THE FUSE BOX ON THE BATTERY AND DISCOVERED THAT THE SLOT WHERE THE FUSE SLIPS INTO ON TOP OF THE VEHICLE BATTERY WAS MELTED AND THERE WAS SOMETHING ON THE DRIVER SIDE HEADLAMP COVER LIKE SOME TYPE OF GAS OR FUMES HAD ESCAPED THE BATTERY AND SPRAYED THE HEADLAMPCOVER. I CHANGED THE FUSES AROUND AND GOT THE AC GOING AGAIN, THEN I CHANGED THEM ALL OUT, AND EVERYTHING WORKED GREAT FOR ABOUT 5 DAYS, THEN THE INTERIOR LIGHTS WENT OUT AGAIN, THE ALARM STOPPED WORKING, RADIO IS OUT, THE BEEPING SOUND IS BACK AND WHEN I CHECKED THE FUSE, IT WAS MELTING AGAIN. I AM AFRAID THAT WHILE IN THE VEHICLE WITH MY CHILDREN I WILL HAVE A MALFUNCTION AND BE INJURED. I JUST PAID OFF THE VEHICLE... WHAT A GIFT FOR PAYING OFF A VEHICLE... SEEMS LIKE EVERYTHING IN AND ON THAT VEHICLE IS A HAZARD AND AN ACCIDENT WAITING TO HAPPEN.. ITS SAD BECAUSE I USE TO LOVE MY NEW BEETLE. *TR

Mileage: 95,400

THE BATTERY TO ALTERNATOR WIRE ON THESE CARS OVERHEATS AND CATCHES FIRE. I OWN A CAR DEALERSHIP AND JUST HAD IT HAPPEN TO ME. I WAS LUCKY AND STOPPED ANYTHING HORRIBLE FROM HAPPENING BUT MOST PEOPLE WOULD NOT KNOW ENOUGH TO STOP IT OR THAT IT WAS HAPPENING. THESE CARS ARE A HUGE FIRE HAZARD AND YOU NEED TO ISSUE A RECALL. CHECK THE PICTURES OF BURNED CARS ON GOOGLE. YOU WONT FIND ONE COMPLAINT BUT MANY AND PLENTY OF BURNED CARS. SO I ASK THAT YOU DO YOUR BEST TO FIX THIS ISSUE. THE CAR I OWN HAS A HISTORY OF THE ALTERNATOR BEING SERVICED. OBVIOUSLY A RECALL ISSUE THAT MAYBE VW SHOULD FIGURE OUT HOW TO FIX INSTEAD A BAND AID AND OUT THE DOOR. CHECK CAR FAX ON THIS CAR. IF SOMEONE LET THERE CAR WARM THEY COULD BURN DOWN THERE HOUSE. I AM GOING TO REROUTE THIS WIRE AND REPLACE IT WITH A BETTER GRADE OF WIRE. *TR

Mileage: 58,000

THE CAR WAS UNRESPONSIVE. THE CAR TURNED OFF. THE CAR WAS STEERED TO SIDE OF THE ROAD. THE CAR CAUGHT FIRE AND WAS DESTROYED IN LESS THAN 10 MINUTES. *TR

Mileage: 110,000

CAR WOULDN'T EXCEL WHILE DRIVING SUDDENLY 1 MILE FROM TOWN SUDDENLY TRAFFIC SLOWED FROM SNOW STORM IN TOWN,THE VEHICLE SMELL WAS FUNNY BLACK SMOKED SLOWLY LEAKED INSIDE THE CAR WINDOWS UP HEARD A MISFIRE ENGINE LIGHT WENT ON BLINKED THEN I HEARD LOUD BLAST LIKE I THOUGHT IT WAS A PLOW TRUCKS MUFFLER LOUDNESS REALIZED IR WAS MY VEHICLE STOPPED IMMEDIATELY LESS 1/3 MILE AT BANK. SHUT OFF MOTOR M NOW SEEING SMOKE SLOWLY ENTERED IN THE MIDDLE OF THE 2 FRONT SEATSAND CONSOLE. FEELING HOT UNDER BELLY OF FLOORS. ORANGE GLOW THROUGH ELECTRICAL OUTLET IN BACK OF CONSOLE APPEARED TO BE HOTWITH PLASTIC CASING IN AND UNDER FLOORS HOT SIZZLING CRACKLING UNDER CENTER CASING/I TRY TO CALL 911 MISUSED THE CELL WOULDN'T OPERATE EFFECTIVELY FLAGGED DOWN A MAN N WOMAN AT THE CORNER LIGHT OF BANK THEY DECLINED TO HELP SO I WENT TO CAR PUT SNOW ON COMPARTMENT AND WET IT DOWN AND AIRED OUT SMOKE WITH PASSENGER DOOR OPEN .I WENT IN BANK FOR ASSISTANCE .THIS VEHICLE WAS RECALLED FOR SAFETY ISSUES BY MANUFACTURER IN THE PAST .WERE SAID TO BE CORRECTED BY REPAIRMAN ALSO SAID SEATBELT HARNESS WAS A ISSUE HEATED SEATS WERE A ISSUE AND AIRBAGS TRANNY ALSO RECALLED FOR ELECTRICAL ISSUES AND OR TRANSMISSION AND AIR BAGS ON SOME 2004 VW VEHICLE BEETLES RECALLS SO FAR OCCURRED TO THIS VW WERE AIRBAG SENSORS/ ALSO THE SEATBELT HARNESS CASES WERE BREAKING REPEATEDLY ONCE PURCHASED DUE TO PUTTING THE SEATS UP AND BACK TO GET IN THE VEHICLE. NOW THIS MYSTERIOUS FIRE AND HEADLAMP ISSUE.. *TR

Mileage: 80,000

I HAVE HAD THE REGULATOR REPLACED IN MY REAR DRIVER'S SIDE WINDOW AND MY FRONT AND REAR PASSENGER SIDE WINDOWS. IT SEEMS THAT THERE MIGHT BE A MANUFACTURER DEFECT WITH THE REGULATORS/WINDOWS. THANK YOU. *TR

Mileage: 114,000

THE BATTERY FUSE BOX THE FUSE TO THE ALTERNATOR HAS MELTED 3 TIMES WITHIN THE LAST 2 MONTHS COSTING ME OVER 1000.00 IN REPAIRS. BATTERY REPLACED,ALTERNATOR REPLACE VOLTAGE REGULATOR REPLACED, ALTER. HARNESS REPLACED AND NUMEROUS OTHER THINGS BUT FUSE KEEPS BLOWING AND MELTS FUSE BOX AND CAR DIES LOSES COMPLETE POWERWITHOUT WARNING. THERE IS A POTIENTIAL FIRE HAZARD. THERE ARE DOZEN OF COMPLAINTS OF THE SAME PROBLEM AND NO RECALL HAS BEEN ISSUED. *TR

I RECENTLY PURCHASED A VW BEETLE IN MAY OF 2010, FOR MY BIRTHDAY FROM HOLLYWOOD AUTO BROKERS IN LOS ANGELES, CA. THE CAR RAN SMOOTH FOR ABOUT A COURSE OF FIVE TO SIX MONTHS, I HAD TO RETURN TO THE DEALERSHIP EARLY ON BECAUSE MY HEAD LIGHTS WERE OUT WHEN I FIRST BOUGHT THE CAR. AS I CONTINUED TO DRIVE THE CAR, A JERKING AND EXTREMELY WEIRD DECELERATION OF THE CAR WOULD BEGIN, BUT IT WOULD "POP BACK TO NORMAL" AFTER A WHILE, MAYBE THREE TO TEN SECONDS. THIS HAD GONE ON AND HAS BEEN GOING ON SINCE FIVE MONTHS AFTER I BROUGHT IT. I FINALLY MADE IT BACK INTO THE DEALERSHIP AND HE RODE WITH ME ON A TEST DRIVE AROUND THE CORNER AND OF COURSE IT DIDN'T REPEAT THE PREVIOUS SHOW OF DEFECTS. HE ASSURED ME THE CAR IS JUST BEING BROKEN IN. A YEAR GOES BY AND I DECIDED I WANT TO TRADE IN MY CAR FOR ANOTHER CAR, SO I HEAD TO NISSAN. I TEST DRIVE A CAR AND LOVE IT AND THEN GO IN FOR THE PAPER WORK. THE GUY RUNS MY VIN TO SEE MY CAR VALUE AND COME BACKS AND TELL ME MY CAR TITLE IS SALVAGED. TO MY DISBELIEF AND DISGUST, I IMMEDIATELY CALLED MY FINANCIAL COMPANY, AL FINANCIAL OF GLENDALE, CA THAT I AM LEASING THE CAR FROM. THEY GIVE ME THE RUN AROUND AND ASSURE ME THAT THE TITLE IS CLEAN AND NOT A SALVAGE. I CONTINUE ON MY INVESTIGATION AND COME TO A CARFAX WEBSITE TO GET THE REAL FACTS ON MY DEFECTED VEHICLE. THE INFORMATION REVEALS THAT NOT ONLY IS THE TITLE SALVAGE BUT IT HAD BODILY DAMAGE AND HAD BEEN TOTALED OUT FROM THE INSURANCE COMPANY FROM IT'S PREVIOUS OWNER. THE CAR HAD BEEN BROUGHT BACK FROM MEXICO AND REGISTERED IN THE STATES AGAIN AS A NEW CAR I BELIEVE. I WOULD REALLY LOVE TO GET TO THE BOTTOM OF THIS SITUATION ASAP AND GET SOME CLOSURE ON A RECURRING PROBLEM THAT IS MESSING WITH MY INCOME AS I AM A TRAVEL NURSE FOR HOSPICE PATIENTS. RECENTLY THE WATER PUMP HAS GONE OUT AND I'M NOT SURE YET IF I NEED TO REPLACE THE HEAD GASKETS. I HOPE I CAN HEAR AN RESPONSE IN A GOOD ENOUGH AMOUNT OF TIME SO I CAN WORK OUT AN REIMBURSEMENT OF SOME KIND WITH PAYMENT ON EITHER BEHALF. *TR

TL*THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED AFTER ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUSE BOX AND THE WIRING HARNESS TO THE ALTERNATOR BURNED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 84,000.

Mileage: 84,000

WELL IT HAS BEEN NOTHING BUT TROUBLE. FIRST THING, THE TRANSMISSION WENT BAD AND THEN RIGHT AFTER THAT THERE WAS NO BRAKE LIGHTS. THE TOP WILL NOT COME DOWN BY IT SELF. THE DASH LIGHTS COME ON ( AIR BAG, BRAKES, CHECK ENGINE, EMISSIONS). SOUNDS LIKE THERE ARE HOLES IN THE MUFFLER. LAST BUT NOT LEAST THE RIGHT REAR WINDOW FELL DOWN AND THEY WON'T 800 TO FIX, THERE ARE SEVERAL COMPLAINTS ABOUT THIS AND NOTHING IS BEING DONE. *TR

Mileage: 60,000

THE REAR WINDOW REGULATORS WENT OUT ON BOTH WINDOWS, CONVERTIBLE TOP WON'T WORK 90% OF THE TIME. REPLACED HEADLIGHT 4 TIMES IN 2 YEARS. *LN

Mileage: 75,000

2004 NEW BEETLE CONV TURBO . ALWAYS IN SHOP. ALWAYS HAD PROBLEMS. IN THE SHOP MORE THAN AT HOME. ELEC ISSUES,WINDOWS NOT WORKING, AIR BAG LIGHTS FLASHING, TOP STAYING DOWN WONT GO UP ONE REPAIR AFTER ANOTHER. NOW THE TRANSMISSION IS GONE. WHAT A PIECE OF [XXX]. JUST HOPE SOME ONE READS THIS AND TALKS THEIR DAUGHTER OR WIFE OUT OF MAKING A 20,000 DOLLAR MISTAKE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 96,000

PROBLEM WITH TRANSMISSION, GEAR STUCK IN LOW. *TR

Mileage: 63,782

MY LEFT FRONT HEADLAMP FAILED WHILE DRIVING. I THOUGHT IT WOULD BE JUST A BULB. I WENT TO PULL THE BULB AND THE HEADLAMP HARNESS WAS MELTED AND FUSED. I CONTACTED THE LOCAL VW DEALER AND THEY CLAIMED THIS CAN HAPPEN AND I WOULD HAVE TO REPLACE THE ENTIRE ASSEMBLY. THIS IS A $400.00 REPAIR. WHY DOES THE HARNESS MELT , THIS IS A FIRE HAZARD UNDER THE HOOD. PLUS WHAT IF THIS HAPPENS TO BOTH HEADLIGHTS AT THE SAME TIME ?? *TR

Mileage: 78,563

I HAVE A 2004 VW BUG WITH 51,000 MILES . THE CAR STARTED JERKING SO HARD ITS ALMOST CAUSED SEVERAL ACCIDENTS TO ME AND OTHERS ! VW SAYS IT NEEDS A NEW 7000 DOLLAR TRANSMISSION! THEY WONT ADMIT THE PROBLEM IS OF EPIC PROPORTIONS WITH THIS MODEL . IT'S ALL OVER THE INTERNET. MY CAR HAS ALSO HAD THE WINDOW MOTOR GO OUT AND MANY PARTS JUST FALL OFF SUCH AS SEATBELT LATCH COVER. THESE CARS SHOULD BE RECALLED FOR SAFETY!PLEASE HELP ME GET VW TO FIX THIS PROBLEM! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 48,000

2004 VW TURBO BEETLE--AFTER LAST TWO DEALER SERVICING THE CAR DIES ON TURNS--DASH LIGHTS COME ON, NO POWER STEERING. CAR REGAINS POWER IN @ 2 SECONDS. A DEFINITE SAFETY CONCERN. THE DEALER AND VW AMERICA WANT TO START REPLACING PARTS AND SEE WHAT WORKS AT MY EXPENSE. HAVE BEEN WITHOUT MY CAR FOR THREE WEEKS. *TR

Mileage: 50

TL*THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE CONVERTIBLE. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER AND OBD DEVISE FAILED. THE DEALER REFUSED TO INSPECT THE VEHICLE BECAUSE ALL THE GAUGES ON THE INSTRUMENT PANEL WERE DISABLED. THE VEHICLE WAS TAKEN TO ANOTHER DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE CURRENT MILEAGE WAS APPROXIMATELY 77,000.

Mileage: 20,000

AT ABOUT 35,000 MILES MY CAR STARTED SLIPPING WITH THE TRANSMISSION. IT WOULD JERK FORWARD AND SOMETIMES GET STUCK IN BETWEEN 1, 3, AND 4TH GEARS. THIS WAS NOT A HUGE PROBLEM AT THIS POINT AND DURING MY REGULAR CHECK UPS, VW DEALERSHIP ALWAYS SAID THERE WAS NO PROBLEM DETECTED. 2. THE AUTOMATIC TRANSMISSION IS NOW FAILING AT 60,000 MILES. IT HAS ALMOST CAUSED ME SEVERAL ACCIDENTS, ESPECIALLY AT INTERSECTIONS. PEOPLE ALMOST REAREND ME DAILY. NOT ONLY IS THE CAR JERKING FORWARD AND BACKWARD UPON GEAR SHIFTING, BUT NOW IT GETS STUCK PERIOD AND WILL NOT MOVE..THE RPM'S GOING ALL THE WAY TO 6-7. THE TIRES SPIN, THE CAR GROANS HORRIBLY, THE GEARS SHOW UP ON MY DASH IN BRACKETS. WHEN I HAD A DIAGNOSTIC TEST DONE AT THE DEALERSHIP ABOUT FOUR MONTHS AGO, AND I EXPLAINED IN DETAIL THE TRANNY PROBLEM, THEY SAID NOTHING WAS WRONG WITH IT. NOW, I CAN TELL IT IS ALMOST UNDRIVABLE AT THIS PT. ON MY FIFTEEN MILE COMMUTE HOME TODAY, I HAD TO PULL OVER SEVEN TIMES BECAUSE THE TRANSMISSION FAILED. I COULD NOT GET OUT OF FIRST GEAR THEN IT JUMPED TO SIX. I WAS STUCK IN THE MIDDLE OF AN INTERSECTION AT A RED LIGHT, ALMOST GETTING BACKENDED. THIS IS TERRIFYING. I HAD A PANIC ATTACK. I HAVE AN APPT. TOMORROW AT THE DEALERSHIP TO SEE WHAT THE PROBLEM IS AND HOW MUCH MONEY THIS WILL COST ME. MY CAR HAS ALWAYS BEEN CHECKED UP REGULARLY. *TR

Mileage: 61,500

MY 2004 VW BEETLE TURBO CONVERTIBLE CHECK ENGINE LIGHT CAME ON, VEHICLE THEN STALLED OUT, SMOKE CAME OUT OF ENGINE HOOD, EMBERS FELL BELOW CAR, SMOKE CONTINUED TO POOR OUT OF ENGINE HOOD, FLAMES CAME OUT OF ENGINE HOOD, 911 CALLED AND FIRE DEPT AND FIRE MARSHALL PUT OUT FIRE. I AM NOW WAITING TO HEAR FROM MY INSURANCE COMPANY. *TR

Mileage: 88,000

THE ELECTRICAL SYSTEM SHORTED OUT AND SHUT DOWN IN THE MIDDLE OF TRAFFIC. AND FRONT HEADLIGHT GOES OFF AND ON THE DRIVERS SIDE. *TR

Mileage: 37,000

2004 VOLKSWAGEN NEW BEETLE TURBO GLS HAS A DEFECTIVE PART PRODUCING HIGH VOLTAGE. CONSUMER WANTS TO BE REIMBURSED FOR EXPENSES AND DEPRECIATION BECAUSE THE VEHICLE WAS DAMAGED BEYOND REPAIR. *NJ THE DEALER TOLD THE CONSUMER THE VEHICLE NEEDED A NEW WINDOW MOTOR. THE CONSUMER DECIDED TO HAVE THE WORK DONE SOMEWHERE ELSE, SO THEY GAVE HER A CABLE KIT AND NOT A REGULATOR. THE OTHER REPAIR SHOP STATED IT WAS THE REGULATOR THAT WAS DEFECTIVE. THE CONSUMER ALSO STATED THE VEHICLE WOULD NOT START. THE CONSUMER RECEIVED A SECOND OPINION AFTER THE ORIGINAL DEALER IMPLIED SHE HAD DONE SOMETHING WRONG. IT WAS DETERMINED THAT SOMETHING WAS OVERCHARGING THE ALTERNATOR, WHICH TURNED OUT THAT A NEW BATTERY WAS NEEDED. A COUPLE OF DAYS LATER, THE VEHICLE WOULD NOT START AGAIN, THE CONSUMER WAS INFORMED THE WINDOW MOTOR WAS CAUSING HIGH VOLTAGE EVEN WHEN THE VEHICLE WAS SHUT OFF; IT WAS DRAINING THE POWER. THE CONSUMER STATED THE DEALER REFUSED TO ACCEPT RESPONSIBILITY FOR LEAVING THE DEFECTIVE WINDOW MOTOR IN THE VEHICLE. *JB

WIRING HARNESS INSIDE HEADLIGHT ASSEMBLY WIRES CRACK AND CORRODE AND CAUSES HEADLIGHT TO PERIODICALLY GO ON AND OFF. CORROSION SEEMS TO BE DUE TO THE DIFFERENT TYPES OF METALS IN THE WIRING. WHEN THE SAME TYPE OF METAL IS USED TO RECONNECT THE WIRES THE PROBLEM IS SOLVED. *TR

I HAVE HAD MY 2004 VW BEETLE AT BOARDWALK DEALERSHIP IN RICHARDSON, TX 3 TIMES FOR THE SAME PROBLEM. MY CAR WILL LOSE ALL POWER THE BATTERY LIGHT WILL COME ON I WILL HAVE TO TURN THE CAR OFF AND RESTART THE CAR. THIS HAS HAPPEN ON INTERSTATES AS WELL AS ON BUSY STREETS. I AM VERY FEARFUL THAT I AM GOING TO BE IN A VERY BAD ACCIDENT. I TAKE MY 76 YEAR OLD MOTHER TO THE DOCTOR SEVERAL TIMES A MONTH. SHE HAS HAD 2 MAJOR BACK SURGERIES THIS YEAR. I HAVE HAD THE CAR IN THE SHOP ON 9-4-07, 9-18-07, 9-21-0. ALL FOR THE SAME THING. ON 9-27-07, I WAS IN DOWN TOWN DALLAS AND IT HAPPENED AT LEAST 7 TIMES. I CALLED THE DEALERSHIP AND THEY HAD A WRECKER TO PUT ME AND THE CAR UP. THEY ARE TELLING ME TODAY 10-26-07 TO PICK THE CAR UP THAT THEY CAN'T GET THE CAR TO DUPLICATE THE PROBLEM. THERE IS A BAD PROBLEM WITH THIS CAR NOT HAVING ANY POWER AND I AM SCARED TO DRIVE IT. *TR

Mileage: 330,000

PURCHASED BRAND NEW. PROBLEMS I HAVE HAD WITH THIS CAR: 1. REAR POWER WINDOWS HAVE BOTH TAKEN TURNS FALLING DOWN INTO THE BODY. WILL NOT POWER UP. ONE HAS BEEN REPLACED. DEALER NOW WON'T FIX SECOND ONE BECAUSE THEY 'DON'T SEE IT AS A KNOWN PROBLEM.' 2. HEADLINER AROUND REAR WINDOW HAS COME UNDONE. 3. HEADLIGHTS HAVE TO BE REPLACED CONSTANTLY. FOR EXAMPLE; A LIGHT BULB WAS INSTALLED ON A SATURDAY, AND HAD STOPPED WORKING BY THE FOLLOWING WEDNESDAY. 4. RUBBER COATING ON GLOVE BOX AND ON INTERIOR DOORS IS PEELING OFF. DEALER WOULD NOT EVEN CONDSIDER FIXING OR ADDRESSING. 5. KEY ASSEMBLY FOR ARM CONSOLE BROKE ALMOST IMMEDIATELY. IT TOOK APPROXIMATELY 8 MONTHS, AND SEVERAL REMINDERS, TO GET DEALER TO REPLACE. 6. SOMETIMES RADIO STAYS ON AFTER KEY HAS BEEN REMOVED FROM IGNITION. 7. AIR BAG LIGHT STAYS ON. WON'T GO OFF. 8. HAND RELEASE ON FRONT PASSENGER SEAT OFTEN GETS 'STUCK' AND WILL NOT WORK. 9. CUP HOLDER HAS COME OFF TRACK. I ONLY DRIVE THIS CAR TO-AND-FROM WORK. NO KIDS/PASSENGERS RIDE IN IT. IT HAS NOT HAD ANY OWNER ABUSE. I WILL NEVER BUY ANOTHER VOLKSWAGEN PRODUCT. *JB

HEADLAMP ASSEMBLY SHORTING OUT AND BURNING ASSEMBLY BEYOND REPAIRABLE. HEAT BEING PRODUCED BY HEADLAMP TOO HIGH AND SHORTS OUT HEADLIGHT. REPLACEMENT OF ASSEMBLY IS AN OPTION, BUT CAUSE OF ASSEMBLY SHORTING OUT IS NOT REMOVED, WITH HIGH PROBABILITY OF A REPEAT SHORT. *JB

Mileage: 68,000

3RD ELECTRICAL FAILURE, 2ND AIRBAG LIGHT/MALFUNCTION. CONTINUED ISSUE WITH AIRBAG LIGHT ON/MALFUNCTIONING SPONTANEOUSLY. *AK

Mileage: 44,963

4 DAYS AFTER PURCHASING VOLKSW BEETLE 1.8L TURBO I HAD A COMPLETE ELECTRICAL SYSTEM FAILURE WHILE DRIVING . NO READOUTS, ENGINE WILL CRANK, BUT DOES NOT TURN OVER. NO ELECTRICAL LIGHTS OR READOUTS. HAD TO HAVE VEHICLE TOWED TO BOB BAKER VOLKSWAGEN DEALERSHIP WHERE CAR WAS PURCHASED FOR SERVICE. REPEATED ELECTRICAL ISSUES/REPAIRS TO CURRENT DATE. *AK

Mileage: 1,048

MAJOR ELECTRICAL, MECHANICAL MALFUNCTION (SEE 10148507, 10148481) 5TH ELECTRICAL/MECHANICAL SAFETY ISSUES/4TH AIRBAG LIGHT/MALFUNCTIONED. VEHICLE 2ND X TOWED IN 10 DAYS FOR SAME ISSUES FOR FREEWAY BREAKDOWN ELECTRICAL/MECHANICAL MALFUCTION. *AK

Mileage: 53,166

4TH ELECTRICAL FAILURE, 3RD AIRBAG LIGHT/MALFUCTION. 5 DAYS AFTER SERVICING CAR FOR AIRBAG SAFETY ISSUE, SAME REPEATED PROBLEM. (SEE COMPLAINT 10148516, 10148511). *AK

Mileage: 44,959

DT: CONSUMER COMPLAINED ABOUT ELECTRICAL PROBLEMS; THE SPEAKERS DIDN'T WORK/WINDOWS KEPT GOING UP AND DOWN, AND TRANSMISSION FAILED. THE CAR WAS NOT EVEN A ONE YEAR OLD. *AK THE REPLACED TRANSMISSION STILL PERFORMS POORLY. THE AIR BAG LIGHT CAME ON AT LEAST 3-4 TIMES. *TT *NM

Mileage: 18,000

DIGITAL ODOMETER "GOES OUT" AND THE CHARACTERS CHANGE WHILE THE CAR IS SITTING OR WHILE STARTING. I DON'T KNOW IF THIS IS BAD OR NOT, BUT IT DOESN'T SEEM NORMAL. I'VE BEEN TO THE DEALER AT LEAST 5 TIMES WITH NO FIX OR URGENCY TO FIND OUT WHAT THE PROBLEM MIGHT BE. CLUSTER WAS REPLACED ONCE.

Mileage: 5,000

WHILE DRIVING 55 MPH DASHBOARD LIGHTS CAME ON AND THE VEHICLE LOST POWER. VEHICLE WOULD NOT ACCELERATE, AND WAS NEARLY REAR ENDED. CONSUMER TOOK VEHICLE TO THE DEALER TWICE FOR REPAIRS. THE PROBLEM RECURRED. *AK