2015 VOLKSWAGEN GOLF SPORTWAGEN Engine Problems

The contact owns a 2015 Volkswagen Golf Sportwagen. The contact stated that while starting the vehicle, there was an abnormal sound coming from the engine. The vehicle was taken to an independent mechanic, who determined that the camshaft module and variable valve timing (VVT) gears needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,900.

The contact owns a 2015 Volkswagen Golf Sportwagen. The contact stated that while starting the vehicle, there was an abnormal sound coming from the engine. The vehicle was taken to an independent mechanic, who determined that the camshaft module and variable valve timing (VVT) gears needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,900.

Engine fire due to exhaust equipment malfunction, if it was not attended to or noticed quickly it could lead to loss of control of vehicle, causing injury or death to occupants or other motorists. This occurred after having a recall completed.

Engine fire due to exhaust equipment malfunction, if it was not attended to or noticed quickly it could lead to loss of control of vehicle, causing injury or death to occupants or other motorists. This occurred after having a recall completed.

In the last year, my car has experienced multiple instances of the Diesel Particulate Filter (DPF) warning light, check engine light, and a flashing glow plug light on the dashboard. Despite multiple visits and repairs at Sheehy Volkswagen of Springfield, these issues persist, particularly in sub-freezing temperatures. Upon independent inspection of the engine compartment, I found multiple exposed wires, broken wires, and poorly repaired broken wires. The most significant concerns are as follows: Repeated DPF Issues: Over the last three years, the DPF warning and related issues have recurred each winter. Initial attempts to rectify the issue included a DPF regeneration procedure, which temporarily cleared the fault codes but did not address the underlying problem. The DPF was finally replaced in mid-2024, yet the same problems manifested with a brand new component just months later. Extended Repair Time: Sheehy Volkswagen of Springfield had my vehicle for a total of six months (Dec-23 to May-24), during which they were unable to diagnose or fix the problem despite escalating the case to Volkswagen HQ (Business Case Numbers: BT1167682 and BT1177805). This delay is unacceptable. Poor Customer Service: Throughout this period, customer service was unsatisfactory. I was frequently passed between customer service representatives, none of whom were sufficiently informed about the ongoing repairs. Incorrect Diagnosis and Repairs: After replacing the DPF, ECM, temperature sensor, and wiring harnesses, the issue persisted. It was eventually suggested that a wiring problem might be to blame, yet no comprehensive solution was provided. Incompetence and Safety Concerns: Upon retrieving my vehicle, I noticed white smoke emanating from the engine compartment, which I discovered was due to the coolant reservoir being overfilled. Additionally, an independent inspection revealed exposed and poorly repaired wires, posing a serious safety hazard.

In the last year, my car has experienced multiple instances of the Diesel Particulate Filter (DPF) warning light, check engine light, and a flashing glow plug light on the dashboard. Despite multiple visits and repairs at Sheehy Volkswagen of Springfield, these issues persist, particularly in sub-freezing temperatures. Upon independent inspection of the engine compartment, I found multiple exposed wires, broken wires, and poorly repaired broken wires. The most significant concerns are as follows: Repeated DPF Issues: Over the last three years, the DPF warning and related issues have recurred each winter. Initial attempts to rectify the issue included a DPF regeneration procedure, which temporarily cleared the fault codes but did not address the underlying problem. The DPF was finally replaced in mid-2024, yet the same problems manifested with a brand new component just months later. Extended Repair Time: Sheehy Volkswagen of Springfield had my vehicle for a total of six months (Dec-23 to May-24), during which they were unable to diagnose or fix the problem despite escalating the case to Volkswagen HQ (Business Case Numbers: BT1167682 and BT1177805). This delay is unacceptable. Poor Customer Service: Throughout this period, customer service was unsatisfactory. I was frequently passed between customer service representatives, none of whom were sufficiently informed about the ongoing repairs. Incorrect Diagnosis and Repairs: After replacing the DPF, ECM, temperature sensor, and wiring harnesses, the issue persisted. It was eventually suggested that a wiring problem might be to blame, yet no comprehensive solution was provided. Incompetence and Safety Concerns: Upon retrieving my vehicle, I noticed white smoke emanating from the engine compartment, which I discovered was due to the coolant reservoir being overfilled. Additionally, an independent inspection revealed exposed and poorly repaired wires, posing a serious safety hazard.

The emissions modification calibration by Volkswagen causes the coolant to be exposed to elevated temperatures due to higher exhaust gas recirculation (EGR) use to control emissions. These elevated higher temperatures degrade the coolant faster than designed and lead to precipitates falling out of solution in the factory filled G13 coolant. This causes buildup and deposits to form throughout the cooling system, particularly in the heater core which can block proper coolant flow & lead to coolant system failure, specifically of hoses associated with the heater core. When these fail the engine can over heat, and stop which causes loss of steering, propulsion and braking abilities. There is a similar problem on 2012 models with the TDI engine, which has been addressed but the 2015 models are being stranded on the roads creating a safety hazard to the drivers of the vehicles and other motorists on the road.

The emissions modification calibration by Volkswagen causes the coolant to be exposed to elevated temperatures due to higher exhaust gas recirculation (EGR) use to control emissions. These elevated higher temperatures degrade the coolant faster than designed and lead to precipitates falling out of solution in the factory filled G13 coolant. This causes buildup and deposits to form throughout the cooling system, particularly in the heater core which can block proper coolant flow & lead to coolant system failure, specifically of hoses associated with the heater core. When these fail the engine can over heat, and stop which causes loss of steering, propulsion and braking abilities. There is a similar problem on 2012 models with the TDI engine, which has been addressed but the 2015 models are being stranded on the roads creating a safety hazard to the drivers of the vehicles and other motorists on the road.

A defect that meets the definition of a nonconformity in Washington State, and that is covered under warranty, caused the vehicle to stall while driving and caused the vehicle to not accelerate when the accelerator was pressed. My safety was put at risk when this happened on a 50 mph road because vehicles behind me expected my vehicle in front of them to accelerate in a predictable way with the flow of traffic. Another time, a stall happened as I turned onto a highway. I had come to a stop, waited for the traffic light, and then turned right and pressed the accelerator as I normally would to get up to 50 mph. A flashing glow plug light came on, and the car immediately had zero propulsion, and so I turned the steering wheel to roll to the side of the road and turned on my hazard lights. I was fortunate that I was not rear-ended. On another occasion, I came off of the interstate as normal, but when I tried to drive over the overpass at a slight incline, the vehicle was unable to accelerate to 20 mph, and would only go about 5 mph no matter how much the accelerator was pressed. This happened multiple times, but not all of the time, and it was unpredictable when it would happen. It was dangerous to me because I could not time traffic circles with confidence that I would be able to press the accelerator and get up to speed without being struck from the left, or turn out onto busy roads with confidence I wouldn't be t-boned, or merge with traffic on the highway. The mileage on the vehicle at the first attempt to diagnose/repair the defect was 63935 on 10/11/2019 when a VW dealership diagnosed and replaced two glow plugs under warranty. Several more times it was warr. repaired. In November 2021, after the vehicle was repaired and failed on the dealership test drive, an engineer from Volkswagen inspected the vehicle, it was further repaired and released to me. A couple of months later, the vehicle stalled on a highway and a flashing glow plug light came on.

A defect that meets the definition of a nonconformity in Washington State, and that is covered under warranty, caused the vehicle to stall while driving and caused the vehicle to not accelerate when the accelerator was pressed. My safety was put at risk when this happened on a 50 mph road because vehicles behind me expected my vehicle in front of them to accelerate in a predictable way with the flow of traffic. Another time, a stall happened as I turned onto a highway. I had come to a stop, waited for the traffic light, and then turned right and pressed the accelerator as I normally would to get up to 50 mph. A flashing glow plug light came on, and the car immediately had zero propulsion, and so I turned the steering wheel to roll to the side of the road and turned on my hazard lights. I was fortunate that I was not rear-ended. On another occasion, I came off of the interstate as normal, but when I tried to drive over the overpass at a slight incline, the vehicle was unable to accelerate to 20 mph, and would only go about 5 mph no matter how much the accelerator was pressed. This happened multiple times, but not all of the time, and it was unpredictable when it would happen. It was dangerous to me because I could not time traffic circles with confidence that I would be able to press the accelerator and get up to speed without being struck from the left, or turn out onto busy roads with confidence I wouldn't be t-boned, or merge with traffic on the highway. The mileage on the vehicle at the first attempt to diagnose/repair the defect was 63935 on 10/11/2019 when a VW dealership diagnosed and replaced two glow plugs under warranty. Several more times it was warr. repaired. In November 2021, after the vehicle was repaired and failed on the dealership test drive, an engineer from Volkswagen inspected the vehicle, it was further repaired and released to me. A couple of months later, the vehicle stalled on a highway and a flashing glow plug light came on.