1996 VOLKSWAGEN GOLF Electrical System Problems

TL*THE CONTACT OWNS A 1996 VOLKSWAGEN GOLF. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 65 AND 70 MPH IN RAINY WEATHER CONDITIONS WITH THE WINDSHIELD WIPERS ENGAGED WHEN SUDDENLY, THE WINDSHIELD WIPERS STOPPED WORKING AND SMOKE BEGAN EMITTING FROM THE STEERING COLUMN. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF. WITHIN A FEW MINUTES, THE SMOKE SUBSIDED AND THE CONTACT WAS ABLE TO CONTINUE DRIVING NORMALLY. THE VEHICLE WAS REPAIRED BY REPLACING THE IGNITION AND THE WINDSHIELD WIPER SWITCH. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

Mileage: 110,000

CONSUMER STARTED VEHICLE AND HEARD A LOUD POPPING SOUND. THEN, SAW SMOKE COMING FROM UNDER THE HOOD. HE SHUT OFF ENGINE AND OPENED HOOD. BATTERY HAD EXPLODED. BATTERY WAS FACTORY REPLACEMENT PART INSTALLED BY DEALER. *AK THE BATTERY HAD BEEN REPLACED THREE TIMES. CONSUMER WAS BURNED FROM THE BATTERY ACID. *YH

DOOR LOCK CYLINDER- SEPARATED FROM INNER ASSEMBLY , #2. WHILE IN HYWAY TRAFFIC, RADIO FAILED, FOLLOWED BY ,IN APPROXIMATELY 10 SECONDS, ENGINE CUTTING OFF ( FUEL/WATER GUAGE FUNCTIONED), COASTED TO ROADSIDE. ATTEMPTED TO START ENGINE, ACTED AS IF BATTERY DEAD. AFTER 1 HOUR WAIT, ATTEMPTED TO RESTART ENGINE, STARTER TURNED SLOWLY BUT DID NOT START ENGINE. HOWEVER, STANDARD ALARM SYSTEM SOUNDED. I TURNED OF ALARM BY INSERTING KEY IN DOOR (STANDARD PROCEDURE). TOW TRUCK GAVE BOOST AT BATTERY. VEHICLE IMMEDIATELY STARTED . THE BATTERY LOW POWER THING, OCCURRED ABOUT TWO WEEKS PRIOR, IN VW DEALER'S CUSTOMER PICK UP AREA, AFTER DEALER HAD REPLACED A HEADLIGHT FUSE/ ALIGNED HEADLIGHTS/WHEELS. WHEN ALARM WENT OFF AND STARTER DID NOT TURN OVER ENGINE, SERVICE MANAGER IMMEDIATELY ARRIVED W/BOOSTER UNIT AND STARTED CAR. HE SAID BATTERY PROBABLY GOT LOW FROM TECHNICIAN HOLDING DOWN BRAKE PEDAL FOR EXTENDED PERIOD OF TIME? DUH? I DID NOT THINK ANYTHING MORE ABOUT PROBLEM AT THE TIME(DENIAL). PROBLEM H. *AK

AFTER CONSUMER TURNED VEHICLE OFF AND THEN STARTED IT BACK ON CAR ALARM CAME ON AND STAYED ON.CONSUMER LOOKED UNDER HOOD TO SEE WHAT WAS GOING ON. THEN, CONSUMER SMELLED SMOK, AND REALIZED THAT WIRING SYSTEM BURNED OUT NOTHING THAT WAS MOTORIZED WAS WORKING. CONTACTED DEALER AND DEALER WAS WILLING TO FIX PROBLEM AT OWNERS COST.*AK

DROVE INTO PARKING LOT. HEARD A NOISE & VEHICLE STOPPED. SMOKE CAME FROM UNDER HOOD, THEN FLAMES SHOT OUT. FIRE DEPARTMENT ARRIVED AND PUT OUT FLAMES. GAVE INDICATION OF ELECTRICAL PROBLEM, CAUSING FIRE. PRIOR TO PROBLEM ,HAD TAKEN VEHICLE TO DEALERSHIP 11 TIMES FOR ENGINE CHECK LIGHT COMING ON/ DOOR LOCKS, AND WINDSHIELD WIPERS. DEALERSHIP WAS NOT HONORING EXTENDED WARRANTY THAT WAS SOLD.*AK

EXTENTED WARENTEE NOT ACCEPTED,HAD TO PAY PARTS AND LABOR. *AK

ELECTRICAL FUSE FAILED.

ELECTRICAL FAILURE RESULTING IN REPLACEMENT OF EVERY LIGHT IN THE CAR MORE THAN A FEW TIMES.

PROBLEM IDLE SURGING, SEVER DIAGNOSIS TO SOLVE THE PROBLEM, BAD CHIP IN ECM COMPUTER, UPDATE CHIP, WIRING PROBLEM-CUT WIRES ING THE ELECTRICAL CIRCUIT OF FUEL INJECTORS, REPLACE BOTH OXYGEN SENSORS, THROTTLE BODY SWITCH BAD-REPLACED, ALL TO NO AVAIL.

BAD CHIP IN ECM COMPUTER.

HORN BUTTON DIFFICULT TO FIND IN EMERGENCY SITUATIONS.

ENGINE ECM FAILED.