2009 VOLKSWAGEN JETTA Engine Problems

The contact owns a 2009 Volkswagen Jetta. The contact stated that while driving at 50 MPH, the vehicle stalled. Several unknown warning lights were illuminated. The contact was able to pull over to the side of the road. The contact stated that the failure had been recurring while driving. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the ABS module had failed and needed to be replaced. The vehicle was not repaired. The contact stopped driving the vehicle due to safety concerns. The manufacturer was notified of the failure. The failure mileage was approximately 86,000.

Mileage: 86,000

I purchased it unknown condition Accident History Damage Report - OKLAHOMA CITY, OK - [xxx] Accident or Damage Reported Vehicle Damage Reported Right Side Damage or Repair Reported Damage or Repair to Bumper Reported Damage or Repair to Hood Reported Damage or Repair to Radiator Reported Damage or Repair to Grille Reported Damage or Repair to Fender Reported INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I brought my car to the dealership not even 2 years ago. They said they fixed my ABS moduler and the EPC updated the software and replaced the ABS moduler if they did then why is my car shutting down and causing me trouble and having issues. I just need this car fixed the correct way. They didnt fix it due to the way they went about it. I need my car fix due to my 8 year old daughter I take yo school and also taking my fiance to PT due to a terrible accident. I need answer or someone to answer why my car is acting up if they fixed it.. Thank You Dawn

My car been fine and went to take my daughter to school and shut the car off and get back in to go home and wouldn't start and the Abs light came on and Check Engine light as well. I am concerned because I think since I have done the ABS no longer then 2 years. I feel like there is a problem and dont think VW fix it the first time when I took it in.. My fiance had a terrible accident 12 month ago and no income and I dont know how we are going to fix it if we have too thats what I am worried about as well.. Thank you, Dawn

I was driving in Clio alabama on state highway 10, when all of a sudden the EPC light came on my 2009 Volkswagen jetta s 2.5 5cyl..... about 2 miles later down the road; the engine cuts off unexpectedly while I am going 62mph down the highway, with an 18 wheeler directly behind me at the same speed. The car just quits, won't do anything, so I swerved over the side the road so I wouldn't get hit by the 18wheeler and tried to restart the car and it wouldn't do anything. I've had to tow it back to my home and I've had multiple mechanics look at it and try to discover the problem but every time they hook up a diagnostic scanner , and it throws a code, I've purchased the parts that shouldve fixed said dtc code, and rescan the car and that fault code will be gone but there'll be a new one each and every time. . It is costing too much to continue to fix it . It will turn over but it will NOT crank up. I don't know what else to do about it but something is just not right about this issue so I am reporting it as a safety issue because the total loss of power near about caused me to get hit by an 18wheeler at very high speeds and could've been killed. And it's also some type of an electrical issue and I am reporting it to hopefully obtain an answer to the issue, help repairing it or replacing it, or Volkswagen to repurchase the car from me and most importantly I'm reporting this so hopefully it will be able to save someone's life one day . Thanks a lot and have a great day .

WHILE DRIVING AT HIGHWAY SPEEDS OF 65MPH, INSTRUMENT CLUSTER INDICATED STOP! OIL PRESSURE ENGINE OFF! AND CAR WENT INTO LIMP. WAS ABLE TO MAINTAIN CONTROL OF VEHICLE AND PULLED OVER TO SIDE OF EXIT. VEHICLE HAD TO BE TOWED FROM HIGHWAY TO REPAIR SHOP. DIAGNOSED TO BE A FAILURE IN THE HEX DRIVE BIT FROM THE BALANCE SHAFT MODULE TO THE OIL PUMP. ALSO CAUSED TURBOCHARGER FAILURE DUE TO LACK OF OIL FLOW. CAR HAS BEEN MAINTAINED TO REQUIRED SCHEDULE AND HAD NO PRIOR INDICATIONS OF IMMINENT FAILURE.

Mileage: 205,000

THE CARS CHECK ENGINE LIGHT CAME ON AND LOST POWER ON THE FREEWAY. I TOOK IT TO GET CHECKED AND A DIAGNOSTIC WAS DONE . I HAD JUST GONE TO THE DEALERSHIP A WEEK BEFORE AND HAD THE BACK BRAKES AND ROTORS REPLACED FOR $500 DOLLARS AND THE OIL CHANGED FOR ANOTHER $100. THEY SAID EVERYTHING WAS FINE.

Mileage: 100,000

THE KEY WOULD NOT TURN TO TURN OFF ENGINE - SO WE WERE NOT ABLE TO TURN THE CAR OFF.

Mileage: 120,000

HAD DROVE THE CAR LITTLE WHILE, THEN MADE A STOP, CRANKED THE CAR TO LEAVE AND SOUNDED LIKE IT WAS LOW ON OIL, THAT KIND OF. TAPPING SOUND. OIL WAS FINE. BUT THE SOUND STILL THERE THE NEXT DAY. AFTER DRIVING IT A MILE OR TWO. IT GOT LOUDER, THEN THE CHECK ENGINE LIGHT CAME ON. I STOPPED AT THE CLOSEST PART STORE ABOUT 5 MIN AFTER THE LIGHT CAME ON. THEY CHECKED IT WITH THE SCANNER. SAID IT WAS A KNOCK SENSOR CODE. P0328, BANK 1.TOOK IT TO VW. TO GET A DIAGNOSITS DONE. AND THE MAN SAID IT WAS DUE TO A RECALL. THE PROBLEM I WAS HEARING, AND THE CODE. WAS FROM THE RECALLED PART. THEY CHANGED THAT PART. SAID IT WAS A FUSE PANEL ON ENGINE BLOCK. THE PROBLEM WAS STILL THE SAME. THEN, HE SAID IT WAS NOT DUE TO THE RECALL. AND I STILL HAD TO PAY THE 120 DOLLAR FOR THE DIAGNOSTIC. AND SAID THEY WOULD HAVE TO OPEN THE ENGINE TO CHECK ANY FURTHER, AND THAT THE LABOR WOULD BE ABOUT 2000 DOLLARS. I HAD TOOK IT BY VW BEFORE IT STARTED TO HAVE ANY NOTICEABLE PROBLEMS.WHEN I HAD HAPPENED TO LOOK UP RECALLS ONLINE. THE MAN LOOKED IT UP BY MY VIN. TOLD ME THERE WERE 3 ACTIVE RECALLS. BUT IT WOULD BE ANOTHER WEEK BEFORE THEY COULD GET TO IT. I ASKED IF IT WOULD BE OK TO CONTINUE DRIVING IT, WAS ANY OF THEM SERIOUS ENOUGH TO NOT. HE TOLD ME , NO, THAT IT WOULD BE FINE TO DRIVE. SAID SPECIALLY SINCE I WASENT HAVING ANY PROBLEMS ALREADY .

Mileage: 150,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE THE VEHICLE WAS IDLING AT A STOP SIGN, IT STALLED AND AN UNKNOWN WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PARKED FOR AN HOUR BEFORE IT WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TIMING SENSOR NEEDED TO BE REPLACED. THE CONTACT REPLACED THE SENSOR, BUT THE FAILURE RECURRED. A DEALER WAS NOT CONTACTED. THE CONTACT WAS UNABLE TO CONTACT THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 173,000.

Mileage: 173,000

MY DAUGHTER IS DRIVING A 2009 VW JETTA THAT IS NOT FIT FOR THE ROAD,THE DEALERSHIP SAYS IT ISN'T THERE PROBLEM,BERLIN CITY HONDA, AND THAT THEY DON'T WORK ON THEM,AND THE EXTENDED WARRANTY DOESN'T COVER IT, AS THE LIGHT TURNS GREEN SHE STEPS ON THE GAS,AND NO POWER AND THE STEERING WHEEL LOCKS,SHE IS IN HEAVY TRAFFIC AND IN A PANIC, SHE PULLS THE KEY,PUTS IT BACK IN AND THE CAR STARTS AGAIN,NOW IT KEEPS HAPPENING AND BERLIN CITY SAYS THEY CAN'T HELP HER? IS THIS A RECALL?

Mileage: 122,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE CHECK ENGINE AND EPC WARNING INDICATORS ILLUMINATED UPON DRIVING THE VEHICLE. THE VEHICLE BEGAN TO JERK, STALL, AND FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE CAM SHAFT SENSOR AND CRANK SHAFT SENSOR FAILED. THE VEHICLE WAS TOWED TO OURISMAN VOLKSWAGEN OF BETHESDA (7001 ARLINGTON RD, BETHESDA, MD 20814, (301) 750-6100) WHERE IT WAS DIAGNOSED THAT THE CAM BRIDGE SPRING DISINTEGRATED AND POPPED OUT INTO THE ENGINE. THE MANUFACTURER STATED THAT THEY HAD NO KNOWLEDGE OF THE FAILURE. THE DEALER QUOTED A REPAIR COST OF OVER $5,000. THE FAILURE MILEAGE WAS 90,084.

Mileage: 90,084

AFTER MONTHS OF CAR BOGGING EVENTUALLY MY CHECK ENGINE LIGHT WENT ON. CODE READ FOR OXYGEN SENSOR. SHORTLY AFTER EPC LIGHT CAME ON. CAR WOULDN'T MOVE. AFTER RESEARCH I FOUND THAT MANY JETTA'S HV THIS ISSUE. RECALL?

Mileage: 125,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V913000 (SERVICE BRAKES, HYDRAULIC, ELECTRONIC STABILITY CONTROL). LATER, WHEN THE VEHICLE WAS STARTED, THE ABS, BRAKE, EPC, AND ESC INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AUTONATION VOLKSWAGEN LAS VEGAS (6375 W SAHARA AVE, LAS VEGAS, NV 89146). THE VEHICLE WAS NOT REPAIRED BECAUSE ANOTHER UNKNOWN REPAIR NEEDED TO BE COMPLETED FIRST. THE VEHICLE WAS THEN TAKEN TO FINDLAY VOLKSWAGEN (983 AUTO SHOW DRIVE, HENDERSON, NV 89014) WHERE THE PREVIOUS DEALER'S ASSESSMENT WAS CONFIRMED. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE AND EPC INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE CONTACT WAS UNSURE OF THE DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 3,000.

Mileage: 3,000

WHILE DRIVING MY 2009 VW JETTA I WENT TO PULL OUT INTO INTERSECTION AND THE CAR SHUT OFF WITH NO WARNING. AT THIS TIME A LIGHT CAME ON THAT SAYS EPC AND PRIOR TO THIS MY CAR WOULD NOT START AND WOULD SAY SAFE ON WARNING LIGHTS. THIS IS A HAZARD TO DRIVE DOES ANYONE KNOW WHAT THE PROBLEM COULD BE AND WHEN ITEM IS REPLACED DO I HAVE TO HAVE THE COMPUTER REPROGRAMMED AFTER THIS WHAT A PAIN

Mileage: 130,000

2009 VOLKSWAGEN JETTA WOLFSBURG 2.0TSI TIMING CHAIN TENSIONER FAILURE. AT 109K MILES THE CAR WOULD NOT START IN THE AM TO GO TO WORK. THIS HAPPENED ON 12/23/16. HAD CAR TOWED TO DEALER AND RECEIVED PHONE CALL FROM SERVICE DEPARTMENT THAT THE TIMING CHAIN TENSIONER HAD FAILED. THE ENGINE WILL NEED BETWEEN $3600 AND $5500 TO REPLACE THE ENGINE COMPONENTS. I WAS TOLD BY THE SERVICE TECH TO CALL VW CUSTOMER CARE BECAUSE THIS IS A KNOWN ISSUE AND THEY MAY HELP WITH THE REPAIRS. VW TOLD ME THEY KNEW NOTHING ABOUT THIS PROBLEM. GOT A SECOND OPINION FROM A MECHANIC THAT WAS PREVIOUSLY EMPLOYED BY VW AND HE VERIFIED THE DIAGNOSIS. THE CAR IS STILL SITTING IN MY DRIVEWAY WITHOUT BEING REPAIRED. I HAVE SINCE FOUND THAT THIS IS A VERY LARGE ISSUE THAT GOES BACK TO THE 2008 MODEL YEAR. THERE ARE SEVERAL CLASS ACTION LAWSUITS PERTAINING TO THIS ISSUE. ONE CASE FILED IN NEW JERSEY IN MAY 2016 HAS JUST HAD ANOTHER HEARING ON MAY 9TH 2017 WHERE THE SUPREME COURT OF NJ HAS AGREED TO LET THE CASE GO FORWARD STATING THERE IS ENOUGH EVIDENCE SHOWING VW AT FAULT. I HAVE DOCUMENTATION FROM THE DEALER AND CAN PROVIDE THAT ONCE I AM BACK AT MY HOME. ANY HELP THE MANY CONSUMERS THAT OWN VW AND AUDI VEHICLES WITH THE 2.0TSI ENGINE FROM 2008-2013 CAN GET WOULD BE GREATLY APPRECIATED. RESEARCHING VW 2.0TSI TIMING TENSIONER ON THE INTERNET WILL BRING UP THE HUNDREDS, IF NOT MORE, OF THE PEOPLE THAT HAVE PAID UPWARDS OF $10K TO HAVE ENGINES REPAIRED ON CARS THAT HAVE AS LITTLE AS 30K MILES ON THEM. THE VW SERVICE MANUAL DOES NOT MENTION THE TIMING CHAIN TENSIONER NEEDING SERVICE AT A PARTICULAR MILEAGE.

Mileage: 109,000

ENGINE REAR MAIN SEAL FAILED ON 80,000 MILES. ENGINE OIL LEAKING.

Mileage: 80,000

OIL SEALS LEAKING OIL ALL OVER ENGINE, MAJOR CARBON BUILD UP FAILING AXLES. I WAS DRIVING ON THE ROAD AND THE CAR MADE A MAJOR THUD AND CHECK ENGINE LIGHT CAME ON. TOOK CAR TO DEALER NEXT DAY AND THEY FOUND ALL SEALS ON THE ENGINE ARE LEAKING OIL AND WATER PUMP HAS FAILED AND MAJOR CARBON BUILD UP IN ENGINE. FOUND OIL ON GROUND OF MY GARAGE. FRONT SUSPENSION KNOWN TO MAKE CRUNCHING SOUNDS WHEN GOING OVER MAJOR BUMPS WHEN COLD.

Mileage: 64,200

FIRST MY CAR HAD TROUBLE TURNING OVER AFTER A MISFIRE. THEN WHILE DRIVING THE CAR (IN MOTION) AS I WAS COMING TO A STOP THE ENGINE BEGAN TO SPUTTER AND FEEL AS IF IT WAS LUNGING FORWARD. I DROVE IT STRAIGHT TO THE VW SERVICE CENTER WHICH WAS NEARBY. NOW THEY ARE TELLING ME IT IS A TIMING ISSUE WHICH I SUSPECT TO BE THE TIMING CHAIN TENSIONER.

Mileage: 73,000

MY 2009 JETTA HAS BEEN EXPERIENCING ISSUES. THE ABS LIGHT, STABILITY CONTROL LIGHT, BRAKE LIGHT, AND CHECK ENGINE LIGHT STAY ON. THE CAR SPUTTERS FROM TIME TO TIME. I TOOK IT TO THE DEALER IN MY TOWN FOR THE VOLKSWAGEN RECALL ON THE ABS SYSTEM. THEY SUPPOSEDLY FIXED THE ABS SOFTWARE AND MODULE. THEN THEY TELL ME THE ABS PUMP IS BAD BUT NOT COVERED UNDER WARRANTY. IT WILL BE $3000 TO REPLACE! THEY REPLACED THE MASS AIR INTAKE, A $442.00 REPAIR AND THE CAR IS STILL MISSING. CHECK ENGINE LIGHTS STILL ON. NOW EPC LIGHT IS ON. ALSO, ALL OF MY ABS LIGHTS, CHECK ENGINE, STABILITY CONTROL, AND BRAKE LIGHTS ARE STILL ON. HOW DO I KNOW THE DEALER ACTUALLY DID THE ABS REPAIR? ALSO, WHY IS THE ABS PUMP NOT PART OF THE RECALL? IT'S DIFFICULT TO BELIEVE THAT THE SOFTWARE CAUSED THE ABS MODULE TO FAIL, BUT HAD NOTHING TO DO WITH THE PUMP. THIS CAR SEEMS TO BE A LEMON. ARE THERE ANY PLANS TO ADDRESS THE ABS PUMP ISSUE?

Mileage: 99,000

CAR'S ABS AND BRAKE SYSTEM HAS BEEN FAILING ONCE A WHILE CAUSING CAR TO LOSE CONTROL OF STABILITY. RANDOM "ENGINE WORKSHOP FAILURE" MANY TIMES WHILE STARTING UP THE CAR AND CAR PERFORMANCE GETS VERY LIMITED.

Mileage: 51,000

WIFE WENT OUTSIDE TO START HER TDI AND AFTER SITTING AND MAKING NO PROGRESS IN WARMING AND SMELLING A LOT OF UN-BURNT DIESEL SHE DECIDED TO SHUT IT OFF. AFTER SHE CAME INSIDE AND TOLD ME IT WAS NOT WARMING UP AND IT SEEMED TO BE RUNNING OUT OF FUEL VERY QUICKLY I WENT OUTSIDE TO CHECK IT OUT. I COULD SEE THAT DIESEL HAD LEAKED ONTO THE GROUND, SO I OPENED THE HOOD AND FUEL WAS DRIPPING FROM THE ENGINE MOUNTED FUEL PUMP. I LEFT IT OVERNIGHT AT THIS POINT TO MAKE SURE NO FIRES WHERE STARTED. THE NEXT MORNING I TOOK IT APART TO FIND OUT WHAT THE SOURCE OF THE LEAK AND AFTER REMOVING THE PUMP, ASSOCIATED ELECTRICAL, AND RUBBER LINES I SAW THE END OF THE PUMP HAD POPPED OUT OF ITS CRIMPED ALUMINUM CASE. THIS WAS ALLOWING DIESEL TO LEAK PAST THE RUNNING ELECTRIC PUMP AND ONTO THE RUNNING ENGINE WHICH AT THE POINT OF TURNING IT OFF HAD COVERED THE ENTIRE SERPENTINE SIDE OF THE ENGINE COMPLETELY IN FUEL. IT WAS A BOSCH PART #1K0 906 098A WE HAVE CONTACTED VW ABOUT THIS AND THEY OFFERED NO ASSISTANCE IN EITHER OFFERING TO INVESTIGATE THE LEAK OR EXPEDITING THE BUYBACK PROCESS TO REMOVE THIS VEHICLE FROM THE ROADS AND MY DRIVEWAY KNOWING THAT IT LEAKED FUEL. VW DID ACKNOWLEDGE A PRIOR RECALL ON A RUBBER FUEL SUPPLY LINE HAD BEEN PERFORMED BEFORE THE CAR WAS PURCHASED. *TR

Mileage: 101,000

THE VEHICLE WAS STATIONARY AT IDLE FOR APPROXIMATELY 15 MINUTES. FIRE STARTED UNDER THE HOOD AT UNKNOWN LOCATION. INITIAL SMELL OF "SOMETHING HOT" WAS FOLLOWED BY SMOKE THROUGH VENTS. NOTICED SMOKE BETWEEN HOOD AND WINDSHIELD. PAINT ON HOOD BUBBLED IN APPROXIMATE LOCATION ABOVE OIL CAP / DIESEL PARTICULATE FILTER. SHUT ENGINE OFF AND EXITED THE VEHICLE.

Mileage: 200,000

I AM REQUESTING THAT THE DOT NHTSA INVESTIGATE THE TIMING CHAIN TENSIONER IN THIS MAKE AND MODEL OF CAR. I STARTED MY CAR ONE MORNING AND THE ENGINE MADE A METALLIC RATTLING SOUND AS I PROCEEDED TO BACK OUT OF THE DRIVEWAY. NO CHECK ENGINE LIGHT CAME ON UNTIL REACHING THE END OF THE DRIVEWAY. CAR WAS THEN DRIVEN TO DEALERSHIP IMMEDIATELY AND DIAGNOSED AS HAVING "JUMPED TIME" DUE TO THE FAILURE OF THE TIMING CHAIN TENSIONER. UPON PICKING UP THE CAR SEVERAL DAYS LATER AFTER THE REPAIRS WERE COMPLETE, THE SERVICE ADVISOR INFORMED US THAT THE METAL RING HOLDING THE TENSIONER LATCH IN PLACE HAD FALLEN OFF; ALLOWING THE TINY ADJUSTABLE LATCH TO FALL OUT, AND THAT BOTH PIECES WERE LYING, LOOSE, IN THE COMPARTMENT WHEN THE CAR WAS TAKEN APART. THIS FAILURE APPEARS TO BE RELATED TO TECHNICAL SERVICE BULLETIN 15-12-01. A WEB SEARCH REVEALS THAT THIS PROBLEM HAS BECOME MORE AND MORE COMMON AND AFFECTS MULTIPLE YEARS AND MODELS OF VOLKSWAGEN AUTOMOBILES. THE CAR HAD APPROXIMATELY 49,000 MILES ON IT AT THE TIME OF THE FAILURE AND NEVER MISSED A SERVICE. VW WAS NOTIFIED OF THE FAILURE. *TR

Mileage: 49,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE THE VEHICLE WAS PARKED, IT FAILED TO START AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN TENSIONER FRACTURED. AS A RESULT, THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,020.

Mileage: 88,020

CHECK ENGINE LIGHT COMES ON FREQUENTLY AND WHEN I TAKE TO DEALER IT IS ALWAYS A SENSOR PROBLEM I HAVE ALSO HAD SOME ELECTRICAL ISSUES REPLACING BULBS FREQUENTLY. ALSO WHILE DRIVING THE SHIFTING LIGHTS WILL ALL LIGHT UP PRNDS, SOMETIMES THERE IS A LOSS OF POWER. ALSO ONE OF THE OVERHEAD LIGHT SEEMS TO HAVE MELTED DUE TO A HIGH HEAT SOURCE OF SOME KIND.

Mileage: 60,000

ENGINE FIRE IN MOTION ON THE HIGHWAY CAUSE UNKNOWN.

Mileage: 84,000

THE ABS MODULE NEEDS TO BE RESTORE OR REPLACE. THE LIGHTS ON THE DASHBOARD THAT COMES ON INCLUDES ENGINE, BRAKES,STEERING, ABS, AND E.T.C.(ELECTRONIC THROTTLE CONTROL).WHAT ACTUALLY HAPPENS WHEN IT COMES ON IS IT HARD TO STEER,ACCELERATION GOES SLOW, BEEPING HEARING TEST NOISE FREQUENTS , GAS GAUGE GOES TO E, AND SPEEDOMETER STOPS WORKING. THIS HAPPENS FREQUENTLY AND DOESN'T MATTER WHAT ROAD OR HIGHWAY I'M WHAT MAKES IT MORE DANGEROUS WHEN ITS HARD TO STEEL AND THE BRAKE LIGHTS ARE CONSTANTLY FLASHING.

Mileage: 95,000

WE HAVE BEEN HAVING AN ISSUE WITH THE ENGINE STALLING OUT WHILE DRIVING. IT STARTED WITH THE EPC LIGHT COMING ON SEVERAL MONTHS AGO, BUT THE LIGHT DOES NOT STAY ON AND THERE HAS BEEN NO CONSISTENCY TO THE OCCURRENCES. HOWEVER, NOW, THE CAR WILL STAY RUNNING FOR LONG AND STALLS OUT SHORTLY AFTER STARTING. THE EPC COMES ON SOMETIMES, BUT NOT EVERY TIME THAT IS STALLS OUT. TODAY I TOOK THE CAR FOR A DRIVE AROUND THE BLOCK, AS SOON AS I GOT IT BACK HOME, IT STALLED OUT. FROM THAT POINT ON THE CAR WOULD NOT STAY RUNNING FOR MORE THAN 15 SECONDS.

Mileage: 87,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE HESITATED AND STALLED. THE CONTACT HAD TO PULL OVER AND PARK THE VEHICLE. THE CONTACT STATED THAT THE CHECK ENGINE AND GLOW PLUG WARNING LIGHTS ILLUMINATED. THE CONTACT, A CERTIFIED MECHANIC, DIAGNOSED THAT THE WATER FROM THE AIR INTAKE COOLER NEEDED TO BE DRAINED.THE EXCESS WATER WAS REMOVED FROM THE VEHICLE; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO STATED THAT, BECAUSE THE VEHICLE WAS NO LONGER UNDER WARRANTY, THEY WOULD NOT PROVIDE A FREE REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.

Mileage: 89,000

JUST BOUGHT THIS CAR FROM A DEALERSHIP 2 MONTHS AGO. WE HAVEN'T EVEN PUT 2,000 MILE ON THE CAR YET AND THE CHECK ENGINE LIGHT CAME ON. I TALKED TO MY MECHANIC AFTER I BOUGHT THE CAR AND HE TOLD ME THESE CARS ARE NOTORIOUS FOR MAF SENSOR FAILURES AND THAT IT IS NOT AN EASY FIX. IN FACT HE WON'T EVEN WORK ON THIS PROBLEM DUE TO HIS PAST EXPERIENCES WITH THIS EXACT PROBLEM. NOW I HAVE TO TAKE IT TO VW AND THEY WILL HAVE TO REPLACE TO WHOLE THROTTLE BODY AND REPROGRAM THE ECU. KINDA FUNNY HOW MY MECHANIC WARNED ME IF THIS PROBLEM AND WASN'T EVEN TIME FOR AN OIL CHANGE BEFORE THIS HAPPENED. SEEMS LIKE VW HAS AN ISSUE WITH THIS PROBLEM AND THE FACT THEY HAVEN'T DONE ANYTHING TO RECTIFY THE PROBLEM SUCH AS RECALL OR OFFER CHEAP SOLUTIONS AND CHARGE OVER 1000$ TO FIX THE PROBLEM AND HAS TO BE DONE AT VW TO RESET THE ECU TELLS ME THEY ARE DOING THIS ON PURPOSE TO MAKE AS MUCH MONEY AS POSSIBLE ON REPAIRS THAT SHOULD ONLY COST A COUPLE HUNDRED DOLLARS... COMPLETELY NOT SATISFIED WITH VW WILL NEVER BUY ONE AGAIN, WILL NEVER RECOMMEND ONE TO ANYONE IN FACT WILL CAMPAIGN TO BOYCOTT VW AT ALL COSTS!!

Mileage: 51,000

THE TIMING CHAIN TENSION BROKE CAUSING THE CHAIN TO BREAK OFF AND BEND SEVERAL VALUES CAUSING EXTENSION DAMAGE TO THE MOTOR. MOST CARS ARE EQUIPPED WITH TIMING BELTS BUT VW WENT TO THE TIMING CHAIN IN RETURN THE TENSIONER WHICH THEY LATER REVISED IS FAULTY AND BREAKS CAUSING THE CHAIN TO DESTROY SEVERAL IMPORTANT PARTS. VW IS UNWILLING TO HELP US WITH THIS ISSUE THAT THEY KNOW IS AN ISSUE BECAUSE THEY LATER CORRECTED IN THE LATER MODELS. I CALLED CUSTOMER CARE BUT BECAUSE THE POWER TRAIN WARRANTY AT 60,000 IS EXPIRED THEY WILL DO NOTHING. THERE IS A HUGE FORUM STARTED WITH SEVERAL PEOPLE THAT HAVE HAD THIS USE AROUND 80-110,00 MILES!! I AM OUTRAGED AND HAVE TO SPEND THOUSANDS OF DOLLARS TO REPAIR ALL THE DAMAGE OR BASICALLY GET A NEW CAR. THE CAR IS WORTHLESS AT THIS POINT.

ENGINE LIGHT CAME ON, I HAD MY MECHANIC DO A 120,000 MILE SERVICE AND DIAGNOSE THE DASH ENGINE LIGHT AND THE INTAKE MANIFOLD WAS REPLACED. WHEN I PICKED THE CAR UP I SMELLED DIESEL. I DROVE IT 13 MILES, WHEN I GOT HOME I SMELLED DIESEL AGAIN. I OPENED THE HOOD AND THERE WAS DIESEL ALL OVER THE LEFT ENGINE SIDE. THERE WAS A WET, SPLIT FUEL LINE, LEAKING FLUID IN THE PARKING LOT, A BLUE PLASTIC SET SMALL RINGS (LIKE THE OLYMPIC SYMBOL) SAT NEAR THE SPLIT HOSE. IT COULD HAVE CAUSED A FIRE, AND OTHER CARS TO BE IN DANGER FROM SLICK ROAD, AMONG OTHER THINGS.

Mileage: 122,040

I WAS DRIVING DOWN THE STREET WHEN A LOUD BEEPING AND THE RED ABS FAILURE + EVERY LIGHT ON DASHBOARD LIT UP. EVERY GAUGE STOPPED WORKING (THE GAS GAUGE, SPEEDOMETER, ETC) I WAS CLOSE TO HOME AND CAREFULLY PROCEEDED TO THE HOUSE. AFTER A HALF MILE THE CAR STALLED AND THE ENGINE DIED. BECAUSE I WAS PREPARED FOR AN EVENT, I IMMEDIATELY SET HAZARDS AND ROLLED TO THE SIDE OF THE ROAD. I RESTARTED THE CAR AND MADE IT THE REST OF THE WAY HOME (2 BLOCKS) WITHOUT IT STALLING AGAIN. I HAVE NOT DRIVEN THE CAR SINCE, I TOOK IT THE VW DEALER AND IT WAS DETERMINED THE ABS MODULE FAILED / BROKE AND CAUSED THE PROBLEMS. THIS IS OBVIOUSLY A MANUFACTURING THE DEFECT WHICH CAN CAUSE AN IMMEDIATE HARMFUL AFFECT. IF I WAS ON A HIGHWAY OR BEING CAREFUL FAR BEYOND ANY NORMAL SENSE I COULD HAVE EASILY BEEN IN A LIFE THREATENING ACCIDENT.

Mileage: 72,015

STOPPED AND LEFT THE LINE AT A GREEN LIGHT WHEN OUR 2009 JETTA TDI SPUTTERED AND STOPPED IN THE MIDDLE OF A BUSY INTERSECTION. WAS ABLE TO GET THE VEHICLE TOWED TO A LOCAL VW DEALERSHIP AND GIVEN AN INVOICE FOR $5500 FOR THE HIGH PRESSURE PUMP, WHICH IS IDENTIFIED A KNOWN ISSUE BY VW UNDER A SELF-IMPOSED EXTENDED WARRANTY BUT NEVER UNDER A RECALL. AS I WAS TOLD BY VW CUSTOMER SERVICE, SINCE THERE WAS NEVER A CATASTROPHIC ISSUE TO OUR VEHICLE PRIOR TO 120K MILES, INSTEAD AT 124K MILES, THE SAFETY ITEMS WERE NOT IDENTIFIED AND CORRECTED.

Mileage: 124,800

DRIVING DOWN THE ROAD AT 35 MPH THE CAR SUDDENLY DIES, LEAVING ME NO POWER TO ESCAPE A POSSIBLE ACCIDENT, BRAKES ARE HARD TO USE, STUCK IN A TRAFFIC LANE WITH CARS COMING UP ON ME AT 35 TO 45 MPH, TURNS OUT THE HPFP EXPLODED SENDING METAL THRU OUT THE FUEL SYSTEM CAUSING THE ENGINE TO STARVE FOR FUEL AND STALL OUT, WITH NO FUEL GETTING TO THE ENGINE THE MOTOR WONT RESTART CAUSING A LIFE THREATENING SITUATION

Mileage: 80,200

STARTED THE CAR AND AFTER ABOUT 5 MINUTES OF DRIVING, THE ENGINE SHUTS OFF BUT ALL ELECTRICAL SYSTEMS APPEAR TO BE WORKING. NO TROUBLE/ INDICATOR LIGHTS COME ON. THIS HAS HAPPENED ON THE INTERSTATE TRAVELING 70, ON A SIDE STREET TRAVELING 35, AND SITTING IDLE AT A STOP LIGHT. EVERY TIME, THE CAR WILL RUN FOR BETWEEN 5-7 MINUTES THAN NOT RESTART FOR 5-7 MINUTES. AT ATTEMPTS TO RESTART INSIDE THAT 5 MINUTE WINDOW AFTER THE ENGINE STALLS, THERE IS NO TURNING OVER, NO CLICKING OR ANYTHING. THERE IS NO TEMP ISSUES, OR LOW FUEL ISSUES. THIS HAS HAPPENED ON A FULL TANK AND A HALF TANK ALSO. *TR

Mileage: 196,000

WHILE DRIVING ON THE HIGHWAY, THE CHECK ENGINE LIGHT CAME ON AND THE CAR BEGAN SLOWING ITSELF DOWN. WHEN I TRIED TO ACCELERATE THE ENGINE REVVED AND THE RPM INDICATOR WENT UP BUT THE CAR WOULD NOT SPEED UP PAST 45 MPH AND THE STEERING WHEEL SHOOK VERY HARD THE REST OF THE WAY. WHEN I TOOK IT FOR DIAGNOSTICS AND REPAIR, THE CODES P2431 AND P2432 INDICATED A FAULTY SENSOR IN THE AIR INJECTION SYSTEM PRESSURE SENSOR. I WAS TOLD THAT VOLKSWAGON WAS AWARE OF THE PARTICULAR PROBLEM, WHICH HAS OCCURRED IN A HIGH NUMBER OF VEHICLES AND THEY IN FACT RECOMMENDED AN UPDATED VERSION OF THE INJECTION HOSE AND SENSOR. THIS WAS A $350 REPAIR ON A VEHICLE WITH LESS THAN 30,000 MILES AND ACCORDING TO VOLKSWAGON A COMMON REPAIR. I DON'T THINK IT'S FAIR THAT CONSUMERS SHOULD ABSORB THE COST OF THIS TYPE OF REPAIR.

Mileage: 29,748

VEHICLE ENGINE SHUT OFF DURING TRAVEL, DUE TO FUEL FILTER BEING CLOGGED BY METAL DEBRIS. THE HIGH PRESSURE INJECTION PUMP FAILED EFFECTIVELY ENDING THE LIFE OF THE ENGINE. THE WELDS ON THE HIGH PRESSURE INJECTION PUMP HAD DETERIORATED, RESULTING METAL DEBRIS TO CIRCULATE THROUGH COMPLETE INJECTION SYSTEM. AFTER MULTIPLE FAILED ATTEMPTS TO FLUSH OUT THE INJECTION SYSTEM IT WAS DECIDED THAT THE BEST COURSE OF ACTION WAS TO REPLACE THE ENGINE IF A REPLACEMENT COULD BE FOUND. A REPLACEMENT WAS FOUND AND THE CURRENT ENGINE INSTALLED HAS THE SAME HIGH PRESSURE INJECTION PUMP, AS A REPLACEMENT PART IS NOT AVAILABLE TO INDEPENDENT SHOPS, ONLY TO DEALERSHIPS. COST OF REPLACING ENGINE - $8,500.00. *TR

Mileage: 228,834

2009 VOLKSWAGEN - JETTA TDI - 2L, IN-LINE4 (120CL) DIESEL * A PREVIOUS CLAIM WAS SUBMITTED LACKING INFORMATION, PLEASE DISREGARD. VEHICLE ENGINE SHUT OFF DURING TRAVEL, DUE TO FUEL FILTER BEING CLOGGED BY METAL DEBRIS. THE HIGH PRESSURE INJECTION PUMP FAILED EFFECTIVELY ENDING THE LIFE OF THE ENGINE. THE WELDS ON THE HIGH PRESSURE INJECTION PUMP HAD DETERIORATED, RESULTING METAL DEBRIS TO CIRCULATE THROUGH COMPLETE INJECTION SYSTEM. AFTER MULTIPLE FAILED ATTEMPTS TO FLUSH OUT THE INJECTION SYSTEM IT WAS DECIDED THAT THE BEST COURSE OF ACTION WAS TO REPLACE THE ENGINE IF A REPLACEMENT COULD BE FOUND. A REPLACEMENT WAS FOUND AND THE CURRENT ENGINE INSTALLED HAS THE SAME HIGH PRESSURE INJECTION PUMP, AS A REPLACEMENT PART IS NOT AVAILABLE TO INDEPENDENT SHOPS, ONLY TO DEALERSHIPS. COST OF REPLACING ENGINE - $8,500.00. *TR

Mileage: 228,834

WE WERE DRIVING ON DOWN THE ROAD AND THE CARS LIGHTS STARTED BLINKING AND THEN CAR STOP RUNNING AND STOPPED DEAD IN THE ROAD. COULD NOT GET IT STARTED AGAIN. IF IT HAD BEEN ON THE FREEWAY I AM SURE I WOULD NOT BE TYPING THIS WE WOULD BE IN HOSPITAL OR WORSE. WE HAD TO GET OUT AND THE STEERING WAS NOT WORKING TO GET IT TO SIDE OF ROAD. I AM ELDERLY AND DO NOT HAVE ALOT OF STRENGTH. WE HAD TO PAY EXTRA TO AAA TO TOW IT SINCE WE WERE FAR AWAY FROM DEALER. THE DEALER CALLED AND SAID THERE WAS METAL SHAVINGS IN FUEL LINE AND COMPONENTS. I RESEARCHED ONLINE AND HAVE SEEN SEVERAL OF THE SAME THINGS HAPPENING TO OTHER CARS. THIS IS A REAL SAFETY ISSUE. PLEASE HELP FIX BEFORE SOMEONE DIES HTTP://WWW.CARPROBLEMZOO.COM/VOLKSWAGEN/JETTA/2009/CAR-STALL-PROBLEMS.PHP CAR STALL PROBLEM 2 FAILURE DATE: 10/25/2012 WHILE DRIVING THE DASH WARNING LIGHTS ILLUMINATED AND THE CAR STALLED CAUSING COMPLETE LOSS OF ALL POWER STEERING ALMOST CAUSING ME TO LOSE CONTROL AND WRECK. I WAS ABLE TO STEER CAR TO SIDE OF ROAD AND STOP. ONCE STOPPED WAS ABLE TO GET CAR TO RESTART BUT WAS BARELY ABLE TO DRIVE HOME (PERIODICALLY DIED AND HAD TO RESTART, WOULDN'T STAY RUNNING OR IDLE). HAD CAR TOWED TO REPAIR SHOP. THEY HAVE DIAGNOSED PROBLEM AS LOW RAIL FUEL PRESSURE CAUSED BY FAILED HIGH PRESSURE FUEL PUMP. THIS FAILURE CAUSED METAL SHAVINGS TO BE DISPERSED THROUGHOUT ENTIRE FUEL SYSTEM. I'M TOLD THAT THE HP FUEL PUMP, LOW AND HIGH PRESSURE FUEL REGULATORS, AND TANK FUEL PUMP ALL MUST BE REPLACED ALONG WITH A COMPLETE REMOVAL AND CLEANING OF ALL FUEL SYSTEM COMPONENTS. ESTIMATED COST TO REPAIR IS BETWEEN $7,000 AND $10,000. THIS CAR IS A DIESEL TDI. *TR

Mileage: 102,000

I WAS DRIVING OUR 2009 VOLKSWAGEN JETTA SPORTSWAGEN TDI ON THE HIGHWAY WHEN THE GLOW LIGHT CAME ON. I STOPPED THE CAR AND THE ENGINE STOPPED WORKING AND STARTED SMOKING. THE DEALER SAID THAT THE ENGINE HAD SEIZED BUT DID NOT KNOW THE REASON. ACCORDING TO THE DEALER THE ENGINE WILL HAVE TO BE REPLACED. THE VEHICLE HAS HAD ALL OF THE RECOMMENDED SERVICES WHICH WERE DONE BY THE DEALER INCLUDING ALL OF THE OIL CHANGES. *TR

Mileage: 105

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE CHECK ENGINE AND THE ELECTRONIC POWER CONTROL WARNING LIGHTS ILLUMINATED. IN ADDITION, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

Mileage: 50,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE CONTACT ALSO STATED THAT THE CHECK ENGINE AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE INJECTOR CIRCUIT IN CYLINDER 1 FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.

Mileage: 65,000

I AM "GUESSING AT SOME OF THE INFORMATION ABOVE SINCE IT WAS THE FIRST TIME IT HAPPENED AND I DIDN'T GIVE IT MUCH THOUGHT THEN. AT THAT TIME, I WAS MAKING A RIGHT-HAND TURN TO ANOTHER STREET AND THE ENGINE STALLED. THERE WAS NO WARNING LIGHT OR SIGNAL. I PULLED OVER TO THE SIDE OF THE ROAD, RESTARTED THE ENGINE AND IT WORKED FINE. THIS OCCURRED SOMETIME IN MID TO LATE SEPTEMBER. YESTERDAY (12/24/2014) I WAS AT A STOPLIGHT AND THIS HAPPENED AGAIN -- THE ENGINE STALLED WHILE I WAS ALREADY STOPPED WHILE WAITING FOR THE LIGHT TO CHANGE FROM RED TO GREEN. AGAIN, THERE WAS NO WARNING LIGHT OR SIGNAL. IT WAS REMNISCENT OF WHEN I DROVE A STANDARD TRANSMISSION VEHICLE AND INAPPROPRIATELY TOOK MY FOOT OFF THE CLUTCH. I WAS ABLE TO RE-START AND ENGINE RAN FINE. I AM LEERY OF DRIVING THE CAR AGAIN, HOWEVER, FOR FEAR THAT THIS WILL HAPPEN AGAIN. I PLAN TO TAKE TO MY MECHANIC ASAP. READING THE DESCRIPTIONS OTHERS HAVE HAD WITH THIS ISSUE ARE VERY SIMILAR TO MINE. I HAVE KEPT UP WITH MAINTENANCE AND CARE OF THE VEHICLE AND IT HAS LESS THAN 25K MILES ON IT. *TR

Mileage: 23,500

DRIVING DOWN FREEWAY AT 61MPH, ENGINE TURNS OFF. NO POWER STEERING OR BRAKES WHILE I CHANGED LANES IN HEAVY TRAFFIC TO GET TO THE SHOULDER OF THE ROAD. CAR WOULD NOT START AND HAD TO TOW TO THE DEALERSHIP. DEALER REPLACED BATTERY, PRIMED FUEL SYSTEM, GAVE CAR BACK. AFTER FIVE DAYS, CHECK ENGINE LIGHT CAME ON, SO I TOOK CAR TO DEALERSHIP. THEY REPLACED GLOW PLUG CONTROL MODULE AND GAVE CAR BACK. DRIVING DOWN HIGHWAY WHEN CAR AGAIN DIES, ENGINE TURNS OFF WITHOUT WARNING. I HAVE TO CHANGE LANES AGAIN WITH NO POWER STEERING OR BRAKES TO GET OFF THE ROAD. TOWED VEHICLE TO DEALERSHIP WHERE THEY SAY THE HIGH PRESSURE FUEL PUMP NEEDS TO BE REPLACED. THIS IS A VERY SCARY AND DANGEROUS PROBLEM TO HAVE A CAR TURN ITSELF OFF WHILE DRIVING DOWN THE FREEWAY. *TR

Mileage: 122,825

2009 VOLKSWAGEN JETTA TDI WITH DSG TRANSMISSION WITH 67,000MILES WHILE ACCELERATING TO ROADWAY SPEED THE VEHICLE BEGAN HESITATING FOLLOWED BY A DRAMATIC LOSS OF POWER AND STRUGGLED TO ACCELERATE AT ALL. GLOW PLUG LIGHT BEGAN FLASHING AND CHECK ENGINE LIGHT CAME ON AFTER ABOUT 1 MINUTE. DRAMATIC LOSS OF POWER COULD HAVE RESULTED IN CRASH. VOLKSWAGEN DEALER DIAGNOSED THE ISSUE AS A DEFECTIVE CRANK SHAFT POSITION SENSOR WHICH COULD ONLY BE REPLACED AT A COST OF OVER $2,000 DUE TO THE IN ACCESSIBILITY OF THE SENSOR AND NEEDING TO UNINSTALL AND RE-INSTALL THE ENGINE. *TR

Mileage: 67,000

AFTER NUMEROUS ATTEMPTS BY DEALER TO FIX ENGINE LIGHT INDICATOR (3 ATTEMPTS IN 5 DAYS) SAID MAF PART BAD AS PER COMPUTER CODES. *TR

Mileage: 51,100

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED AND THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

Mileage: 115,000

FOR THE PAST YEAR OR SO MY 2009 JETTA TDI (DIESEL) HAS HAD THE SAME RECURRING PROBLEM: MY GLOW PLUG LIGHT WILL COME ON AND I LOSE NORMAL DRIVING CAPABILITIES. I CANNOT ACCELERATE OR MAINTAIN SPEED AS I NORMALLY DO. MY CAR WILL REMAIN AROUND 25 MPH, SOMETIMES LOSING POWER UNTIL I AM FORCED TO PULL OVER. MY SOLUTION HAS BEEN TO TURN THE CAR OFF, AND BACK ON AGAIN. THE LIGHT WILL GO OFF AND I CAN DRIVE NORMALLY MOST OF THE TIME. SOMETIMES I HAVE TO LEAVE THE CAR OFF FOR A PERIOD OF TIME TO REGAIN STANDARD DRIVING CAPABILITIES. IT HAS BEEN ABOUT 2 WEEKS SINCE THAT HAS HAPPENED. 2 DAYS AGO, MY ENGINE LIGHT CAME ON. I TOOK IT TO THE DEALER AND THEY PULLED CODES P0087 AND P0088 (FUEL PRESSURE TOO HIGH AND FUEL PRESSURE TOO LOW AT THE SAME TIME). THEY WANT ME TO REPLACE THE FUEL RAIL, WHICH WILL BE AN ESTIMATED $1000 IN TOTAL PARTS/LABOR. I CALLED ANOTHER DEALER IN HOPES OF GETTING A BETTER PRICE AND THEY ARE PUT OFF BY THE FIRST DEALER'S RECOMMENDATIONS. I WAS TOLD THERE IS NO EVIDENCE OF METAL IN MY FUEL SYSTEM BUT EVEN SO, OTHER DEALER THINKS THIS WILL BE MORE SERIOUS THAN JUST REPLACING THE RAIL. AFTER RESEARCHING I AM BEGINNING TO THINK THAT I AM EXPERIENCING THE BEGINNING OF HPFP FAILURE. I FEEL LIKE I AM DRIVING A TICKING TIME BOMB AND I'M NOT SURE WHAT TO DO! REPLACING THE FUEL RAIL FEELS LIKE A QUICK, EXPENSIVE AND INEFFICIENT SOLUTION TO A BIGGER PROBLEM. I CONTACTED VOLKSWAGEN CUSTOMER CARE AND I WAS TOLD THAT I WILL RECEIVE A CALL FROM A REGIONAL AGENT ABOUT MY SITUATION TOMORROW. *TR

Mileage: 66,586

DRIVING ON A BUSY 4 LANE ROAD MY CAR SUDDENLY STOPPED JUST FLASHED A FEW LIGHTS ON THE PANEL FOR FEW SECONDS. THE CAR WOULD NOT START. COULD NOT BE MOVED LUCKY THAT THERE WERE NO INJURIES. THE VEHICLE TOWED TO VW DEALER, BASIL VW AT LOCKPORT AND WAS TOLD THAT THE HIGH PRESSURE FUEL PUMP EXPLODED. CAUSED EXTENSIVE DAMAGE REQUIRING NUMEROUS COMPONENTS, WITH A TOTAL COST OF ABOUT $7,000.00 THE CAR WAS SERVICE BY A VW DEALER OR BY A REPAIR SHOP OWNED BY AAA OF WNY LOCATED AT CLARENCE NY. THIS CAME ON WITH OUT A WARNING, WAS NOT INFORMED ABOUT THIS PROBLEM. HAD OWNED DIESEL CARS SINCE 1977 AND DID NOT FACE ANY SUCH PROBLEM OR HEAR OF SUCH A PROBLEM. *TR

Mileage: 112,000

TIMING CHAIN TENSIONER FAILED RESULTING IN ENGINE FAILURE. *TR

Mileage: 92,000

THE CAR WAS RUNNING FINE UP TO THE TIME IT QUIT. IT STALLED IN A PUDDLE AFTER 7 DAYS OF RAIN SO I ASSUMED IT HAD GOTTEN WATER IN THE SYSTEM SOMEHOW. I HAD IT TOWED TO MY LOCAL MECHANIC. HE IN TURN CALLED THE DEALER WHO SAID THEY WERE UNABLE TO SELL HIM THE PARTS FOR THE REPAIR AND THAT I NEEDED TO HAVE IT TOWED TO THEM. I HAVE SINCE BEEN TOLD THE REPAIR WORK WILL BE BETWEEN 8 AND 10 THOUSAND DOLLARS TO REPLACE THE DIESEL FUEL SYSTEM! I TOLD THEM TO HOLD OFF SO THAT I CAN WAY MY OPTIONS. I HAVE SINCE VERIFIED THAT INDEED THE HIGH PRESSURE FUEL PUMP HAD DISINTEGRATED AND DESTROYED THE FUEL SYSTEM. *TR

Mileage: 114,000

AFTER IDLING FOR APPROX 5 MINUTES ON A HOT AFTERNOON (95F), I TRIED TO ACCELERATE THE VEHICLE AND IMMEDIATELY FELT A SPUTTERING FROM THE ENGINE. THE ENGINE LIGHT CAME ON AND THEN THE EPC LIGHT; THE VEHICLE STARTED TO LOSE POWER. AFTER TURNING OFF THE ENGINE FOR A FEW MINUTES AND RESTARTING, THE VEHICLE WAS STILL SPUTTERING HOWEVER WE WERE ABLE TO DRIVE IT HOME APPROX 10 MILES ON A CITY STREET. THE VEHICLE WOULD NOT ACCELERATE OVER 20 MPH. AFTER TAKING TO THE DEALERSHIP THEY ADVISED THAT AN ENGINE COIL HAD FAILED AND NEEDED TO BE REPLACED. THE INCIDENT OCCURRED AGAIN 5 MONTHS LATER WITH THE SAME CONCLUSION FROM THE MECHANIC. *TR

Mileage: 49,035

THE WATER PUMP FAILED AT APPROXIMATELY 70 MPH. THE IMPELLER CAME OFF OF THE SHAFT INSIDE OF THE PUMP BECAUSE OF A POOR DESIGN(PLASTIC). THIS CAUSED THE VEHICLE TO OVERHEAT. WENT AHEAD AND HAD THE TIMING BELT DONE ALSO. COST OF REPAIR WAS $1131.87. *TR

Mileage: 79,552

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. WHILE THE VEHICLE WAS IDLING AND ATTEMPTING TO ACCELERATE, THE CONTACT HEARD AN ABNORMAL NOISE AND THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000.

Mileage: 57,000

DRIVING ON MY WAY HOME FROM WORK IN TOWN AND ALL OF A SUDDEN THE GLOW PLUG LIGHT COMES ON FLASHING AND THE ENGINE LIGHT APPEARS ON THE DASH. I IMMEDIATELY TURNED OFF THE CAR RESTARTED THE CAR AND THE PROBLEM WAS NOT RESOLVED AND A MESSAGE APPEARED ON THE SASH "ENGINE FAULT WORKSHOP!". HPFP FAILURE. *TR

Mileage: 120,000

WHILE DRIVING ON FREEWAY CAR COMPLETELY SHUT-OFF. COASTED TO OFF-RAMP, STOPPED CAR AND THEN RE-STARTED IT. DEALER LATER DIAGNOSED IGNITION SWITCH PROBLEM (INTERMITTENT IGNITION SWITCH FAULTS LOGGED) AND RECOMMENDED REPLACEMENT OF THE IGNITION SWITCH. *TR

Mileage: 81,000

SUNRISE V.W. HAD MY 2009 JETTA TDI IN THEIR SHOP YESTERDAY, AND AFTER DIAGNOSTICS INFORMED ME THAT I NEEDED BOTH COOLING FANS, AND THE INTAKE MANIFOLD REPLACED. I HAVE GEICO MECHANICAL BREAK DOWN INSURANCE. THE ADJUSTER ONLY APPROVED THE REPLACEMENT OF THE COOLING FANS. ON THE WAY HOME MY CHECK ENGINE LIGHT CAME ON, I HEARD A POP SOUND FROM THE ENGINE, AND LOST ALL OF THE CARS POWER. THIS LOSS OF POWER HAPPENED WHILE TRAVELING IN TRAFFIC AT ABOUT 30 MPH. I BELIEVE THE INTAKE MANIFOLD FAILED, AND CAUSED THE LOSS OF ENGINE POWER. THE CAR WAS THEN TOWED BACK TO SUNRISE V.W. *TR

Mileage: 79,280

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH, THE VEHICLE DECELERATED TO 30 MPH. THE GLOW PLUG ON THE DASH ILLUMINATED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE IMPELLER SHAFT ON THE TURBO NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 42,000 AND THE CURRENT MILEAGE 42,000.

Mileage: 42,000

THE CAR BEGAN TO FLASH THE "GLOW PLUG" WARNING LIGHT ALONG WITH A MESSAGE "ENGINE FAULT WORKSHOP" PULLED TO THE SIDE OF THE ROAD AND ATTEMPTED TO RESTART. ENGINE WOULD CRANK BUT NOT TURN OVER. GOT THE FOLLOWING FAILURE CODES: P0087, P13E3, P2196. LOOKS LIKE THIS IS A COMMON ISSUE AND YET VW DOES NOTHING ABOUT IT. CLASS ACTION ANYONE?. *JS

Mileage: 137,000

FUEL SYSTEM WAS FLUSHED AND REPLACED. AFTER THAT THE TOP OF THE ENGINE WAS LEAKING OIL. I TOOK IT BACK TO VW IN CLARKSVILLE TN. THEY SAID THEY FIXED IT. IT IS STILL LEAKING OIL JUST NOT AS BAD. THEN THE CAR WAS SMOKING AND BURNING/LEAKING OIL FROM THE TURBO. VW DID NOT WANT TO FIX THIS UNDER WARRANTY. EVEN THOUGH I HAD TAKEN THIS CAR IN SEVERAL TIMES BEFORE FOR A CHECK ENGINE LIGHT THAT KEPT BRINGING UP THE EGR. *TR

Mileage: 102,000

THE DEALERSHIP STATED IT WAS A WARPED DUAL MASS FLYWHEEL. THEY REPLACED IT AND IT IS STILL KNOCKING. A SECOND DEALERSHIP SAID THAT IT IS STILL KNOCKING BECAUSE THE DUAL MASS FLYWHEEL IS BAD. IT CAUSES THE CLUTCH TO SHIFT HARD AND ACCELERATION TO BE AN ISSUE. I DO NOT FEEL COMFORTABLE TRAVELING ON THE HIGHWAYS. *TR

Mileage: 25,000

CAR SUDDENLY DIED AND WILL NOT RE-START. ENGINE TURNS OVER, BUT THAT'S IT. I SUDDENLY LOST POWER AND HAD TO COAST TO THE SHOULDER WHICH WAS VERY DIFFICULT BECAUSE THE CAR DECELERATED VERY QUICKLY AND THERE WAS NO POWER STEERING. LUCKILY THIS HAPPENED VERY EARLY IN THE MORNING AND TRAFFIC WENT AROUND ME. *TR

Mileage: 60,000

MY JETTA LOST POWER FROM GOING 60MPH TO 35-40 AND AFTER A MIN IT SHUT DOWN ON HIGHWAY. I MANAGED TO PUSH IT ON A SHOULDER AND TRIED TO START AGAIN BUT NOTHING HAPPENED. I TOWED IT AWAY TO MECHANIC AND FOUND OUT THAT MY HIGH PRESSURE FUEL PUMP SHATTERED AND RELEASED BUNCH OF TINY METAL PEACES IN TO THE FUEL FILTER AND ENGINE. MECHANIC TOLD ME THAT IT HAPPENED BECAUSE OF A DESIGN FLAW WITH THE PUMP THAT VW ADMITTED BUT HAVEN'T DONE ANYTHING ABOUT THAT. SO I'M WONDERING WHAT IF A SEMI TRUCK CAME AT THE SAME TIME AND HIT ME WOULD THEY DO SOMETHING ABOUT IT THEN? *TR

Mileage: 7,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS FOUND THAT THE HIGH PRESSURE PUMP WAS DEFECTIVE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 46,900. UPDATED 07/03/14 MA UPDATED 07/11/2014 *JS

Mileage: 46,900

2009 VW JETTA TDI UNABLE TO START THE VEHICLE IT WOULD CRANK BUT WILL NOT START. THE VEHICLE WAS TOWED TO THE VW DEALER AND THEY SAID THAT THE FUEL PUMP IN THE FUEL TANK FAILED. THE PUMP IN THE TANK WAS REPLACED AND STILL WILL NOT START. THE DEALER THEN SAID THAT THE HPFP HIGH PRESSURE FUEL PUMP ON THE ENGINE WAS BAD. THEY CHANGED THE PUMP AND STILL WILL NOT START. THE DEALER DOES NOT KNOW WHAT IS WRONG WITH THE VEHICLE AT THIS TIME. THEY CALLED THEIR TECH LINE AWAITING AN ANSWER. I BELIEVE THIS IS A HIGH PRESSURE FUEL PUMP FAILURE ISSUE THAT IS A KNOWN ISSUE AND WELL TALKED ABOUT ON THE VW TDI FORUMS. IF THIS IS THE ISSUE THE PUMPS AND ANY REPAIRS SHOULD BE WARRANTIED FOR THE LIFE OF THE VEHICLE AS LONG AS YOU OWN THE VEHICLE SINCE IT WAS PURCHASED NEW FROM THE DEALER. *TR

Mileage: 57,690

THE VEHICLE'S ENGINE STALLED WHILE TRAVELING DOWN THE ROADWAY AT APPROXIMATELY 35 MPH. THE VEHICLE'S ELECTRICAL SYSTEM CONTINUED TO OPERATE (DRIVING LIGHTS, INTERIOR LIGHTS, POWER STEERING AND POWER BRAKES) DURING THIS TIME. ENGAGED EMERGENCY FLASHERS AND COASTED VEHICLE TO A STOP AT THE NEAREST PARKING LOT. AFTER PLACING TRANSMISSION INTO PARK, VEHICLE RESTARTED WITH NO FURTHER INCIDENT. *TR

Mileage: 71,000

WHEN COMING TO STOP AT A RED LIGHT, THERE WAS AN ENGINE FAULT WORKSHOP WARNING MESSAGE AND A BLINKING YELLOW GLOW PLUG WARNING LIGHT. WHEN THE LIGHT TURNED GREEN, THE CAR FELT SLUGGISH, NEEDING EXTRA THROTTLE THAN USUAL TO GET TO 35MPH. AFTER STOPPING AT THE NEXT RED LIGHT, THE CAR WAS STUCK IN FIRST GEAR (ONLY 30 SECONDS AFTER THE WARNING LIGHT), AND I COULD ONLY GET TO 10MPH IN A 35MPH ZONE. TURNING ON MY HAZARD BLINKERS, I WAS LUCKY THAT THERE WAS A DEDICATED LEFT TURN LANE INTO A PARKING LOT, OTHERWISE I WOULD NOT HAVE BEEN ABLE TO SAFELY PULL OVER TO THE RIGHT SHOULDER FROM THE LEFT LANE BEFORE THE ENGINE DIED. *TR

Mileage: 55,318

I WAS STUCK ON A BUSY INTERSECTION BECAUSE MY CAR WOULDN'T LOCK ONTO THE GEAR. ALL GEARS ON THE CONTROL PANEL WHERE FLASHING. UPON LATER RESEARCH, I WAS TOLD THAT THE DSG GAVE A FALSE-NEUTRAL. *TR

Mileage: 56,218

I DROVE HOME FROM WORK ON 9/28/2013 GOT OFF THE FREEWAY, CAME TO A STOP AT END OF OFFRAMP AND THE FIRST WARNING LAMP CAME ON INDICATING A GLOW PLUG FAILURE. IT CONTINUED TO RUN AND I DROVE TO A NEARBY PARKING LOT AT APPROX. 50% POWER, PARKED, CYCLED THE IGNITION FROM ON TO OFF AND BACK ON AGAIN. THIS CLEARED THE FAULT TEMPORARILY, I DROVE TOWARD HOME AND WITHIN ANOTHER 2 MILES THE SAME GLOW PLUG FAULT RETURNED ALONG WITH THE CHECK ENGINE SYMBOL AND A WARNING INDICATING WORKSHOP WAS NEEDED. THE FOLLOWING DAY I BOUGHT A CODE READER, READ THE CODES AND FOUND SEVERAL LOGGED, SOME OF WHICH IM CERTAIN WERE RESIDUAL FAULTS FROM THE ACTUAL CAUSE OF THE FAILURE WHICH WAS INDICATED BY A RECURRING "LOW FUEL RAIL PRESSURE" FAULT. I HAVE CALLED THE DEALER WHICH INSTRUCTED ME TO LOOK AT THE FUEL FILTER AND AIDED BY AN ONLINE TECH INFO BLOG I INSPECTED THE HIGH PRESSURE FUEL PUMP ACTUATOR FOR METAL DEBRIS. THE FUEL FILTER INSPECTION SHOWED SMALL, TRACE AMOUNTS OF METAL DUST WHILE THE FUEL PUMP INSPECTION SHOWED LARGER AND MORE SUBSTANTIAL METAL SHAVINGS UNDER THE ACTUATOR. THE INSPECTION OF THE TWO COMPONENTS ARE INDICATIVE AND INLINE WITH SIMILAR FINDINGS THAT PROVE HIGH PRESSURE FUEL PUMP FAILURE, IT SHOULD BE NOTED THAT NO TRACE OF GASOLINE WAS FOUND IN THIS SYSTEM AND ONLY CLEAN DIESEL FUEL WAS PRESENT DURING INSPECTION. FUEL FILTER WAS JUST CHANGED IN AUG 20 2013 AT SAME TIME AS TIMING BELT WHERE HPFP DRIVE GEAR WAS RETORQUED. I NOW HAVE A CAR THAT IS NOT FUNCTIONAL AND I'M NOT HAPPY. I BOUGHT A DIESEL FOR LONGEVITY AND HIGH FUEL ECONOMY NOT THIS. *TR

Mileage: 122,852

CAR IS A JETTA TDI (DIESEL ENGINE). ENGINE WARNING LIGHT APPEARED WHILE DRIVING, APPROXIMATELY 50 YARDS LATER WHILE SLOWING DOWN THE ENGINE FAILED AND WOULD NOT RESTART. CAR WAS STOPPED AT INTERSECTION ON A BUSY 5 LANE ROAD AT 5:30 PM WITH CARS COMING FROM BEHIND AND AROUND AT SPEEDS OF 45+ MPH. SHERIFF CAME TO DIVERT TRAFFIC TO PREVENT A WRECK AND ALLOW TOW TRUCK TO TOW CAR SAFELY. DEALER STATES THAT HIGH PRESSURE FUEL PUMP FAILED, RUINING FUEL SYSTEM, QUOTES POTENTIAL REPAIR COST OF $8,500. FILLED FUEL TANK 5 MILES PRIOR TO INCIDENT WITH 11 GALLONS OF DIESEL FUEL (REPUTABLE FUEL DEALER, ALMOST ALWAYS USE THIS DEALER). THERE WAS NO WARNING PRIOR TO THE INCIDENT -- NO ROUGH ENGINE OR STALLING OR TROUBLE OF ANY KIND. CAR IS DRIVEN BY ONLY ONE DRIVER AND IS WELL MAINTAINED, HAS NEVER BEEN FUELED WITH ANYTHING BUT DIESEL FROM REPUTABLE DEALERS. CAR IS USUALLY DRIVEN ON THE FREEWAY (DEALER RECOMMENDED IT SPECIFICALLY FOR A LONG FREEWAY COMMUTE). LUCKY THAT IT DIDN'T STALL AT HIGH SPEED ON FREEWAY. *TR

Mileage: 81,000

THE EXHAUST FLAP IS STICKING IN THE OPEN POSITION, THUS CAUSING WARNING LIGHT ON DASH TO COME ON. *TR

Mileage: 140,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER AND TO A MECHANIC, WHO DETERMINED THAT ONE OF THE PRESSURE SENSORS IN THE EXHAUST SYSTEM HAD FAILED. THE DEALER REPLACED BOTH SENSORS BECAUSE IT WAS IMPOSSIBLE TO REPLACE JUST ONE. THE MECHANIC SPOKE WITH THE MANUFACTURER, BUT WAS TOLD THAT THERE WAS NOT A REPAIR AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 143,000. *TR

Mileage: 143,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE AIR SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 22,000. *TR

Mileage: 22,000

VEHICLE BEGAN STALLING AT STOPS AT ABOUT 55000 MILES. VEHICLE AT COMPLETE STOP, TAKE FOOT OF BRAKE AND IT EITHER (1) ROLLS THEN MOVES FORWARD, (2) LURCHES/SHUTTERS AND MOVES FORWARD OR (3) STALLS BEFORE PUTTING FOOT ON GAS. THE STALLING HAS BECOME MORE FREQUENT IN THE LAST MONTH AND ON MAY 31 2013, THE VEHICLE STALLED MULTIPLE TIMES AND ON ONE OCCASION DID NOT RESTART AFTER APPROXIMATELY HALF DOZEN ATTEMPTS BUT FINALLY MANAGED TO RESTART. THE VEHICLE IS GOING IN FOR SERVICE TO HOPEFULLY IDENTIFY AND FIX THIS ISSUE ON JUNE 3 2013. THE LURCHING FORWARD CAN BE DRASTIC AND THE POTENTIAL FOR "JUMPING" FORWARD INTO ANOTHER CAR AND CAUSING AN ACCIDENT IS NOW A REAL CONCERN. *TR

Mileage: 55,000

MY ENGINE CHECK LIGHT CAME ON, FOLLOWED BY THE GLOW PLUG LIGHT AND THEN MY ENGINE STALLED AND DIED 30 SECS LATER. MY HAZARD LIGHTS, DASHBOARD LIGHTS, ETC FUNCTIONED, BUT I COULD NOT BRING THE ENGINE BACK TO LIFE. POLICEMAN SUGGESTED IT MAY BE A FUEL PUMP, BECAUSE WHEN I TRIED THE ACCELERATOR PEDAL WHILE TRYING TO START THE CAR, IT DID NOT HELP. I HAD 3/4 TANK OF DIESEL STILL IN MY TANK AND I ALWAYS FILL AT THE SAME PUMP WHICH HAS A YELLOW HANDLE AND SAYS "DIESEL" AND I AM THE ONLY ONE WHO HAS FILLED THE TANK ON THIS VEHICLE. *TR

Mileage: 65,500

WE WERE DRIVING OUR 2009 VOLKSWAGEN JETTA TDI DOWN THE HIGHWAY AT 65MPH ON FRIDAY MAY 24, 2013 WHEN SUDDENLY THE CAR BEGAN TO SHAKE AND SHUDDER VIOLENTLY. IT WAS VERY SCARY AND THEN IT SEEMED THAT THE POWER WAS COMING IN AND OUT. BECAUSE OF THE SUDDEN SHAKING AND LOSS OF POWER, I HAD TO VERY QUICKLY PULL TO THE SIDE OF THE ROAD, TO AVOID CAUSING AN ACCIDENT ON A HEAVILY CONGESTED HIGHWAY ON A HOLIDAY WEEKEND. THE VEHICLE IS ALWAYS SERVICED BY THE DEALERSHIP (INCLUDING ALL OIL CHANGES) AND IS UP TO DATE ON ALL PERTINENT MAINTENANCE. THE DEALERSHIP HAS DIAGNOSED THE VEHICLE WITH A FAILED HIGH PRESSURE FUEL PUMP (HPFP) AND HAS ACCUSED US OF SOMEHOW ALLOWING METAL INTO THE DIESEL FUEL (THEY EVEN HAD SOME METAL "SAMPLES" TO SHOW ME AT THEIR SERVICE COUNTER, HOW BIZARRE). I WENT BACK TO THE FUEL STATION WHERE WE LAST FILLED UP AND SPOKE TO THE MANAGER, WHO SAID THERE HAVE BEEN NO REPORTS OF ANY ISSUES RELATED TO CONTAMINANTS OF ANY KIND IN THEIR DIESEL FUEL. WE ARE STUCK WITH A $6,000 BILL FOR A DEALER-MAINTAINED CAR THAT HAS ~83,000 MILES ON IT AND IS JUST OVER 3 YEARS OLD, IN ADDITION TO THE FRIGHT OF A VIOLENT LOSS OF THE VEHICLE'S POWER, AT HIGHWAY SPEEDS. *TR

Mileage: 83,500

ON WEDNESDAY 5/22/13 I WAS DRIVING MY 2009 VW JETTA TDI AT ABOUT 45MPH WHEN ALL THE SUDDEN THE CHECK ENGINE LIGHT CAME ON, THE GLOW PLUG LIGHT STARTED FLASHING, AND ENGINE FAULT WORKSHOP CAME UP ON MY DISPLAY. THE CAR LOST POWER AND WASN'T RUNNING RIGHT. I IMMEDIATELY STOPPED THE CAR AND CALLED MY LOCAL VW DEALERSHIP TO SEE IF THE CAR WAS SAFE TO DRIVE. (WARNING IF THIS HAPPENS TO YOU DO NOT DRIVE THE CAR NO MATTER WHAT THE DEALERSHIP SAYS!!!!!) THE VW DEALERSHIP SAID IT WAS SAFE TO DRIVE THE CAR TO THE DEALERSHIP SINCE ALL THE WARNING LIGHTS WHERE ORANGE AND NOT RED. THE CAR HAD VERY LOW POWER WHILE DRIVING TO THE DEALERSHIP AND EVENTUALLY DIED. I THEN TOWED THE CAR TO THE DEALERSHIP AND AFTER 2 DAYS GOT THE DREADED CALL THAT THE HPFP(HIGH PRESSURE FUEL PUMP) HAD FAILED AND SENT METAL SHRAPNEL THROUGHOUT THE ENTIRE FUEL SYSTEM . VW IS TELLING ME THIS IS GOING TO COST ME $7,000 TO FIX WHICH IS ABSOLUTELY ABSURD SINCE VW IS VERY AWARE OF THIS PROBLEM AND HAS COVERED THE COSTS FOR OTHER PEOPLE WHEN THIS HAS HAPPENED. I DON'T THINK IT IS RIGHT THAT A 4 YEAR OLD CAR WITH 80K MILES ON IT SHOULD HAVE A REPAIR COST THIS HIGH. THERE SHOULD BE SOME SORT OF FAIL-SAFE ON THE HPFP THAT WHEN IT FAILS IT DOES NOT SEND METAL SHRAPNEL THROUGHOUT THE FUEL SYSTEM. I AM CURRENTLY WRITING LETTERS TO THE DEALERSHIP AND TO VW AMERICA TO LET THEM KNOW MY DISAPPOINTMENT IN THEIR PRODUCT. THIS PROBLEM IS HAPPENING WAY TO OFTEN TO NOT HAVE A RECALL ON THIS CAR. I ALSO FIND IT FUNNY THAT THE DEALERSHIP MADE A CALL TO VW OF AMERICA BEFORE THEY CALLED ME TO TELL ME WHAT WAS WRONG SOUNDS LIKE THEY KNOW THERE IS A ISSUE HERE. *TR

Mileage: 88,000

THE SAME THING HAS OCCURRED APPROXIMATELY 10-15 TIMES NOW. WHILE DRIVING, IT IS AS IF THE CAR GOES INTO NEUTRAL, AND APPLYING GAS DOES NOTHING. IT IS EXTREMELY DANGEROUS BECAUSE THERE IS NO WARNING THAT IT IS ABOUT TO HAPPEN, AND IF IT WERE TO OCCUR WHILE PULLING OUT IN TRAFFIC, WE WOULD BE STUCK IN PLACE WITH NO WAY TO ACCELERATE AND GET OUT OF THE WAY OF TRAFFIC. THE CAR WAS TAKEN TO THE DEALERSHIP AND THEY COULD FIND NOTHING WRONG AND OUR MONEY FOR THE DIAGNOSTIC WAS SPENT AND SOLVED NOTHING. IT HAS BEEN INCONSISTENT, SOMETIMES NOT HAPPENING FOR WEEKS AT A TIME, BUT IN THE LAST 5 DAYS IT HAS HAPPENED APPROXIMATELY 5 TIMES. IT IS AN EXTREMELY DANGEROUS PROBLEM AND SHOULD BE TAKEN CARE OF ASAP! *TR

Mileage: 60,000

DRIVING UP A MOUNTAIN HIGHWAY, THE CAR LOST ALL POWER (EVEN WITH THE GAS PEDAL TO THE FLOOR). ONCE PULLED OVER, THE VEHICLE WOULDN'T START AGAIN. THE HIGH PRESSURE FUEL PUMP IN THE TDI FAILED CATASTROPHICALLY AND SENT METAL SHRAPNEL THROUGHOUT THE ENTIRE FUEL SYSTEM. *TR

Mileage: 115,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC TEST WHICH LOCATED THE FAILURE WITHIN THE EXHAUST CONTROL MODULE. THE DEALER REPLACED THE EXHAUST MODULE UNDER THE WARRANTY; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE EXHAUST SYSTEM CONTROL MODULE FAILED AGAIN. A SECOND DIAGNOSTIC TEST WAS PERFORMED BY A LOCAL MECHANIC WHICH LOCATED THE FAILURE IN THE EXHAUST SENSOR WHICH MADE IT IMPOSSIBLE FOR THE EXHAUST EMISSION GATE TO OPEN OR CLOSE. THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS REPAIRED AND THE EXHAUST FLAP DOOR WAS LUBRICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 110,000.

Mileage: 60,000

MY 2009 JETTA SPORTWAGEN TDI HAS EXPERIENCED A DISTURBING NO-START CONDITION SEVERAL TIMES. CRANKING THE ENGINE DID NOT RESULT IN A START. ONLY AFTER REPEATED CRANKING (5-10 TIMES) DID THE CAR ACTUALLY START. FIRST IT WOULD NOT START SEVERAL TIMES, THEN START AND DIE IMMEDIATELY, AND FINALLY START, RUN VERY ROUGH,AND THEN SMOOTH OUT ITS IDLE. THIS ENTIRE SEQUENCE (WHICH HAS HAPPENED AT LEAST 4 TIMES IN THE LAST MONTH, TO VARYING DEGREES) OCCURRED IN THE DECEMBER-JANUARY TIME FRAME, WITH THE FIRST INCIDENT OCCURRING WHEN TEMPS WERE RIGHT AROUND FREEZING, WITH PRECIPITATION (RAIN-SNOW MIX) AND HIGH HUMIDITY. AT LEAST 2 TIMES, THE VEHICLE SIMPLY DIED SUDDENLY WHILE DRIVING, WHEN I TOOK MY FOOT OFF THE THROTTLE AND REVS DROPPED DOWN TO IDLE. IN ADDITION, THE CAR HAS DISPLAYED A SOLID CHECK ENGINE AND FLASHING GLOW PLUG LIGHT, WHICH HAVE COME AND GONE SEVERAL TIMES (INTERMITTENTLY: ONE DAY THEY WILL BE ON, THE NEXT DAY NOT). THE LAST SYMPTOM TO REPORT IS A P0638 OBDII CODE (THROTTLE BODY OUT OF RANGE). THIS CODE, HOWEVER, COULD BE A FALSE INDICATION THAT IS RELATED TO THE NUMBER OF FAILED ENGINE START ATTEMPTS? I TOOK THE CAR TO THE DEALER, AND THEY COULD NOT FIGURE OUT WHAT THE PROBLEM IS. I HAVE A STRONG INDICATION TO SUSPECT, AFTER RESEARCHING OTHERS' EXPERIENCES ON SEVERAL ONLINE FORUMS, THAT THIS MAY BE RELATED TO THE ACCUMULATION OF WATER AND/OR ICE IN THE INTERCOOLER, WHICH THEN EITHER BLOCKS THE AIRFLOW OR BECOMES INGESTED INTO THE INTAKE. MY SYMPTOMS ARE CONSISTENT WITH THOSE REPORTED IN THE VOLKSWAGEN TECHNICAL SERVICE BULLETIN (TSB) # 21 11 06 / 2025464 - FROZEN AIR CHARGE COOLER. HOWEVER, WHEN I PRESENTED THIS TSB DATA, ALONG WITH REPORT OF MY SYMPTOMS TO THE DEALER (AFTER THEY INSPECTED THE CAR AND COULD NOT FIND ANYTHING) THEY TOLD ME THAT THEY COULD NOT HELP ME, SINCE THE VEHICLE IS OUT OF ITS WARRANTY PERIOD. *TR

Mileage: 75,000

MY VW JETTA HAD SAT FOR A FEW DAYS IN A INDOOR PARKING SPACE IN THE MIDWEST DURING WINTER DECEMBER TO BE EXACT. WHEN I STARTED THE CAR, IT STARTED WEAK, THEN GAVE AN ERROR ON THE DISPLAY OF "ENGINE FAULT WORKSHOP.". THE CAT CONTINUED TO DRIVE, BUT LACKED POWER AND SEEMED TO SURGE. AFTER I RETURNED HOME, I DISCONNECTED THE LOWER INTERCOOLER HOSE TO FIND A LARGE ICE FORMATION AND WATER RESTRICTING THE OUTLET OF THE INTERCOOLER. THIS PROBLEM CAN CAUSE MAJOR ENGINE DAMAGE AND IS CAUSED.BY THE EXHAUST GASES AND WATER VAPOR FREEZING IN THE INTERCOOLER. EVERY VW WITH THIS STYLE INTERCOOLER SETUP HAS POTENTIAL FOR THIS PROBLEM. IT SHOULD BE RECALLED DO TO ITS SEVERITY. ALSO, THERE IS A TSB ALREADY WRITTEN FOR THE "FIX". BUT VW HAS NOT INFORMED ANYONE, NOR WILL TAKE CARE OF THE PROBLEM FOR ANYONE BEYOND THE 36000 MILE WARRANTY. EVEN THOUGH THIS IS A DESIGN FLAW. *TR

Mileage: 58,500

WHILE DRIVING THE DASH WARNING LIGHTS ILLUMINATED AND THE CAR STALLED CAUSING COMPLETE LOSS OF ALL POWER STEERING ALMOST CAUSING ME TO LOSE CONTROL AND WRECK. I WAS ABLE TO STEER CAR TO SIDE OF ROAD AND STOP. ONCE STOPPED WAS ABLE TO GET CAR TO RESTART BUT WAS BARELY ABLE TO DRIVE HOME (PERIODICALLY DIED AND HAD TO RESTART, WOULDN'T STAY RUNNING OR IDLE). HAD CAR TOWED TO REPAIR SHOP. THEY HAVE DIAGNOSED PROBLEM AS LOW RAIL FUEL PRESSURE CAUSED BY FAILED HIGH PRESSURE FUEL PUMP. THIS FAILURE CAUSED METAL SHAVINGS TO BE DISPERSED THROUGHOUT ENTIRE FUEL SYSTEM. I'M TOLD THAT THE HP FUEL PUMP, LOW AND HIGH PRESSURE FUEL REGULATORS, AND TANK FUEL PUMP ALL MUST BE REPLACED ALONG WITH A COMPLETE REMOVAL AND CLEANING OF ALL FUEL SYSTEM COMPONENTS. ESTIMATED COST TO REPAIR IS BETWEEN $7,000 AND $10,000. THIS CAR IS A DIESEL TDI. *TR

Mileage: 86,000

I WAS DRIVING ON THE INTERSTATE, AT ABOUT 68 MPH, WHEN THE ENGINE COMPLETELY SHUT DOWN WITHOUT ANY WARNING WHATSOEVER. THE CAR, HAVING A MANUAL TRANSMISSION, WAS STILL IN GEAR AND SLOWED DOWN VERY QUICKLY WITHOUT ANY WARNING TO OTHER DRIVERS (NO BRAKE LIGHTS). I TRIED TO PUSH IN THE CLUTCH AND COAST TO THE SHOULDER, AND SUCCESSFULLY MADE IT OFF THE HIGHWAY. THE CAR RESTARTED, AND I MADE IT A FEW MILES TOWARDS THE DEALER BEFORE IT HAPPENED AGAIN, LUCKILY ON A LOW-TRAFFIC STREET. THE CAR WAS TOWED THE REST OF THE WAY TOWARDS THE DEALER AND DIAGNOSED AS A FAILED HIGH PRESSURE FUEL PUMP, CAUSING CATASTROPHIC FUEL SYSTEM DAMAGE. THE FUEL RAIL, INJECTORS, PUMP, TANK, AND ALL LINES WILL NEED TO BE REPLACED AS THE RESULT OF THE PUMP FAILURE CAUSED BITS OF METAL FLAKES TO CIRCULATE ABOUT THE FUEL SYSTEM. THE DIAGNOSIS AND LISTED REPAIRS WERE DETERMINED BY THE VOLKSWAGEN DEALER. *TR

Mileage: 102,815

TDI DIESEL ENGINE. ENTERED HIGHWAY, CAR STUTTERED, ENGINE DIED, DISPLAYED WORKSHOP CODE PROBLEM, GLOWPLUG LIGHT FLASHING. RESTARTED ONE TIME, TRAVELED TO PARKING AREA, ENGINE DIED AND WOULD NOT RESTART. CODE WAS P0087, FUEL PUMP PRESSURE FAILURE. NO PREVIOUS PROBLEMS OR HINTS OF THIS ISSUE. SUDDEN ENGINE FAILURE. VERY DANGEROUS, WAS DRIVING UPHILL, THE ONE RESTART ALLOWED ME TO LEAVE ROAD. DEALER NOTED NO FUEL CONTAMINATION. SYSTEM WAS PROPERLY PRIMED ON FUEL FILTER CHANGES. USED A ROSS-TECH CABLE AND SOFTWARE. REPAIR IS EXPECTED TO BE ABOUT $7000.00. PREVIOUS DIESEL 2001 MODEL WAS STILL RUNNING WITH 332,000 MILES WHEN THIS ONE WAS PURCHASED. TDICLUB.COM WEBSITE HAS NOTED MANY OF THESE FAILURES, SEARCH HPFP, HIGH PRESSURE FUEL PUMP. VW IS NOT FURNISHING PUMPS DESIGNED WITH THE US DIESEL FUEL QUALITY IN MIND. VW NEEDS TO CORRECT THIS PROBLEM, THERE HAVE BEEN A LOT OF THESE FAILURES. *TR

Mileage: 145,264

TRAVELING ON INTERSTATE 10 FROM TALLAHASSEE, THE CAR ENGINE SUDDENLY STOPPED RUNNING. AFTER DRIFTING ONTO THE SHOULDER THE ENGINE LIGHT WAS ON AND THE GLOW PLUG LIGHT WAS ON. THERE WERE NO INDICATIONS OF ANY PROBLEM PRIOR TO THE ENGINE STOPPING. NO INDICATOR LIGHTS CAME ON, NO SPUTTERING, NO LOSS OF POWER ETC. AFTER MANY ATTEMPTS TO RESTART WITH NO SUCCESS, IT WAS TOWED INTO MARION FLORIDA. THEY COULD NOT TELL WHAT WAS WRONG AND I HAD TO HAVE IT TOWED TO THE CLOSEST DEALER IN VALOUSA GA. THERE THEY FOUND METAL PIECES IN THE FUEL FILTER AND SAID THIS WAS GOING TO BE A MAJOR REPAIR. PLEASE CONTACT ME IF YOU NEED MORE INFORMATION ABOUT THIS INCIDENT. *TR

Mileage: 48,000

2009 JETTA VOLKSWAGEN TDI, WITH ONLY 50500 MILES ON IT. THE CAR DIED IN THE MIDDLE OF INTERSECTION AT 35MPH. THIS WAS DURING RUSH HOUR TRAFFIC. IN THE CAR WAS ME 32, MY WIFE 36, MY DAUGHTER OF 8 YEARS OLD AND SON OF 2 YEARS OLD. IT WAS A VERY SCARY EVENT. I HAD IT TOWED TO THE NEAREST VW DEALERSHIP. IT TOOK THEM 3 DAYS TO LOOK AT THIS CAR AND AFTER I CALLED 15 TIMES, THEY TOLD ME THAT THIS FUEL PUMP HAD BEEN SLOWLY BREAKING DOWN INSIDE THE FUEL TANK, RUNNING THROUGH THE LINES AND INTO THE INJECTORS. THEY HAVE TOLD MY THIS COULD BE EXTREMELY EXPENSIVE. I HAVE ALWAYS USED CLEAN DIESEL, AND FILLED UP AT NEW GAS STATIONS. THIS WAS JUST TODAY I SPOKE WITH THEM, AND I HAVE DONE SOME RESEARCHING AND FOUND THIS TO BE CALLED HPFP ISSUE. FROM AS MANY CASES I HAVE SEEN POSTED ON THE INTERNET, THIS SHOULD DEFINITELY BE A RECALL. *TR

Mileage: 50,500

STARTED MY CAR FOR THE SECOND TIME THAT DAY, NOTHING OUT OF THE ORDINARY. ABOUT A MILE AWAY I EXPERIENCED THE CAR SHUTTING DOWN. I DOWNSHIFTED INTO SECOND, TURNED BACK ON BUT WHEN I GAVE IT GAS IT SPUTTERED. I WAS ON THE SIDE OF THE ROAD FOR 1.5HRS WAITING FOR TOW TRUCK. MECHANICS COMPUTER DESCRIBES THE PROBLEM AS LOW FUEL PRESSURE. *TR

Mileage: 88,000

FELT A SHUDDER IN THE DRIVE TRAIN; A FEW SECONDS LATER THE GLOW PLUG LIGHT BEGAN TO FLASH; THE MULTI-FUNCTION COMPUTER FLASHED THAT THERE WAS AN ENGINE FAULT AND TO SERVICE THE ENGINE; THE ENGINE SHUTDOWN AND I PULLED OVER TO THE SIDE OF THE ROAD; ENGINE WOULD NOT RESTART; DEALER ANALYSIS REVEALED THE HIGH PRESSURE FUEL PUMP FAILED APPARENTLY SENDING SHARDS OF METAL PARTICLES DOWNSTREAM OF THE PUMP; PUMP AND OTHER HARDWARE DOWNSTREAM OF THE PUMP ARE SCHEDULED FOR REPLACEMENT *TR

Mileage: 37,002

WHILE LEAVING A CONCERT, THE VEHICLE WAS FINE LEAVING THE PARKING LOT. ONCE WE INCREASED SPEEDS TO 45 MPH, THE ENGINE COMPLETELY SHUT DOWN. THE DIALS ON THE DASHBOARD ALL FELL TO ZERO AND THE GAS PEDEL NO LONGER WORKED. WE COASTED INTO A SMALL CAMPGROUND AREA OFF TO THE SIDE OF THE ROAD. AFTER TRYING TO RESTART THE CAR THREE TIMES, IT FINALLY STARTED AND WE PROCEEDED TO GO DOWN THE ROAD, ONLY TO MAKE IT 500 MORE YARDS AND PULLED IN TO A HAY STACK PAD. AFTER NUMEROUS ATTEMPTS TO START WHILE SITTING ON THE PHONE WIHT OUR INSURANCE COMPANY, THE CAR STARTED ONCE AND DIED AFTER SITTING IDLE FOR THREE MINUTES. WE THEN ATTEMPTED TO START IT ONE LAST TIME AND DROVE 25 MPH TO THE NEAREST GAS STATION. WE ALL GOT OUT OF THE CAR, LOCKED IT UP THINKING IT MAY HAVE SOMETHING TO DO WITH AN ANTITHEFT FEATURE. WE GOT BACK IN THE CAR AND WERE ABLE TO DRIVE 41 MILES HOME AT HIWAY SPEEDS. THE FOLLOWING DAY WE DROVE 5 MILES INTO TOWN AND IT DIED AGAIN GOING 25 MPH. THE CLOSEST VOLKSWAGON IS ANOTHER 25 MILES AWAY. *TR

Mileage: 71,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN JETTA TDI. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD. AS THE CONTACT MERGED THE VEHICLE TO THE SHOULDER, IT RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INSPECTED THE VEHICLE AND STATED THAT THE FAILURE WAS DUE TO A BLOWN TURBO. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED BY THE DEALER. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE REPAIR WAS COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 73,800.

Mileage: 73,800

VEHICLE IS A 2009 JETTA SEDAN - TDI (DIESEL) VEHICLE SHUT DOWN WHILE DRIVING. FLOW PLUG LIGHT FLASHED ON DASH ALONG WITH DISPLAY OF "ENGINE FAULT WORKSHOP" VEHICLE WOULD NOT RESTART. PULLED CODE OF P0087 FUEL RAIL/SYSTEM PRESSURE LOW. TOWED TO DEALER, BOUCHER VW IN FRANKLIN, WI. DEALER CONFIRMED FAULT WAS A HIGH-PRESSURE FUEL PUMP FAILURE. *TR

Mileage: 60,509

I WAS DRIVING UP A HILL IN A NEIGHBORING TOWN AND MY CAR LOST ALL POWER ALMOST INSTANTLY. MY ""MDF" READ "ENGINE FAULT WORKSHOP" AND MY GLOW PLUG LIGHT (SINCE THIS IS A DIESEL POWERED VEHICLE) STARTED RAPIDLY FLASHING. I WAS ABLE TO SHIFT THE CAR TO NEUTRAL AND COAST TO THE TOP OF THE HILL, THEN ONCE REACHING THE APEX OF THE HILL, COAST INTO A GROCERY STORE PARKING LOT. MY CAR WAS COMPLETELY DEAD, AND I HAD TO TOW IT TO THE DEALER. *JS

Mileage: 78,209