2011 VOLKSWAGEN JETTA Fuel System, Diesel Problems

THE CAR IS A 2011 VW JETTA SW TDI. ON SEPT 7, 2015, WHILE DRIVING ON THE AUTOBAHN, THE CAR'S CHECK ENGINE LIGHT ACTIVATED AND THE CAR ABRUPTLY LOST POWER. I COASTED TO A STOP ON THE SHOULDER. I SHUT THE CAR OFF AND IT WOULD NOT RESTART. IT WAS TOWED TO THE NEAREST VW DEALER. WE HAD TO RENT A VEHICLE FOR ALMOST TWO WEEKS. VW SAID THE FUEL PUMP WAS DESTROYED DUE TO TAINTED DIESEL FUEL. REPORTS INDICATED THAT METAL SHAVINGS WERE FOUND IN FUEL SAMPLES. VW REPLACED THE ENTIRE FUEL SYSTEM AT A COST OF EIGHT THOUSAND EUROS. I HAVE CONTACTED THE ESSO STATION & HEADQUARTERS. ESSO HAS INDICATED THAT THERE HAVE BEEN NO REPORTS OF TAINTED DIESEL FUEL AT THE STATION. I AM BEING SHUFFLED BETWEEN THE ESSO STATION & THE VW DEALERSHIP. IT IS OBVIOUS WHO THE RESPONSIBLE PARTY IS. VW NEEDS TO DO WHAT IS RIGHT AND DEMONSTRATE CORPORATE SOCIAL RESPONSIBILITY. *TR

Mileage: 88,000

NOVEMBER 2014 INCIDENTS: TWO INCIDENTS OF FAILING TO START. FIRST INCIDENT: CAR FAILED TO START ONCE AND STARTED ON SECOND TRY. SECOND INCIDENT: CAR SEVERAL TIMES FAILED TO START & ENGINE MADE CLANKING NOISE. HAD CAR TOWED TO VW AGENCY. CAR STARTED AFTER UNLOADED FROM TOW TRUCK AND AGENCY FOUND NOTHING WRONG. DECEMBER 2014 INCIDENT: CAR STARTED, BUT AFTER SLOWLY DRIVING TO PARKING LOT EXIT AND BEFORE AT FULL STOP, AT ENGINE QUIT AND WOULD NOT RESTART. I PUT THE CAR IN NEUTRAL AND BACKED DOWN A SLIGHT GRADE TO GET CAR OUT OF TRAFFIC; AFTER COMING TO A STOP THE CAR STARTED UP.

Mileage: 55,102

WAS DRIVING IN PARKING LOT WHEN VEHICLE SUDDENLY DIED WHILE UNDERWAY AND CHECK ENGINE LIGHT CAME ON. THANKFULLY IT HAPPENED AT A RELATIVELY LOW SPEED AND WHILE NOT IN TRAFFIC AS THERE WAS LITTLE TO NO WARNING BEFORE THE ENGINE DIED COMPLETELY CAUSING LOSS OF POWER, STEERING, BRAKING ETC. AFTER TOWING VEHICLE TO VOLKSWAGEN OF SOUTH CHARLOTTE, THEY INDICATED THE HIGH PRESSURE FUEL PUMP HAD FAILED RESULTING IN METAL PARTICLES FROM THE PUMP BEING SENT THROUGH ENTIRE FUEL SYSTEM. DEALER INDICATED CAUSE WAS BAD FUEL, HOWEVER, I ALSO HAVE A DIESEL TRUCK THAT I FILL UP AT THE SAME STATION ALL THE TIME AND HAVE NEVER HAD ISSUE WITH IT. WHILE VEHICLE WAS REPAIRED UNDER WARRANTY BY VW, AFTER RESEARCHING THIS, IT BECAME CLEAR THAT THIS IS A PROBLEM THAT IS HAPPENING FREQUENTLY ENOUGH THAT IT IS LIKELY A DESIGN FLAW THAT SHOULD BE ADDRESSED BY THE MANUFACTURER. *TR

Mileage: 69,774

SHORTLY AFTER PURCHASING THE VEHICLE NEW WE EXPERIENCED ISSUES WITH THE VEHICLE STUTTERING WHEN DRIVING AND AT TIMES SHUTTING OFF COMPLETELY AS IF IT STALLED (THE VEHICLE IS AN AUTOMATIC WITH THE DSG TRANSMISSION). WE TOOK THE VEHICLE TO THE VW DEALERSHIP UNDER WARRANTY BUT THE TECH COULD NOT REPLICATE THE PROBLEM AND SENT US ON OUR WAY AND TOLD US TO COMEBACK IF IT KEPT OCCURRING. THE PROBLEM PERSISTED AND WE TOOK THE VEHICLE TO THE SERVICE DEPARTMENT AGAIN AND THEY SAID THE PROBLEM COULD NOT BE FOUND AND ONCE AGAIN SENT US AWAY AND TOLD US TO COME BACK IF THE PROBLEM KEPT OCCURRING. THE VEHICLE IS NOW STUTTERING AND STALLING MUCH MORE OFTEN AND THE WARRANTY HAS RUN OUT. I CALLED THE VW HQ THEY TOLD ME TO TAKE THE VEHICLE IN AND HAVE THE TECH LOOK AT IT WHICH HAS COST ME $112 IN WHICH THEY ONCE AGAIN FOUND NOTHING AND RECOMMENDED I LET THE CAR WARM UP PRIOR TO DRIVING. IT IS CURRENTLY SUMMER AND THE LOW TEMPERATURES ARE AROUND 70 AND THE HIGHS ARE 85+. IN ADDITION THIS IS A MODERN VEHICLE AND HAD I KNOW I WAS GOING TO NEED TO LET IT WARM UP I WOULD NOT HAVE PURCHASED IT. THIS ISN?T THE 50?S. MY WIFE AND I NOW FEEL THE VEHICLE IS UNSAFE TO DRIVE DUE TO THE FACT IT STALLS OUT AT UNPREDICTABLE TIMES CAUSING A LOSS OF POWER STEERING, POWER BRAKES. IF VW DOES NOT FIX THIS ISSUE I WILL BE TRADING IT IN DUE TO THEIR DISREGARD FOR SAFETY OF MY FAMILY. *TR

Mileage: 15,000

WHILE DRIVING THE ENGINE LIGHT CAME ON AND THE CAR LOST POWER. WE WERE ON A RURAL ROAD SO WE COULD PULL TO THE SIDE OF THE ROAD SAFELY, IF THIS HAD HAPPENED ON A FREEWAY WE COULD HAVE BEEN IN DANGER OF BEING REAR ENDED. ONCE STOPPED THE CARE WOULD NOT RESTART. HAD TO BE TOWED TO VW DEALER. THE HIGH PRESSURE FUEL PUMP HAD FAILED. *TR

Mileage: 54,000

I WAS OPERATING THE CAR ON A HIGHWAY WHEN THE VEHICLE EXPERIENCED A SUDDEN REDUCTION IN POWER AND THE DASH DISPLAYED A FLASHING GLOW PLUG LIGHT AND SOLID CHECK ENGINE WARNING LIGHTS. I IMMEDIATELY PULLED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS SHUT OFF. THE ENGINE FAILED TO RESTART AND WAS TOWED TO A VOLKSWAGEN DEALERSHIP. THE SERVICE MANAGER TOLD ME THAT THE CAUSE WAS A CATASTROPHIC FAILURE OF THE (HPFP); IT TOTALLY CAME APART AND DISTRIBUTED METAL THROUGHOUT THE FUEL SYSTEM. INJECTOR PUMP (DIESEL), INJECTORS, INJECTOR LINES, PRIMARY FUEL LINES, AND PRIMARY FUEL PUMP. THE CAR ONLY HAS 54,000 MILES ON IT. *TR

Mileage: 54,000

I PURCHASED A USED 2011 VW JETTA SPORTWAGEN TDI ON MONDAY, JULY 28, 2014 AND 5 DAYS LATER ON AUGUST 2ND, THE CAR DIED. I HAD BEEN DRIVING FOR ABOUT AN HOUR MOSTLY ON THE HIGHWAY AND THEN SOME MODERATELY WINDING FOOTHILL ROADS. I STOPPED AT A STOP SIGN AND WHEN I ACCELERATED INTO THE INTERSECTION THE ENGINE ABRUPTLY DIED AND WOULD NOT RESTART. THE ENGINE TURNED OVER WHEN THE KEY WAS TURNED, BUT IT WOULDN'T START. FORTUNATELY, PEOPLE IN THE VEHICLES BEHIND ME HELPED PUSH MY CAR TO THE SIDE OF THE ROAD. IT WAS TOWED TO A NEARBY REPAIR SHOP SPECIALIZING IN FOREIGN CARS FOR EVALUATION. THEY FOUND THE DIESEL FUEL PUMP HAD FAILED AND THEY SAID THERE ARE METAL SHAVINGS THROUGHOUT THE FUEL SYSTEM. *TR

Mileage: 56,610

GLOW PLUG LIGHT STARTED BLINKING, THEN THE ENGINE LIGHT CAME ON. SHIFTING BECAME ERRATIC. PULLED INTO A SERVICE STATION, AND ONCE THE VEHICLE WAS TURNED OFF, IT WOULDN'T RESTART. AFTER BASIC CHECKS, THE FUEL PUMP WAS PULLED FOR INSPECTION AND METAL SHAVINGS WERE FOUND. IN RESEARCHING THE REPAIR, THE INDEPENDENT STATION SUGGESTED PUTTING THINGS BACK TOGETHER, AND HAVING IT TOWED TO THE DEALER, AS IT WAS SUSPECTED TO BE A KNOWN ISSUE WITH THE BOSCH HIGH PRESSURE FUEL PUMP. IN FACT IT WAS, AND WHILE THE CAR WAS TWO MONTHS OUT OF WARRANTY, THE DEALER WENT AHEAD AND COVERED THE REPAIR UNDER THE UNRELATED DRIVETRAIN WARRANTY. I CONSIDER MYSELF INCREDIBLY LUCKY THAT THIS WASN'T 15 MINUTES EARLIER, WHEN I WAS TRAVELING AT HIGHWAY SPEEDS, ON AN INCREDIBLY FULL FREEWAY. IT COULD'VE BEEN A MAJOR ACCIDENT IF I HAD SUDDENLY LOST POWER. CONSIDERING THERE ARE ENTIRE WEBSITES DEVOTED TO TRACKING THIS ISSUE, I CAN'T BELIEVE THAT THERE HASN'T BEEN A RECALL. *TR

Mileage: 30,515

DRIVING AT 45 MPH, ENGINE DID NOT STALL BUT LOST POWER. MOTOR STALLED AFTER ABOUT 10 SECONDS. AFTER PUTTING IN NEUTRAL AND ROLLING TO A STOP THE MOTOR WOULD NOT RESTART. AFTER TOWING TO LOCAL VW DEALER, WAS TOLD THE MECHANICAL FUEL PUMP FAILED. THEY SAID IT WAS 4-5 THOUSAND JOB BUT VW WAS PICKING UP THE REPAIR AND NOT CHARGING IT OUT TO OUR EXTENDED WARRANTY. WAS GIVEN A LOANER CAR UNTIL REPAIRS ARE MADE. NO INDICATION OF HOW LONG. IS THIS AN ADMISSION BY VW THAT A SERIOUS PROBLEM EXISTS WITH TDI MODELS? *TR

Mileage: 41,000

HIGH PRESSURE FUEL PUMP FAILURE. ALWAYS FUELED UP WITH ULTRA LOW SULFUR DIESEL. *TR

Mileage: 79,000

GLOW PLUG & CHECK ENGINE LIGHTS CAME ON , ENGINE DIED 30 SECONDS LATER. WOULD NOT RESTART, TOWED TO DEALER, DIAGNOSED HPFP CATASTROPHIC FAILURE, METAL DEBRIS IN FUEL SYSTEM. WHOLE FUEL SYSTEM REPLACED, TANK THROUGH TO INJECTORS. NO WARNING OF FAULT CONDITION WITH NO TIME TO PULL OFF TO SIDE OF ROAD, LEFT STUCK IN MIDDLE OF HIGHWAY. *TR

Mileage: 64,854

WHILE DRIVING THROUGH TOWN 35 MPH MY TDI SPORTWAGON GLOWPLUG LIGHT STARTED FLASHING. I IMMEDIATELY TURNED INTO A PARKING LOT WITHIN SECONDS AND PUT THE TRANSMISSION IN PARK. THE CAR SOUNDED LIKE IT WAS NOT FIRING ON A CYLINDERS. I TURNED THE CAR OFF. AFTER THAT IT WOULD NOT START BACK UP. FROM WHAT I HAVE READ, IT HAS TO DO WITH THE HIGH PRESSURE FUEL PUMP. THIS MADE THINGS UNSAFE AND THEIR ARE NO VISIBLE SIGNS OF LEAKS/ CORROSION/ OR SIGNS OF WEARING. THE MALFUNCTIONING FUEL SYSTEM CAUSED MY CAR TO FAIL AND STALL IN A BUSY INTERSECTION. THE FUEL SYSTEM SHOULD BE RECALLED. AT LEAST THE PUMP SYSTEM. *TR

Mileage: 68,000

WENT TO PASS A VEHICLE AND I FELT A SURGE THEN A SIREN SOUND STARTED COMING FROM THE RIGHT SIDE OF ENGINE. WAS TOLD BY DEALERSHIP IT WAS A VACUUM ISSUE AND IT WAS SAFE TO DRIVE. WHEN I GOT TO DEALERSHIP THEY TOLD ME IT WAS A BLOWN TURBO. WONDERING IF THIS IS TIED TO THE INCIDENT I HAD WITH THE HIGH PRESSURE FUEL PUMP FAILING AROUND 100K. TOO MANY MAJOR CATASTROPHIC ISSUES WITH THIS CAR. I'VE BEEN QUOTED 15,000 FOR REPAIRS ON A CAR I'M STILL MAKING PAYMENTS ON AND ONLY COST 28K TO BEGIN WITH. *TR

Mileage: 127,754

DRIVING ON SURFACE STREET AT APPROXIMATELY 40 MPH. IN 2011 JETTA SPORTWAGEN TDI WITH ONLY 23000 MILES ."SERVICE NOW! " WARNING CAME ON AND CAR IMMEDIATELY STALLED IN THE MIDDLE OF TRAFFIC AND WOULD NOT RESTART. HAD TO BE TOWED TO VW DEALER, HAS BEEN THERE 5 DAYS SO FAR WAITING FOR HIGH PRESSURE FUEL PUMP REPLACEMENT. FROM INVESTIGATION, THIS IS NOT AN OBSCURE EVENT, IS KNOWN TO OCCUR WITH THIS MODEL AND YEAR TDI (DIESEL) ENGINES. IF THIS OCCURRED ON A HIGH SPEED FREEWAY, I COULD HAVE EASILY BEEN STRUCK AND KILLED WHEN CAR SUDDENLY STOPPED. *TR

Mileage: 23,000

I WAS CRUISING AT 60 MPH THIS MORNING WHEN THE GLOW-PLUG WARNING LIGHT BEGAN TO FLASH AND THE CRUISE CONTROL WAS SHUT OFF IMMEDIATELY CAUSING AN UNEXPECTED DECELERATION. I PULLED INTO THE EMERGENCY LANE AND THE ENGINE SHUT OFF ONCE I CAME TO A STOP. THE ENGINE WOULD NOT RESTART AND THE GLOW-PLUG LIGHT WAS JOINED WITH THE CHECK ENGINE LIGHT. I HAD IT TOWED TO MY MECHANIC WHO READ THE COMPUTER CODES AS "LOW FUEL PRESSURE TO THE INJECTORS". HE LOOKED INTO THE FUEL FILTER AND FOUND METAL SHAVING. HE STATED THOSE SHAVING POINT TO A COMPLETE FAILURE OF THE HIGH PRESSURE FUEL PUMP (HPFP). I OWNED THIS CAR FOR ONLY TWO WEEKS AND, BASED ON VOLKSWAGEN'S REPUTATION AND THE REPUTATION OF THE TDI DIESEL ENGINE I EXPECTED TO OWN THIS CAR FOR YEARS. THE REPAIR COSTS ARE NOW ESTIMATED TO BE HALF THE PURCHASE PRICE I PAID LESS THAN A MONTH AGO. *TR

Mileage: 65,000

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS RECURRING BUT THE VEHICLE WAS ABLE TO BE RESTARTED AFTER SEVERAL MINUTES. THE CHECK ENGINE AND GLOW PLUG WARNING LIGHT WOULD ALSO ILLUMINATE AFTER THE FAILURE HAD OCCURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45000.

Mileage: 45,000

WHILE DRIVING ON 95 NORTH THROUGH PHILA MY 2011 JETTA TDI BEGAN TO LOSE POWER. I COULD NOT ACCELERATE AND THE VEHICLE EVENTUALLY CAME TO A STOP. IT WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE DEALER AND AFTER EVALUATION I WAS TOLD IT WAS THE HIGH PRESSURE FUEL PUMP THAT FAILED. THIS WAS GOING TO BE AN EXTENSIVE REPAIR BUT VW WAS GOING TO PAY FOR THE REPAIR. THE VEHICLE WILL BE IN THE SHOP FOR APPROX. 4 TO 5 DAYS THEY SAY. THERE WAS APPROX 72,200 MILES AT THE TIME OF THE FAILURE. *TR

Mileage: 72,200

THE HIGH PRESSURE FUEL SYSTEM FAILED IN OUR CAR WHEN WE WERE ON A ONE LANE HIGHWAY. 'ENGINE CONTROL MALFUNCTION' LIGHT STARTED FLASHING AND SUDDENLY OUR CAR WAS STALLED. WHEN WE LOOKED IN THE MANUAL IT SAID TO GET THE CAR TO A VW DEALERSHIP ASAP. WE HAD TO HOLD UP TRAFFIC UNTIL THE CAR WAS FINALLY TOWED. NOT ONLY THAT, WE WERE ON VACATION IN THE DIFFERENT CITY AND THIS HAPPENED DURING THE WEEKEND WHEN THE SERVICE CENTERS ARE CLOSED. AFTER A PAINFUL 2 DAYS WE JUST FOUND OUT THAT OUT HIGH PRESSURE FUEL SYSTEM HAS BROKEN AGAIN. IT WAS LAST REPLACED IN APRIL 2013 AND IT WAS EXACTLY THE SAME SITUATION. THIS IS A REALLY BIG STRUCTURAL DAMAGE AND HAPPENED WITH NO FAULT ON OUR SIDE. THE LAST ONE COST UP TO $10K, WHICH VW COVERED DUE TO WARRANTY. HOWEVER, IT IS ALSO A SAFETY HAZARD SINCE WE COULD HAVE EASILY GOTTEN INTO AN ACCIDENT. AFTER HAVING GONE THROUGH THIS TWICE, WE NO LONGER FEEL SAFE DRIVING THE TDI AND STRONGLY FEEL THAT THE CAR SHOULD BE RECALLED. *TR

Mileage: 42,000

THE HIGH PRESSURE FUEL SYSTEM FAILED IN OUR CAR WHEN WE WERE ON A BUSY CITY STREET. 'ENGINE CONTROL MALFUNCTION' LIGHT STARTED FLASHING AND SUDDENLY OUR CAR WAS STALLED. WHEN WE LOOKED IN THE MANUAL IT SAID TO GET THE CAR TO A VW DEALERSHIP ASAP. WE HAD TO HOLD UP TRAFFIC UNTIL THE CAR WAS FINALLY TOWED. NOT ONLY THAT, THIS HAPPENED DURING LATE NIGHT AROUND 10 PM AND ALL THE SERVICE CENTERS WERE CLOSED. AFTER A PAINFUL 2 DAYS WE JUST FOUND OUT THAT OUT HIGH PRESSURE FUEL SYSTEM HAD TO BE REPLACED. THIS IS A BIG STRUCTURAL DAMAGE WITH THE CAR AND I NO LONGER FEEL SAFE OWNING OR DRIVING IT. *TR

Mileage: 23,000

MY 2011 VOLKSWAGEN JETTA TDI STARTED TO SPUTTER WHEN ACCELERATING, I BROUGHT IT THE DEALER AND THEY FOUND SHARDS OF METAL IN THE FUEL SYSTEM. HPFP (HIGH PRESSURE FUEL PUMP) HAD FAILED. THE QUOTE TO FIX WAS 6875.00 TO FIX A TWO YEAR OLD CAR. VERY UN HAPPY. *TR

Mileage: 124,000

BROUGHT TO DEALER TO DIAGNOSE SERVICE ENGINE LIGHT, CODE P191, AND ONCE P087. I GET DIESEL AT THE SAME STATION WHENEVER POSSIBLE. THESE ERRORS STARTED OCCURRING SHORTLY AFTER GETTING A FULL TANK OF DIESEL AT A DIFFERENT STATION. DEALER CONCLUDED THAT HIGH PRESSURE FUEL PUMP FAILURE WAS IMMINENT. ENGINE STALLED ON THE WAY HOME AND FAILED TO RESTART. FUEL SYSTEM WAS REPLACED. CAR AGAIN WORKS SATISFACTORILY. HOW MUCH LIFE (MILES) CAN I EXPECT THIS TIME AROUND? ARE THERE ANY PROVEN PREVENTIVE MEASURES? *TR

Mileage: 96,855

THE EFFECTED CAR WAS A DIESEL MODEL 2011 VOLKSWAGEN JETTA TDI SEDAN WITH 48,074 MILES ON THE ODOMETER AT THE TIME OF THE INCIDENT. WHILE TRAVELING AT APPROXIMATELY 40 MPH IN NORMAL DRIVING CONDITIONS, THE VEHICLE EXPERIENCED A SUDDEN REDUCTION IN POWER AND DISPLAYED A FLASHING GLOW PLUG LIGHT AND SOLID CHECK ENGINE WARNING LIGHTS. THE VEHICLE WAS IMMEDIATELY PULLED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS SHUT OFF. THE ENGINE FAILED TO RESTART AND WAS TOWED TO A VOLKSWAGEN DEALERSHIP SERVICE DEPARTMENT. THE VOLKSWAGEN DEALER DETERMINED THAT A CATASTROPHIC FAILURE OF THE VEHICLE'S HIGH PRESSURE FUEL PUMP (HPFP) HAD OCCURRED. THE DEALER FOUND THAT EXTENSIVE DAMAGE TO THE ENTIRE FUEL SYSTEM HAD RESULTED FROM THE FAILURE, CAUSING INTERNAL METAL DEBRIS CONTAMINATION THAT REQUIRED SUBSTANTIAL REPAIRS. THE TOTAL COST OF REPAIRS WERE REPORTED BY THE DEALERSHIP TO EQUAL $6,500.00. *TR

Mileage: 48,074

DRIVE HOME FROM WORK AT ABOUT 1500 HRS, WITH NO ISSUES. STOPPED AT LOCAL SUPERMARKET, STARTED ENGINE WITH SLIGHT DELAY, LEFT PARKING LOT, CAR STARTED TO BUCK, DROVE MAYBE 1/2 MI STARTED LOSING POWER, AFTER GOING ANOTHER 50 FT CAR ENGINE DIED, PUSHED CAR TO MY DRIVEWAY CALLED DEALERSHIP AND HAD CAR TOWED TO DEALERSHIP. ON 11/21/13 DEALERSHIP INFORMED ME THAT HPFP HAD EXPLODED SENDING METAL SHAVINGS INTO ENGINE, THEY ASKED ME IF I ACCIDENTALLY PUT GAS AND I RESPONDED WITH NO. THEY STATED THAT FUEL MAY HAVE BEEN CONTAMINATED. DEALERSHIP IS REPAIRING CAR SINCE IT IS STILL UNDER WARRANTY, SAID MAYBE 1 WEEK IN THE SHOP. I WAS GIVEN A RENTAL IN THE MEANTIME. *TR

Mileage: 28,400

I WAS ON MY WAY HOME AFTER WORK APPROXIMATELY 6-7 PM DOING 45 MPH. I LOOKED DOWN TO MY INSTRUMENT CLUSTER TO CHECK MY SPEED TO MAKE SURE I WASN'T SPEEDING. THEN I SAW THE GLOW PLUG LIGHT BLINKING MULTIPLE TIMES THEN ABOUT LESS THAN 5-10 SECONDS LATER MY ENGINE CUT OUT. I COST OFF INTO A HARPER COLLEGE PARKING LOT CAME TO A STOP. I TRIED TO START THE CAR 2-3 TIMES, EACH TIME THE ENGINE WAS CRACKIN OVER BUT WOULDN'T START IT UP. I CALLED THE TOW TRUCK COMPANY AND HAD THE VEHICLE TOWED TO VW DEALER IN SCHAUMBURG, IL ( FOX VALLEY VW) DEALER SAID THE HIGH PRESSURE FUEL PUMP FAILED. VWOA COVER THIS UNDER POWER TRAIN WARRANTY 5/60K WARRANTY. THE DEALER REPLACE HPFP,LIFT PUMP, PUMP IN GAS TANK,FUEL LINES TO ENGINE,COILS ETC... REPAIRS CAME TO ROUGHLY $5300.00. VWOA ONLY GIVE 12/12K MILES WARRANTY ON THE HPFP. THIS IS A KNOWN PROBLEM ON SOME VW WITH CJAA 2.0L TURBO DIESEL ENGINES AND VWOA HAS NOT FOUND THE DEFECT IN THE HPFP.VWOA SHOULD EXTEND THE HPFP TO 100K MILES DUE TO DEFT IN THE HPFP SINCE THEY HAVEN'T FOUND THE PROBLEM AND CORRECTED IT. *TR

Mileage: 45,125

WHILE DRIVING I SUDDENLY LOST ALL POWER TO THE ENGINE OF MY 2011 JETTA TDI. UNDER WARRANTY I HAD MY CAR TOWED TO THE VW DEALERSHIP. I WAS TOLD THE ENTIRE FUEL SYSTEM WAS DESTROYED BY THE HIGH PRESSURE FUEL PUMP, AND IT WAS POSSIBLY BE DUE TO THE DIESEL I USED, BEING DIRTY OR OTHERWISE CONTAMINATED. I HAD ALL MY RECEIPTS FOR DIESEL FILL-UPS FROM THE SAME STATION, AND IT WAS LISTED ON THE VW.COM WEBSITE AS A LOCATION FOR DIESEL. THE TANK WAS SUPPOSEDLY EMPTIED AND FILTERED DURING THE REPAIR AND I WAS NOT INFORMED OF CONTAMINATION. ON READING FURTHER I NOTE THAT MANY TDI OWNERS HAVE HAD THE SAME PROBLEM WITH NO ACKNOWLEDGEMENT FROM VW THAT THIS IS A FUEL PUMP PROBLEM, NOT A CUSTOMER MISUSE OF DIESEL FUEL. THIS IS A POTENTIALLY DANGEROUS SITUATION. I WAS STARTING OUT FROM A RED LIGHT AND WAS ABLE TO STEER THE CAR TO THE RIGHT LANE AND THEN THE SHOULDER. THE DANGER ON A BUSY ROADWAY COULD BE LETHAL. READ EDMONDS.COM AND OTHER JETTA OWNER BLOGS AND NOTE THE EXACT SAME INCIDENTS OCCURRING. WITH THE EXPLODING INTEREST IN DIESEL CARS FOR FUEL ECONOMY, THIS SITUATION NEEDS EVALUATION. *TR

Mileage: 23,800

I WAS PASSING A SEMI AND NEEDED TO ACCELERATE TO GET OUT OF THE WAY OF CAR TO MY REAR...DEPRESSED THE ACCELERATOR AND NO RESPONSE. TWO DAYS LATER EXPERIENCED SIMILAR EVENT AT LOW SPEED (30 MPH). *TR

Mileage: 37,000

WHILE DRIVING ON THE FREEWAY, THE GLOW PLUG LIGHT BEGAN TO FLASH AND A "SERVICE ENGINE NOW" INDICATOR LIT. AT THIS TIME, THE CAR ENTERED LIMP MODE AND POWER WAS GREATLY REDUCED. I DECIDED TO DRIVE STRAIGHT TO THE DEALER TO DROP IT OFF. OVER THE NEXT FEW MINUTES THE CAR PRODUCED LESS AND LESS POWER (A FEELING AKIN TO RUNNING OUT OF GAS, BUT THERE WAS STILL 1/2 TANK OF DIESEL IN THE CAR) UNTIL IT DIED AND WOULD NOT RESTART. NO OTHER WARNINGS, NO OTHER DRIVABILITY CUES, JUST A DEAD CAR ON THE FREEWAY UNABLE TO BE STARTED OR MOVED. THIS COULD HAVE BEEN EXTREMELY DANGEROUS/POSSIBLY FATAL HAD I NOT BEEN LUCKY ENOUGH TO FORCE MY WAY TO THE SHOULDER BEFORE THE CAR COMPLETELY GAVE OUT. SO TO SUM UP - ONE OWNER (PURCHASED NEW) DIESEL JETTA; CAR MAINTAINED BY DEALER AT APPROPRIATE INTERVALS. FUELED AT PRETTY MUCH THE SAME THREE STATIONS FOR MUCH OF ITS LIFE, NEVER HAD A NON-DIESEL PUMP ANYWHERE NEAR IT; DRIVING PERFECTLY ONE MINUTE, FIVE MINUTES LATER, A DEAD CAR. IT HAS BEEN TOWED TO THE DEALER TODAY, FROM THE SYMPTOMS IT SOUNDS LIKE THE NOTORIOUS HIGH PRESSURE FUEL PUMP (HPFP) HAS CATASTROPHICALLY FAILED. *TR

Mileage: 26,000

THE FUEL PUMP IN MY CAR'S 2.0 TDI DIESEL ENGINE BROKE. *TR

Mileage: 37,000

I WAS DRIVING ALONG AND THE POWER DROPPED TO ALMOST NOTHING. BEFORE I COULD GET TO A SAFE STOPPING POINT, THE ENGINE DIED. I HAD IT TOWED TO THE DEALERSHIP. THEY DIAGNOSED IT WITH A FAILED HIGH PRESSURE FUEL PUMP(HPFP). IF IT HAD BEEN OUT OF WARRANTY, IT WOULD HAVE COST $6000 TO REPAIR. IF THIS WOULD HAVE HAPPENED IN THE MIDDLE OF A 4 LANE EXPRESSWAY, I DON'T KNOW WHAT WOULD HAVE HAPPENED. *TR

Mileage: 46,000

WHILE DRIVING IN TRAFFIC THE VEHICLE LOST POWER. BEFORE IT COULD BE PULLED OFF THE ROAD TO SAFETY, THE ENGINE DIED COMPLETELY. THE PASSENGERS HAD TO GET OUT OF THE CAR AND PUSH IT ACROSS THE ROAD AND INTO A PARKING LOT. THE CAUSE OF THE INCIDENT WAS A CATASTROPHIC FAILURE OF THE HIGH PRESSURE FUEL PUMP. PROPER MAINTENANCE AND FUELING OF THE VEHICLE HAD BEEN RIGOROUSLY FOLLOWED ON THIS VEHICLE. THE OWNER IS A MECHANICAL ENGINEER AND DIESEL ENGINE ENTHUSIAST. *TR

Mileage: 64,500

2011 VW JETTA DIESEL AT 70 MPH GOING UP A HILL AND WITHOUT WARNING THE CAR LOST POWER AND SPEED DROPPED MAKING IT UNSAFE TO HAVE TIME TO PULL OFF THE ROAD. THE CARS BEHIND ME HAD TO ALL SLOW WAY DOWN TO LET ME GET OFF THE ROAD. THE CAR WOULD NOT RESTART. MY MECHANIC COULD NOT START IT AND SAID IT WAS A FUEL PROBLEM BUT COULD NOT FIX IT. VW REPORTED THE CAR STARTED FOR THEM AND THEY RAN OFF AND FOUND FAULT FOR LOW FUEL PRESSURE BUT NO REASON FOR THE PROBLEM. *TR

Mileage: 720,000

APPROXIMATELY A YEAR AGO, MY ENGINE BEGAN TO GIVE A CLEAR SENSE OF THE CAR SHUDDERING OR ROCKING BACK AND FORTH. WHILE SOMETIMES THE FEELING WOULD OCCUR EVEN WHEN STOPPED AT A LIGHT, THE VAST MAJORITY OF THE TIME THIS OCCURRED WHILE I WAS DRIVING AT CONSISTENT LOW SPEEDS. IN ALMOST ALL CASES, I WAS ATTEMPTING TO MAINTAIN A CONSISTENT SPEED AROUND EITHER 13PMH OR 30 MPH. EVENTUALLY, I FOUND THE ROCKING MOTION VERY EASY TO REPRODUCE. I'D SET THE CAR TO 30 MPH VIA CRUISE CONTROL AND DRIVE DOWN A STRAIGHT ROAD WITH VERY SLIGHT UPWARD AND DOWNWARD SLOPES. WHILE IT HAPPENS EVEN ON FLAT GROUND, I FOUND THAT A SLIGHT DECLINE IS MOST LIKELY TO REPRODUCE THE FEELING. MY BEST GUESS IS THAT THERE'S SOMETHING ABOUT THE WAY THE FUEL SUPPLY SYSTEM/TRANSMISSION IS TRYING TO DETERMINE WHETHER OR NOT DIESEL NEEDS TO BE SUPPLIED TO THE ENGINE. THE FUEL SUPPLY SYSTEM SEEMS TO ALMOST CUT OUT BECAUSE GIVING DIESEL WOULD PRODUCE A SPEED TOO HIGH, AND THEN IT COMES BACK ON SUDDENLY, BECAUSE GIVING IT NO DIESEL WOULD CAUSE THE CAR TO SLOW TOO MUCH. WHILE SOMETIMES THIS IS SIMPLY A NUISANCE, I HAVE HAD ON MANY OCCASIONS FELT THAT IT WAS A GENUINE SAFETY HAZARD SINCE I COULDN'T PREDICT HOW THE ENGINE WOULD REACT. THIS IN COMBINATION WITH OVERLY STRONG ENGINE BREAK WHEN LETTING OFF OF THE ACCELERATOR AND DELAYED ACCELERATION WHEN STEPPING ON THE PEDDLE THAT CAN CAUSE INCONSISTENCIES AND SAFETY HAZARDS WHEN MANEUVERING IN STOP AND GO TRAFFIC ON THE HIGHWAY. I'VE MENTIONED THIS PROBLEM EVERY SINGLE TIME I'VE TAKEN MY CAR IN FOR IT'S REGULARLY SCHEDULED MAINTENANCE. THE VEHICLE HAS A DIESEL DSG ENGINE, AND AS I'VE BEEN TOLD BY SERVICE TECHNICIANS AND REPRESENTATIVES, SOME OF THE THINGS LIKE STRONG ENGINE BREAKING ARE ASSOCIATED WITH THIS TYPE OF ENGINE. HOWEVER, THE CAR'S ROCKING MOTION CERTAINLY GOES BEYOND ANYTHING THAT COULD REALISTICALLY BE CONSIDERED NORMAL AND SAFE. *TR

Mileage: 6,000

I HAD JUST EXITED THE HIGHWAY, WHEN THE ENGINE DIED AT 35 MPH. THE CAR WOULD NOT RESTART AFTERWARDS. THE DEALER INDICATED THAT THE FUEL SYSTEM WAS CONTAMINATED WITH METAL SHAVINGS. THIS APPEARS TO BE ANOTHER CASE OF FAILURE OF THE HIGH PRESSURE FUEL PUMP WITH THE 2.0 TDI ENGINE. ONLY DIESEL FUEL HAS *EVER* BEEN USED IN THE VEHICLE. AS PER VW'S TSB, THE DEALER TESTED THE FUEL AND INDICATED THAT IT WAS OK. VW COVERED THE REPLACEMENT OF THE ENTIRE FUEL SYSTEM UNDER WARRANTY. OTHERWISE, THIS WOULD HAVE COST APPROXIMATELY $10K. *TR

Mileage: 45,000

TDI DIESEL JETTA WITH 30,000 MILES BY ORIGINAL OWNER WAS BEING DRIVEN 35 MPH CITY SECONDARY STREETS, VEHICLE ABRUPTLY LOST POWER. COASTED TO SIDE OF ROAD. POLICE WERE CALLED, THEY ASCERTAINED THAT LOCATION WAS SAFE ENOUGH UNTIL TOW. TOWED TO DEALER. DEALER SAID FUEL PUMP HAD FAILED. VEHICLE HAD BEEN TO DEALER A FEW DAYS BEFORE FOR 30,000 MILE SERVICE. DIESEL FUEL ALMOST ALWAYS PURCHASED AT SAME 3 YR OLD BUSY STATION, AND CAR WAS RUNNING ON SAME TANK OF FUEL AS WHEN IT WAS SERVICED. THERE WAS NO WARNING OF PROBLEMS, NO HESITATION, NO LOSS OF POWER, NO WARNING LIGHTS BEFORE TOTAL SHUTDOWN OF ENGINE. ON A FREEWAY, THIS COULD HAVE BEEN VERY DANGEROUS. *TR

Mileage: 30,000

JETTA TDI HIGH-PRESSURE FUEL PUMP & FUEL LINE BLOW-OUT; STALLING OF ENGINE. *TR

Mileage: 14,185

CAR ENGINE STOPPED SUDDENLY WHILE DRIVING. DRIFTED TO SIDE OF ROAD; CAR WOULD NOT RESTART. HAD TO PAY $250 FOR TOW TO DEALER. SERVICE PERSON CALLED TO SAY THERE WAS METAL IN MY FUEL SYSTEM/TANK, BUT THEY DIDN'T KNOW WHAT WAS WRONG. HE ALSO ACCUSED ME OF PUTTING THE WRONG GAS IN MY CAR. I INFORMED SERVICE PERSON THAT IT TOOK 5 SECONDS ON THE INTERNET TO LEARN ABOUT THE NHTSA INVESTIGATION INTO THE MANY HIGH PRESSURE FUEL SYSTEM FAILURES THAT CAUSE ENGINE TO STOP RUNNING. INTERESTINGLY, HE CALLED BACK 2 HOURS LATER AND ACKNOWLEDGED THAT FUEL SYSTEM AND POWERTRAIN AND OTHER STUFF NEED TO BE REPLACED. THIS IS AN UNSAFE CAR. I COULD HAVE BEEN GOING 65 ON THE FREEWAY WITH A SMALL CHILD OR OTHER PEOPLE IN THE CAR, ALL OF WHOM COULD HAVE BEEN SERIOUSLY INJURED WHEN CAR SUDDENLY LOOSES ALL POWER AND MOMENTUM. MANY ONLINE COMPLAINT REPORTS ARE FOR SECOND FAILURES, AFTER REPAIR. I DO NOT TRUST THE SERVICE DEPT. OF ANY VOLKSWAGEN DEALER AND HAVE NO CONFIDENCE THAT THE PROBLEM IS ELIMINATED. I AM AFRAID TO DRIVE THE CAR. *TR

Mileage: 47,000

2011 JETTA TDI DIESEL - SECOND OCCURRENCE OF ENGINE STALL DUE TO HIGH PRESSURE FUEL PUMP (HPFP) FAILURE WHILE DRIVING AT 40 PLUS MILES PER HOUR. CAR STALLED AND WOULD NOT RESTART AND HAD TO BE TOWED TO DEALER. THIS IS THE SECOND TIME THAT THIS CAR HAS BEEN TOWED DUE TO A DEFECTIVE DESIGN WHICH RESULTS IN THE HIGH PRESSURE PUMP FAILING SENDING DEBRIS THROUGHOUT THE SYSTEM. NHTSA SAYS IN CONCLUDING STATEMENTS DATED 12/21/12 THAT (NHTSA RECALL NO. 11V-490) 'THE ACTION TAKEN BY VOLKSWAGEN IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION. I CAN ASSURE YOU THAT THE DEFECT REMAINS AND IS POTENTIALLY A SERIOUS SAFETY ISSUES AS THE CAR SUDDENLY STALLS WHILE IN MOTION. AS THIS IS THE SECOND REPLACEMENT OF THE FUEL SYSTEM THE DEFECT REMAINS A PROBLEM AND THE CONSUMER IS EXPOSED TO NOT ONLY SAFETY ISSUES BUT HIGH COSTS IN REPAIR AT $10,000+ IF THE CAR IS NOT UNDER WARRANTY. THE TREND IS CONTINUING WITH 2012 TDIS AS WELL. PLEASE FORCE VW TO ADDRESS THIS ISSUE AS I NOW HAVE AN UNSAFE CAR. *TR

Mileage: 40,812

HIGH PRESSURE FUEL PUMP FAILURE CONFIRMED BY VW DEALER. WAS DRIVING 35 MPH WHEN CAR BEGAN TO LOSE POWER, ENGINE MALFUNCTION LIGHT (YELLOW COILS) LIT UP AND CAR LOST ALL POWER. MALFUNCTION LIGHT WENT OFF AND ALTERNATOR AND CATALYTIC CONVERTER LIGHTS CAME ON. CAR COULD NOT BE RESTARTED AND WAS TAKEN DIRECTLY TO DEALER ON FLATBED. REPAIRS ARE UNDERWAY. *TR

Mileage: 21,173

DRIVING 55MPH CAR BEGAN LOOSING POWER CHECK ENGINE AND GLOW LIGHT INDICATOR LIGHTS CAM ON IMMEDIATELY. ONCE ARRIVED HOME WE VERIFIED THE CAR COMPUTER IT RETURNED THAT THERE WAS LOW PRESSURE IN FUEL LINE AND THAT THE CATALYTIC CONVERTER WAS FAILING. WE HAD CAR TOWED TO NEAREST DEALERSHIP. AFTER 4 DAYS DEALER STATED FUEL HAD TRACES OF GASOLINE, THIS IS NOT POSSIBLE I HAVE NEVER PUT GAS IN MY DIESEL CAR. I IMMEDIATELY BEGAN MAKING PHONE CALLS AND THE FUEL COMPANIES WHERE FUEL PURCHASED FOR LAST 5 FUELINGS WHERE REQUESTED. LAST PURCHASE FROM SHEETZ HAGERSTOWN I NOTIFIED THEM WHAT DEALERSHIP WAS PROPOSING THE CORPORATE OFFICE IMMEDIATELY CONTACTED THE DEALERSHIP 'SHARRETTS' AND REQUESTED PROOF OF THEIR BLAME. ONCE I HAVE MADE CONTACT TO SHEETZ AND SHELL THEY INTURN CALL DEALERSHIP THE DEALER STATED THAT THERE WAS METAL SHAVINGS NOTED IN ADDITION TO THE FUELRAIL SYSTEM FAILURE. ON THIRD CALL TODAY THEY WERE NOT SURE IT WAS COVERED AND A FUEL TEST WAS BEING SENT OUT FOR OFFICIAL TESTING TO DETERMINE THE PRESENCE OF GASOLINE CONTAMINATION. AFTER I THREATENED A LAWYER THEY STATE WILL CALL CORPORATE FOR DIRECTION AND HAVE REP REVIEW. VW HAS CONTINUOUSLY LIED TO MANY OWNERS THAT THE DIESEL WAS CONTAMINATED WHEN IN FACT IT IS NOT, THIS SHOULD NOT BE ALLOWED MY CAR IS ONLY 1 YEAR OLD PURCHASED NEW WITH ONLY 4 MILES ON IT I HAVE MADE ALL THE SCHEDULED MAINTENANCE CHECKS AND HAD 3 RECALLS FIXED WITHIN 7 MONTHS OF OWNERSHIP. I DEMAND AN INVESTIGATION AND AN EXTENDED WARRANTY ON THESE DIESEL MOTORS THIS IS NOT FAIR TO THE CONSUMER. *TR

Mileage: 35,465

I WAS DOING MY 20K SERVICE (DIESEL FUEL FILTER). WHEN I OPENED THE FUEL FILTER HOUSING I FOUND METAL SHAVINGS IN, AND ON TOP OF THE FUEL FILTER CARTRIDGE. I HAD THE CAR TOWED RIGHT TO A VW DEALERSHIP KNOWING THAT THERE IS A MAJOR ISSUE, AND ONGOING INVESTIGATION WITH THE NHTSA ON HPFP FAILURES. VW AGREED THAT THEY SAW METAL IN THE FUEL AND ON THE FILTER, AND PROCEEDED TO TELL ME THAT THIS WAS "NOT ABNORMAL". THAT EVERY TDI CAR THEY SERVICE HAS METAL BITS IN THE FILTER. I AM A ASE MASTER TECH IN A HIGH VOLUME LOCAL REPAIR SHOP THAT DEALS IN A VERY HIGH VOLUME OF DIESEL REPAIR SERVICE. METAL IN FUEL IS NOT NORMAL. THERE IS ONLY ONE PLACE FOR THE METAL TO COME FROM, AND THAT IS THE HPFP. VW PUT A NEW FILTER IN THE CAR AND SENT ME ON MY WAY. I GUESS I HAVE TO WAIT FOR THE CAR TO STOP DEAD IN TRAFFIC AND NOT RESTART TO DO ANYTHING ABOUT IT. *TR

Mileage: 19,900

AS I WAS DRIVING MY 2011 JETTA TDI SPORTSWAGON, I NOTICED A STEAM COMING FROM UNDER THE HOOD, AND DIESEL SMELL INSIDE OF THE VEHICLE. WHEN I OPENED THE HOOD THERE WAS DIESEL ALL OVER THE ENGINE AND BELTS, AND LARGE AMOUNT OF STEAM WAS COMING OUT. WHEN I TOOK OF THE ENGINE COVER AND STARTED THE CAR I NOTICED THAT THERE WAS A LEAK IN THE 2ND CYLINDER INJECTOR PIPE. I DO NOT HAVE WARRANTY ON THE VEHICLE, BUT THIS ISSUE SHOULD BE FIXED AND PAID BY VW. THERE IS SMELL IN THE VEHICLE, FOAM IS SOAKED WITH DIESEL, AND BELTS MIGHT HAVE LESS LIFE IN THEM. PLEASE ADDRESS THIS ISSUE SO THIS WOULD BE FIXED AT NO COST TO ME. *TR

Mileage: 9,750

I WAS APPROACHING A HIGHWAY INTERSECTION, AND THE VEHICLE'S GLOW-PLUG LIGHT CAME ON. THE ENGINE IMMEDIATELY SHUT DOWN, AND I WAS ABLE TO STOP JUST SHORT OF THE INTERSECTION. THE VEHICLE WOULD NOT START AGAIN. AAA TOOK THE VEHICLE TO THE LOCAL DEALERSHIP VIA FLATBED. THE DEALERSHIP INITIALLY THOUGHT THE PROBLEM WAS WATER IN THE FUEL, BUT AFTER FLUSHING THE FUEL SYSTEM, THE VEHICLE STILL WOULD NOT START. AT THAT POINT, THEY TOOK APART THE FUEL PUMP, AND DISCOVERED THAT THE PUMP HAD FAILED INTERNALLY, AND PUT METAL SHAVINGS INTO THE FUEL SYSTEM. REPAIR QUOTE WAS APPROXIMATELY $10,000. *TR

Mileage: 16,000

WHILE DRIVING AT 75 MPH ON THE HIGHWAY THE VEHICLE LOST POWER. THE CHECK ENGINE LIGHT BEGAN FLASHING, AS DID THE DPF LIGHT AND THE PRE-HEAT COIL LIGHT. I WAS ABLE TO GET THE VEHICLE OFF THE HIGHWAY AND INTO A DRIVEWAY BEFORE IT QUIT. WOULD NOT START AGAIN. HAD VEHICLE TOWED TO DEALERSHIP THE NEXT DAY. WAS INFORMED THAT THE HPFP FAILED, AND THAT THE PUMP AND FUEL DISTRIBUTION SYSTEM HAD TO BE REPLACED. SERVICE DIRECTOR INDICATED THAT THE REPAIR BILL WOULD BE $10-11,000. VW IS COVERING THE COST OF THE REPAIR. AM GRATEFUL THAT I HAD DROPPED MY WIFE AND YOUNG DAUGHTER OFF AT HOME, AND THAT I WAS NOT IN HEAVY TRAFFIC WHEN THIS OCCURRED. *TR

Mileage: 54,276

TRAVELING IN THE LEFT LANE ON 95 N OUTSIDE BALTIMORE MD AT 65 MPH MY VEHICLE'S GAS PEDAL STOPPED RESPONDING AND THE CAR BEGAN TO LOSE POWER AND LURCH FORWARD AND EVENTUALLY DIE AS THE YELLOW DIESEL ENGINE INDICATOR ALONG WITH THE YELLOW ENGINE INDICATOR BEGAN BLINKING. I WAS ABLE TO AVOID TWO LANES OF TRAFFIC AND COAST OVER TWO LANES TO AN OFF RAMP BEFORE THE STEERING WHEEL LOCKED. AFTER CONTACTING VW ROADSIDE ASSISTANCE THE VEHICLE WAS TOWED TO HERITAGE VW LOCATED AT 9215 HARFORD ROAD #2 PARKVILLE, MD 21234 (877) 398-1963. IT WAS AFTER 9:00 P.M SO THE VEHICLE WAS LEFT IN THE LOT AND ALL THE PAPERWORK WAS DROPPED IN THE BOX. THE SERVICE DEPARTMENT CITED A FUEL PUMP MALFUNCTION ALONG WITH A FAULTY FUEL GAUGE AS THE ISSUE. THIS IS THE SECOND TIME WE HAVE HAD TO SUBMIT A REPORT TO YOUR AGENCY FOR THE EXACT SAME ISSUES (PLEASE SEE REFERENCE NUMBER 10417213), THE AGENTS INFORMATION IS LISTED BELOW. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 18,200

FILLED UP WITH 13.455 GALLONS OF #2 ULSD DIESEL ON 01/25/12 WITH 11,363 MILES ON THE VEHICLE. PRIOR TO FILLING THE VEHICLE HAD LESS THAN A 1/4 TANK OF DIESEL. ON 02/05/12 WAS TRAVELING IN VEHICLE AT APPROXIMATELY 45 MPH AND STARTED TO HEAR PINGING NOISES FROM THE ENGINE BAY. SLOWED TO A STOP WHERE THE ENGINE DIED AND REFUSED TO START. THE VEHICLE HAD 11,721 MILES ON IT, 358 MILES (90% WHICH WERE HIGHWAY MILES) SINCE THE PREVIOUS FUELING. VEHICLE WAS TOWED TO LOCAL VW DEALER WHERE I WAS TOLD THE TANK WAS DRY AND HPFP HAD FAILED AS A RESULT. CONTESTED THE FACT THAT THE TANK WAS DRY GIVEN THE FACT THE VEHICLE HAD SLIGHTLY LESS THAN 1/4 TANK PRIOR TO THE FAILURE AND THAT IT WAS IMPOSSIBLE THAT IT HAD RUN DRY GIVEN THE FACT THAT THE TANK HAD BEEN FILLED TO THE TOP AT THE PRIOR FILLING AND THAT I HAD NOT DRIVEN ENOUGH DISTANCE TO HAVE USED UP THE FUEL. VW TECH CONFIRMED THAT THE GAS GAUGE WAS OPERATIONAL AND CORRECT. VW DEALER REPLACED HPFP UNDER WARRANTY BUT WOULD NOT LISTEN TO ME WITH REGARDS TO RUNNING THE TANK DRY. *TR

Mileage: 11,721

I WAS OPERATING THE CAR ON A HIGHWAY WHEN THE CAR LOST ALL POWER IN TRAFFIC. I WAS LUCKY THAT I WAS ABLE TO GET TO THE SIDE OF THE ROAD WITHOUT A SERIOUS INCIDENT OCCURRING. I WAS A BIT SHAKEN AS THE CAR JUST TOTALLY FAILED IN TRAFFIC. THE CAUSE ACCORDING TO THE DEALER IS CATASTROPHIC FAILURE OF THE INJECTOR PUMP (DIESEL). DEALER INFORMED ME THAT THE INJECTOR PUMP, INJECTORS, INJECTOR LINES, PRIMARY FUEL LINES, PRIMARY FUEL PUMP, AND THE FUEL TANK ALL HAD TO BE REPLACED BECAUSE THE INJECTOR PUMP TOTALLY CAME APART AND DISTRIBUTED METAL THROUGHOUT THE FUEL SYSTEM. THIS CAR HAS LESS THAN 21K ON IT. DEALER ADMITTED THAT THE INJECTOR PUMPS ARE OF QUESTIONABLE QUALITY AND THERE IS A HISTORY OF FAILURE DUE TO INFERIOR PARTS IN THE PUMPS. DEALER SAID THAT THE NEW PUMP IS UPGRADED AND AFTER THE ENTIRE FUEL SYSTEM IS REPLACED THE CAR WILL BE TROUBLE FREE. DEALER ALSO NOTED THAT THE FUEL PUMPS ARE DESIGNED TO OPERATE ON EUROPEAN DIESEL WHICH CONTAINS SULFUR FOR LUBRICITY. US DIESEL WHICH HAS LOW SULFUR IS DESTROYING THE PUMPS. SEEMS AS THOUGH A TOTAL RECALL SHOULD BE ORDERED TO REMOVE THESE BAD INJECTOR PUMPS. DEALER STATED THE TOTAL COST OF THE WORK IN EXCESS OF 10K WHICH WILL BE PAID BY VW AT NO COST TO ME. *TR

Mileage: 20,850

REFERENCE: NHTSA ACTION NUMBER: EA11003 - PLEASE ADD US TO ONGOING INVESTIGATION OUR 2011 VOLKSWAGEN JETTA SPORTWAGEN TDI ONLY 4 MONTHS OLD WITH 3500 MILES - FAILED ON THE HIGHWAY WHILE TRYING TO ACCELERATE AROUND A DANGEROUS SITUATION. THE A BLINKING GLOW PLUG LIGHT CAME ON AND THE CAR WENT INTO LIMP MODE (NO POWER) ON THE HIGHWAY AT HIGH SPEEDS. (FWIW - A BABY + PREGNANT WIFE DRIVING). ABLE TO REPRODUCE AFTERWARDS - PRESSING A HARD THROTTLE/ACCELERATING WOULD DISABLE THE VEHICLE INTO LIMP MODE. REPORT CAME BACK THE ENTIRE FUEL SYSTEM - HPFP NEEDED TO BE REPLACED. A BRAND NEW VEHICLE SHOULD NOT HAVE A FAILURE LIKE THIS FROM JUST FILLING UP THE TANK THE PREVIOUS DAY. WE HAVE KEPT ALL RECEIPTS, LOGGED MILES AND HAD THE STATE DEPT SHUT DOWN THE STATION AND PULL A FULL LAB REPORT ON THE FUEL. EVERYTHING CHECK OUT OK BY THE STATE STANDARDS. *TR

Mileage: 3,500

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE VEHICLE DID NOT HAVE THE VIBRATION DAMPER ISOLATIONS INSTALLED IN THE FUEL INJECTION LINES. THE DEALER AND THE MANUFACTURER WERE CONTACTED AND THEY ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 11V490000 (FUEL SYSTEM, DIESEL) AND DENIED ASSISTANCE WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 7,000.

Mileage: 7,000

I WAS TRAVELING ON A PA INTERSTATE WHEN A WARNING LIGHT BEGAN FLASHING ON MY DASHBOARD. I IMMEDIATELY LOST ACCELERATION IN MY VEHICLE, AND WHEN I PULLED OFF TO THE SHOULDER OF THE ROAD DIESEL FUEL WAS RUNNING FROM BENEATH MY VEHICLE OFF TO THE SHOULD OF THE ROAD. I WAS UNABLE TO MAKE IT TO THE NEAREST EXIT AND HAD TO WAIT FOR ASSISTANCE FROM THE POLICE AND A TOWING COMPANY. THERE WAS NO WARNING THAT ANYTHING WAS GOING WRONG UNTIL IT HAPPENED. THE EVENTS ALL HAPPENED WITHIN 20 SECONDS OF EACH OTHER, WITH NO OTHER WARNING. *TR

Mileage: 16,000

NOTE: TDI (DIESEL) ENGINE, HIGH-PRESSURE FUEL PUMP (HPFP) FAILURE. DRIVER WAS DRIVING 75 MPH ON THE INTERSTATE WHEN THE ENGINE MALFUNCTION (FLASHING COIL) LIGHT ILLUMINATED AND THE CAR STALLED. CAR COASTED TO A STOP, BUT WOULD NOT RESTART. CALLED MANUFACTURER ROADSIDE ASSISTANCE AND THEY PROMPTLY SENT A FLATBED TOW TRUCK TO TRANSPORT VEHICLE TO DEALERSHIP. THE DEALERSHIP DETERMINED THERE WAS METAL DEBRIS IN DIESEL FUEL FILTER AND IN HIGH-PRESSURE FUEL PUMP (HPFP) AND THAT THE HPFP HAD FAILED DESTRUCTIVELY DISTRIBUTING METAL DEBRIS THROUGHOUT THE FUEL SYSTEM. ENTIRE FUEL SYSTEM (TANK TO INJECTORS) WAS REPLACED UNDER WARRANTY BY MANUFACTURER. UPDATED 11/07/11 *BF

Mileage: 13,400

THE DIESEL FUEL HIGH PRESSURE FUEL PUMP FAILED CAUSING METAL PARTICLES TO CONTAMINATE THE ENTIRE FUEL SYSTEM. *TR

Mileage: 7,100

2011 VW JETTA TDI BEGAN TO FEEL SLUGGISH AROUND 7,200 MILES. AT 8240 GOING 35 MPH CAR DIED AND WOULD NOT START. TOLD ENTIRE FUEL SYSTEM NEEDS REPLACED. *TR

Mileage: 8,240

DURING SHORT DRIVE HOME, THE GLOW PLUG LIGHT STARTED FLASHING, THE CAR THEN WENT INTO LIMP MODE. WHEN I GOT HOME, 2 MILES LATER, THE CAR DIED AND WOULD NOT START. I HAULED THE CAR TO THE VW DEALER AND THEY SAID MY HPFP FAILED. VW IS GOING TO FIX IT UNDER WARRANTY, I PRODUCED THE LAST 4 FUEL FILL UPS SHOWING NO GAS HAD BEEN PUT IN THE CAR. THIS WAS A 2011 JETTA TDI, MANUFACTURE DATE UNKNOWN, BUT CAR WAS PURCHASED IN JANUARY. *TR

Mileage: 27,000

CRACK IN SUPPLY LINE TO #2 INJECTOR. FUEL SPRAY ALL OVER BACK OF ENGINE/ENGINE COMPARTMENT AND ONTO GROUND WHILE DRIVING, FUEL MIST/FILM ALL OVER BACK OF CAR. "ENGINE CONTROL FAILURE" WARNING LIGHT CAME ON. STOPPED TO INVESTIGATE, NOTICED DIESEL SMELL, BUT DIDN'T SEE ANYTHING ELSE (IT WAS DARK). RESTARTED, LIGHT NO LONGER ILLUMINATED. AFTER ABOUT 2 MILES, LIGHT CAME BACK ON ALONG WITH "CHECK ENGINE" WARNING LIGHT. I WAS CLOSE TO HOME, SO I CAME ON TO THE HOUSE. THERE I NOTICED A STRONGER DIESEL SMELL, THE FILM ON THE BACK OF THE CAR. GOT FLASHLIGHT AND NOTICED THE FUEL DRIPPING AND THE FUEL IN THE ENGINE COMPARTMENT. CALLED VW 24 HOUR ROADSIDE ASSISTANCE AND HAD THE CAR TOWED TO NEAREST DEALER ON THE NEXT MORNING, A SATURDAY. THEIR DIAGNOSIS (MONDAY) WAS CRACKED FUEL LINE. I ASKED WHICH CYLINDER/INJECTOR, SHE SAID #2. I ASKED THEM TO SAVE PARTS AND TO DOCUMENT AND INFORMED THEM THAT THERE WAS AN INVESTIGATION. THE REPAIR SHOULD BE COMPLETED BY END OF DAY ON TUESDAY. PART HAD TO BE OVER-NIGHTED FROM SOMEWHERE ELSE. *TR

Mileage: 20,061

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE HIGH PRESSURE FUEL HOSE FRACTURED AND CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE HIGH PRESSURE FUEL HOSE WAS REPLACED. THE FAILURE MILEAGE WAS 21,015.

Mileage: 21,015

VEHICLE LOST POWER ABOVE 1000 RPM WHILE DRIVING ON FREEWAY. AFTER COASTING TO A SAFE LOCATION, FOUND ENGINE COMPARTMENT SOAKED WITH FUEL. VEHICLE HAD LEFT A TRAIL OF FUEL BEHIND IT. VEHICLE WAS REPAIRED BY DEALER: FUEL LINE FROM THE COMMON RAIL TO INJECTOR #2 WAS REPLACED. *TR

Mileage: 12,000

ENGINE POWER LOSS, UNPREDICTABLE THROTTLE BEHAVIOR AND UNKNOWN ENGINE RPM RESPONSE TO ACCELERATOR PEDAL POSITION 8/30 NEW CAR DEALER FUELED FULL TANK OF DIESEL 6PM: STOPLIGHT INTERSECTION PULL AWAY ON GRN LIGHT:: ENGINE RPM DROPS TO IDLE IN MIDDLE OF INTERSECTION <RESPONSE: DEPRESS ACCELERATOR NO CHANGE IN RPM MOMENTARILY THEN INSTANT ACCELERATION @ MODERATE-TO-HIGH RPM> UNCONTROLLED SITUATION AS TRAFFIC BEHIND DIDN'T HAVE ANY WARNING OF SLOW IN MIDDLE OF INTERSECTION, NO BRAKE LIGHTS, FORCED TRAFFIC BRAKING TO AVOID OVERRUNNING MY STALLING CAR. 7:40PM: IN-TOWN DRIVING:: DROPOUT OF RPM LOSS OF POWER MOMENTARILY <2000RPM <NO RESPONSE> NO CONSEQUENCE 8/31 7:55AM: RH TURN FROM LEVEL ROADWAY TO MODERATELY STEEP INCLINED SIDE STREET:: ENGINE RPM DROPPED COMPLETELY TO IDLE AND SUSTAINED LOSS OF POWER < RESPONSE: MAINTAINED ACCELERATOR PEDAL POSITION DURING DROP THEN DEPRESSED EXPECTING RPM RECOVERY CONTINUING TO WOT WHEN NO CHANGE IN RPM {BRAKE TO HOLD CAR ON INCLINE} RELEASE PEDAL AND STARTOVER> NO CONSEQUENCE 7:56AM: LH TURN INTO PARK:: NO THROTTLE RESPONSE RPM DROP FROM LOW RPM TO IDLE < RESPONSE: MAINTAINED ACCELERATOR PEDAL POSITION WATCHING FOR RPM POWER RECOVERY OR PICKUP IN RPM TO NO EFFECT {BRAKE TO STOP CAR FROM HITTING STRUCTURE IN FRONT OF PARKING PLACE} STARTOVER> DANGEROUS CIRCUMSTANCE WITH OBSTACLE IN FRONT OF CAR PARKING SPOT WITH 2 FT. REMAINING TO PULL CAR OUT OF TRAVELED ROADWAY AND INTO THE PARKED POSITION. I DID NOT LIKE THE LOSS OF ENGINE CONTROL UNPREDICTABLE THROTTLE BEHAVIOR AND UNKNOWN ENGINE POWER RESPONSE TO DRIVER INPUT. FIRST INDICATION THAT THESE REPEATING ENGINE FAILS ARE NOT BENIGN. *TR

Mileage: 277

WHILE DRIVING MY 2011 VOLKSWAGEN JETTA TDI SPORTWAGON ON INTERSTATE 94 IN MICHIGAN I OBSERVED WHITE SMOKE COMING OFF MY VEHICLE ENGINE. THERE WAS NO WARNING LIGHT. DUE TO THE HEAVY SMOKE AND DIESEL FUMES I PULLED THE VEHICLE TO SAFE LOCATION AND SOUGHT SERVICE. THE VEHICLE DEVELOPED A HEAVY LEAK IN ONE OF THE FUEL INJECTION LINES ON TOP OF THE ENGINE BLOCK. THE VEHICLE WAS COVERED WITH DIESEL FUEL FROM FRONT TO THE REAR OF THE VEHICLE. THE VEHICLE WAS REPAIRED BY VOLKSWAGEN. *TR

Mileage: 11,000

WHILE DRIVING ON THE HIGHWAY WE STARTED TO SMELL DIESEL FUEL. WHEN WE STOPPED WE NOTICED FUEL DRIPPING FROM THE CAR. VOLKSWAGEN WAS CONTACTED TO COME TOW THE CAR TO THE NEAREST DEALER. BEFORE THEY WOULD TOW THE CAR THEY REQUESTED THAT I HAVE THE FIRE DEPARTMENT COME OUT AND CERTIFY THE CAR SAFE TO TOW. ONCE THE DEALER DIAGNOSED THE PROBLEM THEY STATED ONE OF MY O RINGS HAD WEEKEND CAUSING A #2 INJECTOR LINE LEAK. THEY REPLACED THE PART, CLEANED UP THE CAR AND RETURNED IT TO ME.

Mileage: 9,622

THE HIGH PRESSURE FUEL SYSTEM IS LEAKING FROM ONE OF THE FUEL INJECTORS. THERE IS CURRENTLY AN INVESTIGATION GOING ON THAT WAS BROUGHT MY ATTENTION TO SEE IF I HAD THE PROBLEM. AND IT LOOKS AS IF I DO.

Mileage: 8,100

SMOKE FROM UNDER THE HOOD WHILE DRIVING - DROVE DIRECTLY TO DEALER. RESULT WAS INJECTOR LEAK. *TR

I'D LIKE TO ADD MY VEHICLE TO THIS INVESTIGATION #: PE11023 - AFTER READING ABOUT THIS STORY TODAY - I CHECK THE ENGINE BAY AND FOUND POOLING LIQUID ABOVE THE #1/2 INJECTORS ON MY '11 JETTA SPORTWAGEN TDI WITH ONLY 850 MILES. HTTP://FILES.ETIVITI.COM/MISC/11JSWTDI/IMG_2010_SM.JPG HTTP://FILES.ETIVITI.COM/MISC/11JSWTDI/IMG_2016_SM.JPG. *TR

Mileage: 850

2011 VOLKSWAGEN JETTA SPORTSWAGON TDI. CAR STALLED IN TRAFFIC AND WOULD NOT RESTART. EXTREMELY DANGEROUS SITUATION AS THERE WERE CARS FOLLOWING BEHIND AS CAR STOPPED WITHOUT WARNING. ALSO, DURING THE STALL CAR LOST POWER STEERING AND WAS DIFFICULT TO MANEUVER TO SITE OF STREET. CAR WOULD NOT RE-START AND HAD TO HAVE IT TOWED. CAR WAS NEARLY NEW (JUST OVER 2 MONTHS AND HAD LESS THAN 3,000 MILES). *TR

Mileage: 2,947

FUEL LEAKING OUT OF INJECTORS VOLKSWAGEN 2011 JETTA SPORT WAGON TDI *TR

Mileage: 3,600

VEHICLE WILL ACCELERATE AND DECELERATE UPON ACCELERATION AT A STOP SIGN, OR MOST OFTEN WHEN TRAVELING AT 25-45 MPH. SUSPECT LINK TO RECENT INVESTIGATION INTO FUEL LINE LEAKAGE. SERVICE MANAGER AT DEALERSHIP HAS STATED HE FEELS AS THOUGH HE HAS "BEEN HIT FROM BEHIND" AT AND MPH UP TO FREEWAY SPEEDS IN HIS 2011 JETTA TDI.

Mileage: 200

FUEL LEAK ON VW JETTA TDI DEALER CHANGED LINE AND INJECTOR ON #2 CYLINDER. *TT

Mileage: 7,764

2011 VW JETTA SPORTWAGEN TDI SURGING AT TIMES AND SPUTTERING. ONLY 1000 MILES AND HAVE HAD FOR 2 WEEKS. THE CONTROLLABILITY AT THAT SURGING MOMENT SEEMS OFF AND IF IT'S DOING THAT WHILE I NEED TO AVOID SOMETHING OR SOMEONE IT COULD BE DANGEROUS. ALSO SURGING OR BUCKING WHILE YOU STOP. RECIPE FOR A REAR END COLLISION. THIS IS A 6SPD AUTOMATIC AND IT FEELS LIKE A WEIRD DOWNSHIFT AS YOU COME TO A STOP. FINALLY WINDOW NOW DECIDES TO GO DOWN ON IT'S OWN THIS COULD BE AN ISSUE AT THE WRONG TIME IN A RAIN OR SNOW STORM. *TR

Mileage: 750

WHILE ON AN OUT OF STATE ROAD TRIP. WE STOPPED AT A FUEL STATION AND SMELLED A REALLY STRONG DIESEL SMELL. THINKING THERE WAS JUST DIESEL SPILL AT THE FUEL STATION WE CONTINUED ON OUR WAY ON THE INTERSTATE. APPROX. 30 MILES LATER DOWN THE INTERSTATE OUR GLOW PLUG LIGHT STARTED TO BLINK, WHICH INDICATED A PROBLEM WITH THE ENGINE. WE WENT TO THE NEAREST EXIT AND STOPPED THE CAR. WHEN WE GOT OUT THE DIESEL SMELL WAS EVEN STRONGER. SMOKE WAS COMING FROM THE HOOD AND DIESEL WAS HEAVILY DRIPPING FROM THE WHOLE UNDERSIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALERSHIP IN OREGON. THE DEALERSHIP TOLD ME IT WAS A #2 FUEL INJECTOR LEAK AND THAT VOLKSWAGEN WANTS THEM (THE DEALERSHIP IN OREGON) REMOVE THE ENTIRE ENGINE AND SEND IT TO GERMANY FOR EXAMINATION ON A TEST STAND. THREE WEEKS AFTER THE CAR WAS TOWED TO THE OREGON DEALERSHIP THEY CALLED ME AND INFORMED ME I COULD COME GET IT. I DROVE BACK TO OREGON TO GET THE CAR AND IT STILL SMELLED EXTREMELY STRONG OF DIESEL AND THE EXTERIOR WAS STILL COVERED IN THE DIESEL THAT LEAKED FROM THE ENGINE. I ASKED THE SERVICE DEPARTMENT TO CHANGE THE FIBER ENGINE COVER. THEY TOLD ME THERE WAS NO REASON TO DO THAT AND WOULD HAVE TO GET THAT APPROVED. I DROVE THE CAR BACK HOME TO CALIFORNIA AND THEN CALLED VOLKSWAGEN OF AMERICA TO GET MY CAR FIXED RIGHT. THEY HAD ME BRING IT TO THE DEALERSHIP I BOUGHT IT FROM IN ROSEVILLE, CA. ROSEVILLE VOLKSWAGEN SERVICE WORKER IDENTIFIED THE CAR HAVE A STRONG DIESEL SMELL JUST WALKING NEAR THE CAR. THEY WROTE ON THE SERVICE TICKET THAT THEY FOUND THE FIBER ENGINE COVER "SOAKED WITH DIESEL FUEL. ROSEVILLE VOLKSWAGEN HAD THE CAR FOR NINE MORE DAYS TO CLEAN AND DETAIL THE INSIDE AND OUTSIDE OF THE CAR.

Mileage: 6,422

TL*THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA SPORTWAGEN. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT FUEL INJECTOR LINE NUMBER TWO EXPLODED AND WAS LEAKING FUEL ONTO THE ENGINE. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THE FAILED ENGINE WOULD BE SENT TO ONE OF THEIR FACILITIES IN GERMANY TO BE INSPECTED. THE FAILURE AND CURRENT MILES WERE 6,000. UPDATED 07/20/11*LJ UPDATED 08/01/11

Mileage: 6,000

WE PURCHASED A 2011 VOLKSWAGEN JETTA TDI THAT BROKE DOWN WITH ONLY 3081 MILES. NO WARNING LIGHTS CAME ON; IT JUST STALLED OUT IN THE MIDDLE OF THE ROADWAY (WITHOUT WARNING) AND WOULDN'T START BACK UP. IT COULD HAVE CAUSED A SEVERE ACCIDENT! WE PAID AN ADDITIONAL THREE THOUSAND DOLLARS WHEN WE PURCHASED THE CAR FOR THE EXTENDED WARRANTY (BUMPER TO BUMPER), BUT THE REPAIR ISN'T COVERED (OR THE TOW BILL). WE UNKNOWINGLY PURCHASED FUEL THAT HAD WATER IN IT AND THE VOLKSWAGEN DEALER WILL NOT PAY FOR ANYTHING. THEY HAVE TO REPLACE THE ENTIRE FUEL SYSTEM! THE REPAIR WILL COST OVER $6,000.00 AND VOLKSWAGEN'S CORPORATE OFFICE IS UNWILLING TO HELP EVEN THOUGH VOLKSWAGEN FAILED TO PUT A SIMPLE SENSOR IN THE FUEL FILTER SYSTEM TO INDICATE THAT WATER WAS IS IN THE FUEL. EVERY OTHER MAJOR DIESEL ENGINE MANUFACTURER IN THE WORLD HAS A LIGHT IN THE DASH THAT INDICATES WATER IS IN THE FUEL SO THAT YOU CAN SIMPLY DRAIN THE WATER OUT BEFORE IT CAUSES THE VEHICLE TO SUDDENLY STOP RUNNING AND EXCESSIVE DAMAGE THE ENGINE. VOLKSWAGEN CHOSE TO USE A HIGH PRESSURE COMMON RAIL DIESEL FUEL SYSTEM SIMILAR TO WHAT THEIR COMPETITORS HAVE; THIS FUEL SYSTEM IS VERY SENSITIVE AND IS EASILY DAMAGED BY WATER. VOLKSWAGEN OVERLOOKED THE OBVIOUS AND FAILED TO PUT ANY TYPE OF WATER IN FUEL WARNING DEVICE ON THEIR VEHICLES EVEN THOUGH THE REST OF THE WORLD HAS BEEN USING THEM FOR YEARS AND EVEN DECADES. FORD, GM, CHEVROLET, DODGE, AND MERCEDES ALL HAVE WATER IN FUEL WARNING LIGHTS (ONE EVEN HAS A BELL THAT CHIMES FIVE TIMES TO WARN THE DRIVER THAT WATER IS IN THE FUEL. VOLKSWAGEN DIDN'T BOTHER PUTTING ANY TYPE OF PROTECTION ON THEIR EXTREMELY SENSITIVE FUEL SYSTEM. ALSO, VOLKSWAGEN SAYS THERE IS NO WAY TO KEEP IT FROM HAPPENING AGAIN! WITH A SINGLE REPAIR AT OVER 20% OF THE PURCHASE PRICE OF THE VEHICLE, WE ARE PLAYING RUSSIAN ROULETTE EACH TIME WE FILL UP WITH FUEL. ARE WE SUPPOSED TO CHANGE THE FUEL FILTER EACH TIME WE FUEL UP? THIS DANGEROUS FLAW HAS BEEN REPORTED BY OTHERS, BUT VW DOESN'T CARE! *TR

Mileage: 3,081

2011 VW JETTA TDI WITH 1445 TOTAL MILES ON THE VEHICLE SUDDENLY LOST ALL POWER WITH GLOW PLUG LIGHT ON THE DASH BLINKING. CAR WOULD NOT START AGAIN, WAS NOT DRIVABLE AND HAD TO BE TOWED INTO THE DEALER FOR REPAIRS. THE DIAGNOSIS IS THE FUEL PUMP DESTROYED ITSELF AND SENT DEBRIS THROUGH THE FUEL PUMPS, FUEL INJECTORS, FUEL LINES AND FILTER. VEHICLE HAS NOT BEEN REPAIRED AND THERE IS NO ESTIMATE OF WHEN THE VEHICLE WILL BE REPAIRED. *TR

Mileage: 1,445

AFTER DRIVING AT HIGHWAY SPEEDS FOR 1 HOUR A SIGNIFICANT AMOUNT OF SMOKE WAS OBSERVED COMING FROM THE ENGINE COMPARTMENT AFTER WE STOPPED. PRIOR TO STOPPING, THE ENGINE WAS RUNNING ROUGHLY WITH SOME REDUCED POWER. THERE WAS A STRONG SMELL OF DIESEL FUEL OUTSIDE CAR AND INSIDE CAR. VEHICLE WAS TOWED TO DEALER. LEAKING SOLID FUEL LINE TO FUEL INJECTOR #2 DIAGNOSED AND REPLACED. PHOTO'S OF DEFECTIVE PART ARE AVAILABLE. FUEL WAS LEAKING ONTO HOT ENGINE AND EXHAUST SYSTEM CREATING A POTENTIAL FIRE RISK. *TR

Mileage: 6,849

1. WAS DRIVING AT 70MPH IN 6TH GEAR, LOST POWER, CAR TURNED OFF, LIGHTS ON DASH FLASHING INCLUDING GLOW PLUG LIGHT AND "CHECK ENGINE SERVICE NOW!". HAD BEEN DRIVING ON THIS TANK OF DIESEL FOR OVER A WEEK WITH NO ISSUE. MORE THAN QUARTER TANK LEFT. 2. CAR WOULD NOT START FOR 45 MIN, FINALLY STARTED AND DROVE HOME. DROPPED OFF AT DEALER NEXT DAY FOR ALREADY SCHEDULED PANORAMIC MOON ROOF GETTING STUCK. 3. DEALER SAID METAL SHAVINGS DESTROYED HPFP (FUEL PUMP), LINES, AND INJECTORS. FUEL NOT SUSPECTED BAD OR CONTAMINATED. THEY BLAMED FACTORY DEFECT SPECIAL TO MY CAR. WILL BE REPLACING ALL UNDER WARRANTY AS OF NOW. THEY THINK IT WILL BE A WEEK OR SO, AND PROMISE THAT THIS ISSUE WILL NEVER OCCUR AGAIN. *TR

Mileage: 1,733

TL* THE CONTACT OWNS A 2011 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO DECELERATE BEFORE STALLING WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THE FUEL FILTER HAD BECOME CLOGGED. THE VEHICLE WAS IN THE PROCESS OF HAVING THE FUEL PUMP AND FILTER REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 4,800.

Mileage: 4,800

MEDIUM-PITCHED WHINE COMING FROM ENGINE - EVENTUALLY CAR LOSES ALL POWER, GLOW PLUG LIGHT FLASHES, SERVICE MESSAGE APPEARS ON DISPLAY, AND CHECK ENGINE LIGHT COMES ON. CAR GOES INTO "SAFE MODE" OR "LIMP HOME" MODE (VERY LITTLE POWER - FEELS LIKE TURBO IS SHUT DOWN). FIRST OCCURRENCE AT 2300 MILES, 2 MORE OCCURRENCES WHERE MESSAGE AND FLASHING GLOW PLUG LIGHT RESETS AFTER RESTART, 1 MORE OCCURRENCE WITH HIGH PRESSURE FUEL PUMP (HPFP) IDENTIFIED AS BAD BY VW DEALERSHIP. DEALER IS NOW ORDERING PARTS TO COMMENCE REPAIR (NO DEFINITIVE ANSWER ON WARRANTY COVERAGE). *TR

Mileage: 4,600

THERE'S A FUEL LEAK COMING FROM THE TOP OF THE (TDI) ENGINE THAT I CAN CONFIRM, BUT I WAS UNABLE TO SEE EXACTLY FROM WHAT PART. IT'S LEAKING ABOUT A THIRD TO A HALF CUP OF FUEL PER MIN. I HAD THE VEHICLE TOWED TO THE DEALER. WAITING FOR RESULTS. *TR

Mileage: 2,470

ON FRIDAY, APRIL 15TH AT APPROX 10:30PM I WAS DRIVING MY 2011 VW JETTA TDI (WITH LESS THAN 1800 MILES ON IT) ON THE HIGHWAY APPROX 2 1/2 HOURS FROM HOME AND IT STALLED. I COASTED OFF TO THE SHOULDER AND WAS NOT ABLE TO RESTART THE ENGINE. AFTER NEARLY 2 HOURS THE TOW TRUCK ARRIVED THAT VW ROADSIDE ASSISTANCE SENT AND THE CAR WAS TOWED TO THE NEAREST DEALERSHIP WHICH WAS ABOUT 60 MILES AWAY FROM THE BREAKDOWN POINT. I HAD TO SPEND THE NIGHT IN A HOTEL IN A STRANGE AREA. ON MONDAY, APRIL 18TH THE DEALERSHIP STATED AN OUTSTANDING ELECTRICAL RECALL WAS THE PROBLEM. THEY CHANGED A WIRE HARNESS AND SOME FUSES AND THE CAR WAS READY FOR PICK UP. I DROVE 100 MILES TO RETRIEVE MY CAR ON APRIL 18TH. TODAY ON APRIL 19TH AFTER SITTING IN MY DRIVEWAY OVERNIGHT THE CAR WOULD NOT START AGAIN AND WAS TOWED TO THE NEAREST VW DEALERSHIP IN MY HOME TOWN. STILL WAITING FOR WAITING FOR A DIAGNOSIS. THE DEALERSHIP STATES THEY ONLY HAVE 1 VW TECHNICIAN AND HE IS ON VACATION THROUGH FRIDAY APRIL 22ND. *TR

Mileage: 1,889

REPEATED STALLING, ROUGH RUNNING AND LOSS OF POWER ON 2011 VW JETTA SPORTWAGON TDI W/DSG AUTO TRANSMISSION. MOST FUEL PURCHASED FROM SAME BP LOCATION. ALWAYS CONFIRM DIESEL BEFORE FUELING. PROBLEM ACROSS MULTIPLE FUELINGS. RECEIPTS FOR ALL FUEL PURCHASES WITH MILEAGE RECORDED. *TR

Mileage: 3,300

I HAVE A 2011 VW JETTA SEDAN, PURCHASED IN JANUARY OF 2011. I HAD A FUEL INJECTOR FAILURE, CAUSING DIESEL FUEL TO SPRAY WITHIN THE ENGINE COMPARTMENT OF MY VEHICLE AND FUEL TO LEAK ONTO THE ROADWAY AS I WAS DRIVING. THERE WAS NO VEHICLE WARNING LIGHTS INDICATING ANY FAILURE OR LEAKAGE OTHER THAN A FUEL SMELL. WHEN I PARKED MY CAR IN MY DRIVEWAY AND TURNED OFF THE VEHICLE MY HUSBAND NOTICED FUEL LEAKING OUT OF THE VEHICLE. I AM VERY CONCERNED ABOUT THE SAFETY OF THIS VEHICLE AS THE VEHICLE AND I COULD HAVE CAUGHT ON FIRE AT ANY TIME. *TR

Mileage: 4,500

CAR WAS HEATED UP TO OPERATING TEMPERATURE DURING A ROUTINE 15 MILE DRIVE. CAR WAS THEN SHUT OFF FOR ROUGHLY AN HOUR AND THEN BEGAN ANOTHER 15 MILE DRIVE TO THE GROCERY STORE. IT SAT IN THE SUN AT THE STORE FOR ALMOST AN HOUR BEFORE IT WAS STARTED. UPON LEAVING THE PARKING LOT OF THE STORE, THE CAR COMPLETELY STALLED WHILE IN 2ND GEAR AT APPROXIMATELY 2,400 RPMS UNDER LIGHT ACCELERATION. THE CAR WOULD HAVE STOPPED IF MY WIFE WOULDN'T HAVE PUSHED THE CLUTCH IN AND HEADED FOR THE SHOULDER. UPON TURNING THE KEY ALL THE WAY AND BACK ON TO START (SEVERAL TIMES), THE ENGINE WOULD TURN OVER BUT NOT START. ABOUT THE FOURTH KEY CYCLE THE MOTOR FIRED AND PRODUCED A TON OF WHITE SMOKE. NO DASH LIGHTS CAME ON BEFORE, DURING OR AFTER THIS INCIDENT. CAR STALLED AND WAS ALMOST REARENDED BY A SEMI TRUCK IN A 25 MPH ZONE WHERE THERE IS BASICALLY NO SHOULDER. 2011 JETTA SPORTSWAGEN TDI, 6 SPD MANUAL TRANSMISSION WITH 11,500 MILES ON IT. HAS HAD TWO OIL CHANGES FROM THE DEALERSHIP OTHERWISE NO OTHER MAINTENANCE HAS BEEN PERFORMED ON THE CAR EXCEPT CHECKING THE TIRES AND ROTATING THEM. *TR

Mileage: 11,500

2011 VW DIESEL JETTA SIX SPEED MANUAL. THE COMPUTER IS PROGRAMMED TO SHUT THE ENGINE OFF AT ABOUT 750 RPM THIS NUMBER APPEARS TO BE ARBITRARY OR POSSIBLY PICKED FOR SOME FUEL ECONOMY TRADEOFF. THE PROBLEM IS THAT THIS CAUSES SOME VERY DANGEROUS CONDITIONS IN TRAFFIC. NORMALLY A DIESEL CAN BE BROUGHT DOWN TO NEARLY ZERO AND STILL POWER UP AND OUT OF A STOP. GAS ENGINES ARE NOT SO GOOD AT THIS BUT TO SOME EXTENT THIS IS AN ENGINE CONDITION THAT SHOULD BE ANTICIPATED AND SUCCESSFULLY RECOVERED FROM. VW HAS TAKEN THE OTHER ROAD. IF ONE DOES NOT REV THE ENGINE EXCESSIVELY, EVEN ON VERY SLIGHT INCLINES, THE COMPUTER LETS YOU GET ABOUT TEN FEET INTO THE INTERSECTION AND TURNS THE ENGINE OFF. THE GUY BEHIND YOU HAS TO SLAM ON HIS BREAKS IF HE IS LOOKING (YOUR BRAKE LIGHTS ARE OFF BECAUSE YOU ARE NOT USING THEM TO STOP.) OR IF HE IS LOOKING AT HIS LEFT TURN LANE, HIS PHONE OR WHATEVER, POW. OR YOU GET HALF INTO AN INTERSECTION CROSSING FROM THE STOP SIGN AND GET DROPPED IN THE MIDDLE OF THE ROAD UNTIL YOU CAN GO THROUGH THE EVOLUTION OF EVENTS ALLOWING A RESTART. RESTART EVOLUTION ALSO CONTRIBUTES TO THE DANGER AS IT TAKES SO LONG. I HAVE DRIVEN MANUAL TRANSMISSIONS EXCLUSIVELY FOR 40 LICENSED DRIVING YEARS AND A FEW YEARS PRIOR TO THAT ON THE FARM. ONE SHOULD NOT HAVE TO DRIVE WITH ONE'S HEEL ON THE TOP OF THE GAS PEDAL, BUT OVER-REVVING THE ENGINE IS THE ONLY WAY TO SAFELY START OUT FROM A STOP SIGN. THIS SHOULD NEVER HAVE GOTTEN PAST THE ENGINEERS. UNLESS OF COURSE THEY ARE NOT GUYS WHO ENJOY DRIVING. EVEN THE DEALER'S MASTER MECHANICS ARE PUZZLED THAT THEY STALL IT EVERY TIME THEY TRY TO DRIVE IT. *TR

Mileage: 20,000

MY 2011 VOLKSWAGEN JETTA SPORTWAGEN TDI HAD IT'S FUEL PUMP FAIL LEAVING MY WIFE AND CHILD STRANDED. THE CAR WAS STARTED AND SUDDENLY LOST POWER ON THE ROADWAY. CAR WAS TOWED TO DEALER WHERE IT WAS DETERMINED THAT THE FUEL PUMP HAD FAILED. PUMP FAILURE WAS CATASTROPHIC SENDING METAL SHARDS THROUGHOUT THE FUEL SYSTEM (TANK, FUEL LINES, FILTERS, ETC.) THIS HAS BEEN DOCUMENTED BY MANY OTHERS WITH THIS ENGINE (BACK TO 2009). AS OF YET THERE HAS BEEN NO RECALL BY VW. VW IS CURRENTLY TESTING MY FUEL AND HAS ORDERED PARTS FOR REPAIR. THE REPLACEMENT PART WILL BE THE SAME PART # AS THE ONE THAT FAILED. MOST PEOPLE HAVE HAD THIS HAPPEN WHILE OUT ON THE ROAD, ESSENTIALLY STRANDING THEM IN A DANGEROUS ENVIRONMENT. I LOVE MY CAR, BUT I WANT IT TO BE SAFE. *TR

Mileage: 4,000