2009 VOLKSWAGEN ROUTAN Engine Problems

The contact owns a 2009 Volkswagen Routan. The contact stated while at a stoplight, the vehicle stalled. There was an abnormally high pitch noise detected. There were no warning lights illuminated. The vehicle was jump-started by the police and was restarted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The vehicle was taken to an independent mechanic and the contact was informed that the starter needed to be replaced. The failure mileage was approximately 54,000.

Mileage: 54,000

THANK GOD I WAS NOT GOING FAST. VEHICLE SHUT DOWN COMPLETELY WHILE DRIVING. WAS ABLE TO PUT IN PARK AND WAS ABLE TO START IT BACK UP. APPARENTLY, THE ROUTAN IS MANUFACTURED BY CRYSLER AND THIS ISSUE ALSO HAPPENS WITH THE 09 TOWN AND COUNTRIES AS WELL.

Mileage: 134,000

VAN HAS STALLED WHILE DRIVING ON MULTIPLE OCCASIONS. POWER STEERING IS LOST. VEHICLE WILL THEN START RIGHT BACK UP. THIS IS EXTREMELY DANGEROUS FOR A MINIVAN USED TO TRANSPORT MULTIPLE CHILDREN. NO CODES OR FAULTS ARE RECORDED.

Mileage: 104,000

DASH FLASHING, HARD START AFTER PUTTING IN A NEW FUSE BOX AND AFTER FLASH FROM THE DEALER

Mileage: 180,000

VEHICLE HAS BEEN MOVING AND WILL SUDDENLY SHUT DOWN WHILE DRIVING. ALL POWER STEERING, BRAKING AND ELECTRICAL SYSTEMS GO OUT. I HAVE TO TRY TO MANUALLY SWERVE OFF THE ROAD AND PUT THE CAR IN PARK. TAKE THE KEY OUT OF THE IGNITION AND RESTART. I UNDERSTAND THAT THIS PROBLEM HAD BEEN FIXED IN 2015 UNDER A RECALL WITH THE WIN MODULE AND VW INDICATES THAT SINCE IT'S BEEN FIXED THEY ONLY OFFER A 12 MONTH WARRANTY. FOR ME TO GET A NEW WIN MODULE, THE DEALERSHIP SAID IT WOULD BE $2,000 AND A LONG ESTIMATED TIME WITHOUT THE CAR. THIS CAR IS BLUE BOOKED AS ONLY WORTH $3,500.00. THIS IS AGAIN A FAULTY PIECE THAT SHOULD BE COVERED BY THE RECALL. THE CAR ONLY HAS 75K MILES. THERE'S NO REASON TO HAVE A CAR WITH 75K MILES AND NEED TWO WIN MODULES SO FAR. I WANT THIS TO BE IN WRITING THAT WHEN I AM DRIVING ON I-95 AND MY CAR SUDDENLY STALLS AND MY 2 1/2 YEAR OLD AND 4 1/2 YEAR OLD AND MYSELF END UP IN A CASKET, IT'S BECAUSE OF THIS FAULTY PRODUCT WHICH THEY WILL NOT COVER AGAIN ON THE RECALL.

Mileage: 75,000

CAR ELECTRICAL SYSTEM GOES CRAZY, SPEEDOMETER NEEDLE GOES CRAZY. RADIO TURNS OFF AND ON, THEN THE VEHICLE TURNS OFF COMPLETELY. IT TURNS ON AFTER. SOMETIMES ALL THIS HAPPENS BEFORE TURNING OFF, SOMETIMES IT TURNS OFF SUDDENLY WITH NO WARNING. HAVE SPENT A LOT OF MONEY TRYING TO FIX ISSUE WITH NO LUCK. DRIVING IT MAKES ME VERY NERVOUS BUT I CAN'T CHANGE CARS RIGHT NOW. IT HAS HAPPENED BOTH ON SMALL STREETS AND HIGHWAY IN MOTION.

FIRST MY ROUTAN HAS BEEN IN MY POSESSION FOR I BELIEVE ABOUT 5 YEARS. I CHECK THE OIL REGULARY AND KEEP OIL CHANGES, TIRES, AND INSPECTIONS UP TO DATE ARE REGULAR. SINCE OWNING IT, I HAVE HAD A HUGE ANTIFREEZE LEAK (WHILE ON VACATION), WHICH WAS AN EASY FIX, BUT ESSENTIALLY THE PART MELTED AND HAD TO BE REPLACED, WHICH IS ABSURD! I WAS HAVING A LOT OF ISSUES WITH IT NOT STARTING. YOU WOULD HAVE TO TRY TO START IT OVER AND OVER, AND JUST WHEN YOU CALLED A GARAGE IT WOULD START (THIS ISSUE SEEMED TO BE FIXED WHEN THE DEALER CHANGED THE IGNITION, PER THE RECALL) FOR THE PAST SEVERAL MONTHS, THE GOVENER KICKIS IN, AND THE VEHICLE WILL ONLY GO 30MPH. IT HAPPENS INFREQUENTLY, BUT SEEMS TO BECOMING MORE FREQUENT. THE SOLUTION IS TO PULL OVER, TURN IT OFF, START IT BACK UP, AND YOUR GOOD TO GO FOR DAYS TO WEEKS UNTIL IT DOES IT AGAIN. TYPICALLY IT HAPPENS SHORTLY AFTER STARTING A TRIP, AND WHILE GAINING SPEED, YOU SUDDENLY CANNOT GO THE SPEED YOU WOULD LIKE. I DO BELIEVE IT CONTINUES TO GET MORE FREQUENT IN OCCURANCE ****NOW THE SCARY THING THAT GETS ME TO FILE A COMPLAINT**** I HAVE SEEN THIS LISTED MANY TIMES ALREADY. MY HUSBAND WAS AGAIN AWAY ON A TRIP THIS WEEKEND. HE HAD JUST DONE A LOT OF CIRCLE TYPE STEERING AT THE GAS STATION TRYING TO PARK (I MENTION THIS BECAUSE SOMEONE ELSE COMPLAINED OF THIS ISSUE AFTER A ROUND ABOUT). HE PARKED. HE STARTED THE CAR AGAIN, HE BACKED UP, AND WHEN HE TRIED TO TURN TO GET OUT OF THE PARKING SPOT, THERE WAS NO STEERING. HE PULLED FORWARD. HE PUT IT IN PARK, HE TURNED IT OFF. HE STARTED IT, HE DROVE 2.5 HOURS HOME WITH MY 3 KIDS UNDER 9. HE HAD NO ISSUES. WHAT IS WRONG WITH THE CAR, I AM AFRAID TO DRIVE IT. THANKFULLY HE WAS GOING 2 MPH, BUT I HAVE SEEN CASES OF PEOPLE ON THE INTERSTATE. WHAT IF I DRIVE IT, AND WE HAVE AN ACCIDENT AND MY FAMILY DIES? HOW CAN I DRIVE A CAR THAT LOST STEERING AND FEEL SAFE!?

Mileage: 150,000

VEHICLE WILL INTERMITTENTLY NOT START EVEN AFTER MULTIPLE TRY'S. VEHICLE SHUTS OFF DURING DRIVING EVENTS CITY AND HIGHWAY. ABS LIGHTS COME ON AND STAY ON. INTERIOR LIGHTS COME ON AUTOMATICALLY DURING DRIVING. HAVE HAD THE VEHICLE TO A VW DEALER 4 TIMES FOR THIS ISSUE AND THEY CANNOT DIAGNOSES, NOR REMEDY THE ISSUE. I HAVE SPENT WELL OVER $2,000 FOR THESE VW DEALER VISITS. THIS VEHICLE WAS BUILT BY CHRYSLER FOR VW AND CHRYSLER ISSUED A RECALL ON THE TIPM FOR THE CHRYSLER VEHICLES. VW REFUSES TO ISSUE A RECALL FOR THE TIPM. THIS IS A MAJOR SAFETY ISSUE THAT CAUSES THE VEHICLE TO SHUT OFF DURING DRIVING AND ALL POWER AND BRAKING FUNCTIONS ARE LOST. AT THIS TIME, I HAVE NO CHOICE BUT TO PAY AN ADDITIONAL $1,500 TO HAVE VW REPLACE THE TIPM IN THE HOPES THAT IT RESOLVES THIS DANGEROUS SAFETY ISSUE AND KEEPS MY FAMILY SAFE. NHTSA MUST INVESTIGATE THIS ISSUE WITH CHRYSLER AND REALIZE THAT IT APPLIES TO VW ROUTAN VEHICLES BUILT BY THEM AS WELL, AND FORCE VW TO RECALL THE VEHICLES AND FIX THE ISSUE AT THEIR COST AND PROVIDE FULL REIMBURSEMENT TO ALL ROUTAN OWNERS WHO HAVE THIS SAME SAFETY ISSUE. WHAT ACTIONS ARE NHTSA TAKING ON THIS CRITICAL SAFETY ISSUE?

Mileage: 59,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING BETWEEN 30 TO 65 MPH, THE VEHICLE RANDOMLY JERKED FORWARD AND BACKWARD AS IF IT WERE SKIPPING A GEAR. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED AFTERWARDS SEVERAL TIMES. THE CONTACT SPOKE WITH TWO UNKNOWN DEALERS AND THEN CONTACTED AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE UNDERDRIVE SOLENOID CIRCUIT OF THE TRANSMISSION WAS MALFUNCTIONING. AFTER CONDUCTING SOME RESEARCH, THE CONTACT FOUND THAT THE MANUFACTURER PLACED A CHRYSLER ENGINE AND TRANSMISSION INTO HER VOLKSWAGEN VEHICLE. THE INDEPENDENT MECHANIC COMPLETED THE REPAIRS WITH ANOTHER NEW CHRYSLER TRANSMISSION SOLENOID PART. WHILE THE CONTACT WAS DRIVING ON THE HIGHWAY, THE VEHICLE LOST COMPLETE ACCELERATION AND HAD TO BE PULLED OVER TO THE SHOULDER OF THE ROAD. THE VEHICLE WAS TOWED BACK TO THE INDEPENDENT MECHANIC, BUT HAD NOT YET BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER PROVIDED CASE NUMBER: 181899879 AND NHTSA'S PHONE NUMBER TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS 115,226. *TT*JB

Mileage: 115,226

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE THE CONTACT WAS OUT OF TOWN, THE VEHICLE FAILED TO START AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. ONCE THE VEHICLE WAS ABLE TO BE STARTED, THE CHECK ENGINE INDICATOR DIMMED. THE CONTACT CALLED A LOCAL DEALER (GREEN CHEVROLET, 1703 AVENUE OF THE CITIES, EAST MOLINE, IL 61244) AND WAS INFORMED TO TAKE THE VEHICLE TO HER LOCAL DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 124,000.

Mileage: 124,000

WHILE TAKING MY GRANDSON TO SCHOOL THIS MORNING ON A VERY CURVY COUNTRY ROAD THE ENGINE DIED ON MY 2009 VOLKSWAGON ROUTAIN. HAVING NO BRAKES AND NO POWER STEERING MADE IT VERY DIFFICULT TO CONTROL VEHICLE. I TURNED ON EMERGENCY FLASHERS WHEN CAR FINALLY STOPED TURNED TO OFF POSITION THEN RESTARTED ENGINE. THIS IS NOT THE FIRST TIME THIS HAS HAPPENED TO ME AND MY WIFE. PROBLEM CANNOT BE DIAGNOSED BY DEALER WHY CAN'T CHRYSLER FIX THIS SERIOUS PROBLEM BEFORE SOMEONE GETS INJURED OR KILLED. I KNOW AS WELL AS NHTSA THAT THIS HAS HAPPENED TO MANY PEOPLE. PREVIOUS RECALL FIX FOR IGNITION SWITCH AT WV DEALER TO SOLVE THIS PROBLEM DID NOT WORK . ITS A SHAME THAT MANY PEOPLE HAVE TO INJURED OR KILLED BY A SERIOUS KNOWN PROBLEM LIKE THIS BEFORE COMPANIES ARE FORCED TO FIX THEM.

Mileage: 130,000

VEHICLE CONTINUES TO SHUT DOWN WHILE DRIVING WITHOUT WARNING. VEHICLE MUST EITHER BE STOPPED AND RESTARTED OR PLACED IN NEUTRAL WHILE COASTING TO RESTART.

Mileage: 75,000

SINCE BUYING OUR 2009 ROUTAN IN THE FALL OF 2016 WE HAVE SUNK THOUSANDS INTO IT TRYING TO GET IT FIXED BECAUSE OF THE ISSUES WE HAVE HAD SHORTLY AFTER BUYING IT (OURS DID NOT COME WITH A WARRANTY FROM THE VW DEALER). AT LEAST TWICE A WEEK, AND SOMETIMES MORE, IT STALLS WHILE WE ARE DRIVING...USUALLY AT LOW SPEEDS LIKE WHEN WE ARE SLOWING DOWN TO MAKE A TURN OR SLOWING DOWN FOR A STOPLIGHT. USUALLY, ALL OF THE DASHBOARD LIGHTS AND CONTROLS WILL BLINK AND DING REPEATEDLY BEFORE STALLING. IT ALSO STALLS WHEN SITTING STILL. IT WILL BLINK ALL OF THE LIGHTS, THE CONTROLS WILL GO CRAZY AND THE WINDSHIELD WIPERS WILL GO BACK AND FORTH ONE TIME AS IT STALLS. ON DEC 11 IT STALLED ON A MAJOR ROAD IN CHARLOTTE, NC AND I LOST ALL POWER SO I COULD NOT EVEN PUT ON MY FLASHERS. I HAVE AN AUTISTIC CHILD WHO WAS FREAKING OUT BECAUSE I WAS TRYING TO GET ALL OF THE KIDS TO BE QUIET SO I COULD CALL MY HUSBAND AS WE WERE SITTING IN THE MIDDLE OF A BUSY ROAD. WE WERE IN A MIDDLE LANE AND THE WINDOWS WERE UP SO I HAD TO OPEN MY DOOR QUICKLY AND WAVE FOR PEOPLE TO GO AROUND US. I KEPT WATCHING MY REAR VIEW MIRROR AND PRAYING WE WOULDN'T GET HIT AS CARS ZIPPED AROUND US HONKING. THE KEY WAS STUCK IN THE IGNITION SINCE THERE WAS NO POWER. MY HUSBAND WAS HEADED TOWARDS US AND I WAVED PEOPLE AROUND US FOR ABOUT 5 MINUTES WHILE JINGLING THE KEY AND TRYING EVERYTHING TO GET SOMETHING TO WORK. THE POWER FINALLY CAME BACK AND THE KEY CAME OUT AND I WAS ABLE TO RESTART AND GET HOME BUT MY KIDS ARE AFRAID TO GO ANYWHERE IN THAT VAN AGAIN. WE HAVE REPLACED THE BATTERY, THE CONTROL MODULE (ONE OF THE MOST EXPENSIVE THINGS WE TRIED), THE ERG VALVE, THE ALTERNATOR, AND SOME OTHER PARTS OUR MECHANIC WANTED TO TRY. SUPER EAGLE AUTO CARE HAS BEEN SUPER HELPFUL IN TRYING TO FIX IT BUT TO NO AVAIL. WE HAVE LEARNED SINCE BUYING THIS VEHICLE THAT THIS IS A COMMON PROBLEM FOR VW ROUTAN.

Mileage: 119,000

WHILE DRIVING ON STREET OR HIGHWAY OR STOPPED. USUALLY AROUND 20-40MPH CAR STALLS. BRAKES LOCK UP/STEERING WHEEL LOCKS UP/NO CONTROL OF CAR AT ALL. ALL LIGHTS INDICATE CAR IS ON, ONE BELL GOES OFF PRIOR AND ANTI-SKID LIGHT COMES ON. BY THEN PANIC CANNOT CONTROL CAR! PUT CAR IN PARK AFTER STOPPED AND IT STARTS RIGHT UP.

Mileage: 70,000

VEHICLE WON'T START. THIS IS NOT THE FIRST TIME AND I HAVE FILLED PREVIOUS INCIDENT REPORTS. IT LEFT ME STRANDED AGAIN TODAY AFTER I PICKED UP MEDICINE FOR A CHILD AT HOME RECOVERING FROM SURGERY. THIS VEHICLE IS UNRELIABLE AND THEREFORE THE SITUATION IS UNACCEPTABLE. OUR MECHANIC HAS RUN DIAGNOSTICS AND CAN FIND NOTHING WRONG. WE TOOK A LEAP OF FAITH AND HAD A NEW STARTER INSTALLED, THIS WAS NOT THE PROBLEM. I WOULD BUY ANOTHER CAR, BUT RIGHT NOW THIS IS NOT AN OPTION FOR US. WE NEED HELP!

OUR ROUTAN HAS, YET AGAIN, LEFT ME STRANDED. I WAS RUNNING ERRANDS WITH TWO OF MY CHILDREN AND THE VEHICLE WOULD NOT START. THIS IS NOT AN ISOLATED INCIDENT FOR ME OR, IT WOULD APPEAR FROM RESEARCH I'VE DONE, FOR THIS MAKE AND MODEL. OUR MECHANIC HAS RUN DIAGNOSTICS AND CAN NOT FIND ANYTHING WRONG. IT IS A SAFETY CONCERN BECAUSE IT IS UNRELIABLE AND LEAVES ME STRANDED, TWICE LATE AT NIGHT, SEVERAL TIMES, FORTUNATELY, IN FRONT OF MY OWN HOME AND THIS NEEDS TO BE ADDRESSED.

Mileage: 158,687

ENGINE WILL NOT START. HAPPENS ON OCCASION BUT HAPPENED ENOUGH THAT I HAD TWO STARTERS INSTALLED AS WELL AS A BATTERY. WHAT ELSE COULD IT BE? CAN TURN THE KEY AND NOTHING HAPPENS. I CAN POSSIBLY SIT THERE AND TURN THE IGNITION 10+ TIMES AND STILL NOTHING. THOUGHT IT COULD BE A BAD SPOT IN THE NEW STARTER?? CLEANED BATTERY POSTS OFTEN AND NOW HAVE TREATED THE CONNECTIONS. WOULD LIKE NOT TO RECEIVE ANOTHER CALL FROM LOVELY WIFE THAT THE VAN WOULD NOT START. HAS TO BE SOMETHING WITH A CIRCUIT STAYING OPEN OR SOMETHING. SAFETY ISSUE DUE TO NOT KNOWING IF YOUR CAR IS GOING TO START WHEN YOU ARRIVE TO A DESTINATION. ISSUE HAS BEEN GOING ON FOR 2+ YEARS AND VAN HAS 100K MILES LAST INSTANCE OF ISSUE: 23 JUNE 2017

Mileage: 110,000

AS WE ARE DRIVING THE POWER STEERING COMPLETELY CUTS OFF AND WILL NOT LET YOU DRIVE - THE ENGINE SHUTS OFF AND YOUR FORCED INTO TURNING THE VEHICLE COMPLETELY OFF THEM BACK ON AGAIN. THIS HAPPENED WHILE ON THE INTERSTATE IN TRAFFIC WHICH NEARLY CAUSED A COLLISION.

Mileage: 130,000

WHILE DRIVING AT 65 MPH ON I35, THE CAR'S TRANSMISSION ACTED LIKE IT SLIPPED INTO 2ND GEAR AND THE TACK WENT TO 5000RPM. I TRIED TO JUST SLOW DOWN AND GET OFF THE ROAD, TURNED THE CAR OFF AND BACK ON WHEN I GOT TO A PARKING LOT. I THEN STARTED DRIVING AGAIN AND IT APPEARED TO BE ALRIGHT. WITHIN A FEW DAYS IT DID IT A COUPLE TIMES MORE, THIS TIME TURNING ON THE CHECK ENGINE LIGHT. TOOK IT TO THE DEALER AND THEY COULDN'T DUPLICATE PROBLEM IN THE WEEK THEY HAD IT. PICKED IT UP FROM THE DEALERSHIP AND WAS ABOUT 10 TO 15 MILES AWAY AND IT DID IT AGAIN. I TOOK IT BACK TO THE DEALER THE NEXT DAY AND IT HAS BEEN THERE FOR TWO WEEKS. THEY TOLD ME AN ENGINEER FROM CORPORATE CAME TO CHECK IT OUT AND DURING THAT TIME THEY HAD ANOTHER CAR - SAME YEAR, SAME STYLE, EVEN SAME COLOR COME INTO THE SHOP WITH THE SAME PROBLEM AND THEY VERIFIED THE PROBLEM ON BOTH OF THE CARS. THEY SAID IT WAS THE TRANSMISSION AND IT IS GOING TO COST SOMEWHERE AROUND $5000.00 +/- TO GET IT FIXED. THIS IS A VERY DANGEROUS PROBLEM AND I AM HOPING THAT SOMETHING WILL BE DONE ABOUT IT. THERE ARE NUMEROUS STORIES ON THE INTERNET WITH PEOPLE IN VOLKSWAGENS THAT HAVE HAD THE SAME OR SIMILAR PROBLEMS. CANNOT SEE WHY THERE HASN'T BEEN A RECALL FOR THIS PROBLEM. THEY EVEN ADMITTED THAT THEY HAD SEEN THE SAME OR SIMILAR PROBLEMS POSTED ON THE INTERNET.

Mileage: 134,692

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER, BUT HAD NOT YET BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,500. THE VIN WAS UNAVAILABLE.

Mileage: 95,500

RANDOMLY STALLS WHILE DRIVING- BROUGHT TO MECHANIC, PAID ALMOST $1000 TO TRY TO GET FIXED, BROUGHT BACK WHEN EVERYTHING PAID FOR DIDN'T FIX & WAS TOLD TO REPORT IGNITION SWITCH RECALL TO VW TO GET FIXED. ALSO LOST POWER TO REAR DVD WITHIN DAYS AFTER PURCHASE & NEVER KNEW WHAT TO DO. BRAKE PADS ARE BAD WITHIN 3-4,000 MILES- WINDSHIELD WASHER SQUIRTER UNREPAIRABLE. BIGGEST ISSUE IS THE IGNITION SWITCH THOUGH, IF THAT WHAT IS CAUSING VAN TO STALL - WHILE GOING STEADY SPEED, USUALLY OCCURS OVER 25 MPH FOR MORE THAN 5 MILES- VAN STARTS JERKING LIKE IT'S GOING TO STALL & WHEN SITTING AT A STOP LIGHT OR SIGN, OR PARKED, IDLING, STALLS & TAKES MULTIPLE ATTEMPTS TO RESTART - THIS HAS BEEN HAPPENING SINCE I PURCHASED MY 2009 ROUTAN IN 2014 WHEN IT HAD LESS THAN 60K MILES. I HAVE BROUGHT TO MECHANICS THAT ARE FRIENDS & TO MULTIPLE DEALERSHIPS & SHOPS TO DIAGNOSE & FIX & PAID FOR EVERYTHING OUT OF POCKET TO GET FIXED OR REPLACED & IT HAS NEVER FIXED THE PROBLEM FOR MORE THAN A WEEK. FOR THE BRAKES, I BUY ONLY THE MID LEVEL OR HIGH LEVEL GRADE BRAKES & HAVE HAD TO SWITCH BOTH FRONT & REAR BRAKES, ROTORS & CALIPERS OUT @ LEAST 3-4 TIMES PER YEAR SINCE ABOUT 1 MONTH AFTER OWNERSHIP. EVERY TIME, 1-2 BRAKE PADS WERE COMPLETELY BAD & GONE WHILE THE OTHERS WERE ABOUT 50-70% . ANOTHER ISSUE, THAT HAS NEVER BEEN ABLE TO GET FIXED IS THE A/C- AFTER RECHARGING, THE A/C WILL BLOW COLD ON THE DRIVERS SIDE FRONT ONLY & HOT THROUGHOUT THE REST OF THE CAR. WHEN HEAT IS ON, SAME PROBLEM, ONLY BLOWS HEAT IN FRONT & COOL IN BACK. HOW DO I GET ALL RECALLS FOR MY MINIVAN REPAIRED THROUGH VOLKSWAGEN? HOW DOES THE PROCESS WORK? I HAVE 5 SMALL CHILDREN & THIS IS OUR ONLY FORM OF TRANSPORTATION. WILL I BE PROVIDED WITH A LOANER THAT WILL SEAT MY ENTIRE FAMILY WHILE MY VEHICLE IS BEING REPAIRED? PLEASE ADVISE AS I HAVE HAD THIS MINIVAN FOR OVER 3 YEARS WITH THESE ISSUES AND SPENT THOUSANDS OF DOLLARS

Mileage: 59,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE THE CONTACT'S NIECE WAS STOPPED AT A STOP LIGHT, IT EXPERIENCED A COMPLETE LOSS OF POWER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS TOWED TO ANOTHER INDEPENDENT MECHANIC WHO CONFIRMED THAT THE ENGINE WAS DEFECTIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DID NOT OFFER ASSISTANCE. THE FAILURE MILEAGE WAS 65,273.

Mileage: 65,273

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. ONCE THE VEHICLE WAS WARMED UP, IT LOST POWER. WHEN THE ENGINE WAS NOT WARMED UP, THE VEHICLE COULD ONLY BE OPERATED FOR 10 TO 15 MINUTES. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LOCK TORQUE CONVERTER BETWEEN THE VALVE BODY WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.

Mileage: 105,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING 25 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND RESTARTED. THE CONTACT STATED THAT THE FAILURE OCCURRED TEN TIMES PRIOR TO THIS FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 96,000.

Mileage: 96,000

FOR YEARS I HAVE EXPERIENCED INTERMITTENT FAILURES IN STARTING MY CAR, EACH TIME IF I WAIT A WHILE IT WILL START. ADDITIONALLY, BEGINNING IN FEB 2016, MY ENGINE WILL SIMPLY SHUT DOWN WHILE THE CAR IS IN MOTION (PRETTY SCARY). I HAVE DEALT WITH VW SEVERAL TIME TO NO AVAIL AND ALWAYS AT MY EXPENSE. THIS LATEST DEVELOPMENT MAY COST ME OR SOMEONE ELSE THEIR LIFE. VW ACTS LIKE THIS HAS NOT HAPPENED TO ANYONE ELSE AND IF THEY CAN'T RECREATE THE ISSUE THEY CAN'T ADDRESS THE ISSUE, REALLY! THIS IS CRIMINAL! I HAVE HAD A STARTER REPLACED AS WELL AS A SWITCH AND NO CHANGE. ALL I GET FROM VW IS "YOU CAN TAKE IT TO ANOTHER DEALER AND GET A SECOND OPINION WE WILL COVER 1 HOUR OF THE COST TO DIAGNOSE THE PROBLEM" REALLY NO GREATER EXPERTISE NO INFORMATION SHARING, JUST ANOTHER DEALER, THE THIRD OF WHICH WILL LIKELY TELL ME, WE CAN'T CREATE THE PROBLEM!

Mileage: 72,000

AFTER MY VAN HAS BEEN SITTING FOR A WHILE AND IT BEEN WARMED UP FOR 15 MINUTES. WITH IN THE FIRST 2 TO 5 MILES OF DRIVING THE TRACTION CONTROL LIGHT WILL COME ON AND THE VAN WILL SHUT OFF AND THE STEERING WHEEL AND BREAK WILL FAIL. THEN I HAVE TO TURN THE KEY TO OFF AND RESTART THE VAN AND IT SOMETIME REPEAT ITSELF IF I'M STUCK IN TRAFFIC.

Mileage: 105,376

HAD THE WIN MODULE REPLACED FOR THE ELECTRICAL SYSTEM IGNITION SWITCH RECALL. NOW THE CAR WILL MAKE SUDDEN STOPS AND SHUT DOWN. CAR THEN WILL NOT START UP UNLESS THE BATTERY IS UNHOOKED AND HOOKED BACK UP. DEALER WANTS TO CHARGE 350.00 TO DO A DIAGNOSTIC TEST TO DETERMINE THE CAUSE.

Mileage: 90,000

THE VEHICLE WHILE DRIVING HAD ALL THE WARNING LIGHTS COME ON , THE GAUGES GO UP AND DOWN AND THE VEHICLE CUT OFF. THIS HAPPENED MULTIPLE TIMES ONE AFTERNOON. HAD TO HAVE IT TOWED TO THE HOUSE. INTERNET SEARCH SHOWS THAT THIS IS A ROUTINE PROBLEM FOR OTHERS AS WELL.

Mileage: 71,000

WHEN SLOWING DOWN TO TURN INTO THE PARKING LOT AT THE LOCAL LIBRARY THE VEHICLE STALLED AND LOST POWER. AFTER COMING TO A STOP THE VAN WOULD START FINE AND WAS ABLE TO FINISH THE TRIP. A FEW DAYS LATER THIS SAME ISSUE OCCURRED WHILE COMING TO A STOP. WE RETURNED THE CAR TO DEALERSHIP FOR WORK ON A FAULTY RADIO AND MENTIONED THIS ISSUE. THE DEALERSHIP HAD THE RADIO REPLACED AND TOOK IT TO A VW DEALERSHIP TO HAVE THE IGNITION SWITCH REPLACED UNDER A SAFETY RECALL. IT WORKED FINE FOR ABOUT A WEEK THEN STARTED HAPPENING AGAIN. THE VAN WAS TAKEN IN FOR AN OIL CHANGE AT AN INDEPENDENT SHOP AND THEY CHECKED ABOUT THE STALLING ISSUE. THEY COULD NOT FIND ANY CODES INDICATING A PROBLEM, BUT AFTER THE OIL CHANGE THE VAN WORKED BETTER FOR A FEW DAYS. IT NOW STALLS MULTIPLE TIMES PER DAY, USUALLY GOING LESS THAN 30 MPH. ON SEPT 19, 2015 THE VAN STALLED WHILE ACCELERATING ON TO THE ENTRANCE RAMP OF THE HIGHWAY. THE SPEED WAS ABOUT 45MPH.

Mileage: 66,000

VEHICLE LOSES POWER, LOSING POWER STEERING, BRAKES, ETC. WARNING LIGHTS ILLUMINATE. ABLE TO RESTART ENGINE BY SHIFTING INTO NEUTRAL AND TURNING KEY TO START. ***HAPPENS MULTIPLE TIMES APPROX EVERY 1-3 MONTHS, RANDOM*** TAKEN IN FOR RECALL FIX FOR THIS KNOWN PROBLEM IN 2015. HAS HAPPENED NOW 3-4X SINCE THE RECALL FIX. EXTENDED TESTING BY VW HAS NOT ESTABLISHED A REASON. MULTIPLE ATTEMPTED FIXES, NO CHANGE TO THE LOSS OF POWER. LAST HAPPENED 9/6/2015, TRAVELING 40MPH DOWNHILL IN GEAR, ABRUPT LOSS OF POWER, FOLLOWED BY LOSS OF POWER STEERING AND LOSS OF POWER BRAKES. AGAIN, ABLE TO RESTART BY SHIFTING INTO NEUTRAL AND TURNING THE KEY TO START.

Mileage: 36,000

DRIVING DOWNHILL, FOOT OFF ACCELERATOR. ABRUPT LOSS OF ENGINE POWER FOLLOWED BY LOSS OF POWER STEERING AND BRAKING. VEHICLE UNDER KNOWN RECALL AND HAS BEEN "FIXED". THIS INCIDENT HAS NOW OCCURRED 3-4X SINCE THE RECALL FIX, NEARLY IDENTICAL CIRCUMSTANCES APPROX EVERY 1-3 MONTHS. VW KEPT THE VEHICLE FOR > 2 WEEKS, UNABLE TO IDENTIFY THE PROBLEM, VEHICLE WAS RETURNED TO ME WITHOUT ANY NEW ATTEMPTS AT FIXING IT. I WILL BE RETURNING IT TO VW AND TAKING IT OUT OF SERVICE.

Mileage: 51,000

I BOUGHT THIS ROUTAN APROX 8 MONTHS AGO,NOTHING BUT PROBLEMS,IT HAS SHUT DOWN IN CITY TRAFFIC AND HIGHWAY SPEEDS,I AM AWARE OF RECALL #28H1 FROM VW THAT 2 VW DEALERSHIPS DENY EVEN EXIST.THE DEALER I BOUGHT THIS FROM TEST AND DIAGNOSED IT AS A DEFECTIVE WINS MODULE { IGNITION SWITCH } AND CONTACTED A VW DEALERSHIP IN BARRE VERMONT AND SAID THEY WOULD ORDER A MODULE AND SCHEDULED A DATE TO INSTALL IT,A COUPLE OF DAYS BEFORE APPOINTMENT I MYSELF DECIDE TO BRING IN MYSELF AND CALLED TO VERIFY THE DATE AND TIME,THERE SERVICE DEPARTMENT ASKED ME FOR A RECALL NUMBER OF WHICH AT THE TIME I DID NOT HAVE BECAUSE MY SERVICE MANAGER WHERE I BOUGHT IT FROM SET THIS UP.AFTER TRACKING DOWN THE CORRECT SERVICE REP AT WALKER VW IN BARRE VERMONT SHE INFORMED ME THEY DID NOT ORDER THE PART AND THERE IS NO WINS MODULES AVAILABLE YET 06/01/15 EVEN THOUGH THIS RECALL WAS DATED IN MARCH OF 2014 ,STILL NO FIX WHATS UP WITH THAT ? I GUESS OUR LIVES AND THE LIVES OF OUR LOVED ONES DO NOT MATTER IT IS TIME FOR SOMEONE OR THE NHTSA TO IMPOSE SOME SERIOUS PREASURE ON VOLKSWAGON AND DEMAND THAT OUR VEHICLES BE REPAIRED CORRECTLY THEY SHOULD BE BROUGHT UP ON CHARGES FOR DECEIVEING THE PUBLIC.EVEN MY OWN DEALERSHIP HAS NOT BEEN TELLING ME EVERYTHING UNTIL I CORNER THEM OR CATCH THEM OFF GUARD, COME TO FIND OUT AFTER SQUEEZING IT OUT OF MY OWN LOCAL SERVICE MANAGER IS THAT A WINS MODULE HAD ALREADY BEEN REPLACED IN MY ROUTAN FOR THE PRIOR OWNER,PROBABLY TO PASIFY THE CUSTOMER.I AM AT THIS POINT LOOKING AT THE LEGAL GROUNDS WE ALL SHOULD HAVE AGAINST THESE CORPERATIONS LIKE VOLKSWAGON OR EVEN CHRYSLER SINCE THEY PRODUCED ROUTANS FOR VOLKSWAGON. I WOULD HATE TO TRADE THIS VEHICLE IN JUST FOR SOME OTHER SAP TO BE STUCK WITH A LEMON .ITS JUST NOT SAFE OR DEPENDABLE AND WE HAVE A LONG TRIP IN TWO DAYS 50/50 CHANCE WE MAKE IT DOWN AND BACK WITH KNOW PROBLEMS ???

Mileage: 68,500

THE FIRST INCIDENT WITH A "CLUNKING" NOISE OF THE TRANSMISSION BEGAN ON 7/10/2014 AT 51,496 MILES. WHEN SHIFTING FROM REVERSE TO DRIVE CAR MAKES A "CLUNKING" NOISE AND JERKS THE CAR FORWARD. IT WAS NOTED BY DEALERSHIP AFTER A TEST DRIVE NO FAULTS FOUND. ON 3/19/15 AT 58,611 MILES CAR RETURNED TO DEALERSHIP. SAME CLUNKING AND GRINDING NOISES. FAULTS: P0868, P1790 & P0944. PRESSURE READINGS TO LOW IN TCM CONTROL WIRES. TRANSMISSION TO BE REPLACED PER DEALERSHIP. FINDINGS: UNDER DRIVE CLUTCHES WORN OUT, SUNGEARS AND ASSEMBLY DAMAGED WITH METAL METAL FRAGMENTS. ON 4/30/2015 AND 59,215 MILES, CAR RETURNED TO DEALERSHIP FOR SAME GRINDING AND CLUNKING NOISES. DEALERSHIP PERFORMED ANOTHER "QUICK LEARN TEST." AS OF 5/19/2015 AND 60,001 MILES, TRANSMISSION IS STILL GRINDING AND CLUNKING ON OCCASION DURING ACCELERATION AND/OR TRANSMISSION SHIFT FROM REVERSE TO DRIVE. THE VEHICLE ALSO RANDOMLY "STALLS" WHILE AT STOPLIGHTS/STOP-SIGNS WITH NO NORMAL FREQUENCY. EVEN WITH A NEW TRANSMISSION, SAME ISSUES ARE STILL SURROUNDING THIS CAR. THANKS.

Mileage: 51,496

I WENT TO PASS A VEHICLE AT 65MPH AND THE ACCELERATOR PEDAL DID NOT RELEASE, THE VAN HIT 80-MPH BEFORE I POPPED IT IN NEUTRAL AND THEN BACK INTO DRIVE TO CORRECT THE ISSUE. HITTING THE BRAKES HAD NO EFFECT ON THE UNINTENDED ACCELERATION. THIS VEHICLE IS MECHANICALLY IDENTICAL TO CHRYSLER TOWN & COUNTRY AND DADGE GRAND CARAVAN, SEE OTHER IDENTICAL COMPLAINTS HERE: HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/14835/DODGE/VOYAGER/DODGE-GRAND-CARAVAN-SUDDEN-ACCELERATION? *TR

Mileage: 75,400

OVER THE PAST 2 MONTHS, OUR 2009 VW ROUTAN HAS REPEATEDLY SHUT DOWN WHILE DRIVING. THE ENGINE WILL STOP, CAUSING THE POWER BRAKING AND POWER STEERING TO GO OUT. ONCE WE PULL OVER AND TURN THE VEHICLE OFF, WE CAN RESTART IT. HOWEVER, RECENTLY IT'S STARTED TO AGAIN STALL WITHIN ONLY A COUPLE OF MILES OF THE FIRST STALL. WE REPLACED THE ERG VALVE ALREADY. IN DOING SOME RESEARCH, IT APPEARS THAT THIS DANGEROUS PROBLEM MAY BE DUE TO AN IGNITION SWITCH PROBLEM. OUR VEHICLE IS ONE THAT IS PART OF THE RECALL THAT VW ISSUED OVER 7 MONTHS AGO! I CALLED VW CUSTOMER CARE YESTERDAY AND WAS TOLD THAT THE RECALL PART STILL ISN'T AVAILABLE BUT IT SHOULD BE "READY SOON." THE PERSON I TALKED WITH HAD NO IDEA WHEN "SOON" WOULD BE. HE SAID THE PARTS ARE COMING FROM A DIFFERENT MANUFACTURER. HE TOLD ME TO BRING OUR VW TO A VW DEALERSHIP TO HAVE THEM COMPLETE A DIAGNOSIS ON IT. I EXPLAINED THAT THIS VEHICLE HAS BEEN NOTHING BUT PROBLEMS FOR US AND THAT I WAS UNWILLING TO PAY THE DEALERSHIP ANY ADDITIONAL MONEY FOR A DIAGNOSIS FEE WHEN IT IS CLEARLY PART OF THE RECALL PROBLEM. THE CUSTOMER CARE REPRESENTATIVE STARTED A CASE ON OUR VEHICLE (WHATEVER THAT MEANS). IN THE MEANTIME, I AM SCARED TO DRIVE THE VEHICLE AS I HAVE 2 YOUNG CHILDREN THAT I WILL NOT PUT AT RISK OF THIS THING SHUTTING DOWN WHILE WE ARE GOING 65 MPH ON THE HIGHWAY. IT IS CLEAR TO ME THAT VW HAS EXCEEDED AN APPROPRIATE AMOUNT OF TIME TO FIX THE RECALL ISSUE ON ALL OF THESE ROUTANS. WHEN WILL VW BE HELD ACCOUNTABLE TO FIX THE RECALL ISSUE - IT'S BEEN OVER 7 MONTHS! *TR

Mileage: 100,000

OIL CONSUMPTION SINCE 12000 MILES. VW DEALER NEVER WANT TO ADDRESS THE PROBLEM. KEEP TELL ME THIS NORMAL. NOW I HAVE TO ADD QUARTER OIL EVERY1400 MIL. I HOPE THE RECALL WILL FIX THIS PROBLEM. I HAD TO REPLACE BRAKES AT 12000 MILES DUE THE WHILE BRAKES. I'VE DONE OIL CONSUMPTION TEST 3 TIMES ALREADY. *TR

Mileage: 16,080

WE HAVE OWNED THE VEHICLE FOR ABOUT 2 MONTHS WITH NO ISSUES, WHEN WE PURCHASED THE VEHICLE IT CAME WITH A CLEAN CARFAX LISTING NO RECALLS. ON 3/10/15 MY WIFE WAS DRIVING ON A 2 LANE COUNTRY ROAD GOING ABOUT 35MPH WHEN THE VEHICLE SUDDENLY LOST POWER AND SHE LOST CONTROL OF THE VEHICLE. THE ENGINE APPEARED TO HAVE CUT OUT, SHE HAD NO POWER STEERING AND NO POWER BRAKES AND WAS UNABLE TO STOP OR STEER THE VEHICLE. THE DASH DISPLAYED THE ANTI-SLIP LIGHT, BUT NO OTHERS. THE VEHICLE SLOWED DOWN TO A STOP, THANKFULLY THERE WAS NO ONCOMING TRAFFIC AS SHE WAS NO LONGER IN HER PROPER LANE, AND NO CARS BEHIND HER. SHE WAS ABLE TO PUT IT IN PARK AND RESTART IT AS IF NOTHING HAD HAPPENED AND IT WAS FINE AFTER THAT FOR THE REST OF HER COMMUTE. WE CONTACTED VW ABOUT THE ISSUE AND THEY REQUESTED THAT WE BRING THE CAR TO A VW DEALER FOR INSPECTION. WE DID THAT, AND VW CLAIMED THAT OUR VEHICLE WAS NOT IMPACTED BY RECALL # RNA1, BUT INSTEAD THEY INSISTED THE ISSUE WAS CAUSED BY A FAULTY EGR VALVE, AND GAVE ME AN ENGINE TROUBLE CODE OF C121C THAT THEY CLAIMED CORRESPONDED WITH THE FAILING EGR VALVE. VW CHARGED ME OVER $100 FOR THE DIAGNOSIS, AND A DAY LATER AFTER COMPLAINING TO VW CUSTOMER CARE THEY AGREED TO REFUND THE CHARGES. I BROUGHT THE VEHICLE BACK TO THE INDEPENDENT DEALERSHIP THAT I ORIGINALLY PURCHASED THE CAR AT THE SAME DAY THAT VW DIAGNOSED THIS, AND THEY WERE NOT IN AGREEMENT WITH THE EGR DIAGNOSIS, AND ALSO COULD NOT CORROBORATE THE TROUBLE CODE C121C AS BEING RELATED TO AN EGR ISSUE, RATHER IT COMES UP AS A TORQUE REQUEST SIGNAL DENIED TROUBLE CODE INSTEAD. THE INDEPENDENT DEALER ALSO FOUND THAT I HAD STORED CODES FOR ABS MALFUNCTIONS, SUNROOF ERRORS AND MIC/CCN INSTRUMENT CLUSTER. THE INDEPENDENT DEALER CLEARED THESE CODES BEFORE LEAVING THAT DAY. ON 3/25/15 MY WIFE WAS DRIVING AT ABOUT 35MPH WHEN THE CARS ENGINE SHUT OFF AGAIN IN A SIMILAR FASHION. NO CODES *TR

Mileage: 71,000

TL*THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE ENGINE STALLED AS ALL OF THE WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE TOTALLY INTEGRATED POWER MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 34,000.

Mileage: 34,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE RESTART. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. THE VIN WAS UNAVAILABLE.

Mileage: 75,000

WHILE DRIVING TYPICALLY AT SPEEDS LESS THAN 45 MPH THE VEHICLE ENGINE WILL SHUT DOWN AND ELECTRICAL POWER AT THE DASH IS LOST. VEHICLE WILL RESTART AFTER IT SHUTS DOWN. PROBLEM IS NOT CONSISTENT. DEALER CAN NOT VERIFY THE COMPLAINT, THEREFORE CAN NOT REPAIR. NHTSA RECALL 14V396 APPEARS TO BE THE CORRECTION FOR THE ISSUE. DEALER WILL NOT PERFORM THE RECALL UNTIL THEY DUPLICATE THE ISSUE. HAS BEEN AT THE DEALER FOR 6 DAYS WITH NO DUPLICATION OF THE COMPLAINT. *TR

Mileage: 87,500

TL-THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT 20 MPH, THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. DJR

Mileage: 53,000

OUR 2009 ROUTAN RANDOMLY LOSES POWER AND THE ENGINE ATTEMPTS TO TURN OFF WHILE DRIVING. THIS HAS HAPPENED AT LEAST FIVE TIMES IN THE PAST YEAR. OUR ROUTAN IS PART OF THE IGNITION SWITCH RECALL, WHICH SHOULD FIX THIS PROBLEM, YET MORE THAN SIX MONTHS AFTER THIS POTENTIALLY DEADLY RECALL WAS ISSUED, VOLKSWAGEN HAS NOT OFFICIALLY ISSUED A REPAIR, SO OUR DEALERSHIP WILL NOT REPAIR. WE HAVE CONTACTED VOLKSWAGEN DIRECTLY, AND ALL WE HAVE BEEN TOLD IS "WE ARE STILL WAITING FOR MORE INFORMATION." CONSIDERING VOLKSWAGEN ISSUED THIS SAME RECALL ON THE 2010 ROUTAN MORE THAN THREE YEARS AGO AND SHOULD BE FAMILIAR WITH THE REPAIR, I FIND THIS UNACCEPTABLE. IT IS A LAWSUIT WAITING TO HAPPEN. *TR

WE HAVE HAD SEVERAL OCCASIONS WHERE THE VAN COMPLETELY SHUTS OFF EVEN WHILE RUNNING. REPORTED IT TO OUR LOCAL VW DEALER AND HAVE BEEN TOLD THAT IT MIGHT BE AN IGNITION PROBLEM WHICH IS PART OF A RECALL. WAS INFORMED THAT AT THIS TIME THEY CAN'T REPAIR IT BECAUSE THEY DON'T MAKE THAT PART. HAD IT COMPLETELY SHUT DOWN ON US WHILE IT WAS GETTING SERVICED AT THE DEALER FOR NEW BRAKES. WAS TOLD THAT ALL IT NEEDED WAS NEW BATTERY. PAID FOR IT AND GOT IT TO START ONLY TO SHUT DOWN AGAIN TWO DAYS LATER. TOOK IT BACK AGAIN AND WAS TOLD THAT IT IS NOT THE RECALL ITS SOMETHING ELSE THATS CAUSING FOR THE CAR TO SHUT OFF. NOW THE DEALER SAID THAT THEY WILL PAY FOR THE PART BUT WE PAY FOR LABOR AND WE HAVE 7 DAYS TO AGREE. THEY NEED TO FIX THIS ONGOING PROBLEM. WE ARE NOW CARRYING AROUND $175 JUMPER TO START IT WHEN IT SHUTS OFF. HAVE HAD TO SIGN UP FOR TOW ASSISTANCE PROGRAM JUST IN CASE MY FAMILY IS STRANDED. *JS

Mileage: 60,567

WAS DRIVING ON A RESIDENTIAL STREET WHEN THE ENGINE SHUT OFF WITHOUT WARNING. COMPLETELY LOST ALL POWER (STEERING, BRAKES, ETC). WAS ABLE TO PULL OVER TO SIDE OF ROAD THANKFULLY ONLY GOING 25 MPH AND NO TRAFFIC. PUT VEHICLE IN PARK, STARTED UP IMMEDIATELY AND RAN FINE AFTER THAT. RECEIVED RECALL LETTER IN MAIL THE FOLLOWING WEEK STATING THE IGNITION SWITCH CAN TURN OFF WITHOUT NOTICE INCIDENT HAPPENED 2 ADDITIONAL TIMES, SIMILAR CIRCUMSTANCES. SPOKE WITH DEALER AND VW CORPORATE ON 3 SEPARATE OCCASIONS. VOLKSWAGEN STATES THEY DO NOT HAVE A SOLUTION FOR THE RECALL REPAIR AT THIS TIME, NOR WILL THEY DO ANYTHING ABOUT THE POSSIBLE SAFETY ISSUE OF THE VEHICLE SHUTTING OFF AND CAUSING AN ACCIDENT. *TR

Mileage: 65,000

OIL CONSUMPTION SINCE 24000 MILES. VW DEALER NEVER WANT TO ADDRESS THE PROBLEM. KEEP TELL ME THIS NORMAL. NOW I HAVE TO ADD QUARTER OIL EVERY MONTH. ON MORNING CAR WASN'T STARTING AND TOOK TO THE DEALER AND HAD THE IGNITION REPLACED AT 42000 MILES BUT NOW THE KEY GET STUCK ON IGNITION MULTIPLE TIMES. I HOPE THE RECALL WILL FIX THIS PROBLEM. I HAD TO REPLACE BRAKES AT 12000 MILES DUE THE VIBRATION WHILE BRAKES. I HAD MULTIPLES ELECTRICAL PROBLEMS AND SOME WAS REPAIR AFTER COUPLE TRIPS TO THE DEALER. THIS CAR IS A LEMON. WHEN WE WILL HAVE OUR MONEY BACK? *TR

Mileage: 12,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V396000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 02/05/14*LJ THE CONSUMER STATED THE VEHICLE WOULD FAIL TO START. *JS

MY KEY HAS BEEN STICKING IN THE IGNITION INTERMITTENTLY. USUALLY I HAVE TO TURN THE CAR BACK ON TURN THE WHEEL, PUT IT IN GEAR AND BACK IN PARK, ONE OR BOTH OF THOSE THINGS USUALLY FREES THE KEY FROM THE ACC MODE AND ALLOWS ME TO REMOVE IT FROM THE IGNITION. TODAY, I WENT TO START THE VAN AND IT IS DEAD. CLICK. THAT IS ALL IT DOES. IT DOES NOT APPEAR THE BATTERY IS DEAD, AS THE HEADLIGHTS AND INTERIOR LIGHTS COME ON, THE DOOR DINGS, THE MILEAGE COMES UP, ETC. THERE IS A RECALL FOR SOMETHING INVOLVING THE IGNITION, BUT I HAVE NOT BEEN INFORMED BY VW YET AS TO A REPAIR. I HAVE SENT IN FOUR PRIOR COMPLAINTS CONCERNING THIS VEHICLE. I BOUGHT IT USED 7/2010 FROM CARMAX. IT IS UNRELIABLE AND DANGEROUS TO HAVE ON THE ROAD. THE ENTIRE BRAKE SYSTEM NEEDS REPAIRED EVERY 7,000 MILES FOLLOWING A SUDDEN CALIPER SEIZE, THE VAN HAS NUMEROUS ELECTRICAL ISSUES THAT CAUSE THE CAR TO JUST STOP. ONE DAY I HEARD IT RUNNING IN MY GARAGE. I CANT RULE OUT ONE OF MY CHILDREN MESSING WITH THE FOB, HOWEVER, I HAVE DIFFICULTY WITH THE REMOTE STARTER MYSELF? (CLICK2X&HOLD) I DO NOT FEEL SAFE WITH THIS VEHICLE. I WILL NOT DRIVE MY CHILDREN LONG DISTANCES OR TRAVEL ROADS WITH THEM THAT REQUIRE SPEEDS OVER 40 MPH. THE VAN DIED WHILE I WAS DRIVING IT 55-60MPH ON A BUSY HIGHWAY, THE VW DEALERSHIP SAID IT WAS NOT A RECALL ISSUE. I CLEARLY SEE IT IS A RECALL ISSUE FOR SOME ROUTANS, MY RECEIPT READS EXACTLY AS THE SIDE DOOR HARNESS RECALL IS STATED. I WILL BE WORKING WITH VW TO REQUEST REIMBURSEMENT, HOWEVER, I DON'T FEEL THAT IS GOOD ENOUGH. THERE IS A MAJOR PROBLEM HERE. I AM LUCKY MYSELF OR MY CHILDREN HAVE NOT BEEN HURT. IN HINDSIGHT OF THE GM IGNITION RECALL, I WOULD BE AMISS TO THINK A CAR COMPANY HAS MY BEST INTEREST IN MIND. I AM HOPING MY GOVERNMENT DOES. *TR

Mileage: 71,397

WHILE DRIVING IN JACKSONVILLE FLORIDA ON HIGHWAY, WIPERS SUDDENLY CAME ON, ALL IDIOT LIGHTS BEGAN TO BLINK, HEADLIGHTS BEGAN FLASHING OFF AND ON, BEEPING SOUND LIKE WHEN DOOR IS OPEN, THE VAN SUDDENLY DIED AND I WAS UNABLE TO BRAKE, STEER OR CONTROL VEHICLE. THE VAN WAS TOWED TO VW DEALERSHIP THE PROBLEM WAS FOUND TO BE THE SLIDING DOOR HARNESS WHICH WAS INTERFERING WITH NORMAL OPERATION OF THE ELECTRICAL SYSTEM. REPLACED SLIDING DOOR HARNESS AND FAILED BATTERY. WHEN I QUESTIONED THE FAULTY PART POSSIBLY BEING A RECALL ISSUE I WAS TOLD IT WAS NOT. COST=$624.48 + RENTAL CAR. *IT IS IMPORTANT TO NOTE HERE THAT I HAD JUST CROSSED OVER A VERY LONG LARGE BRIDGE. IF I HAD BEEN GOING UPHILL WHEN THE VAN SUDDENLY DIED I AM CERTAIN I WOULD HAVE CAUSED AN ACCIDENT INFLICTING INJURY OR POSSIBLY DEATH TO EITHER MYSELF OR ANOTHER MOTORIST, AS THERE IS NO SHOULDER ON THE BRIDGE AND I WAS TRAVELING AT 55-60MPH. I COULD NOT CONTROL THE VEHICLE. THIS IS CLEARLY AN ISSUE WITH THESE MINI VANS. THANK GOD I WAS TRAVELING TO WORK AND DID NOT HAVE MY CHILDREN IN THE VAN AS I WAITED 2&1/2 HOURS FOR A TOW. *TR

Mileage: 54,694

DRIVING FROM INDIANA TO PHOENIX THE VAN BEGAN TO SHAKE VIOLENTLY WHILE BRAKING DOWNHILL ON MOUNTAINOUS TERRAIN. TEMPERATURE GAUGE WENT UP OVER 200 AND VAN SMELLED WARM. VAN DID NOT OVERHEAT AND PROBLEM SUBSIDED ONCE BACK ON LEVEL GROUND. PURCHASED VAN USED ON JULY 10 2012 WITH APPROX 25,000 MILES. *TR

Mileage: 30,000

VEHICLE COMPLETELY TURNS OFF WHILE DRIVING, LOSING ALL CONTROL, USE OF BRAKES AND STEERING. IT HAS BEEN 4 WEEKS SINCE THE RECALL WAS SENT OUT AND THERE IS STILL NO FIX AVAILABLE, AND THE COMPANY CAN NOT GIVE ANY OTHER INFORMATION BESIDES THEY ARE WORKING ON IT. *TR

Mileage: 79,578

MY WIFE TOOK OUR 2009 VW ROUTAN MINIVAN TO A VW DEALERSHIP TODAY TO REPAIR INOPERABLE ELECTRONIC DOOR LOCKS AND FAULTY HEADLIGHTS (SEPARATE COMPLAIN FILED), AT WHICH TIME SHE WAS INFORMED OF AN IGNITION PROBLEM RECALL. THE IGNITION PART WAS PLACED ON ORDER AND MY WIFE WAS TOLD THE PART HAD TO BE SHIPPED FROM OUT OF STATE AND SHOULD ARRIVE WITHIN FIVE DAYS. MY WIFE ASKED, AND WAS INFORMED THE VEHICLE WAS SAFE TO OPERATE; HOWEVER, I LOOKED UP THE RECALL WHEN I GOT HOME FROM WORK AND DISCOVERED THE RECALL SPECIFICALLY STATES THE ENGINE CAN SHUT OF DURING OPERATION DUE TO ADDED WEIGHT FROM OTHER KEYS OR KEY RINGS ON THE VW KEY FOB. ACCORDING TO THE RECALL, DEALERSHIP AND MAINTENANCE PERSONNEL ARE SUPPOSED TO INFORM CUSTOMERS TO REMOVE ADDED KEYS FROM THE FOB. MY WIFE HAD KEYS ON HER FOB WHICH THE DEALER MECHANIC HAD IN HIS HAND DURING INSPECTIONS, BUT THE MECHANIC NEVER INFORMED HER OF THE RISK, AND ALLOWED HER TO JEOPARDIZE HER LIFE BY DRIVING THE VEHICLE WITHOUT THE REQUIRED SAFETY INFORMATION. *TR

Mileage: 84,000

WHILE ENTERING FREEWAY LOUD NOISE THEN ALL INDICATOR LIGHTS CAME ON. VEHICLE QUIT RUNNING IN TRAFFIC. COASTED OFF ROADWAY. INSPECTED ENGINE AND SPACER BETWEEN ENGINE BLOCK AND OIL PAN WAS CRACKED. ENGINE SEIZED AND INTERNAL PARTS CRACKED BLOCK. ENGINE HAD NEW PISTON RINGS AND VALVE SEALS INSTALLED AT 68000 MILES BY DEALER FOR OIL CONSUMPTION ISSUES. OIL CONSUMPTION ISSUE WAS NEVER RESOLVED. *TR

Mileage: 87,000

THE ENGINE TURNED TO OFF WHILE I WAS DRIVING AND DEPOWERED POWER STEERING AND BRAKES. AT THAT POINT I RESTARTED THE CAR AND WAS ABLE TO DRIVE. TOOK THE CAR IMMEDIATELY TO VW DEALER, KEPT THE CAR FOR 24 HOURS, AND THEY COULD NOT REPLICATE THE INCIDENT SO NOTHING WAS DONE BY THEM. THIS HAPPENED AGAIN AT 93000 MILES ON AUGUST 8, 2014. *TR

Mileage: 91,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THE VEHICLE STALLED AS THE TRACTION CONTROL WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED ON TWO OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 41,300.

Mileage: 41,300

OUR 2009 VW ROUTAN COMPLETELY SHUTS DOWN WHILE DRIVING 3 TIMES NOW. NOT ONLY DOES IT SHUT DOWN, BUT THE STEERING AND BRAKES LOCK AS WELL. ON THE LAST OCCURRENCE, MY WIFE (WITH OUR CHILDREN IN THE CAR) CAME VERY CLOSE TO HITTING A PARKED CAR IN THE STREET. WE HAVE TAKEN IT TO 2 VW DEALERS SO FAR IN CHARLOTTE, NC AND THEY STATE: "WE CANNOT DUPLICATE THE ISSUE." UNFORTUNATELY, THAT IS NOT THE RIGHT ANSWER WHEN YOU HAVE SOMETHING AS DANGEROUS AS THIS HAPPENING TO OUR FAMILY CAR. WE HAVE CALLED VW CORPORATE TO HELP 2ND DEALERSHIP WITH A RESOLUTION, BUT NOTHING HAS BEEN FIXED AT THIS TIME. WE ARE NOT SURE WHAT DO AT THIS POINT, AND SEEMS LIKE BOTH VW AND VW DEALERSHIPS ARE AWARE OF ISSUE, BUT NO ONE WANTS TO TOUCH IT! PLEASE HELP! *TR

Mileage: 55,000

MY 2009 ROUTAN 3.8L WILL INTERMIT NOT START / I GET CHECK ENGINE LIGHT AND ELECTRICAL LIGHTENING BOLT. ABOUT 3 YEARS AGO IT STARTED AND I WAS TOLD IT WAS MY BATTERY. REPLACED MY BATTERY IT WAS GOOD FOR ABOUT 1YR THEN IT STARTED AGAIN HAD THE BATTERY REPLACED AGAIN THEN ABOUT 1YR LATER IT STARTED AGAIN BUT MY BATTERY IS TESTED GOOD. I WENT THROUGH 2 BATTERIES IN ABOUT 3 YRS. I EVEN HAD MY STARTER CHECKED AND IT TESTED GOOD. MY FRIEND WHO IS A MECHANIC SAID WHY IS THE STARTER NEXT TO THE EXHAUST MANIFOLD IT IS GETTING HOT. WHEN I HAVE ISSUE IN THE LAST YEAR IT TAKE ABOUT 30MIN OR LONGER BEFORE IT STARTS THEN I MIGHT NOT HAVE ANY ISSUES FOR ABOUT 1 OR 2 WEEKS AND SOMETIME I MIGHT HAVE THE ISSUES 2 TIMES IN ONE DAY. I HAVE CHECKED ONLINE AND I AM SEEING MANY PEOPLE ARE COMPLAINING ABOUT THE 2009 VW ROUTAN INTERMIT NOT STARTING. I HAVE CALL VW AND MY VAN IS NOT ON THE LIST FOR THE IGNITION SWITCH RECALL. TODAY 8/5/2014 MY ROUTAN I WILL NOT START AT ALL I AM GOING TO HAVE THE BATTERY CHECKED. *TR

Mileage: 30,000

TL* THE CONTACT OWNS 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS.. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 44,000.

Mileage: 44,000

I HAVE BEEN EXPERIENCING THE ENGINE DYING SUDDENLY WHILE I AM DRIVING. THERE IS NO WARNING OR ENGINE LIGHTS. EVERYTHING TURNS OFF INCLUDING THE POWER STEERING. THIS IS TERRIFYING. I TOOK MY VEHICLE TO THE DEALER, I HAVE AN EXTENDED WARRANTY. AFTER KEEPING IT TWO DAYS, THEY CLAIM THAT NOTHING IS WRONG WITH THE CAR. I TRIED TO EXPLAIN THE DANGER INVOLVED IN MY CAR SUDDENLY LOSING POWER BUT THE DEALER STATES THERE IS NOTHING THEY CAN DO ABOUT IT. *TR

Mileage: 70,000

AT LEAST TWICE PER MONTH WHEN I DRIVE MY VAN, THE STEERING WILL SUDDENLY GO OUT, THEN THE BRAKES WILL STOP WORKING, THEN IT WILL JUST SHUT OFF. SO FAR IT HAS ONLY HAPPENED WHEN I WAS DRIVING AT PRETTY LOW RATES OF SPEED. I'VE CALLED THE VW DEALERSHIP SEVERAL TIMES AND EACH TIME THEY SAY THAT THEY HAVEN'T HEARD OF ANYTHING LIKE THIS BEFORE AND WANT TO CHARGE ME A FORTUNE JUST TO LOOK AT IT. WITH THE NEWEST RECALL, I CANNOT UNDERSTAND WHY MY VEHICLE IS NOT INCLUDED AND THE DEALERSHIP STILL CLAIMS THAT THEY HAVE NO CLUE WHAT I'M TAKING ABOUT WHEN ALL THESE VEHICLE WERE MADE BU THE SAME MANUFACTURER. THIS HAS HAPPENED SO MANY TIMES, I CAN FEEL IT IN THE STEERING RIGHT BEFORE IT HAPPENS. AS SOON AS MY STEERING STARTS TO GET TIGHT, I HAVE TO HIT THE BRAKES RIGHT AWAY BEFORE THEY GO OUT, AND TURN THE CAR OFF. USUALLY WHEN I RESTART THE CAR, IT'S FINE. THIS IS GETTING RIDICULOUS AND I SHOULD HAVE TO GO THROUGH THIS WITH A VEHICLE WHEN THERE IS A PROPER FIX. I HAVE 4 CHILDREN AND ANOTHER ON THE WAY AND THIS IS NOT SAFE. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE ENGINE WOULD STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE WIN MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

Mileage: 85,000

WHILE DRIVING, ENGINE SHUT OFF LIKE THE IGNITION WAS TURNED OFF - LOST POWER STEERING AND BRAKES. THIS HAS HAPPENED MULTIPLE TIMES SINCE INCIDENT DATE. VOLKSWAGEN SERVICE COULD NOT DIAGNOSE THE PROBLEM. *TR

Mileage: 65,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE WOULD STALL. THE VEHICLE WAS ABLE TO RESTART AND OPERATED AS NORMAL. THE VEHICLE TAKEN TO THE DEALER MULTIPLE TIMES BUT THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000. UPDATED 10/7/14*CN UPDATED 5/12/2015 *JS

Mileage: 50,000

MY ELECTRICAL SYSTEM WENT OUT ON MY MINIVAN AND I WAS NOT NOTIFIED THAT IT HAD A RECALL ON IT. MY VAN WILL NOT START. I HAVE 2 CHILDREN THAT I HAVE TO GET AROUND TO SCHOOL AND SPORT ACTIVITIES, DOCTORS APPOINTMENTS, ECT. I HAVE SO MUCH TROUBLE WITH THIS VAN SINCE I BOUGHT IT. WITH ALL THE RECALLS, COMPUTER FAILURE AND THE COOLANT LEAK INTO THE INSIDE OF THE VAN, THE INTERIOR COMING DOWN, AND NOW THE ELECTRICAL SYSTEM FAILING NOW. I HAVE NO CAR TO GET ME KIDS ANYWAY NOW. PLEASE HELP ME. *TR

Mileage: 61,344

THE CAR SUDDENLY SHUTS DOWN LOOSING ALL ELECTRICAL POWER. IT LOOSES ALL POWER STEERING AND BRAKING ABILITY.IT HAS DONE THIS SEVERAL TIMES AT VARIOUS SPEEDS. I HAVE TO COMPLETELY TURN OFF THE CAR AND START IT ALL OVER AGAIN. THIS HAS BEEN VERY DANGEROUS. *TR

Mileage: 83,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL BECAME STIFF AS THE VEHICLE STALLED. THE TRACTION WARNING LIGHT ILLUMINATED AFTER THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 74,000.

Mileage: 45,000

THE VEHICLE HAS A NEW BATTERY WHICH IS CORRECTLY INSTALLED AND FREE OF CORROSION. WHEN THE KEY FOB IS PLACED INTO THE IGNITION AND MOVED FORWARD, THE VEHICLE WILL NOT START. THE DASH LIGHTS COME ON, AND IT SHOULD START, BUT IT DOES NOT. IF YOU KEEP TRYING, OR WALK AWAY AND COME BACK AFTER A FEW MINUTES AND TRY AGAIN, IT DOES SOMETIMES START. THIS INTERMITTENT PROBLEM SEAMS TO HAVE NO RHYME OR REASON AND I AM CONCERNED THE VEHICLE MIGHT STOP WHILE MY WIFE OR I DRIVE IT. THIS GENERALLY HAPPENS 4 TO 5 TIMES A MONTH. ANY HELP WOULD BE APPRECIATED. *TR

Mileage: 86,980

WE HAVE A 2009 VW ROUTAN SEL THAT HAS STALLED MULTIPLE TIMES NOW (4-5) WHILE DRIVING. THERE IS NO WARNING AND CAR LOSES POWER. CAR STARTS UP IMMEDIATELY AFTER PUTTING IN PARK AND RESTARTING. THIS SEEMS TO BE COMMON PROBLEM AND THERE IS A RECALL FOR THE 2010 MODEL AS WELL AS THE CHRYSLER MINIVAN WHICH THIS CAR IS BASED FROM. *TR

Mileage: 64,000

WHILE DRIVING AT 35 MPH THE ENGINE INCLUDING ELECTRICITY AND POWER STEERING SHUTS OFF COMPLETELY. HAD TO PULL OVER AND PUT IT IN PARK TO RESTART THE CAR. THIS HAS HAPPENED NUMEROUS TIMES. I TOLD THE DEALER THAT I READ ABOUT THE RECALL ON THE YEAR AFTER MODEL THAT THEY FIXED THEIR CAR (CHANGED WIN MODULE) FREE OF CHARGE. HE SAID MY CAR IS NOT INCLUDED IN THE RECALL. WHEN DOES IT BECOME A RECALL? THIS IS A SAFETY ISSUE. *TR

Mileage: 9,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE WIND MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE. *TR

Mileage: 80,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 11,046.

Mileage: 11,046

VEHICLE ENGINE WILL TURN ITSELF OFF AND LOSE POWER WHILE DRIVING DOWN THE ROAD. ABLE TO PULL THE CAR OFF THE ROAD AND IMMEDIATELY RESTART THE ENGINE. IT CAUSES A LOSS OF POWER STEERING, POWER BRAKES, ETC. THIS HAS HAPPENED MULTIPLE TIMES AND WHENEVER TAKEN TO DEALER FOR DIAGNOSIS THE ISSUE CAN NOT BE DUPLICATED. USUALLY HAPPENS WHEN THE CAR IS COLD, BUT YESTERDAY IT HAPPENED AFTER WE HAD BEEN DRIVING FOR A COUPLE OF HOURS. YOU CAN WATCH THE RPM'S DROP EVERY NOW AND THEN AND SOMETIMES IT WILL CATCH IT AND KEEP THE MOTOR RUNNING, BUT SOMETIMES NOT. *TR

Mileage: 33,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THE CONTACT WAS INFORMED THAT THE WIRELESS IGNITION NODE RECEIVER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 61000.

Mileage: 61,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS RESTARTED. THE VEHICLE RESUMED NORMAL FUNCTION. THE CONTACT ALSO MENTIONED THAT THE BRAKES HAD TO BE REPLACED OFTEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 47,000.

Mileage: 47,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN ROUTAN. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO SAFELY MOVE TO THE SHOULDER AND RESTART THE VEHICLE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.

Mileage: 54,000

WHEN I PURCHASED THE CAR THEY CHECKED THE OIL AND I SAW IT WAS CLEAN AND FULL. AFTER A WEEK MY WIFE TOLD ME THE OIL LIGHT CAME ON. I CHECKED THE OIL AND THEIR WERE NO OIL ON THE DIP STICK. I FILLED THE OIL TO THE CORRECT SPOT ON THE DIPSTICK. A WEEK LATER I CHECK THE OIL AND AGAIN THERE WERE NO OIL ON THE DIPSTICK. SO I CALL THE DEALER AND THEY SENT ME TO SEARS WHO COULD NOT FIND A LEAK AND THEY CHANGED THE OIL. I CHECKED THE OIL THE FOLLOWING WEEK AND AGAIN THERE WERE NO OIL ON THE DIPSTICK. SO I CALL THE DEALER AGAIN AND THEY SENT ME TO ANOTHER MECHANIC WHO COULD NOT FIND A LEAK. I'M NOW CHECKING AND ADDING OIL WEEKLY. *TR

Mileage: 84,219

WHILE DRIVING AT VARIOUS SPEED THE CAR SUDDENLY SHUTS OFF AND LOSES POWER STEERING. THIS HAS OCCURRED 4 TIMES NOW AND IS EXTREMELY DANGEROUS. CAR CAN ONLY BE RESTARTED WHEN AT A COMPLETE STOP AND PLACED BACK IN PARK. *TR

Mileage: 59,500

NOTICE OIL LIGHT COMING ON BETWEEN OIL CHANGE....FILLED OIL TO PROPER LEVEL...I TOOK CAR IN FOR SERVICE TODAY (1/7/13) WAS TOLD BY DEALERSHIP THE GASKET WILL NEED REPLACE, THAT WAS THE REASON FOR OIL USAGE. I JUST HAD MY VEHICLE IN TO FIX THE SLIDING DOOR (TSB RECALL NOT HONORED) IN OCTOBER AND IN WAS INSPECTED WITH NO PROBLEMS. DOING RESEARCH ON INTERNET AND FINDING THE OIL, DOOR IS A COMMON PROBLEM IN VW ROUTAN ( ALSO TALKED TO ANOTHER OWNER WAS IN FOR SAME PROBLEM, STATED HAS BEEN GIVEN RUNAROUND SINCE DAY ONE ABOUT PROBLEMS WITH HIS ROUTAN). *TR

Mileage: 45,000

10/7/12: ENTERING ONTO ROAD, BEGAN ACCELERATION UP TO 20/25 MPH -THEN ALL POWER, CONTROLS DEAD. LOST POWER STEERING AND COASTED INTO PARKING LOT. SHUT CAR DOWN, FLOODED/PUMPED ACCELERATOR PEDAL. DIFFICULTY STARTING BUT WORKED, DROVE LIKE NORMAL, AGAIN. 10/14/12: TURNING FROM SIDESTREET, ON TO MAIN STREET -GOING 20 MPH. LOST ALL POWER AGAIN-MANUALLY TURNED COASTED CAR INTO LEFT MIDDLE TURNING LANE. RE-STARTED, OPERATED NORMAL. *TR

Mileage: 57,000