2022 VOLKSWAGEN TAOS Unknown Or Other Problems

I am reporting a repeated safety-related defect involving exhaust intrusion into the cabin of my 2022 Volkswagen Taos. The vehicle experienced loss of power, coolant loss, and engine warning indicators, and was serviced twice by Volkswagen Southtowne in Sandy, Utah. First Incident – Vehicle Returned as “Safe to Drive” During the first repair visit, the dealer diagnosed issues involving the manifold/exhaust area, head gasket, coolant system, and catalytic converter. After keeping the vehicle for an extended period, the dealership informed me the vehicle was “safe to drive,” although the repair was not fully completed. I relied on this representation. After the vehicle was returned to me, I began experiencing significant physical symptoms only while driving the vehicle, including nausea, dizziness, and vomiting. These symptoms occurred repeatedly during operation and would subside after leaving the vehicle. At the time, I did not understand that these symptoms were caused by exhaust entering the cabin. Second Incident – Defect Confirmed and Additional Repairs Performed Weeks later, the symptoms persisted and I returned the vehicle to the same dealership. At this second visit, the dealer reported coolant leakage and additional gasket failures. They removed the cylinder head, replaced gaskets, and performed additional exhaust-related repairs. I was provided a loaner vehicle during this extended repair. After this second repair, the symptoms while driving stopped. Safety Concern Based on the timing of symptoms, the repair records, and the resolution following the second repair, I believe that exhaust gases were entering the cabin of the vehicle during normal operation for an extended period. This created a significant safety hazard. I was repeatedly assured the vehicle was “safe to drive” when it was not. I unknowingly operated the vehicle while being exposed to exhaust fumes for several months. The condition caused physical illness, impaired my ability.

I purchased the vehicle in 2022 & in 2023 the low coolant light turned on. Now at 54k miles the low coolant light has turned on again and the head gasket is definitely leaking. I’m out of warranty because I’ve hit 54k miles. This is absolutely unacceptable for a brand new car.

I am reporting serious electrical/CPU defects and dealership workmanship issues with my 2022 Volkswagen Taos. Since purchase, the vehicle has shown repeated electronic malfunctions: dash blackouts, HVAC/remote start errors, infotainment resets, and a cooling fan that ran 24+ hours after shutoff. Warning alerts are delayed or absent (no warning before head gasket failure at 42k miles; oil-level alert appeared 8 weeks after a dealer oil change; turbo underboost fault only appeared 9 months after a missing O-ring). Independent scans (AutoZone) have shown generic fault codes (ABS communication error), while Volkswagen dealerships repeatedly reported “no faults found.” Service staff told me they only read “VW codes,” ignoring generic ones that point to safety problems. Major events tied to these failures: Nov 2024: Head gasket failure at 42k miles, no warnings triggered. Aug 2025: Turbo charge pipe disconnected at highway speeds, car went into limp mode. Independent shop documented it “must have come loose or was not properly installed.” Sep 2025: EPC again; dealer found missing O-ring on intake pipe, likely from Nov 2024 repair. These failures have repeatedly stranded me in limp mode with my child in the car. The CPU’s failure to log and alert is a systemic defect. A similar delay with steering or braking could be deadly. I have raised concerns with Fox Valley Volkswagen since 2022 and sent certified letters in Sept 2025. They denied responsibility, calling each failure “unrelated.” Volkswagen of America also pushed me back to the dealer. This is not a one-off repair issue. It is a systemic CPU/electrical defect suppressing warnings until after failure, compounded by sloppy workmanship. My car is unsafe to drive. I request investigation into VW’s diagnostic practices, CPU/sensor monitoring delays, and dealer handling of safety-critical repairs. I have Service reports but I ran out of room and they couldn't be attached with the rest of the documents below.

While driving I heard a small crack I looked up and notice where you can turn the lights on in the inside the whole unit fell out on me while driving. Almost crashed. And once we tried to put it back up it all the plastic strutted to crack.

About a month ago I saw paint flaking off from about the front windscreen where the sunroof meets the body about quarter sized. The paint appeared not to hold to the body of the vehicle even though the primer was applied. A month later it's about the size of 2 credit cards and definitely the primer on the vehicle is not holding the paint and is a manufacturer defect. I reported this to the dealer but they said it's out of warrenty. Other owners with this vehicle reported the same flaking from the same area on online forums and on the news. I would like the manufacturer to fix this before rusting happens on the body of the car and more serious issues occur. It is definitely a defect with the primer or paint, I never got hit by any object while driving nor saw any paint damage prior to this when I purchased the car.

Leaking head gasket, low coolant light came on twice.

Car dies/stalls while in drive when adaptive is engaged. Entertainment / navigation system has quit working despite multiple times I’ve reset. Acceleration is dangerous at times and accelerates too quickly. Also seems to be sluggish due to fuel injector issues requiring me to press gas pedal harder to maintain speed. Windows don’t always respond to button and seem to stall. Check engine light keeps coming on despite being cleared . I only have 28,000 miles.

Coolant warning made me pullover on highway looked online a lot of people have the same trouble of coolant going low without any visible leak.

Sunroof shattered at a red light suddenly. Outside temperature was around 50 F. Two friends had small superficial cuts. We were stopped at a red light at the city (ATL). Vehicle is been inspected and the fault is been adjudicated to an impact. Sunroof has cero impact marks nor does it have impact holes or impact point. Two main horizontal fractures can be seen at the front and back portion of the glass. Affected glass is the first motorized glass. No other impact of scratches on the car.

It’s happened 2x in owning the 22 Vw Taos. The car will start be good for about 5 seconds, then car shakes like the engines misfiring, check engine light flashes, steering does become locked a little and difficult. Once you start up again it’s fine. Happened in Nov 2024 and today 3/8/2024

Car hesitates when gas is pushed and will take off suddenly .Almost caused a accident many times vehicle is dangerous!! Some thing must be done!!

The radiator was broken due to a rock hitting it while simply driving down the road out of town and wasn’t covered by warranty. My engine started overheating and has been overheating every now and then ever since now due to coolant leaking because of a head gasket leak. Oh and that’s not covered by warranty now either.

I recieved an error message stating "start/stop" error.

Driving uphill on the highway at 80 mph with cruise control on. I then turned the cruise control off. Vehicle lost complete engine power and could no longer accelerate. All the warning lights came on, vehicle displayed “max rpm 4000x” with little speed left on vehicle I was able to move to the shoulder of highway and park. The vehicle displayed EPC light and “Please start engine manually” after several minutes I restarted vehicle it did start but it was delayed. I resumed my commute and after getting off the highway I came to a complete stop at the stop sign and when I accelerated the vehicle felt like the brakes got slammed on and it jerked, while a vehicle was following close behind me. Extreme safety hazard

I have 44,000 miles on my 2022 VW Taos. The EPC warning light came on. Took it to VW dealership. It needed a “software update”, which was still covered under warranty

In April 2024, the VW Taos leaked coolant due to a faulty gasket. Upon being fixed, an EPC light came on and leaked oil. This caused us to have it towed to the dealership for repairs to the oil cap lining. After the car was returned, the light was cleared and no longer leaked oil. In May 2024, the EPC light reappeared and cause a significant reduction when accelerating at 50 mph. When the light came on the vehicle had errors stating that the max rpms are exceeded and the car reduced power. We took the car to VW State College who was unable to find an issue with the car and cleared the light. We were able to drive the vehicle at slow speeds back to Moon Township for diagnostic and testing. The vehicle has remained with VW since late may and as of 6/11/2024, Volkswagen is unable to determine the cause of the EPC light. The second time the EPC light came on, the car stalled out at an intersection causing significant injury risk to the occupants. VW Moon Township has performed the investigations and VW State College was unable to diagnose the EPC light cause. The EPC light did not appear prior to the initial coolant leak.

I purchased my vehicle new on 12/31/21. The vehicle currently has 19,200 miles. The coolant light went on so I took it to the VW dealership as it was due for an oil change and tire rotation soon. The dealer indicated that the head gasket is leaking internally. The parts are on back order and there is no eta. From what I have researched regarding other 2022 VW Taos owners experiences with head gasket issues, it could be 30-90 days before I get my vehicle back (which the dealership has indicated is true). There appears to be a host of other issues that people are having with their 2022 VW Taos including rear brakes wearing way too fast and other engine issues. I have no concerns with how the dealership is managing this issue, however, based on my research, I am surprised a recall has not yet been issued. I am concerned about the lifetime health of my vehicle and the issues I may to deal with after the warranty ends, if the engine is already requiring major repairs after only 2 years and less than 20,000 miles.

Complete radio/gps randomly shuts off. GPS is always saying these VW are in different locations than they are.

My 2022 Volkswagen Taos 4 motion around 29,000 miles November 8, 2023 overheat warning light on, call toll to dealership results of head gasket problem part wait time at least 2 months but dealership offers free loaner car, but unfortunately dealership called me on December 29th the part not available until April that I have to return my loaner car that Volkswagen not available and I have drive my own car until part come, any I purchased 5 additional bumper to bumper warranty not even qualify any free loaner car for Volkswagen bad design.

My car suddenly shuts off even while in motion. When this happens I have to brake, put the car in Parking, press the off button, press it again to turn the car on, put the car on Drive, and the I can keep going. This is extremely dangerous, and have almost been hit several times. I don’t feel safe driving my car anymore. I brought my car to the VW dealer and they said there is nothing wrong with the car.

Head gasket is leaking engine coolant. Engine coolant light stays on.

There is a serious acceleration problem. When trying to enter into traffic either turning left or right or going straight from stopped position, there is serious lag/hesitation to the vehicle accelerating. After pressing the throttle for a couple of seconds with very little movement, it will then jerk and squeal the tires. There have been many times when we have come close to being hit by this problem while pulling into traffic. I have had this vehicle back to the dealer twice. The first time they said there was no issue. The second time, I talked to the service manager (a personal friend) and he admitted there was an issue with acceleration. However, Volkswagen had no solution. No one else has looked at this vehicle. No warning lamps or lights. I have another appointment with my dealer for the latest recall and will address this with them again. Please, please, please discuss this with Volkswagen and get them to fix this issue. Other than the lag/hesitation in acceleration, I very much like this vehicle.

Trying to leave work. Have to stop the car to scan my badge. Went to hit the gas and the car was off while in drive. Took me 5 minutes to get the car to turn back on. Serious safety issue that they said is only happening to the AWD but it’s also happening to the FWD and Volkswagen is not doing anything about it.

This car has a very dangerous lag on acceleration. You push the pedal more and more and then all of a sudden it lurches forward and it is very dangerous when turning a corner onto traffic.

This is on going issue with VW. Every time they update the emc the car gets worse. Car has hesitation, jerking and delayed throttle response which almost got me hit 2 times when changing lanes. You depress the gas pedal and car does not going anywhere. When maintaining speed and depressing gas pedal theres no response and then all of sudden it kicks in for the speed you wanted and if not that speed you were doing it jerks, downshifts. Makes transmission go nuts sometimes. When accelerating to get on highway and you depress pedal to floor it literally spins the tires after long delay. This was demonstrated to dealer who returned vehicle stating only occasion lag tech case# 3091845. This issues are very dangerous and someone will get hurt. This has been going on since car was new. It stopped for a year and after Campaign 24IR it messed car up again.

2 instances occurred where the auto start/stop initiated in the midst of driving resulting in a stall and required the car to be restarted in order to start driving again. One time occurred while backing up and another while taking a turn both at low speeds. There was a recall on 2021 Volkswagen Taos’s for the same problem. I brought the car to the dealership to be assessed and the car remained in the service lot from 7/6/23 to 7/17/23, however the problem could not be recreated. Thus the car was returned to me without any solution. I clearly stated to them that I am picking up the car against my wishes as no solution was found and this has been extremely dangerous almost causing accidents.

While driving my vehicle the engine became unable to shift gears or speed up. The check engine light came up and shortly after the EPC light appeared. After coming to a stop, the vehicle died and was unable to turn on. After returning it to the dealer - they informed me it was due to a recall on the VW Taos software which appears to be consistent with the 2022 Taos recalls on AWD vehicles. My car is FWD drive but empierced the same problem and I was not notified of any potential issue. This happened while I was driving to Puerto Penasco, Mexico just south of the Arizona border for a weekend trip. Luckily, my vehicle broke down just outside of the city where we could call a tow truck and safely sit on side of road. The drive is only 4 hours from Phoenix but 90% of the way is through the desert which I feel extremely fortunate this did not happen in a remote area. Volkswagen only provides roadside assistance in the United States, so I had to pay out of pocket to get my car towed across the border and picked up to go to the dealer. My vehicle only has 11,470 miles and is 18 months old. The vehicle was serviced at 10,000 miles and I was not notified of any potential defects.

Error: stop / start message, vehicle acting like it was about to stall out, couldn’t go over 25 mph, engine light came on, and lane assist keeps disabling. First incident 3/8/2023. Second incident 5/3/2023.

System: Infotainment touch screen goes blank. System resets after a period of time. Safety: Unable to see rearview camera, make adjustments, and/or follow navigation prompts while screen is blank. Dealer: Dealer says there isn't a fix. Infotainment has been updated to the latest firmware.

While stop at red light on 2 occasions, the car goes into the auto stop start feature. The light turns green and I depress the accelerator to start to drive and nothing happens. I frantically try to determine what's going on my, shifter is in Drive and nothing. I press ignition to start and it states car in drive. Shift car to park and car starts. This all occurred after VW did Campaign #24IR. This is dangerous since if people don't realize your not moving they can rear end you or go backwards on a hill.

The start/stop system error. I have taken the vehicle in and every time I’ve been told there is nothing they can do to fix it, only annotate the codes. The first incident I had been driving for about 10 minutes and was on the highway and had to slow down. When attempting to accelerate past 50 mph I could not. Multiple incidents have occurred since each has been on city streets. It makes the car stutter to accelerate off at all. This has happened multiple times leaving my neighborhood. This could cause me to be t-boned if it stalls while traffic is high. The issue cannot be reproduced by the VW dealership as shutting off the engine and starting it again corrects the issue temporarily. Until you do so the vehicle will not accelerate properly. Only the dealership has inspected. The check engine light comes on until you restart the vehicle then goes away.

While 19 year old daughter was at highway speed on interstate (speed limit 65 mph) vehicle suddenly stalled while in heavy traffic with epc and check engine light coming on. Happened twice in last 2 days. Called VW Corporate and filed open case and had them check vin for recalls and asked them if this was a known problem. Was told vin is up to date re recalls and TSB's despite finding conflicting information online. Vehicle will be in dealer tomorrow to attempt duplication of issue/read stored codes, and try to repair. Unsafe vehicle and never would have leased it had I known of the numerous issues with this vehicle and know stop sale order by VW to dealers late 2021. Feel deceived with long business dealings with VW and dealership.

Repeat start stop error message check engine light on for a few moments. Today my car completely lost all power on the road.

Driving today 2-25-22 near Dripping Springs TX And heard what sounded like a gunshot and noted that my panoramic sun roof glass imploded.

The infotainment system on this vehicle does not always turn on when the vehicle is started and has stayed off for long durations of time from 2 minutes to an entire day of driving. This means the backup camera does not function nor does Bluetooth. I have brought it back to the dealership multiple times only to be told it just needs a software update. Most recently I had it serviced Feb 17th 2022 for a software update and the issue is still on going. I drove for 20 minutes without the infotainment system turning on.

Periodically the MIB infotainment screen blacks out; this in turn places a warning error in the driver center console screen. While this occurs, nothing else can be accessed or displayed in the center console screen. This creates a potentially dangerous situation as it can lead to confusion on a variety of things (example: Is cruise control still engaged?). It can also deprive the driver of key safety information (example: If one or more tires experiences a loss of pressure, the driver will not be warned). Furthermore, if the driver is reliant on Navigation and is driving under stressful and adverse weather conditions, this could create panic and result in a collision. VW has no fix for the issue currently and is releasing the vehicle back to me, even though I have stated my safety concerns.

MIB infotainment system blanks out, simultaneously sending error code to driver center console rendering it useless. Key functions are therefore inoperable or inaccessible, including (but not limited to) TPMS monitoring / alert warning, rear view camera display, and potentially a host of other safety and advanced driver assist functions.

The vehicle drives well and the problems surface without any prior indication or warning. The PROBLEM: while driving the vehicle slows down to about 10-15 mph. when I try to press the gas pedal, the vehicle does not increase speed. In addition there is a loud sound coming from the engine. also, there is a grating/vibration as if one drives on a gravel road. The service light shows up in red, and the "+" sign next to "D" shows red: I use the "D" to drive and not the overdrive. The gear lever does not release as it is stuck. My wife and I feel very alarmed because the cars behind are braking and blowing their horns. I managed to slowly drive off the main road to the nearest parking and turned off the ignition. When I turned on the engine again I was able to continue. I have been calling for an appointment to correct the problem but have not been able to get an appointment as of date. I am scared to drive the vehicle. I am having it towed to the dealership. I leased the vehicle on 6/3/21. The problem first occurred on 6/18/21. It occurred again on 9/15/21, and 9/17/21

When I depress the accelerator, the car jumps ahead or stalls. I took this to the local dealership and was told this car is on a do not sell list- 1 day after purchase. They, along with VW customer care has advised against driving the vehicle and encouraged it be towed to a dealership. This is my only vehicle and without it I have no transportation. They are unable to provide alternate transportation. I have been working with VW customer care.