2009 VOLKSWAGEN TIGUAN Engine Problems

The car keeps throwing sensors (camshaft, crank sensors, throttle body etc) and the ECM needs to be updated. It keeps turning over. I checked the recall list of VINs and mine is within the range, however there aren't any recalls listed.

The contact owns a 2009 Volkswagen Tiguan. The contact stated while driving at 45 MPH, the accelerator pedal was depressed but the vehicle failed to respond and seized. There was no warning light illuminated. The vehicle was not drivable. The vehicle was towed to an independent mechanic where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The local dealer was not contacted. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 08V235000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 189,000.

Mileage: 189,000

The contact owns a 2009 Volkswagen Tiguan. The contact stated that while her son was driving at an undisclosed speed, the oil pressure warning light illuminated and a message to stop the vehicle immediately was displayed. AAA arrived on the scene and diagnosed the vehicle with oil sensor failure. The vehicle was driven to an independent mechanic and the vehicle was repaired; however, the failure reoccurred. The vehicle was vibrating while driving back to the residence. The vehicle stalled upon arrival at the residence in the driveway. The vehicle was towed to the local dealer and diagnosed with timing chain and timing sensor failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 84,092. The contact stated that VW of America was notified of the failure. The vehicle was taken to another dealer for a second opinion and all of the issues were confirmed. It was strongly recommended that the engine be replaced as well.

Mileage: 84,092

The engine reached 100k miles in the second week of April 2022. After that, I tried to turn on the vehicle, and the engine did not respond. I took my car to the mechanic, and he told me that the car needed an engine replacement. This is very strange since the vehicle had an excellent maintenance schedule, and I usually, this type of car last longer. That engine issue could have caused a severe accident on the road, and fortunately, it never happened. The timing belt might have an issue there, but I had very little information from the engine codes since I did not have an indicator earlier. It just appeared like that. I feel that this type of issue is unfair. After having more than four cars with way more miles, this has never happened, and on average, a Tiguan engine should last at least 150k miles according to the statistics of the vehicle model and year. I feel upset and disappointed with this vehicle model since the cost of replacing the engine cost around 6000$, and I am an international student with no money to do that repair. I feel helpless, and VW told me the only way to get a recall of this car is through a report from the NHTSA, which would be fair given the circumstances I have been through. The only thing I request is to generate a recall for this vehicle if possible. I hope some reads this, and I appreciate the work you do. Thanks

Problems start with ABS and Steering warning lights with EPIC warning on dash, flickering of lights and radio shut off by loosing power steering and rough acceleration and idling. Has been in to VW dealership 5 times now with repairs "fixing" problem for a few days - a week before returning again. This is a safety issue because this happens very quickly and without warning. Once I was on a highway and had to carefully move to side of the road and limp to a safe area (luckily I was in the right lane already).

AIR BAG LIGHT ALL OF A SUDDEN CAME WITHOUT BUMPING - THE ENGINE IDLE WERE NOT NORMAL HIGH AND LOW - ELECTRICAL PROBLEM FROM THE STEERING

Mileage: 97,000

MY VEHICLE HAS BEEN HAVING ELECTRICAL PROBLEMS WITH THE THROTTLE BODY SYSTEM AS WELL AS THE COOLANT HOSE WHICH HAD TO BE REPLACED MY RADIO GOES BLANK TO WHERE I CAN'T SEE MY BACK UP CAMERA ! THIS VEHICLE HAS TO MANY ELECTRICAL ISSUES! *TR

THE TURBO BLEW CAUSING THE CAR TO STOP IN THE MIDDLE OF TRAFFIC. THE BLOWN TURBO CAUSED METAL TO GO INTO MY FUEL SYSTEM AND OIL. THE AIR BAG SENSORS ARE FAULTY. THEY CANNOT SENSE SOMEONE IN THE SEATS. THE CAR HAD TO BE TOWED TO A AUTO SHOP. DUE TO THE BLOWN TURBO, IT WILL COST $5,500 TO FIX.

Mileage: 135,000

VW TIGUAN 09 PURCHASED AS NEW. ONLY 50K MILES ON IT WHEN CHECK ENGINE LIGHT WAS ENCOUNTERED. SOON AFTER (LAST WEEK, NOV 25 2019), ENGINE STALLED WHILE ACCELERATING OUT OF SECOND GEAR AND WAS SEIZED. INDEPENDENT MECHANIC SAID IT WOULD COST 5,800 TO REBUILD ENGINE. WHILE DOING MY OWN INDEPENDENT RESEARCH, DISCOVERED THE COMPLAINTS HERE DETAILING PRECISELY THE SAME ISSUE (TIMING CHAIN TENSIONER FAILURE) THAT WAS DESCRIBED TO ME BY MY MECHANIC. THEN DISCOVERED THAT THERE IS A CLASS ACTION SETTLEMENT REIMBURSEMENT (HTTPS://TIMINGCHAINLITIGATION.COM/) FOR THIS ISSUE THAT I AM NO LONGER ELIGIBLE FOR BECAUSE JAN 25 2019 FILING DEADLINE WAS NOT MET - KEEP IN MIND THAT MY ENGINE FAILED ONE WEEK AGO (11/25/2019) WITH ONLY 50K MILES ON IT. I TOO, NEVER RECEIVED A CLASS ACTION NOTICE IN THE MAIL. AFTER CALLING THE CLASS ACTION HOTLINE, I WAS TOLD TO SEND AN EMAIL TO THE LAWSUIT SETTLEMENT ADMINISTRATOR REQUESTING A FILING DEADLINE EXCEPTION. UNLIKELY THAT ANY OF THIS WILL WORK IN MY FAVOR. BUT I TOO, LIKE MANY OTHERS HAVE BEEN UNNECESSARILY BURDENED BY VOLKSWAGEN'S NEGLIGENT HANDLING OF THIS MAJOR DEFECT. IT'S UNFORTUNATE THAT CUSTOMERS LIKE MYSELF ARE NOW SADDLED WITH THIS COMPLETE LOSS.

Mileage: 50,000

CAR STOPPED AND WOULD NOT START DUE TO TIMING CHAIN TENSIONER FUALT WITH CODE P0016. CAUSED COMPLETE ENGINE FAILURE AND THE NEED TO COMPLETELY REBUILD THE TOP END OF THE ENGINE. THIS WAS VERIFIED AFTER A COMPLETE LOSS OF COMPRESSION DUE TO THE VALVES BEING DESTROYED ON THE ENGINE.

Mileage: 114,000

MY 2009 VW TIGUAN ENGINE FAILED AS I WAS DRIVING TO WORK 35 MPH, IN HEAVY TRAFFIC, OUT OF NOWHERE MY CAR ENGINE MADE SCARY CRUMBLY NOISE AND SUDDENLY DIED IN THE MIDDLE OF THE TRAFFIC; COMPLETELY DEAD. I WAS SCARED TO DEATH AND IF I DIDN'T REACT FAST TO PUT EMERGENCY LIGHTS ON, I COULD HAVE BEEN PLOWED BY A BIG TRUCK BEHIND ME. THERE WERE CARS PARKED ON EACH SIDE OF THE STREET, AND NO PLACE TO PULL OVER. I WAS CLOSE TO WORK BUT WAS STRANDED ON THE STREET WITH HIGH TRAFFIC BECAUSE I COULDN'T MOVE THE CAR. I TRIED TO TURN IT ON BUT AGAIN SAME RUMBLING SOUND AND DEAD AGAIN. I CALLED A FRIEND TO HELP ME PUSH THE CAR TO MY EMPLOYER'S PARKING LOT SO I COULD BE SAFE. AFTER WORK I CALLED AAA FOR ASSISTANCE AND THEY COULDN'T START THE CAR SO IT WAS THEN TOWED TO THE PLACE I LIVE. THEY ALSO CONCLUDED THAT THE ENGINE IS THE PROBLEM. THAT IS WHEN I STARTED RESEARCHING ABOUT IT AND FOUND OUT THERE WAS A SETTLEMENT FOR TIMING CHAIN THAT I WAS NEVER INFORMED ABOUT AND MY VIN GOT MATCHED. I BOUGHT THIS CAR ON 07/31/2018, IT WAS WELL MAINTAINED SINCE THEN AND NO ISSUES PRIOR TO THIS. THIS IS A SERIOUS ISSUE SINCE I HAD NO PRIOR WARNING AND COULD HAVE KILLED SOMEONE OR SOMEONE COULD HAVE KILLED ME IN THE ACCIDENT. I AM ASKING YOU TO HELP ME FIGURE THIS OUT AND HELP FIX THE ENGINE PROBLEM ON MY VEHICLE. I CAN'T STRESS ENOUGH HOW SCARED AND CONCERNED I AM SINCE THEN ESPECIALLY BECAUSE I HAVE TWO CHILDREN THAT I DRIVE IN THIS SAME CAR AND I THOUGHT THIS CAR IS SAFE FOR THEM AND MYSELF AND EVERYONE AROUND ME WHEN I'M IN TRAFFIC. I LOVE THIS CAR BUT NOW NEITHER I CAN DRIVE IT NOR I FEEL SAFE ANY LONGER IN IT. THIS CAR IS EVERYTHING TO ME AND WITHOUT IT I CAN'T GO TO WORK AND MAKE MONEY OR GO TO PICK UP GROCERIES. I'M A SINGLE MOM AND NO FAMILY AROUND AND I ENTIRELY DEPEND ON THIS CAR TO MAKE THE LIFE FOR MY CHILDREN AS STABLE AS POSSIBLE.

Mileage: 113,000

ON ENGINE START UP, THE CHECK ENGINE LIGHT CAME ON. AFTER DRIVING IT A SHORT WHILE, THE CAR WOULD NOT START AGAIN. HAD IT TOWED TO A QUALIFIED MECHANIC WHO DIAGNOSED THAT THE TIMING CHAIN TENSIONER FAILED AND THE ENGINE JUMPED TIME, CAUSING CATASTROPHIC DAMAGE TO THE CYLINDER HEAD AND PISTONS. MECHANIC ESTIMATED A REPAIR COST OF APPROXIMATELY $6000.00 TO REPLACE THE ENGINE WITH A USED ONE. THE CAR HAD LESS THAN 100K MILES BUT THE REPAIR WOULD HAVE COST MORE THAN IT WAS WORTH. VOLKSWAGEN WILL NOT PAY FOR THE REPAIR, EVEN THROUGH A CLASS-ACTION LAWSUIT WAS SETTLED AGAINST THEM FOR THIS ISSUE, SINCE THE DEADLINE FOR APPLYING WAS 6 MONTHS PRIOR TO THIS INCIDENT.

Mileage: 99,760

SUNROOF HAD DEFECTED DRAIN TUBES. DUE TO THE DRAIN TUBES BEING DEFECTED, IT CAUSED A MAJOR LEAK IN THE SUNROOF AND ENDED UP FLOODING THE INSIDE OF THE CAR. DUE TO THE FLOODING, IT SHORTED OUT MY PASSENGER AIR BAG. MY PASSENGER AIR BAG IS NOT FUNCTIONING CORRECTLY. ALSO, THE ENGINE LIGHT KEEPS COMING ON EVEN AFTER THE PROBLEMS ARE FIXED. THE ENGINE HAS BEEN FIXED NUMEROUS TIMES AND THE PROBLEMS STILL COME BACK. THE ENGINE IS FAULTY. PROBLEMS KEEP ARISING WITH THE ENGINE IN GENERAL. I HAD THE CAR LOOKED AT NUMEROUS TIMES AND ITS ALWAYS THE SAME PROBLEM BEING FIXED

Mileage: 120,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TIGUAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO ACCELERATE FROM A STOP POSITION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO VAN HORN NISSAN OF SHEBOYGAN (5515 RACETRACK RD, SHEBOYGAN, WI 53081, (920) 457-8844) WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN AND CYLINDERS NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 82,082.

Mileage: 82,082

I NOTICED A HUGE OIL PUDDLE WHERE MY CAR WAS PARKED. I DROVE STRAIGHT TO THE VW SERVICE DEPT IN MY AREA...THE CAR HAS LESS THAN 75K MILES & WAS LAST SERVICED BY A VW DEALERSHIP DUE TO FUEL PUMP RECALL. UPON MY DISCOVERY OF THE MASSIVE OIL LEAK, I NOW KNOW WAS SPAWNED FROM THE PCV VALVE GOING BAD WHICH HAS RESULTED IN BLOWING OUT 3 SEALS AND REQUIRING A NEW PAN. I HAVE RECIEVED AN ESTIMATE FROM A VW DEALERSHIP SERVICE DEPT AND A WELL KNOW AUTO REPAIR SHOP- BOTH HAVE QUOTED THE COST NO LESS THAN $2000 WITH POTENTIAL OF REACHING $3000. ESSENTIALLY THE PCV PART IS ABOUT $20.00 IN COST, BUT BECAUSE IT JUST "WENT BAD" AND ITS PURPOSE IS TO ALLOW THE ENGINE TO BREATHE...BLOWING OUT THESE ADDITIONAL SEALS MEANS THAT THE ENGINE WILL NEED TO BE REMOVED TO BE REPAIRED. THE CAR IS VALUED AROUND $7000 TO RESALE IN GOOD CONDITION. NOW, A CONSUMER HAS TO SPEND 30% TO 40% OF THE CARS VALUE TO REPAIR THE FAULTY VALVE THAT CAUSED ADDITIONAL ISSUES IN ORDER TO STOP THE BLEEDING. I BOUGHT THIS CAR FROM CARMAX AT 30K MILES IN NOV 2014- AT THE TIME OF PURCHASE THERE WAS NO DISCLOSURE OF A RECALL ISSUED IN AUGUST OF 2014 & DID NOT EVEN RECEIVE A LETTER REGARDING THE RECALLED UNTIL 2 YEARS LATER FROM EITHER CARMAX OR VW. IN ALL ACTUALITY THE ENTIRE SECTION IN THE OWNER'S MANUAL REGARDING THE ENGINE WAS COMPLETELY REMOVED & IS MISSING. NO INDICATOR LIGHTS CAME ON OR WERE DISPLAYED FROM THE LEAK OR SEALS. I WOULD HAVE NEVER KNOWN IF I WASN'T PARK IN A PAVER DRIVEWAY AT SOMEONE'S HOME & ASKED IF THAT LARGE OIL MARK WAS THERE PRIOR TO ME PARKING THERE IN THE PAST 24 HRS. IF I CONTINUED DRIVING MU VEHICLE, IT COULD HAVE RESULTED IN A SEQUENCE CATASTROPHIC EVENTS, IN A VEHICLE THAT HAS BEEN MAINTAINED ACCORDING TO ALL SERVICE STANDARDS & REQUIREMENTS ON BEHALF OF IT'S OWNER.

Mileage: 73,000

I HAVE A 2009 VOLKSWAGEN TIGUAN DURING THE TIME OF FAILURE THE VEHICLE WAS AT 96,872 MILES ON IT. I WAS DRIVING DOWN THE STREET IN MY NEIGHBORHOOD, FAIRLY CLOSE TO MY HOUSE. I HAD JUST GOT OFF WORK AND WAS COMING DOWN A SLIGHT HILL. ONCE I LET OF THE THROTTLE PEDDLE THE VEHICLE JARED AND BEGAN RUNNING TERRIBLY UNTIL THE ENGINE STALLED. I WAS ABLE TO SLOW THE VEHICLE AND PARK IN FRONT OF SOMEONES HOUSE. I TRIED TO START THE CAR AND IT WOULD CRANK BUT NO START. I GOT THE VEHICLE TO MY HOUSE AND TESTED EVERYTHING I COULD UNTIL I DID A COMPRESSION TEST, NOTHING. THE TIMING CHAIN TENSIONER FAILED AND MY TIMING CHAIN JUMPED CAUSEING CATASTROPHIC FAILURE. I WAS LUCKY TO NOT BE GOING VARY FAST AND NO KIDS OUT PLAYING IN THE STREET. WELL JUST LIKE ALL THE OTHER REPORTS, VW OFFERED NO ASSISTANCE WITH THE REPAIRS. I REALLY HOPE A RECALL COMES OUT ON THIS ISSUE DUE TO THE AMOUNT OF OCCURRENCES, BEFORE SOMEONE GETS SERIOUSLY INJURED OR KILLED. THANK YOU FOR YOUR TIME AND CONSIDERATION. SOMEBODY NEEDS TO WORRY ABOUT VEHICLE SAFETY BECAUSE WE ALL KNOW VW DOESN'T.. ITS ALL ABOUT THE $$$ TO THEM

Mileage: 96,872

ENGINE SEIZED AT JUST OVER 117,000 MILES. REPLACED THE ENGINE WITH A NEW USED ONE AND IT SEIZED AGAIN NOT EVEN 4 MONTHS AFTER THE NEW USED ENGINE WAS REPLACED.

Mileage: 117,000

THE TIMING CHAIN JUMPED THE SAFETY AND DESTROYED THE ENGINE AND STEERING. THE WIRING UNDER THE FRONT SEATS IS CORRODED. THE VEHICLE WAS STATIONARY.

Mileage: 110,000

THE VEHICLE HAS HEAVY HESITATTION ON THE HIGHWAY AND WITHIN CITY LIMITS. IT IS AS IFF THE CAR WILL STOP. I TOOK THE CAR TO THE CERTIFIED VW DEALERSHIP DUE TO THE ENGINE LIGHT BEING ON. IT WAS FOUND THAT THERE ARE METAL PIECES FROM THE ENGINE OR SPARK PLUG IN THE OIL AND HAS MESSED THE ENGINE UP. WITH REGULAR OIL CHANGES, HOW WOULD THESE PIECES OF METAL BE IN THE ENGINE. I PERFORMED SOME RESEARCH AND SAW THAT A LOT OF OTHERS HAVE HAD THE SAME ISSUES. THIS SHOULD BE SOMETHING THAT SHOULD BE REVIEWED AND LOOKED INTO FURTHER BY THE NHTSA.

Mileage: 75,000

I STARTED HAVING ISSUES WITH THE EPC LIGHT COMING ON IN MY CAR BACK IN 2017. I WAS TOLD THAT I NEEDED "CARBON CLEANING" WHICH I HAD DONE IN JULY 2017 TO THE TUNE OF $950+. AFTER THE REPAIRS WERE DONE, MY CAR SEEMED FINE UNTIL I WAS OUT DRIVING UP A LONG HILL NEAR HOME AND MY CAR COULD NOT PICK UP SPEED. THE EPC WARNING LIGHT CAME BACK ON. I PULLED OVER AND THE LIGHT WENT OFF AND I WAS ABLE TO DRIVE AGAIN. WEIRD, BUT NO PROBLEMS UNTIL NOVEMBER 2018 AND THE SAME THING STARTED TO HAPPEN. FOR PERSONAL REASONS, I COULD GET TO MY GARAGE, BUT JUST BEFORE I WAS ABLE TO TAKE IT IN TO HAVE THE PROBLEM CHECKED OUT AND FOR ROUTINE MAINTENANCE, I'D COME OUT OF THE GROCERY STORE FRIDAY, MARCH 9, AND MY CAR WOULD NOT WORK. HAD IT TOWED TO THE GARAGE I FREQUENT AND WAS TOLD THAT MY TIMING CHAIN TENSION HAD FAILED AND I WOULD BE LOOKING AT A BILL OF $3,100. PLEASE KEEP IN MIND THAT THIS IS THE SECOND ENGINE ON THIS CAR. I REPLACED THE ORIGINAL ENGINE AFTER IT DIED IN 2012. I PAID $7,000 FOR A NEW ENGINE ONLY TO END UP BACK IN THE SPOT WHERE I'M HAVING TO PAY LOADS OF MONEY TO HAVE THIS "NEW" ENGINE REPAIRED. THE FIRST TIME MY ENGINE DIED IN 2012, I BEGGED AND PLEADED WITH VW TO OWN UP TO THIS AND TO PAY FOR THE REPAIR. THEY ONLY OFFERED ME 10% OFF OF A NEW CAR.

Mileage: 203,766

VEHICLES TIMING CHAIN TENSIONER FAILED CAUSING THE ENGINE TO STOP RUNNING. TIMING GAIN TENSIONER FAILED CAUSING SEVERE ENGINE DAMAGE. WHILE MERGING ONTO FREEWAY ENGINE LOST ALL PROPULSION CAUSING VEHICLE TO LOSE ACCELERATION DUE TO ISSUE. ALMOST CAUSED AN ACCIDENT WITH A SEMI TRUCK AS VEHICLE WAS ONLY MOVING AT 20 MPH ONTO A FREEWAY WHERE SPEED LIMIT IS SEVENTY. WAS ABLE TO MOVE VEHICLE TO THE SHOULDER BUT WOULD NOT RESTART DUE TO ENGINE DAMAGE. VOLKSWAGEN HAS ACKNOWLEDGED THE ISSUE BUT HAS OFFERED ZERO ASSISTANCE

Mileage: 86,231

AT 90K MILES THE REAR MAIN SEAL HAS FAILED. THIS COMES JUST 4K MILES AFTER HAVING THE ENGINE CYLINDER HEAD REPAIRED AND ALL TIMING COMPONENTS REPLACED FROM THE TIMING TENSIONER FAILURE.

Mileage: 90,100

THE REAR MAIN SEAL ON MY 09 TIGUAN 2.0 TSI BLEW AT 709K MILES FROM PCV VALVE DEFECT. I HAVE HEARD OF SEVERAL CASES OF THE PCV CLOGGING ON THE TSI ENGINE CARS SENDING BOOST PRESSURE INTO CRANKCASE AND BLOWING THE SEAL.

Mileage: 70,000

CAR WAS DRIVEN TO FROM FRIENDS HOUSE TO GRANDMOTHERS HOUSE AND SHUT CAR OFF AND WAS VISITING FAMILY FOR 1 HOUR TO 1 1/2 HOURS. THEN GOT IN CAR AND TRIED TO START VEHICLE AND THE TIMING JUMPED AND MADE A LOAD GRINDING NOISE AND WOULDN'T START. IT BENT THE VALVES IN THE ENGINE RAN INTO THE PISTONS. AN RUINED THE MOTOR. (111778 MILES) HAD TO HAVE A NEW MOTOR PUT IN COST $7801.54.

Mileage: 111,778

TIMING CHAIN TENSIONER BROKE AND CAUSED CATASTROPHIC ENGINE DAMAGE. VW QUOTED ME MORE THAN $8,000 TO FIX AND VW AMERICA ACCEPTS NO RESPONSIBILITY. THIS CAR WAS IMPECCABLY MAINTAINED AND REPLACING/SERVICING THE TIMING CHAIN IS NOT ON THEIR MAINTENANCE SCHEDULE. THE CHECK ENGINE LIGHT WENT ON WHILE DRIVING HOME FROM WORK AT 121,000 MILES AND WAS DRIVEN TO THE MECHANIC, AS WE ALREADY HAD AN OIL CHANGED SCHEDULED. WHEN THE MECHANIC WENT TO START THE CAR TO REPLACE THE CAM SENSOR (WHAT THE COMPUTER/ENGINE INDICATED WAS THE PROBLEM), THE CAR WOULDN'T START. I THEN HAD TO HAVE THE CAR TOWED TO LOCAL VW DEALER, WHERE THEY TRIED TO GET ME TO BUY A NEW CAR. WHEN I CALLED VW AMERICA, THEY REFUSE TO ACKNOWLEDGE THE FACT THAT THE TENSIONER HAS A FAULTY DESIGN AND ONLY SAY THAT THEY CANNOT HELP WITH THE COST OF THE REPAIR SINCE THE CAR IS OUTSIDE ITS WARRANTY.

Mileage: 121,731

TIMING BELT TENSIONER FAILURE, CAUSING CATASTROPHIC ENGINE FAILURE AT JUST OVER 93,000 MILES. THIS SEEMS TO BE AN ALL TOO COMMON PROBLEM WITH THIS VEHICLE. A NEWER MODEL OF TIMING BELT TENSIONER HAS BEEN USED SINCE DECEMBER 2011. MINE HAS THE OLD STYLE. VEHICLE WAS IN MOTION WHEN ENGINE LIGHT POPPED ON, INDICATING THE ISSUE.

Mileage: 93,500

THE TIMING CHAIN TENSIONER IN THIS VEHICLE IS KNOWN TO FAIL AND DESTROY ENGINES. THEY HAVE ISSUED TECHNICAL SERVICE BULLETINS ON THE ISSUE, BUT HAVE DONE NOTHING TO RESOLVE THE ISSUE FOR OWNERS. MY WIFE AND CHILD WERE IN THE CAR AND THE TENSIONER FAILED AND THE ENGINE STOPPED IN THE MIDDLE OF A BUSY FREEWAY CAUSING THEM TO ALMOST GET REAR ENDED BY A SEMI TRUCK. YOU CAN FIND THE TECHNICAL SERVICE BULLETINS HERE: HTTP://WWW.CARCOMPLAINTS.COM/VOLKSWAGEN/TIGUAN/2009/TSBS/. I HAD TO REPLACE THE ENGINE DUE TO A KNOWN ISSUE. A RECALL IS TRULY NEEDED ON THIS ISSUE. MANY OTHERS HAVE HAD THE SAME ISSUE HAPPEN TO THEM. ALSO MY DRIVER'S SIDE AIRBAG FAILED AND VW REFUSES TO ADDRESS THIS SAFETY ISSUE.

Mileage: 90,000

2009 TIGUAN 2.0 TSI ALL WHEEL DRIVE IN 2012 I DISCOVERED SOME WETNESS IN THE TIGUAN FLOOR MAT. (LESS THEN 3 YEARS OLD CAR) I TOOK IT TO VW DEALERSHIP, THEY FOUND A MALFUNCTION OF THE ROOF DRAIN HOSE. THE ESTIMATE WAS SO HIGH $700 THAT I FIGURE WELL, I CAN LIVE WITH A LITTLE WETNESS WHEN IT RAINS HARD. 2012 TO 2015 THE CAR WAS AT PIZZA ARDMORE VW SEVERAL TIMES (THE SAME DEALERSHIP) DUE TO AN ONGOING RED AND ORANGE WARNING LIGHTS ON THE DASHBOARD. "CHECK ENGINE"INCLUDING MALFUNCTION OF THE AIRBAG. IN MAY 2015 THE ENGINE COMPLETELY STOPPED RUNNING. "YOU NEED A NEW ENGINE" I WAS TOLD, WITHOUT PROVIDING ME WITH ANY EXPLANATION IN SPITE OF MY REQUEST. HOW COME 25,000 MILE ENGINE BRAKES? NEARLY $8,000 FOR A NEW ENGINE ON A SIX YEAR OLD TIGUAN. TWO YEAR LATER, THE CAR STOPPED RUNNING AGAIN, THE ENGINE WILL NOT START, ALL ELECTRIC ARE SHOT, NO RADIO, NO LIGHT, NO AIRBAGS, NO POWER, ALL GONE. BACK TO PIAZZA ARDMORE VW, THE CAR WAS THEN DECLARED TOTAL LOSS, IT WAS TOO EXPENSIVE TO FIX. IT ALL HAPPENED FOR TWO REASONS. THE VW MANUFACTURER PRODUCTION DEFECT OF THE DRAIN HOSE. AND LOUSY PIAZZA VW DEALERSHIP NEGLECTED TO DETECT AND FIX THE PROBLEM TWICE BEFORE IT WAS DECLARED A TOTAL LOSS.

Mileage: 28,000

WHEN DRIVING VEHICLE STOPPED RUNNING WHILE ON THE HIGHWAY. WOULD NOT START. TOWED TO DEALER AND TOLD THE ENGINE WAS NO GOOD AND NEEDS TO BE REPLACED. TIMING CHAIN FAILURE IS THE REASON. UNABLE TO FIX AS COST TO REPAIR IS $7000.

Mileage: 95,400

THE TIMING CHAIN TENSIONER FAILED CAUSING CATASTROPHIC DAMAGE TO THE ENGINE. THE COST TO REPAIR MY ENGINE IS $8,000. I WAS LUCKY THAT I WAS PARKED, IT HAPPENED WHEN I STARTED THE CAR. OTHERS HAVE FAILED WHILE DRIVING CAUSING LOSS OF CONTROL OF THE VEHICLE. THE VEHICLE CANNOT BE DRIVEN AFTER THE FAILURE. VOLKWAGEN IS AWARE OF THE ISSUE. THEY CURRENTLY ARE PRODUCING THE 4TH VERSION OF THE PART. THE CURRENT PART NUMBER IS 06K-109-467-K.

Mileage: 127,000

ON MONDAY EVENING 02/13/2017 IN DOWNTOWN DENVER, CO, I STARTED MY CAR AND PULLED INTO TRAFFIC WHEN THE CAR BEGAN TO JUMP VIOLENTLY AND ALL WARNING LIGHTS WENT ON. I SHUT THE ENGINE OFF AND IT WOULDN'T START AGAIN. I HAD IT TOWED TO THE GARAGE WHERE IT HAD BEEN SERVICED THE PRECEDING WEEK.THE MECHANIC CALLED LATER TO SAY THAT THE ENGINE WAS DAMAGED BECAUSE THE TIMING MECHANISM HAD SLIPPED BUT THAT HE WOULD HAVE TO PULL THE ENGINE TO EVALUATE THE EXTENT OF THE DAMAGE. LATER ON THE NEXT WEEK, HE REPORTED THAT THE ENGINE WAS DAMAGED BEYOND REPAIR AND THAT I WOULD NEED A REPLACEMENT ENGINE. THERE WAS A WAIT OF SEVERAL DAYS AND TIME TO DO THE WORK. I GOT MY CAR BACK IN RUNNING CONDITION ON 2/24/2017 AFTER PAYING $6776.94 FOR THE REPAIRS.

Mileage: 80,600

I WAS IN DOWNTOWN DENVER, COLORADO ON 2/14/2017. I STARTED THE CAR, PULLED INTO TRAFFIC AND THE CAR STARTED JUMPING, ALL WARNING LIGHTS WENT ON AND I TURNED OFF THE ENGINE. IT WOULDN'T START, WAS TOWED TO A GARAGE WHERE THE MECHANIC REPORTED THAT THE TIMING MECHANISM HAD SLIPPED AND DAMAGED THE ENGINE. WHEN HE EXAMINED IT FURTHER HE REALIZED IT WAS BEYOND REPAIR AND THAT I NEEDED A NEW ENGINE.

Mileage: 80,600

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TIGUAN. WHILE AT A TRAFFIC LIGHT, THE CONTACT NOTICED THAT THE VEHICLE WOULD NOT IDLE. WHEN THE FAILURE OCCURRED, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN FAILED AND THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 170410920. THE CONTACT WAS INFORMED THAT THE VEHICLE HAD NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 93,000.

Mileage: 93,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TIGUAN. WHILE DRIVING 40 MPH, THE VEHICLE STALLED AND ALL THE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED A LOUD NOISE, NO COMPRESSION, AND A METALLIC METAL TO METAL NOISE COMING FROM THE ENGINE. THE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBERS: 14V441000 (FUEL SYSTEM, GASOLINE) AND 13V569000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING). THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V235000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS 125,310.

Mileage: 125,310

67,000 MILES ON AN 8 YEAR OLD TIGUAN MAJOR FAILURE OF THE REAR MAIN OIL SEAL, FOLLOWED 3 DAYS LATER BY THE FAILURE OF THE TIMING CHAIN AND TENSIONER. BOTH THE SEAL AND THE TENSIONER ARE NOTED POINTS OF FAILURE AND VWOA IS NOT STANDING BEHIND THE KNOWN ISSUE AND OR QUALITY ISSUES REGARDING THESE PARTS. REAR MAIN SEAL BROKE DURING A HIGHWAY DRIVE, NO CHECK ENGINEER LIGHT APPEARED, OIL WAS ALMOST COMPLETELY DRAINED FROM THE CAR AND NO LOW OIL PRESSURE LIGHT CAME ON. THE ONLY INDICATION OF THE FAILURE WAS THE POOL OF OIL UNDER THE CAR WHEN THE CAR WAS PARKED. AFTER REPAIR OF THE REAR MAIN SEAL, CAR RAN FINE FOR 3 DAY AND THEN THE TIMING CHAIN SLIPPED CAUSING SEVER ENGINE SHAKE. CAR WAS STATION ARE WHEN THIS OCCURRED AND CAR WAS IMMEDIATELY TOWED TO THE DEAL FOR DIAGNOSTIC. FAILURE OF THE TENSIONER ON THE TIMING CHAIN WAS THE CONTRIBUTING FACTOR AND LOW OIL PRESSURE CAN CAUSE THE FAILURE ACCORDING TO RESEARCH OF THIS PARTICULAR ISSUE. THE FAILURE OF THE REAR MAIN SEAL COULD HAVE CAUSED ENGINE FAILURE AT A HIGH RATE OF SPEED AND WITH NO WARING LIGHTS OR CHECK ENGINE LIGHTS THE DRIVE IS UNAWARE OF THE CONDITION. IN DISCUSSION WITH VWOA THEY ARE NOT INTERESTED IN STANDING BEHIND THE QUALITY OF THE ENGINE AND OFFER NOT ASSISTANCE TO HELP COVER THE COST OF THE DEFECTIVE, INTERNAL PARTS, THAT A CONSUMER WOULD HAVE NO UNDERSTANDING OF HOW TO CHECK OR CONFIRM CONDITION WITHOUT EITHER THE MANUFACTURER OR THE DEALER MAKING A POINT TO CHECK DURING NORMAL SERVICE INTERVALS. THE TENSIONER HAS AN EXISTING TSB NOTING THE PROPENSITY OF THE TIMING CHAIN TO SLIP AND THE TENSIONER TO FAIL.

Mileage: 67,000

THE TIMING TENSIONER WENT BAD AND CAUSE DAMAGE TO THE ENGINE WHICH NOW NEEDS REPLACED AT AROUND $7K-$8K. THIS WAS A KNOWN ISSUE BY VW AND THERE ARE CLASS ACTION LAWSUITS OUT THERE. I CALLED VW OF AMERICA AND THEY REFUSED TO EVEN HELP WITH THIS ISSUE DUE TO THE FACT THE WARRANTY WAS EXPIRED AND THERE ARE NO RECALLS ON THE VEHICLE. HOW COULD THERE BE NO RECALLS ON A CAR THAT THEY KNOWINGLY HAD ISSUES WITH THE TIMING TENSIONER? I CANNOT FIND ANYTHING ON THE NHTSA SITE THOUGH ON SOME FORUMS OTHERS HAVE STATED A FILE NUMBER FOR THE SAME ISSUE. I JUST THINK VW SHOULD STAND UP AND TAKE CARE OF A PROBLEM THEY KNEW ABOUT A LONG TIME AGO.

Mileage: 77,000

TIMING CHAIN TENSIONER IS DEFECTED. THE TIMING CHAIN LOST TENSION WHILE VEHICLE WAS ON ALLOWING THE CHAIN TO JUMP ONE TOOTH CAUSING DETRIMENTAL EFFECTS TO THE ENGINE.

WHIEL DRIVING ON A BUSY STATE ROAD, THE CHECK ENGINE LIGHT CAME ON AROUND 70,900 MILES. I HEARD RATTLING SOUND FROM ENGINE, FRONT END SHAKE. I PULLED OVER NEAR MY HOUSE AND SHUT THE CAR OFF. I THEN HAD TROUBLE STARTING THE VEHICLE. I WAS ABLE TO DRIVE THE CAR TO A VOLKSWAGEN DEALERSHIP WHERE THEY INFORMED ME OF THE FOLLOWING, "TECH FOUND THAT TIMING CHAIN ADJUSTER HAS REACHED ITS LIMITS. FOUND COOLANT FANS HAVE INTERNAL SHORT CIRCUIT. TECH RECOMMENDS TO REPLACE ALL TIMING CHAIN COMPONENTS AND TO REPLACE BOTH COOLNG FANS. TIMING CHAINS AND ALL COMPONENTS $2887.68 COOLING FANS $1252.16" THE TECH THEN TOLD ME HE WOULD NOT RECOMMEND ME DRIVING THE VEHICLE ANYMORE. I'M NOT SURE WHEN THE TIMING ADJUSTOR FAILED, BUT IF I WERE TO KEEP DRIVING THE TIGUAN, IT COULD HAVE CAUSED MY ENGINE TO SEIZE AT ANY TIME. I LATER BECAME AWARE FROM INTERNET RESEARCH THAT THE TIMING CHAIN TENSIONER PROBLEM WAS COMMON AMONG VOLKSWAGEN AND AUDIS WITH THE 2.0T ENGINE SOLD FROM 2008 - 2011 AND IN NOV. 2011 VOLKSWAGEN ISSUED A TECHNICAL SERVICE BULLETIN (TSB) MAKING THEIR DEALERS AWARE OF THE DEFECT. HOWEVER, THE COMPANY NEVER INFORMED CUSTOMERS. THIS PROBLEM IS CURRENTLY THE SUBJECT OF AN ONGOING CLASS ACTION LAWSUIT. VOLKSWAGEN HAS SO FAR REFUSED TO HELP ME IN ANY WAY, INSTEAD MAINTAINING THAT BECAUSE MY CAR IS OUT OF WARRANTY (6 YEARS OR 60,000 MILES) THEY ARE UNABLE TO HELP IN ANY WAY AND THAT I WOULD BE FULLY RESPONSIBLE FOR THE REPAIRS. THE TIGUAN MANUAL SAYS NO MAINTENANCE SHOULD BE NEEDED ON THE TIMING CHAIN UNTIL 130,000 MILES.

Mileage: 70,900

AFTER NOTICING EXCESS OIL LEAKAGE WE TOOK OUR "09 TIGUAN TO OUR ASE CERTIFIED LOCAL INDEPENDENT MECHANIC WHO SPECIALIZES IN EUROPEAN CARS. HE FOUND A REAR MAIN SEAL FAILURE. VW PASADENA FOUND THE FOLLOWING: TIMING CHAIN FAILURE, CRANK CASE BREATHER FAILURE, CARBON BUILD UP ON VALVES, REAR MAIN SEAL FAILURE, PRESSURE CIRCULATION VALVE (PCV) FAILURE. VEHICLE IS WITHIN POWERTRAIN WARRANTY AND VW REALDRIVER MECHANICAL FAILURE SERVICE CONTRACT WARRANTY BY MILES, BUT NOT BY TERMS (5 YR AND 3YR RESPECTIVELY). WENT TO LOCAL DEALER, ESCALATED TO VW AMERICA, AND DENIED CLAIM 1/26/17. AFTER OWNING 10+ VW'S IN THE FAMILY THIS IS IT. ESCALATING PAST CLAIMS MGR TOMORROW AND SEEKING A RESOLUTION.

Mileage: 54,800

THE ENGINE FOR MY PARTICULAR CAR IS VERY POORLY DESIGNED CAUSING IT TO HAVE SO MANY ISSUES ONE AFTER THE OTHER. AT ON 72K MILES I HAVE ALREADY HAD THE FOLLOWING JOBS DONE TO MY CAR: REPLACE PCV VALVE, DECARBONIZATION OF THE CAR, REAR MAIN SEAL LEAK REPLACEMENT.

TIGUAN. PURCHASED THE CAR IN DECEMBER 2015 REPLACED THE WATER PUMP IN FEBRUARY 2016 AND AGAIN IN JANUARY 2017. THE WATER PUMP ON THIS CAR HAS BEEN REPLACED 4 TIMES IN ITS LIFETIME. VW SHOULD ISSUE A RECALL AND OFFER EXTENDED WARRANTIES TO ALL OWNERS OF ITS CARS.

Mileage: 100,000

LARGE POOL OF MOTOR OIL UNDER THE LEFT SIDE OF THE ENGINE. DEALER INSPECTED AND INFORMED ME OF A FAILED REAR MAIN SEAL CAUSED HIGH CRANKCASE PRESSURE BUILDUP DUE TO A STUCK (CLOSED) PVC VALVE.

Mileage: 80,016

CAR WOULD NOT START OR EVEN TURN OVER. BATTERY WAS FINE AND FIRMLY CONNECTED. LIGHTS ALL CAME ON. NO ERROR MESSAGES. ON THIRD OR FOURTH TRY, IT STARTED RIGHT UP. I BACKED THE CAR OUT OF DRIVEWAY ONTO MY STREET WITH DISTANT APPROACHING TRAFFIC. I SHIFTED FROM REVERSE TO DRIVE AND THE CAR BEGAN TO MOVE FORWARD AND LEFT, THEN WITH A LOUD CLUNK IT DIED COMPLETELY, ENGINE OFF, ALL LIGHTS DARK. NOW IN DANGER FROM THE NOT-SO-DISTANT ONCOMING TRAFFIC, I TRIED TO RESTART. SAME TROUBLE AS BEFORE---NO REPONSE BUT THE ALL LIGHTS CAME ON. TWO OR THREE TRIES AND THEN IT STARTED. THE SAME THING OCCURRED THE FOLLOWING MORNING. NO OIL DUMP OR ANY OTHER FLUID. UNKNOWN CAUSE. VW DEALERSHSIP UNABLE TO RECREATE THE PROBLEM AND THUS UNABLE TO DIAGNOSE. THE DYING WHILE IN MOTION PROBLEM IS A POTENTIALLY INJURY-CAUSING OR EVEN FATAL HAZARD.

Mileage: 88,000

WHILE DRIVING THE REAR OIL SEAL FAILED CAUSING SUDDEN LOSS OF OIL PRESSURE THAT REQUIRED AN IMMEDIATE TRIP TO THE MECHANIC. NO WARNING LIGHTS EVER CAME ON TO INDICATE A PROBLEM. HAD OUR VEHICLE STALLED OR ENGINE FAILED DUE TO LOSS OF OIL WHILE WE WERE DRIVING AT HIGH SPEED WE COULD HAVE CAUSED AN ACCIDENT. ALMOST A YEAR LATER WHILE PARKED THE ENGINE FAILED TO TURN OVER AND HAD TO BE TOWED TO MECHANIC. TIMING TENSIONER HAD FAILED CAUSING DAMAGE TO ENGINE REQUIRING REPLACEMENT. THERE WAS NO INDICATION THAT THERE WAS A PROBLEM LEADING UP TO THIS INCIDENT. HAD WE BEEN DRIVING AND THE TIMING CHAIN FAILED WE COULD HAVE CAUSED AN ACCIDENT. THESE ARE BOTH KNOWN PROBLEMS BY VW YET THEY HAVE DONE NOTHING TO REPAIR OR MAKE THEIR CUSTOMERS WHOLE DUE TO THESE DEFECTS. NOW I HAVE AN $7,000 PAPER WEIGHT BECAUSE I HAVE TO REPLACE A BLOWN ENGINE IN A CAR THAT HAS 90,000 MILES AND IS 7 YEARS OLD.

Mileage: 90,000

WHILE DRIVING MY CAR FROM WV TO NY, I BROKE DOWN IN PA. MY CAR WAS MAKING AN ODD NOISE AND RUMBLING FEELING WHILE I WAS DRIVING ON THE FREEWAY AT 70 MPH AND WOULD WORSEN DURING ACCELERATION. I WAS VERY CONCERNED, SO I PULLED OFF TO A GAS STATION. AT THIS POINT NO CHECK ENGINE LIGHTS WERE ON. AFTER I FILLED UP ON GAS, THE CAR WOULD NOT START. IT WAS TOWED TO VW DEALERSHIP IN NORTHERN PA, WHERE I WAS TOLD AN AIR HOSE WAS BROKEN. 10 DAYS LATER, MY CAR BEGAN MAKING THE SAME NOISE AND DRIVING POORLY AGAIN WHILE I WAS DRIVING ON THE EXPRESS IN LONG ISLAND, AND WAS EXACERBATED BY ACCELERATING. MY CAR COULD NOT ACCELERATE ABOVE 30 MPH, SO I PROMPTLY TOOK MY CAR TO THE MECHANICS, WHERE I WAS TOLD THE TIMING CHAIN TENSIONER AND GUIDE, EXHAUST VALVES, GASKET HEADS AND SPARK PLUGS NEEDED TO BE REPLACED. ADDITIONALLY IN 1400 MILES, MY CAR HAD CONSUMED ALL OF THE ITS OIL AND WAS ON RUNNING ON FUMES. APPARENTLY MY CAR CONSUMES OIL AT AN ABSURD AND UNACCEPTABLE RATE. THE TIMING CHAIN TENSIONER FAILING HAS BEEN A COMMON PROBLEM AMONGST VW 2.0TSI ENGINES AND CURRENTLY THERE ARE MULTIPLE LAWSUITS FILED AGAINST THIS TYPE OF ENGINE, AS IS THE CONSUMPTION OF OIL. MY CAR WAS NOT INVOLVED IN AN ACCIDENT DUE TO THESE FAILURES, BUT THAT IS ONLY BECAUSE I PULLED OVER TO A SAFE LOCATION AS SOON AS I FELT SOMETHING WAS WRONG. AGAIN A CHECK ENGINE LIGHT NEVER CAME PRIOR TO BOTH MECHANIC VISITS. HOWEVER THIS COULD HAVE CAUSED AN ACCIDENT AND MAY CONTINUE TO CAUSE ONE IN OTHER VEHICLES. *TR

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TIGUAN. WHILE DRIVING 75 MPH, THE VEHICLE STALLED AND THE OIL PRESSURE INDICATOR ILLUMINATED APPROXIMATELY 30 SECONDS BEFORE THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIMING CHAIN TENSIONER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

Mileage: 64,000

TURNED CAR ON AND STARTED TO SHAKE AND IDLE WILDLY, ENGINE LIGHT CAME ON. TIMING CHAIN JUMPED WAS THE DIAGNOSIS, WENT TO GET 2ND OPINION SAME RESULT. MECHANIC WORKING ON VEHICLE, DONT HAVE EXACT EXTENT OF DAMAGE BUT HAVE AN ESTIMATE OF COST.

Mileage: 95,000

CAR AT 55,000 MILES HAD COIL FAILURE. CAUSED ENGINE TO RACE AND STALL ALMOST CAUSING AN ACCIDENT. LUCKILY, IT WAS ONLY AT 25 MILES PER HOUR IN MY DEVELOPMENT.

Mileage: 55,300

I BOUGHT MY CAR JULY 6 2015 THE FIRST WEEK THE CHECK ENGINE LIGHT CAME ON. SO THEN 2 WEEKS LATER CHECK ENGINE LIGHT COMES ON AGAIN THIS TIME CADILLAC CONVERTER WENT OUT THE THE HEAD LIGHT KEEPS GOING OUT. NO ITS IN THE SHOP FOR THE TIMING THIS CAR HAS BEEN A NIGHT MARE SINCE I GOT IT.

MY CAR WAS PARKED IN A LOT AND WOULDN'T START. I HAD IT TOWED TO THE DEALERSHIP. THEY SAID THE TIMING CHAIN HAD JUMPED AND DAMAGED THE ENGINE BEYOND REPAIR. THEY QUOTED MY $8K TO PURCHASE A NEW ENGINE.

Mileage: 127,000

TIMING CHAIN ISSUE: ON NOV 18 2015 MY WIFE WAS DRIVING FROM WORK WHEN SUDDENLY THE CAR SUDDENLY STALLED. CAR WAS TOWED TO VW DEALERSHIP IN IRVING TX,WHERE THEY DID DIAGNOSTICS AND CONCLUDED THAT THE TIMING CHAIN SLIPPED OUT AND BROKE THE CYLINDER HEAD. THE TOTAL COST WAS FIXING THAT WAS AROUND 5000$. THE DEALERSHIP TOLD ME THAT THEY WERE NO RECALL ON THE TIMING CHAIN ISSUE AND I SHOULD CALL VW OF AMERICA, WHICH I DID. I ASKED THEM WHY THE DEALERSHIP WHENEVER I TAKE THE CAR FOR SERVICE DIDNT NOT REQUEST I CHANGE THE TIMING CHAIN. ACCORDING TO THEM TIMING CHAIN IS NOT PART OF THE ROUTINE SERVICE BECAUSE ITS SUPPOSED TO LAST THE LIFE OF THE CAR. THE VW REPRESENTATIVE TOLD ME I SHOULD GO AHEAD AND FIX THE CAR AND WHENEVER THEY HAVE A RECALL ON THE ISSUE THEY WILL REFUND ME THE FIXING COST. NOW I AM STUCK WITH VEHICLE IN MY DRIVEWAY BECAUSE I CANNOT AFFORD TO FIX THE VEHICLE. AND VW WILL NOT COVER THE COSTS EVEN THOUGH THEY ARE SELLING A VEHICLE WHICH THEY STATE THE TIMING CHAIN DOESNT NEED TO BE CHANGED.

Mileage: 144,158

THE WATER PUMP FAILED AT 106,246 MILES, IT WAS REPLACED. THE PUMP FAILED AGAIN AT 109,802 MILES, IT WAS REPLACED. THE PUMP FAILED AGAIN AT 135,473 MILES. ON ALL THREE OCCASIONS, THE PUMP FAILED ON START UP, THE CAR WAS NOT IN MOTION.

Mileage: 135,470

TIMING CHAIN TENSIONER FAILURE: MY TIGUAN HAD BEEN RUNNING PERFECTLY AND WAS A GREAT CAR SINCE PURCHASING IT 7 MONTHS PRIOR TO THIS INCIDENT. I DROVE IT 250 MILES AND AT THE END OF THE TRIP AS I WAS PULLING INTO MY DESTINATION, I NOTICED BACK-AND-FORTH ROCKING AND THE ENGINE SOUNDING A BIT CLUNKY. I PLANNED TO TAKE IT BACK TO THE DEALER I PURCHASED IT FROM TO GET CHECKED OUT AND WASN'T GOING TO DRIVE IT IF I NOTICED THE BACK-AND-FORTH ROCKING AGAIN, BUT I DIDN'T. APPROXIMATELY 100 MILES BEFORE MAKING IT BACK HOME, I PULLED INTO A GAS STATION FOR A REST STOP. I CAME BACK OUT TO MY CAR TURNED THE KEY, AND NOTHING HAPPENED. THE BATTERY WAS AT FULL CHARGE, BUT THE ENGINE HAD THE STARTER WANTED TO FIRE UP THE ENGINE, BUT THERE WAS NOTHING. I HAD THE CAR TOWED TO MY LOCAL VW DEALER AND WAS EXTREMELY SURPRISED UPON RECEIVING NEWS THAT MY ENGINE AND TURBO WERE BLOWN AND BOTH NEEDED TO BE REPLACED. AFTER NOTIFYING THE USED CAR LOT I PURCHASED THE CAR FROM, I WAS MADE AWARE OF MY VEHICLE BEING ONE MONTH BEYOND THE 6-MONTH WARRANTY. I CALLED VW WHO SAID THEY COULDN'T DO ANYTHING TO HELP SINCE MY VEHICLE WAS WELL OVER THE WARRANTY MILEAGE. I HAVE SINCE PERSUADED THE DEALERSHIP I PURCHASED FROM TO COVER THE INSTALLATION OF A REPLACEMENT ENGINE, BUT PURCHASING THE NEW ENGINE AND TURBO(UPWARDS OF $9K FOR OEM) HAS FALLEN ON ME.

Mileage: 113,000

ON OCT. 24, 2015 WHEN I TRIED TO START MY CAR, IT SHOOK, IDLED ROUGHLY AND STALLED. I TRIED AGAIN AND IT WOULDN'T START. I HAD THE CAR TOWED TO MY VOLKSWAGEN DEALER. THEY CHECKED IT AND TOLD ME THE TIMING CHAIR HAD BROKEN CAUSING CATASTROPHIC DAMAGE TO THE ENGINE. THE ESTIMATE FOR REPAIRS WAS $4952.29. AND IF THE ENGINE HAD TO BE REPLACED, IT WOULD BE $6500. VOLKSWAGEN OF AMERICA GROUP WOULD PAY NOTHING TOWARD THE REPAIR CLAIMING IT WAS OUT OF WARRANTY. (THE POWER TRAIN WARRANTY WAS 5 YEARS/60,000 MILES.) THE CAR HAD 49,000 MILES, BUT WAS OVER THE 5 YEAR TIME PERIOD. BUT A TIMING CHAIN SHOULD BE GOOD FOR THE LIFE OF THE CAR; UNLESS THERE IS A DEFECTIVE PART. YOU HAVE A TSB (TB-15-12-01 -NHTSA ID NUMBER: 10045560) ON THE "TENSIONER" WHICH CAUSES THE CHAIN TO BECOME LOOSE, SKIP AND BREAK. MOREOVER, THERE ARE NUMEROUS COMPLAINTS ON YOUR SITE ABOUT THIS EXACT ISSUE. VOLKSWAGEN FAILED TO NOTIFY CUSTOMERS OF THIS DEFECT AND THERE WAS NO RECALL. THIS IS A TICKING TIME BOMB THAT CAN RESULT IN A SERIOUS ACCIDENT. THE DAY BEFORE THIS HAPPENED, I WAS TRAVELLING ON THE FLORIDA TURNPIKE FOR 8 HOURS AT THE POSTED SPEED OF 70 MPH. IF THE CHAIN HAD BROKEN DURING THAT TIME, IT COULD HAVE RESULTED IN A FATAL ACCIDENT INVOLVING ME AND/OR OTHERS. WHY HASN'T THERE BEEN A RECALL? WHY SHOULD VOLKSWAGEN BE ALLOWED TO PUT MY LIFE AND THE LIVES OF OTHERS AT RISK? WHY SHOULD I HAVE TO PAY FOR VOLKSWAGEN'S NEGLIGENCE WHEN THEY WERE AWARE OF THIS ISSUE FOR ALMOST 3 YEARS? THIS DEFECT HAS THE POTENTIAL TO KILL. DOES SOMEONE HAVE TO DIE BEFORE YOU WILL TAKE ACTION TO REQUIRE VOLKSWAGEN TO FIX THIS PROBLEM?

Mileage: 49,000

ON A CROSS COUNTRY ROAD TRIP, MY 2009 VW TIGUAN WAS RUNNING PERFECTLY. STOPPED AT A REST STOP, AND WHEN TRIED TO RESTART CAR, IT RATTLED SEVERELY AND THE ENGINE LIGHT WENT ON. VEHICLE WAS TOWED TO VW SERVICE, AND I WAS TOLD I NEEDED AN ENGINE REPLACEMENT, DUE TO A FAILED TIMING CHAIN TENSIONER. IT COST ME $5800, ALONG WITH 5 DAYS OF LODGING WHILE WAITING FOR REPAIR. THE VW DEALER SUPPORTED THE FACT THAT I SHOULD GET REIMBURSED BY VW. MY VEHICLE HAD A PERFECT MAINTENANCE RECORD. THERE IS NOTHING IN THE MANUAL PERTAINING TO MAINTENANCE REQUIREMENT FOR TIMING CHAIN/TENSIONER. ALL IT TAKES IS A QUICK SEARCH ON THE INTERNET TO SEE THE UNBELIEVABLE AMOUNT OF CASES AND COMPLAINTS, EVEN TO VEHICLES WITH AS LOW AS 10,000 MILES. THERE IS APPARENTLY A NEW TENSIONER SERVICE KIT AVAILABLE TO AVOID THE CATASTROPHIC DAMAGE, BUT VW HAS NOT NOTIFIED CUSTOMERS. THIS IS ABSOLUTELY A SAFETY ISSUE. MY WIFE OR I COULD HAVE BEEN TRAVELING IN A REMOTE AREA WITH NO CELL RECEPTION, WHICH IS OFTEN THE CASE. IT IS ALSO UNACCEPTABLE TO PUT THE FINANCIAL BURDEN ON CUSTOMERS WHEN IT COULD BE AVOIDED. THIS NEEDS TO BE A RECALL. THIS IS A CANADIAN VEHICLE, BUT THE BREAKDOWN OCCURRED IN NY STATE. THIS SHOULD BE A NORTH AMERICAN RECALL.

Mileage: 120,000

VEHICLE STARED TO RUN RUFF AND STALL CAUSING A DRIVING HAZARD. VW DEALER REPAIR FACILITATE CLAMMED THAT IT WAS FRONT CRANK SEAL P/N 06L-103-085-B COST OF PART $11.30. AFTER REPLACING THE SEAL THE DEALER THEN CLAIMED THAT THE PVC VALVE WAS BAD ALSO P/N 06H-103-495-AC $201.30. IT IS KNOWN THAT WHEN THIS PART FAILS THAT IT WILL CAUSE THE SEAL TO FAIL AS WELL. TOTAL COST OF REPAIR WAS $774.07. THIS VEHICLE HAD 66,973 MILES. THIS IS A MAJOR FAILURE OF THE VEHICLE AND CAUSE A DANGEROUS CONDITION. THE TYPE OF FAILURE SHOULD NOT OCCUR ON AN ENGINE WITH SUCH LOW MILEAGE.

Mileage: 66,973

WAS TRAVELING JUST OFF I270 OUTSIDE OF COLUMBUS OH ON FRIDAY 7/17/2015 WHEN THE REAL MAIN ENGINE SEAL FAILED CAUSING A DUMP OF THE ENGINE OIL AND A WARNING TO IMMEDIATELY STOP THE ENGINE DUE TO LACK OF OIL PRESSURE. THERE WAS NO PRIOR WARNING AT ALL. IF HAD BEEN ON THE INTERSTATE COULD HAVE PUT US AT RISK DUE TO THE ABRUPT FAILURE. HAVE BEEN RESEARCHING THIS PROBLEM AND HAVE FOUND MANY OTHER OWNERS OF THIS VEHICLE AND ENGINE (2.0 TSI 2009 ON) IN OTHER VW'S THAT THIS IS A COMMON PROBLEM IN THE RANGE OF 80 TO 100K MILES. FINALLY HAD TO HAVE THE CAR FLATBEDDED TO A LOCAL DEALER WHERE THE ENGINE WAS DECLARED UNREPAIRABLE AND HAD TO BE REPLACED OUT OF WARRANTY AT A COST OF OVER $7,000.

Mileage: 83,000

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN TIGUAN. UPON TURNING THE KEY IN THE IGNITION TO START THE VEHICLE, IT SHOOK VIOLENTLY. THE VEHICLE WAS TURNED OFF, BUT FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR FURTHER INSPECTION. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 08V235000 (ENGINE AND ENGINE COOLING) AND 14V441000 (FUEL SYSTEM, GASOLINE). THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

Mileage: 72,000

NOTICED OIL LEAK ON OTHERWISE SPOTLESS DRIVEWAY A FEW DAYS AFTER 100K SERVICE AT VW DEALERSHIP. RETURNED TO DEALER WHERE REAR MAIN SEAL WAS IDENTIFIED AS THE SOURCE. ESTIMATE WAS $1400 TOTAL COST TO REPAIR ALONG WITH OIL HOSES TO TURBO. DISCUSSED DETAILS AND FREQUENCY OF RMS REPAIR WITH TECH, SINCE TRANSMISSION HAS TO BE REMOVED. ALSO RESEARCHED VW FORUM THREADS ON RMS FAILURE TO FIND THAT 2008+ MODEL VWS ARE MOST AFFECTED, 2009 TIGUANS IN PARTICULAR. OF THE 13 COMPLAINTS ON THE NHTSA SITE REGARDING FAILED REAR MAIN SEALS ON VWS, MORE THAN HALF (7 OF 13 = 54%) ARE FROM OWNERS OF 2009 TIGUANS. (3 OF 13 COMPLAINTS WERE FOR 2009 PASSATS, WITH 1 EACH FOR A 2009 CC, A 2011 TIGUAN, AND A 2012 JETTA.). EVEN WITH THIS SMALL SAMPLING, HAVING 54% OF THE RMS FAILURES AFFECTING THE SAME MODEL (TIGUAN) OF THE SAME MODEL YEAR (2009) IS MORE THAN A COINCIDENCE. IT SHOWS A TREND. VOLKSWAGEN OF AMERICA ACKNOWLEDGES NO SUCH TREND, AND VW CUSTOMER CARE REFUSES ANY RESPONSIBILITY BEYOND WARRANTY. *TR

Mileage: 100,000

THE MAIN REAR SEAL OF THE ENGINE FAILED. ENGINE GUSHING OIL AND LOSS OF ENGINE POWER. THE ENGINE SEAL SHOULD LAST THE LIFE OF THE VEHICLE. *TR

Mileage: 89,500

I HAVE HAD OVER THE COURSE OF 3 YEARS ONE OF THE 4 ENGINE COILS GO OUT ON MY CAR RIGHT AFTER THE VEHICLE STARTED. MY CAR HAD 41K MILES WHEN THE FIRST WENT OUT AND NOW THE THIRD IS AT 53K. THE MECHANICS AT VW KNOW IT IS A PROBLEM AND THEY EXPECT IT. THERE IS EVEN A NEW PART WITH A NEW PART NUMBER WHICH INDICATED VW KNOWS OF THE ISSUE AND THEY REDESIGNED THE PART. ITS INSANE TO ME THERE IS NOT A RECALL ON THIS PART. *TR

Mileage: 41,000

TL*THE CONTACT OWNS A 2009 VOLKSWAGEN TIGUAN. THE CONTACT STATED THE VEHICLE FAILED TO START AFTER REPEATED ATTEMPTS. THE VEHICLE WAS TOWED TO THE DEALER, WHO STATED THE ENGINE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

COOLANT PUMP WENT OUT JAN 25 2015. I HAD PURCHASED CAR USED FROM A NON VW DEALER BUT TOOK TO IT TO A VW DEALER TO REPAIR. THEY REPLACED FOR $750.00. I RESEARCHED FURTHER ON CARFAX AND FOUND THE PUMP HAD BEEN REPLACED ALREADY BY ANOTHER VW DEALERSHIP WITHIN THE PREVIOUS 12 MONTHS. I CONTACTED VW AND HAD TO FIGHT WITH THEM TO COVER MY REPAIR WHEN IT SHOULD HAVE BEEN PART OF THE WARRANTY WITH PREVIOUS REPAIR. THEY DID REFUND MY MONEY. IT IS NOW 2 MONTHS LATER, 3/25/2015 AND I AM AGAIN EXPERIENCING A COOLANT LEAK. *TR

Mileage: 46,000

THE COIL, THE FUEL PUMP AND THE REAR SEAL ARE DEFECTIVE. THEY ARE COVERED FOR REPAIR UNDER AN EXTENDED WARRANTY. THE ISSUE IS THAT THIS IS THE 3RD ENGINE FAILURE THIS YEAR, ANOTHER IN THE PAST. IF YOU GOOGLE 2009 TIGUAN REAR SEAL, YOU WILL FIND MANY MANY VW OWNERS EXPERIENCING THIS SAME ISSUE AT THIS EARLY AND EARLY MILEAGE ON THIS VEHICLE. THERE IS AN APPARENT MANUFACTURERS DEFECT THAT IS BEING OVERLOOKED. *TR

Mileage: 97,100

I BROUGHT MY TIGUAN IN DUE TO AN ENGINE LEAK AND TO HAVE AN ENGINE DIAGNOSTIC. THEY INDICATED THE MAIN REAR MAIN SEAL WAS LEAKING. 700 PLUS DOLLARS. REPAIRED THE SEAL THE LEAK STOPPED BUT THE LOW ENGINE PRESSURE LIGHT WOULD NOT GO OFF. THE THEN INDICATED THAT THE TENSIONER ARM WAS BAD AND THAT NEEDED TO BE REPLACED. I RECEIVED A CALL THE NEXT DAY THAT THE TENSIONER WAS BAD BUT THE TENSIONER CHAIN HAD WALKED OFF THE ROCKER ARM AND THAT THE ENGINE NEEDS TO BE REPLACED. I CALLED MULTIPLE TIMES TO VOLKSWAGEN CUSTOMER CARE MULTIPLE TIMES AND THEY RESPONDED THAT THEY CANT HELP WITH ANYTHING. I HAVE RESEARCHED THE TENSIONER ARM THROUGH GOOGLE AND FOUND PAGES AND PAGES OF BLOGS WITH PEOPLE THAT HAVE EXPERIENCED THE SAME ISSUE WITH THE TENSIONER ARM FAILING RESULTING IN ENGINE FAILURE. *TR

Mileage: 100,400

AT SLOWER SPEEDS, IDLE, COMING TO A STOP AND ACCELERATING THE ENGINE SPUTTERS CAUSING A HAZARDOUS SITUATION. THIS IS A RESULT OF THE FAILURE OF THE TIMING CHAIN TENSIONER. VW HAS CREATED IMPROVED REPLACEMENT PARTS BUT HAS NOT INFORMED ANY CUSTOMERS. ALSO THE VW TIGUAN OWNERS MANUAL CLAIMS THAT THE TENSIONER IS LIFETIME AND NEED NO MAINTENANCE. EVENTUALLY THE SPROCKET WHEELS BECOME SO WORN THAT THE CHAIN JUMPS AND DESTROYS THE PISTONS/HEADER/ENGINE. FAILURE USUALLY HAPPENS ABOVE THE 60,000 MILE POWERTRAIN LIMITED WARRANTY. VW AMERICA IS AWARE OF THE ISSUE BUT CLAIMS "LIKE ANY COMPONENT ON ANY VEHICLE, IT'S STILL POSSIBLE FOR IT TO FAIL". THEY KNOW THIS IS A SERIOUS HAZARD, THEY HAVE A FIX AND THEY DO NOT INFORM CUSTOMERS. *TR

Mileage: 80,000

THE EPC LIGHT CAME ON MANY TIMES BETWEEN 2011 AND 2014 AND THE ELECTRONIC THROTTLE KICKED OUT OF CRUISE CONTROL. MILLER VW CHECKED THE CAR JULY 2011, DID NOT HAVE A SOLUTION AND CLEARED THE CODES. I ASKED OUR LOCAL MECHANIC ABOUT IT IN JULY 2013 WHO IDENTIFIED THAT THERE WAS A TSB FOR THE THROTTLE BODY WIRING HARNESS. WE CONTINUED TO OBSERVE THE INTERMITTENT EPC FAULT RESPONSE BUT EXPERIENCED NO PROBLEMS. THE FIRST MAJOR INCIDENT OCCURRED 28 JUNE 2014 ENTERING I-89 NORTH WHEN ENTERING TRAFFIC THE EPC AND ENGINE FAULT LIGHTS CAME ON AND THE ENGINE LOST ALL POWER JUST AS WE ENTERED THE TRAVEL LANE. THE CAR WENT INTO LIMP MODE AND WOULD GO NO FASTER THAN 35 MPH I SWITCHED OFF THE ENGINE WHILE TRAVELING WHICH RESET THE THROTTLE FAULT ALLOWING US TO CONTINUE TRAVELING. THIS IS A SHORT RAMP AND THERE IS NO SHOULDER AT THE END OF THE RAMP. I MADE AN APPOINTMENT FOR THE CAR AT WALKER VW TO REPAIR THE CAR ON 2 JULY. THE SERVICE DEPARTMENT WAS UNABLE TO MAKE THE REPAIRS THAT DAY AS THEY DID NOT HAVE ALL OF THE REQUIRED PARTS ON HAND. ON 22 JULY MY WIFE WAS PREPARING TO ENTER I-91 FROM ROUTE 5 SOUTH VIA A LEFT TURN ON RAMP WHEN THE EPC AND ENGINE FAULT LIGHTS CAME ON AND THE ENGINE WENT INTO LIMP MODE JUST AS SHE WAS PREPARING TO TURN INTO THE ON RAMP. A TRACTOR TRAILER WAS RAPIDLY OVERTAKING HER IN THAT LANE IN A DRIVING RAIN AND THE CAR WOULD NOT EXCEED 20 MPH. SHE TURNED ON THE FLASHERS AND THE OVERTAKING TRUCKER VEERED INTO THE RIGHT LANE AVOIDING COLLISION. I THEN MADE AN APPOINTMENT WITH OUR LOCAL CAR REPAIR SHOP AND TRUSTED MECHANIC AT KINGDOM IMPORTS. THEY ORDERED THE PARTS AND INSTALLED THE REPLACEMENT WIRING IAW THE TSB ON 29 JULY 2014. EVEN AFTER ORDERING TWO COMPLETE SETS OF PARTS VW DID NOT INCLUDE THE SHRINK TAPE REQUIRED TO STABILIZE THE WIRING. VW HAS CHOSEN THE WORST SOLUTION AND SHOULD ISSUE A RECALL AND INSTALL A PURPOSE BUILT WIRING HARNESS. *TR

Mileage: 64,000

I DRIVE A 2009 VW TIGUAN 2.0 AUTOMATIC FRONT WHEEL DRIVE ABOUT 63000 MILES SITUATION #1: $782.67 INTAKE MANIFOLD (COVERED UNDER VW WARRANTY EXTENSION) DE CARB FUEL PRESSURE SENSOR PVC VALVE PRESSENS SEPARATOR SITUATION #2: $903.20 REAR MAIN SEAL FILTER OIL CHANGE AFTER CAR RETURNED: ISSUES WITH POWER WINDOWS, CD PLAYER, AND SUN ROOF DURING INSPECTION FOR ABOVE AT SHOP- CAR OVER HEATED WHILE ON A TEST DRIVE ISSUE # 3: ABOUT $1000- HAVEN'T YET GIVEN GO AHEAD CD PLAYER MAY BE FROM 'PLAYING BURNED CDS... SEE BEST BUY TO FIX.... SUNROOF- MAY BE TRACKING ISSUE- SEE AFTER MARKET SUNROOF PERSON TO FIX... WATER PUMP ARE ANY OF THESE CAUSING THE OTHERS? CAN I HOLD THE MECHANICS RESPONSIBLE FOR ANY OF THIS? IS THIS NORMAL FOR A CAR THIS AGE/ MILEAGE?? HELP!!!! *JS

Mileage: 63,000

THE CAM TIMING TENSIONER FAILED WHEN TRIED TO START THE ENGINE. CHECK THE PROBLEM ONLINE AND FIND OUT A COUPLE OF SAME ISSUE IN VOLKSWAGEN VEHICLES. THE CAR IS OVER 5-YEAR WARRANTY BUT STILL IN 60K MILES WARRANTY. VOLKSWAGEN OF THE UNITED STATES DOESN'T WANT TO GIVE ANY FINANCIAL ASSISTANCE. JUST AFTER 5 YEARS OF NEW CAR WARRANTY THE CAR GOT THIS CRITICAL ISSUE IN ENGINE, I THINK THIS WOULD BE AN ESSENTIAL DESIGN DEFECT FROM VW. *JS

Mileage: 56,600

MY 2009 VOLKSWAGEN TIGUAN SUFFERED A TIMING CHAIN MALFUNCTION APPROXIMATELY 40,000 MILES BELOW ITS MANUFACTURER RECOMMENDED REPLACEMENT DATE. THIS INCIDENT RESULTED IN CATASTROPHIC MECHANICAL FAILURE (BENT VALVES). *TR

Mileage: 84,000

FOR A WEEK, THERE WAS A RATTLING SOUND WHEN I STARTED MY CAR THAT USUALLY STOPPED AFTER A FEW SECONDS OF RUNNING. ON 04/05/14, I HEARD THE RATTLING SOUND THE ENTIRE TIME WHEN DRIVING. WHEN I STOPPED, MY VEHICLE CUTOFF AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO REPAIR SHOP WHERE THE MECHANIC TOLD ME THERE WAS NO COMPRESSION IN THE ENGINE. HE LATER EXPLAINED THE TIMING CHAIN TENSIONER BROKE WHICH CAUSED VALVES IN THE ENGINE TO BEND. RESEARCHING THE INTERNET, I NOTICED THE SAME EXACT DIAGNOSIS WAS GIVEN TO SEVERAL OTHER CONSUMERS OF THE SAME YEAR, MAKE AND MODEL. SOME OF WHOM HAD THE MISFORTUNE OF HAVING THEIR VEHICLES CUTOFF ON THE HIGHWAY. *TR

Mileage: 92,000

ENGINE WAS LEAKING OIL ONTO GROUND IN SEVERAL LOCATIONS NEAR THE FRONT OF THE VEHICLE. NO CHECK ENGINE LIGHT OR ANY OTHER WARNING SYSTEM INDICATED A PROBLEM. TOOK VEHICLE IN FOR SERVICE AND FOUND THE REAR MAIN SEAL WAS THE CAUSE FOR THE LEAK. REAR MAIN SEAL WAS REPLACED AND TEST DRIVE INDICATED THAT THIS WAS THE PRIMARY LEAK SOURCE. SUBSEQUENTLY, TWO OTHER MINOR LEAKS WERE FOUND AND REPAIRED TO THE OIL RETURN LINE O-RING AND THE ENGINE VACUUM PUMP GASKET RESPECTIVELY. *TR

Mileage: 75,443

REAR MAIN SEAL FAILED DUE TO MANUFACTURER DEFECT CAUSING OIL TO LEAK ON TO HOT ENGINE. EVERY 2.0 TSI ENGINE IN TIGUAN, CC, GTI, JETTA AND EOS EXPERIENCES THE SAME FAILURE AT AROUND THE SAME MILEAGE. THE REAR MAIN SEAL IS NOT A WEARING PART AND SHOULD LAST FOR THE LIFE OF A VEHICLE IF WELL DESIGNED. THIS FORUM THREAD SHOWS MANY OWNERS WITH THE SAME ISSUE AT AROUND THE SAME MILEAGE. HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?6907215-REAR-MAIN-SEAL-FAILURE-AT-80K-MILES-DUE-TO-PCV-DEFECT-ON-2-0-TSI&P=85203838#POST85203838 THE COST OF THE REPAIR WAS $1,500 AND VWOA REFUSES TO ADMIT IT IS A DESIGN DEFECT OR HELP PAY FOR THE REPAIR. *TR

Mileage: 87,000

PCV VALVE IS DEFECTIVE AND TEARS ON 100 PERCENT OF ALL TIGUANS. THIS OVER PRESSURIZES THE CRANKCASE CAUSING A LOUD NOISE AS PRESSURIZED AIR PASSES OVER THE FRONT AND REAR MAIN SEAL DAMAGING THE SEALS. EXSESSIVE OIL LEAKS FROM THE REAR MAIN SEAL ONTO THE CATALYTIC CONVERTER CAUSING IN MANY CASES, A FIRE. *TR

Mileage: 88,600

I HAD JUST STARTED GOING UP THE HILL I TRIED TO ACCELERATE THE CAR. IT STARTED SHAKING AND DID NOT WANT TO GO ANY FASTER. IN THE MEAN WHILE THE ENGINE LIGHT WAS FLASHING. AFTER THAT THE CAR WAS RUNNING FINE AS LONG I DID NOT ACCELERATED IT. I TOOK IT TO THE DEALER AND FOUND OUT THAT ONE OF THE COIL WAS NOT WORKING PROPERLY AND CAUSING LACK OF POWER. I HAD JUST PICKED UP THE CAR FROM THE DEALER 5 DAYS AGO BECAUSE OF THE SAFETY RECALL ABOUT THE FUSE AND THE FUSE PANEL. THEY CHANGED THE FUSE AND THE FUSE PANEL AND GAVE ME A PAPER WORK SAYING THAT MY CAR CHECKED OUT GOOD. AND THIS HAPPENS! I GOT DONE THE 60K CHECK UP 5 MONTHS AGO AND 3 WEEKS AFTER THAT THE AUXILIARY FAN GOT BROKEN. I BOUGHT THE CAR 9 MONTHS AGO AND I HAVE ALREADY SPENT OVER A THOUSAND DOLLAR ON IT. I AM REALLY FRUSTRATED WITH VW TIGUAN! *TR

Mileage: 63,732

TODAY IS THE 17TH OF DECEMBER AND FOR THE 2ND TIME IN 4 MONTHS THE COOLANT LIGHT HAS GONE OFF IN THE CAR. THE FIRST TIME IT HAPPENED WAS TOWARDS THE END OF AUGUST (I JUST PURCHASED THE VEHICLE A FEW WEEKS EARLIER). WHEN TAKEN TO THE DEALER SERVICE DEPARTMENT THE PROBLEM WAS THE WATER PUMP WENT BAD. AFTER THE MECHANIC SAID IT WAS STILL COVER UNDER WARRANTY THEY REPLACED IT. TODAY THE COOLANT LIGHT WENT OFF AGAIN, SAME ISSUE HAS BEFORE. AFTER CHECKING THE CAR FAX THE FIRST TIME IT HAPPENED, THIS IS THE 5TH WATER PUMP REPLACED IN THE CAR IN 2 YEARS. TODAY CALLING THE DEALERSHIP, THE PERSON AT THE DEALERSHIP HAS SAID THERE ARE QUITE FEW TIGUANS THAT HAVE COME IN WITH THE SAME ISSUE THE LAST FEW WEEKS. RESEARCHING THE ISSUE ONLINE THERE ARE INDICATIONS THAT THIS IS A PROBLEMATIC ISSUE THAT HAS NOT BEEN ADDRESSED BY VOLKSWAGEN. THE WARRANTY FOR THE PART ONLY COVERS A YEAR AND 12000 MILES. *TR

DRIVING ON THE HWY ,CHECK ENGINE LIGHT CAME ON AND EPC LIGHT ,ENGINE STARTS TO RUN VERY ROUGH,TOOK IT TO THE DEALER ,THEY SAID IT IS A COIL,REPLACED IT,A WEEK LATER THE SAME THING HAPPENED AGAIN ON THE HWY DOING 70 WITH FAMILY ,TOOK IT TO THE DEALER,THEY SAID ALL THE OTHER 3 COILS WENT BAD AT THE SAME TIME!!!!!! I AM REALLY AFRAID TO TAKE THIS CAR FOR A LONG TRIP ,THE OTHER ISSUE : THE FUSE MELTED CAUSING THE LICENSE BRAKE LIGHT HARNESS AND TRUNK OPENING TO FAIL TWICE . *TR

Mileage: 53,600

TAKING OFF AFTER GETTING FUEL CAR START TO IDLE ROUGH WHEN SLOWING DOWN. DROVE DIRECTLY TO DEALERSHIP LESS THAN A MILE WHERE THE CAR BARELY MADE IT INTO THE SERVICE AREA AND CHECK ENGINE LIGHT CAME ON. TIMING CHAIN BROKE AND BLEW ENGINE. VEHICLE HAS BEEN PERFECTLY MAINTAINED BY DEALER. IT APPEARS TO BE A RECURRING PROBLEM BASED ON INTERNET RESEARCH. FORTUNATELY, I WAS NOT DRIVING ON THE INTERSTATE AS NORMAL AT THAT TIME OF DAY. *TR

Mileage: 104,000

OVER THE LAST THREE MONTHS: FIRST-CHECK ENGINE AND EPC LIGHTS ON AND ENGINE PERFORMANCE LOW. SECOND-FUEL RAIL/SYSTEM PRESSURE TOO LOW. THIRD-BATTERY LIGHT CAME ON AND VEHICLE DID NOT HAVE NORMAL POWER (BATTERY BRAND NEW OCT12). FOURTH-HEADLIGHTS WENT OUT MULTIPLE TIME OVER A TWO WEEK PERIOD (BULBS BRAND NEW APR13). CAR IS WITH VW NOW FOR MELTED FUSE AND MELTED FUSE BOX. *TR UPDATED 09/17/13*LJ THE CONSUMER STATED THERE WERE MULTIPLE ELECTRICAL SYSTEM DTCS. THE FUSE BURNT AT THE CONNECTION AND BOTH RELAYS DUE TO AN OVERHEATED CONDITION. *JS

Mileage: 35,489

VEHICLE COMPLETELY STOPPED WHILE I WAS DRIVING ON THE FREEWAY. I WAS IN THE FAR LEFT LANE, AND THE ENGINE FAILED AND I WAS NOT ABLE TO MOVE TO THE RIGHT SHOULDER. I PUT MY HAZARDS ON AND CALLED FOR ASSISTANCE. WHILE ON THE PHONE IT WAS CLEAR THAT I WAS NOT IN A SAFE POSITION, SO MYSELF AND MY PASSENGER EXITED THE VEHICLE WHEN THERE WAS A BREAK IN TRAFFIC. WE WERE ABLE TO GET ACROSS TO THE RIGHT SIDE OF THE ROAD, BEHIND A GUARDRAIL. WHILE ON THE PHONE WITH 911 SOMEONE SLAMMED INTO THE BACK OF MY CAR, CAUSING EXTENSIVE DAMAGE TO BOTH VEHICLES. LUCKILY NO ONE WAS INJURED, AND NO OTHER CARS WERE AFFECTED. BOTH VEHICLES WERE INOPERABLE AND HAD TO BE TOWED FROM THE SCENE. I WAS TOLD BY THE VOLKSWAGEN DEALERSHIP THAT AN ENGINE COIL BROKE OFF, AND BACKFED INTO THE HARNESS, CAUSING THE ENGINE TO FAIL. IN ADDITION, I HAD JUST BEEN TO THE DEALER FOR AN OIL CHANGE THAT MORNING, AND HAD DRIVEN 8 MILES WHEN THE INCIDENT HAPPENED. THE DEALER SAYS THERE IS NO RELATIONSHIP, AND THAT ENGINE PARTS FAILED. I AM CONCERNED THAT THERE IS A DEFECT WITH THIS PART, AS I HAVE VERY LOW MILEAGE ON THE VEHICLE. THIS INCIDENT PUT ME IN AN EXTREMELY UNSAFE SITUATION, AND I WANT TO REPORT THIS IN ORDER TO FIND OUT IF THIS IS A DEFECTIVE PIECE, SO THAT THIS DOES NOT HAPPEN TO ANYONE ELSE. *TR

Mileage: 32,500