2003 VOLVO S40 Problems & Recalls

Engine light stays on. I have had 2 mechanics check it out. They don't know why the light is on. I am very concerned about the fuel line problem.

THE REAR STRUT/SHOCKS CONTINUE TO BREAK/CRACK OVER AND OVER. I HAVE GONE THROUGH 3 NEW STRUTS AND SHOCKS AND THEY CONTINUE TO BREAK. I ALSO HAVE GONE TO THE JUNKYARD AND ALL OF THE S40 AND V40'S HAVE ALL OF THEIR STRUTS/SHOCKS BROKEN. I'VE WITNESSED OVER 6 S40 OR V40'S LIKE THIS NOW. MY CAR HAS FAIL...

Mileage: 120,000

PRIOR TO LATEST INCIDENT, THE CAR HAD OCCASIONALLY GONE INTO "LIMP" MODE, STICKING IN 3RD GEAR BUT DRIVABLE. THAT PROBLEM WOULD GO AWAY AFTER A DAY OR SO. LOCAL SHOP COULDN'T FIND ANYTHING DEFINITIVE. BIGGER PROBLEM WAS YESTERDAY EVENING'S LOSS OF THROTTLE CONTROL AND MULTIPLE ELECTRICAL ISSUES. IDL...

Mileage: 108,000

PRIOR TO LATEST INCIDENT, THE CAR HAD OCCASIONALLY GONE INTO "LIMP" MODE, STICKING IN 3RD GEAR BUT DRIVABLE. THAT PROBLEM WOULD GO AWAY AFTER A DAY OR SO. LOCAL SHOP COULDN'T FIND ANYTHING DEFINITIVE. BIGGER PROBLEM WAS YESTERDAY EVENING'S LOSS OF THROTTLE CONTROL AND MULTIPLE ELECTRICAL ISSUES. IDL...

Mileage: 108,000

PRIOR TO LATEST INCIDENT, THE CAR HAD OCCASIONALLY GONE INTO "LIMP" MODE, STICKING IN 3RD GEAR BUT DRIVABLE. THAT PROBLEM WOULD GO AWAY AFTER A DAY OR SO. LOCAL SHOP COULDN'T FIND ANYTHING DEFINITIVE. BIGGER PROBLEM WAS YESTERDAY EVENING'S LOSS OF THROTTLE CONTROL AND MULTIPLE ELECTRICAL ISSUES. IDL...

Mileage: 108,000

I RETURNED TO MY CAR AND FOUND THAT I COULD NOT TURN THE IGNITION SWITCH AND AS A RESULT OF THE SECURITY SYSTEM MY CAR WAS TOTALLY INOPERATIVE. THE CAR HAD TO BE TOWED TO THE NEAREST DEALER, WHERE IT WAS DIAGNOSED WITH A BROKEN IGNITION SWITCH, SPECIFICALLY THE DEVICE THAT READS THE CHIP IN THE KEY...

Mileage: 125,000

TL* THE CONTACT OWNS A 2003 VOLVO S40. THE CONTACT STATED THAT WHILE SITTING AT A TRAFFIC STOP, THE VEHICLE ACCELERATED ABNORMALLY. THE CONTACT HAD HIS FOOT ON THE BRAKE PEDAL AND THEN HAD TO SHIFT INTO NEUTRAL TO GET THE VEHICLE TO SLOW DOWN. THE CONTACT PULLED THE VEHICLE OVER, SHUT OFF AND TRIED ...

Mileage: 94,000

MY 2003 VOLVO S40 HAS BEEN DRIVEN FEWER THAN 70,000 MILES. ALL VOLVO RECOMMENDED SERVICE HAS BEEN PERFORMED BY CERTIFIED MECHANICS AND IS DOCUMENTED. MY VOLVO DEALER DETERMINED THAT THE TRANSMISSION HAD TO BE REPLACED. IT IS NOT AT ALL REASONABLE TO HAVE A CATASTROPHIC TRANSMISSION FAILURE AT O...

Mileage: 69,650

I WAS DRIVING WHEN THE CAR START TO ACCELERATED BY ITSELF, ACCEL PEDAL WENT TO THE FLOOR. I COULD NOT KEEP A CAR EVEN BY THE HAND BRAKE, SO AS IT WAS JUMPING AHEAD. THEN THE CAR BEGAN TO BLOW BLACK AND WHITE SMOKE OUT UNDER THE HOOD. SOME HOW I TURN OFF THE ENGINE, TOOK THE KEY AND RUN AWAY FROM...

Mileage: 85,106

I WAS DRIVING WHEN THE CAR START TO ACCELERATED BY ITSELF, ACCEL PEDAL WENT TO THE FLOOR. I COULD NOT KEEP A CAR EVEN BY THE HAND BRAKE, SO AS IT WAS JUMPING AHEAD. THEN THE CAR BEGAN TO BLOW BLACK AND WHITE SMOKE OUT UNDER THE HOOD. SOME HOW I TURN OFF THE ENGINE, TOOK THE KEY AND RUN AWAY FROM...

Mileage: 85,106

I WAS DRIVING WHEN THE CAR START TO ACCELERATED BY ITSELF, ACCEL PEDAL WENT TO THE FLOOR. I COULD NOT KEEP A CAR EVEN BY THE HAND BRAKE, SO AS IT WAS JUMPING AHEAD. THEN THE CAR BEGAN TO BLOW BLACK AND WHITE SMOKE OUT UNDER THE HOOD. SOME HOW I TURN OFF THE ENGINE, TOOK THE KEY AND RUN AWAY FROM...

Mileage: 85,106

I WAS DRIVING WHEN THE CAR START TO ACCELERATED BY ITSELF, ACCEL PEDAL WENT TO THE FLOOR. I COULD NOT KEEP A CAR EVEN BY THE HAND BRAKE, SO AS IT WAS JUMPING AHEAD. THEN THE CAR BEGAN TO BLOW BLACK AND WHITE SMOKE OUT UNDER THE HOOD. SOME HOW I TURN OFF THE ENGINE, TOOK THE KEY AND RUN AWAY FROM...

Mileage: 85,106

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) ON FEB 12, I HAD A PERIODIC MAINTENANCE DONE AT THE DEALERSHIP AND THEY ADVISED ME THAT MY TIRES WERE BAD. I HAD ONLY HAD THE TIRES A SHORT WHILE SO I BROUGHT THE CAR TO WHERE I BOUGHT THEM (SEARS) AND WAS...

MY 2003 S40 HAS BEEN SLIPPING GEAR BETWEEN 3RD AND 4TH GEAR AND OCASSIONAL HARD SHIFT BETWEEN 2ND AND 3RD GEAR. THE CAR ONLY HAS 49000 MILES. I HAVE GONE TO THE DEALER AND THEY SAID, THERE IS NO SOFTWARE UPDATE FOR THE TCM (TRANSMISSION CONTROL MODULE)AND IT NEEDS TO BE REPLACED. COST $800. THIS GEA...

Mileage: 48,000

GOT A CHECK ENGINE LIGHT ON AND TRIED TO GET A FULL DIAGNOSTIC TEST DONE, BUT THE POWER CONTROL MODULE WAS NOT COMMUNICATING WITH VEHICLE. *JB

TRANSMISSION SLIPS BETWEEN GEARS 2ND AND 3RD

CONSUMER STATED THAT BANRIDGE VOLVO WILL NOT HONOR THE RECALL DEALING WITH THE FUEL RAIL. CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP ON 04/22/2004. *AK

THE FOLLOWING IS A SYNOPSIS OF ORIGINAL E-MAIL I SENT TO VOLVO CARS OF NORTH AMERICA FOR YOUR RECORDS. *AK ------------------------------------------------------------------------------------------------- I FINALLY HAD MY 2003 VOLVO S40 SERVICED FOR EXCESSIVE BUMPY RIDE PROBLEM THAT IVE COMPLA...

CONSUMER INDICATED THAT THE ISOFIX GUIDE THAT THE MANUFACTURER SENT FOR RECALL 03V284000 COULD NOT FIX THE PROBLEM. *AK

TO WHOM IT MAY CONCERN:I WOULD LIKE TO REPORT A COMPLAINT THAT ONE OF THE MICHELIN TIRES ON MY NEW VOLVO S40 (BOUGHT ON JAN 25, 2003: [XXX]) BLEW OUT WHILE I WAS DRIVING TO WORK. FORTUNATELY, I WAS NOT IN AN ACCIDENT AS I WAS DRIVING AT ABOUT 25MPH. ON THE SAME DAY FRIDAY (DEC 12, 03) I CONTACTED TH...

2002 VOLVO S40 EXPERIENCED MECHANICAL FAILURE OF THE ENGINE FUEL LINE. *MR *CB

I AM CURRENTLY DRIVING A 2003 VOLVO S40. IT HAS BEEN EXPERIENCING A TRANSMISSION SLIP BETWEEN 2ND AND 3RD GEARS. I HAD TAKEN THE CAR BACK TO THE DEALER FOR TWO TIMES DUE TO THE ABOVE PROBLEM. THE ONLY THING THEY DID WAS UPGRADING THE PROGRAM, WHICH IT DID NOT HELP AT ALL. THE MAJOR PROBLEM IS I ...

Mileage: 4,500

TRANSMISSION SLIPS FROM 2ND TO 3RD FROM TIME TO TIME. ADDITIONALLY, THE CAR SHIFTS HARSHLY FROM 3RD TO 2ND GEAR. *JB

Mileage: 7,000