2000 VOLVO S70 Engine And Engine Cooling Problems

TL-THE CONTACT OWNS A 2000 VOLVO S70. THE CONTACT STATED THAT WHILE SHE WAS DRIVING AT VARIOUS SPEEDS THE ETS LIGHT WOULD ILLUMINATE ON THE INSTRUMENTAL PANEL. THE VEHICLE WAS THEN DIAGNOSED BY A DEALER AND THEY ADVISED HER THAT THE "ELECTRONIC THROTTLE SYSTEM" WOULD CAUSE THE VEHICLE TO LOOSE ALL POWER AND POTENTIALLY BE DANGEROUS. THE MANUFACTURER WAS CONTACTED AND ADVISED HER THAT THEY WOULD SEND HER A COUPON SINCE THE ACTUAL RECALL HAS EXPIRED. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 79,300. TB

Mileage: 79,300

TL*THE CONTACT OWNS A 2000 VOLVO S70. WHILE DRIVING 40 MPH THE CONTACT NOTICED THAT THE RPM'S SUDDENLY INCREASED FROM 2000 TO 3000 WITHIN 15 SECONDS WITHOUT THE CONTACT ENGAGING THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE AIR MASS METER, EVAPORATOR VALVE, CATALYTIC CONVERTER, AND THE SPEED SENSOR NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 117,000. THE CURRENT MILEAGE WAS 118,000.

Mileage: 117,000

NOTICED ENGINE DYING OUT WHEN ACCELERATING, THE PROBLEM WAS NOTICEABLY GETTING WORSE. FINALLY THE CAR CAME TO A STOP AT THE LIGHT, LIGHT TURNED GREEN PRESSED ON THE ACCELERATOR PEDAL AND NO RESPONSE, CAR SAT THERE IN IDLE WITH NO RESPONSE TO PRESSING ON THE PEDAL. *TR

Mileage: 121,000

TL*THE CONTACT OWNS A 2000 VOLVO S70. WHILE DRIVING APPROXIMATELY 45 MPH, THE CHECK ENGINE LIGHT ILLUMINATED INTERMITTENTLY. APPROXIMATELY THREE MONTHS LATER, THE ELECTRONIC THROTTLE SYSTEM (ETS) LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY CLEANED THE ETS. WHEN THE CONTACT WENT TO RETRIEVE THE VEHICLE, THE ETS LIGHT ILLUMINATED AGAIN AND THE VEHICLE WAS LEFT AT THE DEALER. THE CURRENT MILEAGE WAS 78,728 AND FAILURE MILEAGE WAS 78,528.

Mileage: 78,528

TL*THE CONTACT OWNS A 2000 VOLVO S70. WHILE DRIVING 55 MPH IN AN ATTEMPT TO MAINTAIN SPEED THE THE VEHICLE LOST POWER. THE VEHICLE FAILURE OCCURRED OCCASIONALY ON A DAILY BASIS. THE FAILURE OCCURRED FOR APPROXIMATELY SIX MONTHS. THE CONTACT STATED THAT THE DEALER MISDIAGNOSED THE FAILURE ON THE LAST THREE ATTEMPTS. THE CURRENT MILEAGE WAS 95,000 , AND THE FAILURE MILEAGE WERE 80,000. *AK

Mileage: 80,000

DT: THE CONTACT STATED ENGINE SPUTTERED AND CHOKED, THEN IT EVENTUALLY STALLED. THE ELECTRICAL THROTTLE SYSTEM ( ETS ) LIGHT ILLUMINATED. SHE TOOK THE VEHICLE TO DEALER FOR SERVICE. THE ETS AND EXHAUST/CRANKCASE EMISSION CONTROL MODULE (ECM) WERE REPLACED. THE VEHICLE WAS OPERATING CORRECTLY. THE VEHICLE HAS BEEN TO THE DEALERSHIP FIVE TIMES SINCE SEPTEMBER 2005. *AK

2000 VOLVO S70 MILEAGE: 49642 ETS (ELECTRONIC THROTTLE SYSTEM) LIGHT CAME ON. SUDDEN LOSS OF POWER, HESITATION, AND STALLING WITHOUT ANY INDICATION. SUBSEQUENT SEARCH ON THE INTERNET I FOUND OUT THE ETM (ELECTRONIC THROTTLE MODULE) AND THE ETS FAILURES WERE RELATED AND POSSIBLE RECALL ON PARTS BY VOLVO. SERVICED AT FAIRFAX VOLVO (703) 591-1820 ON 10/18/2005. SERVICE COST $900.00.*JB

Mileage: 49,621

WHILE TEACHING MY SON TO DRIVE OUR 2000 VOLVO S70, OUR CAR STARTED JERKING AS HE WAS COMING TO A STOP. AT THE STOP LIGHT,THE CAR CONTINUED TO HAVE A JERKING MOTION. THE ETS LIGHT CAME ON SO I LOOKED THIS PROBLEM UP IN OUR MANUAL. IT SAYS, 'IF THE LIGHT REMAINS ON, THE SYSTEM SHOULD BE INSPECTED BY AN AUTHORIZED VOLVO RETAILER'. THE LIGHT WENT OUT SO WE DIDN'T THINK THAT THIS WAS GOING TO BE AN ONGOING PROBLEM. WE CONTINUED TO DRIVE THE CAR AND IT WORKED FINE. ON SOME OCCASIONS THE LIGHT WOULD COME ON AND WE WOULD SIMPLY BRING THE CAR TO A STOP AND TURN THE CAR OFF. THE LIGHT WOULD GO OFF. I BECAME CONCERNED ABOUT THIS ONLY AFTER THE LIGHT CAME ON AND I COULDN'T BRING THE CAR TO AN IMMEDIATE STOP. I WAS GEARINGUP TO A MERGE WHERE CARS ARE WEAVING AND OUT OF EACH OTHER AT RUSH HOUR TO POSITION THEMSELVES TO GET ONTO OR OFF THE HIGHWAY,RESPECTIVELY. THE LIGHT CAME ON AND I COULDN'T STOP. THE CAR'S ACCELERATOR BEGAN TO BEHAVE ERRATICALLY LIKE IT WAS LOSING PRESSURE BUT I WASN'T IN A LOCATION WHERE I COULD STOP;I BARELY AVOIDED A MAJOR ACCIDENT. WHEN I BROUGHT THE CAR TO A STOP AND TURNED THE ENGINE OFF THE LIGHT WENT OFF AGAIN AS IF NOTHING WAS WRONG. I CAME STRAIGHT HOME AND GOT ONLINE TO GET INSIGHT. I READ THAT VOLVO OWNERS IN CAL HAD BROUGHT A CLASS ACTION LAWSUIT OVER THIS SAFETY ISSUE. IRONICALLY, WE HAD JUST HAD OUR 90K SERVICE PERFORMED 3 MOS BEFORE THIS PROBLEM OCCURRED. WE THOUGHT THAT WE WERE MAINTAINING OUR VEHICLE TO ITS HIGHEST SAFETY STANDARDS. NOW WE HAVE TO BRING THE CAR BACK IN FOR A $1K FIX. I AM ADDING MY VOICE TO OTHER VOLVO OWNERS WHO'VE HAD THIS PROBLEM AND BELIEVE THAT IT'S VOLVOS DUTY TO CORRECT IT BEFORE THERE ARE SIGNIFICANT DEATHS ATTRIBUTED TO IT. IF NOTHING ELSE, THE MANUAL SHOULD SAY, 'BRING YOUR CAR IN IMMEDIATELY TO BE FIXED BECAUSE THE PROBLEM WILL WORSEN AND EVENTUALLY LEAD TO COMPLETE ENGINE FAILURE AND POTENTIALLY YOUR DEATH AND THE DEATH OF INNOCENT PEOPLE IN THE CARS AROUND YOU WHO HIT YOU UNSUSPECTING BECAUSE YOUR CAR'S ENGINE FAILS'. *NM

Mileage: 91,800

DT: VEHICLE STALLED/DIED AND LOST POWER. DEALER REPLACED THE THROTTLE BODY. *AK *JB

WHILE DRIVING AT 65 WITH CRUISE CONTROL ON, THE ETS LIGHT CAME ON AND THE CRUISE CONTROL TURNED OFF CAUSING THE CAR TO DECELERATE SUDDENLY. THIS IS A SAFETY ISSUE AS IT CAN LEAD TO A COLLISION FROM THE REAR. THE CAR WAS STILL DRIVABLE WITH MANUAL CONTROL OF THE ACCELERATOR, BUT EXPERIENCED INTERMITTENT STUTTERING WHILE BEING DRIVEN AT HIGHWAY SPEED. DIAGNOSTIC BY THE DEALER REVEALED THAT THE ELECTRONIC THROTTLE MODULE IS FAILING AND MUST BE REPLACED. THE COST OF THE REPAIR BEING 900 DOLLARS.*JB

Mileage: 69,000

MY 2000 VOLVO S70 FAILED ON I-55 IN MS. AND I HAD TO PULL OFF THE ROAD IN HIGH SPEED TRAFFIC. IT WAS VERY DANGEROUS. EACH TIME THE FAILURE WAS IMMEDIATELY PRECEDED BY THE ETS LIGHT COMING ON. *NM

Mileage: 61,700

CAR STALLED WITHOUT WARNING A COUPLE OF TIMES. *JB

Mileage: 65,000

DT: VEHICLE INTERRMITTENTLY STALLED AND DIED . TOOK VEHICLE TO DEALER, WHO SUGGESTED THE PROBLEM WA STHE INTAKE MANIFOLD SYSTEM. *AK

Mileage: 56,000

WE PURCHASED THE VOLVO 2000 S70 VEHICLE IN 9/01 WITH 25,000 MILES. A 30,000 MILE CHECK-UP WAS PERFORMED BY SANTA MONICA VOLVO ON 12/26/01. STEVEN AND I BEGAN A 14-MONTH ROAD TRIP AROUND THE US AND HAD THE VEHICLE MAINTAINED AT VOLVO DEALERS THROUGHOUT THE COUNTRY (THE CHECK ENGINE LIGHT PERIODICALLY CAME ON AND WE WOULD ASK THE DEALERS ABOUT IT. WE WERE TOLD NOT TO WORRY ABOUT THE LIGHT.) THE ROAD TRIP ACCOUNTS FOR THE ACCRUED MILES PUT ON THE VEHICLE IN SUCH A SHORT PERIOD OF TIME. RETURNED TO CALIFORNIA 3/04. BROUGHT THE VEHICLE INTO SANTA MONICA VOLVO TO HAVE THE 75,000 MILE CHECK-UP. THEY DID THE CHECK-UP AND WE DROVE AWAY. THE ETS AND CHECK ENGINE LIGHT CAME ON WITHIN ONE MILE, CAR BEGAN TO JERK, CALLED THE DEALER AND IMMEDIATELY RETURNED THE VEHICLE. SM VOLVO DID THE DIAGNOSTICS BUT DID NOT KNOW WHY THE ETS LIGHT CAME ON AS WE DROVE AWAY. THESE THINGS HAPPEN, THEY SAID. SM VOLVO EXPLAINED THAT CERTAIN CODES CAME UP, THEY WOULD RESET THE COMPUTER (CODE EZM#91A7 ON THE THROTTLE UNIT) AND DOWNLOAD A NEW PROGRAM. THEY WOULD BE ABLE TO REPAIR IT BY DOING ADDITIONAL WORK AND DID NOT GUARANTEE THE COMPUTER RESET. WE ASKED IF THE REPAIR WOULD BE GUARANTEED OR COULD WE DRIVE OFF AGAIN AND GET THE SAME RESULTS. THEY COULD NOT GUARANTEE THAT IT WOULD RESOLVE THE ISSUE. THIS LED US TO BELIEVE THAT EVERYTIME WE APPROVED THEM TO REPAIR THE PROBLEM, IT WOULD CONTINUE TO OCCUR. NOT GUARANTEEING THAT THEY CAN RESOLVE THE PROBLEM MADE US CONSIDER MORE RESEARCH AND/OR A SECOND OPINION. WE DECIDED TO LEAVE THE DEALER WITHOUT REPAIR. WE HAVE DRIVEN THE VEHICLE LOCALLY SINCE THEN, BUT WITH MANY FAILURES. ALOT OF JERKING, SOMETIMES THE ENGINE SHUTS OFF AND I HAVE TO SIT FOR 5 MINUTES BEFORE THE ENGINE WILL TURN ON AGAIN. THE VEHICLE CURRENTLY HAS 82,000 MILES. WE HAVE ONLY DRIVEN 5,000 IN 16 MONTHS. WE ARE ONLY USING THE VEHICLE FOR ERRANDS AND WORK. WE DO NOT WANT TO GIVE THE DEALER FREE REIGN OVER CHARGES AND REPAIRS THAT THEY CANNOT JUSTIFY OR GUARANTEE.*JB

Mileage: 77,000

MY 2000 VOLVO S70 HAD A MALFUNCTION OF THE ELECTRONIC THROTTLE CONTROL MODULE AND I ALMOST GOT REAR ENDED ON THE HIGHWAY WHEN THE CAR HAVE AN ABRUPT LOSS OF SPEED. I TOOK THE CAR TO A VOLVO DEALER AND WAS CHARGED $1,500 TO REPLACE THE MODULE ABOUT 5 WEEKS AGO BUT IT LOOKS LIKE THE CAR IS STARTING TO MALFUNCTION AGAIN. *JB

Mileage: 84,000

THE CONSUMER EXPERIENCED A PROBLEM WITH THE THROTTLE BODY AND MASS AIRFLOW ON HIS 2000 VOLVO S70. *JB THE POWER STEERING FAILED AND FLUID LEAKED ALL OVER THE DRIVEWAY. THE POWER STEERING PUMP AND RESERVOIR NEEDED TO BE REPLACED. WHY DRIVING, THE AIR DIRECTOR FELL OFF THE BUMPER. *JB *NM

Mileage: 35,326

2000 S70 - MULTIPLE REPAIRS AND MULTIPLE RECURRING INCIDENTS OF THIS SAME PROBLEM! CHECK ENGINE LIGHT COMES ON, ENGINE RUNS ROUGH, TACH BOUNCES AND POWER DEMINISHES BECOMING A SEVER HAZARD IN HIGH SPEED TRAFFIC. DEALER FOUND THE PROBLEM TO BE "KNOWN ISSUES" WITH THE ELECTRONIC AIR MASS AND THROTTLE SYSTEMS. REPLACED TWICE WHILE UNDER WARRANTY, EXTENDED WARRANTY DENIED, SHORTLY OUT OF WARRANTY AND PROBLEM RETURNS AGAIN. DEALERSHIP NOR VOLVO WILL TAKE ANY CORRECTIVE ACTION ON >$1000 REPAIR (WHICH ACCORDING TO THE SERVICE TECH IS ALMOST GUARANTEED TO RETURN). THIS IS MY THIRD VOLVO, AND CERTAINLY MY LAST.

THE ETS (ELECTRONIC THROTTLE SYSTEM) LIGHT COME ON INTERMITTENLY FOR ABOUT A MONTH, THEN ON APRIL 20, 2004 WHILE I WAS DRIVING ON THE HIGHWAY, THE LIGHT STAYS ON THE CAR WAS SLUGGISH IN ACCELERATING. I HAD TO GET OFF THE HIGHWAY TO TAKE LOCAL STREETS. *AK

Mileage: 63,100

WHILE DRIVING 35 MPH VEHICLE COMPLETELY SHUTDOWN WITHOUT WARNING. VEHICLE WAS TOWED TO DEALER. DEALAER REPLACED AXLE. PLEASE GIVE ANY FURTHER DETAILS.*AK

CONSUMER WAS TRAVELING 60MPH IN A 65MPH ZONE. PASSING ANOTHER VEHICLE GOING 60MPH HE FLOORED THROTTLE AND ETS LIGHT CAME UP ON DASHBOARD. VEHICLE WENT DOWN TO 2,000 RPM'S. CONSUMER PULLED OVER, AND READ MANUAL, STARTING VEHICLE BACK UP AND IT HAPPENED AGAIN. DEALER DIDN'T KNOW WHAT TO DO. THEY HAD TO INSPECT IT FOR PROBLEM. *AK THE TUBE GOING FROM BEHIND THE GRILL TO THE AIR CLEANER INLET WAS COLLAPSING CAUSING LACK OF AIR FLOW TO THE ENGINE. THE TUBE WAS REMOVED AND THE PROBLEM WAS SOLVED. *YH

ENGINE PROBLEMS SINCE DAY 1. ALWAYS INTERMITTANT AND WITHOUT WARNING. I FEEL THE CAR IS RENDERED UNSAFE DUE TO THE POTENTIAL FOR TOTAL UNEXPECTED POWER LOSS. DEAL REFUSES TO WORK ON CAR UNTIL AUTHORIZED BY VOLVO USA. 6 MONTHS AND NO WORD YET