This Problem Across All Years
FAILURE OF ELECTRONIC THROTTLE MODULE ASSEMBLY CAUSING VERY POOR DRIVABLE. PROBLEM IS INTERMITTENT AND SEVERE THAT THE CAR CAN NOT SAFELY BE DRIVEN IN TRAFFIC WITHOUT A RISK OF ACCIDENT. BRIEF CHRONOLOGY: I HAVE A VERY EARLY PRODUCTION 1999 VOLVO V70XC. IT HAD DRIVABLE PROBLEMS SINCE I BOUGHT IT. NEVER WAS FIXED. (SUPPOSEDLY) REPLACED ETM THE FIRST TIME IN ~ 2004, USING PART WHOSE DESIGN WAS KNOWN TO BE FAULTY. LATER DID SOFTWARE UPDATE (CAMPAIGN 155). DRIVABLE IMPROVED SLIGHTLY, BUT WAS NEVER CORRECT. REPLACEMENT MODULE IS NOW FAILING. CAR CAN NOT BE DRIVEN SAFELY. ENGINE RUNS POORLY, RPM LIMITED TO < 2000, ALWAYS IN "LIMP HOME MODE". YOU ARE AWARE (I BELIEVE) THAT THERE IS A RECALL/REPLACEMENT CAMPAIGN UNDERWAY FOR THIS PART. HOWEVER, THE REPLACEMENT PART HAS THE SAME DESIGN FLAW AS THE ORIGINAL. (I AM ALREADY ON A "SUPPOSEDLY" REPLACED MODULE). VOLVO IS PRETENDING TO HONOR AN EXTENDED WARRANTY WHILE EITHER: 1) CHANGING THE MODULE'S SOFTWARE TO POSTPONE OR HIDE THE ACTUAL (MECHANICAL) FAILURE MECHANISM. 2) REPLACING A FAILED MODULE WITH ONE HAVING THE SAME FLAWED DESIGN WHICH HAS THE SAME POTENTIAL FOR FAILURE AS BEFORE. THIS RESULTS IN A SERIOUS POTENTIAL SAFETY ISSUE BEING QUITE LIKELY TO OCCUR TO A CUSTOMER LIKE MYSELF IN THE FUTURE. WORSE YET, THIS IS OCCURRING JUST AS A NUMBER OF THE VEHICLES ARE NEARING THE END OF THE EXTENDED WARRANTY. THE END RESULT OF THIS IS THEY LEAVE A SERIOUS DRIVEABILITY PROBLEM UNSOLVED, AND DUCK THE ACTUAL PROBLEM BY USING A SOFTWARE UPDATE TO GET THE CUSTOMER JUST PAST THE WARRANTY PERIOD. IN CONCLUSION, THEY ARE CONTINUING TO SUPPLY UNRELIABLE AND UNSAFE PARTS UNDER THE GUISE OF HAVING PROVIDED A SAFE, RELIABLE, AND WARRANTED REPAIR. THEY NEED TO BE FORCED TO: ISSUE A FULL RECALL FOR ALL VEHICLES USING THE CURRENT ETM DESIGN, ANNOUNCE A FULL RECALL FOR ALL CARS USING THIS DESIGN, AND SUPPLY ONLY A RE-DESIGNED ETM AS PART OF ALL FUTURE REPAIRS. *TR
FAILURE OF ELECTRONIC THROTTLE MODULE ASSEMBLY CAUSING VERY POOR DRIVABLE. PROBLEM IS INTERMITTENT AND SEVERE THAT THE CAR CAN NOT SAFELY BE DRIVEN IN TRAFFIC WITHOUT A RISK OF ACCIDENT. BRIEF CHRONOLOGY: I HAVE A VERY EARLY PRODUCTION 1999 VOLVO V70XC. IT HAD DRIVABLE PROBLEMS SINCE I BOUGHT IT. NEVER WAS FIXED. (SUPPOSEDLY) REPLACED ETM THE FIRST TIME IN ~ 2004, USING PART WHOSE DESIGN WAS KNOWN TO BE FAULTY. LATER DID SOFTWARE UPDATE (CAMPAIGN 155). DRIVABLE IMPROVED SLIGHTLY, BUT WAS NEVER CORRECT. REPLACEMENT MODULE IS NOW FAILING. CAR CAN NOT BE DRIVEN SAFELY. ENGINE RUNS POORLY, RPM LIMITED TO < 2000, ALWAYS IN "LIMP HOME MODE". YOU ARE AWARE (I BELIEVE) THAT THERE IS A RECALL/REPLACEMENT CAMPAIGN UNDERWAY FOR THIS PART. HOWEVER, THE REPLACEMENT PART HAS THE SAME DESIGN FLAW AS THE ORIGINAL. (I AM ALREADY ON A "SUPPOSEDLY" REPLACED MODULE). VOLVO IS PRETENDING TO HONOR AN EXTENDED WARRANTY WHILE EITHER: 1) CHANGING THE MODULE'S SOFTWARE TO POSTPONE OR HIDE THE ACTUAL (MECHANICAL) FAILURE MECHANISM. 2) REPLACING A FAILED MODULE WITH ONE HAVING THE SAME FLAWED DESIGN WHICH HAS THE SAME POTENTIAL FOR FAILURE AS BEFORE. THIS RESULTS IN A SERIOUS POTENTIAL SAFETY ISSUE BEING QUITE LIKELY TO OCCUR TO A CUSTOMER LIKE MYSELF IN THE FUTURE. WORSE YET, THIS IS OCCURRING JUST AS A NUMBER OF THE VEHICLES ARE NEARING THE END OF THE EXTENDED WARRANTY. THE END RESULT OF THIS IS THEY LEAVE A SERIOUS DRIVEABILITY PROBLEM UNSOLVED, AND DUCK THE ACTUAL PROBLEM BY USING A SOFTWARE UPDATE TO GET THE CUSTOMER JUST PAST THE WARRANTY PERIOD. IN CONCLUSION, THEY ARE CONTINUING TO SUPPLY UNRELIABLE AND UNSAFE PARTS UNDER THE GUISE OF HAVING PROVIDED A SAFE, RELIABLE, AND WARRANTED REPAIR. THEY NEED TO BE FORCED TO: ISSUE A FULL RECALL FOR ALL VEHICLES USING THE CURRENT ETM DESIGN, ANNOUNCE A FULL RECALL FOR ALL CARS USING THIS DESIGN, AND SUPPLY ONLY A RE-DESIGNED ETM AS PART OF ALL FUTURE REPAIRS. *TR
DRIVING ON FREEWAY 65 MILES PER HOUR, VEHICLE LOSES COMPLETE POWER, ETS AND CHECK ENGINE LIGHTS COMES ON. I WAS ABLE TO COAST OFF THE FREEWAY ONTO THE RIGHT SHOULDER. TRIED SEVERAL RESTARTS TO SEE IF ENGINE WILL RUN NORMALLY, AFTER 10-15 MINUTES, STARTED CAR, ENG RAN NORMAL, ETS AND CEL LIGHT STILL ON. I WAS ABLE TO DRIVE HOME WITHOUT FURTHER INCIDENT. *TR
DRIVING ON FREEWAY 65 MILES PER HOUR, VEHICLE LOSES COMPLETE POWER, ETS AND CHECK ENGINE LIGHTS COMES ON. I WAS ABLE TO COAST OFF THE FREEWAY ONTO THE RIGHT SHOULDER. TRIED SEVERAL RESTARTS TO SEE IF ENGINE WILL RUN NORMALLY, AFTER 10-15 MINUTES, STARTED CAR, ENG RAN NORMAL, ETS AND CEL LIGHT STILL ON. I WAS ABLE TO DRIVE HOME WITHOUT FURTHER INCIDENT. *TR
I BOUGHT THIS VOLVO USED W/ 120K MILES. I SAW RECORDS OF MAJOR WORK DONE AT THE DEALER JUST PREVIOUS TO 100,000 AND FIGURED IT WOULD BE GOOD FOR ANOTHER 100K. AT 131K, IT BEGAN CONSTANTLY STALLING AND LUNGING. I DID A TINY BIT OF RESEARCH AND LEARNED OF THE RECALL. I TOOK IT TO THE DEALER AND THEY TRIED TO CHARGE ME 200 TO DO NOTHING OTHER THAN READ THE CODES AND TELL ME THE ETM SOFTWARE HAD ALREADY BEEN UPDATED, AND THAT THE MASS AIRFLOW SENSOR WAS BAD. I REPLACED THE MAFS TO NO CHANGE. *TR
I BOUGHT THIS VOLVO USED W/ 120K MILES. I SAW RECORDS OF MAJOR WORK DONE AT THE DEALER JUST PREVIOUS TO 100,000 AND FIGURED IT WOULD BE GOOD FOR ANOTHER 100K. AT 131K, IT BEGAN CONSTANTLY STALLING AND LUNGING. I DID A TINY BIT OF RESEARCH AND LEARNED OF THE RECALL. I TOOK IT TO THE DEALER AND THEY TRIED TO CHARGE ME 200 TO DO NOTHING OTHER THAN READ THE CODES AND TELL ME THE ETM SOFTWARE HAD ALREADY BEEN UPDATED, AND THAT THE MASS AIRFLOW SENSOR WAS BAD. I REPLACED THE MAFS TO NO CHANGE. *TR
A SUDDEN DROP IN POWER ON FREEWAYS AND CITY STREETS. *JB
A SUDDEN DROP IN POWER ON FREEWAYS AND CITY STREETS. *JB
SURGING, FOULING SPARK PLUGS, HESITATING, STALLING, CUTS OFF WHILE DRIVING AND LOCKS UP. *NM
SURGING, FOULING SPARK PLUGS, HESITATING, STALLING, CUTS OFF WHILE DRIVING AND LOCKS UP. *NM
DT: 1999 VOLVO WAGON VXC. SUDDEN LOSS OF POWER . THE CAR DID NOT STALL EXCEPT AT A STOP SIGN WHEN GIVING IT A LOT OF GAS TO GET IT GOING. THIS HAPPENED INTERMITTENTLY FOR TWO MONTHS. TOOK VEHICLE TO DEALERSHIP, AND THEY SAID IT WOULD COST $1753.00 TO FIX IT. THE CAR IS OUT OF WARRANTY. THEY WOULD PUT IN A NEW STEERING ROD/ FRONT END ALIGNMENT/ VEHICLE SPEED SENSOR/ THROTTLE BODY ASSEMBLY/ AN AUTOMATIC TRANSMISSION, AND DRAIN AND REFILL THE COOLANT. *AK *JB
DT: 1999 VOLVO WAGON VXC. SUDDEN LOSS OF POWER . THE CAR DID NOT STALL EXCEPT AT A STOP SIGN WHEN GIVING IT A LOT OF GAS TO GET IT GOING. THIS HAPPENED INTERMITTENTLY FOR TWO MONTHS. TOOK VEHICLE TO DEALERSHIP, AND THEY SAID IT WOULD COST $1753.00 TO FIX IT. THE CAR IS OUT OF WARRANTY. THEY WOULD PUT IN A NEW STEERING ROD/ FRONT END ALIGNMENT/ VEHICLE SPEED SENSOR/ THROTTLE BODY ASSEMBLY/ AN AUTOMATIC TRANSMISSION, AND DRAIN AND REFILL THE COOLANT. *AK *JB
WHILE PULLING ONTO AN EXIT RAMP AT 45 MPH THERE WAS AN OVERHEATING SMELL IN THE CABIN OF THE VEHICLE, FOLLOWED BY THE VEHICLE STALLING. VEHICLE WAS TOWED TO AN AUTO REPAIR SHOP FROM THE EXIT RAMP THE FOLLOWING DAY. THE ENGINE SEVERELY OVERHEATED, THE EXPANSION TANK AND ENGINE COVER MELTED, AND THE RADIATOR WAS LEAKING AT THE SIDE TANK. RADIATOR LOOKED LIKE IT WAS DEFECTIVE. THE ENTIRE ENGINE WAS REPLACED. CONSUMER INDICATED THAT THIS FAILURE WAS RELATED TO COOLING FAN RECALL 04V451000, BUT THE VIN IS NOT INCLUDED.*AK...........*AK
WHILE PULLING ONTO AN EXIT RAMP AT 45 MPH THERE WAS AN OVERHEATING SMELL IN THE CABIN OF THE VEHICLE, FOLLOWED BY THE VEHICLE STALLING. VEHICLE WAS TOWED TO AN AUTO REPAIR SHOP FROM THE EXIT RAMP THE FOLLOWING DAY. THE ENGINE SEVERELY OVERHEATED, THE EXPANSION TANK AND ENGINE COVER MELTED, AND THE RADIATOR WAS LEAKING AT THE SIDE TANK. RADIATOR LOOKED LIKE IT WAS DEFECTIVE. THE ENTIRE ENGINE WAS REPLACED. CONSUMER INDICATED THAT THIS FAILURE WAS RELATED TO COOLING FAN RECALL 04V451000, BUT THE VIN IS NOT INCLUDED.*AK...........*AK