2019 VOLVO XC40 Problems & Recalls

The component that failed was the Brake pedal, it was unresponsive while driving on the freeway, it was hard to push and the vehicle would not come to a complete stop. My safety along with my daughter was put at risk due to nearly colliding into several vehicles due to not being able to stop vehicle...

Under Engine Cover came loose and fall during highway driving. It tuned out that 5 bolts that suppose to secure that cover were missing (per repair shop) . Fallen cover broke on few pieces and those pieces could impact breaking and vehicle instability causing incident with injuries and fatalities.

Under Engine Cover came loose and fall during highway driving. It tuned out that 5 bolts that suppose to secure that cover were missing (per repair shop) . Fallen cover broke on few pieces and those pieces could impact breaking and vehicle instability causing incident with injuries and fatalities.

The contact owns a 2019 Volvo XC40. The contact stated that the gear shifter knob had detached. The contact stated that the knob was not welded to the lever. The contact became aware that crazy glue had been used to secure the shifter knob. The contact stated that the vehicle failed to shift into ge...

Mileage: 42,000

Diagnostic code failure P0422 Evap system failure had emission testing done recently about two weeks ago . Car was service by Volvo in March 2024 and nonissues . Low mileage on car under 20k This should be recalled as many on online forums are having the same issue . Faulty manufacturing and Volvo...

Diagnostic code failure P0422 Evap system failure had emission testing done recently about two weeks ago . Car was service by Volvo in March 2024 and nonissues . Low mileage on car under 20k This should be recalled as many on online forums are having the same issue . Faulty manufacturing and Volvo...

Both front coil springs broke with under 30,000 miles on vehicle. No warning, just a thump thump.. broken springs could have punctured the front tires. Repair costly!

Air bag not functioning related to seatbelt failure. Will not tighten on sudden stops.

Air bag not functioning related to seatbelt failure. Will not tighten on sudden stops.

I stopped at a gas station and the fuel door would not open. I tried multiple times locking and unlocking the vehicle with the key fob. As I was driving home, I stopped at three other gas stations. All three times, I still could not open the fuel door. This happened when I initially purchased the ca...

My 2019 volvos' xc40 center console has been glitching and blacking out while driving. I rely on this system to navigate and when it blacks out, it does not resume operation till I restart my car. I mentioned this while getting my car serviced and was told I needed to pay a $250 fee to get my system...

While entering a parking spot my car suddenly accelerated and crashed into the wall in front of me in spite of my pushing my brakes 100%. The car never went into the automatic braking system before I applied the brakes, the seat belt never engaged and the air bags on the driver's side did not deplo...

While entering a parking spot my car suddenly accelerated and crashed into the wall in front of me in spite of my pushing my brakes 100%. The car never went into the automatic braking system before I applied the brakes, the seat belt never engaged and the air bags on the driver's side did not deplo...

While entering a parking spot my car suddenly accelerated and crashed into the wall in front of me in spite of my pushing my brakes 100%. The car never went into the automatic braking system before I applied the brakes, the seat belt never engaged and the air bags on the driver's side did not deplo...

I was involved in an accident with my 2019 Volvo xc40. I believe the cause of the accident was due to the emergency braking system that activated when I hit water that accumulated on the road I was traveling. I was accelerating and the braking caused the vehicle to swerve uncontrollably resulting ...

Front seat belts came on suddenly while stopped at light. Bruised front passengers neck. No car in front or near in rear.

The first incident happened back in Oct 2022. I took the car to local Volvo dealer, Rusnak Pasadena, and they said I needed the secondary battery replaced. They replaced it and the car worked for a few weeks until the alarm regarding the power steering failure came on again while my wife was turn...

The contact owns a 2019 Volvo XC40. The contact stated while driving at various speeds, while his wife was seated in the passenger’s side front seat using an orthopedic back support, the air bag warning light illuminated. The contact stated that while not using the back support, the air bag sensor...

Mileage: 26,000

The vehicle has approximately 16,000 miles on it. It began to shudder in the front end when the brakes were applied at any speed. I contacted the dealer, Parkway Volvo of Wilmington, NC concerning the problem and was told that the vehicle had just gone out of warranty. On December 16, 2022, I took t...

Earlier today I submitted a complaint, NHTSA Tracking Number 11498747. Would it be possible to send this back to me as I would prefer to modify it? Please do not post it now. Thanks, Craig Wenger [email protected] 910-471-7653

Driver was stuck on ice pulling into a driveway, car got traction and driver thought they were on the brake but was on the gas. The vehicle ran into the garage going 9.9 mph (we have the EDR) and the steering wheel airbag and knee airbags deployed. The knee airbag caused a significant compound fra...

I WAS BACKING OUT OF MY DRIVEWAY AND MY BACKUP ALARM FAILED TO SOUND AS WELL AS MY BACKUP BREAKING SYSTEM. THE RESULT WAS ME BACKING UP INTO A PARKED VEHICLE. THE FAILURE OF THE SYSTEM WAS REPORTED TO THE VOLVO DEALERSHIP AND THEY DENIED THAT THE SYSTEM WAS NOT WORKING PROPERLY. SEVERAL MONTHS LATER...

Mileage: 137

VOLVO'S PILOT ASSIST SYSTEM DISENGAGES WITHOUT ANY WARNING OR ALARM. THIS HAPPENS WHENEVER LANE MARKINGS ARE NOT VISIBLE OR IF THE CAMERA SYSTEM IS BLOCKED BY SUNSHINE. HOWEVER, IN ANY SCENARIO, THE PILOT ASSIST SYSTEM MUST ALERT DRIVER IF IT'S DISENGAGING. THE SYSTEM DISENGAGED MULTIPLE TIMES WITHO...

Mileage: 17,200

VEHICLE SHUT DOWN AND SHOWED 'SAFETY MODE SEE OWNERS MANUAL' AFTER SUSTAINING MINOR FRONT END DAMAGE IN A COLLISION WITH A DEER. UNABLE TO MOVE VEHICLE TO A SAFE STOPPING LOCATION ON A RURAL INTERSTATE FOR APPROXIMATELY 2 MINUTES UNTIL 'SAFETY MODE' EVENTUALLY RESET AND ALLOWED LIMP-HOME POWER. TH...

Mileage: 5,400

VEHICLE SHUT DOWN AND SHOWED 'SAFETY MODE SEE OWNERS MANUAL' AFTER SUSTAINING MINOR FRONT END DAMAGE IN A COLLISION WITH A DEER. UNABLE TO MOVE VEHICLE TO A SAFE STOPPING LOCATION ON A RURAL INTERSTATE FOR APPROXIMATELY 2 MINUTES UNTIL 'SAFETY MODE' EVENTUALLY RESET AND ALLOWED LIMP-HOME POWER. TH...

Mileage: 5,400

VEHICLE SHUT DOWN AND SHOWED 'SAFETY MODE SEE OWNERS MANUAL' AFTER SUSTAINING MINOR FRONT END DAMAGE IN A COLLISION WITH A DEER. UNABLE TO MOVE VEHICLE TO A SAFE STOPPING LOCATION ON A RURAL INTERSTATE FOR APPROXIMATELY 2 MINUTES UNTIL 'SAFETY MODE' EVENTUALLY RESET AND ALLOWED LIMP-HOME POWER. TH...

Mileage: 5,400

TL* THE CONTACT OWNS A 2019 VOLVO XC40. THE CONTACT STATED THAT THE FORWARD COLLISION AVOIDANCE FEATURE FAILED TO OPERATE PROPERLY. WHILE SLOWING THE VEHICLE DOWN TO 20 MPH, THE VEHICLE WOULD BEGIN ACCELERATING INDEPENDENTLY. ALL THE WARNING INDICATORS STARTED TO ILLUMINATE, A BEEPING NOISE OCCURRED...

Mileage: 2,000

MY CAR HAS LESS THAN THREE THOUSAND MILES ON IT AND WAS PURCHASED IN LATE MAY 2019. I WAS AT A STOP LIGHT WHEN SUDDENLY, I HEARD A LOUD BUZZ AND THE CAR STOPPED AND STARTED COMPLETELY ON ITS OWN. IT HAPPENED AGAIN AT THE NEXT TRAFFIC LIGHT, ONLY THIS TIME, IT KEPT SHUTTING OFF AND RESTARTING. THE DE...

Mileage: 2,700

MY CAR HAS LESS THAN THREE THOUSAND MILES ON IT AND WAS PURCHASED IN LATE MAY 2019. I WAS AT A STOP LIGHT WHEN SUDDENLY, I HEARD A LOUD BUZZ AND THE CAR STOPPED AND STARTED COMPLETELY ON ITS OWN. IT HAPPENED AGAIN AT THE NEXT TRAFFIC LIGHT, ONLY THIS TIME, IT KEPT SHUTTING OFF AND RESTARTING. THE DE...

Mileage: 2,700

CHECK ENGINE EMISSIONS LIGHT KEEPS COMING ON; HAVE HAD 3 SERVICE VISITS TO DEALER (RESULTING IN SAME PART BEING REPLACED TWICE, ONE OR MORE SOFTWARE UPDATES, ONE COMPLETE SOFTWARE RELOAD) AND NOW AM GETTING LIGHT ON AGAIN WHICH WILL REQUIRE YET A FOURTH SERVICE VISIT. (NB VISIT 1 WAS IN SUMMER '18 W...

THE VOLVO INTELLISAFE SYSTEM AUTOMATICALLY APPLIED THE BRAKES WHEN THERE WAS NOTHING IN FRONT OF THE VEHICLE TO BRAKE FOR. IT HAS DONE THIS 8 TIMES, 3 TIMES AFTER I HAD THE CAR IN TO REPAIR THIS PROBLEM. IT ALSO THOUGHT THERE WAS A REAR COLLISION EMINENT AND TIGHTENED THE SEAT BELT SO MUCH IT INJU...

Mileage: 5,110

THE VOLVO INTELLISAFE SYSTEM AUTOMATICALLY APPLIED THE BRAKES WHEN THERE WAS NOTHING IN FRONT OF THE VEHICLE TO BRAKE FOR. IT HAS DONE THIS 8 TIMES, 3 TIMES AFTER I HAD THE CAR IN TO REPAIR THIS PROBLEM. IT ALSO THOUGHT THERE WAS A REAR COLLISION EMINENT AND TIGHTENED THE SEAT BELT SO MUCH IT INJU...

Mileage: 5,110

I HAVE A NEW VOLVO XC40 WITH THE SEMI-AUTONOMOUS DRIVER ASSIST PACKAGE THAT CAN STEER AND CONTROL THE CAR. THE SYSTEM CAN SHUT OFF WHILE DRIVING ON THE HIGHWAY (ACTIVE MODE) FOR 2 REASON: 1. DRIVER TAKES HANDS OFF THE STEERING WHEEL FOR MORE THAN 15-20 SECONDS 2. SYSTEM CAMERAS CAN NOT ADEQUAT...

Mileage: 6,000

PILOT ASSIST FUNCTION DISENGAGES SUDDENLY WITHOUT WARNING. THIS IS DIFFERENT FROM THE EXPECTED OPERATION WHERE THE SYSTEM'S STEERING ASSISTANCE WILL GO INTO STANDBY UPON LOSING LANE MARKING INPUTS. WHILE THE SYSTEM DOES OCCASIONALLY ENTER NORMAL 'STANDBY' INDICATED BY THE GREEN STEERING WHEEL ICON T...

Mileage: 5,000

PILOT ASSIST FUNCTION DISENGAGES SUDDENLY WITHOUT WARNING. THIS IS DIFFERENT FROM THE EXPECTED OPERATION WHERE THE SYSTEM'S STEERING ASSISTANCE WILL GO INTO STANDBY UPON LOSING LANE MARKING INPUTS. WHILE THE SYSTEM DOES OCCASIONALLY ENTER NORMAL 'STANDBY' INDICATED BY THE GREEN STEERING WHEEL ICON T...

Mileage: 5,000

TL* THE CONTACT OWNS A 2019 VOLVO XC40. WHILE DRIVING VARIOUS SPEEDS WITH THE PILOT ASSIST FEATURE ACTIVATED, THE VEHICLE DRIFTED INTO THE OPPOSITE LANE AND WOULD ERRONEOUSLY CHANGE LANES. THE VEHICLE WAS TAKEN TO VOLVO OF TAMPA (6008 NORTH DALE MABRAY HWY, TAMPA, FL) TO BE DIAGNOSED, BUT THE CAUSE ...

Mileage: 1,450

AFTER LESS THAN 2 MONTHS AIR BAG SYSTEM FAILED AT ONLY 2400 MILE MARK. SUGGEST ENTIRE BRAND BE RECALLED SINCE IT IS A NEW MODEL IT WAS NOT TESTED PROPERLY. I AM IN DANGER AND AFRAID TO DRIVE THE CAR

Mileage: 2,400

AFTER LESS THAN 2 MONTHS AIR BAG SYSTEM FAILED AT ONLY 2400 MILE MARK. SUGGEST ENTIRE BRAND BE RECALLED SINCE IT IS A NEW MODEL IT WAS NOT TESTED PROPERLY. I AM IN DANGER AND AFRAID TO DRIVE THE CAR

Mileage: 2,400

AFTER LESS THAN 2 MONTHS AIR BAG SYSTEM FAILED AT ONLY 2400 MILE MARK. SUGGEST ENTIRE BRAND BE RECALLED SINCE IT IS A NEW MODEL IT WAS NOT TESTED PROPERLY. I AM IN DANGER AND AFRAID TO DRIVE THE CAR

Mileage: 2,400

I WAS AT THE DENVER CAR SHOW AND LOOKED AT THIS MODEL. WITH THE REAR HATCH UP THE REAR SEATS CAN BE FOLDED DOWN VIA A BUTTON/LATCH WHEN REACHING IN TO THE BACK. THE REP DEMONSTRATED THIS MANEVER AND THE SEATS RELEASED SO FORCEFULLY WITH A SLAM THAT IT COULD (AND EVENTUALLY WILL) INJURE OR KILL A CH...

Mileage: 11