2012 VOLVO XC60 Problems & Recalls

Four tires purchased June 2022. As of July 2025 with 17,500 miles on the tires there is ozone/weather cracking on the entire tire and the sidewall near the rim is failing with the cord visible on one tire.

The contact owns a 2012 Volvo XC60. The contact stated that while it was raining, water seeped through the driver's side front windshield and onto the steering wheel. The contact placed a towel on top of the steering wheel to prevent water from damaging the electrical system. The vehicle was not dia...

Mileage: 61,174

The windshield leaks constantly. I'm worried about the windshield blowing out or electrical components being damaged. This seems to be a constant complaint according to internet search. Why hasn't this been addressed as a safety issue and a recall ordered?

During rain, water is leaking inside the car from the driver’s side windshield while I’m driving, obstructing my vision.

It was explained to me that since the Back rear seat in the Volvo XC60 seatbelt had a fault that it alerted the SRS airbag system. In event of a crash the airbags in my car would not deploy and that the only remedy was to replace the entire seatbelt in the Volvo. To prove this point I took my car i...

It was explained to me that since the Back rear seat in the Volvo XC60 seatbelt had a fault that it alerted the SRS airbag system. In event of a crash the airbags in my car would not deploy and that the only remedy was to replace the entire seatbelt in the Volvo. To prove this point I took my car i...

It was explained to me that since the Back rear seat in the Volvo XC60 seatbelt had a fault that it alerted the SRS airbag system. In event of a crash the airbags in my car would not deploy and that the only remedy was to replace the entire seatbelt in the Volvo. To prove this point I took my car i...

On October 12, 2022 while driving home from the Schar Cancer Center in Fairfax, my 2012 Volvo XC60 experienced an end of life event. My check engine light came on when I entered my neighborhood. The car began sputtering and the gas pedal was delayed and at times, unresponsive. I was able to make it ...

A faulty radiator anti-tamper device caused loss of communication to the engine control computer. The check engine light turns on and “charging failure-service urgent” message pops up during driving. Which cause the drivers worry even panic. I talked to local dealer several times. I was told to ...

"Failure Charging" warning advisory light came on the dashboard. This problem has been going on for the whole ten years I have owned this vehicle. I am the original owner of this Volvo and had some engine warning on the dashboard since the first month. I took vehicle in to the Culver City Volvo for ...

The front windshield was not properly sealed during manufacturing and is now leaking when it rains. Water drips down the inside of the windshield in front of the driver resulting in distraction and poor visibility. I also fear that in an accident the windshield would not perform as it should and wou...

Lately my vehicle has been shutting off power when I hard right turn during parking everything shut off then I have to restart it again, but the scary part was what happened this morning I was driving on interstate and as I was charging lanes it almost powered off again but it picked up.

The windshield was not sealed properly during manufacturing because of a problem with the sealant used. This has caused a leak from the windshield on both the driver and passenger side from the top of the windshield when it rains. This creates lowered visibility when driving with water on the inside...

Manufacturers original windshield began leaking. On inspection windshield is not properly bonded or adhered to vehicle body and is able to be pushed off the body of the vehicle with little pressure from the inside of the cabin. Windshield repair company advised me to look for a recall notice they we...

Original front windshield separating from frame of car. Leaking water during rain / melting snow. In cold weather forms ICE/FROST on INTERIOR posing visibility hazard! Autobody worker showed me how the windshield MOVED when he pushed on it with nothing more than his hand - warned me this is also a ...

Our 2012 Volvo XC60 has a problem with the seal along the top of the windshield, which allows water into the interior of the car. It can end up dripping onto my lap while driving, which is distracting and a potential safety issue, and it also can obstruct visibility as water runs down the inside of...

During heavy rains and movement there is water leaking into the vehicle along the top drivers inside of the windshield. It also drips onto the steering wheel which often startles me while actively driving. The windshield has no cracks and is the original windshield.

There is a steady leak in the top left (driver side) of the windshield. Heard from the Tom Wood service and collision department that this is a common problem with these vehicles.

When it rains or I go through the car wash the windshield leaks water that runs down the inside of the glass and has stained the headliner

When it rains or when getting a car wash, the windshield leaks water into car.

The rain water leaking through windshield. It could cause rust in the frame, then cause the failure of whole structure. I checked the Volvo forums, seems there are many Volvo owners have similar issues. I owned other cars, it’s the first time I had leaking water through perimeter of windshield.

My volvo windshield started leaking from the top seal. When it rains water runs down the entire inside of the front windshield.

My left front door failed to open using the outside handle. I have tried unsuccessfully to fix the problem by removing the inside door panel, the door window, and the surrounding hardware and electrical components. I contend that this is a safety hazard because a)a rescuer would fail to get the dr...

Windshield seal failed causing water to leak into car

SEVERE INTERIOR WATER LEAK FROM TOP OF WINDSHIELD WHENEVER IT RAINS, DURING A CARWASH, ETC. - CREATING VISIBILITY PROBLEMS FOR THE DRIVER & A RESULTING SAFETY HAZARD SINCE THE WINDSHIELD IS NOT SUITABLY SEALED. THE VEHICLE HAS BEEN GARAGE PARKED, NEVER BEEN IN ANY TYPE OF COLLISION, AND NEVER BEEN D...

THE FUEL GAUGE SHOWS NO FUEL EVEN WHEN FULL OR AT TIMES SHOWS ABOUT 1/3 FULL EVEN WHEN FULL. AND DOES NOT DECREASE - ALLOWING FOR POSSIBLE RUNNING OUT OF GAS- CAUSING A ROAD HAZARD

Mileage: 114,000

THE FUEL GAUGE SHOWS NO FUEL EVEN WHEN FULL OR AT TIMES SHOWS ABOUT 1/3 FULL EVEN WHEN FULL. AND DOES NOT DECREASE - ALLOWING FOR POSSIBLE RUNNING OUT OF GAS- CAUSING A ROAD HAZARD

Mileage: 114,000

WINDSHIELD SEALING PROBLEM. WATER IS LEAKING THRU TOP OF THE WINDSHIELD.

2012 VOLVO XC60. CONSUMER WRITES IN REGARDS TO SOFTWARE PATCH. *LD THE CONSUMER STATED THE XM RADIO DRAINED THE VEHICLE'S BATTERY. THE COSUMER REQUESTED TO HAVE THE SOFTWARED UPDATE PERFORMED FOR FREE. THE DEALER DECLINED. *JS

THE VEHICLE'S WINDSHIELD HAS BEEN LEAKING WATER THROUGH THE TOP OF THE DASHBOARD. WHEN IT RAINS, THE WINDSHIELD LEAKS ALL OVER. I HAVE BEEN FOLLOWING FORUMS AND IT IS A COMMON PROBLEM IN THIS PARTICULAR MODEL OF VOLVO BUT HAS NOT BEEN A RECALL. IF THIS CONTINUES I'M AFRAID SOMEONE DRIVING COULD LOOS...

Mileage: 102,000

I BOUGHT MY XC60 IN 2012 FROM GERALD JONES VOLVO IN EVANS, GA. APPROXIMATELY IN 2017 MY WIFE NOTICE WATER COMING INSIDE THE CAR FROM THE WINDSHIELD ON THE DRIVER'S SIDE. AT THAT TIME, I HAD THE DEALERSHIP LOOK AT THE WINDSHIELD AND SUNROOF. THEY FOUND NOTHING WRONG. THE WATER CONTINUED TO LEAK I...

Mileage: 60,000

OVER A PERIOD OF THE LAST 45 DAYS ON TWO SEPARATE OCCASIONS,IN RAIN, AT HIGHWAY SPEED OF 55MPH+, THE OVERALL PERFORMANCE OF THE DRIVER INPUTS FAILED TO FUNCTION. WHEN DRIVING, TURNING THE WHEEL TO LEFT/RIGHT TO CHANGE LANES OR PULL TO THE SLOW LANE; MADE THE CAR FEEL AS IT WANTED TO SPIN OUT UNCONTR...

Mileage: 57,500

OVER A PERIOD OF THE LAST 45 DAYS ON TWO SEPARATE OCCASIONS,IN RAIN, AT HIGHWAY SPEED OF 55MPH+, THE OVERALL PERFORMANCE OF THE DRIVER INPUTS FAILED TO FUNCTION. WHEN DRIVING, TURNING THE WHEEL TO LEFT/RIGHT TO CHANGE LANES OR PULL TO THE SLOW LANE; MADE THE CAR FEEL AS IT WANTED TO SPIN OUT UNCONTR...

Mileage: 57,500

OVER A PERIOD OF THE LAST 45 DAYS ON TWO SEPARATE OCCASIONS,IN RAIN, AT HIGHWAY SPEED OF 55MPH+, THE OVERALL PERFORMANCE OF THE DRIVER INPUTS FAILED TO FUNCTION. WHEN DRIVING, TURNING THE WHEEL TO LEFT/RIGHT TO CHANGE LANES OR PULL TO THE SLOW LANE; MADE THE CAR FEEL AS IT WANTED TO SPIN OUT UNCONTR...

Mileage: 57,500

DURING RAIN, THE DRIVER'S SIDE OF THE WINDSHIELD LEAKS. WITH RESEARCH OF THE ISSUE, MANY PEOPLE HAVE COMPLAINED. THE PROBLEM IS PRESENT DUE TO A PRIMER ON THE GLASS THAT IS FAILING. THIS BLACK PRIMER IS APPLIED IN A THIN LAYER TO THE WINDSHIELD. THE ADHESIVE BEING USED BY VOLVO, REQUIRES THIS PRIMER...

Mileage: 85,000

I HAVE A 2012 VOLVO XC60 WITH AN ADHESIVE FAILURE AT THE TOP OF THE WINDSHIELD THAT IS APPARENTLY CAUSED BY A MANUFACTURING DEFECT THAT VOLVO HAS YET TO TAKE RESPONSIBILITY FOR REPAIRING AT THEIR DEALERSHIPS. THIS IS A SAFETY HAZARD. ACCORDING TO VOLVO: "THE WINDSHIELD IS ONE OF THE MOST IMPORTA...

TL* THE CONTACT OWNS A 2012 VOLVO XC60. WHILE OPERATING THE VEHICLE IN THE RAIN, WATER LEAKED FROM THE DRIVER'S SIDE WINDSHIELD AND MADE CONTACT WITH THE DRIVER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 98,000. THE VIN WA...

Mileage: 98,000

WATER DRIPS FROM TOP OF WINDSHIELD INTO CAR AS FAST AS IT COMES DOWN. DRAINS INTO LIGHTS FIXTURES AS WELL AS GEARS AND WHEEL. FOGGED UP GLASS ON HIGHWAY CAUSING SERIOUS SAFETY CONCERN. IN WINTER CAUSED GEARS TO FREEZE IN PARK. WATER POOLED IN BOTTOM OF CAR AND IN LIGHT FIXTURES. WATER IN SUNROOF CON...

Mileage: 75,000

WATER DRIPS FROM TOP OF WINDSHIELD INTO CAR AS FAST AS IT COMES DOWN. DRAINS INTO LIGHTS FIXTURES AS WELL AS GEARS AND WHEEL. FOGGED UP GLASS ON HIGHWAY CAUSING SERIOUS SAFETY CONCERN. IN WINTER CAUSED GEARS TO FREEZE IN PARK. WATER POOLED IN BOTTOM OF CAR AND IN LIGHT FIXTURES. WATER IN SUNROOF CON...

Mileage: 75,000

THE FRONT WINDSCREEN / WINDSHIELD BONDING HAD FAILED WITHIN THE FIRST COUPLE OF YEARS OF OWNERSHIP OF THE VEHICLE. THIS WAS NOT KNOWN AT THE TIME, MISDIAGNOSED BY THE MANUFACTURER, AND ONLY RECENTLY IDENTIFIED BY A 3RD PARTY. THIS IS APPARENTLY A COMMON ISSUE ENCOUNTERED AND HAS LED TO, ACCORDING TO...

MY WINDSHIELD STARTED LEAKING ON THE DRIVER SIDE DURING A HEAVY RAIN STORM. WATER WAS DRIPPING IN STREAMS AND IMPEDED VISIBILITY. I HAD IT EVALUATED AND THERE IS A BREAK IN THE FACTORY SEAL. THE WINDSHIELD IS ORIGINAL EQUIPMENT. THE VEHICLE HAS NOT BEEN IN ANY ACCIDENTS OR HAD ANY INJURIES. I SEE T...

Mileage: 71,000

MY ISSUE IS RELATED TO THE CONSTANT CORROSION PROBLEMS ON TPS THAT LEAD TO MULTIPLE REPLACEMENTS ON MY VEHICLE. IT WAS DISCOVERED DURING SEMI ANNUAL CHANGEOVER OF WINTER AND SUMMER TIRES, WHERE ONE OF THE WHEELS AND TIRES DEFLATED DUE TO CORROSION OF THE TPS. COSTLY PART THAT IS LIKELY DEFECTIVE I...

Mileage: 13,000

WATER LEAKING INTO INTERIOR FROM WINDSHIELD. I'VE TAKEN IT TO THE VOLVO DEALERSHIP AND THEY WON'T FIX IT DUE TO BEING OUT OF WARRANTY. SAFELITE WANTS $350-$800 TO RESEAL OR REPLACE THE WINDSHIELD. THE LEAK IS MAKING IT DANGEROUS TO DRIVE IN WET WEATHER AS IT DRIPS ONTO THE STEERING WHEEL AND ONTO TH...

Mileage: 84,000

ADHESIVE FAILURE TO THE WINSHIELD GLASS SURFACE

THE AXLES ARE ALREADY NEEDING TO BE REPLACED ON THE FRONT WHEELS. THERE IS ONLY 68,000 MILES ON THEM. THE AUTO SHOP SAYS IT'S TOO EARLY FOR THAT TO BE HAPPENING. NOT TO MENTION THERE IS A WHOPPING PRICE TAG FOR THE PARTS!!

I WAS IN AN ACCIDENT DRIVING ON A HIGHWAY DRIVING MY VOLVO XC60. I WAS TRAVELING AT APPROX 100KM/H AND RAN INTO THE BACK OF A SEMI THAT WAS TRAVELING AT AN APPROX SPEED OF 80KM/H. THE IMPACT WAS IN THE RIGHT FRONT (PASSENGER) SIDE OF MY XC-60 AND THE LEFT REAR OF THE SEMI. THE AIRBAGS FAILED TO DE...

Mileage: 49,000

I WAS IN AN ACCIDENT DRIVING ON A HIGHWAY DRIVING MY VOLVO XC60. I WAS TRAVELING AT APPROX 100KM/H AND RAN INTO THE BACK OF A SEMI THAT WAS TRAVELING AT AN APPROX SPEED OF 80KM/H. THE IMPACT WAS IN THE RIGHT FRONT (PASSENGER) SIDE OF MY XC-60 AND THE LEFT REAR OF THE SEMI. THE AIRBAGS FAILED TO DE...

Mileage: 49,000

I WAS IN AN ACCIDENT DRIVING ON A HIGHWAY DRIVING MY VOLVO XC60. I WAS TRAVELING AT APPROX 100KM/H AND RAN INTO THE BACK OF A SEMI THAT WAS TRAVELING AT AN APPROX SPEED OF 80KM/H. THE IMPACT WAS IN THE RIGHT FRONT (PASSENGER) SIDE OF MY XC-60 AND THE LEFT REAR OF THE SEMI. THE AIRBAGS FAILED TO DE...

Mileage: 49,000

THE CAR USES AN EXCESSIVE AMOUNT OF ENGINE OIL. CHECK OIL LIGHT COMES ON WILL DRIVING CAUSING A POTENTIAL SAFETY HAZARD WHILE I FIND A SAFE LOCATION TO STOP AND ADD ENGINE OIL.

Mileage: 35,000

LAST EVENING WHEN TURNING A CORNER MY FINGER WAS CUT BY THE METAL PORTION OF THE STEERING WHEEL. WHEN I GOT HOME, I NOTICED THAT AT THE "6 O'CLOCK" POSITION THERE WAS SHARP METAL THAT HAS COME LOOSE AND THAT IS WHAT CUT MY FINGER. I DID SOME RESEARCH AND THIS IS A COMMON PROBLEM WITH THIS CA...

Mileage: 82,000

JUST BOUGHT THE CAR AND DROVE APPROXIMATELY 30 MILES AND THE TIRE PRESSURE MONITORING SYSTEM LIGHT CAME ON. DROVE ANOTHER 10 MILES HOME AND ARRANGED FOR AN APPOINTMENT WITH THE DEALER FOR CORRECTION/REPAIR. NOTICED THAT THE ERROR WARNING DID NOT COME ON INITIALLY AFTER VEHICLE WAS PARKED BUT, SEEM...

Mileage: 41,000

SUDDEN FAILURE OF THE POWER STEERING, AMONGST OTHERS, RIGHT IN THE MIDDLE OF A CROSSROADS. VERY DANGEROUS EMERGENCY STOPPING OF THE CAR, ENGINE STOPPED, ALL ALARMS ON, STEERING NEARLY IMPOSSIBLE TO USE WITHOUT POWER. HAD TO TOW THE VEHICLE TO SERVICE CENTER. VOLVO CLAIMS THIS IS NOTHING MORE THAN A...

Mileage: 3,800

SUDDEN FAILURE OF THE POWER STEERING, AMONGST OTHERS, RIGHT IN THE MIDDLE OF A CROSSROADS. VERY DANGEROUS EMERGENCY STOPPING OF THE CAR, ENGINE STOPPED, ALL ALARMS ON, STEERING NEARLY IMPOSSIBLE TO USE WITHOUT POWER. HAD TO TOW THE VEHICLE TO SERVICE CENTER. VOLVO CLAIMS THIS IS NOTHING MORE THAN A...

Mileage: 3,800

UNCONTROLLABLE ACCELERATION, OVERRIDING BRAKE: UNEXPLAINED ACCIDENT OCCURRED AS I HAD PULLED INTO ANGLE PARKING SLOT, FOOT ON BRAKE READY TO SHIFT TO "PARK" . SUDDENLY THE CAR UNEXPECTEDLY ACCELERATED FORWARD ABOUT 5 FEET AND LURCHED INTO THE WOODEN PARKING BARRIER THAT DELINEATES THE EDGE OF THE P...

Mileage: 800

UNCONTROLLABLE ACCELERATION, OVERRIDING BRAKE: UNEXPLAINED ACCIDENT OCCURRED AS I HAD PULLED INTO ANGLE PARKING SLOT, FOOT ON BRAKE READY TO SHIFT TO "PARK" . SUDDENLY THE CAR UNEXPECTEDLY ACCELERATED FORWARD ABOUT 5 FEET AND LURCHED INTO THE WOODEN PARKING BARRIER THAT DELINEATES THE EDGE OF THE P...

Mileage: 800

BLIND SPOT INFORMATION SYSTEM DOES NOT FUNCTION DURING INCLEMENT WEATHER. SYSTEM PROVIDES INCORRECT INFORMATION TO THE DRIVER ABOUT THE PRESENCE OF ANOTHER VEHICLE IN THE BLIND SPOT. I BELIEVE THIS INCREASES THE RISK OF ACCIDENT. *TR

Mileage: 100