2020 VOLVO XC90 Problems & Recalls
Detailed safety information and owner complaints
Problem Breakdown
Compare to Other Years
Common Problems
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within...
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can caus...
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far ...
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, th...
If a passenger or child in the second row attempts to open a door before/while the doors are unlocked, the interior AND exterior handles no longer function. This can be temporarily fixed by doing a complicated and long random series of enabling/disabling electronic child locks and unlocking and re-l...
If a passenger or child in the second row attempts to open a door before/while the doors are unlocked, the interior AND exterior handles no longer function. This can be temporarily fixed by doing a complicated and long random series of enabling/disabling electronic child locks and unlocking and re-l...
The contact owns a 2020 Volvo XC90. The contact stated while attempting to open the rear passenger's side door from the inside or the outside of the vehicle, the door failed to open as intended, causing passengers to exit the rear driver's side door of the vehicle. No warning light was illuminated. ...
Mileage: 71,000
The sunroof has leaked pouring water into the car. October 29, 2025 This is the second time this has occurred. First flood was January 3, 2023. Volvo covered the first repair done by a Volvo dealership. The current estimate to repair is $13,000 by the Volvo dealer. They have the car. The electronics...
The sunroof has leaked pouring water into the car. October 29, 2025 This is the second time this has occurred. First flood was January 3, 2023. Volvo covered the first repair done by a Volvo dealership. The current estimate to repair is $13,000 by the Volvo dealer. They have the car. The electronics...
The sunroof has leaked pouring water into the car. October 29, 2025 This is the second time this has occurred. First flood was January 3, 2023. Volvo covered the first repair done by a Volvo dealership. The current estimate to repair is $13,000 by the Volvo dealer. They have the car. The electronics...
The camera system when backing up becomes unavailable intermittently. Sometimes it works and sometimes it doesn’t. System has been updated and restarted but it fails to fix the issue. When it happens it states camera unavailable and service required. Shutting off the vehicle and restarting multipl...
The instrument panel just stopped working. Our safety and the safety of others was/is put at risk because you are unable to see how fast you are going in the car. It also doesn’t let us know how much gas we have left in the gas tank so if the car just stalled out on a highway, it could cause a maj...
The instrument panel just stopped working. Our safety and the safety of others was/is put at risk because you are unable to see how fast you are going in the car. It also doesn’t let us know how much gas we have left in the gas tank so if the car just stalled out on a highway, it could cause a maj...
The LED instrument panel will intermittently flicker or in some cases completely go out for extended periods of time making the vehicle unsafe to operate. The instrument panel in these instances is completely unusable and the driver is unable to see critical vehicle information such as speed, any wa...
The contact owns a 2020 Volvo XC90. The contact stated that after plugging in the charger to the vehicle, the cable charger started blinking red. The contact had to jumpstart the vehicle to open the doors. The blinking red light on the cable charger had not stopped blinking. The contact related the ...
Spontaneously the left back side door has failed to close on several occasions. It happened first while parked in the driveway and I had to use my body to get it shut. I went to have it checked out at the Volvo dealer and when I described it they told me several people had been in for service with t...
The instrument cluster display on my 2020 Volvo XC90 went completely out while driving my vehicle. This was a single point of failure and SAFETY ISSUE as it affected my speedometer, gas gauge, etc. I was driving without any functioning indicators on the highway when it went out. There was no advance...
The instrument cluster display on my 2020 Volvo XC90 went completely out while driving my vehicle. This was a single point of failure and SAFETY ISSUE as it affected my speedometer, gas gauge, etc. I was driving without any functioning indicators on the highway when it went out. There was no advance...
The sunroof of the vehicle started leaking water after 4 years of ownership. Upon bringing it to Volvo dealer, I am quoted $2500-3000 to fix and check for faulty electrical or mold in carpeting. This is a safety issue as the water could damage critical electrical components. This is a 2020 vehicle,...
The airbag system detected a fault and caused an automated vehicle warning message, which, with further dealer diagnosis, caused the driver seat belt to have a ground fault issue, preventing the normal, safe, and fully operating vehicle airbags. The cause and what must be replaced to rectify the pr...
The airbag system detected a fault and caused an automated vehicle warning message, which, with further dealer diagnosis, caused the driver seat belt to have a ground fault issue, preventing the normal, safe, and fully operating vehicle airbags. The cause and what must be replaced to rectify the pr...
The electrical rear axle system fails at around 39k miles in the Volvo XC90 with little notice. I purchased my pre owned 2020 XC90 recharge in Jan of 2023. The failure of the ERAD system Caused complete power failure instantly and the engine to cease operating at a high rate of speed (55mph) on the...
The vehicle shudders randomly when taking off from a stopped position around 18mph. The vehicle shudders randomly when slowing down to make a right turn. The vehicle shudders when driving at higher speeds. It's not a violent shudder, but those riding in the vehicle feel it as well. The safety ...
The vehicle shudders randomly when taking off from a stopped position around 18mph. The vehicle shudders randomly when slowing down to make a right turn. The vehicle shudders when driving at higher speeds. It's not a violent shudder, but those riding in the vehicle feel it as well. The safety ...
The vehicle shudders randomly when taking off from a stopped position around 18mph. The vehicle shudders randomly when slowing down to make a right turn. The vehicle shudders when driving at higher speeds. It's not a violent shudder, but those riding in the vehicle feel it as well. The safety ...
The issue started a few months ago. The brake sensor light on the dash turned on and stayed on. We took it to the dealer and they said that they will not fix it because they can see coffee stains on the sensor. Basically they have brake sensors right under the center console where people drink coffe...
The issue started a few months ago. The brake sensor light on the dash turned on and stayed on. We took it to the dealer and they said that they will not fix it because they can see coffee stains on the sensor. Basically they have brake sensors right under the center console where people drink coffe...
The contact owns a 2020 Volvo XC90. The contact stated that while his wife was driving at an undisclosed speed, the vehicle experienced unintended acceleration while the brake pedal was depressed, causing the vehicle to crash into a parked vehicle. The contact's wife did not sustain any injuries, an...
Mileage: 25,000
I need new rear brakes and rotors at 26,296. I have leased cars for the past twenty plus years and never had to replace brakes/rotors after a year and a half.
I was driving the speed limit on the highway in my Volvo 2020 XC90 which was less than one year old. The vehicle lost acceleration power and then an engine performance light came on, then a check engine light. I pulled over immediately and my car engine caught fire under the hood. The entire front o...
I was driving the speed limit on the highway in my Volvo 2020 XC90 which was less than one year old. The vehicle lost acceleration power and then an engine performance light came on, then a check engine light. I pulled over immediately and my car engine caught fire under the hood. The entire front o...
I was driving the speed limit on the highway in my Volvo 2020 XC90 which was less than one year old. The vehicle lost acceleration power and then an engine performance light came on, then a check engine light. I pulled over immediately and my car engine caught fire under the hood. The entire front o...
THE SPOILER COVER OVER THE THIRD BRAKE LIGHT CAME OFF ON I-95 IN THE MIDDLE OF THE FREEWAY FOR UNKNOWN REASONS.
PURCHASED A NEW 2020 XC90 T6 INSCRIPTION WITH THE AIR SUSPENSION. FROM THE FIRST TIME PULLING INTO OUR DRIVEWAY, THERE WAS A DISTINCT, MUFFLED, AGGRESSIVE "THUMP" IN THE FRONT AND REAR END. THE SOUND IS INDEPENDENTLY FROM THE FRONT OR REAR SUSPENSION, DEPENDING ON WHICH IS GOING OVER A BUMP. THIS OC...
Mileage: 300
ON FEBRUARY 5, 2020 I WAS INVOLVED IN A MINOR FENDER BENDER WHICH RESULTED WHEN I DROVE OFF ALIGHT AND THE CAR IN FRONT OF ME DID NOT TAKE OFF AND I HIT IT IN THE REAR AT A VERY LOW RATE OF SPEED. THE AUTO BRAKE DID NOT ENGAGE. I WAS NO MORE THAN ONE AND A HALF CAR LENGTHS BEHIND AND THE CAR WAS M...
Mileage: 4,500