This Problem Across All Years
To Whom It May Concern, I am submitting this complaint to report a repeated and unresolved safety defect in my leased Volvo vehicle involving rear passenger door lock failure, which has resulted in minor children being trapped inside the vehicle on multiple occasions Vehicle Safety Issue: The left rear passenger door fails to open from both inside and outside, despite the child lock not being engaged. This creates a serious safety risk, particularly during emergencies when occupants must exit the vehicle quickly. Incident History: [XXX]: Rear door would not open from inside or outside, trapping my two children (ages [XXX] and [XXX] ). At the same time, the infotainment system froze and the backup camera was not functioning. I reported this to Volvo service. [XXX]: The same issue occurred again, resulting in my children being locked in the rear seat. One child was experiencing leg pain, and it was extremely difficult and unsafe to remove him through the front door. The dealer stated the rear lock assembly was replaced. [XXX]: Despite prior repair and assurances, the rear door failed again, trapping my child inside the vehicle. I have video evidence showing the door cannot be opened from outside. In addition, on a separate occasion, the vehicle completely froze and could not be unlocked using either key. AAA was required to jump-start the vehicle, and I was informed that a required software installation had not occurred. Safety Concern: A rear passenger door that cannot be opened from inside or outside presents an immediate safety hazard, especially involving children, medical emergencies, accidents, or fire. A non-functional backup camera further increases the risk of injury while reversing. This issue has occurred three times, including after a component replacement, indicating a recurring defect rather than an isolated incident. I am reporting this issue so it can be reviewed for potential safety investigation and corrective action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI
To Whom It May Concern, I am submitting this complaint to report a repeated and unresolved safety defect in my leased Volvo vehicle involving rear passenger door lock failure, which has resulted in minor children being trapped inside the vehicle on multiple occasions Vehicle Safety Issue: The left rear passenger door fails to open from both inside and outside, despite the child lock not being engaged. This creates a serious safety risk, particularly during emergencies when occupants must exit the vehicle quickly. Incident History: [XXX]: Rear door would not open from inside or outside, trapping my two children (ages [XXX] and [XXX] ). At the same time, the infotainment system froze and the backup camera was not functioning. I reported this to Volvo service. [XXX]: The same issue occurred again, resulting in my children being locked in the rear seat. One child was experiencing leg pain, and it was extremely difficult and unsafe to remove him through the front door. The dealer stated the rear lock assembly was replaced. [XXX]: Despite prior repair and assurances, the rear door failed again, trapping my child inside the vehicle. I have video evidence showing the door cannot be opened from outside. In addition, on a separate occasion, the vehicle completely froze and could not be unlocked using either key. AAA was required to jump-start the vehicle, and I was informed that a required software installation had not occurred. Safety Concern: A rear passenger door that cannot be opened from inside or outside presents an immediate safety hazard, especially involving children, medical emergencies, accidents, or fire. A non-functional backup camera further increases the risk of injury while reversing. This issue has occurred three times, including after a component replacement, indicating a recurring defect rather than an isolated incident. I am reporting this issue so it can be reviewed for potential safety investigation and corrective action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOI
Several times a month the infotainment system on my car completely freezes. When this happens, my blinkers do not work, my CarPlay does not work, I cannot use voice commands, I cannot play the radio or answer calls, the backup and parking sensors do not make an audible sound. The only way to fix this is to hold down the home button to restart the entire system which does take a few minutes so not ideal to do while driving. Turning the car off and back on does not even fix it. This is an extreme safety issue, as when this happens I am driving without the use of blinkers until my system finishes restarting. Not only am I unable to use blinkers, but I am unable to make calls over Bluetooth or CarPlay which is incredibly dangerous in the event of an emergency. I am unable to park or backup and be able to hear the beep of the sensors. I cannot hear the audio of my gps. It happens out of the blue and is so unsafe.
Several times a month the infotainment system on my car completely freezes. When this happens, my blinkers do not work, my CarPlay does not work, I cannot use voice commands, I cannot play the radio or answer calls, the backup and parking sensors do not make an audible sound. The only way to fix this is to hold down the home button to restart the entire system which does take a few minutes so not ideal to do while driving. Turning the car off and back on does not even fix it. This is an extreme safety issue, as when this happens I am driving without the use of blinkers until my system finishes restarting. Not only am I unable to use blinkers, but I am unable to make calls over Bluetooth or CarPlay which is incredibly dangerous in the event of an emergency. I am unable to park or backup and be able to hear the beep of the sensors. I cannot hear the audio of my gps. It happens out of the blue and is so unsafe.
URGENT SAFETY CONCERN: Intermittent Total Loss of All Vehicle Audio Alerts This issue has occurred multiple times and poses a serious safety concern. While driving, the vehicle intermittently experiences a complete loss of all audio output. This includes: •Turn signal indicators •Hazard warning sounds •Blind spot monitoring alerts •Park distance control tones •Navigation guidance •Audio system playback (music, radio, etc.) •All other safety-related audio warnings and notifications The vehicle becomes completely silent, eliminating essential auditory cues that are critical for safe operation. Temporary Workaround (While Driving): The only way to restore functionality is by performing a forced reboot of the infotainment system. This requires the driver to press and hold the home button until the system power cycles—a distracting and unsafe action that must be done while the vehicle is in motion. Please note that while rebooting does not disable the vehicle’s ability to drive, it temporarily resets multiple core systems, including the climate control and infotainment interface. This creates a significant distraction and impairs the driver’s ability to safely monitor vehicle status and surroundings. This malfunction poses a significant safety risk and must be investigated immediately.
URGENT SAFETY CONCERN: Intermittent Total Loss of All Vehicle Audio Alerts This issue has occurred multiple times and poses a serious safety concern. While driving, the vehicle intermittently experiences a complete loss of all audio output. This includes: •Turn signal indicators •Hazard warning sounds •Blind spot monitoring alerts •Park distance control tones •Navigation guidance •Audio system playback (music, radio, etc.) •All other safety-related audio warnings and notifications The vehicle becomes completely silent, eliminating essential auditory cues that are critical for safe operation. Temporary Workaround (While Driving): The only way to restore functionality is by performing a forced reboot of the infotainment system. This requires the driver to press and hold the home button until the system power cycles—a distracting and unsafe action that must be done while the vehicle is in motion. Please note that while rebooting does not disable the vehicle’s ability to drive, it temporarily resets multiple core systems, including the climate control and infotainment interface. This creates a significant distraction and impairs the driver’s ability to safely monitor vehicle status and surroundings. This malfunction poses a significant safety risk and must be investigated immediately.
1. When the air condition is turned on there is knocking/banging/thumping noise. It starts with a whinning noise and then gets thumping noise and then starts again with a whinning noise followed my a thumping noise. It can go over 15 to 20 mins and then stops and restarts again. Yes, it can easily be reproduced. 2. The whinning and thumping noise while the car is driving can cause a safety issue where something could explode (the way it sounds) or air condition can simply not working as we approach summer. 3. Yes, its been reproduced, I've sent them the videos, i was at the dealership to reproduce and they acknowledge there is an issue. Weaver brother volvo had created an internal case to Volvo Technical Assistance, case number: RTS-US831535. The reply was they are aware about this issue and they are investigating it. The issues seems to be on the expansion valve and they are still investigating it. This was dated August 6th, 2024. 4. No warning lamps or messages or other symptoms. June 26th, 2024. The issue was reported to dealer around July, 25th 2024.
1. When the air condition is turned on there is knocking/banging/thumping noise. It starts with a whinning noise and then gets thumping noise and then starts again with a whinning noise followed my a thumping noise. It can go over 15 to 20 mins and then stops and restarts again. Yes, it can easily be reproduced. 2. The whinning and thumping noise while the car is driving can cause a safety issue where something could explode (the way it sounds) or air condition can simply not working as we approach summer. 3. Yes, its been reproduced, I've sent them the videos, i was at the dealership to reproduce and they acknowledge there is an issue. Weaver brother volvo had created an internal case to Volvo Technical Assistance, case number: RTS-US831535. The reply was they are aware about this issue and they are investigating it. The issues seems to be on the expansion valve and they are still investigating it. This was dated August 6th, 2024. 4. No warning lamps or messages or other symptoms. June 26th, 2024. The issue was reported to dealer around July, 25th 2024.
Air conditioning is not working within one month of purchase. In 110 degree heat in Arizona , this is a safety issue. This has also occured on another new volvo xc90 in Austin , Texas. At least two failures on brand new volvo xc90.
Air conditioning is not working within one month of purchase. In 110 degree heat in Arizona , this is a safety issue. This has also occured on another new volvo xc90 in Austin , Texas. At least two failures on brand new volvo xc90.