2002 WORKHORSE W22 Problems & Recalls

The contact owns a 2002 Workhorse W22 Chassis. The contact stated that while driving at an undisclosed speed, the brake pedal went to the floorboard while depressed. Additionally, the ABS warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 09V110000 (Service Brak...

Mileage: 21,000

WE JUST PURCHASED THIS MOTORHOME AND DURING MY INVESTIGATION FOR VARIOUS REPAIRS FOUND THERE WERE 2 RECALLS ON THIS COACH. ONLY 1ST OF THE 2 OF THE RECALLS WAS ADDRESSED WITH THE 2ND RECALL BEING A MORE INTENSE MODIFICATION OF THE 1ST. I AM NOW TRYING TO FIND OUT HOW TO GET THE 2ND RECALL IMPLEMENT...

1) THE MANUFACTURE, WINNEBAGO INDUSTRIES, EQUIPPED THE DRIVER "COCKPIT" OF THE VEHICLE WITH THERMOPANE WINDOWS WITH AN IDENTIFIED WEAKNESS. THE SEALS IN THE WINDOWS ARE INADEQUATE TO MAINTAIN SEAL INTEGRITY, THUS ALLOWING AIR INFILTRATION. SAID AIR INFILTRATION CAUSED FOGGING OF THE GLASS, AND AN AC...

TL* THE CONTACT OWNS A 2002 WORKHORSE W22. THE CONTACT STATED THAT THE ABS WARNING INDICATOR FLASHED AND REMAINED ILLUMINATED. IN ADDITION, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD, CREATING THE RISK OF A POTENTIAL CRASH. THE CONTACT HAD TO APPLY FORCE TO THE BRAKE PEDAL TO STOP ...

2002 DAMON INTRUDER ON A 2002 WORKHORSE W22 CHASSIS. CONSUMER STATES DEFECTIVE CALIPERS AND SEEKS REIMBURSEMENT FOR REPAIRS *TGW THE CONSUMER STATED THE ROTORS, SEALS, PADS AND HOSES ALSO HAD TO BE REPLACED. THE CONSUMER BELIEVED THE DEFECTIVE CALIPERS CAUSED DAMAGE TO THE OTHER BRAKE COMPONENTS. ...

NON-AVAILABILITY OF PARTS, NHTSA RECALL # EA02035. I HAVE TRIED TO MAKE AN APPT W/AN AUTHORIZED WORKHORSE CHASSIS SERVICE CENTER. THE TWO CENTERS NEAREST ME HAVE HAD THE CALIPER KITS ON ORDER FOR THE LONGEST TIME. I FEEL THAT WORKHORSE CUSTOM CHASSIS IS DRAGGING THEIR FEET WHEN SUPPLYING THE SERVICE...

Mileage: 14,000

2002 WORKHORSE W22 CHASSIS. CONSUMER WRITES IN REGARDS TO PROBLEMS WITH WORKHORSE BRAKES AND REQUESTS REIMBURSEMENT *TGW THE CONSUMER STATED THE FIRST PROBLEM HE ENCOUNTERED WITH THE RV WAS THE SMELL OF BURNING BRAKES WHICH WAS NOTICED IN 2004 AND THE REPAIRS WERE DONE DURING THE BOSCH BRAKE CALIP...

2002 WORKHORSE W22 CHASSIS. CONSUMER IS SEEKING REIMBURSEMENT FOR A TOWING BILL DUE TO PROBLEMS WITH WORKHORSE CUSTOM CHASSIS *TGW THE CONSUMER STATED THE BRAKES FAILED TO RELEASE WHILE DRIVING.*JB

2003 PACE ARROW MOTORHOME ON A 2002 WORKHORSE W22 CHASSIS. CONSUMER IS REQUESTING REIMBURSEMENT FOR BRAKE CALIPER REPLACEMENT SINCE THIS WAS A RECALL ISSUE FOR WORKHORSE W22 CHASSIS. *KB THE CONSUMER STATED AFTER THE RV WAS PURCHASED, THE ABS LIGHT ILLUMINATED AND THE BRAKE PEDAL WAS SOFT. BRAKE F...

TL*THE CONTACT OWNS A 2002 BOUNDER 36U RV EQUIPPED WITH A WORKHORSE CHASSIS W22. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 09V110000 (SERVICE BRAKES, HYDRAULIC). THE TECHNICIAN INFORMED THAT THE FRONT AND REAR ROTORS HAD SEVERE CRACKS SO BOTH ROTORS WERE REPLAC...

Mileage: 40,126

TL*THE CONTACT OWNS A 2002 WORKHORSE W22. WHILE CHANGING THE CALIPERS ON THE VEHICLE HE NOTICED THAT THERE WAS AN EXCESSIVE AMOUNT OF GREASE WITHIN THE MASTER CYLINDER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE BUT HE WAS INFORMED THE ENTIRE BRAKING SYSTEM...

Mileage: 88,000

2002 WORKHORSE W22 CHASSIS. CONSUMER WRITES REGARDING WORKHORSE RECALL *TGW THE CONSUMER STATED HE HAS BEEN UNABLE TO GET THE NECESSARY REPAIRS MADE TO HIS RV. THE CONSUMER IS SEEKING REIMBURSEMENT FOR PREVIOUS BRAKE REPAIRS. *JB

TL*THE CONTACT OWNS A 2003 NATIONAL DOLPHIN MOTOR HOME WITH A 2002 W22 WORKHORSE CHASSIS. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHEN THE BRAKES FAILED. THE BRAKE ROTORS, BRAKE PADS AND THE SEALS WERE REPAIRED AT THE CONTACTS EXPENSE. HE RECEIVED A RECALL NOTICE ON THE CALIPERS FROM WORKHORSE BUT...

Mileage: 40,000

TL*THE CONTACT OWNS A 2002 FLEETWOOD ARROW EQUIPPED WITH A WORKHORSE W22 CHASSIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR RECALL 04V084000 (SERVICE BRAKES, HYDRAULIC) ON OCTOBER 5, 2010. THE DEALER REPLACED THE CALIPERS AND ADVISED THE CONTACT THAT THE ROTORS AND BRAKE PADS NEEDED TO BE RE...

Mileage: 30,840

2002 WORKHORSE W22 CHASSIS. CONSUMER WRITES REGARDING BRAKE FAILURE *TGW THE CONSUMER STATED HE EXPERIENCED BRAKE FAILURE IN DECEMBER 2004. THE BRAKES WERE TEMPORARILY REPAIRED, BECAUSE ACCORDING TO THE REPAIR SHOP A RECALL WAS ISSUED, HOWEVER, THE RECALL PARTS WERE NOT AVAILABLE. IN DECEMBER 200...

TL*THE CONTACT OWNS A 2002 FLEETWOOD SOUTHWIND RV EQUIPPED WITH A 2002 WORKHORSE W22 CHASSIS. THE CONTACT STATED THAT THE SINCE THE DATE OF PURCHASE, THE ABS LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE LIGHT DID NOT INDICATE A FAI...

Mileage: 60,000

2002 WORKHORSE CHASSIS DOLPHIN MOTORHOME. CONSUMER STATES PROBLEMS WITH THE ENGINE STALLING *TGW THE CONSUMER STATED THE RV HAS BEEN REPEATEDLY TOWED, SERVICED AND EVEN REPAIRED ONLY TO ENCOUNTER THE SAME PROBLEM. THE ENGINE WOULD SUDDENLY STALL WITH NO WARNING. WITHIN A PERIOD OF 10 SECONDS, THE ...

TL*THE CONTACT OWNS A 2002 FLEETWOOD BOUNDER WITH WORKHORSE W22 CHASSIS. WHILE DRIVING APPROXIMATELY 50-55 MPH HE ENGAGED THE BRAKES AND SMELLED THE BRAKES BURNING. HE DROVE ONTO THE EMERGENCY LANE AND ALLOWED THE VEHICLE TO COOL OFF AND WAS FORCED TO ALLOW THE VEHICLE TO COOL DOWN SEVERAL TIMES BEF...

Mileage: 8,960

TL* THE CONTACT OWNS A 2000 WORKHORSE W22. WHILE DRIVING AT APPROXIMATELY 40 MPH PRESSURE WAS APPLIED TO THE BRAKE PEDAL AND THE STEERING WHEEL BEGAN TO SHAKE. THE ANTI LOCK BRAKE SERVICES LIGHT ALSO BEGAN TO ILLUMINATE ON THE DASHBOARD. THE RV WAS TAKEN TO AN AUTHORIZED DEALER WHERE HE WAS INFOR...

Mileage: 31,000

TL* THE CONTACT OWNS A 2002 WORKHORSE W22 RV. THE CONTACT STATED HIS VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 09V110000 (SERVICE BRAKES, HYDRAULIC). BOTH THE DEALER AND MANUFACTURER ADVISED THE PARTS NEEDED TO MAKE THE REPAIR WERE NOT AVAILABLE AND COULD NOT PROV...

Mileage: 14,179

2002 WORKHORSE W22 CUSTOM CHASSIS OWNER. CONSUMER EXPRESSES DISCONTENT REGARDING WORKHORSE ONLY TAKING PARTIAL FINANCIAL RESPONSIBILITY FOR FAULTY BRAKE SYSTEM REPAIRS *TGW THE CONSUMER STATED THE ABS ILLUMINATED AND THERE WAS A VIBRATION DURING BRAKING. THE RV WAS TAKEN TO A REPAIR SHOP, WHERE IT...

TL*THE CONTACT OWNS A 2002 FLEETWOOD PACE ARROW RV. THE VEHICLE WAS EQUIPPED WITH A WORKHORSE CHASSIS W22. WHILE THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 50-50 MPH, PRESSURE WAS APPLIED TO THE BRAKES WITH A DELAY RESPONSE. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION. THE FAILURE OCCURRED INT...

Mileage: 23,358

TL* THE CONTACT OWNS A 2002 WORKHORSE W22 CHASSIS RV. THE CONTACT STATED THAT HE RECEIVED NOTIFICATION OF NHTSA RECALL CAMPAIGN ID NUMBER 04V084000 (SERVICE BRAKES, HYDRAULIC) IN DECEMBER 2009, YET THE DEALER ADVISED THE PARTS NEEDED TO MAKE THE REPAIRS WERE NOT YET AVAILABLE. THE MANUFACTURER STAT...

Mileage: 18,000

2002 WORKHORSE W22 CHASSIS RV. *DT THE CONSUMER STATED THE BRAKES ON THE RV LOCKED UP AND IS SEEKING REIMBURSEMENT SINCE A RECALL HAD BEEN ISSUED.

2002 HOLIDAY RAMBLER. WORKHORSE W22 CHASSIS 2002. CONSUMER STATES PROBLEMS WITH THE BRAKES. *TGW THE CALIPERS AND ROTORS HAD TO BE REPLACED TWICE. WORKHORSE STATED THEY DIDN'T HAVE THE PROPER PARTS TO FIX THE PROBLEM. THEY PAID FOR HAVING THE PROBLEM FIXED THE FIRST TIME, BUT THEY REFUSED TO PAY ...

FAULTY BRAKING SYSTEM ON WORKHORSE RV CHASSIS ABS ANTILOCK SYSTEM. *TR

Mileage: 54,000

MULTI-FAILURES OF THE BRAKING SYSTEM ON MY 2002 WORKHORSE W-22 CHASSIS. ALL FOUR CALIPERS HAVE BEEN REPLACED AS WELL AS FRONT WHEEL BEARING AND SEALS DUE TO THE EXTREME HEAT GENERATED WHEN THE SYSTEM FAILED. THIS OCCURRED IN JULY 1ST 2007, JULY 23,2007 AND FEB. 4 2008, .WHEN FAILURES OCCURRED THE...

Mileage: 15,635

MULTI-FAILURES OF THE BRAKING SYSTEM ON MY 2002 WORKHORSE W-22 CHASSIS. ALL FOUR CALIPERS HAVE BEEN REPLACED AS WELL AS FRONT WHEEL BEARING AND SEALS DUE TO THE EXTREME HEAT GENERATED WHEN THE SYSTEM FAILED. THIS OCCURRED IN JULY 1ST 2007, JULY 23,2007 AND FEB. 4 2008, .WHEN FAILURES OCCURRED THE...

Mileage: 15,635

WORKHORSE W22 CHASSIS. 2002 FLEETWOOD BOUNDER. CONSUMER EXPRESSES DISCONTENT WITH DATE OF RECALL AS HIS PROBLEMS BEGAN ONE MONTH PRIOR. *TGW THE CONSUMER STATED HE DID DETECT A BURNING ODOR ON SEVERAL OCCASIONS. THE CONSUMER WAS INFORMED HE NEEDED NEW CALIPERS, THE ABS AND REAR BRAKES WERE HEAVIL...

NOVEMBER 16, 2007 EA07016 WAS OPENED. I STILL (2/24/2010) CAN'T USE MY VEHICLE AS WORKHORSE HAS NOT SCHEDULED ANY REPAIRS YET. WHY ARE YOU LETTING THEM GET AWAY WITH THIS. THE PROBLEM IS KNOWN AND IS A SAFETY ISSUE. *TR

Mileage: 30,000

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 CHASSIS RECREATIONAL VEHICLE. HE STATED HE RECEIVED A RECALL LETTER FOR HIS VEHICLE IN APRIL 2009 INVOLVING SERVICE BRAKES (SEE NHTSA ACTION NUMBER: EA07016, NHTSA CAMPAIGN ID NUMBER: 09V110000: SERVICE BRAKES-HYDRAULIC). THE RECALL STATED A REMEDY WAS CURREN...

TL*THE CONTACT OWNS A 2002 HOLIDAY RAMBLER. THE VEHICLE WAS BUILT ON A WORKHORSE CHASSIS W22. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH ON NORMAL ROAD CONDITIONS WHEN THE BRAKE PEDAL TRAVELED TO THE FLOOR WITHOUT RESISTANCE. PRESSURE WAS APPLIED, THERE WERE SEVERAL ATTEMPTS BEFORE THE VEHICLE SLO...

Mileage: 46,000

TL* THE CONTACT OWNS A 2002 WORKHORSE W22. THE BRAKE PEDAL WOULD NOT RELEASE AFTER APPLICATION. ALSO THE BRAKE SYSTEM WOULD INTERMITTENTLY OVER-HEAT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, AND A SPRING ON THE BRAKE PEDAL AS INSTALLED. THE REPAIR DID NOT REMEDY THE FAILURE. THE CALIPER GU...

Mileage: 8,406

TL*THE CONTACT OWNS A 2002 NEWMAR MOUNTAIN AIRE RV WITH A W22 WORKHORSE CHASSIS. WHILE DRIVING BETWEEN 55 TO 60 MPH THE CONTACT BEGAN TO SMELL THE BRAKE PADS BURNING. THE CONTACT SHUT THE ENGINE OFF AND EXAMINED THE BRAKES. THE DEALER STATED THAT THE FRONT PASSENGER AND BOTH REAR CALIPERS WERE CRACK...

Mileage: 36,588

INCIDENT IN ENGLAND: SOFT PEDAL & LOSS OF BRAKING, ON IMPORTED AMERICAN MOTORHOME (RV). THERE ARE THOUSANDS OF IMPORTED RVS HERE. MY VEHICLE IS A 2002 'TRAIL LITE 262' BY R-VISION ON A WORKHORSE CHASSIS. IT IS USED REGULARLY & HAS 35,000 MILES. A RECENT SERVICE NOTED THE BRAKE CALIPERS WERE FREE...

Mileage: 35,000

TL*THE CONTACT OWNS A 2002 W22 WORKHORSE CHASSIS TRAILER. THERE IS AN ABNORMAL HEAT GENERATION AT THE WHEEL END WHICH CAUSED THE BRAKES TO DRAG. THE MANUFACTURER WAS NOTIFIED IN REFERENCE TO RECALL # 09V110000 (SERVICE BRAKES, HYDRAULIC). HE WAS ADVISED THAT A REMEDY HAS NOT BEEN DEVELOPED; THEREFOR...

LETTER FROM CONSUMER RE RECALL FOR BRAKE PROBLEMS WITH WORKHORSE CHASSIS. *NJ WHILE ON A TRIP, THE BRAKES OVERHEATED. THE RV WAS TAKEN TO THE DEALER AND IT WAS FOUND THAT THE ENTIRE BRAKING SYSTEM WAS DEFECTIVE. THE CONSUMER WAS INFORMED THE PARTS WOULD NOT BE AVAILABLE UNTIL NOVEMBER EVEN THOUGH...

LETTER FROM CONSUMER RE RECALL FOR BRAKE PROBLEMS WITH WORKHORSE CHASSIS. *NJ WHILE ON A TRIP, THE BRAKES OVERHEATED. THE RV WAS TAKEN TO THE DEALER AND IT WAS FOUND THAT THE ENTIRE BRAKING SYSTEM WAS DEFECTIVE. THE CONSUMER WAS INFORMED THE PARTS WOULD NOT BE AVAILABLE UNTIL NOVEMBER EVEN THOUGH...

TL*THE CONTACT OWNS A 2002 HOLIDAY RAMBLER VACATIONER. THE CONTACT STATED HEAT BUILDS UP IN THE BRAKE SYSTEM. THE RV WAS TAKEN TO THE DEALER AND THE CALIPERS AND ROTORS WERE REPLACED. IMMEDIATELY AFTER THE REPAIR HE NOTICED THAT THE TRANSMISSION WOULD NOT CHANGE GEARS AND THE SPEEDOMETER WAS INOPER...

Mileage: 15,000

2002 WINNEBAGO ADVENTURER 35-U HAD A BRAKE PROBLEM. CONSUMER WANTS TO BE REIMBURSED FOR THE REPAIRS (SAFETY RECALL 50901-C). *NJ THE RIGHT FRONT CALIPER LOCKED UP AND THE LEFT REAR CALIPER WAS DRAGGING. 2002 WORKHORSE W22 CHASSIS. UPDATED 09/14/09. *JB THE CONSUMER IS SEEKING REIMBURSEMENT FOR...

CONSUMER IS SEEKING REIMBURSEMENT FOR REPAIRS AFTER RECEIVING SAFETY RECALL 50901-C FOR WORKHORSE RV. *NJ PRIOR TO RECEIVING THE RECALL, THE FRONT BRAKES OVERHEATED. THE ROTORS, CALIPERS, INNER SEALS, RIGHT REAR SPEED SENSOR, HUB SEALS AND OUTER GASKET WERE REPLACED. *JB

DRIVER SIDE REAR BRAKE FIRE ON 2002 WORKHORSE MOTOR HOME CHASIS. FIRE WAS NOTED WHEN STOPPING AT CAMPGROUND ENTRANCE AFTER TRAVELING ABOUT 5 MILES ON LEVEL GROUND AT 25 MILES PER HOUR FROM HIGHWAY ON SIDE ROAD. IMMEDIATELY HOSED DOWN BRAKE ASSEMBLY. MOTORHOME WAS ALLOWED TO SET FOR 3 DAYS. DROVE...

Mileage: 16,500

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 MOTOR HOME. THE CONTACT STATED THAT THE BRAKES FAILED DURING STOP-AND-GO TRAFFIC. HE ALSO STATED THAT THE BRAKES WERE DRAGGING. THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE MANUFACTURER STATED THAT THEY WOULD ASSIST WITH THE REPAIRS AN...

Mileage: 32,870

TL*THE CONTACT OWNS A 2003 FOREST RIVER WINDSONG WITH A 2002 WORKHORSE W22 CHASSIS. WHILE DRIVING 55 MPH, THE FRONT END OF THE VEHICLE VIBRATED CONSTANTLY. THE CONTACT INSPECTED THE VEHICLE AND NOTICED AN ODOROUS SMOKE COMING FROM UNDERNEATH. HE POURED WATER ON THE BRAKE CALIPERS TO COOL THEM DOW...

Mileage: 7,210

WORKHORSE SAFETY RECALL 50901C. *NJ THE CONSUMER STATED THE BRAKES WERE HOLDING. THE CONSUMER TOOK THE RV TO A MECHANIC AND WAS TOLD THE ABS SENSORS HAD MELTED AND WOULD HAVE TO BE ORDERED. THE CONSUMER WENT BACK TO HAVE THE SENSORS INSTALLED, BUT WAS TOLD A THIRD SENSOR WAS BAD. THE BRAKES NEEDE...

TL*THE CONTACT OWNS A 2002 WINNEBAGO ADVENTURER RV, MODEL 35U. THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE BRAKING SYSTEM ON THE VEHICLE. IN OCTOBER OF 2008, THE BRAKES FAILED AND NEARLY CAUSED A CRASH. THE CONTACT CALLED THE DEALER AND A LAWYER AND WAS ADVISED TO FILE A COMPLAINT WITH THE...

Mileage: 20,000

TL*THE CONTACT OWNS A 2002 WINNEBAGO ADVENTURER RV, MODEL 35U. THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE BRAKING SYSTEM ON THE VEHICLE. IN OCTOBER OF 2008, THE BRAKES FAILED AND NEARLY CAUSED A CRASH. THE CONTACT CALLED THE DEALER AND A LAWYER AND WAS ADVISED TO FILE A COMPLAINT WITH THE...

Mileage: 20,000

WE WERE TRAVELING ON INTERSTATE 83 HEADING NORTH PAST BALTIMORE WHEN WE SMELLED A BURNING BRAKE SMELL - WE PULLED OVER ON THE SIDE OF 83 AND THE FRONT DRIVERS SIDE BRAKE CALIBER HAD STUCK AND WOULD NOT RELEASE - THE RUBBER DUST BOOT CAUGHT FIRE - THE INSIDE OF THE TIRE CRACKED AND BEGAN TO MELT DUE ...

Mileage: 41,000

TL*THE CONTACT OWNS A 2002 WORKHORSE W22. THE CONTACT NOTICED THAT THE ABS WARNING INDICATOR WOULD CONSISTENTLY ILLUMINATE ON THE INSTRUMENT CONTROL PANEL. HE TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED ALL THE ABS SENSORS AT THE COST OF $618. SEVERAL MONTHS AFTER THE REPAIR, THE FAILURE RES...

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 CHASSIS. THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 04V084000 (SERVICE BRAKES, HYDRAULIC) IN 2004. SEVERAL YEARS LATER, THE CONTACT NOTICED THAT THE BRAKING SYSTEM WOULD HANG UP OR LOCK DURING EMERGENCY STOPPING. DURING THE FAILURE, THE...

RIGHT FRONT BRAKE CALIPER NOT FULLY RELEASING, CAUSING EXTREME HEAT, MELTING OF PLASTIC COVER, GLAZING OF THE ROTOR, MELTING OF THE ABS SPEED SENSOR. THE FAILURE OCCURS ALMOST EVERY TRIP, WHERE THE BRAKE DRAGS SLIGHTLY, BUT USUALLY RELEASES AFTER A FEW MILES. I HAVE HAD THE WORKHORSE RECALL COMPLE...

Mileage: 31,000

TL*THE CONTACT OWNS A 2002 FLEETWOOD BOUNDER. THE CONTACT TOOK HIS VEHICLE TO A LOCAL RV REPAIR SHOP FOR ROUTINE INSPECTION AND WAS INFORMED THAT HIS BRAKES WERE DAMAGED. THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 04V084000 (SERVICE BRAKES, HYDRAULIC). THREE YEARS AFTER THE RE...

BRAKES HAVE BEEN GIVING TROUBLE. REDID FRONT BRAKES AND NOW HAVE TO DO THE REAR. 2002 WORKHORSE MOTOR HOME CHASSIS. REPAIRS TO THE FRONT WAS OVER 900.00 . DON'T KNOW WHAT THE REAR WILL COST... *TR

Mileage: 20,500

2002 BOUNDER WITH CHEVY WORKHORSE CHASSIS BRAKE SYSTEM FAILURE. *NJ THE CONSUMER WAS INFORMED THE FRONT CALIPER ON THE PASSENGER SIDE HAD SEIZED AND DESTROYED ALL THE PREVIOUS BRAKE WORK THE CONSUMER HAD DONE 56 MILES AGO. THE LEFT FRONT OIL SEAL WAS LEAKING. *JB

2002 BOUNDER WITH CHEVY WORKHORSE CHASSIS BRAKE SYSTEM FAILURE. *NJ THE CONSUMER WAS INFORMED THE FRONT CALIPER ON THE PASSENGER SIDE HAD SEIZED AND DESTROYED ALL THE PREVIOUS BRAKE WORK THE CONSUMER HAD DONE 56 MILES AGO. THE LEFT FRONT OIL SEAL WAS LEAKING. *JB

COMING HOME ON THE 405 FREEWAY IN LOS ANGLES IN STOP AND GO TRAFFIC, MY RIGHT FRONT CALIPER APPARENTLY STUCK ON. ABOUT 2 MILES FROM HOME THE ABS LIGHT CAME ON AND I COULD SMELL THE BRAKES. I WENT ON HOME AND THE RIGHT FRONT WHEEL WAS SMOKING. I LET IT COOL. SINCE THEN I HAVE REPLACED THE RIGHT FRONT...

Mileage: 30,000

TL*THE CONTACT OWNS A 2002 WORKHORSE W22. WHILE DRIVING APPROXIMATELY 10 MPH IN A RESIDENTIAL COMMUNITY, THE BRAKE PEDAL EXTENDED TO THE FLOOR. THE VEHICLE FAILED TO STOP AND COASTED THE REST OF THE WAY TO ITS DESTINATION. THE VEHICLE WAS TOWED TO A DEALER. THE CURRENT AND FAILURE MILEAGES WERE ...

Mileage: 40,000

WHILE DRIVING DOWN THE ROAD, THE ENGINE JUST SHUTS DOWN. THIS HAPPENS AT ANYWHERE FROM 2 TO 10 MILES AFTER STARTING DOWN THE HIGHWAY. THIS HAS HAPPENED A TOTAL OF FOUR TIMES TO ME. IT ACTED AS IF THE IGNITION IS TURNED OFF. UPON THE SECOND SHUT DOWN, A SCAN TOOL WAS USED AND PRODUCED THE CODE INDICA...

Mileage: 15,850

WHILE DRIVING DOWN THE ROAD, THE ENGINE JUST SHUTS DOWN. THIS HAPPENS AT ANYWHERE FROM 2 TO 10 MILES AFTER STARTING DOWN THE HIGHWAY. THIS HAS HAPPENED A TOTAL OF FOUR TIMES TO ME. IT ACTED AS IF THE IGNITION IS TURNED OFF. UPON THE SECOND SHUT DOWN, A SCAN TOOL WAS USED AND PRODUCED THE CODE INDICA...

Mileage: 15,850

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 . WHILE DRIVING BETWEEN 20-30 MPH, THE BRAKES FAILED. THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE CONTACT PULLED OFF THE ROAD INTO A GRASSY AREA, WHICH SLOWED DOWN THE VEHICLE AND EVENTUALLY LED TO A COMPLETE STOP. HE PULLED THE VEHIC...

Mileage: 40,856

TL*THE CONTACT OWNS A 2002 NEWMAR MOUNTAIN AIRE WITH A WORKHORSE CHASSIS. THE CONTACT STATED THAT THERE WERE BRAKE SEIZURES WITH HIS BRAKE CALIPERS. WHILE DRIVING 30 MPH, THE BRAKES LOCKED UP AND CAUSED THE VEHICLE TO PULL TO THE RIGHT. THE FAILURE MELTED THE ABS WIRING AND NEARLY STARTED A FIRE....

Mileage: 30,500

1. RANDOM LOCK UP OF VEHICLE BRAKES 2. OCCURRED SEPTEMBER 2006 AND AGAIN IN AUGUST 2008. EXTREME VEHICLE VIBRATION AND LOSS OF STEERING. BRAKES SMOKE AND BECOME EXTREMELY HOT. 3. VEHICLE CHECKED BY LES SCHWAAB TIRE STORE AND AUTHORIZED GM REPAIR CENTER. CHARGED FOR INSPECTION. NEITHER SHOP COU...

Mileage: 26,293

HAD BRAKE RECALL IN 2/06. BRAKES NEARLY FAILED 7/08 ON TRIP OUT WEST. ABS SENSOR BAD, FRONT BRAKE PADS BAD, AND LEFT FRONT CALIPER BAD. THIS CORRESPONDS TO TROUBLES OTHER DRIVERS HAVE HAD WITH THIS SYSTEM. *TR

Mileage: 33,000

COMING HOME FROM CAMPING,IN TRAFFIC WHEN ABS LIGHT COMES ON. THERE'S A SMELL OF BURNING BRAKES. RV SEEMS TO BE UNDER A HEAVY LOAD. AFTER A FEW STOPS BRAKING GETS HARDER. BY THE TIME I MAKE IT HOME ALMOST A COMPLETE BRAKE FAILURE. BRAKE PEDAL GOES TO THE FLOOR. PUMPING THE BRAKES MAINTAIN SOME STO...

Mileage: 12,420

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 TRAILER. WHEN THE CONTACT EXITED THE VEHICLE, HE SMELLED THE BRAKES AND WHEEL BEARINGS BURNING. THE CONTACT REMOVED THE WHEEL AND NOTICED OIL FROM THE WHEEL BEARING COVERING THE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED. IN OCTOBER OF 2007, T...

Mileage: 16,000

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 TRAILER. WHEN THE CONTACT EXITED THE VEHICLE, HE SMELLED THE BRAKES AND WHEEL BEARINGS BURNING. THE CONTACT REMOVED THE WHEEL AND NOTICED OIL FROM THE WHEEL BEARING COVERING THE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED. IN OCTOBER OF 2007, T...

Mileage: 16,000

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 TRAILER. WHEN THE CONTACT EXITED THE VEHICLE, HE SMELLED THE BRAKES AND WHEEL BEARINGS BURNING. THE CONTACT REMOVED THE WHEEL AND NOTICED OIL FROM THE WHEEL BEARING COVERING THE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED. IN OCTOBER OF 2007, T...

Mileage: 16,000

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 TRAILER. WHEN THE CONTACT EXITED THE VEHICLE, HE SMELLED THE BRAKES AND WHEEL BEARINGS BURNING. THE CONTACT REMOVED THE WHEEL AND NOTICED OIL FROM THE WHEEL BEARING COVERING THE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED. IN OCTOBER OF 2007, T...

Mileage: 16,000

TL*- THE CONTACT OWNS A 2002 WORK HORSEMAN CHASSIS W22. ON SEVERAL OCCASIONS THE CHASSIS BRAKES OVERHEATED. WHEN THE BRAKES OVERHEATED HE WOULD PULL OVER UNTIL THEY COOLED DOWN. ON APRIL 10, 2006 THE CONTACT EXPERIENCE A TOTAL FAILURE OF THE BRAKES, HE WAS TRYING TO SLOW DOWN, AND THE BREAK PEDAL ...

Mileage: 20,000

TL*THE CONTACT OWNS A 2002 WORKHORSE W22. WHILE DRIVING 60 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE BEGAN TO PULL BACK AND FORTH. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE CONTACT PULLED OFF THE ROAD. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND THEY STATED THAT THE BRAK...

Mileage: 11,000

2002 HOLIDAY RAMBLER VACATIONER. REPLACED ENTIRE BRAKING SYSTEM ON 05/21/2005PERRECALL BULITEN #50401-C 32071 MILESON COACH ALL4ROTORS WERE CRACKED ON 11/02/2007 BRAKES MAKING NOISE NOW 3 ROTORS ARE CRACKED.WORKHORSE REFUSE TO REPLACE ROTORS PROBLEM DUE TO EXESSIVE HEAT BRAKES BEING APPLIED FOR 2 M...

Mileage: 48,450

TL*THE CONTACT OWNS A 2002 WORKHORSE W22. WHILE DRIVING 50 MPH, HE HEARD A SCRAPING NOISE AND THE BRAKES THUMPED WHEN HE DEPRESSED THE BRAKE PEDAL. THE DEALER STATED THAT RIGHT FRONT AND BOTH REAR ROTORS WERE CRACKED. IN ADDITION, THEY FELT THAT THE CALIPERS OVERHEATED AND WAS THE CAUSE OF THE FA...

Mileage: 48,583

TL*THE CONTACT OWNS A 2002 WORKHORSE W22. WHILE DRIVING 35 MPH, THE CONTACT NOTICED A BURNING SMELL COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. HE STATED THAT THE CALIPERS OVERHEATED. THERE WAS A RECALL REPAIR PERFORMED FOR THE SERVICE BRAKES, HYDRAULIC (NHTSA CAMPAIGN ID NUMBER 04V08400...

Mileage: 15,254

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 HOLIDAY RAMBLER. WHILE DRIVING 30 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD WHEN DEPRESSED. THE CONTACT PULLED OVER AND NOTICED THAT THE REAR BRAKE CALIBER OVERHEATED AND BOILED THE BRAKE FLUID. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE DEAL...

Mileage: 17,775

TL*THE CONTACT OWNS A 2002 WORKHORSE W22 HOLIDAY RAMBLER. WHILE DRIVING 30 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD WHEN DEPRESSED. THE CONTACT PULLED OVER AND NOTICED THAT THE REAR BRAKE CALIBER OVERHEATED AND BOILED THE BRAKE FLUID. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE DEAL...

Mileage: 17,775

PASSENGER REAR BRAKE WAS DRAGGING. RECALL 04V084000 WAS ISSUED IN JANUARY. HE TOOK VEHICLE TO THE DEALER TO GET THE BRAKES CHECKED, AND THEY FIXED THE ONE THAT WAS DRAGGING. IN JUNE OTHER THREE BRAKES STARTED DRAGGING DUE TO SAME RECALL PROBLEM, IN JULY DEALER REPLACED OTHER THREE BRAKE CALIBERS BUT...

Mileage: 7,500