2004 WORKHORSE W22 Service Brakes Problems

The contact owns a 2004 Workhorse W22 RV. The contact stated while driving approximately 60 MPH, the brakes heated up and seized. The contact stated that the ABS warning light was illuminated. The contact pulled over and smelled a burning odor. The contact stated that he waited for over one hour for the brakes to cool and then he continued driving to his destination. The contact stated that the failure became constant and he no longer took the RV on long trips. The contact had taken the RV to an independent mechanic where it was diagnosed and determined that the calipers, pistons, sensors, and rotors needed to be replaced. The RV had been repaired; however, the failure reoccurred. The manufacturer had not been informed of the failure. The failure mileage was approximately 60,000.

The contact owns a 2004 Workhorse W22 RV. The contact stated while driving approximately 60 MPH, the brakes heated up and seized. The contact stated that the ABS warning light was illuminated. The contact pulled over and smelled a burning odor. The contact stated that he waited for over one hour for the brakes to cool and then he continued driving to his destination. The contact stated that the failure became constant and he no longer took the RV on long trips. The contact had taken the RV to an independent mechanic where it was diagnosed and determined that the calipers, pistons, sensors, and rotors needed to be replaced. The RV had been repaired; however, the failure reoccurred. The manufacturer had not been informed of the failure. The failure mileage was approximately 60,000.

2004 CHEVROLET GULF STREAM. CONSUMER WRITES IN REGARDS TO BRAKE SYSTEM RECALL REPAIR ISSUES - RIGHT FRONT CALIPER/ABS SENSOR REPLACEMENTS. *SMD *TR

2004 CHEVROLET GULF STREAM. CONSUMER WRITES IN REGARDS TO BRAKE SYSTEM RECALL REPAIR ISSUES - RIGHT FRONT CALIPER/ABS SENSOR REPLACEMENTS. *SMD *TR

2000 MILES AFTER RECALL WAS FIXED WHEN BRAKES APPLIED STEERING WHEEL PULLS YOUR HANDS OFF AND GOES TO THE RIGHT AND CANT KEEP IT IN THE ROAD.

2000 MILES AFTER RECALL WAS FIXED WHEN BRAKES APPLIED STEERING WHEEL PULLS YOUR HANDS OFF AND GOES TO THE RIGHT AND CANT KEEP IT IN THE ROAD.

TL* THE CONTACT OWNS A 2004 WORKHORSE W22 CHASSIS MOTORHOME. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 15 MPH, THE BRAKES FAILED AND THE PEDAL SANK TO THE FLOOR. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE AUTHORIZED DEALER WAS NOT ABLE TO PROVIDE A REMEDY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT NOTIFIED OR INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 09V110000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 19,870.

TL* THE CONTACT OWNS A 2004 WORKHORSE W22 CHASSIS MOTORHOME. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 15 MPH, THE BRAKES FAILED AND THE PEDAL SANK TO THE FLOOR. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE AUTHORIZED DEALER WAS NOT ABLE TO PROVIDE A REMEDY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOT NOTIFIED OR INCLUDED IN RECALL NHTSA CAMPAIGN ID NUMBER: 09V110000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 19,870.

TL* THE CONTACT OWNS A 2004 FLEET WOOD MOTOR HOME EQUIPPED WITH A WORKHORSE W22 CHASSIS. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE STARTED TO DECELERATE. AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE REAR BRAKES WERE ON FIRE. THE CONTACT WAS ABLE TO CONTAIN THE FIRE BY USING AN EXTINGUISHER. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN VERIFIED THAT THE BRAKES FAILED AND THE BRAKES, ROTOR, BRAKE CALIPER, SPEED SENSOR AND THE BRAKE LINES WOULD NEED REPLACING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 23,000.

TL* THE CONTACT OWNS A 2004 FLEET WOOD MOTOR HOME EQUIPPED WITH A WORKHORSE W22 CHASSIS. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE STARTED TO DECELERATE. AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE REAR BRAKES WERE ON FIRE. THE CONTACT WAS ABLE TO CONTAIN THE FIRE BY USING AN EXTINGUISHER. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN VERIFIED THAT THE BRAKES FAILED AND THE BRAKES, ROTOR, BRAKE CALIPER, SPEED SENSOR AND THE BRAKE LINES WOULD NEED REPLACING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 23,000.

TL* THE CONTACT OWNS A 2004 GEORGI BOY CRUSE MASTER RV EQUIPPED WITH A 2004 WORKHORSE W22 CHASSIS. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE BRAKE PEDAL WAS ENGAGED AND THE VEHICLE FAILED TO DECELERATE. THE CONTACT WAS ABLE TO REDUCE SPEED AFTER APPLYING THE BRAKES REPEATEDLY AND TO A COMPLETE STOP. AFTER THIRTY MINUTES THE VEHICLE RESUMED NORMALLY. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A NHTSA CAMPAIGN ID NUMBER: 09V193000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE RECENTLY RECURRED AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 12,000...UPDATED 05/16/13 *BF THE CONSUMER STATED THE BREAKS AND ROTORS SHOULD HAVE BEEN CHANGED. THEY WERE WARPED FROM THE EXCESSIVE HEAT CAUSED BY CALIPERS HANGING UP. UPDATED 05/23/2013 *JS

TL* THE CONTACT OWNS A 2004 GEORGI BOY CRUSE MASTER RV EQUIPPED WITH A 2004 WORKHORSE W22 CHASSIS. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THE BRAKE PEDAL WAS ENGAGED AND THE VEHICLE FAILED TO DECELERATE. THE CONTACT WAS ABLE TO REDUCE SPEED AFTER APPLYING THE BRAKES REPEATEDLY AND TO A COMPLETE STOP. AFTER THIRTY MINUTES THE VEHICLE RESUMED NORMALLY. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A NHTSA CAMPAIGN ID NUMBER: 09V193000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE RECENTLY RECURRED AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 12,000...UPDATED 05/16/13 *BF THE CONSUMER STATED THE BREAKS AND ROTORS SHOULD HAVE BEEN CHANGED. THEY WERE WARPED FROM THE EXCESSIVE HEAT CAUSED BY CALIPERS HANGING UP. UPDATED 05/23/2013 *JS