2000 YAMAHA ROAD STAR Problems & Recalls

DRIVING 75MPH ON HIGHWAY, LOSS OF POWER, LOUD BANG! REAR TIRE LOCKED UP FOR A SECOND. ALMOST CAUSED ME TO CRASH. ENGINE WOULD NOT START. VEHICLE PUSHED TO SIDE OF ROAD AND TRAILERED HOME. TOOK ENGINE APART TO FIND OIL PUMP GEAR BROKEN. VERY COMMON ISSUE BUT NO RECALL FROM YAMAHA! IF YOU HAVE A 99-20...

Mileage: 28,654

TL*THE CONTACT OWNS A 2000 YAMAHA ROAD STAR. WHILE DRIVING 45 MPH, THE ENGINE SHUT OFF WITHOUT WARNING AND CAUSED THE REAR TIRE TO LOCK. THE DEALER STATED THAT THE CAUSE OF FAILURE WAS THE OIL PUMP GEAR. AS OF SEPTEMBER 5, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 6,...

Mileage: 6,790

THE YAMAHA ROADSTAR HAVE A CHRONIC PROBLEM OF STICKING VALVES. YAMAHA HAS TOLD THE CUSTOMERS THAT IT WAS OVERFILLING THE OIL. TO DATE THERE HAVE BEEN NUMEROUS RIDERS WHO HAVE NOT BEEN ABLE TO HAVE THEIR MOTORCYCLES FIXED BY YAMAHA, WHO CLAIMED THIS WAS NOT A PROBLEM. HOWEVER AS STATED THERE WER...

Mileage: 35,000

TL*THE CONTACT OWNS A 2000 YAMAHA ROAD STAR. HE RECEIVED A RECALL NOTICE TO REPLACE THE GEARS IN THE TRANSMISSION BEFORE IT LOCKED THE REAR WHEELS. THE DEALER REPLACED IT; HOWEVER, WHEN HE PICKED UP THE VEHICLE THERE WAS OIL UNDER THE ENGINE/MOTOR FRAME AND ON THE TIRES. OIL ON THE TIRES CAN POTEN...

Mileage: 86,029

TL*THE CONTACT OWNS A 2000 YAMAHA ROAD STAR. HE RECEIVED A RECALL NOTICE TO REPLACE THE GEARS IN THE TRANSMISSION BEFORE IT LOCKED THE REAR WHEELS. THE DEALER REPLACED IT; HOWEVER, WHEN HE PICKED UP THE VEHICLE THERE WAS OIL UNDER THE ENGINE/MOTOR FRAME AND ON THE TIRES. OIL ON THE TIRES CAN POTEN...

Mileage: 86,029

DRASTIC POWER FAILURE WHILE CROSSING TRAFFIC . ALSO, POWER FAILURE WHILE MERGING ONTO INTERSTATE IN HEAVY TRAFFIC WAS DUE TO STICKING VALVES, LOSS OF REAR CYLENDER COMPRESSION. *AK

Mileage: 16,000

DT: MOTORCYCLE HAS 7,000 MILES ON IT, AND IT HAS A RUSTY HOLE ON TOP OF THE GAS TANK. DEALER SAID HE SHOULD HAVE IT REPLACED. CONSUMER CALLED YAMAHA, AND THEY REFUSED TO DEAL WITH HIM. THEY WANTED THE DEALER TO COMPENSATE HIM FOR REPAIRS. *AK CONSUMER STATES THAT MOTORCYCLE IS ALWAYS IN THE GARAGE ...

Mileage: 6,000

INTERMITENT OCCURENCES OF TRANSMISSION PROBLEM OCCURING WHEN SHIFTING INTO SECOND GEAR,EVEN UNDER ACCELERATION THE GEAR WILL SLIP INTO NEUTREL.

Mileage: 2,000

VERY CONCERNED OVER THE LARGE NUMBER OF TRANSMISSION FAILURES SEEN IN YAMAHA ROAD STAR MOTORCYCLES MANUFACTURED BETWEEN 3/00 AND 8/01. THIS INFORMATION HAS BEEN TRACKED INDEPENDENTLY BY ROAD STAR OWNERS ON THE DELPHI ROAD STAR RIDERS INTERNET FORUM FOR THE PAST YEAR OR SO. I OWN A 2000 ROAD STAR THA...

I AM CONCERNED FOR MY OWN AND MY FAMILY MEMBERS SAFETY DUE TO REPORTED TRANSMISSION FAILURES ON YAMAHA ROAD STAR MOTORCYCLES. THESE FAILURES HAVE TAKEN PLACE AT HIGHWAY SPEEDS WITH NO ADVANCE WARNINGS. THE TRANSMISSION "LOCKS UP" THEREBY LOCKING THE REAR WHEEL.*AK

YAMAHA ROADSTAR MOTORCYCLE 2000, BUILT BEFORE MARCH OF 2000. SPRING INSIDE TRANSMISSION BROKE, CAUSING LOSS OF SHIFT CAPABILITY. BREAK OCCURRED WHILE STOPPED AT A LIGHT, SO SPRING PARTS DID NOT INTERFERE WITH FORWARD MOVEMENT THAT MIGHT HAVE BEEN CAUSED IF PIECE OF SPRING HAD LODGED BETWEEN GEAR TE...

Mileage: 15,000

WHILE SHIFTING IN GEAR THERE IS A LOUD NOISE AND HESITATION INSIDE OF THE GEAR BOX. *AK

VERY HARD TO SHIFT . *AK

MY MOTORCYCLE, 2000 YAMAHA ROADSTAR, VIN. NO. [XXX], HAS NOT BEEN OPERATED IN MORE THAN A YEAR. I BROUGHT IT IN FOR ALL SERVICE TO PUT IT BACK ON ROAD, INCLUDING SERVICE UNDER RECALL 01V094000. DEALER INFORMED ME THAT MUFFLER BRACKET ONLY NEEDS TO BE INSPECTED. RECALL NOTICE STATES THAT REPLACEM...

OIL PUMP DRIVE GEAR FAILURE LED TO 3 COLLAPSED LIFTERS AND SUBSIQUENT ENGINE FAILURE.

Mileage: 20,260

I HAVE HEARD OF 9 OTHER OIL PUMP FAILURES ON THE ROAD STAR. *AK

REAR FENDER CRACKS ON THIS MODEL BEHIND THE FENDER SUPPORT. IF THIS CONDITION GOES UNNOTICED BY THE DRIVER THE FENDER MAY BUCKLE AND FALL TO CONTACT THE REAR TIRE CAUSING A LOSS OF CONTROL OF THE MOTORCYCLE. CONTACT HAS BEEN MADE WITH THE MANUFACTURER AND THEY DENY THAT THIS IS A COMMON PROBLEM IN...

FRONT TIRE WAS PLACED ON MOTOR CYCLE BACKWARDS. ARROW INDICATED DIRECTION TIRE SHOULD BE. TIRE HAD A KNOT IN IT. STEERING WOULD SHAKE. TOOK TO DEALERSHIP, AND WAS INFORMED BY MECHANIC IT WAS A MANUFACTURER'S DEFECT.*AK

CONSUMER NOTICED A CRACK IN THE REAR FENDER, THE DEALER ORDERED A NEW FENDER WHICH WAS SUPPOSED TO ARRIVE IN ONE WEEK BUT IT HAS BEEN 5 WEEKS AND THE FENDER HAS NOT ARRIVED YET. NLM